2006 Volkswagen Jetta
Problems, recalls and owner-reported issues
Power train is the leading concern among 580 owner complaints filed for this model year. This is the 6th highest complaint count among 26 Jetta model years with reports.
Of the 2006 reports, 15 involved a crash and 6 involved a fire. 17 people were injured.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, foundation components, master cylinderSep 23, 2020
Tenneco Automotive (Tenneco) is recalling certain Beck/Arnley Master Cylinders, part number 072-9831, sold as aftermarket or replacement parts for 2004-2018 Volkswagen Jetta, and 2012-2019 Volkswagen Beetle vehicles. The fluid seal crimp on the master cylinder may be insufficient, causing brake fluid to leak or the cylinder to come apart.
If there is a brake fluid leak, it can reduce braking ability, increasing the risk of a crash.
Beck/Arnley will notify the distributors that sold the master cylinders and will work with the distributors to notify the end users. Affected master cylinders will be exchanged for a new master cylinder (part number 072-9990), free of charge. The recall began October 30, 2020. Owners may contact Tenneco customer service at 1-800-625-9319.
Campaign 20E064000 on NHTSA.gov
Engine and engine cooling, engineMar 7, 2014
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
Campaign 14E007000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 10, 2010
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.
IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 10V621000 on NHTSA.gov
Power train, driveline, driveshaftMay 19, 2009
VOLKSWAGEN IS RECALLING 25,594 MY 2006-2009 JETTA 5TH GENERATION EQUIPPED WITH 2.01 ENGINE. THE FASTENING SCREW CONTACT SURFACES ON THE DRIVESHAFT COVER PLATE MAY NOT HAVE BEEN MANUFACTURED TO FACTORY SPECIFICATIONS. SOME SCREWS MAY NOT HAVE BEEN TORQUED PROPERLY DURING ASSEMBLY AND COULD LOOSEN OVER TIME, CAUSING A KNOCKING SOUND WHEN THE VEHICLE IS IN MOTION. THE DRIVESHAFT SCREWS COULD LOOSEN TO THE POINT WHERE THE DRIVESHAFT DETACHES FROM THE GEARBOX.
IF THE VEHICLE IS MOVING WHEN THIS HAPPENS, THE DETACHED DRIVESHAFT COULD CAUSE DAMAGE THE GEARBOX HOUSING. A DAMAGE GEARBOX HOUSING COULD LEAK GEARBOX OIL ONTO THE STREET AND CREATE A RISK OF A VEHICLE CRASH FOR BOTH THE DRIVER AND OTHER MOTORISTS.
DEALERS WILL INSPECT THE DRIVESHAFT SCREWS AND REPLACE THE SCREWS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 24, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 09V164000 on NHTSA.gov
Exterior lighting, headlightsSep 24, 2007
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES MAY CONTAIN A CAP THAT DISABLES THE VERTICAL AIMING SCREW.
NONCOMPLIANCE CAN INHIBIT PROPER HEADLAMP AIM ADJUSTMENT FOR ROADWAY ILLUMINATION, IMPROPERLY AIMED HEADLAMPS COULD CAUSE REDUCED ROAD VISIBILITY, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE LOW BEAM HORIZONTAL AIMING SCREW AND INSTALL ONE IF MISSING, AND INSPECT FOR THE PRESENCE OF A CAP IN THE SOCKET OF THE VERTICAL AIMING SCREW AND IF PRESENT, THE CAP WILL BE REMOVED. THE RECALL WILL BEGIN ON OCTOBER 31, 2007. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 07V442000 on NHTSA.gov
Visibility, windshield wiper/washerJun 25, 2007
CERTAIN VEHICLES EQUIPPED WITH 2.5L GASOLINE ENGINES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST THE UNDERHOOD FUEL SUPPLY LINE.
IF THIS HAPPENS, THE CHAFING HAS THE POTENTIAL TO CAUSE A FUEL LEAK OVER TIME. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
DEALERS WILL REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR AND WILL ALSO INSPECT AND, IF NECESSARY, REPLACE THE UNDERHOOD FUEL SUPPLY LINE. THE RECALL BEGAN ON AUGUST 24, 2007. OWNERS MAY CONTACT VW AT 1-800-893-5298.
Campaign 07V284000 on NHTSA.gov
Representative owner complaints
580 reports, newest first.
Electrical system, Aug 1, 2013
ALL ELECTRONIC COMPONENTS IN DRIVERS DOOR CEASED TO FUNCTION. AUTO DOOR LOCK, DRIVER'S WINDOW, GAS LATCH. COULD NOT OPEN DRIVER'S WINDOW. APPARENTLY THE ORIGINAL DESIGN OF WIRE HARNESS WAS DEFECTIVE IN THAT IT WAS 80 MM TOO SHORT. VW HAS ISSUE A TECHNICAL SERVICE BULLETIN ON APRIL 20, 2011 (V97-11-04) IDENTIFYING THIS INHERENT DEFECT. DEALER REPLACED DRIVER'S DOOR WIRING HARNESS AFTER DIAGNOSING MULTIPLE BROKEN WIRES. VW WILL NOT REIMBURSE CAR OWNERS FOR REPAIR/REPLACEMENT. *TR
Power train, Jul 13, 2013
IN THE MORNING I WENT TO START MY CAR AND I SHIFTED IT INTO REVERSE AND THERE WAS A LOUD NOISE. I THEN WENT TO DRIVE IT AND THE TRANSMISSION WOULD NOT SHIFT OUT OF THIRD GEAR. *TR
Steering, Electrical system, Jun 28, 2013, crash
I WAS ACCELERATING FROM A STOP SIGN AND I HEARD A NOTIFICATION "BEEP" ON MY CAR'S DASHBOARD. I LOOKED DOWN TO SEE WHAT WAS WRONG AND SUDDENLY MY STEERING LOCKED UP ON ME. HAVING NO CONTROL OF MY CAR, I DRIFTED INTO A CAR PARKED ON THE RIGHT SIDE OF THE STREET, CAUSING MY CAR TO FLIP OVER. *TR
Air bags, Jun 7, 2013, crash
I SWERVED TO MISS AN ANIMAL AND RAN OFF THE ROAD AT 55MPH AND HIT A TREE HEAD ON AND THE DRIVER AIRBAG NEVER DEPLOYED. SPOKE TO VW CUSTOMER CARE AND WAS TOLD THAT THEIR ENGINEERS LOOKED AT THE PHOTOS NOT THE ACTUAL CAR AND DETERMINED THAT THEY FUNCTIONED PROPERLY. I SAID I THOUGHT THEY WERE SPEED RATED AND WAS TOLD THAT II COULD HIT A WALL AT 100MPH AND THE AIRBAG MIGHT NOT GO OFF. ARE YOU KIDDING ME!!! *TR
Electrical system, Engine, May 29, 2013
THE VEHICLE STALLS WHENEVER DRIVING IN WET CONDITIONS ON THE HWY WHILE SNOWING OR RAINING. I HAVE LOST CONTROL OF THE VEHICLE AND HAVE BROKEN DOWN ON THE SIDE OF THE ROAD WITH NO SHOULDER AND FACING AN UPHILL INCLINE. ON EACH OCCASION I HAVE HAD MY CHILDREN IN THE VEHICLE WITH ME AND FACING HEAVY TRAFFIC IN BOTH DIRECTIONS. I WAS FORTUNATE TO HAVE A HIGHWAY PATROL OFFICER ASSIST ME IN PUSHING THE CAR TO OFF THE HIGHWAY THE LAST 3 TIMES. EACH TIME, THEY INFORMED ME THAT I SHOULD CONTACT VOLKSWAGEN AND LET THEM KNOW BECAUSE IT SHOULD DEFINITELY BE A FACTORY RECALL BASED ON THE DANGEROUS CIRCUMSTANCES. THE PROBLEM HAS BEEN IDENTIFIED ON TDI FORUMS HTTP://FORUMS.TDICLUB.COM/SHOWTHREAD.PHP?T=239987&PAGE=6 AS A WIRE CHAFING CONDITION CAUSED BY THE VIBRATION OF THE DIESEL ENGINE. I TOOK MY VEHICLE TO THE REPAIR SHOP 3 DIFFERENT TIMES AND THEY WERE UNABLE TO IDENTIFY THE PROBLEM BECAUSE EACH TIME I WAS ABLE TO GET THE VEHICLE TO THE SHOP THEY WERE UNABLE TO MATCH THE DRIVING CONDITIONS THAT I WAS DRIVING IN AND EACH TIME I WAS ABLE TO START THE VEHICLE AFTER ALLOWING THE VEHICLE TO SIT FOR A PERIOD OF TIME IN ORDER TO ALLOW THE ENGINE COMPARTMENT TO DRY. *TR
Engine, May 15, 2013
ENTIRE CAMSHAFT HAS TO BE REPLACED, CAR IS INOPERABLE. THIS IS APPARENTLY A KNOWN ISSUE BUT VW OF AMERICA WILL NOT ACKNOWLEDGE THIS OR HELP WITH THE REPLACEMENT COST, WHICH IS SUBSTANTIAL. *TR
Seats, Apr 24, 2013
DRIVER'S SEAT, LOWER RIGHT SIDE OF SEAT BACK: NOTICED A DISCOLORATION & CHANGE IN THE FABRIC AT LEAST ONE YEAR AGO. MORE RECENTLY, TWO PINHOLES HAVE APPEARED IN THE AREA. WITHOUT A DOUBT, THIS HAS BEEN CAUSED BY THE HEATED SEAT ELEMENT. IN RETROSPECT, WE REALIZE THAT SEVERAL ARTICLES OF CLOTHING - PRIMARILY OUTERWEAR - WERE DAMAGED BY THE EXCESS HEAT FROM THAT AREA OF THE SEAT. BECAUSE IT WAS OUTERWEAR, THAT PROBABLY ACCOUNTS FOR WHY WE NEVER FELT THE INTENSE, LOCALIZED HEAT. NO INJURIES RESULTED. BUT AFTER READING ABOUT ALMOST 200 SIMILAR COMPLAINTS FOR THE JETTAS BUILT AROUND THAT TIME, SOME RESULTING IN INJURIES AND / OR FIRES, I'M SURPRISED THERE HAVE BEEN NO RECALLS. *TR
Power train, Apr 17, 2013
THE DSG CLUTCH ON THE 2006 VW JETTA TDI LOST STRUCTURAL INTEGRITY AND CAME APART COMPLETELY WHILE DRIVING, DESTROYING THE AUTOMATIC CLUTCH AND POTENTIALLY THE TRANSMISSION. THE SPRINGS ARE SO DAMAGED THAT THEY WERE EJECTED FROM THE CASING ONTO THE ENGINE PROTECTION MATT UNDERNEATH THE VEHICLE. THERE IS EXTENSIVE DAMAGE TO THE CLUTCH WHICH WILL NEED TO BE REPLACED COMPLETELY AND POTENTIAL TRANSMISSION DAMAGE. *TR
Electrical system, Mar 17, 2013
THIS IS SECOND TIME THE WIRE HARNESS SUPPLYING ELECTRICAL COMPONENTS IN THE DRIVER SIDE DOOR HAVE BROKEN. THIS BREAKAGE CAUSES THE CRASH SENSOR TO BECOME INACTIVATING ALONG WITH OTHER CRITICAL ELECTRICAL FUNCTIONS IN THE DOOR, IE WINDOW, LOCK, FUEL DOOR. THIS ALSO HAS A POTENTIAL FOR STARTING A FIRE. WHEN I HAD MY CAR IN FOR A IGNITION LOCK PROBLEM ABOUT A YEAR AGO, THE THERE WAS A COMMENT TYPED ON THE SERVICE REPORT INDICATING THAT THE HARNESS APPEAR IN GOOD REPAIR. THIS ENTRY REVEALS THAT VOLKSWAGEN IS VERY AWARE THAT THEY HAVE A PROBLEM, HOWEVER, THEY ARE DOING NOTHING TO RESOLVE IT. *TR
Engine and engine cooling, Mar 13, 2013
THE OIL PAN IN THE ABOVE MENTIONED VECHILE THAT I OWN HAD TO BE CHANGED DUE TO A DESIGN PROBLEM. THE MANUFACTURER HAD PUT A ALUMINUM PAN WITH A STEEL BOLT. THE STEEL BOLT OVER THE YEARS CORRODED THE PAN NECESSIATING A REPLACEMENT OF THE PAN. FITZGERALD AUTOMALL (410-224-3480) IN ANNAPOLIS MD REPLACED THE PAN FREE OF LABOR BUT CHARGED ME FOR THE OIL PAN. THEY DID INFORM ME THAT IT WAS A DESIGN PROBLEM THAT VW HAS SINCE RECTIFIED IN THE NEWER MODELS AND THAT I HAD TO CONTACT THE MANUFACTURER FOR REIMBURSEMENT. WHEN I CONTACTED VW, THEY REFUSED TO REIMBURSE ME STATING THAT THE VEHICLE WAS NOT UNDER WARRANTY. THEY INFORMED IT WAS UNDER THEIR DISCRETION TO RECTIFY THE DEFECT IN NEWER MODELS AND WERE NOT RESPONSIBLE FOR OLDER MODELS. IN MY OPINION VW SHOULD REIMBURSE ME AND ALSO RECALL ALL THEIR VEHICLES WITH THIS ISSUE TO BE ADDRESSED APPROPRIATELY. PLEASE CONTACT ME AT THE ABOVE ADDRESS IF SOMETHING CAN BE DONE ABOUT THIS OR NOT.[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Engine, Mar 1, 2013
TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT THERE WAS A RATTLING NOISE IN THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED HIM THAT THE PIPING HAD BECOME LOOSE. THE VEHICLE WAS REPAIRED BY APPLYING A RUBBER GUARD HOWEVER, THE FAILURE RECURRED IMMEDIATELY AFTER THE REPAIRS. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THEY ADVISED HIM THAT THE DUEL MASS FLYWHEEL FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 36. THE CURRENT MILEAGE WAS APPROXIMATELY 160,000.
Air bags, Feb 15, 2013
AIR BAG WARNING LIGHT APPEARED, DEALER DIAGNOSED AS A PASSANGER SIDE AIR BAG FAILURE, RHEOSTAT IN AIR BAG WAN'T HEATING PROPERLY & BAG WOULD THEREFORE NOT IGNITE AT IMPACT. *TR
Fuel system, Diesel, Power train, Engine, Fuel/propulsion system, Feb 3, 2013
MY WIFE AND I WERE DRIVING HOME AND SUDDENLY MY CAR STARTED JERKING AND MADE A "KNOCKING" SOUND, WITHOUT ANY WARNING (I.E. CHECK ENGINE LIGHT). WE WERE CLOSE TO HOME AND DECIDED TO CONTINUE ON; HOWEVER, IN THE NEXT COUPLE OF MILES, THE PROBLEMS PERSISTED, STILL WITH NO CHECK ENGINE LIGHT OR ANY INDICATION OF WHAT WAS WRONG WITH THE VEHICLE. OVER THE NEXT SEVERAL DAYS, WHILE PARKED ON A SECURED PREMISE, I STARTED THE CAR UP AND IT HAD AN ERRATIC LOPING SOUND. I PROCEEDED TO CALL A NEARBY VOLKSWAGEN DEALER AND SPOKE TO TWO CERTIFIED VW MECHANICS, WHO FAILED TO ACKNOWLEDGE THE ISSUE THAT THERE WAS NO WARNING INDICATION BEFORE THE CAR STARTED TO ACT UP AND SAID TO BRING IT IN TO SWAP OUT THE ENGINE AT APPROX. $7500; THEY DISMISSED THE PROBLEM AS "NORMAL WEAR AND TEAR". I RESEARCHED THE PROBLEM ON THE INTERNET AND IT LEAD ME TO BELIEVE THAT IT WAS A PROBLEM WITH THE CAM, WHICH I HAD CONFIRMED BY AN AUTO-MECHANIC AFTER TOWING THE CAR IN. HE TOLD ME THE ENTIRE ENGINE WAS WARPED DUE TO THE CAM GOING OUT. OTHER 2006 VW JETTA TDI OWNERS HAVE COMMENTED ON THE SAME ISSUES, WHICH AT THIS POINT LEADS ME TO BELIEVE THAT IT IS NOT "NORMAL WEAR AND TEAR", BUT A MANUFACTURE DEFECT. *TR
Electrical system, Air bags, Jan 31, 2013
I HAVE A 2006 VW JETTA SD W/ 93,000 MILES. I USE THIS VEHICLE FOR WORK. THE AIR BAG FAULT LIGHT HAS BEEN ON FOR ALMOST TWO YEARS. I INITIALLY TOOK THE CAR TO THE DAVID MAUS VW IN SOUTH ORLANDO. I WAS TOLD BY THE REPAIR REP KEVIN IT WOULD COST $400 TO REPAIR THE CONNECTOR LOCATED UNDER THE DRIVER SEAT THAT RELATE TO THE AIR BAG SYSTEM. SINCE MY CAR WAS OUT OF THE WARRANTY PERIOD, I WAS TOLD I WOULD HAVE TO BEAR THIS COST. I ASKED [XXX] HOW THE CONNECTORS WOULD BECOME FAULTY SINCE THERE IS NOTHING EVER STORED UNDER MY DRIVER SEAT AND NO ONE GOES UNDER THE DRIVER SEAT. [XXX] SAID THAT ??IT JUST HAPPENS.?? I TOLD HIM I WAS DISAPPOINTED VW HAD MADE SUCH A FAULTY CAR BECAUSE OF THE MANY PRIOR PROBLEMS I HAD THAT FORTUNATELY WERE COVERED UNDER WARRANTY, E.G., ESP LIGHT CONTINUALLY ON; IGNITION COILS RECALLED/REPLACED; ASR LIGHT CONTINUALLY LIT; TRUNK LATCH REPLACED, AIR CONDITIONING VENTS BROKE, DRIVER SIDE DOOR WOULD NOT LOCK/UNLOCK; AND DRIVER SIDE BUTTON STOPPED WORKING. AFTER THE WARRANTY ENDED, THE AIR BAG LIGHT CAME ON. I PAID TO REPLACE THE BUTTON FOR THE SIDE VIEW MIRRORS BECAUSE IT BROKE OFF. [XXX] TOLD ME THE BUTTON WAS CHEAP AND THEY ALWAYS BREAK. A RECALL FOR THE SIDE AIR BAG HARNESS ON SEATS WERE REPAIRED ON BOTH SIDES ON 3/30/11. IN OCTOBER, 2011 I TOLD [XXX] I DID NOT BELIEVE I SHOULD BE RESPONSIBLE TO PAY FOR THE REPAIR OF THE AIR BAG LIGHT AS I BELIEVED IT WAS A DEFECT ON VW PART. I COULD NOT HAVE CAUSED THE LIGHT TO COME ON BY DRIVING THE VEHICLE. I WAS INFORMED BY [XXX] THAT WITHOUT THIS REPAIR THE AIRBAG SYSTEM WAS CONSIDERED TO BE INOPERABLE AND UNSAFE. AFTER REVIEW OF THE NHTSA COMPLAINTS AND AN INTERNET SEARCH, THIS AIRBAG ISSUE WITH THIS VEHICLE HAS BEEN A KNOWN ONE FOR SOME TIME. VW HAS NOT ISSUED A RECALL BECAUSE THEY DO NOT BELIEVE IT IS A LARGE CONCERN. I BELIEVE A RECALL SHOULD BE ISSUED DUE TO THE OBVIOUS SAFETY CONCERNS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Electrical system, Latches/locks/linkages, Jan 24, 2013
FIRST, VEHICLE'S ELECTRONIC LOCKS STOP RESPONDING TO DEPRESSES FROM BOTH REMOTES. REPLACE THE BATTERIES TO THE REMOTE AND STILL THE CAR WILL NOT RESPOND. THE ONLY WAY TO OPEN THE DOOR IS BY MANUALLY INSERTING THE KEY INTO THE DRIVERS SIDE, WHICH IS THE ONLY MANUAL KEYHOLE, AND TURNING LEFT TWICE. ONCE TURN UNLOCKS THE DRIVER'S SIDE DOOR, ANOTHER TURN UNLOCKS THE PASSENGER DOORS. AFTER SOME TIME PASSENGER DOORS STOP RESPONDING TO SECOND TURN. PASSENGER DOORS DO NO LOCK WHEN MANUALLY TURNING KEY THE RIGHT FROM THE DRIVER SIDE DOOR, WHICH IS THE ONLY MANUAL KEYHOLE. THE PASSENGER DOORS THAT DO NOT LOCK CAUSE THE ALARM TO GO OFF WHEN OPENED. DEPRESSING THE SILENCE ALARM BUTTON ON KEY FOB DOES NOT SILENCE ALARM. THE ONLY WAY TO SILENCE ALARM IS BY CLOSING PASSENGER DOOR, CLOSING DRIVER SIDE DOOR AND TURNING KEY RIGHT ONCE TO LOCK AND LEFT TO UNLOCK. DOING SO ONLY CONTROL DRIVER SIDE DOOR. AFTER SOME TIME DASHBOARD SHOWS "DOOR OPEN" SYMBOL EVEN WHEN ALL DOORS ARE SECURELY CLOSED AND INDICATOR LIGHT ON DOOR IS OFF. DOME LIGHT STAYS ON WHILE DRIVING AS IF THE DOORS ARE INDEED OPEN EVEN THOUGH THEY ARE SECURELY CLOSED. AT THIS STAGE THE ALARM SYSTEM NO LONGER WORKS EITHER BY KEY FOB DEPRESS NOR BY MANUALLY TURNING THE LOCK IN THE DRIVERS SIDE DOOR AS DESCRIBED EARLIER. DOORS MUST BE LOCKED BY OPENING EACH ONE MANUALLY AND PRESSING THE LOCK DOOR BUTTON LOCATED ON EACH PASSENGER DOOR. PRESSING THE DRIVERS SIDE DOOR LOCK DOES NOT LOCK PASSENGER DOORS. ALL FUSES ARE INTACT AND NO ELECTRICAL ISSUES REPORTED. *TR
Power train, Jan 14, 2013
TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED WHILE DRIVING 70 MPH THE TRANSMISSION DISENGAGED AND THE VEHICLE WOULD NOT ACCELERATE. THE TRANSMISSION POSITION LIGHTS WERE ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. A DEALER WAS NOTIFIED OF THE SYMPTOMS AND STATED THEY KNEW THE CAUSE OF FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 146,000.
Power train, Jan 4, 2013
TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE CLUTCH FAILED AND THE CONTACT WAS UNABLE TO SHIFT GEARS. THE VEHICLE WAS SHUT OFF AND TOWED TO A PRIVATE MECHANIC, WHERE IT WAS DETERMINED THAT THE DRIVESHAFT FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V164000 (POWER TRAIN:DRIVELINE:DRIVESHAFT). THE FAILURE MILEAGE WAS 127,000.
Power train, Vehicle speed control, Dec 12, 2012
WHILE TRAVELING ON INTERSTATE 4 AT 65 MPH THE AUTOMATIC TRANSMISSION WENT FROM DRIVE TO SECOND GEAR BY ITSELF EVEN THOUGH THE GEAR SELECTOR WAS IN DRIVE, NEARLY PUTTING ME THROUGH THE WINDSHIELD HAD I NOT HAD MY SEAT BELT ON. I MANAGED TO GET ONTO THE BURM OF THE HIGHWAY AND STOP. AT THIS POINT TRANSMISSION FLUID WAS DUMPING ALL OVER THE ROAD AND THE CAR WOULD NO LONGER MOVE AND THE DIGITAL GEAR SELECTION LIGHT WAS FLASHING ON AND OFF CONTINUOUS(PRND). HAD IT TOWED TO MY VW MECHANIC AND THEY FOUND THAT THE ELECTRONIC VALVE ASSEMBLY HAD QUIT WORKING AND THAT THE MECH TRONIC CLUTCH ASSEMBLY WAS DESTROYED BY IT GOING FROM DRIVE TO 2ND . AFTER RESEARCHING ON THE INTERNET, I FOUND THAT VW HAS KNOWN ABOUT THIS PROBLEM AND HAS SENT OUT LETTERS TO CUSTOMERS THAT HAVE 2007-2010 VEHICLES WITH THIS SAME TRANSMISSION THAT THEY WOULD REPLACE THEIR DEFECTIVE TRANSMISSIONS UNDER AN EXTENDED WARRANTY OR RE-IMBURSE THEM FOR REPAIRS IF DONE PRIOR TO THIS LETTER UP TO 100000 MILES. I CONTACTED VW USA AND ASKED ABOUT MY CAR AND WAS TOLD BECAUSE MY CAR WAS A 2006 IT WASN'T COVERED EVEN THOUGH I GOT THEM TO ADMIT THAT IT WAS THE SAME TRANSMISSION THAT WAS USED FOR 2005.5 THROUGH 2010. *TR
Electrical system, Exterior lighting, Air bags, Nov 10, 2012
2006 VW JETTA, DRIVING DOWN STREET 11/09/12 DOOR AJAR LIGHT COMES ON, I STOP TO CLOSE DOORS AND LIGHT GOES OFF. I PULL INTO WORK PARKING LOT AND GET OUT OF CAR AS I CLICK THE KEY TO LOCK THE CAR, NOTHING. I THEN PROCEED TO CHECK THE CAR.. NOTHING IS WORKING. CANNOT ACCESS GAS CAP TO PUT GAS IN CAR, SOME LIGHTS MAY NOT BE FUNCTIONING PROPERLY, AIRBAG LIGHT NOT ON, DOOR WILL NOT LOCK, WINDOW WILL NOT RESPOND, NO CAR ALARM. DRIVERS SIDE OF CAR HAS NO POWER AT ALL. I HAVE NO IDEA WHAT IS AND IS NOT WORKING CORRECTLY. ALTHOUGH I DID LOOK ONLINE AND FOUND HUNDREDS OF COMPLAINTS WITH REGARD TO A "BROWN WIRE OR WIRES TOO SHORT INSIDE THE BOOT TO THE BODY CONNECTOR". MOST PEOPLE REPORT THAT EVEN AFTER A VW FIX, PROBLEM NOT RESOLVED. CAR NOT ACTING PROPERLY AND WITH ELECTRICAL AND HAVING BEEN IN A VW CAR FIRE DO NOT WISH TO REPEAT THIS SCENARIO. I CONTACTED VW CUSTOMER CARE WHO POLITELY TOLD ME THIS IS NOT THEIR PROBLEM AND REFUSED TO ESCALATE TO A MANAGER. SINCE THIS JUST HAPPENED TODAY I HAVE NOT HAD AN OPPORTUNITY FOR VW TO LOOK AT IT, BUT WILL TOMORROW AS I HAVE TO FIND A WAY TO PUT GAS IN CAR AND SEE IF THEY FEEL AUTO IS SAFE TO DRIVE. I DON'T.. *TR
Power train, Nov 9, 2012
I WAS ON A FREEWAY THAT WAS MERGING WITH ANOTHER FREEWAY, AND THE GEAR LIGHTS STARTED FLASHING, THE TRANSMISSION QUIT, AND I COULDN'T ACCELERATE TO GET OUT OF OTHER VEHICLES WAY. I WAS DOING 10 MPH, AND I HAD TO CROSS TWO LANES OF TRAFFIC DOING 65 MPH. NOWHERE TO GO BUT THAT. I WAS SO SCARED AND WAS REALLY LUCKY THAT NO ONE HIT ME, ALTHOUGH THEY DID HAVE TO HIT THEIR BRAKES HARD AND SWERVE TO AVOID ME. THIS IS SOMETHING I'VE SEEN ON DIFFERENT FORUMS NOW, AND EVERYONE SAYS IT IS A MECHATRONIC UNIT GONE BAD. *TR
Seats, Nov 5, 2012
I WAS DRIVING DOWN THE ROAD WITH THE HEATED SEAT ON , I HAD IT ON 5 WHICH IS THE MAX SETTING AND I FELT A BURNING SENSATION NEAR MY RIGHT SHOULDER AREA SO I FELT MY BACK AND THOUGHT WOW SO I TURNED IT DOWN AND AFTER PULLING IN MY GARAGE I LOOKED AND THE SEAT WAS SLIGHTLY MELTED ABOUT THE SIZE OF A GOLF BALL AND MY JACKET WAS SLIGHTLY MELTED I AM GOING TO CONTACT MY LOCAL DEALER TOMORROW TO SEE IF THERE'S A RECALL (BEWARE IT COULD HAVE RESULTED IN FIRE I BELIEVE IF I WOULD HAVE KEPT IT ON LONG ENOUGH.) *TR
Power train, Oct 16, 2012
TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED WHILE DRIVING 30 MPH, THE TRANSMISSION FAILED. THE CONTACT STATED HE HEARD A LOUD NOISE UNDERNEATH THE ENGINE. THE VEHICLE WAS TAKEN TO A REPAIR SHOP FOR INSPECTION WHERE THE MECHANIC STATED THE DUAL MASS FLY-WHEEL AND TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 60,000.
Air bags, Oct 15, 2012, crash
TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, HE ATTEMPTED TO AVOID CRASHING INTO A CAT AND LOST CONTROL OF THE VEHICLE. THE CONTACT THEN CRASHED INTO A TREE. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS DESTROYED AND THE CONTACT SUSTAINED A GRADE THREE CONCUSSION AS WELL AS FRACTURED RIBS. THE POLICE WERE NOTIFIED AND A REPORT WAS FILED) POLICE REPORT NUMBER:CA1200564). THE CONTACT COULD NOT RECALL SPECIFIC DETAILS OF THE CRASH DUE TO HIS INJURIES. THE MANUFACTURER WAS NOTIFIED AND AFTER PERFORMING AN INVESTIGATION, THEY ADVISED THE CONTACT THAT THE VEHICLE HAD PERFORMED IN THE MANNER THAT IT WAS DESIGNED, OFFERING NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 50,000.
Engine, Oct 4, 2012
VEHICLE LOST POWER. ENGINE BECAME LOUDER. CAR SHUDDERS UNDER ACCELERATION. CAMSHAFT FAILURE. CAMSHAFT MUST BE REPLACED. KNOWN ISSUE WITH THIS CAR. *TR
Structure, Visibility/wiper, Sep 17, 2012
THE HEADLINER IS PULLING AWAY FROM THE REAR PILLARS. BEING THE PRIMARY DRIVER OF THE VEHICLE I DO NOT SPEND TIME IN THE BACK SEAT. MY DAUGHTER IS CURRENTLY LEARNING TO DRIVE SO ON A RECENT ERRAND I WAS SITTING IN THE BACK SEAT AND LOOKED UP TO SEE THE HEADLINER COMPLETELY PULLING AWAY AND COMING DOWN FROM THE ROOF OF THE CAR AND DOME LIGHT. WHEN I GOT BACK HOME, I DID SOME INTERNET RESEARCH AND FOUND A MULTITUDE OF WEBSITES, FORUMS, ETC. WITH PEOPLE EXPERIENCING THE SAME ISSUE. HERE ARE JUST A FEW OF THE ADDRESSES THAT I FOUND: HTTP://WWW.CARCOMPLAINTS.COM/VOLKSWAGEN/JETTA/2006/ACCESSORIES-INTERIOR/HEADLINER_SEPARATING_FROM_CEILING.SHTML HTTP://RICH-BLOG.BLOGSPOT.COM/2010/10/2006-VOLKSWAGEN-JETTA-TDI-HEADLINER-PROBLEMS.HTML HTTP://FORUMS.VOLKSWAGENVORTEX.COM/SHOWTHREAD.PHP?5104886-SAGGING-FALLING-HEADLINER-WARRANTY-SUCCESS-STORIES-PLEASE HTTP://WWW.CARS-GUIDE.COM/VOLKSWAGEN-FORUM/2006-VOLKSWAGEN-JETTA-HEADLINER-T4941.HTML ADDITIONALLY, I PERSONALLY KNOW ANOTHER 2006 JETTA OWNER IN SCHENECTADY, NY WITH THE EXACT SAME ISSUE. AS THE HEADLINER FALLS, IT IS CREATING A VISUAL DISTRACTION AS WELL AS IMPAIRING MY FIELD OF VISION TO THE REAR OF THE VEHICLE. *TR