2005 Volkswagen Jetta
Problems, recalls and owner-reported issues
Power train is the leading concern among 248 owner complaints filed for this model year. This is the 13th highest complaint count among 26 Jetta model years with reports.
Of the 2005 reports, 8 involved a crash and 14 involved a fire. 8 people were injured.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, foundation components, master cylinderSep 23, 2020
Tenneco Automotive (Tenneco) is recalling certain Beck/Arnley Master Cylinders, part number 072-9831, sold as aftermarket or replacement parts for 2004-2018 Volkswagen Jetta, and 2012-2019 Volkswagen Beetle vehicles. The fluid seal crimp on the master cylinder may be insufficient, causing brake fluid to leak or the cylinder to come apart.
If there is a brake fluid leak, it can reduce braking ability, increasing the risk of a crash.
Beck/Arnley will notify the distributors that sold the master cylinders and will work with the distributors to notify the end users. Affected master cylinders will be exchanged for a new master cylinder (part number 072-9990), free of charge. The recall began October 30, 2020. Owners may contact Tenneco customer service at 1-800-625-9319.
Campaign 20E064000 on NHTSA.gov
Engine and engine cooling, engineMar 7, 2014
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
Campaign 14E007000 on NHTSA.gov
Exterior lighting, headlightsSep 24, 2007
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.
NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 07V442000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Exterior lighting, brake lights, switchFeb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 07V063000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsJul 5, 2005
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.5L GASOLINE ENGINE, A FUEL SUPPLY LINE CLAMP LOCATED IN THE ENGINE COMPARTMENT MAY NOT BE POSITIONED PROPERLY AND COULD CAUSE A FUEL LEAK.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL INSPECT THE POSITION OF THE ENGINE COMPARTMENT FUEL SUPPLY LINE CLAMP AND, IF NECESSARY, REPLACE THE CLAMP. THE RECALL BEGAN ON JULY 11, 2005. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 05V305000 on NHTSA.gov
Fuel system, dieselDec 15, 2004
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 04V586000 on NHTSA.gov
Representative owner complaints
248 reports, newest first.
Power train, Apr 4, 2013
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE LOST ACCELERATION POWER WHILE ATTEMPTING TO MERGE INTO HIGHWAY TRAFFIC. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE TRANSMISSION VALVE BODY HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 86,000.
Electrical system, Structure, Apr 3, 2013
SWITCHES IN THE DRIVER'S DOOR HAVE BECOME GRADUALLY (AND INTERMITTENTLY) INCREASINGLY INOPERABLE. DOOR LOCK/UNLOCK, WINDOWS UP/DOWN, WINDOW LOCK, SIDE-VIEW MIRROR ADJUSTMENT, AND TRUNK RELEASE ALL HAVE STOPPED WORKING EITHER ENTIRELY OR INTERMITTENTLY. THE MAJOR SAFETY RELATED ISSUES ARE: 1. NON-FUNCTIONAL SWITCHES ARE A DISTRACTION WHILE DRIVING - CAN'T CLOSE WINDOW AT TOOL BOOTH, ETC. 2. THE INABILITY TO ADJUST SIDE-VIEW MIRRORS. 3. THE INABILITY TO LOCK REAR WINDOWS COMBINED WITH HAVING SMALL CHILDREN RIDING IN THE BACK SEAT. 4. THE INABILITY TO UNLOCK REAR DOORS (WITHOUT USING THE KEYLESS REMOTE - ONE OF WHICH HAS ALSO STOPPED WORKING) TO GET TO THE KIDS IN THE BACK IS A CHALLENGE AND POTENTIALLY HAZARDOUS. 5. THE DOOR SWITCH THAT INDICATES TO THE ON-BOARD COMPUTER WHEN THE DOOR IS OPEN OR CLOSED ALSO IS NOT FUNCTIONAL, CAUSING NIGHTTIME LIGHTING ISSUES WHEN PARKED AND OPENING DOOR. *TR
Power train, Engine, Fuel/propulsion system, Mar 18, 2013
MY 2005 VW JETTA GLI STALLED SUDDENLY WHILE I WAS DRIVING @ 35-MPH. AFTER PULLING OVER AND OPENING THE HOOD TO ASSESS DAMAGE, I TURNED THE IGNITION KEY BUT ALL I HEARD WAS THE STARTER BEING ENGAGED. ONCE THE CAR WAS TOWED TO AN INDEPENDENT REPAIR SHOP, THE TECHNICIAN INFORMED ME THE TIMING BELT BROKE/SNAPPED. I WAS SKEPTICAL BECAUSE MY OWNER'S MANUAL SAYS TIMING BELTS SHOULD BE REPLACED AT 110,000 MILES ACCORDING TO VW'S RECOMMENDED MAINTENANCE SCHEDULE. DURING REPAIRS, THE TECHNICIAN SAID THAT MY VALVES WERE BENT BECAUSE THE 1.8T IS AN INTERFERENCE ENGINE WHICH MEANS THAT CAMS, ROCKERS AND LIFTERS MUST BE REMOVED IN ORDER FOR THE CYLINDER HEAD TO BE SENT TO A MACHINE SHOP FOR ADDITIONAL REPAIRS. TOTAL COSTS = $3,865.66. THERE WAS A CLASS ACTION LAWSUIT AGAINST VW TIMING BELTS BUT I WAS DENIED REIMBURSEMENT BY THE ADMINISTER/CUSTODIAN CLAIMS WERE NO LONGER ACCEPTED AFTER 2009. I SPOKE WITH [XXX] AT VW CUSTOMER SERVICE 1-800-822-8987 WHO SAID THERE ARE NO TIMING BELT RECALLS FOR MY VEHICLE. PLEASE INVESTIGATE THIS CONCERN AND SEE OTHER IDENTICAL COMPLAINTS AT HTTP://WWW.TOPIX.COM/FORUM/AUTOS/VOLKSWAGEN/T33RHDPDVBRPO8D2P/P3 FOR MORE INFORMATION. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Power train, Structure, Jan 31, 2013
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CONTACT STATED THAT SHE NOTICED THE TRUNK FAILED TO CLOSE. THE CONTACT HAD TO SLAM THE TRUNK SEVERAL TIMES IN ORDER FOR IT TO CLOSE PROPERLY. ADDITIONALLY, THE FRONT DRIVER SIDE DOOR FAILED TO LOCK AND THE OPEN DOOR WARNING LIGHT ILLUMINATED CONSTANTLY. THE CONTACT ALSO STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE JERKED FORWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 80,375. ... UPDATED 02/28/13 *BF UPDATED 03/11/13
Power train, Electrical system, Engine, Jan 9, 2013
HI, SO MY 2005.5 2.5L VOLKSWAGEN JETTA STARTED MAKING NOISES UPON ACCELERATION AND THE ENGINE WOULD SHIFT QUITE HEAVILY DURING IDLING. THE CHECK ENGINE LIGHT WENT ON AND I TOOK THE CAR TO DEALERSHIP. APPARENTLY, THERE IS AN ISSUE WITH THE TIMING CHAINS OF THE ENGINE. NEVER MISSED A MAINTENANCE, AFTER ONLY 68,000 MILES IT DOESN'T SEEM OKAY THAT TIMING CHAINS ARE ALREADY AFFECTED. AFTER LOOKING AT A FEW FORUMS ONLINE, IT SEEMS THAT THIS IS A VERY COMMON PROBLEM FOR VOLKSWAGEN JETTAS FROM THAT TIME. PLEASE INVESTIGATE! THANK YOU. *TR
Electrical system, Latches/locks/linkages, Jan 5, 2013
DOOR LOCKS INTERMITTENTLY FAIL TO LOCK OR UNLOCK, EITHER BY THE KEY FOB BUTTON OR DOOR PANEL LOCK/UNLOCK SWITCH. I BELIEVE THIS IS A SAFETY ISSUE AS IT MAY IMPEDE ACCESS TO THE VEHICLE IN THE EVENT OF AN ACCIDENT. *TR
Structure, Visibility/wiper, Dec 14, 2012
FOR CLARIFICATION, MY CAR IS A MARK 5 2005.5 NEW JETTA, NOT A MARK 4 2005 JETTA. WHEN YOU SHUT THE TRUNK, IT SEEMS TO CLOSE COMPLETELY. IT STAYS IN THE CLOSED POSITION AND CANNOT BE PULLED OPEN. HOWEVER, ONCE YOU DRIVE OFF, THE TRUNK MAY OPEN SUDDENLY AND YOU CANNOT SEE ANYTHING BEHIND YOURSELF BECAUSE THE TRUNK HOOD OBSTRUCT YOUR REAR WINDOW. THIS HAS HAPPENED A COUPLE OF TIMES TO ME, AND MANY OTHER JETTA OWNERS CAN BE SEEN SAYING THAT THEY HAVE THE SAME PROBLEM ON ONLINE FORUMS. SOMETIMES, THE TRUNK CANNOT BE CLOSED AT ALL. YOU CAN STAND THERE AND SHUT THE TRUNK OVER AND OVER AGAIN, AND IT WILL NOT LATCH. *TR
Power train, Dec 5, 2012
TRANSMISSION FAILS TO ENGAGE INTO THIRD GEAR, THEN ENGINE REVS UP, THEN SLAMS INTO GEAR. TRANSMISSION STAYS IN THIRD GEAR REGARDLESS OF SPEED. TRANSMISSION STAYS IN FIFTH GEAR REGARDLESS OF SPEED. *TR
Engine, Nov 26, 2012
CHECK ENGINE LIGHT CAME ON IN THE MORNING. NOTICED ROUGH IDLE AND POOR ACCELERATION ON MY MORNING COMMUTE. CHECK ENGINE LIGHT WAS ON FOR MISFIRES ON CYLINDERS 2 - 5. TOOK THE CAR INTO THE DEALERSHIP THAT EVENING. DEALERSHIP PERFORMED $900 OF REPAIRS ON THE CAR AND THEN DECLARED THAT THE TIMING CHAIN HAD STRETCHED, CAUSING THE MISFIRES). THIS ISSUE OCCURRED SUDDENLY AND WOULD HAVE BEEN VERY DANGEROUS HAD IT OCCURRED ON A HIGHWAY, INSTEAD OF SURFACE STREETS. THIS APPEARS TO BE A COMMON ISSUE WITH 2005/2006 JETTAS (DOCUMENTED AT: HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?5457990-CLASS-ACTION-AGAINST-VW-FOR-TIMING-CHAIN-PROBLEM AS WELL AS MANY OTHER FORUMS). I STRONGLY BELIEVE THAT THIS SHOULD BE RECALLED. VOLKSWAGEN CUSTOMER CARE OFFERED NO ASSISTANCE SINCE THE VEHICLE IS 16,000 MILES OUT OF WARRANTY. A TIMING CHAIN FAILING AT 76,000 MILES IS COMPLETELY UNACCEPTABLE AND IS NOT LISTED WITH A SERVICE INTERVAL PER THE OWNERS MANUAL (LATER ADDED AT 105K MILES ON NEWER CARS). VEHICLE FAILED JUST UNDER 76,000 MILES. *TR
Power train, Electrical system, Nov 13, 2012
I PURCHASED THIS CAR FROM A DEALERSHIP ON 10-8-2012 UP IN THE WASHINGTON, D.C. AREA AND DROVE IT BACK HOME TO MY HOUSE IN SC. EVERYTHING WAS FINE ON THE WAY HOME. THE VERY NEXT DAY ON MY WAY INTO WORK THE CAR HESITATED WHEN IT WAS SUPPOSED TO SHIFT FROM 3RD GEAR TO 4TH GEAR AND THEN SUDDENLY DOWNSHIFTED ALL THE WAY BACK TO 1ST GEAR WHICH MADE THE CAR DE-ACCELERATE FROM 35-40MPH TO 10MPH WITHIN 40 FEET OR SO. THE ENGINE REVVED TO 6000 PLUS RPMS WHICH SCARED ME BUT NOT AS MUCH AS THE BIG TRUCK THAT WAS TOWING A TRAILER THAT HAD TO SKID OFF THE ROAD AND GO AROUND ME TO AVOID AN ACCIDENT. THIS IS NOW A DAILY OCCURRENCE. I CARRY MY 16 MONTH OLD DAUGHTER AROUND IN THIS CAR AND I'M SCARED TO DEATH THAT SOMEONE IS GOING TO SMASH INTO THE BACK OF US. I'VE STARTED PULLING OFF THE ROAD AND LETTING CARS GO TO AVOID ACCIDENTS. PLEASE HELP! *TR
Electrical system, Air bags, Oct 5, 2012
A FEW WEEKS AGO, I WENT TO START MY CAR AND ALL THE LIGHTS WERE FLASHING AND CAR DIDN'T START. JUMPED THE BATTERY, GOT THE CAR RUNNING; BUT EVER SINCE MY AIR BAG LIGHT HAS STAYED ON AND THE DRIVER'S WINDOW IS SLOW, THE AUTO UP/DOWN FEATURE NOT WORKING, AND IF THE DRIVER DOOR IS OPEN, I CAN'T POP TRUNK OR GAS LID OR ROLL DOWN ANY OF THE WINDOWS. MY CAR IS NO LONGER UNDER WARRANTY, SO IT'S GOING TO BE VERY EXPENSIVE TO FIX THE MULTIPLE ISSUES. *TR
Service brakes, Sep 6, 2012
ABS CONTROL MODULE DOES NOT ALLOW BRAKES TO FULLY ENGAGE. *TR
Power train, Aug 20, 2012
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
Engine, Aug 14, 2012
I TRIED TO PULL ACROSS A BUSY INTERSECTION AND THE ENGINE DIED. IT WAS BUCKING AND KEPT STALLING OUT WHEN I TRIED TO MOVE THE CAR ACROSS TO GET OUT OF ON COMING TRAFFIC. *TR
Engine, Jul 25, 2012
AT ROUGHLY 7500 MILES MY CHECK ENGINE LIGHT CAME ON. BROUGHT IT TO DEALERSHIP TO CHECK OUT. FOUND OUT THAT THE TIMING CHAIN HAD JUMPED, OR STRETCHED, RESULTING IN POOR IDLE AND A $2700 ESTIMATE TO REPAIR. LOOKED IF OTHER PEOPLE HAD THIS ISSUE. TIMING CHAIN SHOULD LAST 2-3 TIMES LONGER. SINCE I'M OUT OF WARRANTY PERIOD I AM OUT OF LUCK. TIMING CHAIN SHOULD LAST THE LIFETIME OF THE ENGINE NOT TO FAIL AROUND 75000 AND I CHECKED THE OTHER COMPLAINT AND IT LOOKED LIKE ALOT OF OTHER 05 TO 06 OWNERS HAS THE SAME ISSUE . *TR
Engine, Jul 17, 2012
CAR HAS THROWN A CEL OF P0016. TIMING CHAIN TENSIONER IS SHOT AND NEEDS TO BE REPLACED ALONG WITH CHAINS, GUIDES, AND POSSIBLE VALVES. THIS IS A PROBLEM WITH 2005.5 AND 2006 JETTA 2.5 ENGINES. *TR
Electrical system, Jul 12, 2012
WINDOWS, DOOR LOCKS, TRUNK AND FUEL DOOR RELEASE AND AIRBAGS NON-FUNCTIONING DUE TO WIRING HARNESS LOCATED IN DRIVERS DOOR. FOUND OUT THERE IS ISSUE CONCERNING THE LENGTH OF THE HARNESS THAT CAUSES WIRES TO BREAK OVER TIME. *TR
Engine, Jun 19, 2012
2005.5 NEW JETTA TDI DIESEL.CAM SHAFT DEFECT. WORN LOBES AND CYLINDER HEAD DAMAGE. REPLACED TIMING BELT AS WELL. *JS
Electrical system, Jun 5, 2012
THE CAR HAS 83K MILES, SINCE APPROX 1 YEAR AGO (73K MILES) THE LCD MULTIFUCTION DISPLAY IS GETTING DIMMER AND DIMMER UP TO THE POINT THAT SOMETIMES IS ALMOST UNREADABLE AND THE PROBLEM OCCUR ONLY WHEN THE CAR IS EXPOSED TO HIGH TEMPERATURES. (IN THE MORNING THE LCD BRIGHTNESS IS NORMAL). I DID SOME RESEARCH IN THE INTERNET AND FOUND OTHER PEOPLE HAVE THE SAME CONDITION. THE LCD MULTIFUNCTION DISPLAY SHOWS THE ODOMETER DATA, THE TRANSMISSION GEAR POSITION AND ALSO SHOWS SAFETY WARNINGS RELATED TO AIR BAGS MALFUNCTION AND FRONT AND REAR DOORS NOT PROPERLY CLOSED. I WAS ADVISED BY A DEALER SERVICE ADVISOR TO CONTACT VW CUSTOMER SERVICE BECAUSE THE REPAIR OF THIS DEFECT IS VERY EXPENSIVE AND ACCORDING TO HIM MAY BE CAUSED BY DEFECTIVE PARTS. I WAS TOLD BY VW CUSTOMER SERVICE THAT THERE IS NOTHING THEY CAN DO BECAUSE IS NOT RECOGNIZED AS A MANUFACTURER DEFECT. I UNDERSTAND THAT IT IS ILLEGAL FOR A CAR OWNER TO ALTER THE ODOMETER DURING THE LIFETIME OF THE CAR, IF THAT IS THE CASE SHOULD BE ILLEGAL A FOR A CAR MANUFACTURER TO SELL A CAR THAT AFTER SIX YEARS YOU ARE UNABLE TO READ THE ODOMETER INFORMATION.
Power train, May 2, 2012
VEHICLE HAS MANUAL TRANSMISSION, DRIVER SELECTED FIRST GEAR AT AN INTERSECTION, PULLED AWAY FROM LIGHT WHEN IT CHANGED TO GREEN, TRIED TO CHANGE TO SECOND GEAR, HOWEVER GEAR LEVER STUCK IN FIRST GEAR, WOULD NOT MOVE INTO NEUTRAL, LUCKILY DRIVER HAD ENOUGH FORWARD MOMENTUM TO CLEAR INTERSECTION AND ROLL OFF TO THE SIDE OF THE ROAD. WITH ENGINE RUNNING DRIVER IS UNABLE TO SELECT A GEAR, ONLY WAY TO PUT TRANSMISSION INTO A GEAR IS TO TURN OFF THE ENGINE, VEHICLE TAKEN TO VOLKSWAGEN DEALER FOR REPAIR, CLUTCH PRESSURE PLATE HAD CRACKED IN HALF. *JS
Engine and engine cooling, Fuel system, Diesel, Power train, Mar 5, 2012
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WOULD OCCUR INTERMITTENTLY. THE ENGINE WOULD ALSO MISFIRE AND THE VEHICLE WOULD JERK AND DECELERATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN ADVISED THE CONTACT THAT THE B VALVE, THE GLOW PLUG AND THE GLOW PLUG HARNESS WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE CONTINUED AFTER THE REPAIR. THE VEHICLE WAS TAKEN TO A SECOND DEALER FOR DIAGNOSTICS WHERE THE TECHNICIANS STATED THAT THE DIRECT SHIFT GEARBOX UNIT WOULD HAVE TO BE REPLACED. THE CONTACT REFERENCED A RECALL FOR THE 2009-2010 MODELS UNDER NHTSA CAMPAIGN ID NUMBER: 09V333000 (POWER TRAIN:AUTOMATIC TRANSMISSION) BUT WAS ADVISED BY THE MANUFACTURER THAT THE RECALL DID NOT INCLUDE THE 2005 MODEL VEHICLES. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 118,000. UPDATED 04/02/12*LJ
Engine and engine cooling, Feb 29, 2012
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, HE NOTICED THAT THE CHECK ENGINE LIGHT WAS ILLUMINATED AND FLASHING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE THEY ADVISED HIM THAT THE CRANK SHAFT SENSOR FAILED AND THE VEHICLE WAS MISFIRING. THE VEHICLE WAS TAKEN TO ANOTHER MECHANIC WHERE THEY ADVISED THE CONTACT THAT THE TIMING CHAIN SPROCKETS HAD BEEN SHAVED DOWN, WHICH CAUSED THE FAILURE. THE VEHICLE WAS REPAIRED FOR THE TIMING CHAIN SPROCKETS AS WELL AS OTHER COMPONENTS. THE MANUFACTURER WAS CONTACTED WHO OFFERED NO ASSISTANCE BECAUSE THE VEHICLE WAS NOT TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE FAILURE MILEAGE WAS APPROXIMATELY 60,005. THE VIN WAS UNAVAILABLE.
Engine and engine cooling, Jan 31, 2012
AT ROUGHLY 6500 MILES MY CHECK ENGINE LIGHT CAME ON. BROUGHT IT TO DEALERSHIP TO CHECK OUT. FOUND OUT THAT THE TIMING CHAIN HAD JUMPED, OR STRETCHED, RESULTING IN POOR IDLE AND A $2700 ESTIMATE TO REPAIR. LOOKED IF OTHER PEOPLE HAD THIS ISSUE. TIMING CHAIN SHOULD LAST 2-3 TIMES LONGER. SINCE I'M OUT OF WARRANTY PERIOD I AM OUT OF LUCK. VW OFFERED $1500 CREDIT TOWARDS A NEW VW. THIS IS NOT ACPETABLE. MY LAST JETTA LASTED 180000 MILES BEFORE ANY ISSUES. IF MORE PEOPLE HAVE THIS ISSUE, THEN THERE SHOULD BE A RECALL AND IT SHOULD BE COVERED BY THE COMPANY. BE WARY OF VW'S. *TT
Power train, Vehicle speed control, Other or unspecified, Jan 15, 2012
AS I TRY TO ACCELERATE THE GEARS JUMP ERRADICALLY.
Structure, Jan 3, 2012
THE TRUNK LATCH IS EASILY DEFECTIVE CAUSING INABILITY TO SHUT TRUNK OR OPENING OF TRUNK WHILE DRIVING. SEARCH FORUMS ONLINE AND YOU WILL SEE PLENTY OF HITS AS A RECURRING PROBLEM. OURS NEEDS TO BE REPLACED A SECOND TIME AND HAS OPENED WHILE ON THE ROAD. THANKFULLY THE TRUNK WAS EMPTY AND NOTHING FLEW OUT AND THE ROAD WAS EMPTY. *TR