2006 Volkswagen Jetta
Problems, recalls and owner-reported issues
Power train is the leading concern among 580 owner complaints filed for this model year. This is the 6th highest complaint count among 26 Jetta model years with reports.
Of the 2006 reports, 15 involved a crash and 6 involved a fire. 17 people were injured.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, foundation components, master cylinderSep 23, 2020
Tenneco Automotive (Tenneco) is recalling certain Beck/Arnley Master Cylinders, part number 072-9831, sold as aftermarket or replacement parts for 2004-2018 Volkswagen Jetta, and 2012-2019 Volkswagen Beetle vehicles. The fluid seal crimp on the master cylinder may be insufficient, causing brake fluid to leak or the cylinder to come apart.
If there is a brake fluid leak, it can reduce braking ability, increasing the risk of a crash.
Beck/Arnley will notify the distributors that sold the master cylinders and will work with the distributors to notify the end users. Affected master cylinders will be exchanged for a new master cylinder (part number 072-9990), free of charge. The recall began October 30, 2020. Owners may contact Tenneco customer service at 1-800-625-9319.
Campaign 20E064000 on NHTSA.gov
Engine and engine cooling, engineMar 7, 2014
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
Campaign 14E007000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 10, 2010
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.
IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 10V621000 on NHTSA.gov
Power train, driveline, driveshaftMay 19, 2009
VOLKSWAGEN IS RECALLING 25,594 MY 2006-2009 JETTA 5TH GENERATION EQUIPPED WITH 2.01 ENGINE. THE FASTENING SCREW CONTACT SURFACES ON THE DRIVESHAFT COVER PLATE MAY NOT HAVE BEEN MANUFACTURED TO FACTORY SPECIFICATIONS. SOME SCREWS MAY NOT HAVE BEEN TORQUED PROPERLY DURING ASSEMBLY AND COULD LOOSEN OVER TIME, CAUSING A KNOCKING SOUND WHEN THE VEHICLE IS IN MOTION. THE DRIVESHAFT SCREWS COULD LOOSEN TO THE POINT WHERE THE DRIVESHAFT DETACHES FROM THE GEARBOX.
IF THE VEHICLE IS MOVING WHEN THIS HAPPENS, THE DETACHED DRIVESHAFT COULD CAUSE DAMAGE THE GEARBOX HOUSING. A DAMAGE GEARBOX HOUSING COULD LEAK GEARBOX OIL ONTO THE STREET AND CREATE A RISK OF A VEHICLE CRASH FOR BOTH THE DRIVER AND OTHER MOTORISTS.
DEALERS WILL INSPECT THE DRIVESHAFT SCREWS AND REPLACE THE SCREWS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 24, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 09V164000 on NHTSA.gov
Exterior lighting, headlightsSep 24, 2007
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.
NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 07V442000 on NHTSA.gov
Visibility, windshield wiper/washerJun 25, 2007
CERTAIN VEHICLES EQUIPPED WITH 2.5L GASOLINE ENGINES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST THE UNDERHOOD FUEL SUPPLY LINE.
IF THIS HAPPENS, THE CHAFING HAS THE POTENTIAL TO CAUSE A FUEL LEAK OVER TIME. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR AND WILL ALSO INSPECT AND, IF NECESSARY, REPLACE THE UNDERHOOD FUEL SUPPLY LINE. THE RECALL BEGAN ON AUGUST 24, 2007. OWNERS MAY CONTACT VW AT 1-800-893-5298.
Campaign 07V284000 on NHTSA.gov
Representative owner complaints: electrical system
112 reports, newest first. Show all
Suspension, Electrical system, Fuel/propulsion system, Dec 11, 2020
THERE HAS BEEN TAMPERING DONE TO MY VEHICLE HOW DO I ASSURE SAFETY AND HAVE IT INVESTIGATED AND HAVE A REPAIR MAN LOOK OVER THE VEHICLE AFTER THE THEFT?
Electrical system, Air bags, Jul 21, 2020
THE DRIVER'S SIDE WINDOW STOPPED WORKING. THE PROBLEM WAS TRACED BACK TO A FAULTY WIRING HARNESS IN THE DOOR HINGE. THIS IS A VERY COMMON VW ISSUE, AND MANY OTHER ONLINE COMPLAINTS REFERENCE A WIRE HARNESS THAT IS TOO SHORT. I REPAIRED THE SEVERED WIRES WITH BUTT CONNECTORS. AFTER THE REPAIR WAS COMPLETED, THE AIRBAG LIGHT CAME ON. I INSPECTED THE WHOLE AIRBAG SYSTEM (CONNECTORS, WIRING, FUSES, ETC.) TO NO AVAIL. THE AIRBAG LIGHT IS STILL ILLUMINATED ON THE DASHBOARD. AGAIN, OTHERS HAVE COMPLAINED OF THIS SAME ISSUE WHEN FIXING A VW'S WINDOW (I.E., FIX THE WINDOW AND THE AIRBAG LIGHT ILLUMINATES). THE TWO ISSUES SHOULD NOT BE CONNECTED, AND THIS IS A MAJOR SAFETY CONCERN FOR ME.
Electrical system, Nov 24, 2019
CAR WILL NOT TURN OFF - KEY GETS STUCK IN IGNITION WHEN TURNING OFF THE ENGINE. HAVE TO PUSH THE STEERING WHEEL IN FORCEFULLY TO BE ABLE TO TURN KEY AND ENGINE OFF.
Electrical system, Oct 22, 2019
TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE'S BATTERY WAS REPLACED THREE TIMES WITHIN A YEAR. THE NEW BATTERY WAS REPLACED WITHIN A MONTH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE RADIO CAUSED THE BATTERY TO FAIL. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED YORK VOLKSWAGEN (3475 E MARKET ST, YORK, PA 17402, (717) 755-1015) AND WAS INFORMED THAT THERE WAS NO GUARANTEE THAT THEY COULD REPAIR THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT HE COULD NOT DRIVE THE VEHICLE BECAUSE THE KEY FAILED TO INSERT INTO THE IGNITION SWITCH. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR THE IGNITION FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 54,000. THE VIN WAS NOT AVAILABLE.
Electrical system, Jun 10, 2019
JETTA DRIVER SIDE DOOR WIRING HARNESS ISSUES CREATING THE FOLLOWING PROBLEMS: DRIVER WINDOW SWITCH INOPERATIVE, FUEL DOOR SWITCH INOPERATIVE, DOOR AJAR LIGHT IS ON, DOOR LACK SWITCH INOPERATIVE. VEHICLE IS PARKED WHEN THIS PROBLEMS ARE PRESENT. THERE HAS BEEN TECHNICAL SERVICE BULLETINS ISSUED TO SOME 2006 JETTA OWNERS BUT NO TO EVERYONE BEEN AFFECTED BY THIS PROBLEM. AN EXAMPLE OF THIS CAN BE FOUND HERE: HTTPS://WWW.YOUTUBE.COM/WATCH?V=P1EQ5XL-ZPM THIS PERFECTLY DESCRIBES THE ISSUES MENTIONED ABOVE.
Electrical system, Vehicle speed control, Visibility/wiper, Nov 20, 2018
SO INSIDE OF MY VEHICLE I AM UNABLE TO OPEN MY TRUNK BY FLIPPING THE TRUNK SWITCH. MY LEFT PASSENGER DOOR IS UNABLE TO FUNCTION PROPERLY. THE WINDOWS WON'T TOLL DOWN, THE DOOR IS UNABLE TO LOCK AND IT'S STRESSFUL BECAUSE MY CAR GOT BROKEN INTO BECAUSE OF IT. MY RIGHT MIRROR TURN SIGNAL DOESN'T FUNCTION ANY MORE WHEN I SIGNAL RIGHT IT SIGNALS REALLY FAST AND IT'S ONLY SIGNALS USING MY HEADLIGHT AND TAIL LIGHT SIGNALS. SOMETIMES THERE IS A KICK TO MY CAR WHEN I'M DRIVING AND IN A COUPLE OF OCCASION WHEN I START MY VEHICLE MY CAR REVS UP ON IT'S OWN. JUST A BUNCH OF ISSUES IT'S STRESSFUL..
Electrical system, Aug 11, 2018
THE DRIVER DOOR WIRING HARNESS IS TO SHORT AND IN TIME THE WIRES BREAK WHERE THE WIRES GO FROM THE BODY INTO THE DOOR. THERE WAS A RECALL FOR THE 2005 AND 2004 YEARS FOR THIS PROBLEM.
Electrical system, Air bags, Seats, Jul 10, 2018
WHILE DRIVING THE VEHICLE AT APPROXIMATELY 65 MPH THE DRIVER SEAT STARTED TO MOVE FORWARD ON ITS OWN TOWARDS THE STEERING WHEEL IN WHICH I WAS UNABLE TO CONTROL THE DRIVER SEAT IT WOULD NOT REVERSENEARLY CAUSING A SERIOUS ACCIDENT. I ALSO NOTICED THAT THE VEHICLE HORN NO LONGER WORKS DUE TO SOME SORT OFELECTRICAL ISSUE. THE ISSUE TOOK PLACE WHILE I WAS DRIVING ON A MAJOR HIGHWAY.
Electrical system, May 2, 2018
ELECTRICAL HARNESS IN DRIVER'S DOOR MANUFACTURED 2 INCHES TOO SHORT WIRES BROKEN NO WAY TO ADJUST DRIVER'S MIRROR PASSENGER SIDE MIRROR OPEN TRUNK OPEN GAS CAP OPEN DRIVERS WINDOW OR ANY OTHER WINDOWS NOR TO LOCK OR UNLOCK DOORS. WHEN SWITCHING DRIVERS THE OTHER DRIVER CANNOT ADJUST THE MIRRORS IT'S A SAFETY HAZARD ALONG WITH ALL THE OTHER INABILITIES OF THESE SWITCHES NOT WORKING IN THAT DOOR. VOLKSWAGEN KNOWS ABOUT THE PROBLEM BUT WILL NOT DO ANYTHING ABOUT IT THERE ARE THOUSANDS OF THOUSANDS OF CARS WITH THIS PROBLEM! JUST GO ONLINE AND SEE ALL THE COMPLAINTS.
Power train, Electrical system, Jan 8, 2018
TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. DURING A ROUTINE INSPECTION, THE VEHICLE FAILED TO PASS EMISSIONS INSPECTION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE SIGNAL FROM THE ECU AND TRANSMISSION MODULE INDICATED THAT THERE WERE TWO PINS THAT WERE DEFECTIVE AND NEEDED TO BE REPAIRED. COLONIAL VOLKSWAGEN (89 TURNPIKE RD, WEST BOROUGH, MA) WAS CONTACTED REGARDING THE FAILURE, BUT THEY REFUSED TO ASSIST THE CONTACT. THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 163,000. *TT *TR
Power train, Electrical system, Aug 3, 2017
TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE DRIVING VARIOUS SPEEDS, THE INSTRUMENT PANEL INDICATORS REMAINED ILLUMINATED. ALSO, WHILE DRIVING ON AN INCLINE, THE TRANSMISSION WOULD DOWNSHIFT. FURTHERMORE, THE BATTERY WOULD DRAIN OVERNIGHT AND THE VEHICLE WOULD FAIL TO START. THE CONTACT CALLED THE LEE SUMMIT VOLKSWAGEN DEALER (LOCATED IN LEE SUMMIT, MO, (816) 600-4224) WHERE AN APPOINTMENT WAS SCHEDULED FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT OFFER ANY ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.
Electrical system, Air bags, Dec 16, 2016
TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED MULTIPLE ELECTRICAL FAILURES THAT INCLUDED THE HEADLIGHTS SHUTTING OFF WHILE DRIVING, THE DOOR SENSORS ERRONEOUSLY INDICATING THE DOORS WERE OPENED (WHICH ALSO CAUSED AN AUDIBLE WARNING CHIME TO ACTIVATE), AND THE FLOOR LIGHTS ILLUMINATED WHILE DRIVING. IN ADDITION, THE DRIVER SIDE DOOR LOCKS AND WINDOWS WOULD NOT OPERATE, THE TURN SIGNALS WOULD NO LONGER OPERATE, AND THE AIR BAG SENSOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURES. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 175,000.
Electrical system, Other or unspecified, Engine, Nov 6, 2016
KEY GETS STUCK IN IGNITION WHEN TURNING OFF THE ENGINE.
Power train, Electrical system, Engine, Sep 4, 2016
MY CAR HAS SOME SHIFTING PROBLEMS WHEN IN MOTION.MY CAR HAS A JERKING MOTION THAT IT DOES WHEN GOING INTO GEARS AND WHEN SLOWING DOWN ITS ROUGH GOING DOWN GEARS.
Power train, Electrical system, Jun 28, 2016
MY VOLKSWAGEN JETTA TDI 2006 GOT THE PRNDS FLASH OF DEATH, AND I FOUND OUT IT WAS THE MECHATRONIC UNIT WHEN I TOOK IT TO THE SHOP. I WAS DRIVING ON THE HIGHWAY GOING 75MPH WHEN THE FLASHES STARTED TO OCCUR. I COULDN'T GIVE MY ENGINE ANY POWER AND I STARTED TO DECELERATE AT A QUICK PACE, AND THE VEHICLE BEHIND ME ALMOST HIT ME. THIS IS A MAJOR SAFTEY ISSUE FOR ME AND FOR ALL OTHER OCCUPANTS ON THE HIGHWAY, BECAUSE MY FAULTY CAR COULD HAVE CAUSED A MAJOR ACCIDENT, THAT COULD HAVE RESULTED IN MANY INJURIES. I WANT TO BRING THIS ATTENTION TO THE NHTSA TO, PROVIDE ME WITH MORE INFORMATION AS TO WHY THE VEHICLE IS FAULTY, AND THE AMOUNT OF TROUBLE I WOULD BE IN IF I DIDN'T MANAGE THIS SITUATION LIKE I DID TO PROTECT MYSELF AND EVERYONE ELSE.
Electrical system, Electronic stability control (ESC), Engine, May 19, 2016
ORIGINALLY, THE TURBO WOULD LOSE BOOST AND THE ENGINE WOULD LOSE POWER. AFTER SOME TIME, PARTICULARLY DURING WET WEATHER, THE CAR WILL SUDDENLY VIBRATE, JOLT, AND THEN THE ENGINE WARNING CHIME SOUNDS. THE TACHOMETER DROPS TO ZERO, THE OIL PRESSURE LIGHT COMES ON, THE STABILITY CONTROL SHUTS OFF, THE GLOW PLUG LIGHTS FLASH, REAR WINDOW DEFROSTER WILL NOT WORK, CRUISE CONTROL WONT WORK, AND IF THE CAR IS SHUT OFF IT WILL NOT RESTART. THIS IS PARTICULARLY DANGEROUS DURING SNOW OR RAIN, AS THE CAR LOSES TRACTION CONTROL DURING WEATHER IN WHICH IT IS MOST IMPORTANT TO HAVE. ALSO, IF THE CAR DIES AND IS ON THE SHOULDER OF THE ROAD, DURING RAIN OR SNOW, THERE IS POOR VISIBILITY AND IT INCREASES THE RISK OF SOMEONE HITTING THE DISABLED CAR. I HAVE SEEN MANY MENTIONS OF THIS SAME EFFECT HAPPENING ON OTHER 2006 TDI MODELS, AND IT SEEMS TO BE A RECURRING ISSUE WITH THIS PARTICULAR MODEL AND ENGINE TYPE. THE ROOT CAUSE APPEARS TO BE AN ELECTRICAL HARNESS THAT RUNS IN THE ENGINE COMPARTMENT CHAFING OVER TIME, WHICH HAPPENS OUTSIDE OF THE WARRANTY PERIOD, BUT CAUSES SIGNIFICANT SAFETY CONCERNS WITH ITS FAILURE MODE.
Electrical system, Air bags, Fuel/propulsion system, Feb 19, 2016
TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE DRIVING AT VARIOUS SPEEDS, THE PARKING WARNING LIGHT ILLUMINATED INTERMITTENTLY. IN ADDITION, THE AIR BAG WARNING LIGHT ILLUMINATED AND THE FUEL TANK LEAKED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT PROVIDED.
Electrical system, Jan 21, 2016
MY VEHICLE HAS HAD PREVIOUS ELECTRICAL ISSUES AS THEY PERTAIN TO THE DRIVER SIDE DOOR AND WINDOW AND ITS CONNECTION TO ITS POWER DRAW AND BATTERY. IN 2014, THERE WAS AN EXTENDED WARRANTY PLACED ON MY PARTICULAR VEHICLE FOR REPLACEMENT AND REPAIR OF THE WINDOW/DOOR MOTOR MECHANICS AND WIRING HARNESS. I AM NOW EXPERIENCING RECURRING ISSUES AND MY BRAND NEW BATTERY'S CHARGE WILL NOT HOLD - OFTEN BEYOND 24 HOURS AS A FAILURE IS CAUSING A POWER DRAW TO DRAIN THE CAR'S BATTERY.
Steering, Electrical system, Electronic stability control (ESC), Dec 29, 2015
MY VW JETTA HAS HAD ISSUES LOSING ELECTRONIC POWER STEERING ON AND OFF, TYPICALLY WHEN IT RAINS OR THE ROADS HAVE BEEN SALTED AND IT IS SLUSHY OR SNOWING. THIS LAST WEEK I WAS DRIVING AND I LOST TRACTION CONTROL, CRUISE CONTROL, TACHOMETER, ABS BRAKES AND OIL PRESSURE. THE CAR WOULD NOT IDLE. RESEARCHING THE ISSUE, I FOUND THERE MAY BE AN ISSUE WITH THE WIRING HARNESS. I INSPECTED THE HARNESS AND DISCOVERED THAT SEVERAL WIRES HAVE BEEN CHAFED BY THE PLASTIC LOOM AND WORN THROUGH THE INSULATION, EXPOSING THE WIRES. I ALSO DISCOVERED THAT THE POSITIVE CABLE TO THE STARTER HAD CHAFED AND WORN THROUGH THE GROUND WIRE INSULATION CREATING A POTENTIAL HAZARD TO SHORT THE BATTERY.
Electrical system, Air bags, Engine, Nov 10, 2015
ABOUT 4 YEARS AGO ,I TOOK MY JETTA TO THE VOLKSWAGEN DEALER IN REGARD TO FRONT AIRBAGS RECALL. THE LIGHT WOULD NOT GO OFF. THEY REPAIRED IT, BUT AFTER A YEAR THE LIGHT CAME BACK ON AND STAYED ON. WHEN I CALL THE DEALER, I WAS TOLD I WOULD HAVE TO PAY FOR AN INSPECTION OF THE CAR BEFORE THEY CAN DETERMINE IF IT IS DEFECTIVE OR NOT. IT SEEMS TO ME THEY DID NOT FIX THE PROBLEM AND I SHOULD NOT HAVE TO PAY FOR IT. ALSO MY HORN WANT OFF, ONE DAY, AND THE ONLY WAY I WAS ABLE TO STOP IT , WAS TO PULL THE FUSE OUT. WHEN I PUT THE FUSE BACK , THE HORN WOULD NOT WORK. NOTHING WRONG WITH THE FUSE. . MY YELLOW ENGINE LIGHT KEEP COMING ON , ESPECIALLY WHEN I USE MY A/C AND THERE IS A VERY STRANGE SMELL IN THE CAR. I ONLY HAVE 55000 MILES ON THIS CAR. AND TO TOP IT ALL, WHILE DRIVING THE CAR, I GOT A ICON LIGHTING UP IN REGARD TO MY COOLANT. THE LITTLE BLACK TUBE THAT CONNECTS TO THE RESERVOIR HAD SLIPPED OFF AND ALL THE ANTIFREEZE FELL OUT OF IT ONTO THE ENGINE. OWNING A VOLKSWAGEN IS A REAL NIGHTMARE, HAD HONDA BEFORE, PUT OVER 130000 MILES ON IT AND NEVER HAD ANY PROBLEM.WILL DEFINITELY NEVER BUY VOLKSWAGEN AGAIN AND WILL NOT RECOMMEND IT. TO ANYONE
Electrical system, Air bags, Service brakes, Aug 5, 2015
TDI ENGINE WIRING HARNESS CHAFED INSIDE THE WIRE LOOM CAUSE NUMEROUS ELECTRICAL ISSUES. INCLUDING ABS, STEERING MODULE, AIRBAG, ENGINE SPEED SENSOR, TEMPERATURE GAUGE, AND STABILITY CONTROL. VERY DIFFICULT AND COSTLY TO DIAGNOSE.
Electrical system, Air bags, Jul 23, 2015
TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE AIR BAG WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT THE WIRING HARNESS NEEDED TO BE MODIFIED. A FEW MONTHS LATER, THE AIR BAG WARNING LAMP ILLUMINATED AGAIN. THE DEALER CHARGED $125.00 FOR THE REPAIR AND STATED THAT A NEW AIR BAG MAY BE NEEDED AT THE COST OF APPROXIMATELY $750.00. THE FAILURE MILEAGE WAS 103,300.
Electrical system, Air bags, Jun 18, 2015, crash
TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT FELL ASLEEP AND CRASHED INTO A POLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED HEAD AND MOUTH INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE SUSTAINED EXTENSIVE FRONT END DAMAGE AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000. UPDATED 8/6/15*CN THE CONSUMER ALSO EXPERIENCED A PROBLEM WITH THE WINDOWS AND DOOR LOCKS. UPDATED 08/11/15*JB
Electrical system, Seats, Feb 28, 2015
DRIVER SEAT LOWER RIGHT BACK OVERHEATED. BURNT A HOLE IN THE SEAT AND MELTED THE COAT I WAS WEARING. SMELL OF BURNING IN THE CAR AND INTENSE HEAT ON MY BACK. TURNED OFF THE SEAT HEAT. WHEN I ARRIVED AT MY DESTINATION, NOTICED THE BURN IN THE SEAT AND LATER NOTICED A BURN ON MY COAT. INTERIOR OF THE CAR IS WELL MAINTAINED, NEVER FLOODED OR ABUSED. NOW I HAVE A CAR DRIVER SEAT THAT IS BADLY DAMAGED, A RUINED COAT AND SCARED TO OPERATE THE CAR OR TO PARK IN MY GARAGE IN FEAR OF A FIRE THAT COULD BURN DOWN MY HOUSE AND CAR PUTTING MY SELF AND FAMILY IN HARMS WAY. I HAVE NOTICED SEVERAL VW CARS IN THE PAST WITH THE SAME PROBLEM IN THE SAME SPOT AND WAS ALWAYS THANKFUL THAT IT WAS NOT MY CAR. NOW IT IS MY CAR WITH THE SAME PROBLEM. CALLED THE VW DEALER AND THEY SAID THAT THERE IS NOT A RECALL ON THIS. THIS IS A PROBLEM THAT CAN CAUSE A BAD BURN ON A PERSON. I AM GLAD I HAD A COAT ON WHILE DRIVING, OTHERWISE I WOULD HAVE HAD TO SEEK MEDICAL TREATMENT FOR THE BURN. WOULD LIKE TO SEE VW CORRECT THE PROBLEM AND REPLACE THE SEAT AT NO CHARGE TO THE OWNERS. THIS IS A PREVENTABLE PROBLEM THAT NEEDS CORRECTED. *TR
Electrical system, Seats, Feb 28, 2015
DRIVER SEAT LOWER RIGHT BACK OVERHEATED. BURNT A HOLE IN THE SEAT AND MELTED THE COAT I WAS WEARING. SMELL OF BURNING IN THE CAR AND INTENSE HEAT ON MY BACK. TURNED OFF THE SEAT HEAT. WHEN I ARRIVED AT MY DESTINATION, NOTICED THE BURN IN THE SEAT AND LATER NOTICED A BURN ON MY COAT.. INTERIOR OF THE CAR IS WELL MAINTAINED, NEVER FLOODED OR ABUSED. NOW I HAVE A CAR DRIVER SEAT THAT IS BADLY DAMAGED, A RUINED COAT AND SCARED TO OPERATE THE CAR OR TO PARK IN MY GARAGE IN FEAR OF A FIRE THAT COULD BURN DOWN MY HOUSE AND CAR PUTTING MYSELF AND FAMILY IN HARMS WAY. I HAVE NOTICED SEVERAL VW CARS IN THE PAST WITH THE SAME PROBLEM IN THE SAME SPOT AND WAS ALWAYS THANKFUL THAT IT WAS NOT MY CAR. NOW IT IS MY CAR WITH THE SAME PROBLEM. CALLED THE VW DEALER, AND THEY SAID THAT THERE IS NOT A RECALL ON THIS. THIS IS A PROBLEM THAT CAN CAUSE A BAD BURN ON A PERSON. I AM GLAD I HAD A COAT ON WHILE DRIVING, OTHERWISE I WOULD HAVE HAD TO SEEK MEDICAL TREATMENT FOR THE BURN. WOULD LIKE TO SEE VW CORRECT THE PROBLEM AND REPLACE THE SEAT AT NO CHARGE TO THE OWNERS. THIS IS A PREVENTABLE PROBLEM THAT NEEDS CORRECTED. *TR