2003 Toyota Tacoma
Problems, recalls and owner-reported issues
Structure is the leading concern among 371 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Tacoma model years with reports.
Of the 2003 reports, 31 involved a crash and 1 involved a fire. 22 people were injured.
What owners report most often
Recalls and investigations
Tires, temporary/emergency spare tireNov 23, 2012
Toyota is recalling certain model year 2001 through 2004 Tacoma light trucks manufactured from August 28, 2000, through August 27, 2004, and originally sold, or currently registered, in the following cold climate states with high road salt usage: Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. The spare tire in the subject vehicles is located underneath the rear of the vehicle and held by a spare tire carrier. A lift plate on the carrier is used to help raise, lower and retain the tire. During its manufacture, the lift plate may not have been sufficiently coated with anti-corrosion materials. If the plate is insufficiently coated and the vehicle is operated in cold climate regions where road salts are frequently used, road spray can reach the carrier assembly and corrode the lift plate.
Corrosion of the plate could cause it to break, which could result in detachment of the spare tire from the vehicle. Detachment of the spare tire could result in a road hazard which may increase the risk of a vehicle crash.
Toyota will notify owners, dealers will inspect the vehicle and replace the spare tire carrier lift plate as necessary, free of charge. The recall began in February 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Campaign 12V542000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Suspension, front, control arm, lower ball jointMay 17, 2005
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.
THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.
DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 05V225000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsMay 19, 2003
ON CERTAIN PICKUP TRUCKS, DURING SIDE IMPACT NCAP TEST (I.E. LINCAP TEST), A FLANGE AT THE REAR END OF THE DOUBLE CAB BODY DEFORMED AND INTERFERED WITH THE FUEL INLET HOSE THAT CONNECTS THE FUEL FILLER PIPE AND FUEL TANK, RESULTING IN DAMAGE TO THE FUEL INLET HOSE.
THIS DAMAGE COULD RESULT IN FUEL LEAKAGE, WHICH COULD RESULT IN A FIRE IF IN THE PRESENCE OF AN IGNITION SOURCE.
DEALERS WILL INSTALL A FUEL HOSE PROTECTOR ON THE BODY FLANGE. OWNER NOTIFICATION BEGAN JUNE 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Campaign 03V189000 on NHTSA.gov
Representative owner complaints: vehicle speed control
29 reports, newest first. Show all
Engine and engine cooling, Power train, Vehicle speed control, Mar 10, 2004
VEHICLE HAS A HISTORY OF PROBLEMS THAT THE DEALER CANNOT DETERMINE THE CAUSES. VEHICLE DOES NOT PROPERLY SHIFT INTO GEAR, HAS A ROUGH IDLE, AND A KNOCKING NOISE IN THE ENGINE. DEALER COULD NOT DUPLICATE THE PROBLEMS BECAUSE THEY WERE INTERMITTENT. *AK
Vehicle speed control, Feb 2, 2004
AS SOON AS THE CONSUMER STARTED THE VEHICLE THE RPM'S REVVED EXTREMELY HIGH AND THE VEHICLE LUNGED FORWARD. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE THROTTLE ACTUATOR CONTROL MOTOR THREE TIMES IN AS MANY DAYS. THE MANUFACTURER WILL BE INFORMED OF THE PROBLEM. *NM
Vehicle speed control, Sep 10, 2003
NAR 9-10-03. FOIA EMAIL FWD FM KOST/GC INQUIRING HOW MANY 2003 TOYOTA'S HAVE HAD A PROBLEM OF ACCELERATING WHILE THE BRAKE IS BEING APPLIED, ES HAVE NO RECORD. *CB
Power train, Vehicle speed control, Feb 15, 2003
CAR STALLS (GAS PEDAL DOES NOT RESPOND) WHEN TURNING INTO TRAFFIC. ALSO WHEN SLOWING TO A LOW SPEED AND THEN ACCELERATING. THIS HAS CAUSED US TO ALMOST BE HIT SEVERAL TIMES IN THE SIDE AND IN THE REAR. MOST OF THE TIME WHEN THIS HAPPENS THE CAR WITH TIRE MARKS LIGHT ON THE INSTRUMENT PANEL COMES ON AND FLASHES. THERE IS NO WAY TO PREDICT WHEN THIS SUDDEN LOSS OF THE ACCELERATOR WILL HAPPEN. IT IS VERY DANGEROUS. THIS HAPPENS AT LEAST ONCE ALMOST EVERY TIME WE DRIVE. ALSO SOMETIMES WHEN YOU START THE CAR AND BEGIN TO GO YOU HEAR DINGING SOUNDS AND FEEL AND HEAR BUMPS AND GRINDING NOISES. 2 LIGHTS COME ON IN THE INSTRUMENT PANEL WHEN THIS HAPPENS. 1 READS VSC TRAC AND THE OTHER READS TRAC OFF. IF YOU STOP AND RESTART THE ENGINE IT WILL EVENTUALLY STOP DOING IT. SOMETIMES THIS IS AFTER 1 RESTART AND SOMETIMES IT HAS TAKEN 5 AND 6. ON DAY IT WOULD NOT STOP NO MATTER HOW MANY TIMES YOU RESTARTED AND WE HAD TO DRIVE WITH LIGHTS ON. THIS HAS HAPPENED ABOUT 10 DIFFERENT TIMES.