2009 Volkswagen Jetta
Problems, recalls and owner-reported issues
Fuel system is the leading concern among 904 owner complaints filed for this model year. This is the highest complaint count among 26 Jetta model years with reports.
Of the 2009 reports, 31 involved a crash and 8 involved a fire. 17 people were injured.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, foundation components, master cylinderSep 23, 2020
Tenneco Automotive (Tenneco) is recalling certain Beck/Arnley Master Cylinders, part number 072-9831, sold as aftermarket or replacement parts for 2004-2018 Volkswagen Jetta, and 2012-2019 Volkswagen Beetle vehicles. The fluid seal crimp on the master cylinder may be insufficient, causing brake fluid to leak or the cylinder to come apart.
If there is a brake fluid leak, it can reduce braking ability, increasing the risk of a crash.
Beck/Arnley will notify the distributors that sold the master cylinders and will work with the distributors to notify the end users. Affected master cylinders will be exchanged for a new master cylinder (part number 072-9990), free of charge. The recall began October 30, 2020. Owners may contact Tenneco customer service at 1-800-625-9319.
Campaign 20E064000 on NHTSA.gov
Other or unspecifiedSep 25, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and Beetle Convertible, 2008-2010 Beetle, and Beetle Convertible vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Volkswagen will notify owners and repurchase the affected vehicles. The recall began November 6, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01D7. Note: This recall is an expansion of NHTSA recall number 18V-329.
Campaign 19V679000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slipDec 20, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.
A loss of vehicle control can increase the risk of a crash.
Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.
Campaign 16V913000 on NHTSA.gov
Fuel system, dieselOct 3, 2011
VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.
DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.
VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 11V490000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 10, 2010
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.
IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 10V621000 on NHTSA.gov
Power train, automatic transmissionAug 20, 2009
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.
THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.
VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 09V333000 on NHTSA.gov
Power train, driveline, driveshaftMay 19, 2009
VOLKSWAGEN IS RECALLING 25,594 MY 2006-2009 JETTA 5TH GENERATION EQUIPPED WITH 2.01 ENGINE. THE FASTENING SCREW CONTACT SURFACES ON THE DRIVESHAFT COVER PLATE MAY NOT HAVE BEEN MANUFACTURED TO FACTORY SPECIFICATIONS. SOME SCREWS MAY NOT HAVE BEEN TORQUED PROPERLY DURING ASSEMBLY AND COULD LOOSEN OVER TIME, CAUSING A KNOCKING SOUND WHEN THE VEHICLE IS IN MOTION. THE DRIVESHAFT SCREWS COULD LOOSEN TO THE POINT WHERE THE DRIVESHAFT DETACHES FROM THE GEARBOX.
IF THE VEHICLE IS MOVING WHEN THIS HAPPENS, THE DETACHED DRIVESHAFT COULD CAUSE DAMAGE THE GEARBOX HOUSING. A DAMAGE GEARBOX HOUSING COULD LEAK GEARBOX OIL ONTO THE STREET AND CREATE A RISK OF A VEHICLE CRASH FOR BOTH THE DRIVER AND OTHER MOTORISTS.
DEALERS WILL INSPECT THE DRIVESHAFT SCREWS AND REPLACE THE SCREWS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 24, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 09V164000 on NHTSA.gov
Representative owner complaints: diesel
195 reports, newest first. Show all
Fuel system, Diesel, Sep 18, 2011
ACCORDING TO VW THE HPFP WENT OUT. THIS SEEMS TO BE AN ONGOING PROBLEM WITH THE 2009 JETTAS. *TT
Fuel system, Diesel, Aug 21, 2011
MY VEHICLE EXPERIENCES BRIEF HESITATION DURING ACCELERATION USUALLY IN 3RD GEAR AND IT OCCURS INTERMITTENTLY, SOMETIMES 2-3 TIMES/DAY AND SOMETIMES 2-3 TIMES/WEEK. SOMETIMES IT FEELS VERY MINOR, LIKE THE ENGINE WAS STARVED FOR FUEL AND SOMETIMES IT IS MORE SEVERE, AND THE WHOLE CAR JERKS. I HAVE A MANUAL TRANSMISSION AND HAVE EXPERIENCED IT AND REPORTED IT TO THE DEALER MULTIPLE TIMES WITH REPLICATION ONLY ONCE, WHEN THE SERVICE MANAGER WAS RIDING WITH ME. HE ORDERED A PART AND REPLACED IT AND THEY HAVE DOWNLOADED ECM UPDATES MULTIPLE TIMES WITH NO RESULTS. *TR
Fuel system, Diesel, Aug 20, 2011
CAR WAS BEING DRIVEN IN TOWN. GLOW PLUG LIGHT AND CHECK ENGINE LIGHT CAME ON. CAR WAS DRIVEN TO PARKING LOT AND ENGINE STOPPED. WOULD NOT RESTART. TOWED TO AUTOBAHN VW IN FORT WORTH AND FUEL PUMP FAILURE DIAGNOSED. CAR IS 2009 JETTA TDI WITH 47,300 MILES. FUEL WAS PURCHASED AT RACETRACK WHERE WE ALWAYS BUY. TANK WAS DOWN TO HALF FULL. *TR
Fuel system, Diesel, Aug 19, 2011
FILLED FULL TANK JULY 17TH, 2011, WITHIN 120 MILES, 3 COMPLETE ENGINE SHUTDOWNS WHILE DRIVING. BROUGHT TO DEALERSHIP. TESTED AND 17.10 HOURS REPAIR. RAIL FUEL PRESSURE TOO LOW. REMOVED PRESSURE SENSOR ON INJECTION PUMP. FOUND METAL INSIDE PUMP. METAL THROUGHOUT FUEL SYSTEM. CONTACTED TECH ASSISTANCE. REPLACED ALL PARTS AS ADVISED. REPLACED FUEL TANK. REPLACED FUEL LINES. REPLACED FUEL INJECTORS. REPLACED HIGH PRESSURE FUEL PUMP. REPLACED LOW PRESSURE FUEL PUMP. REPLACED AUXILIARY FUEL PUMP. REPLACED FUEL FILTER. DRAINED FUEL IN OLD FUEL TANK AND PUT IN 5 GALLONS OF FRESH DIESEL IN NEW TANK. REPLACED FUEL RAIL. INJECTOR LINES. INITIAL DIAGNOSTIC CONSISTED OF FUEL PRESSURE TEST INSPECTION OF CONTAMINANTS IN FUEL. BASICALLY THE DEALERSHIP TOLD ME THIS IS COVERED UNDER THE DRIVETRAIN WARRANTY, BUT MY FUEL WAS CONTAMINATED. I ONLY USED 1/10TH OF A TANK OF BIOFUEL ONCE LIKE A YEAR AGO. I HAVE CONTACTED SHELL TO SEE IF THAT TANK OF FUEL HAD ANY PREVIOUS COMPLAINTS AND NONE MENTIONED. ALL IN ALL $6,500 IN PARTS. *TR
Engine and engine cooling, Fuel system, Diesel, Aug 18, 2011
CAR STUTTERED AND THEN STALLED. ENGINE WOULDN'T RESTART. DRIVING 35MPH IN RESIDENTIAL AREA. *KB
Fuel system, Diesel, Aug 9, 2011
VEHICLE IS A 2009 VOLKSWAGEN DIESEL JETTA SPORTWAGEN, VIN [XXX]. VEHICLE SERVICED AT THE VW DEALERSHIP FOR THE FULL 40,000 MILE SERVICE AT ACTUAL MILEAGE 40,525. ON TRIP A FEW DAYS LATER AT 41,070 THE HIGH PRESSURE FUEL PUMP FAILED, CONSEQUENCES WERE A DANGEROUS SITUATION DUE TO (1) BEING SUDDENLY WITHOUT POWER TO MOVE THE VEHICLE WITH OTHER VEHICLES APPROACHING BEHIND ME, AND ONCOMING. HAD TO PUSH THE VEHICLE TO A SAFE PLACE; (2) TEMPERATURES WERE OVER 100 F, LEAVING ME AND MY PASSENGERS IN DANGER UNTIL WE COULD BE RESCUED; (3) I HAD TO PAY FOR A TOW OF THE FAILED VEHICLE THEN RENT ANOTHER VEHICLE TO CONTINUE MY TRIP AND WILL HAVE TO DRIVE OVER 400 MILES IF/WHEN THE VEHICLE IS REPAIRED TO PICK IT UP. THIS IS A HUGE UNEXPECTED EXPENDITURE. VEHICLE WAS TOWED TO THE NEAREST DEALERSHIP AND IS AWAITING PARTS. AS I UNDERSTAND IT, METAL SHAVINGS FROM THE PUMP FAILURE TRASH THE ENTIRE FUEL SYSTEM AND ALL PARTS MUST BE REPLACED WITH NEW ONES. AT BEST, I WILL BE WITHOUT A CAR FOR 7 TO 10 DAYS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Fuel system, Diesel, Aug 8, 2011
DURING ACCELERATION ON A COLD ENGINE (FIRST MILE) THE ENGINE WILL OCCASIONALLY STUMBLE AND LOSE POWER ALL TOGETHER. ON SEVERAL OCCASIONS IT HAS SIMPLY TURNED OFF. AS IT IS A STICK SHIFT, I ASSUMED IT WAS MY FAULT AT FIRST. NOW THAT I AM ACCUSTOMED TO THE CAR, IT STILL HAPPENS, PARTICULARLY THE STUMBLING IN THE FIRST MILE. IT FEELS AS IF IT TURNS OFF AND ON... NO WARNING LIGHTS COME ON, BUT IT DEFINITELY HAS NO POWER FOR ABOUT A SECOND OR SO AND THEN LURCHES. IT ONLY SEEMS TO HAPPEN IN COOLER WEATHER. NOW THAT IT IS IN THE HUNDREDS IN HOUSTON, IT DOESN'T HAPPEN. WHEN I TOOK IT FOR AN OIL CHANGE LAST MONTH (JULY 2011), THEY DID A "SOFTWARE UPDATE AS WELL." THAT MAY HAVE SOLVED IT, BUT IT ALSO AM EXPERIENCING SEVERELY DECREASED FUEL ECONOMY. IT WENT FROM AVERAGE HIGH 30S TO LOWER 40S TO THE LOWER 30S AND UPPER 20S AS OF LATE. I WAS TOLD THEY WILL LOOK INTO IT WHEN I BRING IT IN FOR THE NEXT OIL CHANGE.... *TR
Fuel system, Diesel, Aug 8, 2011
OWNER OF AN 2009 VW JETTA TDI, WHICH AFTER BEING TOWED TO THE DEALER WAS TOLD THE HPFP FAILED DUE TO CONTAMINATED DIESEL FUEL. AFTER LOOKING AT FORUMS AND RESEARCH ON THE INTERNET, I FOUND THIS TO BE RECURRING ISSUE ON THIS MODEL. I HAVE USED THE SAME FUELING STATION (SHELL) AND THE SAME DIESEL PUMP FOR THE YEAR AND A HALF, AND GETTING STATEMENTS FOR THE PRIOR OF THAT TIME FROM MY FUEL CARD MAILED TO ME. ON JULY 29, I WAS DRIVING ON A SECONDARY ROAD, WHEN WITHOUT NOTICE, MY CAR STALLED AND LOST ALL POWER, AND NEVER RESTARTED. I HAD THE CAR TOWED TO THE DEALER THAT I HAD PURCHASED IT, AND TAKE TO DO MY SCHEDULED MAINTENANCE, AND RECEIVED THE NEWS OF THE FUEL PUMP ISSUE ON THE FOLLOWING MONDAY. I WAS TOLD THAT HE DEALER HAS CONTACTED THE REGIONAL VW OFFICE, BUT I HAVE NOT HEARD ANY RESPONSE. I ALSO CALLED THE VW ADVOCATE ON AUG. 5, AND WAS TOLD GIVEN A CASE NUMBER AND WAS TOLD THAT A CASE MANAGER WOULD BE CALLING ME OR ABOUT AUG. 8, AND TODAY, AUG. 8, I READ ON THE INTERNET THAT THERE IS ANOTHER INVESTIGATION INTO VW TDI'S AND I'M GROWING CONCERN ON THIS ISSUE. I WAS TOLD THAT MY REPAIRS WOULD COST ABOUT $9000, WHICH IS HALF OF WHAT I PAID FOR THE CAR, AND WAS TOLD THAT THERE WAS NO GUARANTEE IT WOULD HAPPEN IN THE FUTURE, WHICH MAKES ME UNHAPPY WITH VW, I BELIEVE THAT VW NEEDS TO ADDRESS THIS ISSUE. *TR
Fuel system, Diesel, Aug 4, 2011
MY 2009 VW TDI SPORTWAGEN WITH LESS THAN 22,000 MILES LOST POWER AND STALLED AS I PULLED INTO A BUSY INTERSECTION. DASHBOARD DISPLAY SHOWED "ENGINE FAULT WORKSHOP." I ATTEMPTED TO RESTART ENGINE. THE ENGINE RAN A FEW SECONDS AND STALLED AGAIN WITH SAME DISPLAY WARNING. I COASTED OFF THE ROADWAY. THE VEHICLE WOULD THEN NOT RESTART AT ALL. MY VEHICLE WAS TOWED TO DEALER NEXT DAY WHERE THEY DETERMINED THAT MY HPFP (HIGH PRESSURE FUEL PUMP) HAD DISINTEGRATED AND CONTAMINATED THE ENTIRE FUEL SYSTEM. DEALER TRIED TO SAY MY DIESEL FUEL WAS CONTAMINATED BY GASOLINE. I PERSONALLY FUEL THE CAR EACH TIME FROM A LOCAL DIESEL STATION WHICH IS OWNED AND OPERATED BY A DIESEL ENTHUSIAST FAMILY. THEY DO NOT EVEN HAVE A GASOLINE PUMP ON SITE! VW AGREED TO FIX THE CAR UNDER WARRANTY BUT STATED THE ESTIMATE FOR THE JOB WOULD RUN BETWEEN $7000 - $10,000 IF NOT COVERED. THE VEHICLE HAS BEEN IN THE SHOP FOR 15 DAYS SO FAR AND IS NOT YET REPAIRED. A CALL TO VOLKSWAGEN OF AMERICA REVEALED THAT THEY ARE AWARE OF NUMEROUS INCIDENTS OF THIS NATURE IN THEIR NEW CLEAN DIESEL VEHICLES, BUT THAT THEY ARE BLAMING THE PROBLEM ON THE LOW QUALITY OF THE U S FUEL SUPPLY WITH RESPECT TO POOR LUBRICITY. THEY STATED THEY ARE REPLACING MY FUEL PUMP WITH THE SAME PART NUMBER AS THE ORIGINAL. THEY HAVE REFUSED TO RECALL THE CAR SO FAR OR EXTEND THE WARRANTY ON THE REPLACEMENT COMPONENTS. *TR
Fuel system, Diesel, Jul 29, 2011
CAR LOST ENGINE POWER WHEN ONE CRUISE CONTROL ON THE INTERSTATE. LUCKILY IT WASN'T BUSY AT THE TIME. HAD TO SLOWLY COAST OFF THE SIDE OF THE ROAD WITHOUT POWER TO THE ENGINE. WOULDN'T RESTART AFTER. *TR
Fuel system, Diesel, Jul 14, 2011
TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 TO 10 MPH THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE HIGH PRESSURE FUEL PUMP FAILED, ALLOWING METAL TO PENETRATE THE FUEL SYSTEM. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 75,000.
Fuel system, Diesel, Jul 10, 2011
CAR FAILED TO START AT HOME ON JUNE 1, 2011 AT ABOUT 44.3K MILES. HIGH PRESSURE FUEL PUMP (HPFP) FAILED AND REPLACED BY DEALER ON JUNE 10, 2011. I'M AWARE OF THE ONGOING ENGINEERING ANALYSIS PHASE OF THE NHTSA INVESTIGATION OF FAILURES OF THE HPFP. HAD MY CAR STARTED, IT LIKELY WOULD HAVE STALLED ON THE HIGHWAY (LIKE MANY OTHERS) AND AT MINIMUM LEFT ME STRANDED AND POSSIBLY CAUSED AN ACCIDENT. I PUT EVERY DROP OF ULSD IN THE TANK (NOT A MISFUEL) AND HAVE RECEIPTS SHOWING SUCH STARTING AT ABOUT 20K MILES. AT ABOUT 26K MILES MY FUEL FILTER HAD SHINY VISIBLE METAL SPECKS ON TOP (LIKELY ALUMINUM FROM THE HPFP) AND WHAT LOOKED LIKE A COATING OF "DUST" ON THE TOP OF THE FILTER. DEALER DID THE 20K FUEL FILTER REPLACEMENT AND I INSPECTED MY FUEL FILTER FOR CONTAMINATION AT ABOUT 22K MILES AND THE FUEL FILTER TOP WAS PRISTINE. SO, THE SHINY SPECKS DEVELOPED BETWEEN 26K AND 22K MILES. AT 26K, THE DEALER REPLACED FUEL FILTER AND CLEANED FUEL FILTER CANISTER, INSPECTED METERING VALVE AND FUEL TANK FOR CONTAMINATION. DEALER FOUND A FEW SPECKS IN THE TANK. AT 40K MILES I REPLACED MY FUEL FILTER AS PART OF ROUTINE MAINTENANCE AND THERE WERE STILL SOME VISIBLE SPECKS BUT NOT THE "DUST" COATING. I CUT OPEN A SMALL SECTION OF THE FILTER (ABOUT 2 INCHES BY 6 INCHES) AND FOUND SEVERAL VISIBLE SPECKS. WHAT I DON'T KNOW IS IF THE SPECKS WERE REMNANTS FROM THE 26K MILE INCIDENT OR CONTINUAL WEARING OF THE HPFP WHICH LED TO FAILURE ON JUNE 1. *TR
Fuel system, Diesel, Jun 24, 2011
1. THE CAR'S GLOW PLUG LIGHT STARTED FLASHING AND THE CAR LOST POWER AND STALLED. 2. THE CAR STOPPED RUNNING SUDDENLY. PER THE DEALER, IT WAS CAUSED BY THE FUEL PUMP EXPLODING. *TR 3. THE ENTIRE FUEL SYSTEM, INCLUDING THE TANK, WAS REPLACED BY THE DEALER.
Fuel system, Diesel, Jun 14, 2011
TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA WAGON TDI. THE CONTACT WAS DRIVING 28 MPH WHEN THE VEHICLE SUDDENLY STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND THE MANUFACTURER WAS LATER CONTACTED VIA EMAIL. THE CONTACT WAS STILL AWAITING A RESPONSE. THE CONTACT PERFORMED A DIAGNOSTIC TEST ON THE VEHICLE WHICH CONFIRMED A FAULTY HIGH PRESSURE FUEL PUMP FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 21,436.
Fuel system, Diesel, Jun 8, 2011
I PURCHASED A CERTIFIED 2009 VW JETTA TDI ON 5/5/2011. ON 6/3/2011 I HAD A INTERMITTENT CK ENGINE LIGHT. FOUND IT TO BE FUEL DELIVERY RELATED. CK OF FUEL FILTER FOUND ALOT OF FINE METALLIC SHAVINGS PRESENT, I REQUESTED MAINTENANCE HISTORY AND FOUND THIS VEHICLE HAD A HPFP FAILURE IN THE PAST AT 43366 MILES IT CURRENTLY HAS 50700 MILES. THIS VEHICLE HAS A LONG HESITATION TO ENGAGE IN DRIVE AND REVERSE, ALSO HAD A MEGATRONIC UNIT FAILURE. ALL FILTERS WERE REPORTED REPLACED AT 49,129 I LEFT IT ON THE LOT AND BOUGHT A 2011 MODEL. I HAVE A HARD TIME BELIEVING THE DEALER WAS NOT UNLOADING THIS CAR..AND TOLD ME IT WOULD BE RE-CERTIFIED AND SOLD AGAIN ON THEIR LOT. I HAD IT FOR ONE MONTH AND LOST 2000 DOLLARS ON IT. *TR
Fuel system, Diesel, May 27, 2011
CHECK ENGINE LIGHT ON AND GLOW PLUG LIGHT FLASHES. THERE IS A FLUTTER IN ENGINE RPM. ALSO THERE ARE METAL SHAVINGS IN FUEL FILTER. THE DEALER "DEAN MCCRARY VW" SAID CAR NEEDED EXHAUST TEMP SENOR AND IT DID FIX LIGHTS THAT WERE COMING ON. AS FAR AS METAL IN THE FUEL THEY TOLD ME THEY DIDN'T SEE ANY JUST TO KEEP DRIVING IT UNTIL THERE WAS A PROBLEM???. I HAVE A JAR OF THE FUEL THAT CAME OUT OF THE FUEL FILTER! OBVIOUSLY THERE WAS SOME SORT OF ISSUE METAL SHAVINGS IN FUEL FILTER CANNOT BE NORMAL. OBVIOUSLY THERE WAS NOT GOING TO BE METAL IN FUEL FILTER AT THIS POINT BECAUSE I HAVE CLEANED IT BEFORE BROUGHT INTO THE SHOP. BUT I TOLD THEM IT WAS FULL OF METAL AND I HAD A SAMPLE OF FUEL THEY COULD LOOK AT. THEY JUST SAID KEEP DRIVING IT AND WAIT UNTIL SOMETHING HAPPENS? I BELIEVE THEY HAVE A FUEL PUMP PROBLEM I DON'T UNDERSTAND WHY I SHOULDN'T GO AHEAD AND REPLACE THE FUEL PUMP IF ITS PUMPING METAL INTO MY FUEL SYSTEM. *TR
Fuel system, Diesel, May 23, 2011
TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA DIESEL TDI. THE CONTACT WAS DRIVING APPROXIMATELY 15 MPH WHEN THE VEHICLE SUDDENLY STALLED WITH THE ILLUMINATION OF A WARNING LIGHT. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE AND IT WAS TOWED TO THE DEALER. THE VEHICLE WAS INSPECTED BY THE DEALER AND THEY ADVISED HIM THAT THE FUEL WAS CONTAMINATED. THE VEHICLE WAS REPAIRED FOR THE ENTIRE FUEL SYSTEM. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 45,000. THE VIN WAS UNAVAILABLE.
Engine and engine cooling, Fuel system, Diesel, Power train, May 16, 2011
MY 2009 JETTA TDI ENGINE STARTED RUNNING ROUGH WHEN I PUSHED THE CLUTCH IN WHILE TURNING INTO A PARKING LOT 3 WEEKS AGO. I COASTED TO A PARKING SPOT AND TURNED OFF THE IGNITION. I STARTED THE CAR BACK UP IMMEDIATELY TO SEE IF IT WAS GOING TO BE OK AND IT SOUNDED GOOD SO I SHUT IT OFF. WHEN I RETURNED ABOUT 45 MINUTES LATER, THE CAR STARTED BUT SOUNDED LIKE IT WAS RUNNING ON ONLY ONE OR TWO CYLINDERS AND THEN DIED. I CALLED A TOW TRUCK AND IT WOULD NOT START AT ALL WHEN HE ARRIVED. THE DEALER ASKED IF I HAD EVER RUN GASOLINE THROUGH IT. I SAID 'NO, WHY WOULD I DO THAT?' HE SAID THAT THE ENTIRE FUEL SYSTEM NEEDED TO BE REPLACED AND THAT VW WOULD PAY FOR THIS 'ONE TIME' EVEN THOUGH THE WARRANTY HAS RUN OUT. WELL, IF THEY ARE AT FAULT THIS TIME, THEY WILL BE AT FAULT THE NEXT TIME TOO. MY CONCERN IS THE NEXT TIME. I DRIVE ON A 70 MPH INTERSTATE 90 MILES ROUND TRIP TO WORK 5 DAYS A WEEK. WHAT ARE THE CHANCES THAT I WILL BE LUCKY ENOUGH THAT IT DID NOT HAPPEN IN TRAFFIC AT THAT SPEED THE FIRST TIME AND JUST WHERE WILL I BE WHEN IT HAPPENS AGAIN? IF THEY ARE REPLACING THIS SHREDDED HIGH PRESSURE FUEL PUMP WITH THE SAME MODEL MADE OF THE SAME MATERIALS, IT WILL HAPPEN AGAIN. IS THERE ETHANOL BEING PUT INTO DIESEL IN THIS COUNTRY? WHAT ABOUT THE ADDITIVES TO DIESEL THAT ARE NECESSARY FOR LUBRICITY THAT ARE PUT IN BY THE DIFFERENT COMPANIES? IS ONE OR MORE TYPES OF THESE THE CULPRIT? THIS PROBLEM IS ALL OVER THE INTERNET AND I HOPE THAT VW CAN COME UP WITH A PERMANENT SOLUTION BEFORE SOMEONE IS SERIOUSLY INJURED - IF IT HASN'T HAPPENED ALREADY. MEANWHILE - STILL WAITING FOR MY CAR TO BE RETURNED TO ME.
Fuel system, Diesel, May 15, 2011
I WAS DRIVING THE VEHICLE AND IT SUDDENLY STARTED TO LOSE POWER AND WITHIN SECONDS STOPPED COMPLETELY. THE VEHICLE FAILED TO START SO I HAD IT TOWED TO A REPAIR SHOP. ON INSPECTION THE MECHANIC FOUND METAL SHAVINGS THROUGHOUT THE FUEL SYSTEM INCLUDING THE FUEL INJECTORS. ON FURTHER INSPECTION IN WAS DISCOVERED THAT THE HIGH PRESSURE FUEL PUMP (HPFP) HAD FELL APART INTERNALLY SENDING METAL BITS ALL THROUGHOUT THE FUEL SYSTEM CAUSING THE VEHICLE TO SHUTDOWN. THE ENTIRE FUEL SYSTEM WAS REPLACED INCLUDING THE THREE FUEL PUMPS(ONE IN THE FUEL TANK, AND THE OTHERS AT THE ENGINE COMPARTMENT INCLUDING THE HPFP), FUEL LINES, INJECTORS, FUEL RAIL, FUEL FILTERS, AND ALL THE SENSORS IN THE FUEL SYSTEM. BASICALLY ANYWHERE THE FUEL FLOWED THROUGH HAD TO BE REPLACED. THE FUEL TANK WAS NOT REPLACED BUT THOROUGHLY CLEANED. ALL THE OLD PARTS ARE IN MY POSSESSION AND SHOW THE GROUND UP METAL THROUGHOUT. *TR
Fuel system, Diesel, Apr 25, 2011
MY JETTA HAS BEEN STUMBLING EVERY ONCE IN AWHILE FOR QUITE SOME TIME NOW. JUST A COUPLE DAYS AGO IT HAS BEGUN STALLING ALTOGETHER AND I DO NOT KNOW WHAT THE CAUSE IS YET. BASICALLY WHEN I GET TO A CRUISING SPEED OR AM SLOWING DOWN SLIGHTLY WHERE I STILL HAVE MY FOOT ON THE GAS PEDAL BUT AM SLOWING DOWN SLOWLY, THE CAR ALL OF A SUDDEN LOSES ALL POWER AND WHEN I STEP ON THE PEDAL MORE NOTHING HAPPENS. I TAKE IT OFF AND AFTER A SECOND OR SO I STEP ON IT AGAIN AND THE CAR FINALLY ACCELERATES. I AM TAKING IT INTO THE SHOP TODAY TO BE DIAGNOSED. *TR
Fuel system, Diesel, Apr 4, 2011
AUTOMOBILE STALLING, ROUGH RUNNING, LOSS OF POWER, HARD START. HAPPENS ALL THE TIME WITH TEMPERATURE'S ABOVE 40 DEGREES F. HAPPENED FROM THE DAY I TOOK IT OFF THE LOT. HAVE HAD IT IN TO VW MULTIPLE TIMES, COMPUTER "RE-FLASHED" NOBODY KNOWS WHAT IS GOING ON. FROM WHAT I READ ON TDI FORUM'S IT COULD BE THE HPFP HIGH PRESSURE FUEL PUMP, OR SOMETHING IN THE EMISSIONS THAT JUST IS NOT RIGHT. THIS IS VERY DANGEROUS BECAUSE I HAVE HAD THE STALL HAPPEN ON THE HIGHWAY. THE NTSB NEEDS TO GO AFTER VW ASAP TO GET A RECALL ON THESE VEHICLES, IF THE HPFP FAILS IT IS A 10K FIX, THAT IS 50% OF THE VALUE OF THE CAR, UNACCEPTABLE. *TR
Engine and engine cooling, Fuel system, Diesel, Apr 2, 2011
TODAY IS APRIL 2, 2011. I WAS DRIVING MY 2009 JETTA TDI ON THE HIGHWAY WHERE MY ENGINE DIED ON ME RIGHT BEFORE MY COIL LIGHT WENT OFF WHILE DOING 60+ MILES. I HAD MY CAR TOWED TO THE VW DEALERSHIP IN STRATFORD CT. WHILE WAITING I STARTED TO LOOK UP ANY INFORMATION ON ISSUES RELATED TO MINE BECAUSE MY CAR TURNED ONLY 2 YEARS OLD MARCH 15 2011. I HAD HEARD ON THE RADIO ON CAR TALK THAT TDI WERE SHUTTING DOWN ON THE HIGHWAYS AND THAT IT WAS BEING LOOKED INTO BY THE NHTSA. I ALSO READ DOZENS OF OTHER STORIES ONLINE WITH RELATED ISSUES WHICH IN THE END COST THEM A FEW THOUSAND TO TEN THOUSAND TO FIX ON RELATIVELY NEW CAR. I HAVE READ IT IS DUE TO HPFP NEEDING TO BE REPLACED WHICH WAS DAMAGED WHEN FUELED UP WITH INCORRECT FUEL. BASICALLY VW IS SAYING THAT METAL PARTICULATES ARE IN THE FUEL FILTERS AND SYSTEM DUE TO PUTTING GAS INSTEAD OF DIESEL. THEY ARE TELLING THIS SUPPOSED CATCH ALL TO EVERYONE WITH THIS ISSUE. I HAVE NEVER PUT ANYTHING OTHER THAN DIESEL INTO MY CAR. THE WARRANTY IS ONLY GOOD UP TO 50K. I AM AT 54K. THIS IS AN ON GOING ISSUE FOR JETTA TDI OWNERS AND WILL CONTINUE TO BE AN ISSUE WHEN THE MILEAGE CLIMBS. THIS IS ALSO A SAFETY ISSUE THAT I TAKE PERSONALLY DUE TO A CHILD BEING IN THE CAR AT THE TIME OF THE BREAK DOWN IN THE MIDDLE OF THE HIGHWAY. I WANTED TO WRITE IN CONCERN FOR MY OWN ISSUES WITH THIS AND OTHER CT JETTA TDI OWNERS OF CT/USA. I DON'T KNOW IF YOU CAN HELP BUT I WANTED TO TRY. THANK YOU VERY MUCH FOR YOUR TIME. *TR
Engine and engine cooling, Fuel system, Diesel, Power train, Mar 22, 2011
ENGINE ABRUPTLY STALLED ENTERING LARGE MULTI-LANE INTERSECTION, AS ENGINE REPAIR LIGHT CAME ON. SUDDENLY INOPERATIVE POWER TRAIN ON THE VEHICLE WITHOUT ANY PRIOR WARNING. TDI DIESEL POWERED VEHICLE. TOWED TO DEALERSHIP AND DIAGNOSED WITH HPFP (FUEL PUMP) & FUEL SYSTEM FAILURE.
Fuel system, Diesel, Mar 15, 2011
VW JETTA TDI HESITTATION AND FUEL SYSTEM FAILURE. *TR
Fuel system, Diesel, Mar 8, 2011
ON MARCH 6, WHILE DRIVING A 2009 VW JETTA TDI AT APPROXIMATE 70 MPH ON THE HIGHWAY, THE CRUISE CONTROL SHUT OFF, THE GLOW PLUG LIGHT CAME ON, AND AN WARNING THAT READ "ENGINE FAILURE WORKSHOP!" CAME ON. THE CAR WOULD NOT ACCELERATE FASTER THAN 58 MPH AND I PULLED OVER TO THE SIDE OF THE ROAD. THE OWNER'S MANUAL DID NOT INDICATE THE MEANING OF THE GLOW PLUG WARNING LIGHT. I TURNED THE CAR OFF AND RESTARTED IT AND BOTH THE GLOW PLUG LIGHT AND "ENGINE FAILURE WORKSHOP!" LIGHTS WERE OFF. I DROVE THE CAR HOME AND CALLED THE DEALERSHIP THE NEXT MORNING. THE DEALERSHIP SERVICE CENTER INDICATED THAT THE WARNING LIGHT INDICATED THE GLOW PLUG. THE DEALERSHIP STATED THAT I COULD CONTINUE TO DRIVE MY CAR UNTIL A PART THEY ORDERED FOR ME CAME IN UNLESS I EXPERIENCED "DRIVEABILITY" ISSUES, AT WHICH TIME I COULD TAKE IT DIRECTLY TO THE DEALERSHIP. *TR