2006 Volkswagen Jetta
Problems, recalls and owner-reported issues
Power train is the leading concern among 580 owner complaints filed for this model year. This is the 6th highest complaint count among 26 Jetta model years with reports.
Of the 2006 reports, 15 involved a crash and 6 involved a fire. 17 people were injured.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, foundation components, master cylinderSep 23, 2020
Tenneco Automotive (Tenneco) is recalling certain Beck/Arnley Master Cylinders, part number 072-9831, sold as aftermarket or replacement parts for 2004-2018 Volkswagen Jetta, and 2012-2019 Volkswagen Beetle vehicles. The fluid seal crimp on the master cylinder may be insufficient, causing brake fluid to leak or the cylinder to come apart.
If there is a brake fluid leak, it can reduce braking ability, increasing the risk of a crash.
Beck/Arnley will notify the distributors that sold the master cylinders and will work with the distributors to notify the end users. Affected master cylinders will be exchanged for a new master cylinder (part number 072-9990), free of charge. The recall began October 30, 2020. Owners may contact Tenneco customer service at 1-800-625-9319.
Campaign 20E064000 on NHTSA.gov
Engine and engine cooling, engineMar 7, 2014
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
Campaign 14E007000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 10, 2010
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.
IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 10V621000 on NHTSA.gov
Power train, driveline, driveshaftMay 19, 2009
VOLKSWAGEN IS RECALLING 25,594 MY 2006-2009 JETTA 5TH GENERATION EQUIPPED WITH 2.01 ENGINE. THE FASTENING SCREW CONTACT SURFACES ON THE DRIVESHAFT COVER PLATE MAY NOT HAVE BEEN MANUFACTURED TO FACTORY SPECIFICATIONS. SOME SCREWS MAY NOT HAVE BEEN TORQUED PROPERLY DURING ASSEMBLY AND COULD LOOSEN OVER TIME, CAUSING A KNOCKING SOUND WHEN THE VEHICLE IS IN MOTION. THE DRIVESHAFT SCREWS COULD LOOSEN TO THE POINT WHERE THE DRIVESHAFT DETACHES FROM THE GEARBOX.
IF THE VEHICLE IS MOVING WHEN THIS HAPPENS, THE DETACHED DRIVESHAFT COULD CAUSE DAMAGE THE GEARBOX HOUSING. A DAMAGE GEARBOX HOUSING COULD LEAK GEARBOX OIL ONTO THE STREET AND CREATE A RISK OF A VEHICLE CRASH FOR BOTH THE DRIVER AND OTHER MOTORISTS.
DEALERS WILL INSPECT THE DRIVESHAFT SCREWS AND REPLACE THE SCREWS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 24, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 09V164000 on NHTSA.gov
Exterior lighting, headlightsSep 24, 2007
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.
NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 07V442000 on NHTSA.gov
Visibility, windshield wiper/washerJun 25, 2007
CERTAIN VEHICLES EQUIPPED WITH 2.5L GASOLINE ENGINES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST THE UNDERHOOD FUEL SUPPLY LINE.
IF THIS HAPPENS, THE CHAFING HAS THE POTENTIAL TO CAUSE A FUEL LEAK OVER TIME. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR AND WILL ALSO INSPECT AND, IF NECESSARY, REPLACE THE UNDERHOOD FUEL SUPPLY LINE. THE RECALL BEGAN ON AUGUST 24, 2007. OWNERS MAY CONTACT VW AT 1-800-893-5298.
Campaign 07V284000 on NHTSA.gov
Representative owner complaints
580 reports, newest first.
Power train, Sep 13, 2009
2006 JETTA GLI WITH DSG GEARBOX, REPEATED TRANSMISSION CLUNKING (IN AUTOMATIC MODE) WHEN DOWNSHIFTING FROM 2ND TO 1ST, AND HARSH THUNKING IN FIRST GEAR FROM A STOP ENGINE REVS UP BUT CAR WILL NOT MOVE FOR 1 TO TWO SECONDS THEN THUNK AND CAR SURGES FORWARD. ALSO THUNKING WHEN SHIFTING GEAR SELECTOR INTO REVERSE. HAS OCCURRED INTERMITTENTLY AND OFTEN SINCE OCT 2007. POSES DANGEROUS SITUATION AT INTERSECTIONS AND IN STOP AND GO DRIVING WITH POTENTIAL INTERMITTENT LOSS OF FORWARD MOTION AND SUDDEN FORWARD SURGING AFFECTING THE SAFE DRIVEABILITY OF THE VEHICLE COUPLE OF TIMES NARROWLY MISSED RUNNING INTO THE VEHICLE IN FRONT OF ME DUE TO SUDDEN LURCHING OF THE VEHICLE. DEALER REPLACED TRANSMISSION TEMPERATURE SENSOR IN LATE 2008, BUT PROBLEM RECURRED AND PERSISTED AFTERWARDS. AFTER FEW MORE INCIDENTS AND VISITS TO DEALER THROUGH JUN 2009 WAS INFORMED MECHATRONICS UNIT WAS FAULTY AND WOULD BE REPLACED. WAITED 42 DAYS WITH CAR LEFT WITH DEALER FOR NEW PART TO BE DELIVERED FROM FACTORY " DUE TO BACKLOG' , IN MEANTIME CAR WAS RECALLED FOR TRANSMISSION BOLT REPLACEMENT/INSPECTION. FINALLY RECEIVED "FIXED" CAR WITH NEW MECHATRONICS UNIT AND PROBLEM RECURRED THE SAME DAY THREE MILES AWAY FROM THE DEALERSHIP IN STOP AND GO TRAFFIC. WAS TOLD THAT TRANSMISSION 'NEEDED TO RE-LEARN MY DRIVING PATTERN" AND TO DRIVE IT AROUND FOR A WHILE TO SEE IF THE ISSUE WOULD GO AWAY. ISSUE SUBSEQUENTLY RECURRED REPEATEDLY OVER A ONE WEEK PERIOD ESPECIALLY WHEN MOVING FROM A STOP, WITH ENGINE REVVING UP THEN A SUDDEN THUNK AND FORWARD SURGE OF VEHICLE. RETURNED VEHICLE TO DEALER LAST WEEK STILL WAITING FOR RESOLUTION. *TR
Power train, Sep 4, 2009
MY 2006 VW JETTA TDI HAS A DSG TRANSMISSION. THIS TRANSMISSION HAS SLIPPED OUT OF GEAR TWICE WHILE TRAVELING ON THE INTERSTATE AT INTERSTATE SPEEDS. THIS IS AN AUTOMATIC TYPE TRANSMISSION AND SHOULD NOT BE SLIPPING OUT OF GEAR. THIS HAS NOT RESULTED IN AN ACCIDENT BUT I WAS REQUIRED TO MOVE ACROSS 3 LANES OF TRAFFIC ONLY UNDER MY CURRENT FORWARD MOMENTUM. LUCKILY I WAS ABLE TO DO SO WITHOUT INCIDENT. *TR
Power train, Sep 4, 2009
2006 VOLKSWAGEN JETTA TDI -- DUAL MASS FLYWHEEL FAILURE. PART HAS BEEN RECALLED IN AUSTRALIA, BUT NOT THE US. VW DEALERS REFUSE TO TAKE CONCERNS SERIOUSLY. *TR
Power train, Sep 4, 2009
I HAVE A 2006 VOLKSWAGEN JETTA TDI. RECENTLY, I HAVE BEEN EXPERIENCING TRANSMISSION ISSUES. THE VEHICLE LOSSES POWER IN THE TRANSMISSION IN THE UPPER GEARS. CONSEQUENTLY, I LOSE POWER WHILE ON THE INTERSTATE AT HIGHER SPEEDS. THIS HAS CAUSED ME TO HAVE TO TAKE EVASIVE ACTION TO AVOID CAUSING CRASHES FROM CARS BEHIND ME. I HAVE TAKEN THE CAR TO VOLKSWAGEN AS IT IS UNDER WARRANTY. THE WARRANTY COMPANY HAS MADE UNREASONABLE DEMANDS THAT THE DEALERSHIP HAS NOT BEEN ABLE TO FULFILL. AFTER A WEEK, I HAVE NOW TAKEN IT TO AAMCO TO HAVE THE TRANSMISSION SERVICED. I BELIEVE IT IS THE SAME TRANSMISSION THAT HAS BEEN RECALLED ON THE 2009 AND 2010. *TR
Engine and engine cooling, Aug 25, 2009
I OWE A 2006 VOLKSWAGEN JETTA THAT I HAVE BEEN BACK AND FORWARD FOR A LICENSED DEALERSHIP REPORTING THAT MY CAR SHUTS OFF COMPLETELY WHILE DRIVING. IIT HAVE BEEN DURING THIS ABOUT JUNE 2007 AND IT HAS BEEN TO DEALERSHIP ABOUT 6 TIMES FOR THIS SAME THING I TOOK IT IN APRIL 2008 AND THEY TOLD ME I NEED A NEW ENGINE AFTER SEVERAL OF MONTHS LETTING THEM DIAGNOSE THE PROBLEM. I AM PAYING CAR NOTE FOR A CAR I CAN NOT DRIVE. I SEEN GOOD MORNING AMERICA AND THEY SAY IT IS ONLY 2009-2010 MODELS WHEN I HAVE A 2006 THEY HAS SHUT OFF ON ME IN TRAFFIC IN BIRMINGHAM, AL , MOBILE, AND MISSISSIPPI. I CALL VOLKSWAGEN THEY TOLD ME THAT THEY COULD NOT HELP ME BECAUSE OF MY MILEAGE THEY CAN ONLY GIVE ME A 1000 DOLLARS TOWARDS ANOTHER VOLKSWAGEN. I TOLD THEM THAT I WILL NOT BUY ANOTHER. AT 1ST THEY TOLD ME THAT I NEED AND O2 SENSOR AND THE NEXT TIME THEY COULD NOT FIND ANYTHING UNTIL THEY REPORTED THAT IT WAS MY ENGINE. I FEEL IT IS NOT FAIR FOR ME TO PAY FOR A ENGINE BECAUSE I HAVE BROUGHT THE CAR TO THEM ON 5 OCCASION AND I CALL TO REPORT THE CAR SHUT OFF IN MONTGOMERY, AL ON MARCH 19, 2008 AND THEY TOLD ME TO HAVE IT TOW TO THE DEALERSHIP IN MISSISSIPPI WHO WAS FAMILIAR WITH CAR. I WAS STARTING IT FOR THE TOW TRUCK TO TAKE TO DEALER AND THE CAR WE HAYWILD. *TR
Power train, Aug 25, 2009
TL*THE CONTACT HAS A 2006 VOLKSWAGEN JETTA. HE STATED THAT THE VEHICLE WAS SURGING FROM SECOND GEAR AND ALSO BECAME HESITANT AND WASN'T SHIFTING GEARS WHEN IT SHOULD HAVE BEEN. WHILE DRIVING 70MPH GOING UP A HILL HE LOST ALL POWER TO THE VEHICLE AND IT FELT AS IF IT WAS IN NEUTRAL. AFTER LOSING POWER IT TOOK ABOUT FIVE SECONDS TO RESET IT SELF. THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL WITH CODES. THE VEHICLE WAS TAKEN TO A DEALER THE CODES WHERE REMOVED. HE WAS INFORMED THAT THE FAILURE OCCURRED FROM THE USG IN THE TRANSMISSION. THE VEHICLE IS CURRENTLY AT THE DEALER BEING WORKED ON. THE FAILURE MILEAGE WAS 68,000 BL
Service brakes, Hydraulic, Electrical system, Aug 21, 2009
DRIVING ON I-95 IN JACKSONVILLE, FL, IT WAS RAINING WITH SOME POUNDING (APPROX. 1 INCH OF WATER) ON THE ROADWAY. I WAS MAINTAINING A SPEED OF 35-45 MPH WHEN THE EPC AND TRACTION CONTROL WARNING LIGHTS ILLUMINATED ON THE DASHBOARD. AT FIRST THE CAR BEHAVED NORMALLY BUT AFTER ABOUT 5 MINUTES IT LOST POWER AND WOULD NOT ACCELERATE ABOVE 1500 RPM. FORTUNATELY I WAS ABLE TO QUICKLY TAKE AN EXIT RAMP OFF THE FREEWAY AND COAST INTO A GAS STATION, THE CAR CONTINUING TO REFUSE TO ACCELERATE. I TURNED THE CAR OFF AND WAITED FOR ABOUT 5 MINUTES. I STARTED UP AGAIN AND DROVE AROUND THE GAS STATION AND THINGS SEEMED NORMAL AGAIN, ALTHOUGH THE EPC LIGHT WAS STILL ILLUMINATED. STOPPED AGAIN AND WAITED ANOTHER 5 MINUTES. UPON STARTING UP AGAIN, BOTH WARNING LIGHTS WERE GONE AND THE CAR BEHAVED AND ACCELERATED NORMALLY. THIS DEFECT COULD HAVE CAUSED ME TO GET STOPPED IN TRAFFIC ON A BUSY FREEWAY POSSIBLY CAUSING A CRASH AND INJURIES. I WAS VERY LUCKY THAT IT HAPPENED WHERE IT DID AND I WAS ABLE TO PULL OFF TO SAFETY. *TR
Electrical system, Aug 20, 2009
VEHICLE TRUNK UNLATCHES WHILE VEHICLE IS STANDING OR IN MOTION, WITH OR WITHOUT THE ENGINE RUNNING. ITEMS IN TRUNK MAY SPILL ONTO HIGHWAY, CAUSING ACCIDENT OR INJURY. *TR
Engine and engine cooling, Aug 20, 2009
VEHICLE AIR CONDITIONING CONDENSATE DRAIN TUBE IS NOT SECURED FROM THE FACTORY. TUBE WILL POP LOOSE AND FILL VEHICLE CARPET WITH STAGNANT AIR CONDITIONING WATER. DEALER REFUSES TO ACKNOWLEDGE OBVIOUS FACTORY DEFECT AS NO FASTENER WAS FOUND TO BE IN THE TUBE FASTENER TAB. DEALER REFUSES TO REPAIR PROBLEM. *TR
Air bags, Aug 20, 2009
THE CAR AIRBAG LIGHT ILLUMINATES RANDOMLY. DEALER INDICATES SYSTEM MUST BE RESET FOR A CHARGE OF $80 EACH TIME. DEALER REFUSES TO REPAIR PROBLEM UNDER WARRANTY. AIR BAGS MAY NOT DEPLOY IN AN ACCIDENT. *TR
Engine and engine cooling, Aug 20, 2009
THE VEHICLE EXHAUST GAS RECIRCULATION COOLER LEAKS EXHAUST AFTER 50,000 MILES, EXPOSING THE VEHICLE OCCUPANTS TO EXHAUST GASES. ALTHOUGH THE EGR SYSTEM IS PURELY FOR EMISSIONS CONTROL, THE DEALER REFUSED TO FIX THE PART UNDER THE COVERED EMISSIONS WARRANTY. THIS PROBLEM CAN CAUSE THE DEATH OF THE OCCUPANTS OF THE VEHICLE. *TR
Service brakes, Hydraulic, Parking brake, Equipment, Aug 20, 2009
THE REAR BRAKE PADS, ON THE VEHICLE SIDE WITH THE EMERGENCY BRAKE CABLE ATTACHED, WEAR VERY PREMATURELY. THE DEALER INDICATED THIS TYPE OF VEHICLE HAS FAULTY BRAKE ADJUSTERS. THEY WOULD NOT REPLACE UNDER WARRANTY. THIS IS A SEVERE SAFETY HAZARD. *TR
Power train, Aug 14, 2009
KNOCKING SOUND FROM PASSENGER FRONT, BROUGHT VEHICLE INTO DEALER, THEY SAID THEY DIDN'T HEAR ANY KNOCKING. LESS THAN A MONTH LATER IT GOT EXTREMELY WORSE, I TOOK IT TO ANOTHER SHOP & WAS TOLD IT WAS SOMETHING SERIOUS & NEEDED TO HAVE DEALERSHIP LOOK AT IT. WHEN I RETURNED TO THE DEALERSHIP THEY TOOK 2 DAYS TO TELL ME WHAT THE ISSUE WAS AFTER HAVING TO REMOVE ENGINE, I WAS TOLD IT WAS THE FLYWHEEL & CLUTCH HAD TO BE REPLACED BECAUSE THE FLYWHEEL DAMAGED THE CLUTCH. VERY EXPENSIVE REPAIR & AFTER BEING TOLD ABOUT THIS WEBSITE & SEEING ALL THESE COMPLAINTS I CALLED VW & THEY REFUSED TO ACKNOWLEDGE THIS ISSUE EVEN WITH ALL THESE COMPLAINTS. *TR
Power train, Aug 10, 2009
SUDDEN TRANSMISSION FAILURE. WHILE DRIVING AT VARIOUS SPEEDS, SEVERAL TIMES THE TRANSMISSION LOST THE GEAR AND WENT TO NEUTRAL. THE CAR LOST POWER AND HAD TO COME TO A COMPLETE STOP. TWO TIMES THIS OCCURRED AT HIGHWAY SPEED WHERE I HAD TO MAKE AGGRESSIVE MANEUVERS TO AVOID A COLLISION. *TR
Power train, Aug 7, 2009
I NOTICED A NOISE COMING FROM MY ENGINE/DRIVETRAIN ALONG WITH SEVERE ENGINE SHAKING. I IMMEDIATELY TOOK THE VEHICLE TO THE MECHANIC AND WAS INFORMED THAT THERE WERE SEVERAL "TECHNICAL SERVICE BULLETINS" REGARDING THE FLYWHEEL AND CLUTCH IN MY VEHICLE. ALL OF THE BULLETINS ACKNOWLEDGED KNOWN PROBLEMS WITH THE FLYWHEEL AND CLUTCH PARTS. AFTER REMOVING THE TRANSMISSION TO INSPECT THE PROBLEM FURTHER IT WAS DISCOVERED THAT THE FLYWHEEL DISINTEGRATED CAUSING $3800 IN DAMAGE. THE MANUFACTURER WAS CONTACTED BY THE REPAIR FACILITY AND REFUSED TO COVER THE REPAIR CHARGES. *TR
Power train, Aug 4, 2009
MASS FLYWHEEL AND CLUTCH ASSEMBLY FAILURE. ANOTHER VOLKSWAGEN CLUTCH PROBLEM TO ADD TO THE LIST. WHY IS THE UNITED STATES NOT DOING ANYTHING ABOUT THIS LIKE OTHER COUNTRIES HAVE. ARE WE NOT THE MOST CARING COUNTRY IN THE WORLD, I MEAN LOOK HOW MUCH MONEY THIS GOVERNMENT DISHES OUT TO PEOPLE WHO DON'T DESERVE IT. (CAR MANUFACTURERS WHO CANT EVEN MAKE GOOD ON MANUFACTURER DEFECTS. OTHER COUNTRIES ISSUED VW TO FIX THE PROBLEMS. I EVEN READ A LETTER ON THIS WEBSITE THAT THE PROBLEM DID NOT FIND ITS WAY TO THE US BECAUSE IT WAS ONLY IN THE PASSAT. WELL THE JETTA'S, BEETLE'S, GLI'S AND THE GOLF'S ALL HAVE THE SAME TRANSMISSION THAT THEY ARE REFERRING TO IN THE LETTER. I MEAN THE GOVERNMENT IN CHARGE NOW WANTS US TO BE SUPPORTED BY THE GOVERNMENT SO WHY DOES THE GOVERNMENT NOT DO ANYTHING TO PROTECT US. THEY ARE TO MANY CASES LIKE MINE ALL OVER THIS SITE AND THE INTERNET FOR YA'LL NOT TO DO SOMETHING. TOOK THE CAR IN FOR SERVICE THEN WAS DROPPED WITH THE 3900.00 DOLLAR REPAIR BILL FOR THIS. *TR
Power train, Aug 3, 2009
HI I BOUGHTMY 06 TDI JETTA 2 YRS AGO IT HAD 39,800 MILES ON IT AND NOW I SEE WHY IT WAS TRADED IN AT 40,000 IT NEEDS A 560.00 SERVICE THAT I WAS NOT TOLD ABOUT. MY FAULT FOR NOT READING THE WHOLE MANUAL . I WAS TOLD BY DEALER THAT THE DSG WOULD NEED TO BE SERVICED AT 100,000 MILES AND IT WOULD BE GOOD. I BROUGHT THE CAR IN FOR CLATTERING NOISE SEVERAL TIMES AND WAS TOLD IT WAS NORMAL THE CAR HESITATED OFTEN AND SHIFTED POORLY BUT SINCE IT WAS AT THE DEALER I FIGURED IT WAS NORMAL. THE CLATTER GOT WORSE AND BY THIS TIME IT WAS ABOUT DUE FOR ITS 100000 MILE SERVICE BUT BEFORE I COULD GET IT IN ONE DAY DRIVING HOME FROM WORK IT SOULDED LIKE A BUCKET OR BOLTS FEEL OUT FROM MY CAR THE CLATTER BECAME SEVERE AND SOON AFTER THE CAR LEFT ME SIT ON THE SIDE OF THE HIGHWAY.I DESCRIBE THE PROBLEM AND CLATTER NOISE TO THE DEALER AND ALL OF A SUDDEN THEY KNEW THE PROBLEM EXACTLY. THEY TELL ME ITS PROBABLY THE CLUTCHES AND IT CAN'T BE REBUILT AND THEN THE SERVICE MANAGER AT YOUNG VW LAUGHING A LITTLE TELLS ME THAT I MISSED TWO SERVICES ON THE TRANNY WHEN I BOUGHT THE CAR WITH 39800 AND THEN THE CAR WAS BROUGHT IN SEVERAL TIMES AND NO ONE EVER TOLD ME THEIR MIGHT BE A PROBLEM UNTIL NOW THE CAR SITS AND I NEED 5000.00 DOLLARS TO FIX IT. THIS TRANSMISSION IS A PIECE OF '!@#$%'. I DON'T KNOW HOW MANY TIMES I ALMOST GOT SIDE SWIPED TRYING TO PULL OUT INTO TRAFFIC QUICKLY FROM A DEAD STOP. *TR
Air bags, Jul 31, 2009
TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT BOTH OF THE AIR BAG LIGHTS ILLUMINATED ON THE DASHBOARD AND THE MIDDLE CONSOLE. THE DEALER STATED THAT THE PASSENGER OCCUPANCY MODULE PRODUCED A FAULTY CODE, WHICH INDICATED THAT THE SEAT, SENSOR PAD, AND MODULE NEEDED TO BE REMOVED. THROUGH RESEARCH, THE CONTACT DISCOVERED THAT NUMEROUS OTHER CONSUMERS WERE EXPERIENCING THE SAME FAILURE. HE BELIEVES THAT THIS IS A MANUFACTURER DEFECT THAT SHOULD BE RECALLED. THE AIR BAGS WOULD NOT DEPLOY IN THE EVENT OF A CRASH. THE FAILURE MILEAGE WAS 74,000 AND CURRENT MILEAGE WAS 75,000. UPDATED 08/28/09. *LJ THE DEALER TOLD THE CONSUMER THERE WAS A LOW VOLTAGE SIGNAL SENT FROM THE BATTERY THAT CAUSED A MALFUNCTION IN THE PASSENGER AIR BAG MODULE. UPDATED 08/31/09.*JB
Air bags, Jul 29, 2009
AIR BAG DEFAULT- TO MANY TIMES SINCE I PURCHASED MY VEHICLE BACK IN SEPTEMBER OF 2006. I HAVE TAKEN MY CAR IN 6 TIMES ON 11/06, 1/07, 9/08, 10/08, 12/08 AND 7/09. 5 TIMES TO VW OF HAYWARD AND 1 TIME TO MODESTO VW. I FEEL MY LIFE IS ALWAYS AT RISK NOT KNOWING IF MY AIRBAGS WILL WORK IF I AM IN A CAR ACCIDENT.*TR
Power train, Jul 25, 2009
PRIOR TO THE EVENT LISTED BELOW, WE NOTICED THAT THE CAR WAS NOT PERFORMING AS IT NORMALLY WOULD. WE WERE STOPPED AT A TRAFFIC SIGNAL, LIGHT TURNED GREEN PROCEEDED TO ACCELERATE, CAR MOVED 10 FEET, RPM WENT HIGH AND IT WAS AS IF THE CAR WAS IN NEUTRAL. HAD ENOUGH MOMENTUM TO REACH THE SIDE OF THE ROAD. PRND WAS LIT UP AND FLASHING AND THE POWER STEERING SYSTEM SYMBOL HAD ERRATIC FLASHING. TRIED PARK, NEUTRAL, REVERSE NOTHING HAPPENED. PUT THE CAR IN PARK AND SHUT OFF ENGINE. RESTARTED ENGINE AND IT ALLOWED US TO DRIVE OFF. WENT APPROXIMATELY 10 MILES DRIVING AT ABOUT 55 MPH, THOUGHT WE SEEN AN ANIMAL AND LET OFF THE ACCELERATOR. UPON TRYING TO ACCELERATE, INCIDENT DESCRIBED ABOVE HAPPENED AGAIN, THIS TIME A CHECK ENGINE LIGHT APPEARED. BEFORE CALLING THE DEALER WE DID A SEARCH AND CAME ACROSS THIS SITE. OUR VEHICLE HAD A DSG TRANSMISSION SERVICE (FOR A COST OF $286.75) AT 43,703 MILES AND THE CAR NOW HAS 71,491 MILES. THIS VEHICLE ALSO HAS A PROBLEM AT TIMES, THAT WAS REPORTED TO THE DEALER ON JUNE 5, 2007 AND NOTHING WAS DONE ABOUT IT, ON COLD START UP, PUTTING IT IN GEAR AND HAVING A VERY SEVERE JERKING, ALMOST TO THE POINT THAT IT MIGHT STALL THE ENGINE. THIS IS A 2006 VW JETTA TDI W/DSG TRANSMISSION. THE MODEL SELECTION ON FOLLOWING PAGE ONLY LISTED A GLI FOR SELECTION. *TR
Power train, Jul 17, 2009
WHEN I BOUGHT MY 2006 VW JETTA TDI THE DSG TRANSMISSION WORKED FINE. AT ABOUT 50,000 MILES THE TRANSMISSION HAS PROGRESSIVELY BECOME ROUGHER AND ROUGHER AND IS NOW BORDERING ON UNSAFE. WHEN I START MOVING FROM A COMPLETE STOP THE CAR JERKS BACK AND FORTH MAKING IT FRIGHTENING TO PULL OUT INTO TRAFFIC. ALSO THE CAR SLAMS INTO THE LOWER GEARS WHEN DOWNSHIFTING. SOMETIMES WHEN I PRESS THE GAS PEDAL FROM A STOP THE CAR HESITATES FOR A FEW SECONDS BEFORE SLAMMING INTO GEAR. WHEN BACKING UP IT IS HARD TO CONTROL BECAUSE OF THE SURGING. UNFORTUNATELY MY CAR IS OUT OF WARRANTY AND I CANNOT AFFORD TO SPEND $3000 TO PAY FOR VW TO FIX THIS KNOW DEFECT IN THE DSG TRANSMISSION. *TR
Power train, Jul 16, 2009
I HAVE A JETTA TDI 2006 DSG. THE DUAL MASS FLYWHEEL RIPPED APART. THIS TOOK OUT THE TRANSMISSION AND CAUSED THE CAR TO BE INOPERABLE. IT COASTED TO THE SIDE OF THE ROAD. THE WAS NO INDICATION OF A PROBLEM PRIOR TO FAILURE. THE FAILURE WAS SUDDEN AND CATASTROPHIC. VW REPLACED THE DUAL MASS FLYWHEEL AND TRANSMISSION. THEY TOLD ME THE OLD PART WAS GOING BACK TO GERMANY FOR INSPECTION. I HAVE NO IDEA OF WHEN IT WILL FAIL AGAIN, NEXT TIME IT MAY CAUSE A CRASH OR DEATH. I HAVE BEEN READING ABOUT THIS, AND A LOT OF DRIVERS OF THIS TYPE OF VEHICLE HAVE THIS ISSUE OF THE FLYWHEEL RIPPING APART. A FLYWHEEL RIPPING APART UNDER THE STRESS OF THE DRIVE TRAIN SHOULD BE RARE, BUT IN THIS VEHICLE IT IS NOT. IT SEEMS THE HIGH TORQUE OUTPUT OF THE DIESEL ENGINE IS CAUSING ADDITIONAL STRESS ON THE FLYWHEEL, THUS BREAKING IT APART. THERE SHOULD BE A RECALL. ALSO, THE DSG TRANSMISSION IS A HYBRID TRANS, IT OPERATES LIKE AN AUTO TRANSMISSION, BUT MECHANICALLY IS MORE LIKE A MANUAL, BUT IT IS NOT THE MANUAL VERSION WHICH IS ALSO OFFERED IN THE JETTA TDI. *TR
Power train, Jul 14, 2009
2006 VW JETTA TURBODIESEL WITH DSG TRANSMISSION AT 27K MILES SHIFTING UNPREDICTABLY AT HIGHWAY SPEED. REPAIRED BY DEALERSHIP, MECHANTRONIC FAILURE. FAILED AGAIN AT HIGHWAY SPEED ONE MONTH LATER, CAUSING POTENTIAL INJURY DO TO FAILURE. SIX MONTHS LATER, FLYWHEEL EXPLODES KNOCKING HOLE IN TRANSMISSION AND CAUSING THE VEHICLE LOSE ALL POWER AND THE ENGINE TO DIE. *TR
Power train, Jul 10, 2009
CLUTCH COMPLETELY FAILED, AS WELL AS FLYWHEEL. NO WARNING, JUST A CATASTROPHIC FAILURE. FORTUNATELY, AT A STOP LIGHT, SO NO ONE WAS INJURED. HOWEVER, IF THIS HAD HAPPENED WHILE DRIVING DOWN THE ROAD, COULD HAVE RESULTED IN DEATH. ALTHOUGH THIS FAILURE IS OCCURRING QUITE FREQUENTLY (IN CARS WITH AS LITTLE AS 400 MILES ON THEM), MANUFACTURER HAS DONE NOTHING TO REMEDY SITUATION, EITHER TO CORRECT IT OR TO COME UP WITH A NEW DESIGN. CURRENTLY AWAITING RESPONSE FROM MANUFACTURER, BUT NO RESOLUTION TO DATE. *TR
Engine and engine cooling, Jul 2, 2009
I HAVE A 2006 JETTA TDI, FAILURE OCCURRED ON INTERSTATE I - 65 ON 7/1/09 I HEARD A POP AS IF SOMETHING FAIL OUT FROM UNDER THE CAR , ALL THE OIL DROPPED OUT OF THE VEHICLE ALL OVER THE INTERSTATE FOR APPROXIMATELY 1 TO 2 MILES. NOTHING HAS BEEN DONE TO CORRECT THE FAILURE. *TR