2005 Volkswagen Jetta
Problems, recalls and owner-reported issues
Power train is the leading concern among 248 owner complaints filed for this model year. This is the 13th highest complaint count among 26 Jetta model years with reports.
Of the 2005 reports, 8 involved a crash and 14 involved a fire. 8 people were injured.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, foundation components, master cylinderSep 23, 2020
Tenneco Automotive (Tenneco) is recalling certain Beck/Arnley Master Cylinders, part number 072-9831, sold as aftermarket or replacement parts for 2004-2018 Volkswagen Jetta, and 2012-2019 Volkswagen Beetle vehicles. The fluid seal crimp on the master cylinder may be insufficient, causing brake fluid to leak or the cylinder to come apart.
If there is a brake fluid leak, it can reduce braking ability, increasing the risk of a crash.
Beck/Arnley will notify the distributors that sold the master cylinders and will work with the distributors to notify the end users. Affected master cylinders will be exchanged for a new master cylinder (part number 072-9990), free of charge. The recall began October 30, 2020. Owners may contact Tenneco customer service at 1-800-625-9319.
Campaign 20E064000 on NHTSA.gov
Engine and engine cooling, engineMar 7, 2014
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
Campaign 14E007000 on NHTSA.gov
Exterior lighting, headlightsSep 24, 2007
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.
NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 07V442000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Exterior lighting, brake lights, switchFeb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 07V063000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsJul 5, 2005
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.5L GASOLINE ENGINE, A FUEL SUPPLY LINE CLAMP LOCATED IN THE ENGINE COMPARTMENT MAY NOT BE POSITIONED PROPERLY AND COULD CAUSE A FUEL LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL INSPECT THE POSITION OF THE ENGINE COMPARTMENT FUEL SUPPLY LINE CLAMP AND, IF NECESSARY, REPLACE THE CLAMP. THE RECALL BEGAN ON JULY 11, 2005. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 05V305000 on NHTSA.gov
Fuel system, dieselDec 15, 2004
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 04V586000 on NHTSA.gov
Representative owner complaints: power train
84 reports, newest first. Show all
Power train, May 19, 2020
TUGGING OCCURS, BUT RARELY. THE CAR DRIVES SMOOTHLY BUT WILL DO A BIT OF A TUGGING. IT HAD THIS PROBLEM FOR A WHILE EVER SINCE IT WAS PURCHASED BACK IN 2015 IT WAS WORSE AT THOSE TIMES BUT FIXED THROUGHOUT THE YEARS. I'VE INVESTED MAJOR MONEY TO GET THE TRANSMISSION, MOTOR, AND SO ON OF WHAT THE MECHANIC HAS TOLD ME OF THE PROBLEMS THE CAR HAS HAD FIXED. *TR
Power train, Electrical system, Fuel/propulsion system, Aug 12, 2019
THE TRANSMISSION IS TERRIBLY MADE. THERE IS ALSO AN ISSUE WITH THE FUEL INJECTION THAT DOES NOT ALLOW THE CAR TO RECEIVE THE CORRECT FUEL AS WELL AS THE GAS TANK. THE CAR JERKS BECAUSE OF THE GAS TANK AND THE CODES READ AD IF THE CAP NEEDS TO BE REPLACED BUT THE WHOLE GAS TANK NEEDS TO BE REPLACED.
Power train, Air bags, Jan 14, 2019
2005 VW.JETTA - VIN# [XXX]. THE TRANSMISSION SHIFTS HARD & DOWN SHIFT HARD WHEN THE CAR HAS RUN FOR A PERIOD OF TIME DURING TRAVEL. ALSO, THE FAULTY AIR BAG LIGHT COMES ON WHEN THE CAR IS FIRST STARTED AND MAY SHOW INTERMITTENTLY WHILE DRIVING. THE CATALYTIC CONVERTER & 02 SENSOR HAVE BEEN REPLACED BUT THE CODES STILL SHOW WHEN PUT ON THE MACHINE. THE IGNITION KEY GETS STUCK IN THE IGNITION. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Power train, Nov 5, 2018
MY CAR HAVES ALL THE GEARS HIGHLIGHTED ON THE DISPLAY AND OCCASIONALLY WHEN I'M DRIVING IT GETS STUCK ON A LOW GEAR WHEN I COME TO A COMPLETE STOP AND TRY TO START GOING OR IF IM IN THE HIGHWAY IT ALL OF A SUDDEN DECIDES TO SHIFT TO NEUTRAL GEAR MAKING ME SLOW DOWN ALL OF A SUDDEN WITH POTENTIAL TO HIT THE PERSON BEHIND ME OR CREATING A CATASTROPHIC ACCIDENT WITH MANY INJURIES OR EVEN DEATH TO DOES I MIGHT HIT JUST BECAUSE OF MY FAULTY TRANSMISSION AND I HAVE LOOK UP THE PROBLEM AND THERE ARE MANY PEOPLE WITH THE SAME TRANSMISSION TROUBLE THE NHTSA SEND A RECALL FOR THE 2009-2010 BUT THE PREVIOUS MODELS HAVE ALSO THE SAME PROBLEMS FOR IT SO PLEASE AT LEAST OPEN AN INVESTIGATION ABOUT IT SO THAT WAY ME AND MY FELLOW DRIVERS UNDERSTAND THE PROBLEM THAT KEEPS GOING ON.
Power train, Vehicle speed control, May 25, 2018
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. WHILE DRIVING 65 MPH, THE VEHICLE DID NOT ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE HAD TO BE TURNED OFF AND RESTARTED TO REMEDY THE FAILURE. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 279,000. THE VIN WAS NOT AVAILABLE. *TT CONSUMER STATED INCIDENT HAPPENS WHEN DRIVING IN THE RAIN.*JB
Power train, Mar 5, 2017
AXLE BOLTS WORKED LOOSE AND AXLE PUNCTURED TRANSMISSION HOUSING ON DRIVERS SIDE WITH OUT WARNING.
Power train, Dec 15, 2015
WE HAVE A 2005.5 VW JETTA AND HAVE BEEN EXPERIENCING HARD SHIFTING WHILE DRIVING FOR ABOUT A YEAR AND HALF . MORE RECENTLY THE GEARS ARE STALLING TO SHIFT WE WERE DRIVING IN A LOCAL STREET WHEN OUR CAR WOULD NOT SHIFT INTO 4TH GEAR THE ENGINE WOULD REV BUT WOULD NOT SHIFT. IT IS VERY UNSAFE FOR THIS TO HAPPEN WHEN YOU ARE ON BUSY ROADS OR MERGING ON TO HIGHWAYS ETC. WE HAVE NOT USED OUR CAR SINCE AND OUR MECHANIC TOLD US IT WAS U SAFE TO DRIVE. I CAN'T BELIEVE VW HAS NOT TAKEN OWNERSHIP FOR THERE MISTAKE AND MAKE A RECALL. OUR CAR JUST PASSED 100,000K AND SHOULD NOT BE HAVING THIS PROBLEM . TO FIX THE PROBLEM WE WERE TOLD ITS THE VALVE BODY AND THE PART ITSELF IS $1,200 NOT INCLUDING LABOR COST.
Power train, Jul 15, 2015
I HAVE AN EARLY MODEL MKV TDI JETTA , WITH AROUND 87,000 MILES ON IT. YESTERDAY, ON THE WAY HOME, THE DSG DUAL MASS FLYWHEEL LET GO WITH PIECES OF METAL COMING OUT ONTO THE ROAD AND TRAFFIC. I LOOKED UP THIS ON THE TDICLUB SITE AND FOUND NUMEROUS ISSUES WITH THIS PART IN EARLY PRODUCTION, WHICH IS NOT PART OF MAINTENANCE. IS THERE A SAFETY RECALL OR OTHER TSB ON THIS? I CANT DRIVE THE CAR AND JUST MADE IT HOME. IT WAS SCAREY.
Power train, Apr 20, 2015
THE REASON FOR THE LATE POST IS THAT I JUST DISCOVERED THIS SITE. I PURCHASED MY 2005 VW JETTA BRAND NEW IN 2005. IT HAD 61 MILES ON IT. I HAD THE CAR FOR ABOUT 5 MONTHS WHEN IT WAS SHIFTING VERY HARD AND NEARLY SNAPPING MY NECK. I TOOK THE VEHICLE TO THE VW DEALERSHIP OVER 30 TIMES WITHIN A YEARS TIME AND THEY CONTINUED TO TELL ME NOTHING WAS WRONG. THEY KEPT THE CAR AND DROVE IT AND IT OF COURSE IT WOULD NOT HAPPEN WHILE THEY DROVE IT. THEY ACTUALLY TOLD ME I WAS DRIVING THE CAR INCORRECTLY (WHAT THAT MEANS I DON'T KNOW). I WAS UNAWARE OF THE LEMON LAW AT THE TIME. THE CAR CONTINUED TO SHIFT EXTREMELY HARD. FINALLY AFTER IT WENT BACK FOR THE 30TH TIME I DEMANDED THAT THEY KEEP THE CAR AND DRIVE IT UNTIL IT HAPPENED. FINALLY AFTER 2 WEEKS (THEY ACTUALLY GAVE ME A LOANER) THE MECHANIC CALLED ME STATING THAT IT NEARLY SNAPPED HIS NECK AND THAT THEY WOULD PUT IN A NEW TRANSMISSION (REBUILT MIND YOU). AFTER GETTING IT BACK ABOUT 2 WEEKS LATER THE CAR WOULD NOT GO IN REVERSE AND WAS MAKING THE WORST NOISE EVER BUT I CONTINUED TO DRIVE IT TO THE DEALERSHIP. THEY HAD TO REPLACE THE TRANSMISSION ONCE AGAIN (ANOTHER REBUILT TRANSMISSION). THE OTHER ISSUE I HAD WAS THE LOCKS ON THE CAR. SOME OF THE DOORS LOCK WITH THE KEY FOB WHILE THE BACK DOORS DON'T WORK WITH THE FOB OR THE SWITCH ON THE DOOR PANEL. THIS IS FRUSTRATING WHEN YOU HAVE CHILDREN AND NEED TO LOCK AND UNLOCK THE CAR AND GET THEM IN AND OUT. *TR
Power train, Jan 9, 2015
THERE IS A PROBLEM WITH TRANSMISSION OF JETTAS ONCE I WAS ON THE HIGHWAY AND MY VEHICLE STALLED I WAS LUCKY AS THERE WERE NO VEHICLE BEHIND ME OTHER WISE THAT WOULD HAVE BEEN A CATASTROPHIC SITUATION FOR BOTH ME AND THE DRIVER BEHIND ME. I PULL OVER THE SHOULDER AND WAITED AND STARTED THE VEHICLE I WAS ABLE TO DRIVE AFTER SOME TIME. THIS IS A KNOWN ISSUE FOR ALL THE JETTAS VOLKSWAGEN KNOWS ABOUT THIS AND THEY EXTENDED THE WARRANTY FOR SOMETIME. THIS PROBLEM WITH TRANSMISSION VALVE BODY HAPPENS AFTER CERTAIN MILES. I AM OUT OF THIS COVERAGE AND THIS IS A SAFETY ISSUE AND I WOULD REQUEST THAT THERE SHOULD BE A SAFETY RECALL SO THAT THIS SHOULD NOT HAPPEN WITH ANY ONE ELSE. PLEASE TAKE ACTION AS SOON AS POSSIBLE. *TR
Power train, Dec 16, 2014
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 93,000.
Power train, Nov 18, 2014
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE FAILED TO SHIFT GEARS. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE VALVE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 76,500.
Power train, Nov 8, 2014
I BOUGHT THE CAR IN MARCH OF 2012 AND ON THE WAY HOME I NOTICED THAT THE CAR WASN'T SHIFTING AT THE APPROPRIATE TIMES AND THERE WAS A TRANSMISSION ISSUE. AFTER I GOT HOME I CALLED THE DEALER AND ASK THEM OF THE CAR HAD ANY PREVIOUS ISSUES WITH THE TRANSMISSION, HE SAID NO AND NATURALLY I HAD TO REPLACE THE TRANSMISSION THAT WAS COMPATIBLE. 2 YEARS LATER I AM NOW HAVING THE SAME ISSUE WITH THE CAR AND I DID RESEARCH AND NOTICED I AM NOT THE ONLY ONE THERE ARE HUNDREDS OF PEOPLE I HAVE MY CAR AND ARE HAVING THE SAME EXACT ISSUE I AM. THAT BEING SAID THIS ISN'T A COINCIDENCE AND I AM IN THE SAME SITUATION I WASN'T TWO YEARS AGO HAVING TO PAY $1200 FOR A FIXED OR A NEW TRANSMISSION. THE REASON I KNOW THIS IS WHEN THE CAR IS IN FIRST IT DOESN'T WANT TO SHIFT TO SECOND AND HAS A BUMP AT EVERY OTHER GEAR.IF IT WAS JUST ME I WOULD UNDERSTAND BUT THERE ARE MULTIPLE FORUMS THIS ISSUE HAS CAUSED PEOPLE. I CAN'T TELL YOU HOW TO DISSATISFIED I AM ABOUT THIS BECAUSE I LOVE MY CAR AND I CAN'T KEEP AFFORDING TO REPLACE THE TRANSMISSION. I HOPE THIS CAN BE FIXED IN THE FAVOR OF THE HUNDREDS OF PEOPLE EXPERIENCING THIS THANK YOU. *TR
Power train, Oct 10, 2014
I HAVE BEEN HAVING ISSUES ON MY 2005.5 VW JETTA FOR THE LAST SEVERAL MONTHS WITH IT SHIFTING HARD OR NOT GOING INTO GEAR. IT HAPPENS EVERY TIME THE CAR IS DRIVEN, SO MUCH TO THE POINT THAT I WILL NOT LET MY DAUGHTER OR WIFE DRIVE THE CAR AS I DO NOT FEEL IT IS SAFE FOR THEM. THEY HAVE BEEN STUCK IN THE MIDDLE OF THE ROAD AND THE CAR WOULD JUST SIT THERE AND REV, BUT NEVER ENGAGE IN DRIVE OR IT WOULD SHIFT SO HARD THAT THEY FELT LIKE THEY HAD WHIPLASH. I TOOK IT TO A REPAIR SHOP AND THEY TOLD ME IT NEEDS A NEW TRANSMISSION WITH THE PRICE SOMEWHERE BETWEEN $3-5K, PROBABLE CLOSE TO $7K IF YOU GO TO THE DEALER. AFTER DOING SOME RESEARCH ONLINE, IT APPEARS THIS IS A COMMON ISSUE AND VW IS AWARE OF THE PROBLEM, BUT SO FAR NOT WILLING TO DO SOMETHING ABOUT IT. IT IS A SAFETY ISSUE AND SHOULD NOT TAKE A PERSON DYING FOR THEM TO CORRECT THE ISSUE. I HAVE BEEN A LOYAL VW OWNER FOR YEARS, BUT AM NOT WILLING TO RISK THE LIFE OF MY FAMILY FOR A COMPANY WHO DOES NOT CARE ABOUT THEIR CONSUMERS. THIS IS AN ISSUE THAT NEEDS TO BE ADDRESSED IMMEDIATELY. *TR
Power train, Jun 19, 2014
I BROUGHT MY CAR IN FOR AN EARLY 65K MILE SERVICE BECAUSE I NOTICED MY TRANSMISSION WAS NOT SHIFTING PROPERLY & WAS GETTING PROGRESSIVELY WORSE. I THOUGHT HAVING THE 85K SERVICE DONE WOULD TAKE CARE OF THAT, IT DIDN'T & IT GOT WORSE, SO I BROUGHT IT BACK TO THE DEALER. THE DEALER INDICATED THAT THE VALVE BODY WAS FAULTY & THAT IT WOULD COST $1000+ TO FIX. I JUST PAID OVER $1000 FOR THE K MAINTENANCE & OTHER REPAIRS; I CAN'T AFFORD THE ADDITIONAL EXPENSE. [XXX], IN THE SERVICE DEPARTMENT, STATED THAT THE ISSUE WAS ??NOT THAT BAD, ...THAT THEY SEE MUCH WORSE, ?WON'T BE A PROBLEM TO KEEP DRIVING IT...?. I WASN'T CONVINCED THAT A MALFUNCTIONING VALVE BODY WOULDN'T CAUSE ADDITIONAL PROBLEMS, BECAUSE WHEN I AM DRIVING IT FEELS LIKE THE TRANSMISSION IS ABOUT TO DROP OUT OF THE CAR & THE CAR HESITATES TO THE POINT THAT IT IS NOT SAFE! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Power train, May 16, 2014
I WAS DRIVING ON THE FREEWAY WHEN AN ACCIDENT IN FRONT OF ME CAUSED ME TO ABRUPTLY STOP. IN ORDER FOR ME TO BACK UP AND GO AROUND, I HAD TO GET OUT THE VEHICLE AND PUSH IT BACKWARDS DURING RUSH HOUR TRAFFIC. *TR
Power train, Engine, Feb 1, 2014
THE CAR WOULD BUCK AND BUCK THEN GO INTO GEAR , THEN IT WOULD BUCK GET STUCK IN 3RD OR 4TH GEAR I WOULD HAVE TO TURN THE CAR OFF LET IT SIT THEN TURN IT BACK ON . THE PRNDS PANEL WOULD ALL LIGHT UP AND STAY ON AND SOMETIMES GO OFF IF THE CAR SAT FOR LIKE 2-3 DAYS BUT THE LIGHT WOULD STAY ON AND THE CAR WOULD DO THE SAME THING . THE TRANSMISSION WENT OUT THE MECHANIC STATED THE 3RD OR 4TH GEAR WAS STRIPPED AND THAT IT WILL COST ME ANYWHERE FROM 4K TO7K TO GET IT FIXED. *TR
Power train, Dec 22, 2013
I HAVE A VW JETTA 2005 THAT HAS THE 2.5 ENGINE. FOR THE LAST THREE MONTHS, THE AUTOMATIC TRANSMISSION HAS STARTED SHIFTING GEARS BY ITSELF IN HARD SHIFTS, MOSTLY FROM 1ST TO 2ND AT ODD TIMES. I WAS TOLD THIS WAS A KNOWN PROBLEM IN THE VWS AND REQUIRED A TRANSMISSION REBUILD. (I'VE HEARD THAT A NUMBER OF TIME). I HAD TO HAVE THE TRANSMISSION REBUILT AT A COST OF $4,000 TO END THE PROBLEM. *TR
Power train, Dec 18, 2013
I WROTE TO YOU ABOUT A MONTH AGO ABOUT RECALLING THE 2005 JETTA. NOTHING CAME OUT OF IT. IT IS MY FIRM BELIEF THAT THERE IS SOMETHING WRONG WITH THE TRANSMISSION. GOOGLE THE PROBLEMS WITH THE 2005 JETTA AND YOU WILL SEE TONS ABOUT COMPLAINTS REGARDING THEIR TRANSMISSION WOES. PLEASE BE OBJECTIVE IN YOUR INVESTIGATION. *TR
Power train, Nov 5, 2013
WE BOUGHT THIS CAR FROM A FIRST OWNER IN 2010 FOR MY DAUGHTER WHO WAS THEN A SENIOR AT UC DAVIS. NO PROBLEM FOR THE FIRST 2 YEARS BUT 2013 SEEMS TO BE THE BEGINNING OF SOME PROBLEMS. THE MOST MAJOR ONE IS THE TRANSMISSION. THERE IS A SLIPPAGE ON 2ND, 3RD, AND 4TH GEARS. THERE IS A JOLT ACCOMPANYING THE SLIPPAGE AND IF THERE IS A BABY ONBOARD, I PROBABLY FEEL THE BABY WILL BE SUFFERING SOME KIND OF PAIN. CHECKED THE INTERNET FOR SIMILAR COMPLAINTS FROM OWNERS OF THE SAME MODEL AND SEEMS THIS IS A COMMON PROBLEM WITH THE 2005 JETTA BUT THERE WAS NO RECALL. PLEASE INVESTIGATE. *TR
Power train, Oct 14, 2013
07/22/13 I BROUGHT MY CAR IN FOR AN EARLY 100K MILE SERVICE BECAUSE I NOTICED MY TRANSMISSION WAS NOT SHIFTING PROPERLY & WAS GETTING PROGRESSIVELY WORSE. I THOUGHT HAVING THE 100K SERVICE DONE WOULD TAKE CARE OF THAT, IT DIDN'T & IT GOT WORSE, SO I BROUGHT IT BACK TO THE DEALER. THE DEALER INDICATED THAT THE VALVE BODY WAS FAULTY & THAT IT WOULD COST $1000+ TO FIX. I JUST PAID OVER $1000 FOR THE 100K MAINTENANCE & OTHER REPAIRS; I CAN'T AFFORD THE ADDITIONAL EXPENSE. [XXX], IN THE SERVICE DEPARTMENT, STATED THAT THE ISSUE WAS ??NOT THAT BAD, ...THAT THEY SEE MUCH WORSE, ?WON'T BE A PROBLEM TO KEEP DRIVING IT...?. I WASN'T CONVINCED THAT A MALFUNCTIONING VALVE BODY WOULDN'T CAUSE ADDITIONAL PROBLEMS, BECAUSE WHEN I AM DRIVING IT FEELS LIKE THE TRANSMISSION IS ABOUT TO DROP OUT OF THE CAR & THE CAR HESITATES TO THE POINT THAT IT IS NOT SAFE! I DID SOME RESEARCH, FOUND THAT THERE WAS AN EXTENDED WARRANTY ON THE VALVE BODY, HOWEVER, I NEVER RECEIVED ANY NOTIFICATION IN ANYWAY REGARDING THIS, EVEN WHEN MY CAR HAD BEEN IN FOR SERVICE. I CONTACTED VW HEADQUARTERS & SPOKE TO [XXX] 8/30/13 WHO INDICATED THAT THERE WAS AN EXTENDED WARRANTY ON THE VALVE BODY, APOLOGIZED THAT I DIDN'T RECEIVED NOTIFICATION, THEN INDICATED THAT VW COULD NOT HELP ME. THIS IS A SAFETY ISSUE & SHOULD BE COVERED BY VW. PLEASE HAVE SOMEONE CONTACT ME. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Power train, Electrical system, Vehicle speed control, Aug 6, 2013
2005.5 JETTA--VEHICLE HAS ROUGH SHIFTING BETWEEN 2ND AND 3RD GEARS. AS WELL AS DOWNSHIFTING. WHILE DRIVING ON A MOUNTAINSIDE, GOING 65 MPH, THE CAR SUDDENLY DOWNSHIFTED TO 3RD GEAR AND WOULD NOT ACCELERATE. I HAD TO PULL OVER ON THE SIDE OF A MOUNTAIN, WITH CARS FLYING BY ME. THE CAR WOULD NOT SHIFT GEARS UNTIL TURNED OFF AND ON AGAIN. THIS IS NOW HAPPENING DURING REGULAR ACCELERATION AT LOW SPEEDS. THIS IS A HUGE SAFETY CONCERN, AS I COULD HAVE BEEN REAR ENDED BY ANOTHER VEHICLE DUE TO LOSS OF POWER/SPEED. *TR
Power train, Apr 4, 2013
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE LOST ACCELERATION POWER WHILE ATTEMPTING TO MERGE INTO HIGHWAY TRAFFIC. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE TRANSMISSION VALVE BODY HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 86,000.
Power train, Engine, Fuel/propulsion system, Mar 18, 2013
MY 2005 VW JETTA GLI STALLED SUDDENLY WHILE I WAS DRIVING @ 35-MPH. AFTER PULLING OVER AND OPENING THE HOOD TO ASSESS DAMAGE, I TURNED THE IGNITION KEY BUT ALL I HEARD WAS THE STARTER BEING ENGAGED. ONCE THE CAR WAS TOWED TO AN INDEPENDENT REPAIR SHOP, THE TECHNICIAN INFORMED ME THE TIMING BELT BROKE/SNAPPED. I WAS SKEPTICAL BECAUSE MY OWNER'S MANUAL SAYS TIMING BELTS SHOULD BE REPLACED AT 110,000 MILES ACCORDING TO VW'S RECOMMENDED MAINTENANCE SCHEDULE. DURING REPAIRS, THE TECHNICIAN SAID THAT MY VALVES WERE BENT BECAUSE THE 1.8T IS AN INTERFERENCE ENGINE WHICH MEANS THAT CAMS, ROCKERS AND LIFTERS MUST BE REMOVED IN ORDER FOR THE CYLINDER HEAD TO BE SENT TO A MACHINE SHOP FOR ADDITIONAL REPAIRS. TOTAL COSTS = $3,865.66. THERE WAS A CLASS ACTION LAWSUIT AGAINST VW TIMING BELTS BUT I WAS DENIED REIMBURSEMENT BY THE ADMINISTER/CUSTODIAN CLAIMS WERE NO LONGER ACCEPTED AFTER 2009. I SPOKE WITH [XXX] AT VW CUSTOMER SERVICE 1-800-822-8987 WHO SAID THERE ARE NO TIMING BELT RECALLS FOR MY VEHICLE. PLEASE INVESTIGATE THIS CONCERN AND SEE OTHER IDENTICAL COMPLAINTS AT HTTP://WWW.TOPIX.COM/FORUM/AUTOS/VOLKSWAGEN/T33RHDPDVBRPO8D2P/P3 FOR MORE INFORMATION. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Power train, Structure, Jan 31, 2013
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CONTACT STATED THAT SHE NOTICED THE TRUNK FAILED TO CLOSE. THE CONTACT HAD TO SLAM THE TRUNK SEVERAL TIMES IN ORDER FOR IT TO CLOSE PROPERLY. ADDITIONALLY, THE FRONT DRIVER SIDE DOOR FAILED TO LOCK AND THE OPEN DOOR WARNING LIGHT ILLUMINATED CONSTANTLY. THE CONTACT ALSO STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE JERKED FORWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 80,375. ... UPDATED 02/28/13 *BF UPDATED 03/11/13