2004 Toyota Tacoma
Problems, recalls and owner-reported issues
Structure is the leading concern among 414 owner complaints filed for this model year. This is the 6th highest complaint count among 26 Tacoma model years with reports.
Of the 2004 reports, 27 involved a crash and 3 involved a fire. 23 people were injured.
What owners report most often
Recalls and investigations
Tires, temporary/emergency spare tireNov 23, 2012
Toyota is recalling certain model year 2001 through 2004 Tacoma light trucks manufactured from August 28, 2000, through August 27, 2004, and originally sold, or currently registered, in the following cold climate states with high road salt usage: Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. The spare tire in the subject vehicles is located underneath the rear of the vehicle and held by a spare tire carrier. A lift plate on the carrier is used to help raise, lower and retain the tire. During its manufacture, the lift plate may not have been sufficiently coated with anti-corrosion materials. If the plate is insufficiently coated and the vehicle is operated in cold climate regions where road salts are frequently used, road spray can reach the carrier assembly and corrode the lift plate.
Corrosion of the plate could cause it to break, which could result in detachment of the spare tire from the vehicle. Detachment of the spare tire could result in a road hazard which may increase the risk of a vehicle crash.
Toyota will notify owners, dealers will inspect the vehicle and replace the spare tire carrier lift plate as necessary, free of charge. The recall began in February 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Campaign 12V542000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Suspension, front, control arm, lower ball jointMay 17, 2005
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.
THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.
DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 05V225000 on NHTSA.gov
Seat belts, frontMay 5, 2004
CERTAIN PICKUP TRUCKS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, 'SEAT BELT ASSEMBLIES.' THE DRIVER'S SIDE SEAT BELT HAS INCORRECT MARKINGS.
THIS DOES NOT MEET THE STANDARD.
DEALERS HAVE REPLACED THE SEAT BELTS. NO VEHICLES WERE SOLD TO CONSUMERS.
Campaign 04V214000 on NHTSA.gov
Representative owner complaints: electrical system
17 reports, newest first. Show all
Fuel system, Gasoline, Electrical system, Structure, Jan 13, 2023
The contact owns a 2004 Toyota Tacoma. The contact stated while driving 20 MPH and making a right turn, the vehicle lost motive power and stalled. There was no warning light illuminated. The contact was able to veer to the side of the road. The vehicle failed to restart after several attempts. The vehicle was towed to the dealer, where it was diagnosed that the Electronic Fuel Injection (EFI) main fuse had blown due to a short circuit. The dealer replaced the Electronic Fuel Injection (EFI) main fuse; however, the failure persisted. Additionally, the dealer diagnosed that the subframe was severely corroded, including transmission components and fuel system components. The manufacturer was notified of the failure and informed the contact that they could not assist as unknown recalls had expired. The vehicle was not repaired. The failure mileage was approximately 150,000.
Electrical system, Structure, Mar 14, 2018
DRIVERS SIDE DOOR HANDLE FELL OFF, WHILE STATIONARY. I GRABBED HANDLE TO OPEN DOOR LIKE NORMAL, AND PART OF IT CRUMBLED IM MY HAND AND THEN FELL TO THE GROUND. IT COULD NOT BE PUT BACK ON DUE TO EXCESSIVE CORROSION. THIS IS A HUGE SAFTY RISK OF SOMEONE GETTING TRAPPED IN THE VEHICLE IF SOMETHING HAPPENED AND THE HANDLE FELL OFF AT THE MOST IMPORTUNED TIME, IT COULD EASILY CAUSE FATALITIES. WHILE SEARCHING FOR A REPLACEMET PART I MET SEVERAL OTHERS WITH THIS SAME PROBLEM. THE FACT THAT TOYOTA IS CHARGING AND EXUBERANT ABOUT FOR THE HANDLE ASSEMBLY'S ($4251
Electrical system, Feb 25, 2016
THE VEHICLE WAS IN MOTION AT HIGHWAY SPEEDS WHEN THE TRUCK INSTANTLY BEGAN DECELERATING EVEN THOUGH I HAD THE ACCELERATOR DEPRESSED. THIS PROBLEM RESOLVED AFTER TURNING THE TRUCK OFF AND THEN ON AGAIN. THE PROBLEM RECURRED SEVERAL TIMES WHILE STOPPED AND WHILE DRIVING OVER THE COURSE OF THE NEXT MONTH. I WAS NEARLY REAR ENDED AS A RESULT OF THIS FAILURE. UPON READING, AND INSPECTION BY A MECHANIC I WAS NOTIFIED THAT THE THROTTLE SENSOR HAD FAILED, AND THE ENTIRE THROTTLE BODY NEEDED TO BE REPLACED AS A RESULT. UPON RESEARCHING THIS I DID DISCOVER THAT THIS IS THE CASE THE '03-'04 TACOMA (I HAVE AN 04), FOR WHICH A THROTTLE POSITION SENSOR IS NOT AVAILABLE, AT LEAST IN THE U.S. THIS IS A VERY DANGEROUS ISSUE THAT SEVERAL PEOPLE HAVE COMPLAINED ABOUT WITH '03-'04 TACOMA TRUCKS. REPLACING THE ENTIRE THROTTLE ASSEMBLY IS AN OBNOXIOUS AND EXPENSIVE CONSEQUENCE FOR A FAULTY ELECTRONIC PART THAT PUTS VEHICLE OWNERS' LIVES AT RISK. THIS SHOULD HAVE BEEN ADDRESSED BY THE MANUFACTURER!
Electrical system, Oct 9, 2015
2004 TOYOTA TACOMA V6 3.4L 5VZ-FE WITH AUTOMATIC TRANSMISSION. TOYOTA ORIGINALLY EQUIPPED THIS VEHICLE WITH A THROTTLE BY WIRE SYSTEM. THE VEHICLE UNEXPECTEDLY DOES NOT RESPOND TO ACCELERATOR PEDAL POSITION. TOYOTA ON BOARD DIAGNOSTIC SYSTEM DOES NOT DETECT FAULT THUS DOES NOT LOG ANY ERROR CODES OR ILLUMINATE CHECK ENGINE LIGHT. OCCURRENCE RATE AND DURATION OF EVENTS IS INTERMITTENT AND INCONSISTENT. VELOCITY OF THE VEHICLE RAPIDLY DECREASES UNEXPECTEDLY AND MOMENTARILY AS IF FOOT WAS TEMPORARILY REMOVED FROM THE ACCELERATOR PEDAL. VEHICLE ALSO UNEXPECTEDLY AND MOMENTARILY DOES NOT RESPOND WHEN ACCELERATOR PEDAL IS DEPRESSED TO BEGIN MOVING OR SUDDENLY DECREASES SPEED WHEN ACCELERATING. THIS IS A POTENTIAL HAZARD IN SITUATIONS SUCH AS CRUISING IN TRAFFIC, CLEARING AN INTERSECTION, CROSSING RAILROAD TRACKS, ETC... OCCURRENCE RATE AND DURATION OF PROBLEM SEEMS TO BE WORSENING OVER TIME OR WITH INCREASED AMBIENT TEMPERATURES. *TR
Electrical system, Structure, Latches/locks/linkages, Oct 1, 2015
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT THE DRIVER SIDE DOOR'S ELECTRONIC LOCK SYSTEM FAILED. THE DOOR LOCKED ON ITS OWN AND DID NOT UNLOCK WITH THE INTERIOR OR EXTERIOR DOOR HANDLES. THE PASSENGER SIDE DOOR WAS USED TO EXIT THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE A DIAGNOSTIC WAS PERFORMED, WHICH WAS UNABLE TO LOCATE A FAILURE CODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 1/19/16 LN; UPDATED4/16/18*JB *TR
Electrical system, Other or unspecified, Fuel/propulsion system, Jun 5, 2015
FROM A DEAD STOP TO ANY SPEED, IT FELT LIKE I NO ACCERATION. I WOULD HAVE TO FEATHER THE GAS PEDAL TO GET UP TO SPEED. I'VE REPLACED FUEL FILTER, 02 SENDER ( FRONT), MAF SENDER ,FUEL PRESSURE REGULATOR ,CLEANED ALL GROUNDS, HAD FUEL PUMP TESTED , HAD HEAD GASKET CHECKED ,CHANGED SPARK PLUGS AND WIRE'S, CLEANED THROTTLE BODY AND PRESSURE CLEANED FUEL SYSTEM. EVERY TIME I CHANGE A PART OR DO ANY CLEANING , THE TRUCK WILL RUN FINE, FOR AWHILE , BUT THE PROBLEM RETURNS. I NOW HAVE 150K ON TRUCK ,AND I WANT TO GET 150 K MORE. I FELL THIS IS A EXTREMELY HAZARDS SITUATION. ALL I'M LOOKING FOR IS A ANSWER TO WHAT'S WRONG!!!! TOYOTA IS AWARE OF WHAT'S WRONG ,BUT THE DEALERS ONLY TO KEEP REPLACING PARTS ($) . THE TOYOTA FORUM S ON WEB HAVE 1000S OF ANSWER S, BUT, NOTHING DEFINITE. PLEASE HELP!!!!
Electrical system, Vehicle speed control, Engine, Jan 27, 2015
WHILE DRIVING THE VEHICLE LOSES PEDAL RESPONSE DUE TO THE THROTTLE CONTROL MOTOR SHUTTING DOWN AND THE CHECK ENGINE LIGHT COMING ON. THE ENGINE EITHER SHUTS DOWN COMPLETELY OR THE BECOMES VERY JERKY AND CANNOT SUSTAIN AN IDLE. INCIDENTS BEGAN TO OCCUR AROUND 95,000 MILES ODO BUT STOPPED FOR SEVERAL YEARS AFTER A MECHANIC WORKED ON THE VEHICLE AND SAID THE THROTTLE POSITION SENSOR WAS OUT OF ALIGNMENT. MORE RECENTLY THE TRUCK HAS AGAIN BEEN EXPERIENCING THE SAME PROBLEM AS BEFORE: LOSS OF PEDAL RESPONSE, AND IN ADDITION IT NOW SHUTS THE ENGINE DOWN AND THE GAUGES SHOOT UP TO THE TOP OF THE CHARTS AND TICK UNRESPONSIVELY UNTIL THE KEY IS REMOVED FROM THE IGNITION. THIS HAS OCCURRED MULTIPLE TIMES NOW IN TRAFFIC AND ALONG THE ROADWAY WHERE THE TRUCK BECOMES UNRESPONSIVE AND IS DIFFICULT TO DRIVE SAFELY OFF OF THE ROADWAY. *TR
Electrical system, Engine, Jan 5, 2015
I WAS DRIVING AT A NORMAL SPEED ON THE HIGHWAY. THE GAS PEDAL BECAME UNRESPONSIVE. I HAD TO PUSH THE PEDAL ALL THE WAY TO THE FLOOR IN ORDER TO GET UP TO SPEED. THE CHECK ENGINE LIGHT CAME ON AND THE TRANSMISSION HAD TROUBLE SWITCHING BETWEEN GEARS. THIS PROBLEM OCCURRED INTERMITTENTLY AND CONTINUES TO HAPPEN. THE CODE THAT HAS COME UP IS TO REPLACE THE THROTTLE BODY, WHICH I HAVE TWO SEPARATE TIMES, BUT AGAIN THE NEW REPLACEMENT PART IS QUOTED AT $1000. *TR
Power train, Electrical system, Jan 22, 2010
I WAS DRIVING MY TRUCK TO A WORK LOCATION AND STOPPED AT A T-INTERSECTION TO YIELD TO THE NORMAL TRAFFIC FLOW. WHILE STOPPED, THE ENGINE BEGAN TO REV UP FOR NO APPARENT REASON. I WAS NOT TOUCHING THE ACCELERATOR PEDAL, BUT HAD MY FOOT FIRMLY ON THE BRAKE. AT FIRST, I HEARD THE ENGINE NOISE BUT DID NOT REALIZE THAT IT WAS MY VEHICLE MAKING THE NOISE. THEN WHEN I LOOKED DOWN AT MY INSTRUMENTS, I SAW THAT MY ENGINE RPM'S WERE ABOVE 1800 AND STAYING STEADY. THERE WAS AN AUDIBLE CLUNK NOISE AND THE TRUCK SUDDENLY LURCHED FORWARD (TRANSMISSION ENGAGING I WOULD GUESS) AND I PRESSED THE BRAKE WITH INCREASED FORCE TO KEEP FROM ROLLING FORWARD. THEN THE ENGINE RPM'S RETURNED TO A NORMAL IDLE JUST AS SUDDENLY. THIS OCCURRED WITH A WARM ENGINE AFTER SEVERAL MILES OF NORMAL DRIVING. WHILE THE SAME EXACT THING HAS NOT OCCURRED SINCE THIS INCIDENT, I HAVE HAD AT LEAST ONE OTHER EPISODE WHERE THE TRUCK'S ENGINE RPM'S INCREASED FOR NO REASON WHILE I WAS STOPPED AT A RED LIGHT. THE LATTER OCCURRENCE WAS NOT AS SEVERE AS THE FIRST INCIDENT AND HAPPENED WITHIN THE LAST MONTH OR SO. I WANTED TO REPORT THIS BECAUSE MY TRUCK IS A TOYOTA BRAND AND I HAVE READ ABOUT THE RECENT RECALLS RELATED TO ACCELERATOR ISSUES ON SOME OF THE SMALLER TOYOTA PASSENGER CARS, BUT NEVER SAW ANY MENTION OF THIS INVOLVING THEIR TRUCK PRODUCTS. AS AN ENGINEER MYSELF, I STRONGLY SUSPECT THAT THIS PHENOMENON IS DUE TO AN ELECTRICAL AND/OR COMPUTER MALFUNCTION AND NOT SOME SORT OF MECHANICAL OR PHYSICAL INTERFERENCE ISSUE. I SAY THIS BECAUSE OF MY OWN EXPERIENCE WHEN I KNOW FOR A FACT THAT THERE WAS NOTHING INTERFERING WITH THE ACCELERATOR PEDAL AND IT WAS NOT STUCK MECHANICALLY. *TR
Electrical system, Exterior lighting, Apr 20, 2009
EMERGENCY FLASHERS COME ON BY THEMSELVES. UNABLE TO DISENGAGE SWITCH AND TURN SIGNALS WILL NOT WORK. *TR
Electrical system, Feb 18, 2008
WHILE DRIVING VEHICLE, EXPERIENCED A BURNING SMELL COMING FROM BEHIND THE DASHBOARD. THE STEREO, CLOCK, AND AUTO ALARM CEASED WORKING. TOOK THE VEHICLE TO THE DEALERSHIP TO DIAGNOSE THE PROBLEM. THE DEALERSHIP STATED THAT THE DOME FUSE WAS THE WRONG SIZE AND REPLACED IT WITH THE CORRECT SIZE. FIXED THE PROBLEM, BUT NOW THE STEREO NO LONGER WORKS. THE FUSE IN QUESTION WAS FROM THE FACTORY. *TR
Electrical system, Nov 26, 2005
HAVE A 2004, TOYOTA TACOMA, V6, 4X4. I WAS DRIVING DOWN THE FREEWAY AND EVERY NOW AND THEN IT IS LIKE I TOOK MY FOOT OFF THE GAS BUT I DIDN'T! IF I STEP ON IT, IT IS FINE. *JB THE PROBLEM: IS THROTTLE BY WIRE THROTTLE BODIES ON 03 AND 04 TACOMAS. THE ACCELERATOR PETAL POSITION SENSOR ASSEMBLY HAS A SHAFT ONTO WHICH THE LEVER FOR THE ACCELERATOR CABLE IS MOUNTED WITH SOME RETURN SPRINGS. THIS SHAFT ALSO TURNS THE POTENTIOMETER. THIS LEVER (A PLASTIC PIECE) LIMITS THE TRAVEL OF THE ASSEMBLY, SO THE HIGHEST AND LOWEST RESISTANCES OF THE POTENTIOMETER ARE NOT ENCOUNTERED IN THE POTENTIOMETER. THE PROBLEM IS THAT THE POTENTIOMETER CAN ALSO TURN IN THE ASSEMBLY, LOOSING ITS REFERENCE TO THE ARM AND LEVER. THEN THE RANGE OF RESISTANCE THAT IS POSSIBLE CAN BE CHANGED. IF IT TURNS TOO FAR ONE WAY, THE HIGHER RESISTANCE WILL BE SUCH THAT THERE IS NOT SUFFICIENT VOLTAGE SENT TO THE ECU TO INDICATE THAT THE PEDAL HAS BEEN DEPRESSED. CONVERSELY, THERE IS A POINT AT THE OTHER END OF THE PETITIONER WHERE THE FULL VOLTAGE IS APPLIED AND THE ECU SEES THIS AS A FAILURE AND CLOSES THE THROTTLE BY RELEASING THE THROTTLE CONTROL MOTOR'S CLUTCH. NOTHING HAS BEEN TO DONE TO SOLVE THIS ISSUE WITH TOYOTA OR DEALERSHIP. MECHANIC CAN NOT REPLICATED PROBLEM. SUGGESTED I REPLACE BRAND NEW THROTTLE BODY WHICH IS ABOUT $600. *NM
Electrical system, Oct 8, 2005
ALARM AND ELECTRICAL SYSTEM ON 2004 TOYOTA TACOMA DOUBLE CAB PRERUNNER SR5 PICKUP. ALARM SYSTEM ACTIVATED ON ITS OWN AT 5:30 AM SEP 18-05 AND COULD NOT DISENGAGE IT. LOUD ELECTRICAL CLICKING NOISES EMITTED FROM UNDER THE DASHBOARD AROUND THE ASHTRAY THAT COULD BE HEARD FROM OVER 100 FEET AWAY, EVEN THROUGH WALLS INSIDE A HOUSE (CLICKING/POPPING NOISE) LIGHTS FLICKERING INSIDE TRUCK. LEFT TRUCK WITH TOYOTA IN SAVANNAH ALL DAY MONDAY. (THEY HAD TOLD ME WHEN I DROPPED IT OFF THAT THEY WOULD CHECK THE ENTIRE ELECTRICAL SYSTEM FOR SHORTS OR FAULTS.) WHEN I PICKED IT UP I WAS TOLD THAT THERE WAS NOTHING WRONG WITH THE TRUCK, AND NOTHING HAPPENED ALL DAY WHILE IT WAS THERE. WHEN I WENT TO GET INTO THE TRUCK, AND PUSHED THE BUTTON TO DISENGAGE THE ALARM AND UNLOCK THE TRUCK, THE HORN BEEPED 4 TIMES (INSTEAD OF THE NORMAL 2 TIMES) SO I WENT BACK IN AND TOLD THE SERVICE MANAGER. HE REASSURED ME IT WAS NOTHING TO WORRY ABOUT, AND SAID SOMETIMES THESE THINGS HAPPEN, AND IT DOESN'T MATTER WHETHER THE HORN BEEPS TWICE, OR 4 TIMES, THAT AGAIN, THERE WAS NOTHING WRONG WITH THE VEHICLE. I DROVE THE TRUCK BACK HOME TO CHARLESTON,SC AND 30 MINUTES AFTER I PARKED IN THE DRIVEWAY, THE ALARM WENT OFF ON IT'S OWN AGAIN, EVERY 6 MINUTES THE ALARM WENT OFF ON ITS OWN AGAIN SO I NEEDED TO DISCONNECT THE POSITIVE BATTERY CABLE AGAIN, IT WAS MAKING THE LOUD CLICKING ELECTRICAL SHORT NOISES AGAIN. CALLED TOYOTA HQ TO SEE WHAT WOULD BE DONE, AS THIS VEHICLE IS ALSO UNDER A MAJOR RECALL FOR THE LOWER BALL JOINTS AND THEY REFUSED TO REPLACE THEM ON SEVERAL OCCASIONS, EXPLAINED THAT I HAVE TRIED REPEATEDLY AT SEVERAL DIFFERENT TOYOTA DEALERS AND HAVE BEEN TOLD THEIR HANDS ARE TIED UNLESS I HAVE THE RECALL LETTER FROM HQ IN HAND. AFRAID TO DRIVE THIS LEMON AS IT IS OBVIOUSLY UNSAFE WITH THE FRONT LOWER BALL JOINT PROBLEM ESPECIALLY, AND NOW WITH THIS POSSIBLE MAJOR ELECTRICAL FAULT, DON'T WANT THE TRUCK TO CATCH FIRE AND BURN UP.
Electrical system, Aug 29, 2005
THROTTLE BODY RELATED AND RE-OCCURRING PROBLEM. WHERE THE ACCELERATOR POSITION SENSOR MAL-FUNCTIONS CAUSING THE VEHICLE TO STALL. TOYOTA DOES NOT SELL THE SENSOR BUT DOES SELL THE ENTIRE THROTTLE BODY AT A COST OF OVER $700. WARRANTED VEHICLES WITH CALIF. EMISSIONS, GOES FOR 5 YEARS OR 60K MILES. BUT FED EMISSION VEHICLES ONLY HAVE A 3 YEAR 36K MILE WARRANTY ALTHOUGH IT IS THE SAME EXACT PART NUMBER IN QUESTION.*JB
Electrical system, May 18, 2005
WHEN EXITING THE VEHICLE, PASSENGERS ARE SHOCKED WHEN THEY TOUCH THE DOOR TO CLOSE IT. THE SHOCK IS MORE THAN WHAT WOULD BE FELT WHEN TOUCH THE CONTACTS ON AN ELECTRICAL OUTLET. OFTEN LEAVING A SHOCKED FEELING IN THE FINGERS FOR AOME TIME AFTER EXITING THE VEHICLE.
Electrical system, Jan 26, 2005, fire
WHILE DRIVING VEHICLE INADVERTENTLY CAUGHT ON FIRE. THE CAUSE OF THE FIRE WAS UNDETERMINED.*AK
Fuel system, Gasoline, Electrical system, Vehicle speed control, Jan 11, 2005
AFTER RUNNING THE VEHICLE AND SHUTTING IT OFF FOR ABOUT 2 HOURS THE VEHICLE DID NOT WANT TO START, THERE WAS ONLY ABOUT 2,000 MILES ON THE TRUCK. THE STARTER IS CRANKING THE ENGINE, BUT THE ENGINE IS NOT STARTING UP. I TOOK IT TO THE TOYOTA SERVICE DEPARTMENT, AND THEY SAID NOTHING WAS WRONG WITH THE VEHICLE. THE SAME THING HAPPEND SEVERL TIMES AFTER I HAD TAKEN IT TO TOYOTA. THE ONLY WAY TO START THE VEHICLE WOULD BE TO CRANK IT UP FOR ABOUT 5 MINUTES, THEN THE VEHICLE WOULD RUN ROUGH FOR ABOUT A MINUTE. I TOOK IT TO THE TOYOTA SERVICE DEPARTMENT AGAIN AND THIS TIME THEY WORKED ON IT. THEY SAID THEY HAD TO CHANGE THE THROTTLE POSITION SENSOR, THE ENGINE WIRING HARNESS, AND THE FUEL INJECTORS. NO OLD PARTS WERE AVAILABLE. PROBLEM HAS STILL NOT BEEN CORRECTED. VEHICLE NOW HAS ABOUT 6,000 MILES AND EVERY 3-4 DAYS IT STILL DOESN'T WANT TO START UP. *AK