2008 Toyota Tacoma
Problems, recalls and owner-reported issues
Suspension is the leading concern among 446 owner complaints filed for this model year. This is the 5th highest complaint count among 26 Tacoma model years with reports.
Of the 2008 reports, 48 involved a crash and 6 involved a fire. 27 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Seats, front assembly, seat heater/coolerJun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Campaign 16V396000 on NHTSA.gov
Seats, front assembly, seat heater/coolerNov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Campaign 14V743000 on NHTSA.gov
Suspension, rear, springs, leaf spring assembly, leafSep 29, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Campaign 14V604000 on NHTSA.gov
Equipment, other, labelsAug 4, 2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2014 FJ Cruiser and Tacoma vehicles equipped with accessory wheels and tires installed by Toyota or dealers prior to the vehicle's first sale. The affected vehicles may list incorrect spare tire size and/or cold tire inflation information on the tire placard. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard No. 110, "Tire Selection and Rims for Passenger Cars."
If the spare tire is inflated to the incorrect pressure provided on the placard, tire failure may occur while it is being driven on, increasing the risk of a crash.
For the involved vehicles, overlay stickers to correct the tire placard will either be mailed to owners or provided to dealers for placement over the incorrect information on the placard. The recall is expected to begin in September 2014. Owners may contact Toyota customer service at 1-800-331-4331.
Campaign 14V475000 on NHTSA.gov
Seat beltsAug 7, 2013
Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach from the seat belt retractor.
If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Campaign 13V337000 on NHTSA.gov
Air bags, frontalMar 7, 2012
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2009 TACOMA VEHICLES, MANUFACTURED FROM SEPTEMBER 14, 2004, THROUGH AUGUST 29, 2008. OVER TIME, STEERING WHEEL VIBRATION MAY DAMAGE THE SPIRAL CABLE ASSEMBLY (CLOCKSPRING) THAT POWERS THE DRIVERS AIR BAG MODULE. IF DAMAGE OCCURS, THE AIR BAG WARNING LAMP WILL ILLUMINATE AND THE AIR BAG MAY BECOME DEACTIVATED.
IN THE EVENT OF A CRASH, THE DRIVERS SIDE AIR BAG MAY NOT DEPLOY, INCREASING THE RISK OF PERSONAL INJURY.
TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE SPIRAL CABLE ASSEMBLY, FREE OF CHARGE. AN INTERIM LETTER IS EXPECTED TO BE MAILED TO OWNERS DURING APRIL 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 12V092000 on NHTSA.gov
Tires, pressure monitoring and regulating systemsMar 4, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FJ CRUISER, LAND CRUISER, TACOMA, SEQUOIA AND TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEM (TPMS)." WHEN FACTORY-INSTALLED WHEELS AND TIRES WERE REPLACED WITH TOYOTA AUTHORIZED ACCESSORY WHEELS AND LT TIRES PRIOR TO FIRST SALE, THE TIRE PRESSURE MONITORING SYSTEMS WERE NOT RE-CALIBRATED CORRECTLY AND THEREFORE DO NOT START ILLUMINATING THE LOW TIRE PRESSURE WARNING TELLTALE AT THE REQUIRED MINIMUM ACTIVATION PRESSURE.
FAILURE TO WARN OF TIRE DEFLATIONS IS A NON-COMPLIANCE WITH FMVSS 138 AND COULD LEAD TO TIRE FAILURE INCREASING THE RISK OF A CRASH.
FOR THE LAND CRUISER, SEQUOIA, TACOMA AND TUNDRA VEHICLES, THE DEALER WILL RE-CALIBRATE THE TIRE PRESSURE MONITORING SYSTEM ON AFFECTED VEHICLES AND INSTALL AN UPDATED TIRE AND LOADING INFORMATION LABEL AT NO CHARGE. FOR THE FJ CRUISER VEHICLES, THE TPMS CANNOT BE RESET SO THE ELECTRONIC CONTROL UNIT (ECU) FOR THE TPMS WILL BE REPLACED. TOYOTA IS CURRENTLY DEVELOPING THE REMEDY ECU. IF AN OWNER IS NOT CERTAIN WHETHER HIS OR HER VEHICLE IS EQUIPPED WITH THESE ACCESSORIES, PLEASE CONTACT ANY TOYOTA DEALER FOR AN INSPECTION AT NO CHARGE. THE SAFETY RECALL BEGAN ON MARCH 31, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Campaign 11V148000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Campaign 10V036000 on NHTSA.gov
Equipment, other, labelsFeb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Campaign 10V035000 on NHTSA.gov
Vehicle speed control, accelerator pedalOct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Campaign 09V388000 on NHTSA.gov
Equipment, other, labelsJun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Campaign 09V223000 on NHTSA.gov
Representative owner complaints: structure
77 reports, newest first. Show all
Suspension, Structure, Aug 14, 2018
TL* THE CONTACT OWNS A 2008 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE VEHICLE WAS TAKEN TO SERVCO AUTO KAUAI (2477 ULU MAIKA ST, LIHUE, HI 96766, 877-689-1808) WHERE THE TECHNICIAN DISQUALIFIED THE VEHICLE FOR THE RECALL REPAIR DUE TO AN AFTERMARKET LEVELING KIT BEING INSTALLED. THE CONTACT STATED THAT THE FRAME WAS RUSTED AND THERE WERE HOLES UNDERNEATH THE FRONT DRIVER AND PASSENGER SEATS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 85,000.
Structure, Mar 27, 2017
TL* THE CONTACT OWNS A 2008 TOYOTA TACOMA. WHILE STATIONARY, IT WAS OBSERVED THAT THE SUBFRAME OF THE VEHICLE WAS SEVERELY RUSTED AND CORRODED. THERE WERE ALSO HOLES IN THE FRAME WHERE THE WHEELS CONNECTED TO THE FRAME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT AVAILABLE.
Suspension, Structure, Other or unspecified, Jan 31, 2017
FRAME RUST. THERE WAS A INSPECTION PERIOD FOR RUSTED FRAMES ON THIS VEHICLE (AND OTHERS), I MISSED THE INSPECTION PERIOD AND AM FEARFUL THAT MY TRUCK IS POTENTIALLY DANGEROUS. I THINK THIS INSPECTION TIME PERIOD AND WORK SHOULD BE EXPANDED TO PROTECT CURRENT OWNERS AND OTHERS ON THE ROADS. TOYOTA STATES IT IS OUT OF THEIR HANDS AND THEY CAN DO NOTHING FOR ME, REGARDLESS OF THE SAFETY ISSUE. PLEASE HELP EXPAND THIS INTO A RECALL OR EXPAND THE INSPECTION AND CORRECTION PERIOD. NOTE: ACTUAL DATE OF INSPECTION OR INSPECTION NOTICE IS UNKNOWN
Structure, Jan 13, 2017
POSSIBLE RUST CORROSION ON FRAME OF VEHICLE. I HAD THE SAME PROBLEM IN A TACOMA TRUCK, 2000 MODEL YEAR. I WANT TO MAKE CERTAIN THAT THIS ISSUE DOES NOT AFFECT THE 2008 TACOMA I PURCHASED TO REPLACE THE OLDER VEHICLE.I STILL OWN THE 2008 TACOMA. I AM NOTICING A HUM IN THE FRONT END OF THIS VEHICLE.
Structure, Dec 2, 2016
TL* THE CONTACT OWNS A 2008 TOYOTA TACOMA. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE VIBRATED AND A HUMMING NOISE WAS PRESENT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DISCOVERED THAT THE SUBFRAME EXPERIENCED SEVERE RUSTING AND CORROSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 99,000.
Suspension, Structure, Aug 19, 2016
TL* THE CONTACT OWNS A 2008 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE DEALER INDICATED THAT THE VEHICLE WOULD NEED TO RECEIVE A MANUFACTURER RECALL REMEDY FIRST FOR THE UNDERCOATING. THE MANUFACTURER ADVISED THE CONTACT TO TAKE THE VEHICLE TO THE DEALER; HOWEVER, THE DEALER INDICATED THAT THEY DID NOT HAVE THE COATING FOR THE REPAIR FOR MONTHS. THE CONTACT WENT TO A SECOND DEALER AND THE VEHICLE WAS PLACED ON A LIFT TO BE COATED. THE PART WAS ON A NATIONAL BACK ORDER. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Structure, May 19, 2016
TL* THE CONTACT OWNS A 2008 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE FAILED INSPECTION DUE TO EXCESSIVE CORROSION ON THE REAR CROSS MEMBER FRAME. THE TECHNICIAN STATED THAT THE REAR CROSS MEMBER FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 72,598.
Structure, May 5, 2016
THIS TRUCK WAS RECALLED FOR PREMATURE FRAME CORROSION. AT THE DEALER'S INSPECTION THE VEHICLE WAS PRONOUNCED AS BEING STRUCTURALLY SOUND. HOWEVER, AT THE CORPORATIONS EXPENSE THE VEHICLE WOULD BE SENT ELSEWHERE FOR FRAME ANTI CORROSION TREATMENT. I PICKED UP THE TRUCK A COUPLE OF DAYS LATER AND FOLLOWED THE INSTRUCTIONS AS FAR AS ALLOWING THE TREATMENT TO CURE OUTSIDE FOR SEVERAL DAYS. THIS REPAIR WAS DONE IN JANUARY F THIS YEAR. AFTER SEVERAL WEEKS IT SEEMED AS THOUGH THE FRAME TREATMENT HAD NOT CURED AS A STRONG CHEMICAL SMELL PERSISTED WHICH WAS PHYSICALLY NAUSEATING. IT IS NOW MAY 5TH AND THE VEHICLE IS AT THE DEALERSHIP (WHERE THE VEHICLE WAS PURCHASED) FOR AN UNRELATED RECALL REPAIR. THE SERVICE MANAGER AND MECHANIC WHO LOOKED AT THE VEHICLE SAY THE TREATMENT WILL EVENTUALLY CURE AND STOP SMELLING. THE TOYOTA CORPORATION CLAIMS TO HAVE NO RESPONSIBILITY IN THIS MATTER. THE DEALER SENT THE VEHICLE OUT FOR A TOYOTA CORPORATION AUTHORIZED TREATMENT THAT APPARENTLY DID NOT WORK. THIS HAS MADE THE VEHICLE NOT USEFUL FOR ME ANY LONGER; I DON'T EXPECT TO HAVE TO LIVE WITH MY PRIMARY VEHICLE HAVING BEEN MADE USELESS UNLESS I INTEND TO BE MADE ILL WHILE DRIVING IT. THE VEHICLE WAS MORE USEFUL, EVEN WITH MINOR FRAME CORROSION, BEFORE THIS TREATMENT WAS DONE AND I FULLY EXPECTED TO HAVE THE USE FOR SEVERAL MORE YEARS.
Steering, Structure, Wheels, Apr 20, 2016
TL* THE CONTACT OWNS A 2008 TOYOTA TACOMA. WHILE DRIVING AT A LOW SPEED, THE STEERING WHEEL SEIZED. AS A RESULT, THE CONTACT WAS UNABLE TO STEER THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SEALS WERE CORRODED AND THE POWER STEERING JOINT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FRONT DRIVER SIDE WHEEL NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE REPAIR DID NOT CORRECT THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE FAILURE MILEAGE WAS 95,000.
Structure, Apr 12, 2016
TL* THE CONTACT OWNS A 2008 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRAME OF THE VEHICLE WAS RUSTED. THE VEHICLE WAS TREATED FOR RUST A YEAR AGO, BUT THE SOLUTION USED TO COAT THE FRAME RUBBED RIGHT OFF. THE CONTACT NOTIFIED THE MANUFACTURER. THE APPROXIMATE FAILURE MILEAGE WAS 138,000.
Suspension, Structure, Mar 9, 2016
TL* THE CONTACT OWNS A 2008 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V602000 (SUSPENSION) AS WELL AS A RECALL PERTAINING TO THE FRAME. THE CONTACT FELT UNSAFE DRIVING THE VEHICLE. DUE TO THE FRAME BEING RUSTED, THE TIRES HAD TO BE REPLACED TEN TIMES. THE CONTACT FELT THAT THE LEAF SPRINGS COULD SNAP, PUNCTURE THE FUEL TANK, AND POSSIBLY CAUSE A FIRE. THE DEALER DIAGNOSED THE VEHICLE AND THE FRAME WAS ORDERED, BUT HAD NOT YET ARRIVED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 118,000.
Structure, Dec 18, 2015, crash
ON FRIDAY, DECEMBER 4TH I WAS DRIVING MY TACOMA PICKUP. WHEN I HAD TO STOP IN TRAFFIC I APPLIED THE BRAKE. THE PICKUP HAD UNINTENTIONAL ACCELERATION RATHER THAN STOPPING. I WAS NOT GOING MORE THAN FIVE MPH. I WAS ON A CITY STREET. THERE IS DAMAGE TO MY PICKUP.
Structure, Nov 2, 2015
I PURCHASED A BRAND NEW 2008 TOYOTA TACOMA. IT CAME WITH GENINUE FACTORY INSTALLED RUNNING BOARDS. ABOUT A YEAR AGO I NOTICED PITTING ON THE RUNNING BOARDS (BOTH SIDES OF THE VEHICLE) THE COROSION STARTED AT THE REAR OF THE BOARDS (NEAR THE REAR WHEELS). I BROUGHT THE TRUCK TO THE DEALERSHIP WHERE I PURCHASED IT. I INQUIRED IF THE TACOMA WAS COVERED UNDER ANY WARRANTY OR RECALL, SINCE I'VE HAD SEVERAL AND ONE IS STILL OUTSTANDING (TOYOTA IS IN PROCESS OF DECIDING HOW TO FIX, SOMETHING TO DO WITH A REAR SPRING NEAR GAS TANTK). THIS MIGHT BE ASSOCIATED WITH MY CURRENT PROBLEM WITH THE-RUNNING BOARDS ON MY TRUCK! LAST WEEK WEDNESDAY I LEFT MY TRUCK FOR REPAIR WITH THE DEALERSHIP AGREEING TO PAY $300 FOR RESTORING MY RUNNING BOARDS. BY THE WAY THEY GUARANTEE THEIR WORK FOR LIFETIME. I RECEIVED A CALL FROM DEALERSHIP THE NEXT DAY INFORMING ME THAT UPON INSPECTIOEN OF THE RUNNING (TOYOTA GENUINE FACTORY INSTALLED) BOARDS THAT THE PROBLEM WAS THAT BOTH BOARDS WERE CORRODED FROM WITHIN THE PARTS AND CONSIDERED UNSALVAGEABLE. IF THEY DID THE WORK THEY COULD NOT GUARANTEE THE SAFETY OF THE PARTS. IN FACT THE BOARDS COULD COME OFF IN THE COMING MONTHS. NO WARRANTY ON DOING THIS JOB. MY WIFE & I ARE SENIOR CITZENS AND RELY ON USING THE RUNNING BOARDS TO GAIN ENTRANCE TO THE TRUCK. ANOTHER CONCERN I HAVE IF I HIT SOMETHING ON THE ROAD AND THE DEFECTIVE RUNNING BOARDS BREAK OFF AND HIT ANOTHER VEHICLE. THE ATTITUDE FROM TOYOTA CORPORATE WAS THAT THEY ARE NOT RESPONSIBLE IF ANYTHING HAPPENS. WHEN I ASKED TO SPEAK WITH A SUPERVISOR I WAS TOLD THAT I WOULD RECEIVE A CALLBACK WITH 24 HOURS. IT HAS BEEN 3 DAYS AND I'VE NOT HEARD BACK. MY COMPLAINT IS LODGED AGAINST TOYOTA FOR MAKING DEFECTIVE PARTS THAT COULD INJURY OTHERS. TOYOTA'S INDIFFERENCE TO MY SITUATION ONLY INCENSES ME BECAUSE I THOUGHT I WAS BUYING A QUALITY PRODUCT.
Suspension, Structure, Feb 25, 2015
I BROUGHT MY TRUCK IN FOR THE FRAME CHECK. THEY SAID I WAS GOOD FOR A FRAME SPRAY. THEY SPRAYED MY TRUCK BECAUSE I WAS TOLD IT WAS WARRANTIED. I GET MY TRUCK BACK AND THE SPRAY IS ALL OVER MY GARAGE MY DRIVEWAY MY PAINT AND RUBS OFF BY DRIVING THROUGH SNOW. I WAS TOLD SOME TRUCKS COME BACK AFTER A YEAR WITH BAD FRAMES WITH THIS TREATMENT. HOW ARE THEY ALLOWED TO COVER UP SUCH A SAFETY HAZARD. I SHOULD HAVE LEARNED FROM MY LAST TOYOTA FRAME THAT SNAPPED ON ME AS I WAS DRIVING. BUT AFTER THERE LAST RECALL I WAS THINKING SOMETHING CHANGED. TURNS OUT THEY MADE NO CHANGES TO THEIR FRAMES EVEN AFTER ALL THERE ISSUES. SO I ASKED IF I WAS TO BUY A BRAND NEW TRUCK IS THERE A NEW FRAME PROCESS.. GUESS WHAT NO CHANGE. *JS
Suspension, Structure, Feb 25, 2015
I WAS DRIVING DOWN THE ROAD HEARD A LOUD SNAP. TRUCK SKIPPED SIDEWAYS LIKE I HIT A POTHOLE. FOUND A BROKEN DRIVER SIDE LEAF SPRING. I REPORTED IT TOYOTA THEY SAID THEY DIDN'T KNOW HOW TO FIX IT. SO I WENT OUT AND HAD 2 NEW SPRINGS PUT ON FOR SAFETY. I WAS THEN TOLD THEY WOULD PAY ME FOR THE REPAIR. NOW BECAUSE THEY DON'T KNO THE "REMEDY" TO REPAIR THIS. THEY WON'T DO ANYTHING FOR ME. *JS
Suspension, Structure, Feb 11, 2015
MY LEAF SPRING SNAPPED WHILE DRIVING DOWN THE ROAD. AND THEY STILL WONT DO ANYTHING FOR IT. BECAUSE THEY DON'T KNOW HOW TO FIX THERE OWN PROBLEM. ALSO THEY WON'T STAND BEHIND THE THERE FAKE REMEDY FOR A FRAME THAT IS GOING TO BREAK APART. THEY DID ON THE 2001-2004 BECAUSE THEY KNEW THE SPRAY DOES NOTHING BUT MAKE IT WORSE. 04-08 YOUR ON YOUR OWN. *TR
Air bags, Structure, Wheels, Dec 5, 2014, crash
THIS TOYOTA TACOMA SLID DOWNGRADE ON BLACK ICE AND THERE WAS NO AIRBAG DEPLOYMENT DESPITE AN END-FOR-END, BACKWARDS, DOWNHILL FLIP INITIATED AT 40 MPH, THAT CAUSED THE FULL WEIGHT OF THE VEHICLE TO IMPACT ON THE FRONT BUMPER, DISLOCATING ALL FRONT BUMPER ATTACHMENTS FROM THE FRONT CROSS MEMBER OF THE VEHICLE'S FRAME. THIS VEHICLE IS AT A SALVAGE YARD AWAITING ACTION BY THE INSURANCE CARRIER... UPDATED 12/17/14 *BF
Structure, Jun 29, 2014
EXCESSIVE RUST ON FRAME. *TR
Structure, May 5, 2014
TL* THE CONTACT OWNS A 2008 TOYOTA TACOMA. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE SUB FRAME WAS EXCESSIVELY CORRODED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 30,435.
Structure, Mar 12, 2014
2008 TOYOTA TACOMA. CONSUMER WRITES IN REGARDS TO THE HEAT SHIELDS ABOVE EXHAUST PIPES AND CATALYTIC CONVERTER. *SMD THE CONSUMER STATED THE FASTENERS ATTACHED TO THE BODY, DETERIORATED CAUSING THE HEAT SHIELD TO FALL OFF.
Exterior lighting, Air bags, Structure, Engine, Jan 27, 2014, crash
AIR BAGS DID NOT DEPLOY IN FRONTAL CRASH. *TR
Structure, Nov 21, 2013
THIS COMPLAINT IS IN REGARDS TO THE FRAME OF MY 2008 TOYOTA TACOMA TRUCK VIN #[XXX]. THE COMPLAINT IS BASED ON THE SEVERE CORROSION PROBLEM WITH THE TRUCK FRAME. THE TRUCK WAS STILL UNDER WARRANTY WHEN I FIRST NOTICED IT IN 2011. BEFORE THE WARRANTY EXPIRED I TOOK THE TRUCK TO A LOCAL TOYOTA DEALERSHIP FOR THEM TO INSPECT THE FRAME AND HAVE A RECALL ADDRESSED. AT THE TIME I WAS TOLD IT WAS MINOR SURFACE RUST AND THEY WERE NOT WILLING TO DO ANYTHING ABOUT IT. FAST FORWARD TO APRIL, 2012 WHEN I SENT AN EMAIL TO TOYOTA MOTOR CO., THEIR RESPONSE WAS FOR ME TO CONTACT THE CUSTOMER RELATIONS MANAGER AT THE LOCAL DEALERSHIP. IN THE SAME EMAIL I WAS INFORMED THAT THE VEHICLE'S FRAME WARRANTY WAS FOR 3 YEARS OR 36,000 MILES. FAST FORWARD TO AUGUST/SEPTEMBER OF 2013. I SPOKE WITH THE CUSTOMER RELATIONS MANAGER AND SCHEDULED AN APPOINTMENT FOR THE FRAME TO BE INSPECTED. WHEN THE TRUCK WAS ON THE LIFT THE SERVICE MANAGER DIDN'T EVEN CARE TO LOOK AT THE FRAME. THE LOCAL DEALERSHIP IS NOT INTERESTED IN HELPING ME AT THIS POINT. I WAS TOLD THAT THE AMOUNT OF FRAME RUST ON THE TRUCK IS "NORMAL'. THEY SUGGEST I HAVE THE RUSTY FRAME UNDERCOATED. IT'S TOO LATE FOR THAT. THERE ARE SEVERAL AREAS OF THE FRAME THAT HAS SEVERE CORROSION. MY CONCERN IS THE POSSIBILITY OF THE FRAME CRACKING, ETC. NEEDLESS TO SAY, WHILE I'M DRIVING DOWN THE ROAD. IT IS A SAFETY CONCERN, AND THE TRUCK SHOULD NOT HAVE PROBLEMS LIKE THIS AT 5 YEARS OLD. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Structure, Aug 13, 2013
MY 2008 TOYOTA TACOMA HAS A FACTORY BED EXTENDER. WHICH ALLOWS USE TO USE THE TAILGATE AS PART OF THE TRUCK BED. DUE TO THE SMALL 5 FT BED. LOAD THE WEIGHT OF A ROTOTILLER INTO THE TRUCK CASED THE TAILGATE TO BOW AND BECOME UNSTABLE. THEY DO NOT HAVE ANY WEIGHT LIMIT OR RESTRICTION POSTED. IF THEY SELL PARTS TO USE THE TAILGATE TO SUPPORT ITEMS IT SHOULD NOT FAIL UNDER SUCH LIGHT LOADS. 2008 TOYOTA TACOMA TAILGATE IS DANGEROUSLY WEAK, AND IS UNABLE TO SUPPORT WHAT MOST CONSIDER NORMAL WEIGHT FOR A TRUCK TAILGATE. ALTHOUGH SUBSTANDARD DESIGN MAY BE CONSIDERED "BUYER BEWARE", TRUCK BUYERS EXPECT A TAILGATE TO SUPPORT THE WEIGHT OF NORMAL TRUCK USE ACTIVITIES. TOYOTA PROVIDES NO WARNING OR CAUTION ANYWHERE THAT THE TAILGATE IS OF INSUFFICIENT STRENGTH TO PERFORM NORMAL 1/2-TON TRUCK DUTIES, AND TYPICALLY (PER INTERNET FORUM THREADS) TELLS THEIR CUSTOMERS THAT IT IS THEIR PROBLEM AND THAT THEY SHOULD NOT EXPECT TO BE ABLE TO SAFELY USE THE TAILGATE FOR ANYTHING MORE THAN HIDING THE INSIDE OF THE BED. SINCE TOYOTA HAS PRODUCED A SUBSTANDARD DESIGNED PART, THEY SHOULD HAVE PROVIDED A VISUAL WARNING ON THE PART TO ALERT CUSTOMERS TO THE DANGER THEIR PRODUCT IMPOSES IF USED IN A TRADITIONAL MANNER. SINCE THEY DID NOT DO SO, THEY SHOULD BE HELD LIABLE TO PROVIDE A REDESIGNED PART TO THEIR CUSTOMERS OR FULL RESTITUTION FOR THE PURCHASE PRICE OF THE VEHICLES. A GOOGLE OR SIMILAR INTERNET SEARCH ON "TACOMA TAILGATE FORUM" WILL SUBSTANTIATE MY STATEMENTS BEYOND MY PERSONAL EXPERIENCE WITH THE TAILGATE BENDING. *TR
Engine and engine cooling, Electrical system, Exterior lighting, Structure, Feb 10, 2010
FUEL FILLER NECK FLAP BROKE OFF AND FELL INTO THE TANK.GAS MILEAGE IS TERRIBLE. LEFT TURN SIGNAL STAYED ON AND AIR CONDITIONER WAS WORKING INTERMITTENTLY. TOOK VEHICLE TO CHAMPION TOYOTA ON 10-15-09. DEALERSHIP STATED THAT FLAP INSIDE TANK IS NORMAL... THEY REPAIRED TURN SIGNAL AND STATED THAT THIS COULD HAVE CAUSED THE A/C TO NOT WORK PROPERLY. DEALERSHIP STATED THAT WIRES WERE BURNT TOGETHER CAUSING THE TURN SIGNAL TO STAY ON. RECEIVED VEHICLE BACK ON 10-20-09. ALSO, I HAD TAKEN THE VEHICLE TO DEALERSHIP A FEW MONTHS PRIOR TO THE 10-15-09 INCIDENT CONCERNING A/C NOT WORKING, THEY SAID THEY CORRECTED PROBLEM. ALSO, TAILGATE HAS BOWED AFTER MOVING A LIGHT DRYER. DEALER STATES THAT TAILGATE IS NOT RATED. *TR
Structure, Aug 14, 2008
THE TOYOTA TACOMA (2008) IS ADVERTISED FOR USE TO TRANSPORT MOTORCYCLES. THIS IS A CENTRAL THEME IN THEIR MARKETING PROGRAM. THE BED IS TURNS OUT IS MADE OF "COMPOSITE" (PLASTIC). THE TIE DOWN POINTS ARE RAILS AND CLEATS THAT COME OFF OR SLIDE ALONG THE SIDES OF THE BED, NOT REGULAR TIE DOWNS IN THE FRONT CORNERS, AS IN NORMAL METAL TRUCKS. THERE IS NO METAL IN THE BED TO AFFIX A TIE DOWN POINT TO. THIS SYSTEM IS NOT STRONG ENOUGH TO HANDLE THE WEIGHT OR ANGLE OF MOTORCYCLES. PLUS THE ANGLES REQUIRED TO TIE DOWN MOTORCYCLES FORCE THE CLEATS TO BEND AND FLEX BECAUSE THEY ARE ONLY INSTALLED IN PLASTIC. IT TURNS OUT THE OWNER'S MANUAL FOR THE 2008 HAS LIMITATIONS ON THE CLEATS BOTH IN ANGLE OF TIE DOWNS AND WEIGHT, BOTH OF WHICH ARE EXCEEDED IN THEIR AD PHOTOGRAPHS, LEADING ONE TO BELIEVE IT CAN BE USED FOR THIS PURPOSE, AND IN WHAT THEIR DEALERS (OR AT LEAST POWER TOYOTA IN TEMPE ARIZONA, AND TOYOTA MOTOR SALES USA, INC IS ADVERTISING). IN FACT, MANY HAVE PURCHASED THE TRUCK FOR THIS PURPOSE AND ARE DANGER OF A FAILURE OF THE SYSTEM. TOYOTA HAS ADMITTED IT IS INSUFFICIENT TO HANDLE THE WEIGHT, BUT CONTINUES TO SELL THE VEHICLES FOR THIS PURPOSE, AS IS SHOWN IN THEIR ADS. THE DEALER THAT I BOUGHT MINE FROM WITHHELD THE OWNER'S MANUAL UNTIL AFTER I TOOK THE TRUCK HOME, AND LET ME KNOW I COULD COME BACK FOR IT. THE SPECIFICATIONS ON THE TIE DOWN LIMITATIONS ARE NOT DISCLOSED ANYWHERE BUT IN THE OWNER'S MANUAL. THE DEALER ALSO TOLD ME TO USE THE TRUCK IN VIOLATION OF THE OWNER'S MANUAL WHEN I MET WITH THEM ABOUT THE PROBLEM. THIS CREATES A DANGEROUS SITUATION IN THE EVENT A MOTORCYCLE COMES OFF THE BACK OF A TRUCK AND HURTS/KILLS SOMEONE. *TR