2023 Toyota Tacoma
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 54 owner complaints filed for this model year. This is the 25th highest complaint count among 26 Tacoma model years with reports.
Of the 2023 reports, 5 involved a crash and 1 involved a fire. 5 people were injured.
What owners report most often
Recalls and investigations
Steering, columnJan 29, 2025
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Toyota Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, Lexus RX350, 2023-2024 NX250, and NX350 vehicles that may have been incorrectly repaired under previous NHTSA recall number 23V-480. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A deactivated driver's air bag will not deploy as intended, increasing the risk of injury during a crash.
Dealers will inspect and replace the spiral cable assembly as necessary, free of charge. Owner notification letters were mailed March 17, 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 25TA02. Lexus' number for this recall is 25LA02.
Campaign 25V040000 on NHTSA.gov
Power train, axle assemblyFeb 27, 2024
Toyota Motor Engineering & Manufacturer (Toyota) is recalling certain 2022-2023 Tacoma vehicles. The axle shaft sub-assembly may separate from the axle housing due to debris causing improperly secured fasteners.
Axle shaft separation can cause a loss of vehicle stability and brake performance, increasing the risk of a crash.
Dealers will inspect the rear axle assembly, tighten the axle retaining nuts as necessary, and repair or replace any damaged components, free of charge. Owner notification letters were mailed April 17, 2024. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 24TB05 and 24TA05.
Campaign 24V152000 on NHTSA.gov
Steering, columnJul 12, 2023
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, 2023 Lexus RX350, RX350 Hybrid, RX500 Hybrid, 2023-2024 Lexus NX250, NX350, and NX350 Hybrid vehicles. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
A deactivated driver's air bag that does not deploy as intended increases the risk of injury during a crash.
Dealers will inspect and replace the spiral cable assembly, if necessary, free of charge. Owner notification letters were mailed September 8, 2023. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 23TA08. Lexus' number for this recall is 23LA02.
Campaign 23V480000 on NHTSA.gov
Child seat, vehicle latch anchorJul 21, 2022
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2023 Tacoma vehicles. One or more of the individual welds in the upper child seat anchors may be insufficient. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child Restraint Anchorage System."
An insufficient weld may prevent the child seat from being anchored properly, allowing the seat to move during a sudden stop or crash, increasing the risk of injury.
Dealers will inspect the upper child seat anchors and reweld the child seat anchors, as necessary. Owner notification letters are expected to be mailed September 02, 2022. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's number for this recall is 22TB09/ 22TA09.
Campaign 22V520000 on NHTSA.gov
Representative owner complaints: electrical system
12 reports, newest first. Show all
Electrical system, Lane departure, Sep 9, 2026
Check BSM light came on Dealer found chafed wiring harness
Steering, Service brakes, Hydraulic, Electrical system, Aug 4, 2026
The contact owns a 2023 Toyota Tacoma. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 24V152000 (POWER TRAIN). The contact stated that while driving 55 MPH, the steering wheel was firm, the brake pedal was firm, and the vehicle was violently vibrating. Several unknown warning lights were illuminated. The message “Pull Over – Do Not Drive” was displayed before the vehicle lost automotive power. The vehicle was pulled over to the side of the road and was towed back to the dealer. The vehicle was inspected; however, the vehicle was not diagnosed or repaired. The contact was informed that the battery and alternator needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 43,000.
Electrical system, Fuel/propulsion system, Mar 9, 2026
On February 16 I started my vehicle to drive home from work and the vehicle threw multiple error codes and shutdown while driving and would not start again. It was towed to the dealership. The dealership advised the problem was remedied. 11 days later the same problem occurred, vehicle threw multiple error codes and shutdown while driving. Vehicle needed to be towed again to the dealership.
Steering, Electrical system, Service brakes, Dec 15, 2025
On June 20, 2025, my 2023 Toyota Tacoma (VIN [XXX] ed a sudden loss of effective braking during normal driving conditions (dry roadway, clear weather). The vehicle was being driven by my adult son. While slowing for a turn, the instrument cluster displayed a Pre-Collision System (PCS) malfunction warning and a Vehicle Stability Control (VSC) warning. The Driver applied the brake pedal continuously, but the vehicle did no decelerate as expected. ABS did not activate, and braking effectiveness was insufficient. During braking, the driver experienced reduced steering responsiveness. In order to avoid entering a busy roadway without adequate braking capability, the driver applied maximum steering input, fully loading the left side of the steering wheel with as much force as possible in an attempt to redirect the vehicle. Any reduction in speed occurred primarily due to the change in direction and tire to road friction, not effective braking. The vehicle was towed to a Toyota dealership. Dealer intake records document a PCS warning and no brakes upon arrival. Event Data Recorder (EDR/CDR) data shows continuous brake pedal application for approximately 5 seconds prior to the event, accelerator at 0%, and brake system hydraulic pressure reaching approximately 12.14 MPa (maximum recorded). Despite this, the vehicle did not stop as expected. No frontal crash pulse recorded. Toyota Motor North America later denied responsibility, asserting incorrect vehicle speed and stating that a CARFAX report indicated prior front-end damage. The CARFAX vehicle history report, dealer purchase disclosures, and service records show no reported accidents or damage. Toyota declined to provide brake system ECU logs (ABS/VSC/brake control modules). This incident raises concerns regarding a potential safety defect involving electronically controlled braking and its interaction with PCS stability control systems. Supporting documentation available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Steering, Power train, Electrical system, Jul 28, 2025
The contact owns a 2023 Toyota Tacoma. The contact stated that while the vehicle was being serviced, the contact was informed that the rack and pinion needed to be replaced due to an oil leak. The vehicle was repaired. The contact stated that on a separate occasion, while driving at an undisclosed speed, the speedometer gauge failed to function as intended. The vehicle was taken back to the dealer, and the contact was informed that the instrument panel had a factory defect. The vehicle was repaired. In addition, the contact was informed that the rear axle needed to be replaced. The vehicle was repaired. The contact stated that the rack and pinion recently failed. The contact stated that the vehicle veered to the right and the left independently while driving with an abnormal sound coming from the vehicle. The vehicle was not diagnosed or repaired after the most recent failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.
Electrical system, Jul 10, 2025
The contact owns a 2023 Toyota Tacoma. The contact stated that upon refueling, the fuel gauge indicated that there was 1/8 tank full, even though the fuel tank was full. There was no warning light illuminated. The local dealer was contacted; however, the vehicle was not diagnosed, and the contact was informed that the VIN was not under recall. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 4,700.
Electrical system, May 19, 2025, fire
The owner and operator of the vehicle, stated that they were driving the vehicle on the Interstate when they noticed white smoke and ashes emanating from the steering column. They pulled into the parking lot to investigate and opened the hood to see no smoke or fire. When they returned to the passenger compartment, the smoke turned black in color, and they observed fire emanating from the steering column. I am the Lead Fire Investigator on this incident for the Edmond Fire Department. The electrical components in the area observed with fire contained electrical arc sites and melting. No other accidental heat sources were present, and natural causes and human involvement were ruled out as well. Incident number is [XXX] in Edmond, OK. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Service brakes, Mar 25, 2025
Brake booster failure. When pressing and holding onto brake, it makes a buzzing/clicking noise. Just like the toyota prius brake booster recall/failure. Toyota claimed to be normal.
Steering, Engine and engine cooling, Electrical system, May 29, 2024
The contact owns a 2023 Toyota Tacoma. The contact stated that while reversing, the RPM and engine surged while turning the steering wheel. There were no warning lights illuminated. The vehicle was taken to the local dealer, who informed the contact that there was no coverage for the failure of the vehicle. The vehicle was not diagnosed or repaired. The contact related the failure to TSB: 0125-18. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 300.
Electrical system, Exterior lighting, Engine, Feb 17, 2024
Wiring harness on the vehicle is being completely replaced due to "rodent damage" according to the dealer. I am not an automotive engineer but if compromised wiring finally fails while driving I suspect a number of systems could be affected. There was no indication of this problem during vehicle operations. My insurance company agreed to pay for this about $7200. I have owned the vehicle for ten months.
Electrical system, Jan 18, 2024
Bearing failure inside heater blower motor causing fan motor to burn out and filling the cabin with toxic electrical smoke
Electrical system, Dec 5, 2023
This Toyota Tacoma's soy based wiring attracts rodents and I have had to have repairs for the wiring. My 2 other older vehicles in the same location that does not have the soy based wiring there no problem. This is a world wide issue and no one has done nothing about. This is a safety issue that can be potentially dangerous, if some of the safety systems fail due to soy based wiring attracting rodents.