2004 Toyota Tacoma
Problems, recalls and owner-reported issues
Structure is the leading concern among 414 owner complaints filed for this model year. This is the 6th highest complaint count among 26 Tacoma model years with reports.
Of the 2004 reports, 27 involved a crash and 3 involved a fire. 23 people were injured.
What owners report most often
Recalls and investigations
Tires, temporary/emergency spare tireNov 23, 2012
Toyota is recalling certain model year 2001 through 2004 Tacoma light trucks manufactured from August 28, 2000, through August 27, 2004, and originally sold, or currently registered, in the following cold climate states with high road salt usage: Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. The spare tire in the subject vehicles is located underneath the rear of the vehicle and held by a spare tire carrier. A lift plate on the carrier is used to help raise, lower and retain the tire. During its manufacture, the lift plate may not have been sufficiently coated with anti-corrosion materials. If the plate is insufficiently coated and the vehicle is operated in cold climate regions where road salts are frequently used, road spray can reach the carrier assembly and corrode the lift plate.
Corrosion of the plate could cause it to break, which could result in detachment of the spare tire from the vehicle. Detachment of the spare tire could result in a road hazard which may increase the risk of a vehicle crash.
Toyota will notify owners, dealers will inspect the vehicle and replace the spare tire carrier lift plate as necessary, free of charge. The recall began in February 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Campaign 12V542000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Suspension, front, control arm, lower ball jointMay 17, 2005
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.
THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.
DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 05V225000 on NHTSA.gov
Seat belts, frontMay 5, 2004
CERTAIN PICKUP TRUCKS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, 'SEAT BELT ASSEMBLIES.' THE DRIVER'S SIDE SEAT BELT HAS INCORRECT MARKINGS.
THIS DOES NOT MEET THE STANDARD.
DEALERS HAVE REPLACED THE SEAT BELTS. NO VEHICLES WERE SOLD TO CONSUMERS.
Campaign 04V214000 on NHTSA.gov
Representative owner complaints
414 reports, newest first.
Vehicle speed control, Jan 2, 2006
AFTER SHIFTING FROM SECOND GEAR TO THIRD GEAR, THE GAS PEDAL STOPPED WORKING COMPLETELY. SECONDS LATER IT FUNCTIONED NORMALLY, AND AS IF NOTHING HAD HAPPENED. THIS HAS HAPPENED BEFORE, AND I HAVE IDENTIFIED THE PROBLEM AS A FAILURE OF THE THROTTLE BODY MOTOR/SENSOR. I WILL BE ASKING THE TOYOTA DEALERSHIP TO FIX THE PART. *JB
Fuel system, Gasoline, Vehicle speed control, Jan 1, 2006
2004 TOYOTA TACOMA 4X4 WITH 3.4L ENGINE AND MANUAL TRANS. HAVING THROTTLE BODY ISSUES. THE ACCELERATOR POSITION SENSOR IS FAILING CAUSING THE TRUCK TO STALL FOR A SECOND AND THEN PICK BACK UP. TRUCK DOES NOT THROW A CHECK ENGINE CODE WHEN THIS OCCURS, SO DEALER HAS INFORMED ME ON DIFFERENT OCCASIONS THAT NOTHING IS WRONG. I WAS ALMOST RAN OVER THE OTHER DAY TRYING TO PULL OUT INTO TRAFFIC WHEN THE THROTTLE BODY FAILED. THIS IS A SAFETY CONCERN AND TOYOTA NEEDS TO ADDRESS IT IMMEDIATELY!!!!!!!! WHAT'S IT GOING TO TAKE, SOMEONE GETTING SERIOUSLY INJURED OR A HEALTHY LOW SUIT FOR TOYOTA TO TAKE ACTION? *JB
Vehicle speed control, Jan 1, 2006
I HAVE A 2004 TOYOTA TACOMA 4X4 WITH A 3.4 LITER V6. I HAVE ALREADY FILED 1 COMPLAINT BUTT IN FRUSTRATION WILL TRY THIS AGAIN. THE ELECTRONIC THROTTLE BODIES THAT COME ON 2003 AND 2004 TOYOTA TACOMAS ARE FLAWED AND NEED TO BE INVESTIGATED AND RECALLED DUE TO SAFETY CONCERNS. THE PROBLEM IS THAT THE ACCELERATOR POSITION SENSORS ON THESE THROTTLE BODIES ARE GOING OUT, CAUSING THE ACCELERATOR TO BECOME USELESS UNLESS DEPRESSED GREATER THAN 60%. I HAVE ALL MOST BEEN IN 2 ACCIDENTS WHILE PULLING OUT INTO TRAFFIC AND HAVING THIS OCCUR. WHEN THE SENSOR FAILS THE THROTTLE VALVE CLOSES LEAVING THE PERSON DRIVING THE VEHICLE WITHOUT ENOUGH ACCELERATION TO GET OUT OF THE WAY OF ON COMING TRAFFIC. IN VEHICLES WITH MANUAL TRANSMISSION IT IS ESPECIALLY DANGEROUS WHEN ON AN INCLINE (VERY DIFFICULT NOT TO ROLE BACKWARDS AND HIT SOMETHING BEHIND YOU). ALSO, NO CHECK ENGINE LIGHT HAS CAME ON WHEN THIS HAS OCCURRED. I HAVE READ HUNDREDS OF LETTERS ON THE INTERNET FROM PEOPLE HAVING THE SAME PROBLEM. IS IT GOING TO TAKE SOMEONE GETTING KILLED OR A HEALTHY LAW SUIT TO MAKE TOYOTA TAKE ACTION? *NM
Service brakes, Hydraulic, Power train, Dec 21, 2005
#1. 2004 TACOMA DBL CAB TRD: I'M ON MY 3RD SET OF ROTORS AND DRUMS AT JUST 40,000 MILES. EACH SET OF ROTORS WARPED AT JUST OVER 10,000 MILES CAUSING THE EXPECTED PULSING AND BOUNCING. I'M EXPECTING THE 3RD SET TO DO THE SAME. #2. SINCE ABOUT 10,000 MILES, I HAVE EXPERIENCED A "THUMPING" WITH A CORRESPONDING JOLT OF THE GEAR SHIFT UPON FINISHING A BREAKING CYCLE. THIS ALSO HAPPENS OCCASIONALLY WHEN RELEASING THE FOOT BRAKE. SOMETIMES IT IS QUITE LOUD AND VIOLENT. I AM AWARE THAT ALL THE LATE MODEL AUTOMATICS DO THIS. THE FACTORY HAS ACKNOWLEDGED THAT THERE IS A PROBLEM BECAUSE THEIR "FIX" WAS TO DRILL A HOLE IN THE TWO-PIECE DRIVE SHAFT TO "VENT" THE TRAPPED AIR. THIS VERY TEMPORARILY SOLVED THE PROBLEM. AGAIN TODAY, THE DEALER ACKNOWLEDGED THE "THUMP" AND TOLD ME THAT THIS IS "THE WAY THE TRUCK IS SUPPOSED TO OPERATE" AND THAT I SHOULD "CHANGE MY BRAKING HABITS". ON A 15 MINUTE TEST DRIVE IT PROBABLY DOESN'T SEEM TOO BAD. BUT I HAVE TO DRIVE THE VEHICLE ALL THE TIME AND IT IS VERY ANNOYING (AND THIS WAS NOT HAPPENING WHEN I TEST DROVE THE VEHICLE BEFORE I PURCHASED IT). PERHAPS THIS IS NOT A "SAFETY" ISSUE, BUT IT IS INSULTING TO BE TOLD THAT THIS IS "NORMAL". THEY MUST THINK I'M AN IDIOT OR SOMETHING. JUST BECAUSE ALL THE LATE MODEL TACOMAS DO IT, DOES NOT MAKE IT RIGHT! IT'S SO ARROGANT FOR THEM TO EXPECT US TO LIVE WITH THIS DEFECT IN DESIGN. I ALSO BELIEVE THAT THIS SAME PROBLEM IS RELATED TO THE SOMETIMES VIOLENT SHIFTS ESPECIALLY FROM 1ST TO 2ND GEAR. #3. THERE IS ALSO A VIBRATION THAT COMES UP THROUGH THE STEERING WHEEL AT ABOUT 40 MILES PER HOUR. IT IS THE FREQUENCY OF THE DRIVE SHAFT, NOT THE TIRES. I CAN ALWAYS TELL WHEN I'M AT 40 MPH WITHOUT EVEN LOOKING AT THE SPEEDOMETER. *JB
Suspension, Equipment, Dec 16, 2005
I WAS DRIVING ON THE ROAD IN MY 2004 TOYOTA TACOMA WHEN I SAW MY TIRE GO ROLLING AHEAD OF MY VEHICLE, THE TRUCK LEANED OVER TO THE LEFT, SKIDDED SIDEWAYS AND THEN STOPPED IN THE MIDDLE OF THE ROAD. I GOT OUT OF THE TRUCK AND MY TIRE WAS IN THE DITCH AND MY CHASSIS WAS ON THE GROUND ON THE LEFT SIDE. I CALLED A TOW TRUCK AND THEY SAID IT LOOKED LIKE MY BALL JOINTS JUST SEPARATED. I HAD THE VEHICLE TOWED TO MY MECHANIC AND HE SAID THE BALL JOINTS LOOKED LIKE THEY GAVE WAY AND THIS ALLOWED THE WHEEL TO FALL OFF. I HAVE MECHANICAL BREAKDOWN THROUGH MY INSURANCE COMPANY GIEICO AND THEY TOLD ME I WOULD HAVE TO GET A LETTER FROM TOYOTA STATING IF IT WASN'T UNDER WARRANTY FROM OUR LOCAL DEALERSHIP IN TALLAHASSEE, FLORIDA LEGACY AND SPOKE WITH A SERVICE MEMBER (ROBB) HE TOLD MY THAT THERE WASN'T A RECALL ON 2004 TOYOTA TACOMAS AND I WOULD HAVE TO PAY TO HAVE IT TOWED IN TO CHECK AND SEE IF IT WAS STILL UNDER WARRANTY. THIS OCCURRED ON 12/13/05 AND AS OF 12/15/2005 THERE STILL WASN'T A DETERMINATION WHETHER OR NOT IT IS UNDER WARRANTY. MY CONCERN IS AFTER READING ABOUT A RECALL ON THE INTERNET STATING THAT THE BALL JOINT MAY SEPARATE FROM THE KNUCKLE, THAT MY VEHICLE SHOULD BE A PART OF THE RECALL AND THE WHEEL FALLING OFF COULD BE A RESULT FROM A DEFECT. THE DEALERSHIP ISN'T ACCEPT RESPONSIBILITY FOR THE RECALL OR EVEN LOOKING AT THE VEHICLE IN THIS REGARDS. IF THEY DON'T WARRANTY THE BALL JOINTS, THEN MY MECHANIC WILL FIX THE PROBLEM, BUT I WILL KEEP ALL OF THE OLD PARTS IN CASE THEY NEED TO BE EXAMINED. *JB
Power train, Nov 29, 2005
DROVE VEHICLE DOWN A PAVED ROAD IN THE SNOW. TRANSMISSION LINKAGE FROZE UP IN DRIVE WHEN VEHICLE WAS PARKED. HAD TO DRIVE VEHICLE DIRECTLY TO DEALER. DEALER ONLY THAWED OUT THE LINKAGE. NOW EVERYTIME IT SNOWS, LINKAGE FREEZES UP. *NM
Fuel system, Gasoline, Nov 29, 2005
SMALL ROCK WAS HIT ON A DIRT ROAD. IT PUNCTURED THE GAS TAKE. HAD VEHICLE TOWED TO DEALER. GAS TANK WAS REPLACED. *NM
Electrical system, Nov 26, 2005
HAVE A 2004, TOYOTA TACOMA, V6, 4X4. I WAS DRIVING DOWN THE FREEWAY AND EVERY NOW AND THEN IT IS LIKE I TOOK MY FOOT OFF THE GAS BUT I DIDN'T! IF I STEP ON IT, IT IS FINE. *JB THE PROBLEM: IS THROTTLE BY WIRE THROTTLE BODIES ON 03 AND 04 TACOMAS. THE ACCELERATOR PETAL POSITION SENSOR ASSEMBLY HAS A SHAFT ONTO WHICH THE LEVER FOR THE ACCELERATOR CABLE IS MOUNTED WITH SOME RETURN SPRINGS. THIS SHAFT ALSO TURNS THE POTENTIOMETER. THIS LEVER (A PLASTIC PIECE) LIMITS THE TRAVEL OF THE ASSEMBLY, SO THE HIGHEST AND LOWEST RESISTANCES OF THE POTENTIOMETER ARE NOT ENCOUNTERED IN THE POTENTIOMETER. THE PROBLEM IS THAT THE POTENTIOMETER CAN ALSO TURN IN THE ASSEMBLY, LOOSING ITS REFERENCE TO THE ARM AND LEVER. THEN THE RANGE OF RESISTANCE THAT IS POSSIBLE CAN BE CHANGED. IF IT TURNS TOO FAR ONE WAY, THE HIGHER RESISTANCE WILL BE SUCH THAT THERE IS NOT SUFFICIENT VOLTAGE SENT TO THE ECU TO INDICATE THAT THE PEDAL HAS BEEN DEPRESSED. CONVERSELY, THERE IS A POINT AT THE OTHER END OF THE PETITIONER WHERE THE FULL VOLTAGE IS APPLIED AND THE ECU SEES THIS AS A FAILURE AND CLOSES THE THROTTLE BY RELEASING THE THROTTLE CONTROL MOTOR'S CLUTCH. NOTHING HAS BEEN TO DONE TO SOLVE THIS ISSUE WITH TOYOTA OR DEALERSHIP. MECHANIC CAN NOT REPLICATED PROBLEM. SUGGESTED I REPLACE BRAND NEW THROTTLE BODY WHICH IS ABOUT $600. *NM
Fuel system, Gasoline, Nov 10, 2005, fire
DT:THE CONTACT STATED THE FUEL LINE CAUGHT ON FIRE O. WHILE STOPPING AT A RED-LIGHT HE NOTICED THERE WERE FLAMES COMING FROM BETWEEN THE CAB AND BED OF THE PICKUP TRUCK. THE FIRE WAS EXTINGUISHED, AND THE VEHICLE WAS TOWED TO THE DEALERSHIP. THE DEALERSHIP HAD THE VEHICLE FOR NINE WEEKS. THE VEHICLE HAS BEEN REPAIRED, AND IS READY TO BE PICKED UP. THE CAUSE OF THE FIRE WAS FROM THE FUEL LINE AND THE SEAL OF THE FUEL TANK.*AK
Steering, Oct 26, 2005
NOISE AND EXCESS PLAY IN STEERING WHEEL WHEN DRIVING OVER BUMPY SURFACES. FOUND UPPER STEERING SHAFT SLIP JOINT IMPROPERLY MACHINED /CRIMPED RESULTING IN ABNORMAL NOISE AND EXCESS PLAY WHEN DRIVING UNDER CERTAIN CONDITIONS. DEALER REPLACED UPPER STEERING SHAFT WITH AND IDENTICAL PART. THIS PART HAS NOT BEEN REDESIGNED AND WILL FAIL AGAIN. PART IS NOT AVAILABLE AS IT WAS REPLACED UNDER WARRANTY AND THE DEALER KEPT THE OLD PART. HAVE FOUND FROM OTHERS THROUGH THE INTERNET THAT THIS PLAY AND NOISE IS VERY COMMON BUT NO ONE KNEW THE CAUSE UNTIL RECENTLY. *NM
Steering, Oct 25, 2005
1) NORMAL DRIVING, ON ROAD AND OFF OF HIGHWAY ON DIRT ROADS 2) LOOSE STEERING SHAFT, RATTLES ON ROUGH ROADS OR WHEN HITTING OBSTACLES IN ROAD. 3) DEALER CLAIMS SUSPENSION MODIFICATIONS HAVE VOIDED MY WARRANTY ON STEERING COMPONENTS. DEALER REFUSES TO DO WARRANTY WORK ON VEHICLE FOR NON RELATED COMPONENTS.
Service brakes, Hydraulic, Power train, Tires, Oct 11, 2005
PURCHASED NEW 2004 TOYOTA TACOMA ON 1/24/05. AT 1,577.8 MILES, RIGHT REAR BRAKE DRUM AND WHEEL COVERED WITH GEAR OIL. REPAIRED AT TOYOTA OF GREENFIELD, MA. 01302, PHONE 413-772-0231 2/17/05. BEGAN LEAKING AGAIN ON 2/21/05, AT 1844.6 MILES. RETURNED TO GREENFIELD ON 2/28/05 AT 2284 MILES. CONTACTED DEALER AGAIN ON 4/8/05 AT 67345.9 MILES BRAKE DRUM AND TIRE STILL COVERED WITH OIL. DEALER SAID KEEP DRIVING IT AND THE LEAK WILL GO AWAY. CONTACTED TOYOTA CONSUMER SERVICE ON 4/14/05 CASE #[XXX]. RECEIVED NO FOLLOW UP CORRESPONDENCE FORM FABIOLA. VEHICLE CONTINUED TO LEAK GEAR OIL AND HANDLE POORLY WHEN BRAKING. CONTACTED NEW DEALER(TOYOTA OF COLCHESTER, CT.) ON 5/27/05. VEHICLE REPAIRED ON 6/2/05 AT 8,188 MILES. CONTACTED DEALER AGAIN ON 6/29/05 AT 9085.1 MILES. VEHICLES WAS PICKED UP ON 7/11/05. TRIES ROTATED ON VEHICLE ON 9/26/05 AT 17,266.4 MILES. FOUND OIL ON BRAKE SHOES AND INSIDE OF BRAKE DRUM SEVERELY GLAZED. NEW CASE FILED ON 7/28/05 CASE # [XXX] WITH SALVADORE. I AM STILL DRIVING A VEHICLE WITH THE INTEGRITY OF THE BRAKING SYSTEM IS COMPROMISED. AND HAVE NOT RECEIVED A REASONABLE RESOLUTION TO THIS PROBLEM FROM TOYOTA MOTOR COMPANY. IS IT A COMMON PRACTICE FOR AN AUTO MAKER TO LET A CONSUMER KNOWINGLY DRIVE AN UNSAFE VEHICLE. UNFORTUNATELY I AM STILL PAYING ON A BRAND NEW VEHICLE THAT I DO NOT FEEL SAFE DRIVING. THE REGIONAL FIELD SERVICE TECHNICIAN, JOE LACEFIELD FROM TOYOTA MOTOR COMPANY HAS BEEN UNAVAILABLE BY PHONE FOR THE LAST WEEK 1-973-464-0938. I WOULD LIKE MY MONEY RETURNED FOR THIS VEHICLE IN FULL. I FEEL THAT I HAVE BEEN MORE THAN PATIENT IN TRYING TO RESOLVE THIS MATTER WITH TOYOTA MOTOR COMPANY. V.I.N. # [XXX]. *JB UPDATED 07/18/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Oct 8, 2005
ALARM AND ELECTRICAL SYSTEM ON 2004 TOYOTA TACOMA DOUBLE CAB PRERUNNER SR5 PICKUP. ALARM SYSTEM ACTIVATED ON ITS OWN AT 5:30 AM SEP 18-05 AND COULD NOT DISENGAGE IT. LOUD ELECTRICAL CLICKING NOISES EMITTED FROM UNDER THE DASHBOARD AROUND THE ASHTRAY THAT COULD BE HEARD FROM OVER 100 FEET AWAY, EVEN THROUGH WALLS INSIDE A HOUSE (CLICKING/POPPING NOISE) LIGHTS FLICKERING INSIDE TRUCK. LEFT TRUCK WITH TOYOTA IN SAVANNAH ALL DAY MONDAY. (THEY HAD TOLD ME WHEN I DROPPED IT OFF THAT THEY WOULD CHECK THE ENTIRE ELECTRICAL SYSTEM FOR SHORTS OR FAULTS.) WHEN I PICKED IT UP I WAS TOLD THAT THERE WAS NOTHING WRONG WITH THE TRUCK, AND NOTHING HAPPENED ALL DAY WHILE IT WAS THERE. WHEN I WENT TO GET INTO THE TRUCK, AND PUSHED THE BUTTON TO DISENGAGE THE ALARM AND UNLOCK THE TRUCK, THE HORN BEEPED 4 TIMES (INSTEAD OF THE NORMAL 2 TIMES) SO I WENT BACK IN AND TOLD THE SERVICE MANAGER. HE REASSURED ME IT WAS NOTHING TO WORRY ABOUT, AND SAID SOMETIMES THESE THINGS HAPPEN, AND IT DOESN'T MATTER WHETHER THE HORN BEEPS TWICE, OR 4 TIMES, THAT AGAIN, THERE WAS NOTHING WRONG WITH THE VEHICLE. I DROVE THE TRUCK BACK HOME TO CHARLESTON,SC AND 30 MINUTES AFTER I PARKED IN THE DRIVEWAY, THE ALARM WENT OFF ON IT'S OWN AGAIN, EVERY 6 MINUTES THE ALARM WENT OFF ON ITS OWN AGAIN SO I NEEDED TO DISCONNECT THE POSITIVE BATTERY CABLE AGAIN, IT WAS MAKING THE LOUD CLICKING ELECTRICAL SHORT NOISES AGAIN. CALLED TOYOTA HQ TO SEE WHAT WOULD BE DONE, AS THIS VEHICLE IS ALSO UNDER A MAJOR RECALL FOR THE LOWER BALL JOINTS AND THEY REFUSED TO REPLACE THEM ON SEVERAL OCCASIONS, EXPLAINED THAT I HAVE TRIED REPEATEDLY AT SEVERAL DIFFERENT TOYOTA DEALERS AND HAVE BEEN TOLD THEIR HANDS ARE TIED UNLESS I HAVE THE RECALL LETTER FROM HQ IN HAND. AFRAID TO DRIVE THIS LEMON AS IT IS OBVIOUSLY UNSAFE WITH THE FRONT LOWER BALL JOINT PROBLEM ESPECIALLY, AND NOW WITH THIS POSSIBLE MAJOR ELECTRICAL FAULT, DON'T WANT THE TRUCK TO CATCH FIRE AND BURN UP.
Vehicle speed control, Sep 5, 2005
CRUISE CONTROL MALFUNCTION WHEN DRIVING IN HILLY TERRAIN. CRUISE CONTROL WILL CAUSE THE VEHICLE TO OVER SPEED BY SEVERAL MILES AN HOUR FASTER THAN DESIRED WHILE GOING UPHILL OR DOWNHILL. *JB
Structure, Aug 30, 2005, crash
STATE FARM MUTUAL AUTOMOBILE CLAIM #06-5795-637 REGARDING A REAR END COLLISION TO A TRUCK IN WHICH THE FRAME WAS BENT.*MR THE REPAIRMAN INFORMED THE CONSUMER THERE WAS NO NEED TO REPAIR THE FRAME DAMAGE BECAUSE IT WAS WITHIN THE MANUFACTURER'S SPECIFICATIONS WHICH WAS LESS THAN 5 MILLIMETERS. *JB
Electrical system, Aug 29, 2005
THROTTLE BODY RELATED AND RE-OCCURRING PROBLEM. WHERE THE ACCELERATOR POSITION SENSOR MAL-FUNCTIONS CAUSING THE VEHICLE TO STALL. TOYOTA DOES NOT SELL THE SENSOR BUT DOES SELL THE ENTIRE THROTTLE BODY AT A COST OF OVER $700. WARRANTED VEHICLES WITH CALIF. EMISSIONS, GOES FOR 5 YEARS OR 60K MILES. BUT FED EMISSION VEHICLES ONLY HAVE A 3 YEAR 36K MILE WARRANTY ALTHOUGH IT IS THE SAME EXACT PART NUMBER IN QUESTION.*JB
Suspension, Aug 9, 2005
DT: THE CONTACT OWNS A 2004 TOYOTA TACOMA. HAD TRUCK LIFTED ON 6-7-04 FOR $3700 , AND ON 6-24-04 GOT THE TRUCK RETORQUED WHICH TIGHTENED AND ALIGNED IT. AROUND FEBRUARY 2005 HEARD A CLANKING NOISE FROM THE BRAKE SYSTEM, AND THE STEERING WHEEL SHOOK. WHILE PRESSING ON THE BRAKES AND THE TRUCK SHOOK AND IT TURNED TO THE RIGHT, SUSPENSION WAS LOOSE. ON 3-7-05 TOOK IT TO A TOYOTA DEALER TO INSPECT VEHICLE AND FIX IT. CONSUMER REFUSED TO DEAL WITH THE OTHER COMPANIES BECAUSE THEY WERE RUDE AND INTIMIDATING. VEHICLE WAS NOT UNDER A WARRANTY BECAUSE ANOTHER COMPANY TIGHTENED THE BOLTS AND CHARGED CONSUMER $80. THE TOYOTA DEALER REPLACED REAR:AXLE:SPINDLE. *AK
Seats, Aug 4, 2005
DT: THE CONTACT OWNED A 2004 TOYOTA TACOMA. WITH A REAR FACING INFANT SEAT LOCATED ON THE PASSENGER SIDE OF THE VEHICLE IN THE CAB THE FRONT PASSENGER SEAT WILL NOT LOCK BECAUSE THE CHILD SEAT WAS PUSHING IT FORWARD. THE CHILD SEAT INSTALLATION STATION STATED THEY WERE NOT HAPPY WITH THE WAY THE FRONT SEAT WOULD NOT LOCK. THE CHILD SEAT COULD NOT GO BEHIND THE DRIVERS SEAT BECAUSE THERE WAS NOT ENOUGH ROOM. *AK
Suspension, Service brakes, Air, Power train, Structure, Jul 27, 2005
MY 2004 TOYOTA TACOMA DOUBLE CAB PRERUNNER V6 SR5 HAS 18,000MILES AND HAS HAD THE FOLLOWING PROBLEM FOR A WHILE. I DID NOT NOTICE IT UNTIL ABOUT 2 MONTHS AFTER I HAD PURCHASED THE VEHICLE. WHICH TELLS ME THAT THE PROBLEM COULD BE A PROGRESSIVE ISSUE. THE TRUCK CONTINUES TO SHOW AN INCREASE IN THE PROBLEM. PROBLEM DESCRIPTION: WHEN DRIVING THE TACOMA DOWN THE ROAD THE TACOMA DRIVES FINE. BUT WHEN APPROACHING AN INTERSECTION WHERE THE VEHICLE IS BROUGHT TO A COMPLETE STOP IS WHEN THE FOLLOWING OCCURS. THE VEHICLE WILL SHIFT TO THE REAR AND A JERK SOUND IS HEARD AND FELT. WHEN RELEASING THE BRAKE ON THE VEHICLE YOU WILL FEEL AND HEAR ANOTHER MORE INTENSE JERK. WHEN YOU PRESS ON THE THROTTLE PEDAL TO MOVE FORWARD FROM AN INTERSECTION THE VEHICLE DISPLAYS YET ANOTHER JERK. ALL OF THESE FEELS AS IF IT IS COMING FROM THE REAR. I TOOK THE TRUCK TO THE DEALERSHIP FOR IT'S REGULAR MAINTENCE AND QUESTIONED THE SERVICE ADVISOR ABOUT THIS ISSUE. I WAS TOLD IN A VERY "I DON'T HAVE TIME FOR YOU MANNER" IT'S A TACOMA IT WILL ALWAYS DO THAT. I CAN'T NOR WILL I ACCEPT THAT ANSWER.
Power train, Jul 10, 2005
WHEN COMING TO A STOP, AFTER RELEASING THE BRAKE TO MOVE FOWARD THERE IS A JOLT, (SOMETIMES SO SEVERE YOU WOULD THINK YOU WHERE HIT FROM BEHIND) OTHER TIMES IT IS MINOR. IT HAS OCCURRED SINCE WHEN I PURCHASED MY VEHICLE ABOUT A YEAR AGO. HAVE BEEN TOLD THAT IT IS A COMMON ISSUE WITH THE DOUBLE CAB, WITH A TWO PART DRIVE SHAFT.
Air bags, May 19, 2005, crash
2004 TOYOTA TACOMA SLID ON ICE AND HIT A TREE RESULTING IN THE VEHICLE FLIPPING AND INJURING THE THREE PASSENGERS AND THE AIR BAGS DID NOT INFLATE.***NO ANSWER REQUIRED***.*MR *BF *NM
Electrical system, May 18, 2005
WHEN EXITING THE VEHICLE, PASSENGERS ARE SHOCKED WHEN THEY TOUCH THE DOOR TO CLOSE IT. THE SHOCK IS MORE THAN WHAT WOULD BE FELT WHEN TOUCH THE CONTACTS ON AN ELECTRICAL OUTLET. OFTEN LEAVING A SHOCKED FEELING IN THE FINGERS FOR AOME TIME AFTER EXITING THE VEHICLE.
Engine and engine cooling, Mar 23, 2005
HARD START WITH 2004 TOYOTA TACOMA. THIS PROBLEM BEGAN THE DAY I DROVE IT OFF THE LOT. SOMETIMES THE VEHICLE STARTS RIGHT UP AND OTHER TIMES IT TAKES 3-5 ATTEMPTS AT STARTING. THIS NONCONFORMITY USUALLY HAPPENS AFTER ITS BEEN DRIVEN AND SITS FOR 1-2 HOURS. THE VEHICLE HAS BEEN BROUGHT IN FOR THIS INTERMITTENT STARTING PROBLEM 5 TIMES. WITH 870 MILES ON THE VEHICLE I BROUGHT IT IN AND TOYOTA SAID THE SPARK PLUGS WERE FOULED AND CHANGED THEM. THE PROBLEM CONTINUED TO OCCUR 2-3 TIMES PER WEEK. WITH 1500 MILES WE BROUGHT IT IN AGAIN AND TOYOTA SAID THE PROBLEM WAS THE ELECTRO MAGNETIC CURRENT INTERFERING WITH THE INJECTOR CIRCUIT. THEY REMOVED THE GROUND WIRE CABLE OUT OF THE WIRE HARNESS AND SAID THE ENGINE STARTED JUST FINE. THE PROBLEM CONTINUED TO OCCUR. THE THIRD TIME I BROUGHT IT IN WITH 9087 MILES. THEY PERFORMED A TSB EG042-04 FPN-8122-04052, 0P EG4016. THE PROBLEM CONTINUED TO OCCUR. THE FOURTH TIME I BROUGHT IT IN WITH 9901 MILES THE TECHNICIAN COULD NOT DUPLICATE THE PROBLEM AND SAID EVERYTHING WAS IN SPECIFICATIONS. THE PROBLEM CONTINUED TO OCCUR. THE FIFTH TIME I BROUGHT IT IN IT HAD 11.700 MILES. TOYOTA REPLACED THE UBE SUB-ASSMBLY E. THE ENGINE STILL HAS PROBLEMS STARTING.*AK
Air bags, Feb 18, 2005, crash
CONSUMER'S VEHICLE WAS INVOLVED IN A FRONTAL COLLISION AT 40-45 MPH, CONSUMER VEHICLE WAS HIT ON THE FRONT RIGHT SIDE NEAR THE TIRE AREA. UPON IMPACT, FRONTAL AIR BAGS FAILED TO DEPLOY. DRIVER WAS RESTRAINED WITH THE SEAT BELT, AND NO INJURY WAS REPORTED. DEALER WAS NOTIFIED.*AK THE VEHICLE WAS HIT SO HARD IN THE FRONT THAT IT WAS TOTALED. *TC
Service brakes, Hydraulic, Feb 16, 2005
WHILE DRIVING AT ANY SPEED, IN INCLEMENT WEATHER THE BRAKES FAILED. THE DRIVER APPLIED THE BRAKE PEDAL AND THE BRAKES FAILED TO STOP COMPLETELY. PLEASE PROVIDE FURTHER DETAILS. THIS INFORMATION WAS PROVIDED BY THE CONSUMERS DAUGHTER. *JB *ER