2006 Volkswagen Jetta
Problems, recalls and owner-reported issues
Power train is the leading concern among 580 owner complaints filed for this model year. This is the 6th highest complaint count among 26 Jetta model years with reports.
Of the 2006 reports, 15 involved a crash and 6 involved a fire. 17 people were injured.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, foundation components, master cylinderSep 23, 2020
Tenneco Automotive (Tenneco) is recalling certain Beck/Arnley Master Cylinders, part number 072-9831, sold as aftermarket or replacement parts for 2004-2018 Volkswagen Jetta, and 2012-2019 Volkswagen Beetle vehicles. The fluid seal crimp on the master cylinder may be insufficient, causing brake fluid to leak or the cylinder to come apart.
If there is a brake fluid leak, it can reduce braking ability, increasing the risk of a crash.
Beck/Arnley will notify the distributors that sold the master cylinders and will work with the distributors to notify the end users. Affected master cylinders will be exchanged for a new master cylinder (part number 072-9990), free of charge. The recall began October 30, 2020. Owners may contact Tenneco customer service at 1-800-625-9319.
Campaign 20E064000 on NHTSA.gov
Engine and engine cooling, engineMar 7, 2014
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
Campaign 14E007000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 10, 2010
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.
IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 10V621000 on NHTSA.gov
Power train, driveline, driveshaftMay 19, 2009
VOLKSWAGEN IS RECALLING 25,594 MY 2006-2009 JETTA 5TH GENERATION EQUIPPED WITH 2.01 ENGINE. THE FASTENING SCREW CONTACT SURFACES ON THE DRIVESHAFT COVER PLATE MAY NOT HAVE BEEN MANUFACTURED TO FACTORY SPECIFICATIONS. SOME SCREWS MAY NOT HAVE BEEN TORQUED PROPERLY DURING ASSEMBLY AND COULD LOOSEN OVER TIME, CAUSING A KNOCKING SOUND WHEN THE VEHICLE IS IN MOTION. THE DRIVESHAFT SCREWS COULD LOOSEN TO THE POINT WHERE THE DRIVESHAFT DETACHES FROM THE GEARBOX.
IF THE VEHICLE IS MOVING WHEN THIS HAPPENS, THE DETACHED DRIVESHAFT COULD CAUSE DAMAGE THE GEARBOX HOUSING. A DAMAGE GEARBOX HOUSING COULD LEAK GEARBOX OIL ONTO THE STREET AND CREATE A RISK OF A VEHICLE CRASH FOR BOTH THE DRIVER AND OTHER MOTORISTS.
DEALERS WILL INSPECT THE DRIVESHAFT SCREWS AND REPLACE THE SCREWS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 24, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 09V164000 on NHTSA.gov
Exterior lighting, headlightsSep 24, 2007
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.
NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 07V442000 on NHTSA.gov
Visibility, windshield wiper/washerJun 25, 2007
CERTAIN VEHICLES EQUIPPED WITH 2.5L GASOLINE ENGINES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST THE UNDERHOOD FUEL SUPPLY LINE.
IF THIS HAPPENS, THE CHAFING HAS THE POTENTIAL TO CAUSE A FUEL LEAK OVER TIME. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR AND WILL ALSO INSPECT AND, IF NECESSARY, REPLACE THE UNDERHOOD FUEL SUPPLY LINE. THE RECALL BEGAN ON AUGUST 24, 2007. OWNERS MAY CONTACT VW AT 1-800-893-5298.
Campaign 07V284000 on NHTSA.gov
Representative owner complaints
580 reports, newest first.
Power train, Jul 27, 2007
I WENT TO STOP AT A LIGHT PUSHED IN MY CLUTCH AND WHEN IT GOT TO THE FLOOR IT CLICKED EVER SO QUIETLY AND WOULDN'T RETURN TO ENGAGED POSITION. I PULLED THE CLUTCH PEDAL BACK UP OFF THE FLOOR AND NOW IT CAN'T BE PUSHED MORE THAN 3/4 OF THE WAY TO THE FLOOR AND IF YOU TRY WHILE THE ENGINE IS RUNNING YOU GET AN AWFUL GRINDING NOISE. CLUTCH PLATE FLEW APART. *JB
Power train, Jul 23, 2007
CLUTCH FLYWHEEL PROBLEMS WITH MY 2006 JETTA TDI. LEFT ME STRANDED ON HIGHWAY WITH ONLY 41 K MILES ON IT. THE VEHICLE IS IN THE SHOP AND UNDER REVIEW. I'M CONCERNED OVER THE NUMBER OF CLUTCH FAILURES AT SUCH LOW MILEAGE. I AM VERY GENTLE WITH MY CLUTCH. *TR
Electrical system, Exterior lighting, Vehicle speed control, Jul 17, 2007
VEHICLE FAILED TO START ON MULTIPLE OCCASIONS DUE TO INSUFFICIENT BATTERY CHARGE. OWNER OBSERVED BRAKE LIGHTS INCLUDING CHMSL WOULD COME ON INDEPENDENTLY WHILE THE VEHICLE WAS PARKED, SHUT OFF, AND UNOCCUPIED WITH NO BRAKE PEDAL APPLICATION. NO OTHER LIGHTS WERE ON AT THE SAME TIME INTERIOR, HEADLIGHTS, TURN SIGNALS WERE ON. THIS WAS PRESUMABLY THE CAUSE OF THE BATTERY DRAIN ISSUE. ON MULTIPLE OCCASIONS AFTER JUMP STARTING THE VEHICLE OWNER OBSERVED LOSS OF POWER WHILE TRYING TO ACCELERATE. INPUT TO THE ACCELERATOR WAS MOMENTARILY INEFFECTIVE AND HAD TROUBLE MAINTAINING HIGHWAY SPEED. THE ENGINE DID NOT STALL AND NO FAULT CODES WERE GENERATED. POWER WAS RESTORED AFTER A FEW SECONDS, BUT THE SYMPTOMS WOULD OCCUR SEVERAL TIMES DURING A DRIVE. VEHICLE WAS BROUGHT TO A VOLKSWAGEN DEALERSHIP SERVICE FACILITY (LINDSAY VW IN STERLING, VA) ON 7/13/2007. THE OWNER DESCRIBED THE ABOVE SYMPTOMS TO THE SERVICE ADVISOR. THE OWNER WAS CALLED LATER ON THE SAME DATE AND TOLD THAT THE DEALERSHIP COULD NOT VERIFY THE CLAIM AND THAT NO REPAIR WAS PERFORMED. TOOK CAR TO A DIFFERENT DEALER (FAIRFAX VW) WHO CORRECTLY DIAGNOSED THE PROBLEM AS A FAULTY BRAKE LIGHT SWITCH. THE REPAIR PART IS THE SAME PART USED IN THE RECALL. THE CAR WAS FIXED UNDER WARRANTY AND THE REPAIR INVOICE EVEN STATES "RECALL" ON IT BUT THE DEALER SAYS MY CAR IS NOT PART OF THE RECALL AND I NEVER RECEIVED NOTIFICATION.
Power train, Jul 7, 2007
AT 65 MPH THERE WAS A BRIEF LOCKUP OF THE FRONT WHEELS, STALLING OF THE ENGINE FOLLOWED BY A LOUD MECHANICAL GRINDING NOISE. STOPPED VEHICLE, POPPED HOOD, NOTED ENGINE TO SHAKE VIOLENTLY TO THE EXTENT THAT THE OIL DIPSTICK CAME LOOSE. BROUGHT VEHICLE TO DEALERSHIP. INFORMED BY SERVICE THAT FAILURE IS DUE TO DISINTEGRATION OF THE DUAL MASS FLYWHEEL LOCATED BETWEEN THE ENGINE AND THE AUTOMATIC TRANSMISSION. DEBRIS FROM THE FLYWHEEL LEAD TO DESTRUCTION OF THE TRANSMISSION HOUSING. LATER, WHEN TALKING TO A MECHANIC, FOUND OUT THAT THIS IS THE SECOND JETTA WITH THE DSG AUTOMATIC TRANSMISSION THAT HAD A DMF FAILURE IN ADDITION TO THREE CATASTROPHIC DMF FAILURES ON MANUAL TRANSMISSION JETTAS). AS THIS HAS THE POTENTIAL TO LEAD TO COMPLETE LOCKUP OF THE FRONT WHEELS AT HIGHWAY SPEEDS WITH POTENTIALLY DIRE CONSEQUENCES, I BELIEVE THAT THIS IS A SAFETY RELEVANT ISSUE THAT MIGHT WARRANT BEING ADDRESSED BY NHTSA. *AK
Tires, Jul 6, 2007
CONTIPRO TIRES. THREE OF THE TIRES ON MY NEW CAR HAVE HAD SIDEWALLS BULGES. THE FIRST I FEEL WAS MY FAULT. I DROVE ON THE TIRE THAT HAD LOW TIRE PRESSURE. BUT THE TWO OTHER TIRES HAVE NOT HAD ANY COMPROMISING SITUATIONS. EACH TIRE HAD LESS THAN 5,000 MILES ON IT. CONTINENTAL TIRE WARRANTY IS A JOKE, THEY HAVE BEEN NO ASSISTANCE. I HAVE NEVER HAD TIRES FAIL ME, I HAVE ALWAYS JUST WORN THEM OUT. *TR
Vehicle speed control, Jul 5, 2007
TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE DRIVING 50 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL, BUT THE VEHICLE FAILED TO DECELERATE. SHE SHIFTED INTO NEUTRAL IN ORDER TO SLOW DOWN THE VEHICLE. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE CURRENT MILEAGE WAS 14,000 AND FAILURE MILEAGE WAS 12,000.
Electrical system, Jul 1, 2007
I HAVE A 2006 VW JETTA TDI WITH AN AUTOMATIC. THE SPEEDOMETER READS 5 MPH FAST AND THEY REFUSE TO FIX IT. I BELIEVE THIS IS A SAFETY ISSUE. *TR
Engine and engine cooling, Power train, Jun 28, 2007
AFTER ABOUT 22,000 MILES THE ENGINE STARTED LOSING POWER, AND THE CLUTCH STARTED MAKING NOISES AND VIBRATIONS UPON ENGAGING/DISENGAGING. THE FIRST TIME IT HAPPENED WE WERE DRIVING ON THE INTERSTATE, SO THE LOSS OF POWER WAS REALLY DANGEROUS. THE DEALERSHIP REPLACED THE WHOLE FLYWHEEL AND CLUTCH ASSEMBLY. *AK
Power train, Jun 23, 2007
I WAS DRIVING MY 2006 VW JETTA TDI ON FREEWAY DOING ABOUT 60 MPH WHEN I NEEDED TO DOWN SHIFT FROM TRAFFIC AND WHEN DEPRESSING THE CLUTCH IT STUCK TO THE FLOOR MANAGED TO GET TO THE SIDE OF THE ROAD CALLED DEALER I BOUGHT THE CAR FROM. THEN TOLD ME TO TRY TO PULL UP THE CLUTCH PEDAL AND IF SO TRY PUMPING THE CLUTCH AND IF FEELS GOOD THEN GIVE IT A TRY. SO I DID ,THE PEDAL CAM UP, I PUMPED IT FELT OK I JUST STARTED THE CAR , SLOWLY RELEASED THE CLUTCH THE CAR SHOT FORWARD AND DIED WITH A CLUNK. SO I HAD THE CAR TOWED TO THE NEAREST DEALER ( NOT MINE ). TALKING TO THE SERVICE REP HE TOLD ME THEIR HAS BEEN A PROBLEM WITH THESE CLUTCHES AND THEY HAD DONE EIGHT OF THE SAME YEAR AND MODEL UNDER WARRANTY . I CALLED TO SEE IF IT WAS READY THEY TOLD ME IT IS NOT COVERED UNDER WARRANTY AND THAT THE CAR WAS READY TO BE PICKED UP AND I OWED THEM $2700.00 FOR THE REPAIRS IE; NEW CLUTCH, PRESSURE PLATE, FLYWHEEL AND BEARING. I COMPLAINED TO NO AVAIL. MY CAR HAS 20,000 MILES AND OTHER PROBLEMS THEY HAVE NOT FIGURED OUT YET. *TR
Power train, Jun 21, 2007
AROUND 12-13K MI A LOT OF STRANGE VIBRATION APPEARED ON THE CLUTCH PEDALS, A LOT OF PULSATION DURING TAKE OFFS AND SHIFTS, SLIGHT GRINDING NOICE DURING SHIFTS, VIBRATION FROM THE ENGINE COMPARTMENT AND THE SHIFT LEAVERAGE AT AROUND 2K RPM. MAKES IT EASY TO STALL ESPECIALY DURING HOT DAYS. DEALER IDENTIFY THE PROBLEM AS THE FAILING DMF AND THROW-OUT BEARING AND POSSIBLY A SPRING/PRESSURE PLATE. THE CLUTCH DISK ITSELF WAS NOT SLIPPING.
Air bags, Jun 20, 2007
AIRBAG LIGHT KEEPS COMING ON WITH AN INTERMITTENT AIRBAG FAULT. 3RD TIME FOR THE REPAIR. THIS HAS BEEN A CONTINUAL PROBLEM SINCE JULY 2006. ONLY 3 MONTHS AFTER PURCHASE. *AK
Engine and engine cooling, Power train, Jun 20, 2007
I WAS DRIVING ON I-80, I MOVED TO THE OFF RAMP , AND WHEN I PUSHED THE CLUTCH, IT WENT ALL THE WAY DOWN TO THE FLOOR. THE 2006 JETTA TDI WITH 26 000 MILES NOW NEEDED A NEW CLUTCH AND FLYWHEEL, $1700 REPAIR BILL. THE NEW CLUTCHA ND FLYWHEEL WERE NOT THE SAME AS THE ORIGINAL. THE REPLACEMENT PARTS HAVE BEEN UPGRADED BY VOLKWAGEN, WHY? MAYBE THE ORIGINAL CLUTCH WAS DEFECTIVE. OR VOLKSWAGEN DID NOT TAKE INTO ACCOUNT THE ADDED TORQUE OF THE NEW PD ENGINE. VERY ANNOYING. *AK
Power train, Jun 15, 2007
GRINDING SOUND WHEN CLUTCH PEDELAL IS DEESSED, SHUDDERING AT TAKE OFF. DEALER AND VW WILL NOT WARRANTY AT 29000 MILES COST OF A NEW CLUTCH $2500. *AK
Power train, Equipment, May 29, 2007
CLUTCH HAS FAILED TWICE WHILE DRIVING. FIRST TIME MARCH 2007 AT 8,000 MILES. CLUTCH AND FLYWHEEL REPLACED AND FAILED AGAIN MAY 2007 AT 10,000 MILES. *TR
Power train, Vehicle speed control, May 21, 2007
THE CAR JUMPS INTO GEAR AND LURCHES BECAUSE OF A HYDRAULIC BRAKE SWITCH IN THE MASTER CYLINDER THAT APPEARS TO TICK OR BE DELAYED IN TRANSMITTING THE ON /FF SIGNAL TO THE ACCELERATOR CIRCUIT WHICH DURING THE DELAY APPEARS UNRESPONSIVE AS IT IS DESIGNED NOT TO ALOW ACCELLERATING IN GEAR WHILE THE BRAKE IS ON. WHEN THE BRAKE SWITCH TURNS OFF , DELAYED UP TO 5 SECONDS, THE CAR LURCHES FORWARD AS THE DRIVER EXPECTS THAT THE ACCELERATOR IS NOT WORKING AND KEEPS PREASSING ON THE GAS. THIS LURCH IS VERY UNSAGFE AND CAUSED BY A STICKY OR DELAYED BRAKE SWITCH. I HAVE HAD THE SWITCH REPLACED ONCE ALREADY BUT ALL OF THE SWITCHES APPEAR TO BEHAVE IN THE SAME UNSAFE, DELAYED MANNER.*AK TO REPRODUCE THE DELAY, PUT AN AUTOMATIC TRANSMISSION 2006 JETTA TDI INTO DRIVE AND WATCH THE "FOOT ON BRAKE" INDICATOR ON THE DASHBORAD TURN OFF 1-5 SECONDS AFTER THE FOOT IS TAKEN OFF THE BRAKE.
Power train, May 18, 2007
TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT SHE FELT THE VEHICLE'S CLUTCH SLIPPING WHILE DRIVING 5 MPH. THE DEALER STATED THAT THE CLUTCH ASSEMBLY NEEDED REPLACING. THE CONTACT STATED THAT SHE EXPERIENCED THE CLUTCH SLIPPING, DIFFICULTY SWITCHING GEARS, AND THE VEHICLE HAS STALLED SINCE THE VEHICLE WAS PURCHASED. THE VIN, PURCHASE DATE, AND ENGINE SIZE WERE UNKNOWN. THE CURRENT MILEAGE IS 33,000 AND FAILURE MILEAGE WAS 31,000.
Power train, May 11, 2007
OUR 2006 VOLKSWAGEN TDI WAS TOWED TO THE DEALER AGAIN YESTERDAY FOR CLUTCH PROBLEMS. AT 2 MONTHS WITH 5,000 MILES THE CLUTCH WOULD INTERMITTENTLY NOT ENGAGE. WAS ABLE TO DRIVE IT TO DEALER , AND DEALER REPLACED MASTER CYLINDER, BLEED SYSTEM AND REASSEMBLED. AT 6 MONTHS, WITH 15,000 MILES THE CLUTCH FAILED, STRANDING US ALONG THE HIGHWAY. HAD IT TOWED TO THE DEALER, WHO REMOVED THE TRANSMISSION, AND INSPECTED DUAL MASS FLYWHEEL. SLIPPED THROW OUT, BEARING CAME APART, THE FORK FOR BEARING SLID INTO PRESSURE PLATE. REPLACED FLYWHEEL, CLUTCH PLATE, PRESSURE THROW OUT BEARING FORK AND SPRING. - AT 9 MONTHS WITH 20,000 MILES TRANSMISSION WHINED IN THIRD GEAR AND HAD A HARSH SHIFT IN ALL GEARS. WHILE DRIVING TO DEALER THE CAR POPPED OUT OF GEAR. DEALER FOUND TRANSMISSION LEAKING FLUID FROM BELL HOUSING. CALLED VOLKSWAGEN, AND WAS TOLD TO CHECK FOR CRACKS IN CASE. REMOVED CASE ,AND INSPECTED FOR CRACKS. HAD HAIRLINE CRACKS. REMOVED AND REPLACED TRANSMISSION, AND REASSEMBLED AND ADDED FLUID." THIS REPAIR TOOK THE LONGEST AS THE DEALER HAS TO WAIT FOR PARTS. THE CAR WAS AT THE DEALER THIS TIME FOR OVER THREE WEEKS. 4- 10 MONTHS WITH 22,000 MILES THREE WEEKS AFTER LAST REPAIR WE WERE AGAIN STRANDED AT THE SIDE OF THE ROAD. AT A STOP SIGN DEPRESSED CLUTCH, PUT CAR IN FIRST, STARTED TO MOVE AND CAR MADE A LOUD NOISE AND CLUTCH WAS DEAD AGAIN. TOWED TO DEALER ,AND WE ARE WAITING TO HEAR AGAIN FROM THEM. BOTH MY HUSBAND AND I HAVE BEEN DRIVING STICK SHIFT FOR OVER 20 YEARS EACH. OUR DEALER HAS NEVER SUGGESTED THAT WE DON'T KNOW HOW TO DRIVE A STICK SHIFT ALTHOUGH I HAVE SEEN ONLINE THIS WAS OFTEN SAID AS SOON AS THE CLUTCH WENT OUT. EVERYTHING SO FAR HAS BEEN REPLACED AT NO COST TO US. THE MANUAL TRANSMISSION WAS VERY UNRELIABLE, AND IN HEAVY TRAFFIC IT COULD EASILY LEAD TO AN ACCIDENT. LUCKILY, WHILE WE DRIVE MANY MILES IT WAS MOSTLY COUNTRY HIGHWAYS. *AK
Service brakes, Hydraulic, Power train, Apr 25, 2007
IN JANUARY SOMETHING BROKE OFF FROM THE TRANSMISSION AND KILLED THE ENTIRE ENGINE. IT GOT A NEW ENGINE AND A NEW TRANSMISSION. THAT HAS LED TO A SLEW OF OTHER DIFFERENT PROBLEMS FROM MINOR RATTLES TO DANGEROUS EXHAUST LEAKS AND OIL LEAKS. CORPORATE VW WAS ONLY ABLE TO GIVE ME TWO MONTHS CREDIT ON MY LOAN WHICH FROM READING EVERYWHERE IS JUST THEIR WAY OF GETTING US TO SHUT UP. NOW MY REAR BRAKES ARE METAL TO METAL AND I HAVE A BEARING PROBLEM. I HAVE READ THAT THIS IS A COMMON PROBLEM BUT MY SERVICE DEPARTMENT STATES THAT I CAUSED IT BY HITTING A CURB WHICH IN TURN RUINED THE BEARING. I THINK THE BEARING WAS RUINED WHEN THEY PUT IN THE NEW ENGINE AND SCREWED WITH THE TORQUE. *TR
Service brakes, Hydraulic, Air bags, Apr 12, 2007, crash
WIFE STATED THAT WHEN SHE HIT BRAKES IT WAS HARD TO STOP CAR ,DID NOT SLOW, REAR ENDED A SUV AT ABOUT 30 MPH WHICH PUSHED FRONT END UP TO WINDSHIELD ABOVE BUMPER, PUSHED ENGINE INTO FIREWALL. SHE INCURRED MAJOR SEAT BELT BRUISING WITH NO AIR BAG DEPLOYMENT. AFTER INSPECTION THE INSURANCE COMPANY FOUND THAT TWO SENSORS HAD BEEN DISTORTED ALONG WITH CRACKED ENGINE MOUNTS AND BENT CRADLE. THEY TOTALED THE CAR DUE IN PART TO NO AIR BAG DEPLOYMENT,T AND FELT THAT THE CAR WOULD BE UNSAFE AFTER REPAIRS. AFTER CONTACTING VOLKSWAGEN, THEY SAID THAT AIR BAG DEPLOYMENT SHOULD NOT HAVE HAPPENED. BUT WHAT IF MY WIFE HAD JUMPED INTO THE CAR AND FORGOT TO PUT THE SEAT BELT ON SHE WOULD HAVE GONE THROUGH THE WINDSHIELD. I FEEL THAT THIS IS A MAJOR SAFETY DEFECT SINCE MOST ACCIDENTS WOULD OVER RIDE THE BUMPER DUE TO LOW BUMPER HEIGHT. VOLKSWAGEN DOES NOT SEEM TO THINK THIS IS A PROBLEM FROM THE PICTURES I SENT THEM AND OUR TALK ON THE PHONE. *AK
Air bags, Apr 2, 2007
THE MANUFACTURER OF MY VEHICLE AND THE DEALER HAVE INFORMED ME THAT MY VOLKSWAGEN TDI'S WIRING HARNESS WAS CRUSHED DUE TO A FOREIGN OBJECT UNDERNEATH THE SEAT. ALTHOUGH I AM CONTESTING THAT THE OBJECT IS MINE, I DO THINK IT IS OF CONCERN THAT THE WIRING HARNESS IS NOT SECURED OR PROTECTED IN ANY WAY, AND ANY OBJECTS THAT SLIDE UNDERNEATH THE SEAT MAY CRUSH THIS HARNESS AND MAY POSSIBLY RENDER THE AIRBAG SYSTEM USELESS. *JB
Power train, Mar 9, 2007
TL*- THE CONTACT STATED THAT AFTER DRIVING THE 2006 VOLKSWAGEN TDI DIESEL AND COMING TO A STOP SHE PUT THE VEHICLE IN PARK AND THE VEHICLE CONTINUED TO ROLL ABOUT 4-6 INCHES FURTHER. THE CONTACT STATED THAT THIS WAS A SAFETY PROBLEM, IF SOMEONE WERE IN FRONT OF THE VEHICLE IT COULD HIT HIM/HER. THIS WAS NOTICED AFTER BUYING THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALERSHIP AND WAS INFORMED THAT THERE WAS NO ADJUSTMENT TO BE MADE ON THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO ANOTHER DEALERSHIP CALLED WALLACE VOLKSWAGEN IN TENNESSEE. HE STATED THAT THE SERVICE MANAGER WAS WAITING FOR A VOLKSWAGEN REPRESENTATIVE TO COME IN TO THE DEALERSHIP AND HAVE HIM LOOK AT THE VEHICLE. THE SALES MANAGER INFORMED THE CONTACT THAT THIS WAS A PROBLEM. THE FAILURE MILEAGE WAS 40 MILES AND THE CURRENT MILEAGE WAS 24,800.*AK CONSUMER STATES WHILE GETTING OIL CHANGE THE DEALER WAS NOTIFIED OF THE PROBLEM BY ADJUSTING CABLE ON GEAR SHIFT BUT TO NO AVAIL THE PROBLEM IS STILL YET TO BE FIXED. 4/23/07*TR
Exterior lighting, Mar 4, 2007
THE HIGH BEAM HEADLAMP ASSEMBLIES ON MY 2006 VOLKSWAGEN JETTA TDI ARE DESIGNED IN A MANNER THAT I FEEL IS EXTREMELY DANGEROUS. THE DESIGN OF THESE HEADLAMPS IS SUCH THAT THE HIGH BEAMS CANNOT BE ADJUSTED INDEPENDENTLY OF THE LOW BEAMS. WHEN THE LOW BEAMS ARE AIMED CORRECTLY, THE HIGH BEAMS ARE AIMED FAR TOO HIGH TO BE EFFECTIVE. THIS HEADLAMP DESIGN COULD MOST DEFINITELY RESULT IN AN ACCIDENT AND I DO NOT UNDERSTAND HOW THEY ARE EVEN CONSISTENT WITH THE DOT LIGHTING CODE. *JB
Power train, Feb 25, 2007
CLUTCH FLYWHEEL PROBLEMS WITH MY 2006 JETTA TDI. LEFT ME STRANDED ON HIGHWAY WITH ONLY 37 K MILES ON IT. DEALER SAYS NOT COVERED UNDER WARRANTY AS WEAR AND TEAR, THIS IS THE SECOND TIME IT HAS NEEDED TO BE REPLACED IN 1 YEAR. WE WERE EXITING OFF OF A HIGHWAY AND THE CLUTCH STAYED DEPRESSED STUCK TO THE FLOOR AND THE TRANSMISSION WAS NOT WORKING. *NM
Service brakes, Hydraulic, Feb 15, 2007
28K MILES... REAR BRAKES WORN DOWN INTO THE METAL, REQUIRING NEW REAR BRAKES AND ROTORS. FRONT HAVE 75% REMAINING. VW AUTHORIZES $150 ASSISTANCE ON LABOR BUT REFUSES TO CALL BRAKES DEFECTIVE. *NM
Engine and engine cooling, Power train, Feb 13, 2007
WHEN STARTING IN DRIVE, AT A STOP LIGHT, CAR DOES NOT ACCELERATE AS IT WOULD NORMALLY WOULD, BUT JUST CREEPS FORWARD FROM 3 TO 10 SECONDS, THEN IT BEGINS TO ACCELERATE NORMALLY. *JB