2004 Toyota Tacoma
Problems, recalls and owner-reported issues
Structure is the leading concern among 414 owner complaints filed for this model year. This is the 6th highest complaint count among 26 Tacoma model years with reports.
Of the 2004 reports, 27 involved a crash and 3 involved a fire. 23 people were injured.
What owners report most often
Recalls and investigations
Tires, temporary/emergency spare tireNov 23, 2012
Toyota is recalling certain model year 2001 through 2004 Tacoma light trucks manufactured from August 28, 2000, through August 27, 2004, and originally sold, or currently registered, in the following cold climate states with high road salt usage: Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. The spare tire in the subject vehicles is located underneath the rear of the vehicle and held by a spare tire carrier. A lift plate on the carrier is used to help raise, lower and retain the tire. During its manufacture, the lift plate may not have been sufficiently coated with anti-corrosion materials. If the plate is insufficiently coated and the vehicle is operated in cold climate regions where road salts are frequently used, road spray can reach the carrier assembly and corrode the lift plate.
Corrosion of the plate could cause it to break, which could result in detachment of the spare tire from the vehicle. Detachment of the spare tire could result in a road hazard which may increase the risk of a vehicle crash.
Toyota will notify owners, dealers will inspect the vehicle and replace the spare tire carrier lift plate as necessary, free of charge. The recall began in February 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Campaign 12V542000 on NHTSA.gov
Exterior lightingJul 17, 2006
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Campaign 06E065000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Suspension, front, control arm, lower ball jointMay 17, 2005
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.
THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.
DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 05V225000 on NHTSA.gov
Seat belts, frontMay 5, 2004
CERTAIN PICKUP TRUCKS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, 'SEAT BELT ASSEMBLIES.' THE DRIVER'S SIDE SEAT BELT HAS INCORRECT MARKINGS.
THIS DOES NOT MEET THE STANDARD.
DEALERS HAVE REPLACED THE SEAT BELTS. NO VEHICLES WERE SOLD TO CONSUMERS.
Campaign 04V214000 on NHTSA.gov
Representative owner complaints
414 reports, newest first.
Structure, Engine, Oct 16, 2015
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. WHILE PARKED, THE ENGINE WARNING INDICATOR ILLUMINATED. IN ADDITION, THE CONTACT DISCOVERED A HOLE ON THE REAR DRIVER SIDE LEAF SPRING AND IT WAS NOT CONNECTED TO THE FRAME. THE CONTACT STATED THAT THE FRAME HAD RUSTED. THE VEHICLE WAS DRIVEN TO A DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 162,000.
Structure, Oct 14, 2015
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT THE METAL PLATE BELOW THE FUEL TANK WAS HANGING LOOSELY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 144,000. UPDATED 12/03/15*LJ
Electrical system, Oct 9, 2015
2004 TOYOTA TACOMA V6 3.4L 5VZ-FE WITH AUTOMATIC TRANSMISSION. TOYOTA ORIGINALLY EQUIPPED THIS VEHICLE WITH A THROTTLE BY WIRE SYSTEM. THE VEHICLE UNEXPECTEDLY DOES NOT RESPOND TO ACCELERATOR PEDAL POSITION. TOYOTA ON BOARD DIAGNOSTIC SYSTEM DOES NOT DETECT FAULT THUS DOES NOT LOG ANY ERROR CODES OR ILLUMINATE CHECK ENGINE LIGHT. OCCURRENCE RATE AND DURATION OF EVENTS IS INTERMITTENT AND INCONSISTENT. VELOCITY OF THE VEHICLE RAPIDLY DECREASES UNEXPECTEDLY AND MOMENTARILY AS IF FOOT WAS TEMPORARILY REMOVED FROM THE ACCELERATOR PEDAL. VEHICLE ALSO UNEXPECTEDLY AND MOMENTARILY DOES NOT RESPOND WHEN ACCELERATOR PEDAL IS DEPRESSED TO BEGIN MOVING OR SUDDENLY DECREASES SPEED WHEN ACCELERATING. THIS IS A POTENTIAL HAZARD IN SITUATIONS SUCH AS CRUISING IN TRAFFIC, CLEARING AN INTERSECTION, CROSSING RAILROAD TRACKS, ETC... OCCURRENCE RATE AND DURATION OF PROBLEM SEEMS TO BE WORSENING OVER TIME OR WITH INCREASED AMBIENT TEMPERATURES. *TR
Suspension, Oct 7, 2015
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A DEALER FOR AN UNRELATED SERVICE WHERE IT WAS DISCOVERED THAT THE LEAF SPRING FRACTURED DUE TO FRAME CORROSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
Electrical system, Structure, Latches/locks/linkages, Oct 1, 2015
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT THE DRIVER SIDE DOOR'S ELECTRONIC LOCK SYSTEM FAILED. THE DOOR LOCKED ON ITS OWN AND DID NOT UNLOCK WITH THE INTERIOR OR EXTERIOR DOOR HANDLES. THE PASSENGER SIDE DOOR WAS USED TO EXIT THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE A DIAGNOSTIC WAS PERFORMED, WHICH WAS UNABLE TO LOCATE A FAILURE CODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 1/19/16 LN; UPDATED4/16/18*JB *TR
Suspension, Other or unspecified, Sep 24, 2015
THERE IS FRAME ROT ON THE VEHICLE WEAKENING THE FRAME AND SUSPENSION COMPONENTS. THE WORST AREA OF ROT IS ON THE DRIVERS SIDE OF THE VEHICLE WHERE THE REAR LEAF SPRING ATTACHES TO THE FRAME. THIS AREA ALSO HAS THE GAS TANK AND FUEL LINES AND REAR BRAKING LINES. I WAS NEVER NOTIFIED OF A RECALL. UPON DISCOVERY OF THIS HAZARD I NOTIFIED THE DEALER AND WAS TOLD MY VEHICLES RECALL HAD ENDED. I ALSO NOTIFIED TOYOTA CORPORATE AND WAS TOLD THERE IS NOTHING THEY CAN DO. TOYOTA TACOMAS HAVE HAD FRAME ROT ISSUES WITH RECALLS THAT HAVE AFFECTED THE REAR BRAKES FUEL LINES AND TANK. I FEEL IT IS UNFAIR OF TOYOTA TO ADMIT AN ONGOING PROBLEM AND REPLACE FRAMES ON TRUCKS WITH THIS ISSUE, YET DENY ME BECAUSE I WAS NOT MADE AWARE OF IT. HAVING A WINDOW OF TIME ON A RECALL THAT IS A HUGE ISSUE IS NOT FAIR. NOW I HAVE AN UNSAFE VEHICLE, THAT I AM AFRAID TO PUT MY CHILDREN IN, AND NO WHERE TO TURN.
Fuel/propulsion system, Sep 21, 2015
DRIVING AT 35 MPH, HEAR A DRAGGING NOISE AND PULL TO THE SIDE OF THE ROAD. I LOOKED UNDER THE CAR A SAW THAT THE METAL STRAPS HOLDING THE GAS TANK TO THE CAR HAD RUSTED THRU, ALLOWING THE TANK TO DROP DOWN TO ABOUT 3 INCHES ABOVE THE ROADWAY, CAUSING THE TANK TO DRAG THE GROUND
Structure, Wheels, Sep 21, 2015
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 12V542000 (TIRES); HOWEVER, THE MANUFACTURER AND THE DEALER REFUSED TO REMEDY THE RECALL DUE TO EXCESSIVE CORROSION OF THE SUBFRAME. THE CONTACT STATED THAT THE VEHICLE RECEIVED AN ANTI-CORROSION COATING TREATMENT PRIOR TO THE RECALL NOTIFICATION. THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT THE ANTI-CORROSION TREATMENT WAS PERFORMED OUTSIDE OF THE RECALL; THEREFORE, NULLIFYING THE RECALL REMEDY TO THE LIFT PLATE FOR THE SPARE TIRE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 99,876.
Seat belts, Sep 17, 2015
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT THE SEAL BELT RETRACTORS ON THE DRIVER AND PASSENGER SIDES FAILED TO FUNCTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Structure, Sep 14, 2015
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR REPLACEMENT TIRES; HOWEVER; THE TECHNICIAN DISCOVERED THAT THE STRUCTURE OF THE VEHICLE HAD EXCESSIVE CORROSION. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 91,000. UPDATED 11/19/15*LJ *CN
Structure, Sep 1, 2015
NEAR TERMINAL FRAME ROT. EXCESSIVE RUSTING OF FRAME. NO RUST ON BODY.
Structure, Aug 18, 2015
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRAME PREMATURELY RUSTED. THE VEHICLE WAS UNABLE TO PASS AN INSPECTION DUE TO THE FAILURE. THE DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 147,000.
Suspension, Fuel/propulsion system, Aug 14, 2015
THE OWNER FOUND A RECALL ON 2004 TOYOTA TACOMAS ON THE INTERNET. THIS RECALL SPECIFIED THAT THERE WAS A MANUFACTURING DEFECT IN THE FORMULATION OF THE UNDERCOATING. THIS MANUFACTURING DEFECT RESULTED IN THE RUSTING OF THE SUSPENSION, AND TIRE PLATE. UPON INSPECTION OF THE VEHICLE BY A TOYOTA DEALER, IT WAS FOUND THAT THE A-FRAME IS RUSTED THROUGH, THE LEAF SPRINGS ARE FAILING AND ARE BOWED IN THE OPPOSITE DIRECTION, GAS TANK MOUNTS ARE RUSTED AND THE UNDER BODY OF THE GAS TANK HOUSING IS RUSTING THROUGH. TOYOTA DEEMED THE VEHICLE UNSAFE BUT REFUSED TO DO ANYTHING BECAUSE THE RECALL HAD EXPIRED. THE OWNER NEVER RECEIVED A NOTICE BY MAIL DURING THE RECALL PERIOD. IF THE OWNER WOULD HAVE RECEIVED THE RECALL NOTICE HE WOULD HAVE BROUGHT THE VEHICLE IN FOR INSPECTION AND REPAIR. THIS VEHICLE HAS LOW MILEAGE AND IF IT WERE NOT FOR THESE MANUFACTURING DEFECTS, COULD BE DRIVEN FOR ANOTHER 10 YEARS. CONTACT WITH ANY COMMON ROAD HAZARD SUCH AS A BUMP OR POT HOLE COULD CAUSE THE BOW SPRINGS TO FAIL, AND THERE IS A POSSIBILITY OF GAS TANK RUPTURE, EXPLOSION AND DEATH.
Structure, Aug 12, 2015
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT THE SKID PLATE WAS RUSTED ON THE FRONT END OF THE VEHICLE AND THERE WAS EXTENSIVE RUST AND CORROSION ON THE FRAME. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN COATED THE RUST, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 181,000.
Structure, Jul 16, 2015
THE BODY FRAME OF MY TOYOTA IS RUSTED AND I WAS TOLD BY THE DEALERSHIP THAT TOYOTA CONTACTED THE OWNERS OF THE VEHICLES (EFFECTED YEARS) TO HAVE THE FRAMES REPLACED. I HAVE NOT BE CONTACTED BY TOYOTA ABOUT THE RUST AND CORROSION ON MY TRUCK AND THE RUST IS VERY BAD. I WAS TOLD THAT IF THE FRAME CRACKS WHILE DRIVING, IT'S A MAJOR SAFETY ISSUE. PLEASE HELP!
Suspension, Vehicle speed control, Service brakes, Jul 9, 2015
GOING 35 MILES AN HOUR THE VEHICLE WILL START TO PULL TO THE SIDE AND THE BALL JOINT WILL COME OUT ALSO THE ABS SENSOR CABLE WILL BRAKE AND YOU WILL HAVE TO REPLACE IT A $2500 DOLLAR SPENCE FOR A TOYOTA MALFUNCTION IN THE SUSPENSION I HAVE A FRIEND IN CALIFORNIA THAT HAS ONE A YEAR EARLY MODEL THAN MINE A 2003 TOYOTA TACOMA AND HE TOLD ME ABOUT THIS PROBLEM HAD HAPPEN TO HIM IN THE FREEWAY ABOUT 60 MPH TO HIM A HAD TO LEARN THE HARD WAY IF YOU HAVE A TOYOTA TACOMA PLEASE I AM WARNING YOU TO HAVE THE BALL JOINT REPLACE BEFORE ITS TO LATE THE NEW BALL JOINTS ARE WARRANTY FOR LIFE BUT I WILL CHECK IN TO THAT IF I STILL HAVE THE PICK UP IN FOUR YEARS
Suspension, Jul 2, 2015
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT THE REAR AND FRONT PASSENGER SPRING CHASSIS WERE CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SPRING CHASSIS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 99,370.
Structure, Jul 1, 2015
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. WHILE THE VEHICLE WAS UNDERGOING MAINTENANCE, THE TECHNICIAN DISCOVERED THAT THE VEHICLE HAD EXCESSIVE CORROSION ON THE FRAME AND STATED THAT THE VEHICLE WAS UNSAFE TO OPERATE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE DEFECT WAS PART OF A LIMITED SERVICE CAMPAIGN, BUT THE VEHICLE WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 101,000.
Structure, Jun 25, 2015
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. AFTER THE VEHICLE WAS INSPECTED, THE TECHNICIAN STATED THAT THE FRAME WAS RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 167,000.
Other or unspecified, Jun 23, 2015
RECALL ON FRAME AND I BROUGHT IT TO DEAL WHERE THEY SAID FRAME WAS NOT DEFECTED. ONE YEAR LATER FRAME IS CORRODED AND RUSTED OUT. CALL DEALER AND SAID IT WAS MY PROBLEM RECALL ENDED 6 MONTHS AGO. HOW CAN THEY GET AWAY WITH THIS!!!
Suspension, Structure, Jun 16, 2015
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. WHILE DRIVING 45 MPH, THE CONTACT HEARD AN ABNORMAL POPPING NOISE UNDER THE VEHICLE. THE CONTACT DISCOVERED THAT THE LOWER BALL JOINT FAILED AND THE WHEEL WENT UNDER THE VEHICLE. THE CONTACT NOTICED THE FRAME SKIDDING ON THE HIGHWAY. THE VEHICLE WAS TOWED AWAY, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 228,000.
Structure, Other or unspecified, Jun 10, 2015
I PURCHASED A USED 2004 TOYOTA TACOMA 4X4 4 YEARS AGO IN NY. I MOVED TO MA 2 YEARS AGO AND TOOK TRUCK TO A CAPE COD TOYOTA DEALER AND ASKED THEM TO CHANGE OIL AND TELL ME IF THERE WERE ANY ISSUES I NEEDED TO DEAL WITH. TO MAKE A LONG STORY SHORT THEY TOLD ME ABOUT THE SPARE TIRE RUST RECALL AND MADE THE REPAIR. WHEN WE PICKED UP THE TRUCK THEY GAVE IT A CLEAN BILL OF HEALTH. THEY THEN SAID "BY THE WAY, YOU HAVE A TINY HOLE IN FRAME THAT MAY NEED TO BE TAKEN CARE OF AT SOME POINT-NOT URGENT." FAST FORWARD 2 YEARS- A GARAGED TRUCK THAT ONLY HAD AN ADDITIONAL 7,000 MILES. WE TOOK IT FOR THE MA STATE INSPECTION AND IT FAILED. THEY SAID IT NEEDED A NEW MUFFLER. WE TOOK IT TO OUR LOCAL CAPE COD MECHANIC WHO CALLED AND SAID THE PROBLEM WAS MUCH BIGGER- THE ENTIRE FRAME IS RUSTED OUT AND IT IS NOT SAFE TO DRIVE. WE FILED A COMPLAINT WITH TOYOTA CORPORATE AND THEY WON'T DO ANYTHING. THE DEALER CALLED TO SAY COME PICK IT UP EVEN THOUGH THEY KNOW IT IS NOT SAFE TO DRIVE. HOW MUCH IS A LIFE WORTH? OBVIOUSLY TOYOTA DOESN'T CARE. HELP PLEASE!!!
Structure, Jun 8, 2015
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT OBSERVED THAT THE BED FRAME ON THE DRIVER SIDE OF THE VEHICLE WAS LOWER THAN THE PASSENGER SIDE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BED FRAME WAS ROTTED, FRACTURED, AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 93,000.
Structure, Jun 7, 2015
HAD 2004 FRAME RECALL TESTED BY DEALER AND THEY APPLIED THE UNDERCOATING IN 2012. THE TRUCK WILL NOT PASS INSPECTION DUE TO HOLES ROTTING THROUGH FRAME AND EXCESSIVE CORROSION. THE TRUCK IS IN PERFECT SHAPE OTHERWISE AS TOTAL BODY WAS REPAINTED AT THE TIME OF THE UNDERCOATING. THIS TERRIBLE INFORMATION TO HEAR WHEN YOU PURCHASED THE TRUCK BRAND NEW AND PLANNED ON PASSING IT DOWN. ITS 11 YEARS OLD AND A LAWN ORNAMENT.
Electrical system, Other or unspecified, Fuel/propulsion system, Jun 5, 2015
FROM A DEAD STOP TO ANY SPEED, IT FELT LIKE I NO ACCERATION. I WOULD HAVE TO FEATHER THE GAS PEDAL TO GET UP TO SPEED. I'VE REPLACED FUEL FILTER, 02 SENDER ( FRONT), MAF SENDER ,FUEL PRESSURE REGULATOR ,CLEANED ALL GROUNDS, HAD FUEL PUMP TESTED , HAD HEAD GASKET CHECKED ,CHANGED SPARK PLUGS AND WIRE'S, CLEANED THROTTLE BODY AND PRESSURE CLEANED FUEL SYSTEM. EVERY TIME I CHANGE A PART OR DO ANY CLEANING , THE TRUCK WILL RUN FINE, FOR AWHILE , BUT THE PROBLEM RETURNS. I NOW HAVE 150K ON TRUCK ,AND I WANT TO GET 150 K MORE. I FELL THIS IS A EXTREMELY HAZARDS SITUATION. ALL I'M LOOKING FOR IS A ANSWER TO WHAT'S WRONG!!!! TOYOTA IS AWARE OF WHAT'S WRONG ,BUT THE DEALERS ONLY TO KEEP REPLACING PARTS ($) . THE TOYOTA FORUM S ON WEB HAVE 1000S OF ANSWER S, BUT, NOTHING DEFINITE. PLEASE HELP!!!!