2003 Toyota Tacoma
Problems, recalls and owner-reported issues
Structure is the leading concern among 371 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Tacoma model years with reports.
Of the 2003 reports, 31 involved a crash and 1 involved a fire. 22 people were injured.
What owners report most often
Recalls and investigations
Tires, temporary/emergency spare tireNov 23, 2012
Toyota is recalling certain model year 2001 through 2004 Tacoma light trucks manufactured from August 28, 2000, through August 27, 2004, and originally sold, or currently registered, in the following cold climate states with high road salt usage: Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. The spare tire in the subject vehicles is located underneath the rear of the vehicle and held by a spare tire carrier. A lift plate on the carrier is used to help raise, lower and retain the tire. During its manufacture, the lift plate may not have been sufficiently coated with anti-corrosion materials. If the plate is insufficiently coated and the vehicle is operated in cold climate regions where road salts are frequently used, road spray can reach the carrier assembly and corrode the lift plate.
Corrosion of the plate could cause it to break, which could result in detachment of the spare tire from the vehicle. Detachment of the spare tire could result in a road hazard which may increase the risk of a vehicle crash.
Toyota will notify owners, dealers will inspect the vehicle and replace the spare tire carrier lift plate as necessary, free of charge. The recall began in February 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Campaign 12V542000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Suspension, front, control arm, lower ball jointMay 17, 2005
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.
THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.
DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 05V225000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsMay 19, 2003
ON CERTAIN PICKUP TRUCKS, DURING SIDE IMPACT NCAP TEST (I.E. LINCAP TEST), A FLANGE AT THE REAR END OF THE DOUBLE CAB BODY DEFORMED AND INTERFERED WITH THE FUEL INLET HOSE THAT CONNECTS THE FUEL FILLER PIPE AND FUEL TANK, RESULTING IN DAMAGE TO THE FUEL INLET HOSE.
THIS DAMAGE COULD RESULT IN FUEL LEAKAGE, WHICH COULD RESULT IN A FIRE IF IN THE PRESENCE OF AN IGNITION SOURCE.
DEALERS WILL INSTALL A FUEL HOSE PROTECTOR ON THE BODY FLANGE. OWNER NOTIFICATION BEGAN JUNE 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Campaign 03V189000 on NHTSA.gov
Representative owner complaints
371 reports, newest first.
Structure, Service brakes, Sep 11, 2014
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT INDICATED THAT WHILE HAVING THE EMISSIONS INSPECTION PERFORMED, THE TECHNICIAN NOTICED THAT THERE WAS EXTENSIVE RUST ON THE UNDERBODY, SHIELDS, WELDING, LOWER FRAME, UPPER FRAME AND THE SUB-FRAME OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHO INDICATED THAT THE PLATE BY THE BRAKES WAS RUSTED. THE TECHNICIAN WELDED THE FRAMES AS AN INTERIM FIX AND SUGGESTED THAT THE MANUFACTURER NEEDED TO REMOVE THE CORRODED FRAMES AND COMPONENTS AND REBUILD THE FRAME OR IT MAY POTENTIALLY FRACTURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFUSED TO PROVIDE ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. IN ADDITION, THE CONTACT INDICATED THAT THE BRAKE PEDAL WAS STUCK AND ADJUSTMENTS HAD TO BE MADE IN ORDER TO RELEASE THE PEDAL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 47,600.
Structure, Aug 12, 2014
WE PURCHASED A USED TACOMA IN MARCH 2014. WE INSPECTED IT VERY CAREFULLY FOR RUST. NONE WAS NOTED. ABOUT 2 WEEKS LATER MY SON WAS CHANGING THE OIL AND NOTICED THAT RUST WAS APPEARING AROUND THE HOLES NEAR THE SWAY BAR. NOW THE HOLES ARE GETTING DANGEROUSLY LARGE. WE PROBABLY WON'T BE ABLE TO SAFELY DRIVE THE TRUCK IN A FEW MONTHS. THE FRAME RUSTS FROM THE INSIDE OUT SO YOU CAN'T SEE THE PROBLEM UNTIL IT'S TOO LATE. WE HAVE TALKED TO TOYOTA AND THEY ARE NOT WILLING TO HELP BECAUSE THEY HAVE NO RECORD OF IT BEING SPRAYED EVEN THOUGH I HAVE EVIDENCE IT WAS AT A TOYOTA DEALER SEVERAL TIMES THAT THEY DON'T HAVE. TOYOTA RECEIVED A SETTLEMENT FROM [XXX] FOR SUPPLYING THE DEFECTIVE FRAMES BUT THEY AREN'T WILLING TO FIX THEIR DEFECTIVE FRAMES. SOME ONE WHO DOESN'T SPEND MUCH TIME UNDERNEATH THEIR TRUCK IS GOING TO HAVE A FRAME BREAK WHILE THEY'RE SPEEDING DOWN THE HIGHWAY AND GET HURT. WE ARE GOING TO BE OUT A LOT OF MONEY BECAUSE OF THIS DEFECTIVE FRAME. PLEASE HOLD TOYOTA ACCOUNTABLE BEFORE SOMEONE GETS HURT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Suspension, Aug 11, 2014
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT THE REAR LEAF SPRING FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 130,000.
Structure, Aug 6, 2014
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING TAKEN TO A DEALER FOR AN OIL CHANGE, THE MECHANIC NOTICED THAT THERE WAS A RUST HOLE THAT HAD RUSTED THROUGH THE FRAME NEAR THE RIGHT REAR PASSENGER'S SIDE. THE DIAGNOSIS WAS THAT THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 118,500. UPDATED 10/22/14*LJ
Structure, Jul 18, 2014
THIS TRUCK IS ONLY 11 YEARS OLD AND THE FRAME IS RUSTED OUT. THERE IS A HOLE ABOUT 12 INCHES LONG IN THE FRAME RAIL, ON THE RIGHT SIDE, WHICH CAUSED MY SHOCK MOUNT TO BREAK IN THE REAR OF THE TRUCK. I CALLED TOYOTA AND THEY WON'T DO ANYTHING ABOUT IT. I TOLD THEM I WOULD NEVER BUY ANOTHER TOYOTA. THIS FRAME SHOULD LAST LONGER THAN 11 YEARS. *TR
Suspension, Structure, Jul 18, 2014
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 05V225000 (SUSPENSION) AND STATED THAT AN INDEPENDENT MECHANIC BEFORE THE NOTIFICATION OF THE RECALL SPRAYED THE UNDERCARRIAGE. THE DEALER INFORMED THE CONTACT THAT THE RECALL REPAIR WOULD NOT BE HONORED DUE TO THE COATING OF THE UNDERCARRIAGE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE ENTIRE FRAME WAS RUSTED AND CORRODED AND MAY FRACTURE. A LIFT PLATE INSPECTION WAS PERFORMED AND IT WAS DIAGNOSED THAT THE FRAME WAS COVERED WITH UNDERCOATING AND THE LIFT PLATE WAS UNABLE TO BE REPAIRED DUE TO THE RUST. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,880.
Structure, Jul 9, 2014
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT UPON INSPECTION, IT WAS DISCOVERED THAT THE FRAME WAS RUSTED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO CONFIRMED THAT THE FRAME HAD RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE AND THE CURRENT MILEAGE WAS 40,000.
Fuel system, Gasoline, Power train, Engine, Jun 18, 2014
CAR STUMBLES/HESITATES INTERMITTENTLY AT VARIOUS SPEEDS. HAVE SPENT TIME/MONEY TROUBLE SHOOTING THE PROBLEM/MAKING REPAIRS WITH NO AFFECT ON PROBLEM. PROBLEM APPEARS TO BE DRIVE BY WIRE THROTTLE BODY TOYOTA PART # 22030-62020 (TOYOTA DATA PER VIN SHOWS THIS PART SHOULD NOT BE ON MY CAR). TOYOTA HAS A PROGRAM TO REPLACE THROTTLE BODY IF FOUND TO BE DEFECTIVE (FOR A LIMITED TIME) EXCEPT PROBLEM CANNOT BE DUPLICATED IN THE SHOP AND IT DOES NOT CAUSE ANY CODES. ON-LINE RESEARCH INDICATED PROBLEM IS WITH THE THROTTLE POSITION SENSOR (TSP) OR THE ACCELERATOR PEDAL POSITION SENSOR (APPS) ON THE THROTTLE BODY FAILING. RESEARCH INDICATES TOYOTA IS AWARE OF THIS PROBLEM AS THEY WILL REPLACE PART FREE IF PROVEN DEFECTIVE AND APPARENTLY HAS REDESIGNED THEIR THROTTLE BODY. ISSUE IS, MOST OF THE TIME THE DEALER CANNOT REPRODUCE THE PROBLEM IN THE SHOP AND SINCE IT DOES NOT CAUSE A CODE THEY WILL NOT HONOR THE WARRANTY PROGRAM BECAUSE THEY WILL NOT BE REIMBURSED WITHOUT PROVING THE PART IS DEFECTIVE. THE PROBLEM WITH THIS THROTTLE BODY HAS BEEN IDENTIFIED IN VEHICLES WITH AS LITTLE AS 30000 MILES TO OVER 250000 MILES PER ON-LINE RESEARCH. WHILE RIDING WITH ME THE DEALER'S TECHNICIAN HAS SEEN AND FELT THE STUMBLE/HESITATION (RPM DROPS ABOUT 150 TO 250 RPM WHEN TRAVELING AT A CONSTANT SPEED FOR NO REASON) BUT HAS NEVER BEEN ABLE TO DUPLICATE IT IN THE SHOP OR IDENTIFY THE CAUSE. THIS STUMBLING/HESITATION OCCURS EVERYTIME THE CAR HAS BEEN DRIVEN FOR LONGER THAN 20-30 MINUTES SINCE THE 1ST OCCURRENCE. TWICE IT HAS STUMBLE WHILE MAKING A LEFT TURN AT AN INTERSECTION CAUSING ME TO ALMOST GET HIT BY AN ON COMING VEHICLE. THIS THROTTLE BODY IS A NON-SERVICEABLE PART AND CANNOT BE REPAIRED, PER THE DEALER IT IS REQUIRED TO BE REPLACED AS A UNIT. THIS PART NEEDS TO BE RECALLED AND TOYOTA REQUIRED TO REPLACE IT AT NO COST NOW INSTEAD OF ONLY WHEN IT FAILS BEFORE SOMEONE IS KILLED. *TR
Structure, May 28, 2014
VEHICLE HAS GONE THROUGH 2 RECALLS, FRAME AND SPARE TIRE HOLDER. BACK BUMPER IS CORRODING. *TR
Structure, May 12, 2014
RUSTED FRAME. WILL NOT PASS INSPECTION AND VERY DANGEROUS TO DRIVE. *TR
Structure, Tires, May 9, 2014
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE SPARE TIRE CARRIER AND SUBFRAME WAS RUSTED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 12V542000 (TIRES:TEMPORARY/EMERGENCY SPARE TIRE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Structure, May 5, 2014
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING INSPECTED BY A PRIVATE MECHANIC, IT WAS FOUND THAT THE FRAME WAS RUSTED. THE VEHICLE WAS TAKEN TO THE DEALER WHO CONFIRMED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 180,000.
Air bags, Apr 30, 2014
MY 2003 MATRIX HAD LESS THAN 40,000 ORIGINAL MILES WHEN THE DASH AIR BAG LIGHT CAME ON. TOYOTA RECALLED THE MATRIX FOR THIS PROBLEM AND WAS CORRECTED IN 2013. MY 2003 TACOMA TRUCK'S CURRENT MILEAGE IS ONLY 29,667 ORIGINAL MILES. AT APPROXIMATELY 28,000 MILES THE DASH AIR BAG LIGHT CAME ON. A FRIEND WHO SPECIALIZES IN TOYOTA REPAIRS CHECKED IT AND SAID IT WAS THE B1100-AIR BAG SENSOR MODULE.. TOYOTA HAS YET TO RECALL THE 2003 TACOMA FOR AN AIR BAG PROBLEM.
Structure, Apr 25, 2014
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE FRAME WAS RUSTED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS CONFIRMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 94,650. THE VIN WAS NOT AVAILABLE.
Structure, Apr 17, 2014
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRAME, SPARE TIRE CARRIER AND OIL PAN SHIELD WERE COMPLETELY CORRODED. THE CONTACT MENTIONED THAT HE WAS WAITING FOR THE PARTS TO BECOME AVAILABLE FOR THE RECALL REPAIR UNDER NHTSA CAMPAIGN NUMBER: 12V542000 (TIRES). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 214,000 AND THE CURRENT MILEAGE WAS 218,000. UPDATED 6/10/14*CN
Tires, Apr 7, 2014
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE WAS EQUIPPED WITH GOODYEAR DUNLOP TIRES, SIZE 215/70/15. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH THE TIRE PRESSURE WARNING INDICATOR ILLUMINATED AND A LOUD NOISE EMITTED OUTSIDE OF THE VEHICLE. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE CONTACT NOTICED THAT THE REAR PASSENGER'S SIDE TIRE EXPLODED. THE SPARE TIRE WAS MOUNTED TEMPORARILY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE SPARE TIRE WAS REPLACED WITH A NEW TIRE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 2,400. THE VIN AND DOT NUMBERS WERE UNAVAILABLE.
Fuel/propulsion system, Apr 7, 2014
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED AFTER REFUELING THE VEHICLE, FUEL WOULD LEAK ONTO THE GROUND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC THREE TIMES WHERE THE FUEL CAP WAS REPLACED EACH TIME. THE FAILURE PERSISTED AND THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
Structure, Mar 19, 2014
TOYOTA HAS BLATANTLY STATED THEY PUT FAULTY FRAMES ON THEIR 2003 TACOMAS AND AS A RESULT OF THIS, THE FRAMES WOULD RUST BECAUSE OF COATING NOT BEING PUT ON PROPERLY. TOYOTA EVEN WON A LAWSUIT FROM THE COMPANY WHO MADE THE FRAMES. NOW, TOYOTA DOES NOT WANT TO MAKE GOOD ON THE RUSTED FRAMES ON THESE TACOMAS. OUR FRAME MAY NOT PASS INSPECTION DUE TO THE RUST AND IF IN THE EVENT, THIS FRAME CAUSES HARM TO MY FAMILY, A LAWSUIT WILL BE FILED BY ME AGAINST TOYOTA. AFTER MANY CONTACTS VIA EMAIL AND PHONE, TOYOTA STATES THAT WE DID NOT CONTACT THEM IN THE TIME FRAME THEY GAVE REGARDING THE FRAME PROBLEM. WELL, YOU ONLY CONTACT A COMPANY ABOUT SOMETHING WHEN THE PROBLEM IS BROUGHT TO YOUR ATTENTION AND IN OUR CASE, WAS TOO LATE. THERE SHOULD NOT HAVE BEEN A TIME FRAME PUT ON THIS AND THERE SHOULD HAVE BEEN A RECALL DONE ON ALL THESE FRAMES. WHEN A PERSON DIES FROM THESE RUSTED FRAMES BREAKING IN HALF WHILE DRIVING, THEN MAYBE SOMEONE WILL DO SOMETHING. *TR
Structure, Mar 18, 2014
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS ADVISED THAT THE UNDER CARRIAGE WAS EXTREMELY RUSTED. THE MECHANIC STATED THAT THE ENTIRE FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 180,000.
Steering, Suspension, Mar 13, 2014
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT THE AXLE, POWER STEERING LINES AND OIL PAN WAS SEVERELY RUSTED. THE CORROSION WAS SO SEVERE THAT IT CAUSED A FRACTURE ON THE POWER STEERING LINE. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO BE REPAIRED. THE DEALER REPLACED THE FRAME AND ADVISED THE CONTACT THAT THE FAILURE WAS CAUSED BY ENVIRONMENTAL FACTORS. THE VEHICLE WAS REPAIRED. THE MANUFACTURE WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. THE CURRENT MILEAGE WAS 118,000.
Suspension, Structure, Feb 26, 2014
FRAME RUSTED/ CRACKED WOULD NOT PASS STATE INSPECTION. TRUCK WAS TAKEN TO TOYOTA DURING THE FIRST RECALL AND I WAS TOLD IT PASSED. DID NOT GO BACK FOR SUBSEQUENT RECALLS TO HAVE THE FRAME SPRAYED. CALLED TOYOTA WHEN THE TRUCK FAILED INSPECTION AND WAS TOLD THAT BECAUSE I DIDN'T HAVE THE FRAME SPRAYED THERE WAS NOTHING THEY WOULD DO FOR ME. THE EXHAUST SYSTEM OUTLASTED THE FRAME. THIS IS NOT ACCEPTABLE. *TR
Structure, Feb 15, 2014
I NOTICED THE REAR SKID PLATE IS HANGING ON BY ONLY ONE SIDE ABOUT TO FALL OFF DUE TO RUST ON HARDWARE/PLATE WHEN DRIVING IN THE HIGHWAY PLATE WOBBLES UP AND DOWN. IT SEEMS LIKE IT WILL FALL WHILE DRIVING AND CAUSE A POSSIBLE ACCIDENT, OR INJURY. *TR
Seat belts, Feb 12, 2014
SEAT BELTS WON'T RETRACT. *TR
Seat belts, Feb 12, 2014
SEAT BELTS WON'T RETRACT. *TR
Suspension, Dec 19, 2013
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE TURNING AT 10 MPH, THE CONTACT LOST CONTROL OF THE STEERING WHEEL AS THE FRONT DRIVER'S SIDE DROPPED TO THE GROUND. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHERE THE FRONT SUSPENSION LOWER BALL JOINT WAS FOUND TO BE SEPARATED, CAUSING THE FRONT SUSPENSION TO FAIL. THE MANUFACTURER ADVISED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 05V225000 (SUSPENSION). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 175,640.