2004 Toyota Tacoma
Problems, recalls and owner-reported issues
Structure is the leading concern among 414 owner complaints filed for this model year. This is the 6th highest complaint count among 26 Tacoma model years with reports.
Of the 2004 reports, 27 involved a crash and 3 involved a fire. 23 people were injured.
What owners report most often
Recalls and investigations
Tires, temporary/emergency spare tireNov 23, 2012
Toyota is recalling certain model year 2001 through 2004 Tacoma light trucks manufactured from August 28, 2000, through August 27, 2004, and originally sold, or currently registered, in the following cold climate states with high road salt usage: Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. The spare tire in the subject vehicles is located underneath the rear of the vehicle and held by a spare tire carrier. A lift plate on the carrier is used to help raise, lower and retain the tire. During its manufacture, the lift plate may not have been sufficiently coated with anti-corrosion materials. If the plate is insufficiently coated and the vehicle is operated in cold climate regions where road salts are frequently used, road spray can reach the carrier assembly and corrode the lift plate.
Corrosion of the plate could cause it to break, which could result in detachment of the spare tire from the vehicle. Detachment of the spare tire could result in a road hazard which may increase the risk of a vehicle crash.
Toyota will notify owners, dealers will inspect the vehicle and replace the spare tire carrier lift plate as necessary, free of charge. The recall began in February 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Campaign 12V542000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Suspension, front, control arm, lower ball jointMay 17, 2005
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.
THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.
DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 05V225000 on NHTSA.gov
Seat belts, frontMay 5, 2004
CERTAIN PICKUP TRUCKS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, 'SEAT BELT ASSEMBLIES.' THE DRIVER'S SIDE SEAT BELT HAS INCORRECT MARKINGS.
THIS DOES NOT MEET THE STANDARD.
DEALERS HAVE REPLACED THE SEAT BELTS. NO VEHICLES WERE SOLD TO CONSUMERS.
Campaign 04V214000 on NHTSA.gov
Representative owner complaints: vehicle speed control
30 reports, newest first. Show all
Fuel system, Gasoline, Vehicle speed control, Jan 1, 2006
2004 TOYOTA TACOMA 4X4 WITH 3.4L ENGINE AND MANUAL TRANS. HAVING THROTTLE BODY ISSUES. THE ACCELERATOR POSITION SENSOR IS FAILING CAUSING THE TRUCK TO STALL FOR A SECOND AND THEN PICK BACK UP. TRUCK DOES NOT THROW A CHECK ENGINE CODE WHEN THIS OCCURS, SO DEALER HAS INFORMED ME ON DIFFERENT OCCASIONS THAT NOTHING IS WRONG. I WAS ALMOST RAN OVER THE OTHER DAY TRYING TO PULL OUT INTO TRAFFIC WHEN THE THROTTLE BODY FAILED. THIS IS A SAFETY CONCERN AND TOYOTA NEEDS TO ADDRESS IT IMMEDIATELY!!!!!!!! WHAT'S IT GOING TO TAKE, SOMEONE GETTING SERIOUSLY INJURED OR A HEALTHY LOW SUIT FOR TOYOTA TO TAKE ACTION? *JB
Vehicle speed control, Jan 1, 2006
I HAVE A 2004 TOYOTA TACOMA 4X4 WITH A 3.4 LITER V6. I HAVE ALREADY FILED 1 COMPLAINT BUTT IN FRUSTRATION WILL TRY THIS AGAIN. THE ELECTRONIC THROTTLE BODIES THAT COME ON 2003 AND 2004 TOYOTA TACOMAS ARE FLAWED AND NEED TO BE INVESTIGATED AND RECALLED DUE TO SAFETY CONCERNS. THE PROBLEM IS THAT THE ACCELERATOR POSITION SENSORS ON THESE THROTTLE BODIES ARE GOING OUT, CAUSING THE ACCELERATOR TO BECOME USELESS UNLESS DEPRESSED GREATER THAN 60%. I HAVE ALL MOST BEEN IN 2 ACCIDENTS WHILE PULLING OUT INTO TRAFFIC AND HAVING THIS OCCUR. WHEN THE SENSOR FAILS THE THROTTLE VALVE CLOSES LEAVING THE PERSON DRIVING THE VEHICLE WITHOUT ENOUGH ACCELERATION TO GET OUT OF THE WAY OF ON COMING TRAFFIC. IN VEHICLES WITH MANUAL TRANSMISSION IT IS ESPECIALLY DANGEROUS WHEN ON AN INCLINE (VERY DIFFICULT NOT TO ROLE BACKWARDS AND HIT SOMETHING BEHIND YOU). ALSO, NO CHECK ENGINE LIGHT HAS CAME ON WHEN THIS HAS OCCURRED. I HAVE READ HUNDREDS OF LETTERS ON THE INTERNET FROM PEOPLE HAVING THE SAME PROBLEM. IS IT GOING TO TAKE SOMEONE GETTING KILLED OR A HEALTHY LAW SUIT TO MAKE TOYOTA TAKE ACTION? *NM
Vehicle speed control, Sep 5, 2005
CRUISE CONTROL MALFUNCTION WHEN DRIVING IN HILLY TERRAIN. CRUISE CONTROL WILL CAUSE THE VEHICLE TO OVER SPEED BY SEVERAL MILES AN HOUR FASTER THAN DESIRED WHILE GOING UPHILL OR DOWNHILL. *JB
Fuel system, Gasoline, Electrical system, Vehicle speed control, Jan 11, 2005
AFTER RUNNING THE VEHICLE AND SHUTTING IT OFF FOR ABOUT 2 HOURS THE VEHICLE DID NOT WANT TO START, THERE WAS ONLY ABOUT 2,000 MILES ON THE TRUCK. THE STARTER IS CRANKING THE ENGINE, BUT THE ENGINE IS NOT STARTING UP. I TOOK IT TO THE TOYOTA SERVICE DEPARTMENT, AND THEY SAID NOTHING WAS WRONG WITH THE VEHICLE. THE SAME THING HAPPEND SEVERL TIMES AFTER I HAD TAKEN IT TO TOYOTA. THE ONLY WAY TO START THE VEHICLE WOULD BE TO CRANK IT UP FOR ABOUT 5 MINUTES, THEN THE VEHICLE WOULD RUN ROUGH FOR ABOUT A MINUTE. I TOOK IT TO THE TOYOTA SERVICE DEPARTMENT AGAIN AND THIS TIME THEY WORKED ON IT. THEY SAID THEY HAD TO CHANGE THE THROTTLE POSITION SENSOR, THE ENGINE WIRING HARNESS, AND THE FUEL INJECTORS. NO OLD PARTS WERE AVAILABLE. PROBLEM HAS STILL NOT BEEN CORRECTED. VEHICLE NOW HAS ABOUT 6,000 MILES AND EVERY 3-4 DAYS IT STILL DOESN'T WANT TO START UP. *AK
Vehicle speed control, Dec 7, 2004
WHILE RELEASING THE ACCELERATOR PEDAL A LOUD GRINDING NOISE WAS PRODUCE FROM THE REAR. DEALER STATED THAT WAS NORMAL BECAUSE IT WAS A NEW PART. *AK