2002 Toyota Tacoma
Problems, recalls and owner-reported issues
Structure is the leading concern among 360 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Tacoma model years with reports.
Of the 2002 reports, 30 involved a crash and 3 involved a fire. 23 people were injured.
What owners report most often
Recalls and investigations
Tires, temporary/emergency spare tireNov 23, 2012
Toyota is recalling certain model year 2001 through 2004 Tacoma light trucks manufactured from August 28, 2000, through August 27, 2004, and originally sold, or currently registered, in the following cold climate states with high road salt usage: Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. The spare tire in the subject vehicles is located underneath the rear of the vehicle and held by a spare tire carrier. A lift plate on the carrier is used to help raise, lower and retain the tire. During its manufacture, the lift plate may not have been sufficiently coated with anti-corrosion materials. If the plate is insufficiently coated and the vehicle is operated in cold climate regions where road salts are frequently used, road spray can reach the carrier assembly and corrode the lift plate.
Corrosion of the plate could cause it to break, which could result in detachment of the spare tire from the vehicle. Detachment of the spare tire could result in a road hazard which may increase the risk of a vehicle crash.
Toyota will notify owners, dealers will inspect the vehicle and replace the spare tire carrier lift plate as necessary, free of charge. The recall began in February 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Campaign 12V542000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Suspension, front, control arm, lower ball jointMay 17, 2005
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.
THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.
DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 05V225000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsMay 19, 2003
ON CERTAIN PICKUP TRUCKS, DURING SIDE IMPACT NCAP TEST (I.E. LINCAP TEST), A FLANGE AT THE REAR END OF THE DOUBLE CAB BODY DEFORMED AND INTERFERED WITH THE FUEL INLET HOSE THAT CONNECTS THE FUEL FILLER PIPE AND FUEL TANK, RESULTING IN DAMAGE TO THE FUEL INLET HOSE.
THIS DAMAGE COULD RESULT IN FUEL LEAKAGE, WHICH COULD RESULT IN A FIRE IF IN THE PRESENCE OF AN IGNITION SOURCE.
DEALERS WILL INSTALL A FUEL HOSE PROTECTOR ON THE BODY FLANGE. OWNER NOTIFICATION BEGAN JUNE 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Campaign 03V189000 on NHTSA.gov
Representative owner complaints
360 reports, newest first.
Structure, Sep 24, 2020
THERE WAS A RECALL ON THE FRAME IN 2010 AND THEY SAID UNDERCOATING WOULD PROTECT THAT HOWEVER NOW THE FRAME IS RUSTED AND NOT SAFE TO DRIVE IF I GET IN AN ACCIDENT IT WILL FAIL. IT ONLY HAS 90,000 MILES ON IT AND TOYOTA IS REFUSING TO DO ANYTHING ABOUT IT. I FEEL THEY SHOULD HAVE A WARRANTY ON THE FRAME.
Suspension, Structure, Sep 11, 2020
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT STATED THAT AN INDEPENDENT MECHANIC INSPECTED HER VEHICLE AND DISCOVERED SEVERE CORROSION THROUGHOUT THE ENTIRE UNDERCARRIAGE. THE CONTACT SPOKE WITH MARKQUART TOYOTA (1844 COMMERCIAL BLVD, CHIPPEWA FALLS, WI 54729) WHO INFORMED HER THAT THERE WERE NO RECALLS ON THE VEHICLE. THE CONTACT THEN CALLED THE MANUFACTURER WHO WAS NOTIFIED OF THE FAILURE AND DISREGARDED HER CONCERN WITH THE CORROSION. THE MANUFACTURER SUGGESTED THE VEHICLE BE SOLD AND OFFERED NO FURTHER ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 32,021.
Suspension, Structure, May 1, 2020
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE HAVING A ROUTINE CHECK ON THE VEHICLE BY AN INDEPENDENT MECHANIC, THE TECHNICIAN BECAME AWARE THAT THE REAR SUBFRAME WAS SEVERELY RUSTED. A DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 190,000.
Suspension, Mar 9, 2020
FRAME IS ROTTED, SHOCK SEPARATED FROM FRAME
Structure, Nov 20, 2019
I HAVE A 2002 TACOMA THAT WAS PART OF THE FRAME PERFORATION RECALL. HOWEVER, I DID NOT GET A FRAME REPLACEMENT. THE "FIX" WAS TO APPLY A GEL OVER THE RUST ON THE FRAME, WHICH, SUBSEQUENTLY, ALL FELL OFF THE FRAME ONTO MY DRIVEWAY. RECENTLY, I TOOK MY TRUCK INTO THE DEALERSHIP FOR A 4WD REPAIR AND WAS TOLD THAT MY "FRAME WAS SHOT" AND THE TRUCK WAS "UNSAFE TO DRIVE", DUE TO THAT. AND IF THEY LIFTED MY TRUCK TO DO THE REPAIR, IT MIGHT "CRUSH MY FRAME". I EXPRESSED MY DISPLEASURE FOR THE RECALL FIX AND HAD THEM DO AN ESTIMATE ON THE 4WD REPAIR. THEY CAME BACK WITH AN OUTRAGEOUS NUMBER, AS IF THEY DID NOT WANT TO DO THE WORK. I HAVE SINCE CONTACTED INDEPENDENT REPAIR SHOPS AND NO ONE WILL TOUCH IT. *SO, I HAVE A TRUCK NO ONE WILL REPAIR, I CAN'T SELL IT, I CAN'T TRADE IT IN...AND I CAN'T DRIVE IT. IT HAS NO WORTH.ONE OF MY LEAF SPRINGS HAS RUSTED AND BROKEN, TOO. THE TRUCK HAS 215K AND IS IN GOOD CONDITION OTHER THAN RUST. THE ENGINE WILL GO 500K. I SEE RECALLS ON THE FRAME AND LEAF SPRING FOR OTHER MODEL YEARS, BUT THE 2002 SEEMS TO NOT FALL INTO ANY OF THEM. I DON'T EXPECT A NEW FRAME, BUT ASSISTANCE IN OBTAINING A SIMILAR TRUCK AT A REASONABLE PRICE OR OTHER FAIR SOLUTION MAY BE A CONSIDERATION.
Structure, Other or unspecified, Engine, Sep 19, 2019
FRAME FAILURE DUE TO CORROSION: TOYOTA HAD PLACED A "WARRANTY ENHANCEMENT" TO REPLACE THE FRAMES BECAUSE THEY WEREN'T TREATED FOR CORROSION BUT WITH AN ENHANCEMENT, IT EXPIRES AND DID SO IN 2017. I JUST BOUGHT THE TRUCK AND LEARNED THEY HAVE A SAFETY RECALL FOR CORROSION OF THE SPARE WHEEL COMPARTMENT. THIS IS THE SAME ISSUE. WHY IS THE FRAME NOT A SAFETY RECALL?? I HAVE HUGE HOLES AND LARGE CRACKS ALONG MUCH OF THE FRAME AND MY MECHANIC TELLS ME IT'S UNSAFE TO DRIVE. MY FINGERS GO THROUGH THE SIDE OF THE FRAME! MY MECHANIC TELLS ME BASED ON THE LOCATION OF THE CORROSION IN THE FRONT OF THE TRUCK, THE ENTIRE ENGINE IS IN DANGER OF FALLING OUT!! LOOKING ON THE INTERNET, THIS IS A HUGE SAFETY ISSUE FOR TOYOTA TRUCKS FOR 2002 AND BEYOND. FOR MANY YEARS THIS HASN'T BEEN ADDRESSED. THE GOV NEEDS TO DEMAND A SAFETY RECALL FOR THIS TRUCK AND ALL THE OTHERS AFFECTED.
Structure, Sep 17, 2019
MECHANIC TOLD ME THAT MY FRAME WAS RUSTED THROUGH. HE COULD PUT HIS FIST THROUGH A HOLE IN THE FRAME AND RECOMMENDED I CALL A DEALER TO SEE IF THIS WAS ON A RECALL LIST. WHEN I CALLED AND GAVE THEM THE VIN, THEY SAID NO IT IS NOT A RECALL. WHAT CAN I DO? ESPECIALLY IF I CANNOT AFFORD ANOTHER VEHICLE!
Other or unspecified, Aug 30, 2019
REAL BAD RUST ISSUE ON THE FRAME FRAME JUST ABOUT INTO , THAT IS ONLY 1 PHOTO I HAVE MORE . I BOUGHT THE TRUCK USED IN 2013 THE ATTACHED PIC WAS TAKEN 2-3 WEEKS AGO TRUCK IS NOT SAFE TO RIDE/DRIVE
Other or unspecified, Aug 22, 2019
7/31/2019, I DROVE MY TRUCK TO A TOYOTA DEALER SHOP AFTER I NOTICED THE REAR OF MY TRUCK TILTING DOWN WHEN LOADING. PER TOYOTA DEALER INSPECTION, ITS FRAME 3/4 WAY RUSTED THROUGH ON BOTH SIDES AND VERY UNSAFE TO DRIVE. AND TOYOTA'S EXTENDED WARRANTY ON THE FRAME EXPIRED ON JANUARY 2, 2017. REPLACING THE FRAME WOULD COST $24,000, OR THE TRUCK IS JUST A PIECE OF JUNK. ON THE SAME DAY 1:20PM, I CALLED TOYOTA CUSTOMER EXPERIENCE, 800-331-4331, AND WAS TOLD THAT THERE WAS NOTHING THEY COULD DO, AS I DIDN'T BRING IT IN BEFORE THE WARRANTY ON TRUCK FRAME EXPIRED. 7/22/2011, THE TRUCK HAD A FRAME RECALL IN RESPONSE TO EXCESSIVE RUST AND PERFORMED CORROSION TREATMENT PER TOYOTA GUIDELINE (NOT REPLACEMENT OF FRAME). 2/11/2013, THE TRUCK WAS IN TOYOTA SHOP FOR INSPECTION AND DIDN'T HAVE ANY WORDS REGARDING THE FRAME. MY TRUCK IS IN GREAT SHAPE, INTERIOR AND EXTERIOR, OTHER THAN THE RUST FRAME, WITH ONLY 102,000 MILES. I LIKE THE TRUCK, TAKE GOOD CARE OF IT, AND INTENT TO DRIVE FOR A FEW MORE YEARS. BUT I NEVER THOUGHT THE FRAME WOULD BE AN ISSUE EVEN AFTER HAVING A FRAME RECALL WORK DONE. I FEEL TOYOTA SHOULD STILL TAKE CARE OF MY TRUCK FRAME, AS IT HAS GONE BAD DUE TO THE FACT THAT (1) TOYOTA DIDN'T BUILD IT WITH GOOD QUALITY PARTS TO START WITH, (2) TOYOTA DEALER DIDN'T PERFORM A GOOD QUALITY RECALL - JUST PATCH/PAINTED WHICH DIDN'T PREVENT FROM FURTHER RUSTING, AND (3) THIS BAD RUST MUST HAVE HAPPENED BEFORE THE 15-YEAR WARRANTY EXPIRED; I JUST OVER-TRUSTED TOYOTA AND OVER-LOOKED THE FRAME... I HAVE TALKED TO SEVERAL FRAME BODY SHOPS. THEY ARE ALL AWARE OF THE TOYOTA TACOMA FRAME PROBLEMS AND THINK THE FRAME HAD BEEN RUSTING A LONG TIME AGO, WHILE THE TRUCK LOOKS/RUNS GREAT. REPLACEMENT OF THE FRAME IS THE ONLY YET COSTLY OPTION TO SAVE THE TRUCK. I BELIEVE THERE MUST BE MANY TACOMA OWNERS EXPERIENCING THE SAME RESULTED FROM BAD-QUALITY-BUILT TRUCK FRAMES.
Structure, Jul 15, 2019
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THE REAR PASSENGER SIDE WAS LOWER THAN THE OTHER SIDE. THE CONTACT MANAGED TO DRIVE THE VEHICLE TO JEFF WYLER TOYOTA OF CLARKSVILLE (808 E LEWIS AND CLARK PKWY, CLARKSVILLE, IN 47129, (812) 284-2277) WHERE IT WAS DIAGNOSED THAT THE REAR FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 305,000.
Structure, Jul 10, 2019
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. WHEN THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR AN ALTERNATOR AND BATTERY CHANGE, THE TECHNICIAN STATED THAT THE FRAME WAS COMPLETELY CORRODED AND THE VEHICLE WAS UNSAFE TO DRIVE. THE CONTACT ALSO STATED THAT THE FUEL TANK COVER OFTEN POPPED OPEN WITHOUT WARNING. THE CONTACT STATED THAT HE RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 12V542000 (TIRES). THE VEHICLE WAS TAKEN TO BILL WALSH TOYOTA (815-768-1962, LOCATED AT 4000 N COLUMBUS STREET, OTTAWA, IL 61350) WHERE THE FRAME WAS COATED. THE DEALER STATED THAT THE WARRANTY WAS EXPIRED. THE CONTACT STATED THAT THERE WAS NO REMINDER ABOUT THE WARRANTY EXPIRATION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE RECALL REPAIR WAS PERFORMED AND THAT THE WARRANTY EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 124,000.
Structure, Jun 5, 2019
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT STATED THAT THERE WAS EXTENSIVE RUST AND CORROSION ON THE CHASSIS AND THE FRAME HAD CRACKS ON THE PASSENGER SIDE FROM THE FRONT TO THE REAR. ELMHURST TOYOTA (440 W LAKE ST, ELMHURST, IL 60126, (630) 279-2160) INDICATED THAT THE VEHICLE WAS NOT SAFE TO DRIVE AND THAT THE ENTIRE FRAME AND CHASSIS NEEDED TO BE REPLACED. THE DEALER AND MANUFACTURER INDICATED THAT THERE WAS NO RECALL CAMPAIGN TO REPAIR THE VEHICLE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Structure, Jun 3, 2019
FRAME RUST RECALL, NOT TAKEN CARE OF IN 2010 WHEN I TOOK INTO HEISER TOYOTA IN MILWAUKEE WI. NOW WE NEED IT TAKEN CARE OF, THIS IS A SAFETY ISSUE AND BOTH TOYOTA AND HEISER REFUSE TO TAKE CARE OF.
Other or unspecified, May 9, 2019
THE FRAME HAS ROTTED AWAY CAN'T EVEN DRIVE IT.
Structure, May 8, 2019
THE FRAME WAS COATED WITH AN ANTI RUST COATING DURING THE MANUFACTURER RECALL THAT LASTED UNTIL 2017 NOW THE THE METAL IS BECOMING POROUS AND UPON SLIGHTLY TAPPING THE FRAME ONE CAN POKE HOLES IN THE FRAME WITH A PENCIL. THE TRUCK HAS BECOME UNSAFE TO DRIVE. UPON TAKING IT MY LOCAL TOYOTA DEALER WILLIS TOYOTA OF TWIN FALLS IDAHO IN 2016 AND 2017 THEY PERFORMED A POORLY EXECUTED INSPECTION JUST TO AVOID REPAIRING THE ISSUE. THEY TOLD ME BOTH TIMES THE FRAME WAS FINE WHEN IT CLEARLY WAS NOT. THIS TRUCK HAS ONLY 110K MILES ON IT BUT IS SLOWLY BECOMING A PILE OF RUST. HOW CAN A VEHICLE THAT IS JUST 16 YEARS OLD BE SO RUSTED. TOYOTA IS OF NO HELP AFTER REPEATED CALLS
Other or unspecified, Apr 8, 2019
I PURCHASED A USED TOYOTA TACOMA 2002 ON 12/16/11 (NOW WITH 124K MILES). TOYOTA ISSUED AN EXTENDED WARRANTY COVERAGE TO OWNERS REGARDING A SAFETY ISSUE & THE POSSIBILITY OF FRAME SPLITTING WITH STEPS TO TAKE FOR TOYOTA TO COVER THIS ISSUE IN A 1X LETTER THEY SENT OUT IN FEB 2012. TOYOTA SENT THE LETTER TO THE PREVIOUS OWNER & NOT TO ME (THE RIGHTFUL OWNER AT THAT TIME.) I RECENTLY FOUND OUT ABOUT THIS PROBLEM FROM A LOCAL TIRE COMPANY THAT NOTICED A SPLIT IN MY TRUCK'S FRAME (THIS ISSUE WAS NEVER BROUGHT TO MY ATTENTION BY THE LOCAL TOYOTA DEALER WHEN I HAD ANOTHER RECALL ISSUE TAKEN CARE OF ON 5/11/15). I WENT RIGHT TO THE LOCAL TOYOTA DEALER AND THEY SAID THE FRAME MUST BE REPLACED (WHICH WAS PART OF THE PROGRAM THAT TOYOTA OFFERED IN THE LETTER SENT TO THE PREVIOUS OWNER, NOT ME' THE CORRECT OWNER AT THAT TIME). TOYOTA WILL NOT ASSIST ME WITH THE REPAIR/FIX BECAUSE THEY CLAIM THEY DID THEIR JOB AND SENT THE NOTICE TO THE OWNER THAT THEY HAD ON FILE FROM THEIR RESOURCES. I HAVE A COPY OF MY DMV REGISTRATION SHOWING THE REGISTRATION DATE, PROVING THAT THEY MAILED THE LETTER & REPAIR DETAILS TO THE INCORRECT OWNER. I SENT A CERTIFIED LETTER TO THE TOYOTA LEGAL DEPARTMENT WITH THE DETAILS & PROOF OF OWNERSHIP, WHICH CLEARLY SHOWS I WAS THE RIGHTFUL OWNER AT THE TIME THEY MAILED THE LETTER. THEY SIGNED FOR MY LETTER ON 12/21/18. NOW IT IS 3 1/2 MONTHS LATER AND I HAVE NOT YET HEARD BACK FROM THEM. WHEN I CALL THEY OFFERED NO ASSISTANCE, TELLING ME THAT THE LEGAL DEPARTMENT CAN ONLY COMMUNICATE BY MAIL. TOYOTA HAS A MAJOR SAFETY ISSUE WITH THE FRAME THAT THEY NEVER INFORMED ME ABOUT. NOW MY CHERISHED TRUCK & DAILY TRANSPORTATION IS WORTH NOTHING BECAUSE OF TOYOTA'S DEFECTIVE FRAME. THIS COMPLAINT IS BEING ISSUED BECAUSE TOYOTA SHOULD BE HELD ACCOUNTABLE FOR THEIR DEFECTIVE FRAME AND LACK OF PROPERLY NOTIFYING ME, THE CORRECT OWNER, WITH THE SAFETY ISSUE & REPAIR OPTIONS.
Structure, Mar 14, 2019
I RECENTLY TOOK MY CAR TO MY MECHANIC AND HE INFORMED ME OF A RECALL FOR MY CAR MADE DUE TO THE ROTTING OF THE FRAME. I'VE HAD MY DAUGHTER CALL TOYOTA, WHO'S INFORMED HER THAT MAILS WERE SENT TO MY HOME ABOUT THE RECALL, WHICH I HAVE NEVER RECEIVED. I FEEL THE CONDITION OF THE FRAME IN MY CAR IS A VERY DANGEROUS HAZARD AND I AM NOT ABLE TO USE THIS VEHICLE AFRAID OF WHAT MIGHT HAPPEN.
Other or unspecified, Dec 29, 2018
TAKATA RECALL THE CHASSIS OF THE TRUCK IS COMPLETELY RUSTED. DOES NOT LOOK SAFE TO DRIVE.
Structure, Dec 24, 2018
FRAME IS RUSTING REAL BAD AND FALLING APART.CALLED TOYOTA AND DEALER AND THEY SAID THERE IS NOTHING THEY CAN DO. THERE IS A SUBSTANTIAL CRACKING AND BREAKING APART ON THE FRAME I READ ONLINE THIS IS A KNOWN ISSUE AND THERE IS PROBLEMS WITH A LOT OF TACOMA'S AND LIKE TRUCKS. BUT NO ONE WANTS TO TAKE OWNERSHIP OF THE PROBLEM. EVERYWHERE ELSE ON THE FRAME IS LITTLE RUSTY GIVEN THE AGE OF THE TRUCK BUT IN ONE SPOT IT IS ABSOLUTELY HORRIBLE AND SCARY. I DON'T KNOW WHAT ELSE TO DO OR WHERE ELSE TO TURN.
Structure, Nov 14, 2018
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT TOOK THE VEHICLE TO TOYOTA OF PORTLAND (55 NE BROADWAY ST, PORTLAND, OR 97232, (503) 284-1105) TO BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 12V542000 (TIRES). THE CONTACT WAS INFORMED THAT THE RECALL REPAIR COULD NOT BE PERFORMED DUE TO EXCESSIVE RUST ON THE VEHICLE'S FRAME. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 212,000.
Structure, Nov 4, 2018
I RECEIVED A RECALL FOR A SPARE TIRE HOLDER. I TOOK THE VEHICLE TO LE MIEUX TOYOTA-GREEN BAY FOR REPAIR AND THEY TOLD ME THAT THEY COULD NOT DO IT BECAUSE THE FRAME WAS TOO RUSTED OUT AND REMOVING THE OLD SPARE TIRE CARRIER WOULD MAKE THE PROBLEM WORSE. LE MIEUX SAID THAT THERE WAS AN EARLIER RECALL THAT ADDRESSED THE FRAME ISSUE. I DID NOT RECEIVE THAT RECALL. I CALLED DIRECTLY TO TOYOTA USA HOME OFFICE AND THEY REFUSE TO FIX THE RUSTING FRAME ISSUE. I BELIEVE THAT THIS HAPPENED MAYBE 2-3 YEARS AGO. I WAS NOT GIVEN A REASON FOR REJECTING MY REQUEST FOR THE REPAIR., AND I KNOW THAT LE MIEUX TOYOTA HAS FIXED OTHER TOYOTA VEHICLES WITH THE SAME ISSUES. I BELIEVE THAT THEY WOULD NOT FIX MY VEHICLE BECAUSE I AM A 2ND OWNER. I HAVE HAD SERVICE ISSUES WITH THIS DEALER ON 3 OTHER SEPARATE OCCASIONS, AND I HAVE REFUSED TO DO BUSINESS WITH THEM. WITH THIS RECALL ISSUE I HOPED FOR A POSITIVE SOLUTION, BUT THAT HAS NOT HAPPENED.
Structure, Nov 2, 2018
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. WHILE THE VEHICLE WAS STATIONARY, THE CONTACT NOTICED THAT THE UNDERCARRIAGE FRAME WAS SEVERELY RUSTED AND CORRODED. THE CONTACT STATED THAT THE UNDERCARRIAGE FRAME WAS FILLED WITH HOLES AND WAS PENETRABLE WHEN TOUCHED, THUS CREATING FURTHER DAMAGE. LE MIEUX TOYOTA (2550 SOUTH ONEIDA STREET, GREEN BAY, WISCONSIN 54304, (920) 496-2200) WAS MADE AWARE OF THE FAILURE AND STATED THAT DUE TO SIGNIFICANT FRAME DAMAGE, NHTSA CAMPAIGN NUMBER: 12V542000 (TIRES) COULD NOT BE REPAIRED ON THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.
Suspension, Oct 6, 2018
THE UNDERCARRIAGE IS SHOWING SUBSTANTIAL RUST AND CORROSION
Structure, Oct 3, 2018
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT TOOK THE VEHICLE TO RICK MCGILL'S AIRPORT TOYOTA (865-970-2615, LOCATED AT 3145 ALCOA HWY, ALCOA, TN 37701) FOR AN OIL CHANGE. THE TECHNICIAN DIAGNOSED THAT THE ENTIRE FRAME WAS RUSTED AND THE VEHICLE WAS DANGEROUS TO DRIVE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE MANUFACTURER ALSO INFORMED THE CONTACT THAT A CUSTOMER SUPPORT PROGRAM, WHICH PROVIDED ASSISTANCE TO VEHICLE OWNERS, EXPIRED IN SEPTEMBER OF 2017. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 118,000. *JS
Suspension, Structure, Sep 25, 2018
VEHICLE FAILED INSPECTION DUE TO FRAME RUST. WAS TOLD THAT ITS UNSAFE TO DRIVE. RESEARCHED AND FOUND THAT THIS IS LONG ONGOING ISSUE WITH TOYOTA AND A NUMBER OF THERE VEHICLES. TOYOTA HAS KNOWLEDGE OF THIS ISSUE AND STILL SOLD THESE INFERIOR FRAMES FOR MANY YEARS.