2005 Toyota Tacoma
Problems, recalls and owner-reported issues
Structure is the leading concern among 707 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 Tacoma model years with reports.
Of the 2005 reports, 47 involved a crash and 4 involved a fire. 16 people were injured.
What owners report most often
Recalls and investigations
Suspension, rear, springs, leaf spring assembly, leafSep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Campaign 14V604000 on NHTSA.gov
Seat beltsAug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Campaign 13V337000 on NHTSA.gov
Air bags, frontalMar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 12V092000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Vehicle speed control, accelerator pedalOct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Campaign 09V388000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Air bagsApr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
Campaign 06V096000 on NHTSA.gov
Air bagsJun 28, 2005
ON CERTAIN REGULAR CAB PICKUP TRUCKS EQUIPPED WITH A BENCH SEAT, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR CONNECTOR PINS ARE INCORRECTLY POSITIONED DUE TO A WIRE HARNESS MANUFACTURING PROCESS ERROR.
IN THIS CONDITION, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR MAY NOT FUNCTION AS DESIGNED, AFFECTING THE ADAPTIVE AIR BAG DEPLOYMENT, WHICH IF THE VEHICLE IS INVOLVED IN A CRASH, COULD RESULT IN IMPROPER OCCUPANT RESTRAINT.
DEALERS WILL INSPECT THE SEAT POSITION AND SEAT BELT FASTENING CONDITION SENSOR CONNECTOR. AN ADDITIONAL SUB-WIRE HARNESS WILL BE INSTALLED TO CORRECT THE CONNECTOR PIN MANUFACTURING ERROR, IF NECESSARY. THE RECALL BEGAN ON JULY 25, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-431-4331.
Campaign 05V302000 on NHTSA.gov
Parking brakeFeb 11, 2005
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THERE IS A POSSIBILITY THAT THE PARKING BRAKE PEDAL CABLE LOCK NUT MAY NOT HAVE BEEN TIGHTENED TO THE PROPER TORQUE SPECIFICATION. IN THIS CONDITION, THE LOCK NUT MAY LOOSEN AND COME OFF, WHICH WILL REDUCE THE EFFECTIVENESS OF THE PARKING BRAKE.
THIS CONDITION COULD ALLOW THE VEHICLE TO ROLL IF THE TRANSMISSION IS NOT PLACED INTO THE "PARK" POSITION AND THE VEHICLE IS PARKED ON A SLOPE, THUS RAISING THE POSSIBILITY OF A CRASH.
DEALERS WILL INSPECT AND TIGHTEN THE PARKING BRAKE PEDAL CABLE LOCK NUT TO THE PROPER TORQUE SPECIFICATION FREE OF CHARGE. THE RECALL BEGAN ON MARCH 3, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 05V050000 on NHTSA.gov
Representative owner complaints: structure
260 reports, newest first. Show all
Structure, Sep 23, 2016
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT NOTICED THAT THE SUBFRAME WAS RUSTED. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.
Structure, Sep 15, 2016
MY TRUCK FRAME IS SEVERELY RUSTED. TOYOTA HAD A VOLUNTARY FRAME EXCHANGE PROGRAM, FOR WHICH I QUALIFIED. I FIRST TOOK MY TRUCK TO THE LOCAL DEALER (PENN TOYOTA IN GREENVALE, NY) FOR INSPECTION AS PER TOYOTA'S PROGRAM IN OCTOBER 2015. DEALER CONFIRMED THAT A NEW FRAME IS NEEDED AND ADVISED ME THAT IT IS ON ORDER. SINCE OCT 2015, I FOLLOWED UP WITH DEALER SEVERAL TIMES, AND IN JANUARY 2016, DEALER ADVISED THAT THEY DO NOT HAVE THE DOCUMENTATION IN THEIR SYSTEM. SO I BROUGHT MY TRUCK BACK IN AGAIN, AND SERVICE MANAGER JIMMY CONFIRMED THAT I AM ENTITLED TO A NEW FRAME UNDER TOYOTA PROGRAM AND THEY WILL PLACE THE ORDER FOR ME. AGAIN, I CONTINUED TO FOLLOW UP SEVERAL TIMES EACH MONTH AND WAS TOLD THAT FRAME IS ON ORDER. IN MARCH 2016, I FOLLOWED UP AGAIN WITH DEALER BECAUSE THE TOYOTA PROGRAM WAS ABOUT TO EXPIRE. DEALER AGAIN REASSURED ME THAT MY CASE IS IN THE SYSTEM BUT IT WILL TAKE SOME TIME TO RECEIVE NEW FRAME. IN APRIL 2016, I FOLLOWED UP AGAIN BUT THIS TIME I WAS TOLD THAT THERE IS NO DATA IN THEIR SYSTEM ABOUT HAVING ORDERED A NEW FRAME FOR MY TRUCK. I IMMEDIATELY CONTACTED TOYOTA CORPORATE OFFICE AND THEY OPENED A CASE NUMBER (160-422-2525). I WAS TOLD BY TOYOTA REPRESENTATIVE HANDLING MY CASE THAT THEY ARE GETTING A NEW FRAME FOR ME. IT IS NOW SEPTEMBER 2016 AND I STILL HAVE NOT RECEIVED ANY NEW UPDATES. DUE TO THE LARGE RUST HOLES IN MY FRAME AND HAVING READ REPORTS OF OTHER OWNERS HAVING SIMILAR ISSUES (AND TOYOTA'S ACKNOWLEDGEMENT OF THE PROBLEM AS EVIDENCED BY THE FRAME REPLACEMENT PROGRAM), I HAVE NOT BEEN ABLE TO FULLY MAKE USE OF MY TRUCK SINCE I FIRST LEARNED ABOUT THE RUST BECAUSE I DO NOT FEEL SAFE DRIVING IT.
Structure, Sep 15, 2016
THE FRAME ON THIS TRUCK HAD BEEN REPLACED DUE TO EXCESSIVE RUST. THE REAR BUMPER SUPPORT BC AND FACTORY INSTALLED TOW HITCH WERE RE INSTALLED. THAT WAS NOVEMBER 2014. IN AUGUST OF BRAD 2016 WHILE TOWING A SMALL CAMPER ON THE MASS TURNPIKE, THE HITCH TO FRAME ATTACHMENT FAILED ON THE DRIVER'S SIDE OF THE FRAME. PULLED OVER WHEN I HEARD THE THUMP.
Structure, Sep 15, 2016
THE TACOMA IS SUSCEPTIBLE TO UNUSUAL AMOUNTS OF FRAME RUST AND WHILE UNDERNEATH MINE, CHANGING THE OIL IN THE TRUCK I FOUND HOLES IN THE TRUCK FRAME LARGE ENOUGH TO FIT MY FIST IN. SO FAR I'VE RECEIVED THE RUN AROUND FROM TOYOTA. THEY HAD A LIMITED SERVICE CAMPAIGN AND REPLACED MANY TRUCK FRAMES. THAT STOPPED IN MARCH OF 2016. NOW THEY AREN'T DOING ANYTHING ABOUT THIS PROBLEM AND LEAVING IT ON THE SHOULDERS OF AMERICANS TO DEAL WITH. IN ADDITION TO THAT, AFTER THEIR OWN ADMISSION, ONE COULD ONLY SUSPECT THAT THE FRAMES THAT WEREN'T REPLACED HAVE A HIGH LIKELIHOOD OF FAILURE ON THE HIGHWAYS, ESPECIALLY IN STATES WHERE THEY (THE STATES) DON'T DO RIGOROUS INSPECTIONS TO GET VEHICLES LICENSED. AFTER THE RESEARCH THAT I'VE DONE I'VE DISCOVERED A FEW THINGS; THE TRUCKS HAVE A FUNDAMENTAL FRAME PROBLEM. TOYOTA ADMITTED THAT THERE IS A PROBLEM. MANY OF US, (TACOMA OWNERS) CAN'T AFFORD TO REPLACE THE TRUCK FRAME OR PURCHASE ANOTHER VEHICLE TO REPLACE IT WITH POTENTIALLY MAKING THE HIGHWAYS AND TOYOTA DRIVERS UNSAFE BECAUSE OF A KNOWN MANUFACTURING DEFECT THAT TOYOTA WON'T RECTIFY. ADDITIONALLY, I'M SURE BASED ON FORUMS AND OTHER REVIEWS I'VE UNCOVERED ONLINE, THAT MANY OF THE VEHICLE OWNERS ARE COMPLETELY UNAWARE OF THE DEFECT AND THE THREAT TO THEIR OWN SAFETY, AND THE SAFETY OF THOSE AROUND THEM ON THE ROADWAYS DUE TO SAID DEFECT.
Structure, Sep 6, 2016
WHILE UNDERNEATH TRUCK INVESTIGATING NOISE FROM VIBRATING METAL I NOTICED THE FRAME BADLY RUSTED NEAR THE CATALYTIC CONVERTER TO THE POINT WHERE A LARGE HOLE FORMED. RUSTED PIECES OF THE FRAME FALL OFF WHEN LIGHTLY TAPPED WITH A HAMMER. A QUICK INTERNET SEARCH MADE IT APPARENT THIS IS A VERY COMMON PROBLEM. TRUCK WAS BOUGHT AND ALWAYS REGISTERED IN A SOUTHERN STATE BUT WAS DRIVEN IN ILLINOIS FOR 3 YEARS WHILE ON MILITARY ORDERS. THERE IS SURFACE RUST EVERYWHERE BUT I HAVEN'T DONE A COMPLETE INSPECTION YET TO FIND OTHER HOLES.
Fuel system, Gasoline, Structure, Aug 24, 2016
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. AFTER PUMPING TEN GALLONS OF FUEL IN THE VEHICLE AND DRIVING HOME, THE CONTACT NOTICED THAT THE FRONT STRAP HOLDING THE FUEL TANK FRACTURED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 59,000. UPDATED 010/04/16*LJ *TR
Steering, Structure, Aug 8, 2016
MAJOR RUST DAMAGE ON FRAME AFTER ONLY 8 YEARS OF VEHILCE BEING RELEASED, A 2 BY 4 INCH WIDE HOLE ON BOTH SIDES FOR THE TRUCKS FRAME CAUSING WARPING AND BENDING AS WELL AS UNSAFE DRIVING CONDITIONS. WHEN TAKEN TO TOYOTA DEALERSHIP REPAIRS TOOK 9 MONTHS, AND UPON COMPLETION WAS SEND BACK TO OWNERS POSSESSION WITHOUT TEST DRIVING OR VERIFYING PROJECT COMPLETION.
Structure, Service brakes, Aug 4, 2016
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. WHILE THE VEHICLE WAS STATIONARY, IT WAS DISCOVERED THAT THERE WERE HOLES IN THE FRAME OF THE VEHICLE. THE CONTACT ALSO STATED THAT THERE WAS A BRAKE LINE FAILURE THAT OCCURRED IN THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 91,213. THE VIN WAS NOT AVAILABLE.
Structure, Jul 28, 2016
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (AIR BAGS); HOWEVER, THE DEALER REFUSED TO PERFORM THE RECALL REPAIR FOR FREE DUE TO EXCESSIVE CORROSION. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Suspension, Structure, Other or unspecified, Jul 27, 2016
THE OWNER OF THE TOYOTA TACOMA RECEIVED A SAFETY RECALL NOTICE INFORMING THE OWNER THAT CERTAIN TOYOTA VEHICLES FROM THE YEAR 2005 -2011 HAS HAD A DEFECT WITH REAR LEAF SPRING . THE OWNER IMMEDIATELY WENT TO TOYOTA OF BOWIE , MARYLAND HE INFORMED THEM THE NOTICE HE RECEIVED IN MARCH . HE HAS CALLED THE MANAGER SEVERAL TIMES DURING THE LAST 4 MONTHS TO GIVE AN UPDATE OF THE PARTS . IT'S BEEN 4 MONTHS THE CAR HASN'T BEEN FIXED.
Structure, Jul 24, 2016
I AM WRITING TO YOU IN REFERENCE TO MY 2005 TOYOTA TACOMA. AS YOU MAY BE AWARE, TACOMAS HAVE BEEN HAVING PROBLEMS IN THE STATES WITH HARSH WINTERS, AND WITH CORROSIONS OF THE FRAME FROM ROAD SALT. THE PROBLEM HAS BEEN SO EVIDENT THAT TOYOTA HAS ADMITTED TO NOT HAVING ADEQUATE CORROSION RESISTANT PROTECTION. THE FIRST TIME I BECAME AWARE OF THIS ISSUE WAS AT THE END OF JUNE 2016. I CALLED MY TOYOTA DEALER ABOUT TWO OTHER RECALLS AND INQUIRED ABOUT THE FRAME ISSUE AS WELL. THE SERVICE TECHNICIAN TOLD ME THAT THE FRAME IN FACT HAD A 'LIMITED SERVICE CAMPAIGN' ISSUED BY TOYOTA WHICH EXPIRED MARCH 31, 2016. HE SAID TO BRING IN MY TRUCK FOR THE OTHER TWO RECALLS (ONE WAS FOR THE LEAF SPRING) AND HE WOULD INSPECT THE FRAME (SEE PAGE 2 OF SERVICE INVOICE). AFTER INSPECTION, THE TECHNICIAN SAID HE DID NOT THINK THE TRUCK WOULD HOLD UP IN AN ACCIDENT. I CALLED TOYOTA CUSTOMER SERVICE EXPERIENCE, IN CALIFORNIA, AND ASKED FOR THEIR HELP AND EXPLAINED THE SITUATION ABOVE. THEY GAVE ME A CASE NUMBER (1607110805) AND SAID THEY WOULD GET BACK TO ME. WHEN I RECEIVED THE CALL BACK, THEY DECLINED MY REQUEST DO TO MISSING THE DEADLINE. IF THIS PROBLEM IS A KNOWN SITUATION WITH TACOMAS (ENOUGH FOR A 'LIMITED SERVICE CAMPAIGN'), ONE WOULD THINK TO ENSURE THE SAFETY OF THEIR CUSTOMERS, THEY WOULD SEND A CERTIFIED LETTER. NOT ONLY IS MY SAFETY IN JEOPARDY, BUT I CANNOT EVEN TRADE MY VEHICLE IN FOR ONE THAT WILL ENSURE MY SAFETY DUE TO FINANCIAL LIMITATIONS AND THE DECREASED VALUE OF MY TRUCK NOT HAVING THIS ISSUE RESOLVED. IF TOYOTA REALLY CARES ABOUT THEIR PRODUCT AND THE SAFETY OF THEIR CUSTOMERS, THEY WOULD DO THE RIGHT THING AND REPLACE MY TRUCK FRAME (ESPECIALLY SINCE ONE OF THEIR OWN CERTIFIED MECHANICS DETERMINED THE TRUCK HAS BEEN EFFECTED BY THE VERY SAME CAMPAIGN). THANK YOU FOR TAKING THE TIME TO READ THIS AND HOPEFULLY YOU CAN HELP ME RESOLVE THIS ISSUE. *TR
Seat belts, Structure, Jul 8, 2016
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. AFTER THE VEHICLE WAS TAKEN TO BE SERVICED FOR NHTSA CAMPAIGN NUMBER: 13V337000 (SEAT BELTS), THE TECHNICIAN STATED THAT THE FRAME OF THE VEHICLE WAS SEVERELY CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED DUE TO THE FRAME AND RECALL PARTS BEING UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 189,000. PARTS DISTRIBUTION DISCONNECT.
Structure, Jun 22, 2016
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRAME OF THE VEHICLE, NEAR BOTH FRONT TIRES AND THE REAR DRIVER'S TIRE, HAD RUST THAT CREATED HOLES. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY TO RECEIVE A RECALL REPAIR. THE APPROXIMATE FAILURE MILEAGE WAS 171,000.
Structure, Jun 20, 2016
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THE SUBFRAME UNDERNEATH THE VEHICLE WAS CORRODED AND HAD HOLES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS INCLUDED IN AN EXTENDED WARRANTY CAMPAIGN, BUT THE CAMPAIGN HAD EXPIRED. THE FAILURE MILEAGE WAS 170,000. UPDATED 09/06/16*LJ TOYOTA'S MAIN HQ STATED IT WAS OUT OF HIS HANDS NOTHING HE CAN DO AND FOR THE CONSUMER TO PAY FOR IT. UPDATED 06/15/18*JB
Structure, Jun 3, 2016
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. A MECHANIC FOUND LARGE HOLES, APPROXIMATELY FIVE INCHES IN DIAMETER, IN THE FRAME THAT HELD THE VEHICLE TOGETHER. THE DEALER CONFIRMED THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT WAS INFORMED THAT MANY VEHICLES WERE REPAIRED WITH THE SIMILAR FAILURE. THE DEALER REFUSED TO REPAIR THE VEHICLE BECAUSE THE SERVICE BULLETIN EXPIRED ON 3/31/2016. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 109,450.
Structure, May 4, 2016
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHEN THE VEHICLE WAS TAKEN TO THE DEALER TO BE SERVICED FOR NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION), THE TECHNICIAN STATED THAT THE FRAME OF THE VEHICLE WAS RUSTED AND NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 225,000. THE VIN WAS NOT AVAILABLE.
Suspension, Structure, Apr 20, 2016
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THERE WAS CORROSION AROUND THE ATTACHMENT AREA OF THE LEAF SPRINGS. THE TECHNICIAN DIAGNOSED THAT THE SUBFRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE SUBFRAME WAS PREVIOUSLY SPRAYED WITH AN ANTI-CORROSION AGENT UNDER AN EXTENDED WARRANTY CAMPAIGN BY THE MANUFACTURER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 76,000.
Structure, Apr 18, 2016
I PURCHASED A 2005 TOYOTA TACOMA IN AUGUST OF 2015. I TOOK MY VEHICLE TO A TOYOTA DEALER TO REMOVE A WHEEL LUG NUT IN SEPTEMBER OF 2015. I WAS ADVISED BY A TOYOTA SERVICE REPRESENTATIVE THAT THERE WAS A RECALL ON THE FRAME OF MY TRUCK BUT WHEN THE SERVICE RECORDS WERE CHECKED, THE SERVICE REPRESENTATIVE ADVISED THAT THE RECALL SERVICE HAD BEEN PERFORMED ON MY TRUCK BY TREATING THE FRAME. ON MARCH 17 2016 MY SON TOOK THE TRUCK TO OUR LOCAL TOYOTA DEALER IN REFERENCE TO THE LEAF SPRING RECALL. THE SERVICE REPRESENTATIVE ADVISED THE SAME INFORMATION TO MY SON IN REFERENCE TO THE FRAME RECALL AND THAT THE SERVICE TREATMENT HAD BEEN PERFORMED. MY VEHICLE WAS NEVER INSPECTED ON THESE TWO OCCASIONS AT THE TOYOTA DEALER FOR POSSIBLE FRAME DAMAGE. MY SON AND I INSPECTED THE VEHICLE AND LOCATED WHAT APPEARED TO BE RUST NEAR THE LEAF SPRING HANGERS WHICH WAS COMING UNDER THE PROTECTIVE COATING THAT HAD BEEN APPLIED BY TOYOTA. I SCHEDULED AN APPOINTMENT WITH MY LOCAL TOYOTA DEALER TO INSPECT THE FRAME. ON APRIL 15 2016 THE SERVICE REPRESENTATIVE ADVISED ME THAT THE FRAME HAD A HOLE IN THE FRAME ON THE DRIVERS SIDE NEAR THE PART OF THE FRAME WHERE IT STARTS TO GO TOWARDS THE MOTOR. THE SERVICE REPRESENTATIVE ADVISED THAT IN HIS OPINION THE HOLE HAD BEEN THERE FOR AWHILE AND THAT THE HOLE COULD NOT HAVE GOTTEN THAT LARGE IN A YEAR SINCE BEING TREATED.I CONTACTED TOYOTA AND WAS ADVISED THIS WAS NOT A RECALL BUT A SERVICE CAMPAIGN AND THAT IT EXPIRED ON MARCH 31 2016 AND THAT THEY COULD NOT GIVE ANY ASSISTANCE WITH THE RUSTED FRAME.I ADVISED THE TOYOTA CASE MANAGER THAT I COULD UNDERSTAND IF IT HAD NEVER BEEN INSPECTED OR TREATED BUT THAT'S NOT THE CASE WITH MY VEHICLE. I ALSO ADVISED THE CASE MANAGER THAT IT WAS APPARENT THAT THE FRAME TREATMENT DID NOT STOP THE PROBLEM WITH RUST IN THE FRAME. SHE JUST KEPT ADVISING THAT TOYOTA COULD NOT ASSIST ME WITH THIS MATTER.
Structure, Apr 15, 2016
10 - 12 INCH LONG VERTICAL RUST AND CRACKS IN THE FRAME. LOCATED ON BOTH SIDES OF THE FRAMES INTERIOR. LOCATIONS ARE BOTH OPPOSITE OF THE CATALYTIC CONVERTERS. I WAS TOLD BY A FRIEND THERE WAS AN ISSUE AND TOYOTA WAS REPLACING THE FRAMES DUE TO INFERIOR QUALITY OF PRODUCTION CAUSING A SAFETY ISSUE IN WHICH THE FRAMES WERE RUSTING FROM THE INSIDE OUT. I MADE AN APPOINTMENT WITH THE LOCAL DEALER ON 4/4/2016, I HAD TO WAIT UNTIL 4/13/2016 FOR THE FIRST AVAILABLE APPOINTMENT. UPON ARRIVING AT THE DEALER I WAS INFORMED THE "RECALL" EXPIRED MARCH 31ST AND THEY CAN DO NOTHING FOR ME. THEY REFUSED TO EVEN LOOK AT THE ISSUE. I CALLED TOYOTA TO ASK IF THERE WAS ANY RECOURSE AS I HAD NEVER RECEIVED NOTIFICATION OF THIS ISSUE LET ALONE A DEADLINE. I WAS TOLD THIS WAS NOT A RECALL AND THE TIME HAD EXPIRED AND THERE WAS NOTHING THEY WOULD DO FOR ME. I AM AFRAID THE TRUCK IS NOT SAFE TO DRIVE.
Structure, Apr 13, 2016
2005 TOYOTA TACOMA FRAME RUST RECALL. TOYOTA REP INSPECTED THE FRAME AND STATED IT HAS FAILED DUE TO RUST AND CORROSION. TOYOTA REFUSES TO OFFER ANY REMEDY FOR THIS PROBLEM. FRAME COULD BREAK AND CAUSE PERSONAL OR VEHICLE DAMAGE.
Structure, Apr 8, 2016
A LIMITED SERVICE CAMPAIGN NOTIFIED ME OF POSSIBLE FRAME RUST PROBLEM. RECEIVED CRC COATING 9/10/2014. NOTICED RUST HAD ADVANCED THROUGH THE FRAME AND NOTIFIED DEALER. DEALER CHECKED DAMAGE 3/21/16 AND GAVE ME A TOYOTA CUSTOMER SERVICE NUMBER. TOYOTA SAID THEY COULDN'T DO ANYTHING ABOUT IT SINCE I RECEIVED THE CRC COATING, WHICH WAS POORLY APPLIED. (SEE PICTURES OF OVERSPRAY ON BED, INDICATING IT HAD NOT BEEN REMOVED TO SPRAY THE WHOLE FRAME) PUNISHED FOR BEING PROACTIVE. STUCK WITH A RUSTY FRAME.
Structure, Mar 23, 2016
THE TOYOTA DEALER IN CONCORD, NH INSPECTED MY 2005 TOYOTA TACOMA ON MARCH 17, 2016. THEY REPORTED THAT THE FRAME IS CORRODED AND THAT THERE IS A PERFORATION INSIDE THE FRAME BY THE FRONT BODY MOUNT. THEY SUGGESTED I CALLED TOYOTA. THREE PHONE CALLS TO TOYOTA. THEY ARE AWARE OF FRAME CORROSION ISSUES, BUT REFUSED TO CORRECT THIS, BECAUSE "THE REPLACEMENT PROGRAM NO LONGER APPLIES." CLEARLY THE MANUFACTURER IS AWARE OF A PROBLEM WITH THIS MODEL, YET REFUSES TO ADDRESS AN ISSUE THAT IS A SAFETY RISK.
Structure, Mar 11, 2016
FRAME RECALL. I TOOK MY FRAME IN TO BE SPRAYED WITH RUST PROTECTION BUT 4 MONTHS LATER THE VEHICLE FAILED THE STATE INPECTION DUE TO HOLES IN THE FRAME. TOYOTA SAID THAT SINCE THEY ALREADY PUT THE RUST PROTECTION ON THEY CAN NOT DO ANYTHING. THEY DID NOT PROPERLY INSPECT MY FRAME. THE RUST HOLES DID NOT APPEAR AFTER 4 MONTHS. THEY SHOULD OF REPLACED THE BAD FRAME.
Structure, Mar 9, 2016
PLEASE SEE BELOW. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Suspension, Structure, Mar 7, 2016
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. WHILE THE VEHICLE WAS AT THE LOCAL DEALER, THE MECHANIC DIAGNOSED THAT THE SUBFRAME WAS CORRODED AROUND THE REAR OF THE VEHICLE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS PREVIOUSLY INSPECTED UNDER A VOLUNTARY RECALL BY THE MANUFACTURER. THE VIN WAS ALSO INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION); HOWEVER, THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 155,294. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.