2003 Toyota Tacoma
Problems, recalls and owner-reported issues
Structure is the leading concern among 371 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Tacoma model years with reports.
Of the 2003 reports, 31 involved a crash and 1 involved a fire. 22 people were injured.
What owners report most often
Recalls and investigations
Tires, temporary/emergency spare tireNov 23, 2012
Toyota is recalling certain model year 2001 through 2004 Tacoma light trucks manufactured from August 28, 2000, through August 27, 2004, and originally sold, or currently registered, in the following cold climate states with high road salt usage: Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. The spare tire in the subject vehicles is located underneath the rear of the vehicle and held by a spare tire carrier. A lift plate on the carrier is used to help raise, lower and retain the tire. During its manufacture, the lift plate may not have been sufficiently coated with anti-corrosion materials. If the plate is insufficiently coated and the vehicle is operated in cold climate regions where road salts are frequently used, road spray can reach the carrier assembly and corrode the lift plate.
Corrosion of the plate could cause it to break, which could result in detachment of the spare tire from the vehicle. Detachment of the spare tire could result in a road hazard which may increase the risk of a vehicle crash.
Toyota will notify owners, dealers will inspect the vehicle and replace the spare tire carrier lift plate as necessary, free of charge. The recall began in February 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Campaign 12V542000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Suspension, front, control arm, lower ball jointMay 17, 2005
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.
THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.
DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 05V225000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsMay 19, 2003
ON CERTAIN PICKUP TRUCKS, DURING SIDE IMPACT NCAP TEST (I.E. LINCAP TEST), A FLANGE AT THE REAR END OF THE DOUBLE CAB BODY DEFORMED AND INTERFERED WITH THE FUEL INLET HOSE THAT CONNECTS THE FUEL FILLER PIPE AND FUEL TANK, RESULTING IN DAMAGE TO THE FUEL INLET HOSE.
THIS DAMAGE COULD RESULT IN FUEL LEAKAGE, WHICH COULD RESULT IN A FIRE IF IN THE PRESENCE OF AN IGNITION SOURCE.
DEALERS WILL INSTALL A FUEL HOSE PROTECTOR ON THE BODY FLANGE. OWNER NOTIFICATION BEGAN JUNE 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Campaign 03V189000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
16 reports, newest first. Show all
Suspension, Engine and engine cooling, Nov 23, 2012
PURCHASED USED VEHICLE FROM PRIVATE SELLER. ON THE FIRST DAY OF USE, AFTER OBTAINING NEW TITLE, TAGS, INSURANCE COVERAGE, THE CHECK ENGINE LIGHT CAME ON. THE FOLLOWING DAY SCHEDULED SERVICE W/ THE LOCAL TOYOTA DEALER. UPON INSPECTION WAS TOLD THAT THE TRUCK NEEDED A CATALYTIC CONVERTER AND THERE WAS A RECALL FOR THE LOWER FRONT BALL JOINTS THAT THE DEALER WILL REPLACE FOR FREE. THE DEALER HAD TO ORDER THE PARTS. AFTER RECEIVING THE PARTS AND UPON START OF THE REPAIRS, I RECEIVED A PHONE INFORMING ME THAT THE FRAME WAS RUSTED AND THE VEHICLE IS DEEMED UNSAFE TO DRIVE. I WAS GIVEN AN 800 PHONE NUMBER TO CALL AND DEAL DIRECTLY WITH TOYOTA CORPORATE OFFICE. I AM PATIENTLY AWAITING FOR A RESPONSE. *TR
Engine and engine cooling, Feb 25, 2010
WELL, I HAVE OWNED MY TOYOTA TACOMA 03' SINCE IT WAS NEW AND WAS AWARE OF SOME UNUSUAL PATTERNS OF INCREASED ENGINE REVVING FOR YEARS. I TOLD MY MECHANIC SPECIFICALLY ABOUT THE ISSUE AND HE REALLY DIDN'T BELIEVE IT WAS ACTING THAT WAY. THE FIRST TIME I EXPERIENCED THIS PHENOMENON WAS WHEN I LEFT THE VEHICLE IDLING WHILE I WENT INTO A GAS STATION CONVENIENCE STORE AND WAS ALERTED OF THE IDLING TO BE HIGHER THAN WHEN I WENT IN THE STORE. I WAS STARTLED BECAUSE IT WAS REVVING ON ITS OWN, HIGHER AND HIGHER UNTIL IT LEVELED OFF AT A BIT HIGHER THAN NORMAL AND FINALLY TO AVERAGE IDLING. IT WAS CREEPY. THIS HAPPENED ON SEVERAL OCCASIONS MOSTLY WHEN I WOULD LEAVE THE CAR IDLING. ONLY 1 INCIDENT OCCURRED WHILE AT A STOP LIGHT I WAS IDLING IN PARK AND IT BEGAN TO IDLE HIGHER BUT NOT AS I SHOULD NOTICE ABSOLUTELY SOMETHING WAS WRONG. WHEN I SHIFTED FROM PARK TO DRIVE THE REVVING INCREASED AND I SHUTTLED AHEAD TOWARDS THE VEHICLE IN FRONT OF MY TRUCK WITHOUT PRESSING THE GAS AND AS I WAS ABOUT TO HIT THE VEHICLE AHEAD OF MINE THE ENGINE SLOWED AGAIN. I WAS EXTREMELY TERRIFIED AT THAT MOMENT. NOTHING STRANGE OCCURRED THAT DAY AFTER THAT. I QUESTIONED IF I HAD PRESSED THE GAS OR IF MAYBE SOMETHING, SOMEHOW, I MIGHT HAVE OVER LOOKED, BUT I DECIDED THAT THERE WAS DEFINITELY A STRANGE STICKING GOING ON IN THE ENGINE. I ALSO CONSIDERED IF IT WAS THE GAS PEDDLE PERHAPS, BUT I RULED THAT OUT AS, IT WOULD REV MOSTLY ON IDLES ON ITS OWN. *TR
Engine and engine cooling, Jan 14, 2010
LEAKY WATER PUMP DISCOVERED UPON ROUTINE CHANGE OF TIMING BELT ON 2003 TOYOTA TACOMA 2WD PRERUNNER. DISCOVERED COMPLETE LACK OF GASKET AND WOEFULLY INADEQUATE AMOUNT OF SEALANT APPARENTLY APPLIED AT FACTORY. (NO MORE THAN 1/8" WIDE AFTER COMPRESSION BETWEEN WATER PUMP HOUSING AND ENGINE BLOCK) ENGINE CONTINUALLY USED A SMALL AMOUNT OF COOLANT/ANTIFREEZE AND OVER TIME HAD BUILT UP A SUBSTANTIAL VOLUME OF SLUDGE/CRUSTY COOLANT AROUND WATER PUMP HOUSING AND TIMING BELT (CRANKSHAFT) PULLEY. ALTHOUGH ABSENT IN THIS INSTANCE, THIS BUILD-UP HAS THE POTENTIAL TO BREAK LOOSE AND FALL BETWEEN THE TIMING BELT AND PULLEY AND ULTIMATELY CAUSE TIMING BELT BREAKAGE. REPLACED BELT AND WATER PUMP. RE-MANUFACTURED WATER PUMP IS EQUIPPED WITH A GASKET. *TR
Engine and engine cooling, Apr 1, 2009
I WAS DRIVING MY 2003 TACOMA WHEN THE BATTERY AND OIL LIGHTS CAME ON AND THE TRUCK BECAME UNDRIVEABLE. WHEN THE LIGHTS WENT OFF I WAS ABLE TO DRIVE AGAIN. I HAD TRUCK TOWED TO MECHANIC AND FOUND OUT THAT CRANKSHAFT BOLT WAS BROKEN/SHEARED OFF. HAD TRUCK TOWED TO DEALERSHIP FOR CONFIRMATION - THEY CONFIRMED. HAD INSURANCE ADJUSTER LOOK AT IT TO DETERMINE IF RELATED TO ANY ACCIDENTS - NO RELATION. CALLED TOYOTA CORP AND THEY SAID THAT BOLT SHOULD NOT BREAK UNLESS UNDER EXTREME TORQUE OF DEFECT. MECHANIC, DEALERSHIP AND INSURANCE ADJUSTER ALL SAID THE SAME. THE BOLT IS MADE OUT OF CASE-HARDENED STEEL. I HAVE NOT HAD ANY MAJOR WORK DONE TO THE TRUCK THAT WOULD INVOLVE THE CRANKSHAFT BOLT!! DEALERSHIP IS QUOTING COST OF APPROX $4000 FOR SHORT BLOCK REPAIR. IF BOLT IS/WAS DEFECTIVE I SHOULD NOT HAVE TO PAY FOR ANY OF THE REPAIRS THAT SHOULD FALL ON TOYOTA WHETHER OR NOT THE TRUCK IS OUT OF WARRANTY. I NEED THIS FIXED! *TR
Engine and engine cooling, Fuel system, Gasoline, Oct 1, 2008
MY ENGINE LIGHT ON MY 2003 TOYOTA TACOMA KEEPS COMING ON. I SENT $1000 TO REPLACE THE OXYGEN SENSOR AND THEN THE EVAP CONNECTOR ASSEMBLY. THE ENGINE LIGHT IS STILL ON. THE REPAIR SHOP TOLD ME THEY'VE REPLACED MANY OF THESE ON TOYOTAS. *TR
Engine and engine cooling, Fuel system, Gasoline, Jul 7, 2008
MY 2003 TOYOTA TACOMA V6 SR5 DOUBLE CAB 4X4 HAS A CONDITION WHERE THE THROTTLE CUTS OUT WHILE ACCELERATING. THIS IS A VERY DANGEROUS SITUATION WHEN PULLING INTO TRAFFIC OR WHILE DRIVING IN TRAFFIC. *TR
Engine and engine cooling, Sep 26, 2007
TL*THE CONTACT OWNS A 2003 TOYOTA CAMRY. THE CONTACT HEARD A LOUD TICKING AND RATTLING NOISE COMING FROM UNDER THE HOOD WHEN THE VEHICLE WAS STARTED. SHE IMMEDIATELY TOOK THE VEHICLE TO A DEALER AND THEY PERFORMED A DIAGNOSTIC TEST. THE TEST INDICATED THAT THE INTAKE MANIFOLD WAS SEPARATING FROM THE INSIDE. THE DEALER STATED THAT THE VEHICLE HAD TOO MANY MILES TO BE COVERED UNDER WARRANTY. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 62,000.
Engine and engine cooling, Electrical system, Dec 29, 2006
I PURCHASED MY 2003 TOYOTA TACOMA 4X4 IN MAY OF 2003 IN WHICH AS OF THIS DATE OF 12.29.06 MY TRUCK HAS 43K MILES ON IT AND IS IN EXCELLANT CONDITION. OVER THE COURSE OF THE PAST 6 MONTHS I HAVE HAD TO SPEND THOUSANDS OF DOLLARS ON THIS TRUCK AND STILL CAN NOT DRIVE IT. I HAVE HAD TO PUT A BRANDNEW CRANKSHAFT KIT IN MY TRUCK DUE TO THE KEYWAY ON THE CRANKSHAFT SHEARING OFF RESULTING IN MY TRUCK SHUTTING DOWN. AFTER INSPECTING MY TRUCK BY A CERTIFIED MECHANIC THE KEY WAS NOT THERE AFTER IT HAD SHEARED OFF IN WHICH PARTS HAD MOVED FORWARD AND GROUND INTO THE METAL. AFTER THE CRANKSHAFT REPLACEMENT I CONTINUED TO HAVE MORE AND MORE PROBLEMS WITH THE TRUCK. I HAVE REPLACED THE CRANKSHAFT, HARMONIC BALANCER, NEW FAN, OIL PUMP BECAUSE THE TRUCK WILL NOT HOLD OIL PRESSURE, MASS AIR FLOW SENSOR, CRANK SENSOR, CAM SENSOR'S, RE-SETTING OF THE COMPUTER AND LABOR COST. I PICKED MY TRUCK UP ON A FRIDAY AFTER IT CAME BACK FROM HUNTERSVILLE, NC AT LAKE NORMAN TOYOTA IN WHICH THE TRUCK WAS HOOKED UP AND WAS GIVEN A CLEAN BILL OF HEALTH BUT, THE TRUCK LEFT ME STRANDED ONCE AGAIN ON SUNDAY NIGHT AT 7:00 PM IN WHICH I HAD TO HAVE A ROLL BACK PICK IT UP FOR THE FOURTH TIME. THE OIL LIGHT CAME ON WHEN THE ENGINE WOULD IDLE LESS THAN 1K RPMS IN WHICH IT THEN FINALLY HAD TO BE SHUT OFF AS SOON AS I HEARD THIS DUE TO THE SOUNDS OF METAL RUBBING METAL. THE TRUCK IS NOW LOCATED AT LEATHERMAN AUTO LOCATED IN NEWTON, NC (828.465.5269) IN WHICH THE OWNER, SCOTT HAS NOT MADE ANY REPAIRS TO THIS TRUCK YET. THE CHECK ENGINE LIGHT HAS CAME ON IN ALL FOUR INSTANCES AS WELL AS THE OIL LIGHT AND OTHER LIGHTS AND I THEN LOOSE CONTROL OF MY TRUCK DUE TO IT SHUTTING DOWN. I WAS ON I-40 TRAVELING AT 65-70 MPH WHEN MY TRUCK STARTED JERKING AGAIN AND THEN I LOST MY POWER STEERING AGAIN AND HAD TO FIGHT WITH THE TRUCK TO GET IT OFF THE ROAD. THE TRUCK IS STALLING OUT IN WHICH I AM IN FEAR OF EITHER MYSELF OR ONE OF MY FAMILY MEMBERS BECOMING INJURED OR POSSIBLY KILLED BECAUSE OF THIS INSTANCE.
Engine and engine cooling, Fuel system, Gasoline, Jul 14, 2006
INTERMITTENT CHECK ENGINE LIGHT AND ROUGH IDLE - 2003 TOYOTA TACOMA 2.7L AUTO, DOUBLE CAB, 55K MILES CHECK ENGINE LIGHT CAME ON. TOOK VEHICLE TO LOCAL CHAIN SHOP WHO DIAGNOSED ERROR CODE PO511 - IDLE AIR CONTROL VALVE (IACV). TOYOTA PARTS DEPARTMENT PRICES THIS PART AT $226 AND SERVICE MANAGER INDICATED $249 FOR LABOR (NOT INCLUDING TAX). VEHICLE CURRENTLY HAS 55K MILES ON IT AND "ENGINE" SHOULD BE COVERED BY 6 YR/60K MILE POWERTRAIN WARRANTY. TOOK VEHICLE TO DEALER (TO HAVE OTHER RECALLS CORRECTED) WHO INDICATED A $90 FEE WAS REQUIRED JUST TO DIAGNOSE CHECK ENGINE LIGHT. TOYOTA CUSTOMER SERVICE INDICATED THE IACV WAS ONLY COVERED TO 3YR/36K AND THAT I SHOULD PAY DEALER FEE AND SEEK "FACTORY ASSISTANCE" FOR ANY COSTS TO REPAIR. I CONTEND THAT THIS TYPE OF A PART - NOT SERVICEABLE/MAINTAINABLE BY THE CUSTOMER, SHOULD BE GUARANTEED AGAINST FAILURE FOR MORE THAN ~50K MILES AND REPAIR SHOULD BE COVERED BY MANUFACTURER. *JB
Engine and engine cooling, May 9, 2006
I BROUGHT THIS CAR AND IT WAS IN A ACCIDENT. THE DEALERSHIP LIED TO ME BECAUSE THEY TOLD ME THAT AL THE PARTS WERE GOING TO BE COVERED BY THE GUARANTEE. HOW EVER ALL THE PARTS WERE NOT COVERED AND I HAD TO PAY SOME OF THE. I WENT TO THE DEALERSHIP AND COMPLAINED BUT THEY WOULD NOT LISTEN TO ME. THE CAR ALSO LEAKS OIL BUT THE DEALERSHIP DOESN'T PAY ATTENTION. *JB
Engine and engine cooling, Nov 1, 2005
DT: THE CONTACT STATES THAT AFTER SUDDENLY BRAKING ON LEVEL GROUND THE VEHICLE STALLED. ON THREE OTHER OCCASIONS IT STALLED WHILE TRYING TO INCREASE SPEED ON AN INCLINE. ONE OF THESE OCCASIONS WHILE DRIVING BETWEEN 40-45 MPH THE VEHICLE WOULD RESTART AFTER BEING COMPLETELY TURNED OFF. THE DEALERSHIP COULD NOT DUPLICATE THE PROBLEM. *AK UPDATED 11/29/2005 - *NM
Engine and engine cooling, Feb 28, 2005
AFTER DRIVING THE VEHICLE FOR 40 MINUTES TO ONE HOUR FUMES BECOME SICKENING TO THE POINT THAT IT WAS UNBEARABLE. DEALER CHECKED THE VEHICLE, HAD EVEN KEPT THE VEHICLE IN THE SHOP, TYPED OUT A REPORT, BUT FUMES WERE STILL COMING INTO THE VEHICLE. *AK
Engine and engine cooling, Oct 25, 2004
WHILE EXITING A 65 MPH TOLLWAY DURING THE RAIN. THE DRIVER ENCOUNTERED A PUDDLE APPROXIMATELY 18" - 24" DEEP AND ~70' LONG GOING ~35MPH. ABOUT HALFWAY THROUGH THE PUDDLE THE VEHICLE STARTED TO FAULTER. UPON EXITING IT TOTALLY STOPPED AND WOULD NOT TURN OVER. THE REPAIR SHOP REPORTS THAT THE ENGINE HAD INGESTED WATER, DESTROYING THE INTERNAL WORKINGS AND IT WOULD REQUIRE A LONG BLOCK REPLACEMENT AT A COST OF ~$6,500.*AK
Engine and engine cooling, Power train, Vehicle speed control, Mar 10, 2004
VEHICLE HAS A HISTORY OF PROBLEMS THAT THE DEALER CANNOT DETERMINE THE CAUSES. VEHICLE DOES NOT PROPERLY SHIFT INTO GEAR, HAS A ROUGH IDLE, AND A KNOCKING NOISE IN THE ENGINE. DEALER COULD NOT DUPLICATE THE PROBLEMS BECAUSE THEY WERE INTERMITTENT. *AK
Engine and engine cooling, Feb 19, 2004
WHILE STARTING UP THE VEHICLE IDLING IS HIGH FOR TWELVE MINUTES. THE DRIVER HAS TO PRESS DOWN ON THE BRAKES TO PREVENT THE VEHICLE FROM ACCELERATING. THE DRIVER DROVE THE VEHICLE TO DEALER FOR ANALYSIS. THE TECHNICIAN CAN NOT DUPLICATED THE PROBLEM. *MR
Engine and engine cooling, Feb 5, 2003
CONSUMER IS LOOSING ENGINE POWER. DEALER WAS CONTACTED. PH