2003 Toyota Tacoma
Problems, recalls and owner-reported issues
Structure is the leading concern among 371 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Tacoma model years with reports.
Of the 2003 reports, 31 involved a crash and 1 involved a fire. 22 people were injured.
What owners report most often
Recalls and investigations
Tires, temporary/emergency spare tireNov 23, 2012
Toyota is recalling certain model year 2001 through 2004 Tacoma light trucks manufactured from August 28, 2000, through August 27, 2004, and originally sold, or currently registered, in the following cold climate states with high road salt usage: Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. The spare tire in the subject vehicles is located underneath the rear of the vehicle and held by a spare tire carrier. A lift plate on the carrier is used to help raise, lower and retain the tire. During its manufacture, the lift plate may not have been sufficiently coated with anti-corrosion materials. If the plate is insufficiently coated and the vehicle is operated in cold climate regions where road salts are frequently used, road spray can reach the carrier assembly and corrode the lift plate.
Corrosion of the plate could cause it to break, which could result in detachment of the spare tire from the vehicle. Detachment of the spare tire could result in a road hazard which may increase the risk of a vehicle crash.
Toyota will notify owners, dealers will inspect the vehicle and replace the spare tire carrier lift plate as necessary, free of charge. The recall began in February 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Campaign 12V542000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Suspension, front, control arm, lower ball jointMay 17, 2005
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.
THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.
DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 05V225000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsMay 19, 2003
ON CERTAIN PICKUP TRUCKS, DURING SIDE IMPACT NCAP TEST (I.E. LINCAP TEST), A FLANGE AT THE REAR END OF THE DOUBLE CAB BODY DEFORMED AND INTERFERED WITH THE FUEL INLET HOSE THAT CONNECTS THE FUEL FILLER PIPE AND FUEL TANK, RESULTING IN DAMAGE TO THE FUEL INLET HOSE.
THIS DAMAGE COULD RESULT IN FUEL LEAKAGE, WHICH COULD RESULT IN A FIRE IF IN THE PRESENCE OF AN IGNITION SOURCE.
DEALERS WILL INSTALL A FUEL HOSE PROTECTOR ON THE BODY FLANGE. OWNER NOTIFICATION BEGAN JUNE 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Campaign 03V189000 on NHTSA.gov
Representative owner complaints
371 reports, newest first.
Fuel system, Gasoline, Apr 9, 2021
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED WHILE THE VEHICLE WAS PARKED IN THE GARAGE, RODENTS ATE THE FUEL LINE CAUSING A FUEL LEAK. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO HALEY TOYOTA OF ROANOKE (1530 COURTLAND RD NE, ROANOKE, VA 24012) WHERE IT WAS DIAGNOSED WITH THE FUEL LINE NEEDING TO BE REPLACED. THE VEHICLE HAD BEEN REPAIRED TWICE HOWEVER, THE ISSUE RECURRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000. THE VIN WAS UNAVAILABLE.
Suspension, Other or unspecified, Apr 3, 2021
THE FRAME IS ROTTED AND WAS NEVER ADDRESSED TO BE FIXED
Structure, Tires, Mar 12, 2021
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 12V542000 (TIRES) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT STATED THAT WHILE HAVING A ROUTINE CHECK UP AT LITHIA TOYOTA OF REDDING (250 E. CYPRESS AVE, REDDING, CA 96002, (530) 250-3207) THE TECHNICIAN INFORMED HIM THAT THE SPARE TIRE HAD SEVERE CORROSION, AS WELL AS THE REAR SUBFRAME. THE VEHICLE WAS NOT REPAIRED DUE TO PART NOT BEING AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE RECALL HAD EXPIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 450,000. PARTS DISTRIBUTION DISCONNECT.
Seats, Other or unspecified, Mar 11, 2021
ONCE YOU FASTEN THE SEAT BELT, IT TIGHTENS WITH ANY MOVENT AND RESTRAINS THE BODY TO THE POINT THAT DISABLES MOVEMENT OR EVEN BREATHING. THIS IS VERY UNSAFE.
Suspension, Seat belts, Structure, Feb 28, 2021
I NOTICED A SMALL HOLE UNDERNEATH THE PASSENGER SIDE OF THE FRAME JUST IN FRONT OF THE LEAF SPRING AND NOW THE HOLE HAS GROWN TO THE SIZE OF A QUARTER. THERE IS ALSO QUITE ALOT OF RUST UNDERNEATH THE TRUCK AS WELL AS THE SPARE TIRE HOLDER. I LIVE IN CALIFORNIA AND THIS TRUCK WAS PURCHASED FROM A TOYOTA DEALERSHIP IN PENNSYLVANIA. THANKS FOR YOUR COOPERATION. SINCERELY,[XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Structure, Feb 25, 2021
WHEN I WENT TO THE GARAGE FOR THE YEARLY INSPECTION, I WAS INFORMED BY THE MECHANIC THAT THE FRAME ON MY TACOMA WAS RUSTED SEVERELY WITH MAJOR HOLES AND COULD NOT BE INSPECTED. I WAS TOLD THAT THERE WAS A RECALL ON THE FRAME FOR SUCH ISSUES AND THAT I SHOULD CALL THE DEALER WHO SOLD THE TRUCK. BEING AS THE DEALER WAS NO LONGER OPEN (RETIRED), I WAS UNABLE TO SPEAK TO HIM. II CALLED THE TOYOTA COMPANY, AND WAS TOLD THAT THE RECALL WAS NO LONGER IN EFFECT AND THAT THEY COULD NOT HELP ME. I ASKED WHY I WAS NOT INFORMED ABOUT THIS RECALL AS I WAS THE REGISTERED OWNER OF THE VEHICLE, I WAS TOLD THAT "EVERYONE THAT OWNED ONE SHOULD HAVE GOTTEN A NOTICE." I WROTE A LETTER TO THE TOYOTA COMPANY IN JANUARY 2020 AND DID NOT RECEIVE A REPLY.
Structure, Jan 8, 2021
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED WHILE THE VEHICLE WAS AT AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE, IT WAS DISCOVERED THAT THE UNDERCARRIAGE WAS RUSTED AND CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE HOWEVER, OFFERED NO ASSISTANCE. THE WARRANTY WAS EXPIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 123,208.
Suspension, Oct 24, 2020
FRAME IS RUSTING.
Structure, Oct 1, 2020
RUST, CORROSION, OR OTHER FAILURE OR DETACHMENT OF EXTERIOR BODY AND FRAME COMPONENTS, THE VEHICLE IS ROTTED UNDERNEATH
Other or unspecified, Sep 3, 2020
I TOOK MY TACOMA FOR STATE INSPECTION AND THEY COULD NOT LIFT IT BECAUSE THE FRAME HAS A HOLE THROUGH IT AT THE FRONT MOUNTING POINT OF THE REAR SPRING ON THE DRIVERS SIDE. THE MECHANIC TOLD ME HITTING A SEVER BUMP OR A POTHOLE COULD SNAP THE FRAME IN HALF. I HAVE OWNED THE TRUCK FOR ALMOST 10 YEARS AND NEVER RECEIVED A RECALL NOTICE ABOUT THE FRAME, ONLY ON THE SPARE TIRE CARRIER. I'M NOT A COMPUTER EXPERT AND DON'T KNOW HOW TO ADD A PICTURE OF THE FRAME TO THIS DOCUMENT. I DO KNOW THAT I NEED THE TRUCK BUT I AM UNABLE TO GET IT INSPECTED TO DO SO. PLEASE HELP.
Structure, Aug 17, 2020
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE'S SUBFRAME HAD RUSTED THROUGH WITH FIVE HOLES TO THE SUBFRAME. THE VEHICLE WAS TAKEN TO BENNETT TOYOTA (1951 LEHIGH ST, ALLENTOWN, PA 18103), WHERE IT WAS CONFIRMED THAT THERE WERE FIVE HOLES IN THE SUBFRAME AND THAT THE SUBFRAME NEEDED TO BE REPLACED. THE DEALER INFORMED THE CONTACT THE VEHICLE WAS OUT OF WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS OUT OF WARRANTY AND OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 143,000.
Suspension, Structure, Jul 24, 2020
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC, WHERE SHE WAS INFORMED THAT THE DRIVER?S AND PASSENGER?S SIDE REAR SUBFRAME AND REAR LEAF SPRING WERE FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO BERLIN CITY TOYOTA OF PORTLAND LOCATED AT 191 RIVERSIDE ST, PORTLAND, ME 04103 (207) 618-6528, AND THE DEALER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.*DT 8/14/2020 EDIT BY [XXX]: I WOULD ALSO LIKE TO ADD THAT THE TACOMA WAS BROUGHT INTO THE SEASHORE TACOMA DEALERSHIP IN NEW JERSEY BACK IN 2013 FOR A DIFFERENT RECALL AND THE FRAME RECALL WAS NEVER ADDRESSED OR BROUGHT UP TO ME WHILE MY TACOMA WAS THERE. I WOULD ALSO LIKE TO NOTE THAT IN 2016 WHILE I WAS STATIONED IN ALASKA, I RECEIVED A POST CARD ABOUT THE EXTENDED WARRANTY. I PROMPTLY CALLED THE NUMBER AND WAS ADVISED THAT THE WARRANTY DID NOT PERTAIN TO MY TACOMA. OTHERWISE, I WOULD HAVE PUT IT ON THE FERRY TO JUNEAU FOR THE INSPECTION. LASTLY, I HAVE OWNED THIS TACOMA SINCE 2009. IT AS BEEN STATIONED WITH ME FOR 4 YORK IN FL, 4 YORK IN NJ, 4 YORK IN SITES, AK AND 2 YEARS IN ME. IT ALSO PREVIOUSLY LIVED BETWEEN IN KY AND FL PRIOR TO ME. HAD I BEEN ASKED THE RIGHT QUESTIONS ABOUT THE ORIGIN OF THE TACOMA THEN I'M SURE THEY WOULD HAVE TOLD ME THE TRUCK WAS ELIGIBLE FOR THE EXTENDED WARRANTY. *DT INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB
Structure, Jun 19, 2020
A LOT OF RUST ON THE FRAME AND RUST UNDERNEATH. CLEAN AND WELL TAKEN CARE BUT THE RUST STILL EXIST. I EVEN HAVE TO REPLACE THE EXHAUST BECAUSE IT FALL OFF DUE TO THE RUST. THE RUST UNDERNEATH ARE ALMOST EVERYWHERE. *TR
Structure, Jun 9, 2020
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT THE SUBFRAME AND UNDERCARRIAGE OF THE VEHICLE WAS RUSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT INFORMED OF THE FAILURE. THE MANUFACTURER WAS INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
Suspension, Structure, Jun 6, 2020
I PURCHASED MY 2003 TACOMA SECOND HAND BACK IN 2015 WHICH SERVES AS MY PRIMARY VEHICLE TO THIS DAY. AFTER RETURNING FROM A YEAR LONG DEPLOYMENT OVERSEAS, I HAD A FEW FRIENDS OVER ON 4JUN OF WHICH ONE WAS ADMIRING MY TRUCK UNTIL HE LOOKS UNDERNEATH AND NOTICES ALL THE FRAME RUST. HE ADVISES THAT THERE IS A RECALL ON IT AND I SHOULD CONTACT MY TOYOTA DEALER TO GET IT SERVICED. FEELING DISTRAUGHT, I GO ONLINE AND LOOKUP RECALLS FOR MY CAR WHICH LED ME TO THE "FRAME RUST" SAFETY ISSUE ON A MANY TOYOTA MODELS TO INCLUDE MY OWN. THE ADVISEMENT SUGGESTS SAFETY CONCERNS WITH THE FRAME RUSTING THROUGH DUE TO FACTORY NEGLIGENCE IN SUFFICIENTLY COATING WITH ANTI-CORROSION MATERIALS. FURTHER RESEARCH IN OTHER FORUMS STATE OTHER TOYOTA OWNERS DESCRIBING IT AS FRAME RUST ALTOGETHER AND NOT JUST ON THE SPARE TIRE PLATE. ISSUES DESCRIBED INCLUDE THE ISSUE CAUSING THE LEAF SPRING TO SNAP AND THE FRAME ITSELF RUSTING THROUGH. INSPECTION OF MY TRUCK PROVES TRUE TO ALL ACCOUNTS DESCRIBED. I CONTACTED SERVCO TOYOTA IN HONOLULU, HI THE VERY NEXT DAY AND SPOKE TO A NICE LADY. I EXPLAINED HOW I BECAME THE OWNER OF THE VEHICLE SINCE 2015 AND WAS NEVER MADE AWARE OF THIS RECALL. SHE CHECKED MY VIN TO CONFIRM THAT I WAS AFFECTED BY IT, HOWEVER THE RECALL HAS EXPIRED AS OF 2018 SO THERE IS NOTHING THEY CAN DO. SHE GAVE ME THE 1-800 NUMBER TO TOYOTA WHICH LED ME NOWHERE AND KEPT DIVERTING ME BACK TO SERVCO TOYOTA INSTEAD OF THEIR MAIN OFFICE..... WHAT FRUSTRATES ME THE MOST IS THAT TOYOTA PROVIDED ME NO NOTICE OR WARNING ABOUT THIS RECALL. SO HOW CAN I REACT TO SOMETHING I WAS NEVER MADE AWARE OF. SAFETY RECALLS SHOULD NEVER HAVE EXPIRATION DATES AS IT REMAINS A SAFETY ISSUE UNTIL ITS PROPERLY REMEDIED. *TR
Structure, Jan 16, 2020
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS AT THE DEALER BEING SERVICED AT A DEALER (CUMBERLAND TOYOTA 1540 INTERSTATE DR, COOKEVILLE, TN 38501 (931) 272-3719) WHERE IT WAS DISCOVERED THAT THE FRAME WAS DISCOVERED TO BE RUSTED OUT. THE DEALER STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE AND ADVISED THAT THE MANUFACTURER DID NOT OFFER ANY ASSISTANCE. THE MANUFACTURER HAD EXTENDED THE WARRANTY BUT IT HAD EXPIRED BY 2018. THE FAILURE MILEAGE WAS 100,000.
Other or unspecified, Nov 21, 2019
WE BOUGHT A TOYOTA TACOMA OFF A USED CAR LOT UNAWARE OF THE PREVIOUS RECALL ON THE TRUCK. WE ARE NOW STUCK WITH A UNDRIVEABLE VEHICAL THAT IS RUSTED THROUGH TO THE FRAME. IT IS IN ARE YARD. WE STILL OWE 10.000 FOR IT AND BEING FORCED TO PAY INSURANCE FOR A VEHICAL IM NOT EVEN ABLE TO USE.
Steering, Suspension, Structure, Oct 25, 2019, crash
WAS DRIVING DOWN THE ROAD AND THE FRAME BROKE COMPLETELY IN HALF ON THE DRIVERS SIDE AN CAUSED THE DRIVE SHAFT TO FALL OUT AND WHEN IT DID IT BOUNCED UP AND KNOCKED A HOLE IN THE GAS TANK CAUSING ME TO WRECK.AND THE BED OF THE TRUCK HAS HUGE HOLES RUSTED THROUGH THEM.
Structure, Sep 17, 2019
ON SEPTEMBER 14 2019, I TOOK MY TRUCK (2003 TOYOTA TACOMA) TO JERRY TOYOTA DEALER FOR A SERVICE. THEY FOUND A CRACK ON THE FRAME OF THE TRUCK AND THEY TOLD ME IT IS UNSAFE TO DRIVE THE TRUCK, BUT THEY DIDN'T OFFER ANY REPAIR. I CALLED TOYOTA AND THEY TOLD ME THAT THE RECALLED FOR THE FRAME WAS EXPIRED ON 2018.
Air bags, Sep 6, 2019
AT APPROXIMATELY 128K MILES, THE AIR BAG LIGHT ILLUMINATED AND WILL NOT GO OUT. THE PROBLEM WAS FIRST NOTICED WHILE DRIVING, BUT NOTHING HAPPENED TO THE VEHICLE THAT WOULD HAVE BEEN AN OBVIOUS CAUSE. ADDITIONALLY, THE VEHICLE HAS BEEN CONTINUALLY GARAGED SINCE I PURCHASED IT NEW IN 2003.
Steering, Suspension, Structure, Aug 31, 2019, crash
POWER STEERING PUMP HAVING ISSUES I CAN FILL IT UP TO THE FULL LINE AND IT WILL GO DOWN TO HALF EMPTY EVERYTIME I'VE DONE IT THEREFORE STEERING IS VERY TIGHT AND DIFFICULT, THE TRUCK BED HAS HUGE HOLES RUSTED/CORROSION COMPLETELY THROUGH IT ON BOTH SIDES, THE SPARE TIRE MECHANISM IS RUSTED SO BADLY IT DOESN'T WORK AND HALF OF IT IS MISSING DUE TO RUST/CORROSION AN HAS FALLEN OFF, AND THE FRAME BROKE COMPLETELY IN HALF ON THE DRIVER SIDE OF THE TRUCK WHILE I WAS DRIVING IT AN CAUSED THE DRIVE SHAFT TO HANG ON THE GROUND AND IT KNOCKED A HOLE IN THE GAS TANK BEFORE I COULD GET THE TRUCK STOPPED, ALSO THE SUSPENSION ON THE REAR OF THE TRUCK IS NOT ATTACHED TO THE FRAME ON THE TOP UNDER THE BED JUST ATTACHED TO THE FRAME ON THE BOTTOM.
Structure, Aug 6, 2019
COMPLETE RUST WITH THE UNDERCARRIAGE. THERE WAS A VOLUNITARY RECALL BY TOYOTA BUT I NEVER RECEIVED THIS RECALL NOTICE. THIS CAN BE VERY DANGEROUS BECAUSE THE VEHICLE CAN BREAK IF HALF. THIS IS ALSO WHY THERE IS A RECALL ON THE SPARE TIE HOLDER. BUT CAN NOT GET THE SPARE TIRE HOLDER FIXED WHAT TO THEY FIX IT TO A RUSTED UNDERCARRIAGE. I HAVE CALLED AND COMPLAINTED IN THE PAST.
Suspension, Other or unspecified, Jul 23, 2019
BROUGHT TRUCK INTO BODY SHOP IN JUNE 2019 TO HAVE WORK DONE. THEY TOLD ME THE FRAME ON THE TRUCK WAS SEVERELY RUSTED IN SEVERAL PLACES. THEY SAID IT MAY BE UNSAFE TO DRIVE. IN 2016 (ABOUT 2.5 YRS AGO) I BROUGHT THE TRUCK INTO THE LOCAL TOYOTA DEALER TO HAVE FRAME INSPECTED UNDER A RECALL NOTICE. AT THAT TIME THEY TOLD ME THAT THE FRAME WAS OK. IN ADDITION THE TRUCK WAS AT THE DEALER IN 2018 FOR ANOTHER RECALL FOR LEAF SPRINGS. AT THIS TIME THEY REPLACED LEAF SPRINGS BUT DID NOT REPORT ANY PROBLEMS WITH FRAME RUST. THE ORIGINAL BODY SHOP AND MY LOCAL CAR REPAIR SHOP TOLD ME THAT THE SEVERITY OF THE RUST DAMAGE ON THE TRUCK INDICATED THAT THIS HAS BEEN GOING ON A LONG TIME AND WERE SURPRISED THAT IT HAD PASSED TOYOTA DEALER FRAME INSPECTION. I CALLED TOYOTA NATIONAL LINE AND THEY TOLD ME THAT FOR FRAME REPLACEMENTS FOR MY TRUCK THE PROGRAM ENDED IN JANUARY 31 2019. SUBSEQUENTLY I TRIED TO WORK WITH THE LOCAL DEALER AND THEY HAVE ALSO TOLD ME THAT NATIONAL TOYOTA WILL NOT HELP. CLEARLY THE SEVERITY OF THE PROBLEM (SEE ATTACHED PHOTOS) INDICATES THAT THE RUST DAMAGE WAS HAPPENING OVER A LONG PERIOD OF TIME AND TOYOTA WAS NEGLIGENT IN REPORTING THIS TO ME. TOYOTA SHOULD TAKE RESPONSIBILITY FOR REPAIRING/REPLACING THE FRAME SINCE CLEARLY THE PROBLEM HAS EXISTED LONG BEFORE THE JANUARY 31 2019 DATE AND I HAVE FOLLOWED UP ON ALL THE RECALL NOTICES FOR THIS TRUCK.
Suspension, Structure, Jul 3, 2019
BOUGHT THE TRUCK USED, FRAME RUSTED, FROM COLD WEATHER STATE, HEARD LOTS OF TRUCKS DID THIS, RUST SO BAD AFRAID TO DRIVE IT,EVERYTHING ELSE ON TRUCK GOOD, FROM WHAT I UNDERSTAND IT'S HAD 5 RECALLS, NOT ONE DONE BY FORMER OWNER, INTERNET WEB SITE SAID FRAMES WERE NOT COATED RIGHT, FACTORY DEFECT, WANT TOYOTA TO FIX ISSUE AS IT'S THEIR FAULT THIS HAS HAPPENED, IT'S DANGEROUS TO DRIVE.
Structure, Jul 2, 2019
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 35 MPH, A NOISE EMERGED FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE REAR FRAME WAS SEVERELY RUSTED ON BOTH SIDES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 46,733.