2003 BMW 3 Series
Problems, recalls and owner-reported issues
Air bags is the leading concern among 489 owner complaints filed for this model year. This is the 5th highest complaint count among 21 3 Series model years with reports.
Of the 2003 reports, 17 involved a crash and 21 involved a fire. 26 people were injured and 2 people died.
What owners report most often
Recalls and investigations
No safety recalls on file.
Representative owner complaints
489 reports, newest first.
Exterior lighting, Mar 20, 2012
TL* THE CONTACT OWNS A 2003 BMW 330I. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING:BRAKE LIGHTS) AND WAS TAKEN TO THE DEALER FOR REPAIRS. THE TECHNICIANS STATED THAT THE BULB HOUSING WOULD HAVE TO BE REPLACED BUT WOULD NOT BE COVERED UNDER THE RECALL. THE TECHNICIAN ADVISED THE CONTACT THAT THE RECALL REPAIR WOULD ONLY COVER THE WIRING HARNESS, WHICH CONNECTED TO THE TAILLIGHT. THE REPAIR COULD NOT BE PERFORMED UNLESS THE BULB HOUSING WAS REPLACED. THE REPLACEMENT OF THE BULB HOUSING WAS PERFORMED AS WELL AS THE RECALL REPAIR. THE APPROXIMATE FAILURE MILEAGE WAS 158,000. UPDATED 05/09/12 *BF THE CONSUMER STATED THE REPAIR WAS BEGAN WITHOUT FIRST INFORMING HIM OF THE ADDITIONAL CHARGERS FOR THE ADDITIONAL PARTS NOT COVERED BY THE RECALL. THE DEALER INFORMED THE CONSUMER AFTER THE ORIGINAL HARNESS WAS DESTROYED DURING REMOVAL THAT IT COULD NOT BE RE-INSTALLED . UPDATED 06/07/12 *JS
Exterior lighting, Mar 2, 2012
2003 BMW 325I. CONSUMER REQUESTS REIMBURSEMENT FOR RECALL REPAIRS PRIOR TO RECALL NOTIFICATION. *TGW THE CONSUMER STATED THE VEHICLE WAS SERVICED SEVERAL TIMES, TO CORRECT THE PROBLEM REGARDING THE REAR LAMPS. THE CONSUMER STATED SINCE SEVERAL OF THE REPAIRS WERE DONE PRIOR TO THE TIME FRAME ESTABLISHED BY THE RECALL, SHE WAS ONLY REIMBURSED PARTIALLY. RECALL# 11V438000. *JB
Exterior lighting, Feb 25, 2012
I HAVE ENCOUNTERED A FAILURE OF THE FACTORY XENON HEADLAMP ASSEMBLY. I HAVE HAD REDUCED VISIBILITY AS A RESULT OF A BURNT BULB HOUSING THAT DID NOT MAKE ITSELF READILY APPARENT. BECAUSE THERE IS NO REMEDY OUTSIDE OF REPLACING THE POORLY DESIGNED HOUSING, I HAVE A CONCERN OF THE SAFETY OF MYSELF, MY OCCUPANTS, AND OTHERS ON THE ROAD. A FAILED BULB IS UNDERSTANDABLE MAINTENANCE. A FAILED HEADLAMP ASSEMBLY DUE TO BURNING AND CRACKING THE PLASTIC LENS FROM SO MUCH HEAT IS NOT. THIS IS A POOR DESIGN, AND SHOULD WARRANT A RECALL. *TR
Fuel system, Gasoline, Feb 22, 2012
THE FUEL PUMP WENT BAD ,AND LEFT ME STRANDED ON A BUSY STREET,IT SUPPOSE TO HAVE A MANUFACTURER WARRANTY FOR 15YEARS OR 150,000 MILES FROM BMW, BUT THEY DON'T HONOR IT AT THE DEALER,I FEEL THIS SHOULD BE A RECALL DUE TO THE FACT THAT THE FUEL PUMP IS SEALED INSIDE THE TANK,WHICH LEAVES NO ACCESS TO CHANGE THE PUMP,AND THE DEALER IS STATING THAT WE HAVE TO PAY 6500.00 FOR THE WHOLE TANK.. THIS SHOULD BE A RECALL.. *TR
Exterior lighting, Feb 16, 2012, fire
TL* THE CONTACT OWNS A 2003 BMW 325I. THE CONTACT STATED THAT THE REAR PASSENGER SIDE TAIL LIGHT WOULD FAIL INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE VEHICLE WAS FUNCTIONING AS DESIGNED. THERE WAS A SMALL ELECTRICAL FIRE FROM THE TAIL LIGHTS. THE MANUFACTURER WAS CONTACTED, BUT DENIED ASSISTANCE WITH THE REPAIR BECAUSE THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING:TAIL LIGHTS . THE FAILURE MILEAGE WAS 53,000 AND THE CURRENT MILEAGE IS 94,000. THE CONSUMER STATED THE INTERMITTENT ISSUE WITH THE TAIL LIGHTS WAS IGNORED FOR MANY YEARS. UPDATED 02/23/12
Exterior lighting, Feb 14, 2012
PURCHASED VEHICLE NEW WHILE I WAS STATIONED WITH THE US AIR FORCE IN GERMANY, TO MY UNDERSTANDING IT WAS MADE IN GERMANY UNLIKE MOST 325'S AT THE TIME. IT WAS PRODUCED UNDER US SPECIFICATIONS AS I'D PLANNED TO BRING IT BACK TO THE STATES. I HAVE CONTINUOUSLY HAD PROBLEMS OVER THE YEARS WITH THE EXTERIOR LIGHTING TURN SIGNAL ACTING INTERMITTENTLY AS MENTIONED IN RECALL NHTSA CAMPAIGN ID NUMBER: 11V438000. HOWEVER, AFTER CONTACTING MY LOCAL BMW DEALER, AND BMW N.A., THEY HAVE INFORMED ME MY VIN ISN'T COVERED UNDER THE RECALL. I BELIEVE I MAY HAVE SLIPPED THROUGH THE CRACKS AS A VIN IDENTIFIED IN THE RECALL AS MY BMW WAS PRODUCED OUTSIDE THE NORMAL CHANNELS OF BMWS AFFECTED IN NORTH AMERICA. I BELIEVE THIS BECAUSE MY VEHICLE EXHIBITS THE EXACT CHARACTERISTICS OF THE RECALL IN QUESTION. I WOULD LIKE MY VIN INCLUDED ON THE RECALL AS EVEN TODAY DRIVING THE VEHICLE THIS MORNING I DIDN'T FEEL SAFE BECAUSE THE TURN SIGNAL IS INTERMITTENT. *TR
Suspension, Jan 31, 2012
BOTH REAR SPRINGS OF MY BMW 2003 325I WERE CRACKED & REPLACED FEB. 23, 2009. THEY NOW BOTH ARE BROKEN AGAIN. ANY TYPE WARRANTY ON THE PARTS ? RIDICULOUS !!!! *TT
Electrical system, Air bags, Latches/locks/linkages, Jan 20, 2012
MULTIPLE INTERMITTENT PROBLEMS WITH DOOR LOCKS FAILING TO OPEN EITHER BY KEY FOB, DEPRESSING BUTTON INSIDE CAR, OR BY PULLING INSIDE DOOR HANDLE. TO EXIT CAR, MUST LOWER WINDOWS AND INSERT KEY INTO OUTSIDE KEYHOLE. THIS IS A SERIOUS HAZARD! PROBLEM ARISES WITH NO APPARENT CAUSE, THEN WILL DISAPPEAR A FEW DAYS LATER WITH FOR NO APPARENT REASON. BMW REPLACED ACTUATOR (?) AND THE PROBLEM APPEARS TO HAVE DISAPPEARED, BUT IT COST ME $1400. OTHER ELECTRICAL PROBLEM IS WITH AIR BAG WARNING LIGHT COMING ON AFTER CAR SITS UNDRIVEN FOR MORE THAN A COUPLE OF DAYS. WAS TOLD THAT AIR BAGS WILL NOT WORK WITH LIGHT ON. NO REASON FOUND. BATTERY CHECKS OUT FULLY CHARGED. *TT
Exterior lighting, Jan 18, 2012
ZKW XENON HEADLIGHT REFLECTOR BOWL IS BURNED RESULTING IN VERY DIM LIGHT OUTPUT. I AM OFTEN AFRAID OF DRIVING AT NIGHT BECAUSE I FEEL IT IS A DANGER TO MY SAFETY.
Exterior lighting, Jan 13, 2012
TL* THE CONTACT OWNS A 2003 BMW 323. THE CONTACT STATED THAT THE HEADLIGHTS WOULD FLICKER ON AND OFF. THE TURN SIGNAL LIGHT WOULD ALSO FLICKER ABNORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HIM THAT THE TAILLIGHT ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING:TAIL LIGHTS). THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.
Exterior lighting, Jan 12, 2012
TAIL LIGHTS CONTINUE TO FAIL ON THIS MODEL. CALLED THE MANUFACTURER, BMW, AND THEY SAID THAT EVENTHOUGH A RECALL EXISTS FOR 2003 BMW 325I MODELS FOR TAIL LIGHT FAILURE (ID NO. 11V4380000), MY VIN NUMBER DID NOT CORRESPOND TO PRODUCTION RUN FAILURES UNDER RECALL. *TR
Engine and engine cooling, Jan 9, 2012
ENGINE VAPOR SEPARATOR, HOSES, DIPSTICK, AND VANOS LINE REPLACEMENT. THIS PART SEPARATES THE WATER VAPOR FROM THE OIL TO REMOVE CONDENSATION SO IT DOESN'T CIRCULATE INSIDE THE ENGINE. THE CAR WAS UNSAFE TO DRIVE WITH A FAULTY VAPOR SEPARATOR AND CAN CAUSE ENGINE VAPOR LOCK IF IT FAILS. THE REPAIR WAS ABOUT $1,400. *TR
Engine and engine cooling, Jan 9, 2012
THE OIL FILTER HOUSING GASKET FAILS ON BMW CARS. IT IS A MESH GASKET BETWEEN THE ENGINE AND THE BLOCK WHERE THE OIL ENTERS/EXITS THE FILTER. THE REPAIR IS ABOUT $600 AND FAILS FREQUENTLY ON THESE CARS. IT CAUSES OIL TO LEAK ONTO THE BLOCK AND GIVES A STRONG BURNING OIL SMELL. OIL CAN ACCUMULATE ON TOP OF THE ENGINE DEPENDING ON THE SEVERITY OF THE LEAK. OIL BLOWS AND COVERS THE OIL FILTER HOUSING AND THE INSIDE OF THE HOOD WITH A SPRAY OF STICKY OIL. *TR
Exterior lighting, Jan 9, 2012, fire
TL* THE CONTACT OWNS A 2003 BMW 325I. THE CONTACT STATED THAT THE REAR TAIL LIGHT FAILED. THE CONTACT EXAMINED THE VEHICLE AND FOUND THAT THE REAR TAIL LIGHT WIRES WERE BURNED. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING:TURN SIGNAL). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 161,000.
Exterior lighting, Jan 2, 2012
THE BMW E46 (3 SERIES BMW) THAT WAS MADE FROM 1999 TO 2006. IN SOME CASES DURING THESE YEARS THEY USED A LIGHTING MANUFACTURER "ZKW" FOR THEIR XENON HEADLIGHTS. UNFORTUNATELY THESE LIGHTS HAVE A COMMON FAILURE ISSUE COMMONLY REFERRED TO AS A "BURNT REFLECTOR" ON THE INTERNET AND ON BMW FORUMS. THIS IS A NON-CONSUMER REPLACEABLE PART. WHEN THIS PART FAILS IT CAUSES THE VEHICLE TO NOT HAVE EFFECTIVE HEADLIGHTS. I PERSONALLY HAVE HAD TIMES WHERE MY FIELD OF VISION COULD NOT SEE ITEMS ON THE ROAD DUE TO THE DIM LIGHTS. THE ONLY REMEDY APPEARS TO BE TO REPLACE THE ENTIRE HEADLIGHT ASSEMBLY TO THE TUNE OF HUNDREDS OF DOLLARS (WELL OVER A THOUSAND IF YOU DO BOTH SIDES). IN MY OPINION BMW SHOULD CORRECT THIS ISSUE FOR THE CONSUMER. HEADLIGHTS ARE AN IMPORTANT SAFETY ITEM. TO HAVE A PART FAIL THAT IS NOT CONSUMER REPLACEABLE IS UNACCEPTABLE. MANY PEOPLE HAVE THIS ISSUE BUT HAVE NO WAY TO REMEDY IT. JUST GOOGLE IT OR CHECK E46FANATICS.COM. YOU WILL SEE THAT THERE ARE PLENTY OF PEOPLE THAT REALIZE THIS IS AN ISSUE. *TR
Exterior lighting, Dec 29, 2011
XENON HEADLIGHT REFLECTORS ARE MELTING/BURNING CAUSING A SIGNIFICANT REDUCTION IN LIGHT OUTPUT. VERY SIMPLE PROBLEM FOR WHICH THERE IS NO FIX OTHER THAN TO PURCHASE NEW HEADLIGHT ASSEMBLES FOR $2,000. SEEMS TO AFFECT ALL XENON HEADLIGHTS PRODUCED BY ZWK FOR THE 2002-2004 3 SERIES BMW. *KB
Latches/locks/linkages, Dec 21, 2011
TL* THE CONTACT OWNS A 2003 BMW 325XI. THE CONTACT STATED THAT ALL FOUR DOOR LOCKS COULD NOT BE OPENED FROM THE INTERIOR OR EXTERIOR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THE CONTACT THAT THE COMPUTER CHIP NEEDED TO BE REPLACED AT THE OWNERS EXPENSE OF $1000. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHO ADVISED THE CONTACT THAT THEY WOULD NOT ASSIST. THE FAILURE MILEAGE WAS 46,000.
Exterior lighting, Dec 16, 2011, fire
TL* THE CONTACT OWNS A 2003 BMW 325I. THE CONTACT WAS DRIVING 20 MPH WHEN THE TURN SIGNAL FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER CONFIRMED THAT THE TURN SIGNAL WIRING AND THE BRAKE LIGHTS BURNED OUT. THE MANUFACTURER WAS CONTACTED WHERE THEY ADVISED THAT THE VEHICLE QUALIFIED FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING: TAIL LIGHTS), BUT THE CONNECTOR WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED AND THE VIN WAS UNAVAILABLE. THE FAILURE AND THE CURRENT MILEAGES WERE 110,000.
Electrical system, Structure, Latches/locks/linkages, Dec 13, 2011
PASSENGER SIDE DOOR AND BOTH REAR DOORS FAILED TO OPEN. ALL THREE DOORS REMAINED LOCKED AND COULD NOT BE OPEN FROM INSIDE BY USING THE MECHANICAL HANDLES. NEITHER THE REMOTE KEY NOR THE REGULAR KEY WAS ABLE TO UNLOCK THE DOORS. *TR
Exterior lighting, Dec 13, 2011
TL* THE CONTACT OWNS A 2003 BMW 330I. THE VEHICLE WAS INCLUDED IN THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING:TAIL LIGHTS). THE MANUFACTURER WAS CONTACTED AND STATED THAT THE WIRING CONNECTOR WOULD HAVE TO BE REPLACED PRIOR TO PERFORMING THE RECALL REPAIRS. THE WIRING CONNECTOR WOULD NOT BE COVERED UNDER THE RECALL REPAIRS. THE CONTACT STATED THAT THE CONSEQUENCES OF THE RECALL HAD DAMAGED THE WIRING CONNECTOR AND HE FELT IT SHOULD BE COVERED UNDER THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.
Electrical system, Latches/locks/linkages, Dec 11, 2011
MY 2003 BMW 325I WILL NOT UNLOCK. I CANT GET INTO THE CAR. I HAVE TRIED THE KEY AND THE FOB AND THE DOORS WILL NOT UNLOCK. I HAD TO BREAK THE WINDOW TO GET INTO THE CAR ONLY TO FIND OUT THE DOORS STILL WILL NOT UNLOCK. THIS IS A SAFETY ISSUE YOU CANT UNLOCK THE DOORS FROM THE INSIDE OR THE OUTSIDE. THIS IS EXTREMELY CONCERNING AND A TRUE SAFETY ISSUE. *TR
Electrical system, Latches/locks/linkages, Dec 11, 2011
DOORS WILL NOT OPEN BECAUSE DOOR LOCKS WILL NOT UNLOCK. KEY FOB BUTTON WILL NOT UNLOCK ANY DOORS 90% OF THE TIME. MOST OF THE TIME I CAN ONLY GET IN CAR ON DRIVERS SIDE WITH MANUAL OPERATION OF DRIVER'S SIDE DOOR LOCK (STICKING KEY IN LOCK AND TURNING). ONCE IN CAR, 90% OF TIME I STILL CANNOT UNLOCK ANY OTHER DOORS, EVEN BY PULLING ON DOOR HANDLE (WHICH WOULD ORDINARILY UNLOCK THE DOOR). THE INTERIOR BUTTON TO UNLOCK THE DOORS WILL NOT WORK. ON FRIDAY, 12/9/11, I COULD NOT EVEN GET OUT OF THE DRIVER'S SIDE DOOR WHEN I ARRIVED AT MY DESTINATION. (CAR IS SET TO AUTOMATICALLY ENGAGE ALL LOCKS ONCE I START DRIVING) I HAD TO ROLL WINDOW DOWN AND REACH OUT AND UNLOCK DOOR WITH KEY. WHEN MY SON AND DAUGHTER DRIVE WITH ME, THEY HAVE TO GET IN AND OUT OF CAR EITHER BY CRAWLING ACROSS DRIVER'S SEAT OR GO THROUGH A WINDOW OPENING. MY WIFE CANNOT RIDE IN THIS CAR NOW BECAUSE SHE MAY NOT BE ABLE TO GET OUT. DUE TO THIS DEFECT, PASSENGERS ARE TRAPPED IN CAR. ALSO, ENTRY INTO VEHICLE IS DELAYED (BECAUSE FOB WILL NOT UNLOCK DOORS) WHICH ALSO POSES SAFETY RISKS WHEN PARKED AT NIGHT IN DOWNTOWN PARKING GARAGES. THERE ARE FIVE OTHER COMPLAINTS ON NHTSA WEBSITE ON THIS EXACT SAME ISSUE. RECALL SHOULD BE INITIATED. *TR
Exterior lighting, Dec 11, 2011
MY BMW 2003 330I IS EQUIPPED WITH ZKW HEADLIGHT ASSEMBLIES THAT HAVE PLASTIC XENON PROJECTOR BOWLS INSTALLED INSIDE THE HEADLIGHT ASSEMBLIES. AFTER SEVERAL YEARS OF USAGE THESE PROJECTOR BOWLS BURN OUT AND AS A RESULT, THE REFLECTIVE COATING THAT ALLOWS LIGHT TO BE FOCUSED THROUGH THE PROJECTORS ARE BURNED OFF REDUCING EFFECTIVE LIGHT OUTPUT FROM THE HEADLIGHT ASSEMBLY. UPON INSPECTION, BOTH MY HEADLIGHT ASSEMBLIES SUFFERED APPROXIMATELY 50% LOSS IN EFFECTIVE LIGHT OUTPUT DUE TO BURNED OUT XENON PROJECTOR BOWLS AND I FOUND THAT MY FOG LIGHTS WERE PUTTING OUT MORE LIGHT THAN BOTH MY ZKW HEADLIGHTS. THIS PROBLEM AFFECTS ALL 3-SERIES SEDANS MADE FROM 2002 - 2005. THERE HAVE BEEN MANY PEOPLE WHO HAVE, AS A RESULT OF BMW INACTION TO DO THE RIGHT THING AND CORRECT THIS SERIOUS SAFETY DEFICIENCY, EITHER REPLACED THEIR ORIGINAL ZKW HEADLIGHT ASSEMBLIES WITH DEPOT AFTERMARKET HEADLIGHT ASSEMBLES OR HAVE REPLACED THE DEFECTED ZKW PROJECTOR BOWLS WITH AL PROJECTOR BOWLS OR FX-R PROJECTOR BOWLS. THIS PROBLEM NEEDS TO BE ADDRESSED AS IT IS A SERIOUS ROAD SAFETY ISSUE WHILE DRIVING AT NIGHT. *TR
Exterior lighting, Dec 11, 2011
ZKW BI XENON HEADLIGHTS REFLECTORS BURN OUT OVER TIME. THE BOWLS ARE SHOT AND THEY WERE BLACK, BURNED TO A CRISP. THEY WERE MADE OUT OF A PLASTIC MATERIAL WITH A CHROME COATING, INSTEAD OF A METAL REFLECTOR. THIS SHOULD BE A RECALL FOR BMW. THEY GOT THE TAIL LIGHT WHICH WORKS FINE IN MY CAR, I NEED MY HEADLIGHTS TO SEE! *TR
Exterior lighting, Dec 9, 2011
TL* THE CONTACT OWNS A 2003 BMW 3SERIES. THE CONTACT STATED THAT THE REAR TAIL LIGHT WARNING INDICATOR ILLUMINATED ON THE INSTRUMENTAL PANEL. AFTER CHECKING THE REAR OF THE VEHICLE, THE TAIL LIGHT APPEARED TO BE OPERATING AS DESIGNED. THE WARNING LIGHT WOULD ILLUMINATE ON AN INTERMITTENT BASIS. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 11V438000 (EXTERIOR LIGHTING:TAIL LIGHTS). THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.