2009 Volkswagen Jetta
Problems, recalls and owner-reported issues
Fuel system is the leading concern among 904 owner complaints filed for this model year. This is the highest complaint count among 26 Jetta model years with reports.
Of the 2009 reports, 31 involved a crash and 8 involved a fire. 17 people were injured.
What owners report most often
Recalls and investigations
Service brakes, hydraulic, foundation components, master cylinderSep 23, 2020
Tenneco Automotive (Tenneco) is recalling certain Beck/Arnley Master Cylinders, part number 072-9831, sold as aftermarket or replacement parts for 2004-2018 Volkswagen Jetta, and 2012-2019 Volkswagen Beetle vehicles. The fluid seal crimp on the master cylinder may be insufficient, causing brake fluid to leak or the cylinder to come apart.
If there is a brake fluid leak, it can reduce braking ability, increasing the risk of a crash.
Beck/Arnley will notify the distributors that sold the master cylinders and will work with the distributors to notify the end users. Affected master cylinders will be exchanged for a new master cylinder (part number 072-9990), free of charge. The recall began October 30, 2020. Owners may contact Tenneco customer service at 1-800-625-9319.
Campaign 20E064000 on NHTSA.gov
Other or unspecifiedSep 25, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and Beetle Convertible, 2008-2010 Beetle, and Beetle Convertible vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Volkswagen will notify owners and repurchase the affected vehicles. The recall began November 6, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01D7. Note: This recall is an expansion of NHTSA recall number 18V-329.
Campaign 19V679000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slipDec 20, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.
A loss of vehicle control can increase the risk of a crash.
Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.
Campaign 16V913000 on NHTSA.gov
Fuel system, dieselOct 3, 2011
VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.
DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.
VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 11V490000 on NHTSA.gov
Fuel system, gasoline, delivery, hoses, lines/piping, and fittingsDec 10, 2010
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.
IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 10V621000 on NHTSA.gov
Power train, automatic transmissionAug 20, 2009
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.
THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.
VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 09V333000 on NHTSA.gov
Power train, driveline, driveshaftMay 19, 2009
VOLKSWAGEN IS RECALLING 25,594 MY 2006-2009 JETTA 5TH GENERATION EQUIPPED WITH 2.01 ENGINE. THE FASTENING SCREW CONTACT SURFACES ON THE DRIVESHAFT COVER PLATE MAY NOT HAVE BEEN MANUFACTURED TO FACTORY SPECIFICATIONS. SOME SCREWS MAY NOT HAVE BEEN TORQUED PROPERLY DURING ASSEMBLY AND COULD LOOSEN OVER TIME, CAUSING A KNOCKING SOUND WHEN THE VEHICLE IS IN MOTION. THE DRIVESHAFT SCREWS COULD LOOSEN TO THE POINT WHERE THE DRIVESHAFT DETACHES FROM THE GEARBOX.
IF THE VEHICLE IS MOVING WHEN THIS HAPPENS, THE DETACHED DRIVESHAFT COULD CAUSE DAMAGE THE GEARBOX HOUSING. A DAMAGE GEARBOX HOUSING COULD LEAK GEARBOX OIL ONTO THE STREET AND CREATE A RISK OF A VEHICLE CRASH FOR BOTH THE DRIVER AND OTHER MOTORISTS.
DEALERS WILL INSPECT THE DRIVESHAFT SCREWS AND REPLACE THE SCREWS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 24, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 09V164000 on NHTSA.gov
Representative owner complaints: engine
167 reports, newest first. Show all
Engine, Fuel/propulsion system, Nov 18, 2014
FOR THE PAST YEAR OR SO MY 2009 JETTA TDI (DIESEL) HAS HAD THE SAME RECURRING PROBLEM: MY GLOW PLUG LIGHT WILL COME ON AND I LOSE NORMAL DRIVING CAPABILITIES. I CANNOT ACCELERATE OR MAINTAIN SPEED AS I NORMALLY DO. MY CAR WILL REMAIN AROUND 25 MPH, SOMETIMES LOSING POWER UNTIL I AM FORCED TO PULL OVER. MY SOLUTION HAS BEEN TO TURN THE CAR OFF, AND BACK ON AGAIN. THE LIGHT WILL GO OFF AND I CAN DRIVE NORMALLY MOST OF THE TIME. SOMETIMES I HAVE TO LEAVE THE CAR OFF FOR A PERIOD OF TIME TO REGAIN STANDARD DRIVING CAPABILITIES. IT HAS BEEN ABOUT 2 WEEKS SINCE THAT HAS HAPPENED. 2 DAYS AGO, MY ENGINE LIGHT CAME ON. I TOOK IT TO THE DEALER AND THEY PULLED CODES P0087 AND P0088 (FUEL PRESSURE TOO HIGH AND FUEL PRESSURE TOO LOW AT THE SAME TIME). THEY WANT ME TO REPLACE THE FUEL RAIL, WHICH WILL BE AN ESTIMATED $1000 IN TOTAL PARTS/LABOR. I CALLED ANOTHER DEALER IN HOPES OF GETTING A BETTER PRICE AND THEY ARE PUT OFF BY THE FIRST DEALER'S RECOMMENDATIONS. I WAS TOLD THERE IS NO EVIDENCE OF METAL IN MY FUEL SYSTEM BUT EVEN SO, OTHER DEALER THINKS THIS WILL BE MORE SERIOUS THAN JUST REPLACING THE RAIL. AFTER RESEARCHING I AM BEGINNING TO THINK THAT I AM EXPERIENCING THE BEGINNING OF HPFP FAILURE. I FEEL LIKE I AM DRIVING A TICKING TIME BOMB AND I'M NOT SURE WHAT TO DO! REPLACING THE FUEL RAIL FEELS LIKE A QUICK, EXPENSIVE AND INEFFICIENT SOLUTION TO A BIGGER PROBLEM. I CONTACTED VOLKSWAGEN CUSTOMER CARE AND I WAS TOLD THAT I WILL RECEIVE A CALL FROM A REGIONAL AGENT ABOUT MY SITUATION TOMORROW. *TR
Engine, Nov 3, 2014
DRIVING ON A BUSY 4 LANE ROAD MY CAR SUDDENLY STOPPED JUST FLASHED A FEW LIGHTS ON THE PANEL FOR FEW SECONDS. THE CAR WOULD NOT START. COULD NOT BE MOVED LUCKY THAT THERE WERE NO INJURIES. THE VEHICLE TOWED TO VW DEALER, BASIL VW AT LOCKPORT AND WAS TOLD THAT THE HIGH PRESSURE FUEL PUMP EXPLODED. CAUSED EXTENSIVE DAMAGE REQUIRING NUMEROUS COMPONENTS, WITH A TOTAL COST OF ABOUT $7,000.00 THE CAR WAS SERVICE BY A VW DEALER OR BY A REPAIR SHOP OWNED BY AAA OF WNY LOCATED AT CLARENCE NY. THIS CAME ON WITH OUT A WARNING, WAS NOT INFORMED ABOUT THIS PROBLEM. HAD OWNED DIESEL CARS SINCE 1977 AND DID NOT FACE ANY SUCH PROBLEM OR HEAR OF SUCH A PROBLEM. *TR
Engine, Oct 24, 2014
TIMING CHAIN TENSIONER FAILED RESULTING IN ENGINE FAILURE. *TR
Fuel system, Diesel, Engine, Oct 20, 2014
THE CAR WAS RUNNING FINE UP TO THE TIME IT QUIT. IT STALLED IN A PUDDLE AFTER 7 DAYS OF RAIN SO I ASSUMED IT HAD GOTTEN WATER IN THE SYSTEM SOMEHOW. I HAD IT TOWED TO MY LOCAL MECHANIC. HE IN TURN CALLED THE DEALER WHO SAID THEY WERE UNABLE TO SELL HIM THE PARTS FOR THE REPAIR AND THAT I NEEDED TO HAVE IT TOWED TO THEM. I HAVE SINCE BEEN TOLD THE REPAIR WORK WILL BE BETWEEN 8 AND 10 THOUSAND DOLLARS TO REPLACE THE DIESEL FUEL SYSTEM! I TOLD THEM TO HOLD OFF SO THAT I CAN WAY MY OPTIONS. I HAVE SINCE VERIFIED THAT INDEED THE HIGH PRESSURE FUEL PUMP HAD DISINTEGRATED AND DESTROYED THE FUEL SYSTEM. *TR
Engine, Oct 6, 2014
AFTER IDLING FOR APPROX 5 MINUTES ON A HOT AFTERNOON (95F), I TRIED TO ACCELERATE THE VEHICLE AND IMMEDIATELY FELT A SPUTTERING FROM THE ENGINE. THE ENGINE LIGHT CAME ON AND THEN THE EPC LIGHT; THE VEHICLE STARTED TO LOSE POWER. AFTER TURNING OFF THE ENGINE FOR A FEW MINUTES AND RESTARTING, THE VEHICLE WAS STILL SPUTTERING HOWEVER WE WERE ABLE TO DRIVE IT HOME APPROX 10 MILES ON A CITY STREET. THE VEHICLE WOULD NOT ACCELERATE OVER 20 MPH. AFTER TAKING TO THE DEALERSHIP THEY ADVISED THAT AN ENGINE COIL HAD FAILED AND NEEDED TO BE REPLACED. THE INCIDENT OCCURRED AGAIN 5 MONTHS LATER WITH THE SAME CONCLUSION FROM THE MECHANIC. *TR
Engine, Oct 3, 2014
THE WATER PUMP FAILED AT APPROXIMATELY 70 MPH. THE IMPELLER CAME OFF OF THE SHAFT INSIDE OF THE PUMP BECAUSE OF A POOR DESIGN(PLASTIC). THIS CAUSED THE VEHICLE TO OVERHEAT. WENT AHEAD AND HAD THE TIMING BELT DONE ALSO. COST OF REPAIR WAS $1131.87. *TR
Electrical system, Engine, Sep 23, 2014
TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. WHILE THE VEHICLE WAS IDLING AND ATTEMPTING TO ACCELERATE, THE CONTACT HEARD AN ABNORMAL NOISE AND THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO RESTART AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 57,000.
Engine, Fuel/propulsion system, Jul 21, 2014
DRIVING ON MY WAY HOME FROM WORK IN TOWN AND ALL OF A SUDDEN THE GLOW PLUG LIGHT COMES ON FLASHING AND THE ENGINE LIGHT APPEARS ON THE DASH. I IMMEDIATELY TURNED OFF THE CAR RESTARTED THE CAR AND THE PROBLEM WAS NOT RESOLVED AND A MESSAGE APPEARED ON THE SASH "ENGINE FAULT WORKSHOP!". HPFP FAILURE. *TR
Electrical system, Engine, Jul 10, 2014
WHILE DRIVING ON FREEWAY CAR COMPLETELY SHUT-OFF. COASTED TO OFF-RAMP, STOPPED CAR AND THEN RE-STARTED IT. DEALER LATER DIAGNOSED IGNITION SWITCH PROBLEM (INTERMITTENT IGNITION SWITCH FAULTS LOGGED) AND RECOMMENDED REPLACEMENT OF THE IGNITION SWITCH. *TR
Engine, Jun 10, 2014
SUNRISE V.W. HAD MY 2009 JETTA TDI IN THEIR SHOP YESTERDAY, AND AFTER DIAGNOSTICS INFORMED ME THAT I NEEDED BOTH COOLING FANS, AND THE INTAKE MANIFOLD REPLACED. I HAVE GEICO MECHANICAL BREAK DOWN INSURANCE. THE ADJUSTER ONLY APPROVED THE REPLACEMENT OF THE COOLING FANS. ON THE WAY HOME MY CHECK ENGINE LIGHT CAME ON, I HEARD A POP SOUND FROM THE ENGINE, AND LOST ALL OF THE CARS POWER. THIS LOSS OF POWER HAPPENED WHILE TRAVELING IN TRAFFIC AT ABOUT 30 MPH. I BELIEVE THE INTAKE MANIFOLD FAILED, AND CAUSED THE LOSS OF ENGINE POWER. THE CAR WAS THEN TOWED BACK TO SUNRISE V.W. *TR
Engine, May 27, 2014
TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE TRAVELING 60 MPH, THE VEHICLE DECELERATED TO 30 MPH. THE GLOW PLUG ON THE DASH ILLUMINATED. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE IMPELLER SHAFT ON THE TURBO NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 42,000 AND THE CURRENT MILEAGE 42,000.
Engine, Fuel/propulsion system, May 17, 2014
THE CAR BEGAN TO FLASH THE "GLOW PLUG" WARNING LIGHT ALONG WITH A MESSAGE "ENGINE FAULT WORKSHOP" PULLED TO THE SIDE OF THE ROAD AND ATTEMPTED TO RESTART. ENGINE WOULD CRANK BUT NOT TURN OVER. GOT THE FOLLOWING FAILURE CODES: P0087, P13E3, P2196. LOOKS LIKE THIS IS A COMMON ISSUE AND YET VW DOES NOTHING ABOUT IT. CLASS ACTION ANYONE?. *JS
Engine, May 3, 2014
FUEL SYSTEM WAS FLUSHED AND REPLACED. AFTER THAT THE TOP OF THE ENGINE WAS LEAKING OIL. I TOOK IT BACK TO VW IN CLARKSVILLE TN. THEY SAID THEY FIXED IT. IT IS STILL LEAKING OIL JUST NOT AS BAD. THEN THE CAR WAS SMOKING AND BURNING/LEAKING OIL FROM THE TURBO. VW DID NOT WANT TO FIX THIS UNDER WARRANTY. EVEN THOUGH I HAD TAKEN THIS CAR IN SEVERAL TIMES BEFORE FOR A CHECK ENGINE LIGHT THAT KEPT BRINGING UP THE EGR. *TR
Power train, Engine, May 1, 2014
THE DEALERSHIP STATED IT WAS A WARPED DUAL MASS FLYWHEEL. THEY REPLACED IT AND IT IS STILL KNOCKING. A SECOND DEALERSHIP SAID THAT IT IS STILL KNOCKING BECAUSE THE DUAL MASS FLYWHEEL IS BAD. IT CAUSES THE CLUTCH TO SHIFT HARD AND ACCELERATION TO BE AN ISSUE. I DO NOT FEEL COMFORTABLE TRAVELING ON THE HIGHWAYS. *TR
Engine, Mar 3, 2014
CAR SUDDENLY DIED AND WILL NOT RE-START. ENGINE TURNS OVER, BUT THAT'S IT. I SUDDENLY LOST POWER AND HAD TO COAST TO THE SHOULDER WHICH WAS VERY DIFFICULT BECAUSE THE CAR DECELERATED VERY QUICKLY AND THERE WAS NO POWER STEERING. LUCKILY THIS HAPPENED VERY EARLY IN THE MORNING AND TRAFFIC WENT AROUND ME. *TR
Fuel system, Diesel, Vehicle speed control, Engine, Feb 22, 2014
MY JETTA LOST POWER FROM GOING 60MPH TO 35-40 AND AFTER A MIN IT SHUT DOWN ON HIGHWAY. I MANAGED TO PUSH IT ON A SHOULDER AND TRIED TO START AGAIN BUT NOTHING HAPPENED. I TOWED IT AWAY TO MECHANIC AND FOUND OUT THAT MY HIGH PRESSURE FUEL PUMP SHATTERED AND RELEASED BUNCH OF TINY METAL PEACES IN TO THE FUEL FILTER AND ENGINE. MECHANIC TOLD ME THAT IT HAPPENED BECAUSE OF A DESIGN FLAW WITH THE PUMP THAT VW ADMITTED BUT HAVEN'T DONE ANYTHING ABOUT THAT. SO I'M WONDERING WHAT IF A SEMI TRUCK CAME AT THE SAME TIME AND HIT ME WOULD THEY DO SOMETHING ABOUT IT THEN? *TR
Engine, Feb 4, 2014
TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE ENGINE STALLED AND THE CHECK ENGINE LIGHT ILLUMINATED. THE CONTACT MENTIONED THAT THE VEHICLE FAILED TO RESTART AND WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS FOUND THAT THE HIGH PRESSURE PUMP WAS DEFECTIVE. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 46,900. UPDATED 07/03/14 MA UPDATED 07/11/2014 *JS
Engine and engine cooling, Fuel/propulsion system, Jan 29, 2014
WHILE DRIVING ON A 3 LANE ROAD MY VEHICLE LOST POWER AND SHOWED A WARNING MESSAGE OF "ENGINE FAULT". IT HAD ABOUT 50% POWER FOR APPROXIMATELY 30 SECONDS AND DIED. THE VEHICLE WAS TOWED TO VW DEALER AND THEY REPORT THAT IT WAS THE HIGH PRESSURE FUEL PUMP FAILURE WITH COMPLETE FUEL SYSTEM CONTAMINATION. *TR
Fuel system, Diesel, Engine, Jan 15, 2014
2009 VW JETTA TDI UNABLE TO START THE VEHICLE IT WOULD CRANK BUT WILL NOT START. THE VEHICLE WAS TOWED TO THE VW DEALER AND THEY SAID THAT THE FUEL PUMP IN THE FUEL TANK FAILED. THE PUMP IN THE TANK WAS REPLACED AND STILL WILL NOT START. THE DEALER THEN SAID THAT THE HPFP HIGH PRESSURE FUEL PUMP ON THE ENGINE WAS BAD. THEY CHANGED THE PUMP AND STILL WILL NOT START. THE DEALER DOES NOT KNOW WHAT IS WRONG WITH THE VEHICLE AT THIS TIME. THEY CALLED THEIR TECH LINE AWAITING AN ANSWER. I BELIEVE THIS IS A HIGH PRESSURE FUEL PUMP FAILURE ISSUE THAT IS A KNOWN ISSUE AND WELL TALKED ABOUT ON THE VW TDI FORUMS. IF THIS IS THE ISSUE THE PUMPS AND ANY REPAIRS SHOULD BE WARRANTIED FOR THE LIFE OF THE VEHICLE AS LONG AS YOU OWN THE VEHICLE SINCE IT WAS PURCHASED NEW FROM THE DEALER. *TR
Fuel system, Gasoline, Engine, Nov 22, 2013
THE VEHICLE'S ENGINE STALLED WHILE TRAVELING DOWN THE ROADWAY AT APPROXIMATELY 35 MPH. THE VEHICLE'S ELECTRICAL SYSTEM CONTINUED TO OPERATE (DRIVING LIGHTS, INTERIOR LIGHTS, POWER STEERING AND POWER BRAKES) DURING THIS TIME. ENGAGED EMERGENCY FLASHERS AND COASTED VEHICLE TO A STOP AT THE NEAREST PARKING LOT. AFTER PLACING TRANSMISSION INTO PARK, VEHICLE RESTARTED WITH NO FURTHER INCIDENT. *TR
Fuel system, Diesel, Power train, Engine, Oct 24, 2013
WHEN COMING TO STOP AT A RED LIGHT, THERE WAS AN ENGINE FAULT WORKSHOP WARNING MESSAGE AND A BLINKING YELLOW GLOW PLUG WARNING LIGHT. WHEN THE LIGHT TURNED GREEN, THE CAR FELT SLUGGISH, NEEDING EXTRA THROTTLE THAN USUAL TO GET TO 35MPH. AFTER STOPPING AT THE NEXT RED LIGHT, THE CAR WAS STUCK IN FIRST GEAR (ONLY 30 SECONDS AFTER THE WARNING LIGHT), AND I COULD ONLY GET TO 10MPH IN A 35MPH ZONE. TURNING ON MY HAZARD BLINKERS, I WAS LUCKY THAT THERE WAS A DEDICATED LEFT TURN LANE INTO A PARKING LOT, OTHERWISE I WOULD NOT HAVE BEEN ABLE TO SAFELY PULL OVER TO THE RIGHT SHOULDER FROM THE LEFT LANE BEFORE THE ENGINE DIED. *TR
Engine and engine cooling, Fuel system, Diesel, Oct 23, 2013
CHECK ENGINE LIGHT AND GLOW PLUG INDICATOR LIGHT ILLUMINATE AND ENGINE GOES INTO LIMP OR SAFE MODE. HAS HAPPENED TWICE AND DEALER CANNOT FIND PROBLEM. *TR
Power train, Engine, Oct 22, 2013
I WAS STUCK ON A BUSY INTERSECTION BECAUSE MY CAR WOULDN'T LOCK ONTO THE GEAR. ALL GEARS ON THE CONTROL PANEL WHERE FLASHING. UPON LATER RESEARCH, I WAS TOLD THAT THE DSG GAVE A FALSE-NEUTRAL. *TR
Fuel system, Diesel, Engine, Oct 1, 2013
I DROVE HOME FROM WORK ON 9/28/2013 GOT OFF THE FREEWAY, CAME TO A STOP AT END OF OFFRAMP AND THE FIRST WARNING LAMP CAME ON INDICATING A GLOW PLUG FAILURE. IT CONTINUED TO RUN AND I DROVE TO A NEARBY PARKING LOT AT APPROX. 50% POWER, PARKED, CYCLED THE IGNITION FROM ON TO OFF AND BACK ON AGAIN. THIS CLEARED THE FAULT TEMPORARILY, I DROVE TOWARD HOME AND WITHIN ANOTHER 2 MILES THE SAME GLOW PLUG FAULT RETURNED ALONG WITH THE CHECK ENGINE SYMBOL AND A WARNING INDICATING WORKSHOP WAS NEEDED. THE FOLLOWING DAY I BOUGHT A CODE READER, READ THE CODES AND FOUND SEVERAL LOGGED, SOME OF WHICH IM CERTAIN WERE RESIDUAL FAULTS FROM THE ACTUAL CAUSE OF THE FAILURE WHICH WAS INDICATED BY A RECURRING "LOW FUEL RAIL PRESSURE" FAULT. I HAVE CALLED THE DEALER WHICH INSTRUCTED ME TO LOOK AT THE FUEL FILTER AND AIDED BY AN ONLINE TECH INFO BLOG I INSPECTED THE HIGH PRESSURE FUEL PUMP ACTUATOR FOR METAL DEBRIS. THE FUEL FILTER INSPECTION SHOWED SMALL, TRACE AMOUNTS OF METAL DUST WHILE THE FUEL PUMP INSPECTION SHOWED LARGER AND MORE SUBSTANTIAL METAL SHAVINGS UNDER THE ACTUATOR. THE INSPECTION OF THE TWO COMPONENTS ARE INDICATIVE AND INLINE WITH SIMILAR FINDINGS THAT PROVE HIGH PRESSURE FUEL PUMP FAILURE, IT SHOULD BE NOTED THAT NO TRACE OF GASOLINE WAS FOUND IN THIS SYSTEM AND ONLY CLEAN DIESEL FUEL WAS PRESENT DURING INSPECTION. FUEL FILTER WAS JUST CHANGED IN AUG 20 2013 AT SAME TIME AS TIMING BELT WHERE HPFP DRIVE GEAR WAS RETORQUED. I NOW HAVE A CAR THAT IS NOT FUNCTIONAL AND I'M NOT HAPPY. I BOUGHT A DIESEL FOR LONGEVITY AND HIGH FUEL ECONOMY NOT THIS. *TR
Fuel system, Diesel, Engine, Jul 5, 2013
CAR IS A JETTA TDI (DIESEL ENGINE). ENGINE WARNING LIGHT APPEARED WHILE DRIVING, APPROXIMATELY 50 YARDS LATER WHILE SLOWING DOWN THE ENGINE FAILED AND WOULD NOT RESTART. CAR WAS STOPPED AT INTERSECTION ON A BUSY 5 LANE ROAD AT 5:30 PM WITH CARS COMING FROM BEHIND AND AROUND AT SPEEDS OF 45+ MPH. SHERIFF CAME TO DIVERT TRAFFIC TO PREVENT A WRECK AND ALLOW TOW TRUCK TO TOW CAR SAFELY. DEALER STATES THAT HIGH PRESSURE FUEL PUMP FAILED, RUINING FUEL SYSTEM, QUOTES POTENTIAL REPAIR COST OF $8,500. FILLED FUEL TANK 5 MILES PRIOR TO INCIDENT WITH 11 GALLONS OF DIESEL FUEL (REPUTABLE FUEL DEALER, ALMOST ALWAYS USE THIS DEALER). THERE WAS NO WARNING PRIOR TO THE INCIDENT -- NO ROUGH ENGINE OR STALLING OR TROUBLE OF ANY KIND. CAR IS DRIVEN BY ONLY ONE DRIVER AND IS WELL MAINTAINED, HAS NEVER BEEN FUELED WITH ANYTHING BUT DIESEL FROM REPUTABLE DEALERS. CAR IS USUALLY DRIVEN ON THE FREEWAY (DEALER RECOMMENDED IT SPECIFICALLY FOR A LONG FREEWAY COMMUTE). LUCKY THAT IT DIDN'T STALL AT HIGH SPEED ON FREEWAY. *TR