2021 Volkswagen Tiguan
Problems, recalls and owner-reported issues
Engine is the leading concern among 141 owner complaints filed for this model year. This is the 7th highest complaint count among 17 Tiguan model years with reports.
Of the 2021 reports, 2 involved a crash. 2 people were injured.
What owners report most often
Recalls and investigations
Back over prevention, sensing system, cameraJul 20, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Golf GTI, Jetta GLI, Jetta NF, Arteon FL, Tiguan LWB, 2022 Taos, Jetta PA, Tiguan PA, 2021-2022 Atlas Cross Sport, and Atlas FL vehicles. The manufacturing process of the eMMC memory module in the infotainment system may cause the rearview camera image not to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Dealers will update the infotainment software, free of charge. Owner notification letters are expected to be mailed September 16, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 91DV.
Campaign 22V514000 on NHTSA.gov
Structure, bodyApr 6, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 Tiguan and 2018-2021 Tiguan long wheel base (LWB) vehicles. Due to incorrect installation instructions, the accessory rear hatch spoiler may be insufficiently attached to the vehicle.
An insufficiently attached spoiler may separate from the vehicle, becoming a road hazard and increasing the risk of a crash.
Dealers will replace the spoiler, free of charge. Owner notification letters were mailed June 3, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 66N5.
Campaign 22V226000 on NHTSA.gov
SuspensionMar 23, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 Tiguan, Taos, and 2021 Tiguan long wheel base (LWB) vehicles. A second notice will be sent once remedy parts become available. The left or right rear suspension knuckles may corrode, crack, and break.
A broken rear suspension knuckle can cause a loss of stability, increasing the risk of a crash.
Dealers will inspect and, if necessary, replace one or both rear suspension knuckles, free of charge. Owner notification letters were mailed June 13, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42L8.
Campaign 22V176000 on NHTSA.gov
SeatsFeb 1, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Volkswagen Tiguan Long Wheelbase and Jetta vehicles. Bolts may be missing from the front seat tracks.
The seat can move front and back without restriction if bolts are missing, increasing the risk of injury during a crash.
Volkswagen will notify owners, and dealers will inspect the front seat tracks and, as necessary, install the bolts, free of charge. The recall began February 18, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 72L6.
Campaign 21V038000 on NHTSA.gov
Back over prevention, sensing system, cameraNov 18, 2020
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Atlas Cross Sport, Tiguan LWB, Jetta NF, Jetta GLI, Golf GTI, Atlas FL and Arteon vehicles. The rear view camera could malfunction during an ignition cycle, leading to a black screen or infotainment system freeze. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A black or frozen rear view image reduces the driver's visibility when reversing, increasing the risk of a crash.
Volkswagen will notify owners, and dealers will update the infotainment system software, free of charge. The recall began December 11, 2020. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 91BB/91BC.
Campaign 20V716000 on NHTSA.gov
Representative owner complaints: engine
56 reports, newest first. Show all
Engine, Sep 22, 2026
At 58,218 miles, the engine on this 2021 Volkswagen Tiguan failed after excessive oil consumption progressed to engine knocking. The vehicle was brought to Volkswagen of Orange Park on July 24, 2025, for excessive oil consumption. The dealer performed a second oil-consumption test. During the test, the engine was heard knocking. The dealer removed the oil pan and found excessive metal. Volkswagen replaced the engine under warranty. The repair invoice was dated August 31, 2025. This created a safety concern because an engine failure can cause loss of propulsion or stalling while driving. The dealer confirmed and repaired the condition.
Engine, Sep 16, 2026
At approximately 53,876 miles, my 2021 Volkswagen Tiguan experienced a severe, premature failure of the Positive Crankcase Ventilation (PCV) valve / oil separator assembly. The failure of this component caused an immediate, dangerous buildup of internal crankcase over-pressurization. Because the excess pressure could not vent safely, it caused a catastrophic domino effect through the engine block, structurally blowing out multiple critical engine gaskets and rubber oil seals. Furthermore, the extreme downward pressure physically cracked the factory-installed composite plastic oil pan, leading to an immediate and rapid engine oil leak. A sudden and rapid loss of engine oil and internal oil pressure while operating a vehicle at highway speeds poses an extreme safety hazard. Had the oil pressure dropped completely while driving with my children in the vehicle, it could have resulted in a sudden engine seizure, sudden loss of motive power, or complete engine failure on a live highway, placing my family and surrounding drivers in imminent danger of a high-speed collision. Volkswagen is aware of this engine design defect, as evidenced by active internal Technical Service Bulletins (TSBs) and a pending federal class-action lawsuit (Reece v. Volkswagen Group of America, Inc.) detailing identical PCV-induced seal and plastic oil pan failures in the exact same model year. Volkswagen's failure to issue a safety recall for this unlisted "lifetime" part forces families to drive under the threat of sudden component blowout and subsequent engine failure. A mandatory safety investigation and recall are required to address this systemic powertrain defect.
Vehicle speed control, Engine, Sep 6, 2026
Like many others, at 55k miles, our oil separator malfunctioned causing our oil pan to crack and dump every drop of oil. We had to replace the oil pan and fortunately our mechanic friend figured out it was the new pcv valve malfunction causing too much pressure in the engine. My wife was luckily pulling onto our property when the car essentially shut itself off. When searching for the valve I needed, talking to multiple parts dealers and then a vw tech, none of them are sure why there’s no recall. It happens between 50-60k to THOUSANDS of people now. Then I watched videos on the issue and the mechanics online are all saying the same thing- this should’ve been a recall 2 years ago and are all asking the same question. It’s time VW does what’s right. It’s awfully coincidental that they installed plastic oil pans that would crack and leak under instead pressure, rather than a blowout seals because of the valve failure.
Engine, Aug 28, 2026
Known issues with Tiguan models of overconsumption of motor oil due to faulty engineering of top(head) of engine.
Other or unspecified, Engine, Fuel/propulsion system, Aug 27, 2026
Taking left turns is dangerous. My turn very slowly and Hard press on pedal to turn. Oil consumption is insane. Started at 38k miles, manufacture warranty ended after 4 years. I’m under 52k miles now and have to fill oil about every 1k miles. I’ve had 4 oil changes this year alone. I’m regular about Maintenence. Last oil change was 08/03/26 check oil light came on 8/15 had to add 3.5 quarts 8/26/26 Will keep track of each time I need to add oil and update here. This has been an issue for many Tiguan owners where is the recall???
Engine, Aug 25, 2026
Noticed the check engine oil light started coming on periodically between oil changes 3-4 years ago, but no external or noticeable oil leaks. Was told by VW multiple times it’s standard for VWs to burn oil. I started having to top off oil much more frequently over the last year, 1 quart per 1000 miles. The check engine oil light would turn on every month at random times while driving. Took my car to a shop; they removed 02 Sensor 1 and borescoped the exhaust system. Found oil leaks from valve seals, leaking into the exhaust manifold. A few weeks later, the check engine light came on for the first time (codes: P24D6 and U3501). Brought car to another shop; they scanned the car and the following codes were found: U350100 (Passive/Sporadic) - Control Module Input Power "A" Circuit Low U041600 (Passive/Sporatic) - Invalid data received from vehicle dynamics control module) P003000 (Passive/Sporatic) - O2 Sensor Heater Control Circuit Bank 1 Sensor 1 U105400 (Passive/Sporadic) - Information electronics 1 control unit No communication P24D600 (Passive/Sporadic) - Evaporative Emission (EVAP) system pressure sensor/switch B circuit range performance. The second shop also stated the valve stem seals needed to be replaced in addition to the Upstream Oxygen sensor and PCV valve. The car was brought to Volkswagen for repair under the extended warranty. Volkswagen confirmed the PCV valve and valve stem seals were bad and needed to be replaced. VW also noted smoke coming from the exhaust. The vehicle has 53k miles on it.
Engine, Aug 20, 2026
Vehicle abruptly lost power on the highway and limited itself to 3000 RPM. PCV valve failed and oil pan cracked at only 45k vehicle miles.
Engine, Aug 10, 2026
PCV value/oil leak is a known issue with this specific model of car. The repair I was quited was over $2700 when the car is just out of warranty. There was no oil light indication showing that the oil was low! I only checked everything out because I saw oil in the drive way. The car read zero oil on the dip stick. I added 4 quarts and finallt started to get into operating range. My wife drives this car and could have been in a major accident if it hadn't been noticed. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Engine, Forward collision avoidance, Aug 6, 2026
My name is [XXX], and I am writing today to express my complete frustration mentally and financially with a CPO 2021 Volkswagen Tiguan (VIN [XXX]) I purchased XXX. To date my vehicle has been in for service multiple times – countless times for an issue with the infotainment system and driver warning indicators that is still unresolved and again for months waiting on a new engine due to an oil consumption issue that was finally resolved November of 2025 (Case XXX). My recent service visit on XXX was due to a “12 v battery not charging” error message. The vehicle was immediately taken to VW of [XXX] where we were advised it would be 3 weeks before my vehicle would even be looked at (which is atrocious) and not to drive it because further damage would be caused with no alternative solution offered for transportation. I then had the vehicle towed to a repair shop where I was advised the alternator “fried a 400-amp fuse and killed the battery, which should not happen, especially on a vehicle that has less than 50,000 miles on the odometer.” I paid $1,605.37 for a new alternator, 400-amp fuse and battery. Completely appalling and disappointing considering I take excellent care of my vehicle and it is supposedly an inspected, certified pre-owned vehicle – that’s a lemon in my opinion! I am seeking reimbursement for this huge expense for a vehicle that should not have these issues! I look forward to a resolve to this urgent complaint. Regards, INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Aug 1, 2026
My Tiguan leaks and burns oil like crazy. Now it has 111k miles on it, but this has been an ongoing issue for the last five years since I've had it. I now have to put a quart of oil in every 100 miles. This is not the fault of me getting an oil change, this is a persistent problem caused by the manufacturing of the car. I have had the engine nearly seize up while driving on the freeway due to low oil from this issue. Please investigate and fix.
Engine, Jul 9, 2026
The PCV valve does not last past 60k miles. Multiple forums and customers stating this. When the failure shows up as a check engine light symptom it has already caused a major oil leak in the crank shaft that leaks with the car off at about 500ml and is significantly worse while driving- Up to a quart of oil loss from driving 10miles. VW has had issues with the PCv valve design from 2012. I bought a 2012 Passat but it did not leak till well after 200k miles but the code would continuously go on and off.
Engine, Jun 25, 2026
approximately 1 year after purchase, we started having the oil light come on. Returned to dealer and they stated it was normal. This continued for approximately 4 or 5 more times. A "comprehensive" test/diagnostic was conducted and they said normal consumption but no issues. Moving now in 2026 with 40k and now out of warranty with age of vehicle, we brought it back to Scott Motors and NOW it's an issue with the head. The same common problem that they have known about with all their vehicles in this class with this motor since I believe 2018. They want to split the repair bill 50/50 and then 70/30. I stated I addressed and documented the issue years ago and now since we are out of warranty, now you find it. Please Help.
Engine, Jun 14, 2026
My 2021 Volkswagen Tiguan is experiencing excessive engine oil consumption. The oil level drops rapidly between oil changes, and I have had to add oil multiple times to prevent engine damage. The low oil warning light has appeared unexpectedly while driving, creating a safety hazard. I am concerned about potential engine failure, stalling, or loss of power at highway speeds. I have reviewed multiple NHTSA complaints from other 2021 Tiguan owners (IDs 11742786, 11741539, 11741067, 11739933) reporting the same oil consumption and low oil pressure issues. This indicates a pattern of defects involving the EA888 2.0 TSI engine. Volkswagen dealerships often claim this is ‘normal,’ but the frequency and severity of oil loss suggest a mechanical defect involving piston rings, PCV system, or internal engine components. This poses a serious safety risk, especially during long distance travel. I am requesting that NHTSA investigate this issue for the 2021 Tiguan model year.
Electrical system, Service brakes, Engine, May 25, 2026, crash
Vehicle was just turned on and put into reverse. Dash and infotainment center lights flashed and shut off. Vehicle rolled backwards uncontrollably down a sloped driveway. Steering and brakes were not properly functioning. Vehicle came to a stop when it struck a parked vehicle in its path.
Electrical system, Seat belts, Engine, May 15, 2026
Parking brake violently engaging with every stop
Engine, May 4, 2026
Car is burning an excessive amount of oil
Engine, May 1, 2026
Excessive oil consumption. Paid out of pocket and 2 weeks later the same issue. Dealer is aware of this common problem and refuses to do anything. These vehicles have faulty piston rings and PCV valves.
Engine, Apr 12, 2026
Tiguans have been reporting excessive burning oil consumption- reported this to the dealership and consider this "normal" but how is going through several oil containers to make sure there's enough oil in the car "normal"??? I've never had this issue with any other car- other Tiguan owners have reported this issue and it's over a 6k repair.
Engine, Apr 12, 2026
Oil consumption issue. The vehicle is experiencing blue / white smoke from tailpipe when starting also lost of oil due to a valve seal issue with engine that requires dealers to remove head and service it
Engine, Apr 12, 2026
Engine has excessive oil consumption. Low oil indicator light will come on and Engine oil needs to be topped and added about every 2500 miles sometimes more often depending on driving conditions.
Engine, Apr 12, 2026
Oil consumption issues affecting all cars of this make and model
Power train, Engine, Mar 16, 2026
Here is a quick description of the issue from our Volkswagon of Huntington service report. We have had this ongoing issue for a few months now. the check engine light will come on. We get it checked, we replace a sensor, and all is good for a day or week. Then we do it again, replacing a different sensor. Now the dealer is saying the oil separator is leaking and requires repairs starting at 8,400 and going up from there as they uncover more. We have always maintained the car properly. From research this appears to be a very known issue with this model car and should be reported and covered by VW. SCANNED VEHICLE AND FOUND FAULTS PRESENT FOR SECONDARY AIR. OBSERVED OIL SEPARATOR LEAKING CUASING UPPER TIMING COVER GASKETS TO BLOW OUT ALLOWING OIL TO ESCAPE. FOUND SECONDARY AIR PORTS IN CYLINDER HEAD CLOGGED TRIGGERING CHECK ENGINE LIGHT. ADVISED TO REPLACE OIL SEPARATOR,CAM SHAFT MAGNETS AND CYLINDER HEAD TO START. APPROX 8480.00 PLUS TAX
Engine, Mar 10, 2026
After oil changes (always maintained at dealerships) it would require a quart of oil with in 2 days. Random starts will blow smoke out the rear. random sluggish behavior. Dealership confirmed PCV valve is causing a buildup in engine pressure which caused a premature oil pan gasket leak. Without full teardown cannot know full extent of damages caused. (which spills out of the bottom and towards tires.....) dealership and fellow Tiguan owners have all reported the same issue! with a repair cost of $1,000-8,000+. same with alot of other years as well.. The date below that i will list is for when the problem was fully confirmed (89k miles) but has always been an issue told its fine ... really noticed it after (68k miles) when i purchased the vehicle. With how many people are dealing with this it is hard to understand how we dont see an open recall for them..... also dealer said pvc valves are on back order and have been. why should one replace with oem if they won't acknowledge its a faulty part?
Engine, Mar 6, 2026
Check Engine Light came on and got estimate from Pete Moore VW Dealer in Pensacola, Florida and was told the car needed extensive engine repair which included a new cylinder head part. So we waited to come get the car repaired on 3/5/2026 once we had saved up the money for it. We found out the cylinder head is on a Nationwide back order with NO estimated time to get it fixed properly. The technician who gave us the estimate back in September 2025 failed to mention that the cylinder head has been on a Nationwide back order during that time. I am not the only person dealing with this issue in the USA but feel VW has not provided a fix or estimate time to repair these cars properly causing a safety hazard. This time to wait for a part is unacceptable and feel our cars fall under the Lemon Law.
Engine, Dec 19, 2025
I am experiencing severe oil consumption and leakage with my 2021 Volkswagen Tiguan. The low oil level light began coming on weekly, and I have had to add oil nearly every week to keep the engine from running dry. Recently, I noticed oil leaking underneath the vehicle and immediately parked it. After parking, the vehicle began leaking oil excessively. The problem appears related to PCV system failure, which has caused multiple oil seals to rupture. After researching online, I found many other Tiguan owners reporting the same issues — including PCV valve failure, cracked oil pans, damaged valve seals, and crankshaft seal failures. My vehicle is no longer under the manufacturer’s warranty, and the dealership has not provided a fix. This defect presents a major safety concern because the engine can suddenly lose oil pressure or seize while driving, leading to sudden loss of power or control, which could cause an accident and potential injury. It appears Volkswagen has been aware of similar issues in other model years, but has not issued a recall or permanent repair for this problem. There is currently a class action lawsuit for the exact same issue for 2022 - 2023 Volkswagen Tiguan but doesn't currently include the 2021 Tiguan that I have. I am requesting that NHTSA investigate these widespread PCV and oil consumption failures in 2021 Volkswagen Tiguan vehicles.