2005 Toyota Tacoma
Problems, recalls and owner-reported issues
Structure is the leading concern among 707 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 Tacoma model years with reports.
Of the 2005 reports, 47 involved a crash and 4 involved a fire. 16 people were injured.
What owners report most often
Recalls and investigations
Suspension, rear, springs, leaf spring assembly, leafSep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Campaign 14V604000 on NHTSA.gov
Seat beltsAug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Campaign 13V337000 on NHTSA.gov
Air bags, frontalMar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 12V092000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Vehicle speed control, accelerator pedalOct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Campaign 09V388000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Air bagsApr 3, 2006
ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.
THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.
DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.
Campaign 06V096000 on NHTSA.gov
Air bagsJun 28, 2005
ON CERTAIN REGULAR CAB PICKUP TRUCKS EQUIPPED WITH A BENCH SEAT, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR CONNECTOR PINS ARE INCORRECTLY POSITIONED DUE TO A WIRE HARNESS MANUFACTURING PROCESS ERROR.
IN THIS CONDITION, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR MAY NOT FUNCTION AS DESIGNED, AFFECTING THE ADAPTIVE AIR BAG DEPLOYMENT, WHICH IF THE VEHICLE IS INVOLVED IN A CRASH, COULD RESULT IN IMPROPER OCCUPANT RESTRAINT.
DEALERS WILL INSPECT THE SEAT POSITION AND SEAT BELT FASTENING CONDITION SENSOR CONNECTOR. AN ADDITIONAL SUB-WIRE HARNESS WILL BE INSTALLED TO CORRECT THE CONNECTOR PIN MANUFACTURING ERROR, IF NECESSARY. THE RECALL BEGAN ON JULY 25, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-431-4331.
Campaign 05V302000 on NHTSA.gov
Parking brakeFeb 11, 2005
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THERE IS A POSSIBILITY THAT THE PARKING BRAKE PEDAL CABLE LOCK NUT MAY NOT HAVE BEEN TIGHTENED TO THE PROPER TORQUE SPECIFICATION. IN THIS CONDITION, THE LOCK NUT MAY LOOSEN AND COME OFF, WHICH WILL REDUCE THE EFFECTIVENESS OF THE PARKING BRAKE.
THIS CONDITION COULD ALLOW THE VEHICLE TO ROLL IF THE TRANSMISSION IS NOT PLACED INTO THE "PARK" POSITION AND THE VEHICLE IS PARKED ON A SLOPE, THUS RAISING THE POSSIBILITY OF A CRASH.
DEALERS WILL INSPECT AND TIGHTEN THE PARKING BRAKE PEDAL CABLE LOCK NUT TO THE PROPER TORQUE SPECIFICATION FREE OF CHARGE. THE RECALL BEGAN ON MARCH 3, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 05V050000 on NHTSA.gov
Representative owner complaints
707 reports, newest first.
Other or unspecified, Sep 30, 2019
PREMATURE FRAME RUST PROBLEM. I CANNOT DRIVE THIS TRUCK BECAUSE OF SAFTY CONCERNS.
Structure, Sep 1, 2019
I BOUGHT A USED 2005 TACOMA IN JULY OF 2019. NO FRAME ISSUES WERE APPARENT AT THE TIME THAT I PURCHASED IT. THE WEEK AFTER I BOUGHT IT, I TOOK IT TO THE DEALERSHIP TO HAVE RECALL WORK DONE ON THE LEAF SPRINGS AND SEAT BELTS. I ASKED THE DEALERSHIP SERVICE DEPARTMENT TO CHECK OUT THE FRAME BECAUSE I HAD BECOME AWARE OF THE FRAME SERVICE CAMPAIGN. THEY TOLD ME THAT THE DEADLINE HAD PASSED IN JANUARY OF 2019 AND THAT THEY COULDN'T DO ANYTHING ABOUT IT. I HAVE SINCE DISCOVERED MUCH MORE TROUBLESOME FRAME CORROSION AND AM CONCERNED THAT THE TRUCK IS NOT SAFE TO DRIVE.
Structure, Aug 4, 2019
2005 TOYOTA TACOMA FRAME IS CORRODED AND TOYOTA REFUSED TO REPLACE THE FRAME.
Power train, Jul 22, 2019
SQUIRK-LIKE SOUND AT THE BEGINNING OF A TRIP, SPECIFICALLY WHEN THE VEHICLE REACHES 5 MPH. THIS NOISE PREVAILS AS LONG AS THE SPEED IS INCREASED, SPECIFICALLY ALONG THE RANGE OF 5 TO 15 MPH. FROM 16 MPH IT STARTS A VIBRATION ALONG THE ENTIRE VEHICLE BODY, WHICH AUGMENTS AS LONG AS THE SPEED IS INCREASED. THESE SYMPTOMS APPEARED FOR FIRST TIME 5 YEARS AGO, APPROXIMATELY. ON THAT FIRST EVENT THE PROPELLER SHAFT SPIDER ANT THEIR BEARINGS WERE REPLACED BY THE TECHNICIAN WHERE THE VEHICLE WAS BOUGHT. NOWADAYS I JUST SCHEDULED AN APPOINTMENT TO BRING THE VEHICLE TO ANOTHER TOYOTA AUTHORIZED SERVICE CENTER FOR PROPER DIAGNOSIS AND REPAIR. IT IS NECESSARY TO HIGHLIGHT THAT THIS AUTOMOTIVE UNIT PRESENTED SYMPTOMS OF VIBRATION AT CRUISE SPEED (55 MPH), SINCE THE VERY FIRST TIME IT WAS DRIVEN ON THE HIGHWAY, FOR THE YEAR OF 2005. WHEN THAT OCCURRED, THIS DRIVER BROUGHT THE UNIT TO THE DEALER. THE RESPONSE WAS THAT THE VIBRATION DESCRIBED IS "NORMAL". THIS STRANGE "SHAKING" AT CRUISE SPEED HAS NOT DISAPPEARED. IT THINK IT IS A DESIGN AND MANUFACTURING DEFECT OF THE PROPELLER SHAFTS AND THEIR JOINTS, WHICH CAUSE A DYSFUNCTIONAL PROPELLER SHAFT RUNOUT (GREATER THAN 0.6MM [0.024 IN.]). OTHER TACOMA 2005 OWNERS HAVE LET ME KNOW THEY HAVE EXPERIENCED THE SAME SITUATION IN THEIR VEHICLES. THIS COULD REPRESENT A POTENTIAL SAFETY RISK FOR ALL VEHICLE OCCUPANTS.
Steering, May 23, 2019
MY STEERING HAD STARTED TO GET STIFF DURING A TRIP TO PHILADELPHIA. SINCE THEN IT GOT TO THE POINT WHERE IT WAS ALMOST IMPOSSIBLE TO DRIVE. AFTER ABOUT SIX MONTHS OF THIS IT BECAME NORMAL AGAIN. NOW IT IS GOING BACK TO BEING STIFF AND HARD TO TRANSITION FROM A TURN TO STRAIGHT MAKING IT UNSAFE TO DRIVE.
Suspension, May 15, 2019
I OWN A 2005 TOYOTA TACOMA, I TOOK IT TO WHITE RIVER TOYOTA, 303 SYKES MOUNTAIN AVENUE, WHITE RIVER JUNCTION VT 05001 802-299-2880 FOR SOME RECALL WORK, THEY WERE UNABLE TO COMPLETE THE RECALL WORK ON THE LEAF SPRINGS BECAUSE THE FRAME WAS SO ROTTED THAT THERE WAS NOTHING THAT THEY COULD ATTACH THE LEAF SPRINGS TO, IT WAS AT THAT TIME THAT I WAS INFORMED THAT THERE WAS A WARRANTY FOR THE FRAME THAT HAD EXPIRED ON 1/31/19 AND THEY WERE NO LONGER ABLE TO HELP ME. MY TRUCK HAS 25,125 ORIGINAL MILES ON IT, THE BODY AND ENGINE ARE IN GREAT SHAPE, BUT THE FRAME IS JUNK. I HAD NOTICED SOME INSTABILITY IN THE HANDLING OF THE TRUCK ABOUT A WEEK PRIOR AND FOUND OUT THAT THERE WAS A RECALL ON THE LEAF SPRINGS AS WELL AS THE FRAME.
Other or unspecified, May 15, 2019
I OWN A 2005 TOYOTA TACOMA. I TOOK THE VEHICLE TO WHITE RIVER TOYOTA AT 303 SYKES AVENUE, WHITE RIVER JUNCTION VT. 802-299-2880 FOR SOME RECALL WORK , THE DEALERSHIP INFORMED ME THAT THE FRAME WAS COMPLETELY ROTTED AND THEY STATED THAT THERE WAS A WARRANTY ENHANCEMENT PROGRAM DATED FROM 7/17/17 TO 01/31/19. THE DEALER AND MANUFACTURER STATED THAT DURING THAT TIME, THEY COULD HAVE MADE THE REPAIRS; HOWEVER, THEY COULD NO LONGER ASSIST SINCE THE WARRANTY WAS EXPIRED. THE VEHICLE WAS DIAGNOSED BUT NOT REPAIRED. THE FAILURE MILEAGE WAS 25,125. YES THAT IS CORRECT! 25,125
Electrical system, Vehicle speed control, May 3, 2019
BLOWER MOTOR ONLY WORKS ON HIGH. SOMETIMES SPEED OD. DOESN'T WORK, SOMETIMES IT DOES. SPEED OD. READS ABOUT 5 MILES PER HOUR FAST. GAUGES PAUSE FOR ABOUT 10 SEC. BEFORE WORKING WHEN I FIRST START TRUCK. ALL STARTED AROUND 120,000 MILES.
Structure, Apr 30, 2019
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE, THE INDEPENDENT MECHANIC DISCOVERED THAT THE FRAME WAS CORRODED. THERE WERE NO WARNING INDICATORS ILLUMINATED. ROYAL SOUTH TOYOTA (3115 S WALNUT ST, BLOOMINGTON, IN 47401, (866) 609-4926) WAS CONTACTED AND UNABLE TO ASSIST. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 137,357.
Structure, Apr 29, 2019
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THERE WAS A HOLE IN THE FRAME OF THE VEHICLE. THE VEHICLE WAS TAKEN TO HOLMAN TOYOTA (1301 NJ-73, MT LAUREL TOWNSHIP, NJ 08054, (888) 632-3967) AND THEY STATED THAT THERE WAS A WARRANTY ENHANCEMENT PROGRAM DATED FROM 7/17/17 TO 01/31/19. THE DEALER AND MANUFACTURER STATED THAT DURING THAT TIME, THEY COULD HAVE MADE THE REPAIRS; HOWEVER, THEY COULD NO LONGER ASSIST SINCE THE WARRANTY WAS EXPIRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 140,698. *BF*JB
Structure, Apr 22, 2019
MECHANIC NOTED RUST ON FRAME. CONTACTED TOYOTA, THERE WAS A LAWSUIT ABOUT PREMATURE RUSTING ON FRAMES, BUT SETTLEMENT IS DONE AND THERE IS NOTHING THEY(TOYOTA) CAN DO?
Structure, Mar 26, 2019
EXHAUST SYSTEM WAS IN NEED OF REPAIR. SHOP WOULD NOT BE ABLE TO FIX BECAUSE THE FRAME IS SO RUSTED THERE IS NOTHING LEFT TO ATTACH NEW PARTS TO. SHOP SHOWED ME LARGE HOLES IN FRAME. THEN ADVISED ME THAT I SHOULD NOT BE DRIVING IT WITH THE POSSIBILITIES OF BREAKING. WHICH I HAVE HEARD HAPPEN TO OTHERS. I HAVE NEVER RECEIVED A NOTICE OR RECALL FOR THIS PROBLEM. THE ONLY RECALL THAT I HAVE RECEIVED AND TAKEN CARE OF WAS THE ISSUE WITH THE ACCELERATOR. THIS ALARMS ME SINCE I OFTEN HAVE MY CHILDREN WITH ME.
Structure, Mar 8, 2019
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. WHEN THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR AN OIL CHANGE, THE TECHNICIAN FOUND THAT THE FRONT END FRAME WAS COMPLETELY RUSTED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 107,000.
Steering, Dec 22, 2018
STARTED TRUCK AND WHEN PULLING OUT OF DRIVEWAY STEERING BECOME EXTREMELY STIFF. NO UNUSUAL SOUNDS. STIFFNESS IS NOT ALWAYS THERE, IT PULSATES. FLUID LEVEL AND COLOR ALL WITHIN SPECS. BELT WITHIN SPECS. I PLAN ON PUTTING IT ON A LIFT WHEN I RETURN HOME AND PREFORM AN INSPECTION. SUSPECT U JOINT FAILURE.
Steering, Nov 21, 2018
INTERMEDIATE STEERING SHAFT FAILURE. CAUSED STIFF STEERING
Suspension, Fuel/propulsion system, Oct 7, 2018
OUR 2005 TOYOTA TACOMA'S GAS TANK HAD FALLEN OFF THE FRAME DUE TO CORRODED STRAPS WHILE THE VEHICLE WAS MOVING AT SLOW SPEED ON OUR PROPERTY. THE VEHICLE HAS LESS THAN 140,000 MILES ON IT. THE VEHICLE NEEDED TO BE TOWED TO A LOCAL TOYOTA DEALERSHIP. THERE WAS NO SERIOUS INJURY. HOWEVER, HAD THE TANK SEPARATED WHILE BEING DRIVEN IT IS VERY POSSIBLE AND PROBABLE THAT THIS COULD HAVE RESULTED IN IGNITION, FIRE, EXPLOSION AND LOSS OF CONTROL OF THE VEHICLE, SERIOUS INJURY OR DEATH. THE DEALERSHIP HAD GIVEN US AN AN INITIAL ESTIMATE OF $1,800 OUT OF POCKET EXPENSE TO PAY FOR THE REPAIRS STATING THAT THE CORROSION IS 'PART OF WINTER DRIVING' THIS IS FAR FROM A PLAUSIBLE AND ACCEPTABLE EXPLANATION. GAS TANKS SHOULD NOT FALL OFF VEHICLES AND POSE SUCH A SIGNIFICANT SAFETY THREAT. TOYOTA CORPORATE REFUSED TO PAY FOR MORE THAN ROUGHLY $400 IN REPAIRS TO THE OUT OF POCKET EXPENSES. THE FINAL BILL OUT OF POCKET EXPENSES WERE $2,300 IN COSTS FOR REPAIR.
Steering, Suspension, Structure, Jun 25, 2018
WE BROUGHT THE TRUCK IN TO HAVE IT CHECKED FOR RUST AND CORROSION THAT WE SEEN, PALMERS AIRPORT TOYOTA SAID THEY SEEN NONE, THE A-FRAME HAS RUSTED AND CORRODED TO THE POINT OF SNAPPING AND THE METAL IS CORRODED AND PEELING WITH A CRACK GOING AROUND THE WHOLE A-FRAME. THE TRUCK IS NOW NOT MOVEABLE, THE WHOLE TIRE WILL FALL OFF IF WE DO MOVE IT, WE MADE IT BACK TO OUR HOME WITH IT LUCKILY AND TOYOTA CORPORATE SAYS THERE IS NOTHING THEY CAN DO.
Suspension, Power train, Wheels, Engine, Jun 11, 2018
TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THERE WAS A STRONG VIBRATION COMING FROM THE VEHICLE, THE SERVICE ENGINE INDICATOR ILLUMINATED, AND THE U-JOINTS HAD NOT BEEN PROPERLY LUBRICATED FROM THE MANUFACTURING PROCESS. THE DEALER (LEGACY TOYOTA, 3800 W TENNESSEE ST, TALLAHASSEE, FL 32304, (850) 688-9264) DIAGNOSED THAT THE TIRES WERE THE CAUSE OF THE FAILURES. THE DEALER DID NOT REPLACE THE DRIVETRAIN AND THE U-JOINTS. THE CONTACT CONSTANTLY HAD TO LUBE THE U-JOINTS TO PREVENT DRYNESS, WHICH WOULD HAVE CAUSED THE DRIVETRAIN TO FRACTURE. THE CONTACT, A MECHANIC, REPLACED THE U-JOINTS AND TOOK THE DRIVESHAFT TO THE DEALER TO INSPECT THE PART, BUT NO REMEDY WAS PROVIDED. THE MANUFACTURER ISSUED A SERVICE CAMPAIGN AND INDICATED THAT THE VEHICLE WAS EXCLUDED; THEREFORE, THE DEALER REFUSED TO REPLACE THE U-JOINTS AND THE DRIVESHAFT. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER FOR FURTHER DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND PROVIDED NO REMEDY. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Engine, May 15, 2018
FRAME CRACKED AT THE MOTOR MOUNT WELDS, SPECIFICALLY THE DRIVERS (RIGHT) SIDE MOTOR MOUNT. CAUSES THE MOTOR TO DROP DOWN LEADING TO A SERIOUS, AND DANGEROUS CONDITION OF HAVING THE MOTOR FALL OUT. THIS PROBLEM IS MOST NOTICEABLE DURING DRIVING CONDITIONS.
Air bags, Apr 16, 2018
AIRBAG EXPLODED WHILE DRIVING, NO ACCIDENT INVOLVED.
Air bags, Apr 13, 2018
AIRBAG ON PASSENGER SIDE IS NOT WORKING. LIGHT CONTINUOUSLY SAYS AIR BAG "OFF". THE UPHOLSTERY COVERING AIR BAG SHOWS OIL STAINING ON INSIDE. THIS HAS BEEN PRESENT FOR SEVERAL MONTHS..
Power train, Engine, Mar 27, 2018
I HAVE HAD THE REAR END ON MY VEHICLE REPLACED 2X. NO HARD DRIVING. NO SIGNS OF ABUSE OR REGULAR WEAR BUT HAS COST ME OVER 2200 EACH TIME. THE HEAD GASKET HAVE NOW FAILED AND IN READING MANY ONLINE SITES THIS IS A COMMON PROBLEM. MY VEHICLE HAS BEEN SERVICED AND NEVER OVER HEATED. THIS JOB IS NOW GOING TO COST ME 2500. IT STARTED A GURGLING NOISE IN THE DASH AND GOT WARM ONE DAY. THE ENGINE THEN THREW A MISFIRE IN CYLINDER 4 A PRESSURE CHECK CONFIRMED THE HEAD GASKET. THE REAR END IS A CONCERN ALONG WITH THE HEAD GASKETS.
Power train, Mar 26, 2018
2005 TOYOTA TACOMA. CONSUMER WRITES IN REGARDS TO VEHICLE PULLS TO THE LEFT WHILE DRIVING, GEAR SHIFTER PROBLEMS AND STALLING ISSUES. *LD *JS
Steering, Mar 18, 2018
STEERING GETS DIFFICULT AT THE STAR OF TURNS THEN LOOSENS UP AS YOU TURN, MAKING IT VERY DIFFICULT TO CONTROL WHILE TURNING. AS IF POWER STEERING IS TURNING ON AND OFF?
Electrical system, Mar 15, 2018
AROUND 150,000MI THE FAN BLOWER ONLY WORKS ON HIGH SPEED (LOW AND MEDIUM DON'T WORK). ON VERY RARE OCCASIONS, ALL FAN SPEEDS WORK FINE. TRIED CHANGING THE FAN RESISTOR BUT IT DIDN'T HELP.