2001 Volkswagen Jetta
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 677 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Jetta model years with reports.
Of the 2001 reports, 41 involved a crash and 12 involved a fire. 51 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Engine and engine cooling, engineMar 7, 2014
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
Campaign 14E007000 on NHTSA.gov
Exterior lighting, brake lights, switchFeb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 07V063000 on NHTSA.gov
Exterior lighting, brake lights, switchMay 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 06V183000 on NHTSA.gov
Exterior lighting, hazard flashing warning lights, switchDec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 04V584000 on NHTSA.gov
Exterior lighting, brake lights, switchFeb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 04V096000 on NHTSA.gov
Equipment, other, owners/service/other manualSep 12, 2002
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." CHILD SEAT ANCHORAGES INSTALLED IN THE VEHICLE'S REAR SEATS MUST BE IDENTIFIED BY MARKINGS, AND THEIR LOCATION AND USE BE DESCRIBED IN THE OWNER'S MANUAL.
THESE VEHICLES WERE NOT MARKED OR DESCRIBED AS REQUIRED BY THE STANDARD.
OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THE OWNER'S MANUAL AND ALSO ONE SET OF FOUR GUIDANCE FIXTURES INTENDED TO USE IN CONJUNCTION WITH CHILD SEATS EQUIPPED WITH RIGID OR SEMI-RIGID LOWER ANCHORAGE ATTACHMENTS. ALSO ENCLOSED WILL BE FOUR DECALS TOGETHER WITH INSTALLATION INSTRUCTIONS AND A TEMPLATE FOR ATTACHING THE DECALS TO THE LOWER SEAT BACKS. OWNER NOTIFICATION IS EXPECTED TO BEGIN SEPTEMBER 15, 2002. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987.
Campaign 02V244000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slipJan 31, 2002
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
THIS CAN RESULT IN A FIRE.
DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 02V031000 on NHTSA.gov
Representative owner complaints
677 reports, newest first.
Power train, Apr 29, 2004
WHILE SHIFTING GEAR INTO REVERSE VEHICLE WOULD NOT MOVE ON IT'S OWN. CONSUMER WAS ABLE TO DRIVE THE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC COULD NOT RESOLVE THE PROBLEM. *AK *LA
Seats, Apr 28, 2004
I WAS CLEANING MY VEHICLE AND NOTED UNDERNEATH THE PASSENGER SEAT FRAME A BROKEN SPRING. I TOOK MY 2001 VOLKSWAGEN TDI JETTA IN FOR INSPECTION TO THE TIMMONS OF LONG BEACH VW DEALERSHIP. I WAS TOLD THAT THE SEAT FRAME WAS DEFECTIVE AND THAT THE BOTTOM SEAT WOULD HAVE TO BE TAKEN APART TO REPLACE A NEW ADJUSTER SPRING . I WAS TOLD BY THE SERVICE MANAGER THAT MY VEHICLE WAS OUT OF ITS TWO WARRANTY PERIOD....ALTHOUGH IT HAS LESS THAN 24,000 MILES AS STATED IN MY OWNER'S MANUAL. THE WARRANTY POLICIES OF VOLKSWAGEN OF AMERICA HAS CHANGED IN ALL MODELS AFTER 2002 SINCE I BOUGHT THE VEHICLE...GIVING OTHER CUSTOMERS 4YEARS OR 50,000 MILES. THERE HAS BEEN NUMEROUS, HORRENDOUS QUALITY ISSUES CONCERNING THIS VEHICLE INCLUDING THE PROBLEM I AM CURRENTLY EXPERIENCING WITH THE VEHICLE. I DON'T FEEL THE CAR IS SAFE TO DRIVE WITH ANOTHER PASSENGER SINCE THE SEAT IS NOT ABLE TO HOLD ITS PROPER POSITION AND COULD BE A POSSIBLE PRODUCT LIABILITY ISSUE IF I EVER WAS IN AN ACCIDENT. FURTHERMORE, I FEEL THIS REPAIR SHOULD BE COVERED UNDER A RECALL AND I SHOULD NOT HAVE TO ENDURE THE COSTLY REPAIR.
Air bags, Apr 27, 2004
WHILE DRIVING 25 MPH AND WITHOUT WARNING BOTH FRONTAL AIR BAGS DEPLOYED. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND PULLED OVER. VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION, BUT DEALER COULD NOT DUPLICATE OR RESOLVE THE PROBLEM. *AK
Fuel system, Other, Electrical system, Vehicle speed control, Apr 9, 2004
MY SPEEDOMETER STARTED BOUNCING UP AND DOWN. ONE SECOND IT WOULD REGISTER 25MPH THE NEXT IT WOULD REGISTER 100MPH. IT WOULD DO THAT FREQUENTLY. THE FUEL GAUGE ACTED FUNNY AS WELL. IT WOULD MOVE LEFT AND RIGHT. FINALLY THE SPEEDOMETER STOPPED WORKING COMPLETELY. THE FUEL GAUGE WORKS OK NOW. I HAVE READ ABOUT WHAT THE PROBLEM IS. THE COOLANT MIGRATION SYSTEM IS FAULTY. THE COOLANT BOTTLE LEAKS FLUID ONTO THE ELECTRICAL WIRING HARNESS WHICH IN TURN ACTS AS A VACUUM AND THE COOLANT MAKES ITS WAY ALL THE WAY TO THE ECM. AFTER IT REACHES THE ECM IT MAKES ALL THE ELECTRICAL COMPONENTS ACT FUNNY. THIS COULD BE DANGEROUS CONSIDERING IT MAY BE THE CAUSE OF AIR BAG DEPLOYMENT WHICH I HAVE HEARD. MY WIRING HARNESS ON MY COOLANT DOES HAVE COOLANT ON IT. WHICH HAS STOPPED MY SPEEDOMETER. THANKFULLY MY AIRBAGS HAVEN'T BLOWN(YET). PLEASE CONSIDER THIS SERIOUS ISSUE. THANK YOU FOR YOUR TIME. ~CHAD~*AK
Power train, Apr 7, 2004
PREMATURE FAILURE OF CLUTCH IN VW 1.8T (JETTA). *AK
Fuel system, Gasoline, Apr 7, 2004
I HAVE A 2001 VOLKSWAGON JETTA WITH 50000, VEHICLE HAS ONLY BEEN IN SERVICE FOR 31 MONTHS. IT HAS A CRACKED HARNESS VW PART # 06A-971-627-MF THAT HAS TO BE REPLACED DUE TO MANUFACTURER'S DEFECT, PART ALONE COSTS $465.00 VOLKSWAGON IS SEEING MORE OF THESE SHOW UP, BUT THEY ARE REFUSING TO ISSUE A BULLITEN NOW TO FIX THE PROBLEM. THE SERVICE MANAGER TOLD ME THAT VW IS AWARE OF THE PROBLEM, AND ARE GOING TO ISSUE A BULLETIN. BUT UNTIL THEY DO, I HAVE TO FRONT OVER $500 TO FIX THE DEFECT AND WAIT TILL THEY ISSUE THE BULLETIN TO GET MY MONEY BACK. THAT IS THE SAME WAY THAT VW HANDLES ALL THE OTHER DEFECTS, I HAD TO DO THE SAME PROCESS WITH THE IGNITION COIL RE-CALL. IT IS NOT FAIR HOW THEY TREAT CUSTOMERS ONCE THEY CROSS THE 24000 MILE THRESEHOLD. SOMETHING HAS TO BE DONE TO CORRECT THIS!*AK
Vehicle speed control, Apr 6, 2004, crash
MY WIFE WAS PULLING INTO AN UPHILL PARKING SPOT AND PRESSED THE BRAKE TO STOP. INSTEAD, THE CAR ACCELERATED OUT OF CONTROL AND HIT A CONCRETE BLOCK WALL, WHICH CAUSED THE AIRBAGS TO DEPLOY AND DAMAGED THE FRONT OF THE CAR. THE CAR THEN REVERSED ITSELF AND MY WIFE HAD TO PULL THE EMERGENCY BRAKE TO BRING THE CAR TO A STOP. *LA
Service brakes, Hydraulic, Engine and engine cooling, Electrical system, Exterior lighting, Seats, Equipment, Apr 6, 2004
SINCE I HAVE HAD MY JETTA I HAVE HAD TO KEEP OIL IN THE TRUNK BECAUSE THE CAR BURNS OIL, I WAS TOLD BY THE DEALER THAT IT IS NORMAL FOR A CAR TO USE THAT MUCH OIL, I HAVE HAD TO HAVE THE BRAKE SWITCH REPLACED, THE ARM REST LATCH REPLACED, CD PLAYER REPLACED TWICE, MY PASSENGER REAR BRAKE LIGHTS BURN OUT REGULARLY (ONLY PASSENGER SIDE), MY KEY IN THE IGNITION ALARM AND LIGHTS LEFT ON ALARM TURNED AND STAYED ON EVERYTIME I DROVE MY CAR. THE DEALER'S SOLUTION TO ALL THESE PROBLEMS WAS TO DOWNGRADE MY CAR AND BUY A VW BEETLE. I PURCHASED A 2002 USED BEETLE - DEALER ALLOWED ME TAKE CAR AND PROMISED TO FIX ANYTHING ON THE FOLLOWING MONDAY. THERE WAS A LIGHT ON THE DASH THAT WAS LIT UP CALLED EPC - I ASKED THE DEALER WHAT THE LIGHT WAS FOR AND THEY SAID THAT THE ALIGNMENT NEEDED TO BE ADJUSTED NO BIG DEAL THEY WOULD FIX IT WHEN I RETURNED ON MONDAY. I DROVE THE CAR OFF THE LOT GOT ABOUT 20 MILES FOR THE DEALERSHIP AND THE CAR DIED ON THE FREEWAY!!!!! WHILE WAITING FOR THE TOW TRUCK I READ IN THE CAR MANUAL THAT EPC STOOD FOR ELECTRIC POWER CONTROL - IT SAID IF THIS LIGHT GOES ON DO NOT ATTEMPT TO DRIVE - TOW TO DEALERSHIP IMMEDIATELY - AFTER THAT I MARCHED RIGHT BACK TO THE DEALER AND GOT MY JETTA BACK - HOWEVER I STILL HAVE ALL OF THE ABOVE PROBLEMS AND FEW TO ADD TO THE LIST DEFECTIVE ELECTRIC WINDOW, NOISY BRAKES WHEN IN REVERSE EVEN AFTER BRAKES WERE REPLACED. I CAN'T WAIT TO TURN THE PIECE OF @#$%# IN TO THE DEALER WHEN MY LEASE IS UP AND WALK AWAY - I JUST FEEL SORRY FOR THE FOOL THEY TURN AROUND AND SELL IT TO! *LA
Exterior lighting, Apr 6, 2004
MY PASSENGER REAR BRAKE LIGHT HAS BURNT OUT APROXIMATELY FIVE TIME SINCE I PURCHASED THE VEHICLE - I ASKED THE DEALER TO INSPECT TO SEE IF THERE WAS A SHORT CAUSING THE LIGHTS TO BURN OUT AND WAS TOLD THAT IT IS NORMAL WEAR AND TEAR. FUNNY THING IS THAT MY DRIVER'S SIDE BRAKE LIGHT HAS NEVER BURNT OUT IN THREE YEARS AND I HAVE TWO FRIENDS WITH THE EXACT SAME PROBLEM SAME SIDE AND EVERYTHING. *LA
Exterior lighting, Apr 6, 2004
MY BRAKE LIGHTS WENT ON WHEN THE CAR WAS PARKED AND STAYED ON - I HAD TO HAVE IT TAKEN TO THE DEALER TO FIX THE SWITCH AND WAS OUT A CAR FOR THREE DAYS. *LA
Power train, Apr 1, 2004
THE MANUAL TRANSMISSION SLIPS OUT OF GEAR FOR NO REASON, WITH NO WARNING AT CERTAIN SPEEDS AND IN CERTAIN GEARS. WHEN YOU TRY AND ACCELERATE THE ENGINE REVS BUT YOU DON'T GO ANYWHERE, POSSIBLY A VERY DANGEROUS SITUATION. I HAVE HAD THE CAR IN TWICE FOR REPAIRS AND THE PROBLEM STILL OCCURS, ALL THAT HAS CHANGED IS WHICH GEAR. THE DEALER CLAIMED THESE REPAIRS WERE NOT UNDER WARRANTY EVEN THOUGH THE TRANSMISSION IS COVERED BY A 10-YEAR WARRANTY.*AK
Electrical system, Apr 1, 2004
I HAVE HAD NUMEROUS TROUBLES WITH THE CONTROL MODULE HAVING CODES IN IT. RIGHT NOW, I HAVE A P0411 CODE, SECONDARY AIR FLOW. THE ECM HAS BEEN REPLACED ALREADY, LEADING ME TO BELIEVE THAT THERE'S TROUBLE FOR ME DOWN THE ROAD!*AK
Engine and engine cooling, Mar 31, 2004
MY THREE YEAR OLD JETTA HAD TO BE TOWED OFF OF A MAJOR HIGHWAY DUE TO OXYGEN SENSOR FAILURE. I ALREADY HAD ONE OXYGEN SENSOR REPLACED ONE YEAR AFTER PURCHASING THIS CAR.THIS HAS BEEN A PROBLEM EVER SINSE I OWNED THE CAR. THIS A MAJOR SAFETY CONCERN SINSE THE CAR IS STALLING OUT WHILE TRAVEING AT HIGH SPEEDS. I FEEL THAT THERE NEEDS TO BE A MAJOR INVESTIGATION INTO WHY THESE VEHICLES ARE PERFORMING SO POORLY WHEN THEY ARE STILL NEW. EVERYONE I KNOW THAT OWNS A JETTA REPORTS THE SAME TYPE OF STALLING AND NUMEOUS OTHER EXPENSIVE PROBLEMS. THIS IS UNACCEPTABLE FOR A $20000 PRODUCT. ON SEVERAL OCCASIONS THE DEALER HAS NOT REPAIRED THE VEHICLE STATING THAT THERE ARE NO PROBLEMS. THE DEALER HAS INFORMED ME THAT IT IS GOING TO COST ME ALMOST $1000 TO FIX THE PROBLEM AND IT IS NOT COVERED UNDER THE VEHICLES WARRANTY. *AK
Exterior lighting, Mar 31, 2004
IN NOV 2003, OUR 2001 JETTA TDI WOULD NOT SHIFT OUT OF PARK, CAUSING MYSELF AND MY SONS NUMEROUS TIMES TO BE STRANDED. THE PROBLEM WAS INTERMITTENT. AL SANCHEZ VW IN GILROY, CA, DIAGNOSED A SHIFTER PROBLEM AND REPLACED IT. THE PROBLEM PERSISTED. I CONTINUED TO DISCUSS IT WITH AL SANCHEZ VW, EVEN LEAVING IT WITH THEM FOR ONE WEEK TO DRIVE. I WAS TOLD THE PROBLEM WAS INTERMITTENT AND THEY COULD NOT DUPLICATE THE PROBLEM, THERE WAS NOTHING THEY COULD DO. SEVERAL WEEKS AGO, THE PROBLEM AGAIN OCCURRED. I PHONED A TOW COMPANY WHO NOTED THE VEHICLE STUCK IN PARK AND MENTIONED THE BRAKE INVOLVEMENT. AFTER TURNING OFF THE CAR AND FUSSING WITH THE BRAKE/SHIFTER, IT ENGAGED. THE NEXT MORNING, I PHONED AL SANCHEZ AND WAS TOLD THAT IT SHIFTED FINE. LATER THAT DAY, I WAS TOLD THAT IT GOT A LITTLE STICKY.THEY DIAGNOSED THE BRAKE LIGHT SWITCH. I HAVE SPOKE TO SERVICE ADVISORS AND THE SERVICE MANAGER. THEY MAINTAIN THE POSITION THAT THE SHIFTER NEEDED REPLACING IN NOV 2003, AND NOW THE BRAKE LIGHT SWITCH NEEDS REPLACING. I AM OF THE OPINION THAT THE PROBLEM WAS NOT CORRECTED. SINCE THE PROBLEM CONTINUED TO PERSIST, THIS DOES NOT SEEM TO BE AN UNREASONABLE ASSESSMENT. ON 2/21/04, I DOWNLOADED INFO FROM YOUR SIGHT. THERE WERE TWO RECALLS FOR MY CAR. TODAY, 3/31/04, THERE ARE THREE, INCLUDING AN EXTERIOR LIGHTING;BRAKE LIGHTS;SWITCH. I DECIDED TO CHECK THIS SITE TODAY ONLY BECAUSE DURING DURING ONE OF MY MORE RECENT CONVERSATIONS TO NHTSA, I WAS INFORMED THAT THERE WERE THREE RESULTS. I HAVE NOT CONFIRMED IF MY VEHICLE IN ONE INCLUDED IN THIS RECALL. IF MY VIN IS NOT ON THE RECALL LIST, THIS IS TOO MUCH OF A COINCIDENCE TO OVERLOOK. ALSO, THE LACK OF COOPERATION OF AL SANCHEZ VW AND VOLKSWAGON ADVOCATES CANNOT BE OVERLOOKED AS WELL. IDEALLY, I WOULD LIKE THE REPAIR COST OF THE SHIFTER REFUNDED TO ME AND THE RECALL TO COVER MY SHIFTING PROBLEM. *AK
Power train, Mar 24, 2004
I WAS TOLD TODAY BY THE VW DEALERSHIP THAT I NEED A NEW CLUTCH, PRESSURE PLATE, AND FLYWHEEL FOR MY 2001 VW JETTA 1.8T IT ONLY HAS 33,249 MILES ON IT. I HAVE BEEN DRIVING CARS AND P/U TRUCKS WITH CLUTCHES SINCE 1972. I BELIEVE THIS IS A DEFECT IN WORKMANSHIP BY THE VW MANUFACTURER. I WAS TOLD IT WILL COST $1,555.00 IN PARTS AND LABOR. *JB
Power train, Mar 23, 2004
WHILE DRIVING, THE CLUTCH DIED. *PH AFTER BEING TOLD THE REPAIRS WOULD NOT BE COVERED UNDER WARRANTY, THE CONSUMER DID SOME RESEARCH AND DISCOVERED THERE WERE MANY COMPLAINTS OF FAULTY PRESSURE PLATES. *JB
Engine and engine cooling, Mar 23, 2004
MY 2001 VW JETTA BURNS A QUART OF OIL EVERY 600 MILES. THIS PROBLEM OCCURED FROM THE FIRST MOMENTS I OWED THE VEHICLE. I IMMEDIATEDLY REPORTED THIS TO THE DEALER WHO INFORMED ME THAT IT WAS "A CONDITION WITH NEW JETTAS AND WOULD RIGHT ITSELF AFTER I DROVE THE CAR A WHILE." THIS POSITION WAS REPEATED DURING THE "FREE" OIL CHANGES UP TO THE POINT WHERE THE WARRANTY EXPIRED. NOW THAT THE WARRANTY HAS EXPIRED, VW MECHANICS INSISIT THAT THEY HAVE TO DO A $90 DIAGNOSIS TEST BEFORE THEY WILL ADDRESS IT (I HAD A PREVIOUS ONE DURING THE WARRANTY PERIOD THAT FOUND NOTHING). NOW THE CAR IS GETTING OLDER, THE OIL BURING IS GETTING WORSE. I SEARCHED THE INTERNET AND FOUND NUMEROUS JETTA OWNERS WITH THE SAME PROBLEMS, AND EVEN WORSE AS A RESULT - INCLUDING BLOWN ENGINES. ONE JETTA OWNER STATED THAT THERE IS A MANUFACTURING DEFECT WITH THE RINGS OF THE CAR. HE HAD THE CAR'S RINGS REPAIRED (AT A COST OF NEARLY $1,000) AND NOTHING IS NOW WRONG WITH THE CAR. HE ALSO STATED THAT HE FOUND OUT THAT THE DEFECT IMPACTS A SIGNIFICANT PORTION OF THE CARS SOLD IN TWO YEARS, MANAFESTING IN BLOWN CATALITIC CONVERTERS AND ENGINES. HE ALSO STATES THAT VW INSTRUCTED ITS DEALERS TO TELL OWNERS THAT IT IS NORMAL WITH THE CAR DURING THE BREAK-IN PERIOD - THEREBY PUSHING THE PROBLEM PAST THE 28,000 MILE WARRANTY OBLIGATION. WHICH MAKES SENSE SINCE THIS PROBLEM WOULD COST VW MILLIONS. *AK
Power train, Mar 18, 2004
I AM COMPLAINING ABOUT THE CLUTH ON MY 2001 JETTA 1.8T. AT APPROXIMATELY 5100 MILES (MAY 2003) I HAD THE CLUTCH BURN OUT. VW REPLACED IT UNDER WARRANTY. LESS THAN 100 MILES LATER (JUNE 2003) THAT REPLACEMENT CLUTCH BURNT OUT. VW AGAIN REPLACED IT BUT SAID THAT THEY WOULD NOT COVER ANY OTHER PROBLEMS RELATED TO THE CLUTCH. I WAS TOLD THAT THIS HAPPENED BECAUSE MY DAUGHTER DIDN'T KNOW HOW TO DRIVE A MANUAL TRANSMISSION. SHE LEARNED TO DRIVE IN 1996 ON AN OMNI WITH MANUAL TRANSMISSION AND HAS BEEN DRIVING MANUAL TRANSMISSIONS FOR ALL BUT TWO YEARS SINCE THAT TIME. SINCE WE GOT THE VW JETTA OUT OF THE SHOP LAST JUNE I HAVE BEEN THE DRIVER OF THE VEHICLE AND HAD THE CLUTCH BURN OUT AGAIN ON 15 MARCH 2004. I HAVE BEEN DRIVING NUMEROUS VEHICLES IN THE LAST 35 YEARS AND HAVE NEVER BURNT UP A CLUTCH. THE JETTA STILL HAS LESS THAT 12,000 MILES ON IT. THIS MAKES FOR REPLACEMENT OF THE CLUTCH 3 TIMES SINCE I BOUGHT THE VEHICLE NEW IN AUGUST 2001.*AK
Air bags, Mar 17, 2004
WHILE DRIVING 25 MPH DRIVER'S SIDE DOOR AND WINDOW AIR BAGS DEPLOYED INADVERTENTLY. DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND DROVE IT TO THE DEALER FOR INSPECTION. *AK *MR
Power train, Mar 15, 2004
JETTA SUFFERED A FAILURE WHERE THE CLUTCH PLATE SHATTERED AND THE PRESSURE PLATE FAILED. THE CLUTCH PLATE DID NOT SHOW DRASTIC WEAR, THE WEAR LINE ON THE CLUTCH PLATE WERE STILL VISIBALE. VW CONSIDERED THIS NORMAL WEAR AND TEAR. I BELIEVE THAT THE PART WAS DEFECTIVE. *AK
Service brakes, Hydraulic, Mar 15, 2004
READ BRAKE PADS WORE OUT PREMATURLEY. WHEN TAKEN TO THE DEALER FOR SERVICE AND NOTIFIED THEM OF THAT WE HEARD GRINDING AND BOISE IN THE REAR, THEY WERE QUITE SURPRISED. THIS RESULTED IN $283.05 IN PARTS AND LABOR TO REPLACE THE PADS.*AK PARTS 1J0-615-601-C (2) AND 160-698-451-D (1)
Power train, Mar 15, 2004
CLUTCH WENT BAD VERY EARLY IN LIFE OF AUTO. EXPERIENCED MANUAL DRIVER. CLUTCH SEEMED TO GO BAD IN ONE DAY FROM NOTHING WRONG TO CAR NOT DRIVEABLE. VW REPLACED FLYWHEEL WITH UPGRADED PART PROVING THAT OLD PART WAS UNRELIABLE. *AK CAR HAD JUST BEEN IN FOR 40,000 MILE COMPLETE CHECK-UP WITH PASSING COLORS.
Power train, Mar 10, 2004
MY 2001 VW JETTA 1.8T CLUTCH FAILED AFTER JUST 16,000 MILES WITHOUT ANY WARNING. I WAS TOLD IT WAS DUE TO "DRIVER ERROR". HOWEVER, AFTER SOME RESEARCH I HAVE FOUND MANY OTHERS THAT HAVE HAD THE SAME PROBLEM. THE 1.8T CLUTCHES ARE A DUAL-MASS FLYWHEEL (DMF) DESIGN WHICH SEEMS TO BE THE CAUSE OF THE ISSUE. IT SEEMS THEY CANNOT HANDLE THE UPPED POWER/TORQUE OF THE TURBO. THEY ARE KNOWINGLY SELLING A DEFECTIVE PRODUCT AND CHARGING US UPWARDS OF $1300 TO REPAIR IT WITH THE SAME FAULTY PART!*AK
Visibility, Feb 29, 2004
I WAS DRIVING WHEN ALL OF A SUDDEN THE WINDOW ON MY 2001 VW JETTA FELL INSIDE THE DOOR. THE PIECES THAT HELD THE WINDOW UP BROKE. *JB
Structure, Feb 26, 2004
WHILE TRAVELING IN THE LEFT LANE OF THE PA TURNPIKE AT A SPEED OF 65 MPH, THE RIGHT SIDE SEAT AND CURTAIN AIR BAGS DEPLOYED FOR NO REASON AND WITHOUT WARNING. I WAS SAFELY ABLE TO PULL OVER TO THE RIGHT LANE AND THEN OFF TO THE HIGHWAY SINCE THE ENGINE SHUTS DOWN WITH AIR BAG DEPLOYMENT.UPON HAVING THE VEHICLE INSPECTED BY A VW DEALER NO DAMAGE TO THE VEHICLE WAS FOUND. I DID NOT HIT ANY POT HOLE OR ROAD DEBRIS. THERE IS AN OBVIOUS FAULT WITH THE COMPUTER AND/OR SENSOR SYSTEM IN THE VEHICLE. THE VW DEALER CLAIMS TO HAVE HEARD OF NO SUCH OCCURENCE EVENTHOUGH THERE APPEAR TO BE MANY SUCH OCCURENCES AS LISTED ON THIS WEBISTE. VW AMERICA CLAIMS THERE WAS AN IMPACT TO THE RIGHT REAR AXEL WHICH SET OFF THE AIRBAG. AGAIN THERE WAS NO IMPACT AT THE TIME OF DEPLOYMENT. TRAVELING AT THAT SPEED AND IN THE ENVIRONMENT I WAS THERE SHOULD HAVE BEEN MORE DAMAGE TO MY CAR THAN A SCRATCH ON THE REAR AXEL UNDERCARRIAGE. *AK