2004 BMW 3 Series
Problems, recalls and owner-reported issues
Air bags is the leading concern among 558 owner complaints filed for this model year. This is the 4th highest complaint count among 21 3 Series model years with reports.
Of the 2004 reports, 26 involved a crash and 23 involved a fire. 29 people were injured.
What owners report most often
Recalls and investigations
No safety recalls on file.
Representative owner complaints: electrical system
63 reports, newest first. Show all
Electrical system, Seats, Nov 3, 2014, fire
THE HEATING ELEMENT ON MY 2004 BMW X3 CAUGHT ON FIRE WHILE I WAS DRIVING. I DON'T USE IT OFTEN, BUT HAD NOTICED A HOT SMELL WHEN I DID USE IT AND THAT IT WOULD BE TOO WARM IN THE LUMBAR AND HIP REGION. THE FIRE ACTUALLY BURNED ABOUT A DIME SIZE HOLE IN THE DRIVER SIDE LEFT SEAT PANEL (UNDER THE THIGH). AFTER READING OF MANY OTHERS HAVING THE SAME OR WORSE EXPERIENCES, I AM GLAD I IMMEDIATELY SHUT IF OFF, ALTHOUGH IT STILL BURNED ALL THE WAY THROUGH THE LEATHER. PLEASE ADVISE ME OF NEXT STEPS I SHOULD TAKE. I HAVE SHUT OFF THE HEATER AND WILL NO LONGER USE IT. WITH SO MANY COMPLAINTS, I WOULD THINK THIS WOULD RESULT IN A RECALL. THANKS FOR YOUR ADVICE. *TR
Electrical system, Exterior lighting, Oct 30, 2014
WIRE LOOSING COATING ON INSIDE OF ADAPTIVE HEADLIGHTS, CAUSING SHORTS OR BROKEN WIRES WHERE THE HEADLIGHTS AND OR TURN SIGNALS WILL FAIL TO WORK. WIRE IS VERY BRITTLE AS THIS IS ALSO ROUGHLY 20 GAUGE WIRE. THIS CAN BE AN EXTREME HAZARD ESPECIALLY AT NIGHT. THIS SEEMS TO BE AFFECTING BMW'S 3/5/6/ SERIES FROM AT LEAST 2004 TO 2008 FROM MY INDEPENDENT RESEARCH. MANY PICTURES AND COMPLAINTS ON VARIOUS BMW FORUMS TO DOCUMENT THIS PROBLEM. MY PROBLEM OCCURRED WHEN I LOST ONE HEADLIGHT ON MY WAY HOME IN THE DARK AND AN INDICATOR CAME ON TO IDENTIFY A FAULT IN THE HEADLIGHT. ORIGINALLY I THOUGH IT WAS A BULB, CHANGED BULB AND IT STILL DID NOT WORK. FURTHER INVESTIGATION LED TO A BROKEN WIRE INSIDE OF THE HEADLIGHT ASSEMBLY. I FIXED THE BROKEN WIRE AND THEN NOTICED TWO MORE WIRES WHERE THE COATING ON THE WIRE SEEM TO HAVE FLAKED OFF CAUSING BARE WIRE. I ALSO FIXED THOSE WIRES AND ALL WAS WELL. A DAY OR TWO LATER, THE INDICATOR CAME ON AGAIN POINTING TO THE SAME HEADLIGHT. THIS TIME THE TURN SIGNAL WAS OUT. I OPENED THE ACCESS PANEL TO CHECK THE WIRING AND NOW A FORTH WIRE HAS BEEN SEVERED, HOWEVER I CAN NOT FIX IT AS IT IS DOWN PRETTY FAR INSIDE THE HEADLIGHT AND TO REPAIR WOULD REQUIRE REMOVING THE HEADLIGHT AND TAKING IT APART. APPARENTLY BMW USED BIODEGRADABLE WIRE FOR THE HEADLIGHTS?? SOURCE OF THE HEADLIGHT IS BELIEVED TO BE HELLA. SUPPOSEDLY BMW KNOWS ABOUT THE ISSUE BUT UNWILLING TO FIX UNLESS YOU PURCHASE A $800-1500 NEW HEADLIGHT. THIS IS CRAZY FOR A CAR THAT IS 10 YEARS OLD AND WELL MAINTAINED. THIS IS A SAFETY HAZARD AS YOU WILL CAN LOOSE A HEADLIGHT IN THE DARK AND MAYBE BOTH HEADLIGHTS GOING OUT, PLUS THE FACT OF BARE WIRES THAT CAN SHORT AND CAUSE A FIRE. *TR
Electrical system, Exterior lighting, Visibility/wiper, Aug 25, 2014
AS REPORTED BY OTHER OWNERS, THE BI-XENON HEADLIGHTS NO LONGER LIGHT UP THE ROAD. IT IS A SAFETY HAZARD AND IS A KNOWN ISSUE WITH HEADLIGHTS MANUFACTURED BY ZKW ON 2003-2005 BMW 330 MODELS. THE REFLECTOR BOWLS ON THESE UNITS BURN OUT OVER TIME AND REDUCE THE HEADLIGHTS ABILITY TO REFLECT LIGHT. DRIVING AT NIGHT IS LITERALLY NO BETTER WITH THE HEADLIGHTS ON OR OFF. I HAVE TO RELY ON MY FOG LIGHTS JUST TO SEE ANYTHING. PLEASE LOOK INTO THIS SAFETY ISSUE AS IT IS WIDE-SPREAD. REPLACEMENT OF HEADLIGHTS IS EXPENSIVE AT $1300 EA, THIS HAS TO BE RESOLVED BY BMW IMMEDIATELY. *TR
Electrical system, Jan 22, 2014
CANNOT OPEN THE 3 PASSENGER DOORS FROM INTERIOR. PASSENGERS CANNOT EXIT THE CAR. *TR
Electrical system, Exterior lighting, Feb 18, 2013
MY BI-XENON HEADLIGHTS HAVE BEEN SLOWLY FADING RESULTING IN EXTREMELY POOR VISIBILITY DURING NORMAL NIGHTIME DRIVING. THIS DEGRADATION HAS BEEN OCCURRING WITHOUT MY KNOWLEDGE UNTIL IT BECAME OBVIOUS AFTER DRIVING ANOTHER VEHICLE. AS IT TURNS OUT, MY MECHANIC HAS ADVISED THERE IS A COMMON ISSUE WITH CERTAIN BMW ASSEMBLIES THAT THE PROJECTOR LENSES LITERALLY BURN DUE TO HEAT RESULTING IN THE NEED TO REPLACE THE ENTIRE ASSEMBLY. THIS LOSS OF HEADLIGHT INTENSITY RESULTING IN POOR VISIBILITY IS A SIGNIFICANT SAFETY SITUATION AND REQUEST SOMEONE LOOK INTO WHY NO RECALL HAS OCCURRED AS THIS IS OBVIOUSLY A SAFETY CONCERN. I HAVE ENTERED TODAY'S DATE AS INCIDENT DATE AS I AM NOT SURE WHEN DEGRADATION OF THE PROJECTORS BEGAN. *TR
Electrical system, Latches/locks/linkages, Jan 21, 2013
DOOR LOCKS INTERMITTENTLY WILL NOT UNLOCK WITH SWITCH OR REMOTES. CENTRAL LOCKING DOES NOT WORK EVEN WHEN USING THE KEY FOB. MY KIDS AND I HAVE BEEN TRAPPED IN THE CAR ON SEVERAL OCCASIONS FOR UP TO 10 MINUTES. THIS IS A SERIOUS RISK TO MY LIFE AND THE LIFE OF OTHERS ON THE ROAD. BMW REFUSES TO FIX THIS PROBLEM. I HAVE VIDEO OF ME TRAPPED IN THE CAR. I ADDRESSED HIS PROBLEM WITH BMW BEFORE MY WARRANTY WAS UP BUT THEY STATE SINCE THE TECHNICIANS COULD NOT IDENTITY ANY PROBLEM IT'S NOT COVERED. I RESEARCHED THIS ISSUE AND THIS IS AN ONGOING PROBLEM WITH OTHER CUSTOMERS. *TR
Electrical system, Dec 4, 2012
TL* THE CONTACT OWNS A 2004 BMW 325CI. THE CONTACT STATED THAT SHE NOTICED THERE WAS A LEAK FROM UNDER THE FRONT OF THE VEHICLE. THE CONTACT THEN ATTEMPTED TO START THE VEHICLE BUT TO NO AVAIL. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION WHERE THEY ADVISED HER THAT THE BATTERY FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 63,000.
Electrical system, Exterior lighting, Oct 23, 2012
DRIVER SIDE BRAKE LAMP HAS GONE OUT. IN RESEARCHING, FOUND THAT THIS IS A COMMON PROBLEM WITH THIS MODEL IN THE LED TAIL LIGHT AND CAN CAUSE A CRASH DUE TO OTHER DRIVERS NOT BEING ABLE TO TELL THAT YOU ARE STOPPING. FOUND RECALL INFORMATION ON NHTSA SITE AND CONTACTED BMW. I WAS INFORMED THAT MY SPECIFIC VIN WAS NOT INCLUDED IN THIS CAMPAIGN, YET THE PROBLEM IS THE SAME PROBLEM THAT AFFECTS 241,000 OTHER CARS. I WOULD LIKE TO ASK THAT MY SITUATION (AND VIN) BE EVALUATED AND INCLUDED IN THE RECALL SINCE THIS IS A KNOWN ISSUE WITH THIS MODEL. THANK YOU FOR YOUR ASSISTANCE! *TR
Electrical system, Visibility/wiper, Oct 9, 2012
THE GENERAL MODULE 5 IN E46 3 SERIES MODEL YEARS 2004-2006 FAIL CAUSING FAILURE OF TURN SIGNALS, CENTRAL LOCKING, WIND SHIELD WIPERS, AND HAZARD LIGHTS. THIS DEFECT IS KNOWN BY BMWNA BUT HAS NOT BEEN ADDRESSED. *TR
Electrical system, Visibility/wiper, Aug 10, 2012
MODULE THAT CONTROLS CENTRAL LOCKING, WIPERS, AND SEVERAL OTHER PARTS (THE GM5) STARTED TO DEVELOP A FAULT. WE HAD PROBLEMS UNLOCKING DOORS, LOCKING DOORS, USING WINDOWS, AND WORST OF ALL - THE WIPERS WERE HIT OR MISS. BMW WANTED $750 FOR THE PART REPLACEMENT. *TR
Electrical system, Exterior lighting, Visibility/wiper, Jul 13, 2012
DEAR NHTSA, THE HEADLIGHT DESIGN OF BMW'S E46 BODIES ARE JUST HORRIBLE. LIGHT OUTPUT IS CLOSE TO NONE CREATING A SIGNIFICANT PROBLEM REGARDING VISIBILITY. THE REASON IS DUE TO BMW'S REFLECTOR BOWL THAT DETERIORATES THROUGH OUT TIME DUE TO ITS PLASTIC MATERIAL AND FINALLY ENDS UP BURNING. IT IS SO BAD THAT THE FOG LIGHTS PRODUCE MUCH MORE LIGHT THEN ITS LOW BEAMS. WE DEFINITELY NEED YOUR HELP NHTSA BECAUSE BMW SURE DOES NOT WANT TO HELP, THEIR SOLUTION IS THAT YOU HAVE TO REPLACE THE WHOLE HEADLIGHT WHICH IS 1200 A PIECE. MILLIONS OF E46 OWNERS HAVE TO DEAL WITH THIS PROBLEM AND IS A MAJOR SAFETY CONCERN. NHTSA INVESTIGATORS MUST GO AND INVESTIGATE THE PROBLEM SO THEY KNOW HOW BAD IT REALLY IS. YES THAT MEANS BMW WILL LOOSE MILLIONS OF DOLLARS BUT IT IS SAFETY THAT MATTERS, WE DON'T WANT ANY PERSON OR CHILD TO BE KILLED JUST BECAUSE OF A POOR HEADLIGHT DESIGN. ONLY SOLUTION TO THIS PROBLEM IS UP TO YOUR GUYS, NHTSA. THANK YOU FOR TAKING TIME TO READ MY MESSAGE, I REALLY APPRECIATE IT. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Electrical system, Exterior lighting, Visibility/wiper, Jul 2, 2012
BOTH BIXENON HEADLAMPS ASSEMBLIES HAVE FAILED ON THE VEHICLE THEY EMIT LITTLE TO NO LIGHT DUE TO THE KNOWN BOWL BURN ISSUES WITH THE PLASTIC REFLECTORS (SHOULD HAVE BEEN FABRICATED FROM METAL), INSIDE THESE HEADLAMP ASSEMBLIES. IN LOOKING AT THE LIGHT ASSEMBLIES, THEY SEEMED TO HAVE FAILED A LONG TIME AGO. THIS IS A VERY UNSAFE AND HAZARDOUS SITUATION THAT RENDERS THE VEHICLE BASICALLY INOPERATIVE AT NIGHT TO THE OWNER, BECAUSE FELLOW DRIVERS, PEDESTRIANS, AND/OR BICYCLIST MAY BE NOT ABLE TO SEE YOUR HEADLIGHTS. THIS COULD CAUSE OR MAY HAVE ALREADY LEAD TO FATAL VEHICULAR ACCIDENT(S) OR THE DEATH OF A PEDESTRIAN(S) AND/OR BICYCLIST(S) BECAUSE OF THE LOW TO NO LIGHT EMITTED BY THESE FAULTY HEADLAMPS. WHILE PERFORMING IN DEPTH RESEARCH ON THE INTERNET DISCOVERED THAT THIS IS A VERY COMMON AND KNOWN PROBLEM ON THIS MAKE AND MODEL AT ALL MILEAGES. THE BMW FORUMS ARE FULL OF COMPLAINTS ABOUT THIS PROBLEM AND AN OPEN COMPLAINT SEEMS TO BE OPEN AND IN PROCESS WITH NHTSA SINCE 2009 SOME THREE YEARS AGO. NEITHER BMW OR ITS SUPPLIER OF THIS FAULTY PART MAKE A REASONABLY PRICED SERVICE PART THAT CAN BE PURCHASED TO CORRECT THIS KNOWN PRODUCT AND SAFETY PROBLEM. NOT EVEN THE AFTERMARKET INDUSTRY MAKES A SERVICE PART TO CORRECT THIS PRODUCT PROBLEM. TO CORRECT THIS ISSUE, YOU MUST PURCHASE TWO NEW COMPLETE HEAD LAMP ASSEMBLIES AT A COST OF APPROXIMATELY $ 1,200.00 EACH FROM BMW WHICH IS OUTRAGEOUS ESPECIALLY FOR SUCH A KNOW PRODUCT AND SAFETY PROBLEM. I CAN'T UNDERSTAND WHY A RECALL HAS NOT BEEN INITIATED FOR SUCH A KNOWN PROBLEM ON SO MANY VEHICLES THAT HAS BEEN ON GOING FOR SO LONG.. I CONTACTED BMW NORTH AMERICA FOR RELIEF WITH THIS KNOW SAFETY AND PRODUCT PROBLEM AND THEY COULD NOT HELP ME WITH THIS ISSUE BECAUSE THERE IS NO OPEN RECALL FOR THIS KNOWN PRODUCT AND SAFETY PROBLEM. *JS
Electrical system, Jun 10, 2012
SECURITY LOCK SYSTEM FAILED TO ALLOW PASSENGERS TO EXIT THE VEHICLE. THE DOORS WOULD NOT UNLOCK AND THE PASSENGERS HAD TO CLIMB OUT OF THE WINDOWS TO EXIT. IF THERE WERE AN EMERGENCY (E.G. CAR DROVE INTO DEEP WATER) THE WINDOWS WOULD NOT FUNCTION AND THERE WOULD HAVE BEEN NO WAY TO EXIT THE CAR. SEEM LIKE A SERIOUS FAILURE. *TR
Electrical system, Exterior lighting, Visibility/wiper, Jun 4, 2012
THE VEHICLE CAME EQUIPPED FROM THE FACTORY WITH BI-XENON AUTO LEVELING HEADLIGHTS MANUFACTURED BY ZKW. THE LIGHT OUTPUT OF THE HEADLIGHTS IS BELOW ANY VEHICLE THAT I HAVE ENCOUNTERED ON THE ROAD. CARS THAT ARE OVER 20 YEARS OLD HAVE BRIGHTER HEADLIGHTS. I HAVE REPLACED THE BULBS AND IT HASN'T HELPED. LOOKING AT IT FURTHER, BROWN SCORCH MARKS ARE VISIBLE IN THE PROJECTOR WHEN THE HEADLIGHT IS ON. THE REAR OF THE PROJECTOR IS COMPLETELY BROWN AND BURNT. AT NIGHT, IT IS BECOMING VERY DIFFICULT TO SEE. AT THIS POINT I DON'T FEEL SAFE DRIVING THE VEHICLE. THIS PROBLEM IS GETTING PROGRESSIVELY WORSE. *TR
Electrical system, Exterior lighting, Mar 24, 2012
MY BMW 325I XENON HEADLIGHT BOWLS HAD MELTED AND DIMMED TOA DANGEROUS POINT, THEY ARE ALL ORIGINAL AND UNALTERED. *TR
Electrical system, Mar 15, 2012, fire
THE VEHICLE HAD BEEN PARKED APPROXIMATELY 15-20 MINUTES WHEN WE WERE ALERTED BY THE FIRE ALARM IN OUR CONDO BUILDING. UPON EVACUATING THE BUILDING, WE WERE TOLD THAT OUR 2004 BMW 325I WAS ON FIRE. WE STILL HAVE NOT BEEN GIVEN ANY SPECIFIC CAUSE FOR THE FIRE, EXCEPT THAT IT WAS PROBABLY ELECTRICAL IN NATURE. SPECIAL AGENTS FROM OUR INSURANCE COMPANY WERE ALSO CALLED IN, WHO, IN TURN, CALLED IN TWO MORE EXPERTS. EVIDENCE WAS BAGGED AND THE CAR WAS SHRINK WRAPPED TO BE TAKEN TO A LOT WITH AT LEAST THREE OTHER BMW'S WHICH HAD ALSO CAUGHT FIRE WHILE PARKED. THIS IS ONE OF THE MOST FRIGHTENING THINGS TO EVER HAPPEN TO US. WE ARE POSTING THIS HOPING IT CAN HELP THIS FROM HAPPENING TO ANYONE ELSE. *TR
Electrical system, Jan 17, 2012
I RECEIVED A LETTER FROM BMW STSTING THERE WAS NOW A RECALL FOR THE BAD GROUND WIRE ON THE REAR TAILLIGHT ASSEMBLY THAT CAUSED THE METLING OF THE CONNECTOR. I HAD ALREADY SPENT $400 FOR THE FIX, NOW THEY RECALL THE PART. BMW NORTH AMERICA TOOK TOO LONG TO DO THIS, AND I AM GOING INTO THE DELAERSHIP TO SEE ABOUT GETTING A REFUND FOR THE SERVICE I PAID FOR THAT THEY WOULD NOT COVER.
Electrical system, Exterior lighting, Jan 8, 2012
I PURCHASED MY 2004 BMW 330I IN SEPT 2010, AT LEAST IN PART BECAUSE IT WAS ADVERTISED AS HAVING FACTORY INSTALLED XENON LIGHTS AND I HAVE ALWAYS WANTED BRIGHTER HEADLIGHTS THAN OTHER CARS I HAVE OWNED. WITHIN 3 MONTHS I WAS SO DISGUSTED WITH THE DIMNESS OF THOSE XENON'S THAT I PURCHASED 2 NEW D2S BULBS AND HAD THEM INSTALLED AT THE COST OF ABOUT $400. (I WAS TOLD THAT EVEN XENON'S "WEAR OUT" OVER TIME SO I FIGURED I WOULD BITE THE BULLET THIS ONE TIME) I FOUND RIGHT AWAY THAT THESE NEW BULBS WERE NO BETTER THAN I HAD BEFORE. AS A MATTER OF FACT, THE RIGHT SIDE LIGHTS SHINED AGAINST A WALL WERE ACTUALLY DIMMER THAN A D CELL FLASHLIGHT. I SUFFERED THOUGH TRYING TO DRIVE WITH MY PASSING LIGHTS ON AT NIGHT (YOU ACTUALLY HAVE TO HOLD THE HIGH BEAM STICK IN TO GET THESE LIGHTS TO STAY ON ) FOR A YEAR BEFORE I DECIDED TO REPLACE THE WHOLE HEADLIGHT ASSEMBLY BUT NO-ONE SELLS A REPLACEMENT FOR THE XENON EQUIPPED CARS. I THEN REMOVED THE ASSEMBLIES MYSELF AND WAS SHOCKED TO SEE CLEAR SIGNS OF BURNING OR CORROSION ON THE INSIDE OF THE REFLECTOR BOWLS. NO WONDER THE LIGHTS WOULD NOT SHINE ON THE HIGHWAY. IT IS SO BAD THAT EVERY TIME I AM PASSED ON THE HIGHWAY AT NIGHT I ACTUALLY SEE MY CAR'S SHADOW DIRECTLY IN FRONT OF ME FROM THE HEADLIGHTS OF THE CAR 50-100 FEET BEHIND ME. I NOW UNDERSTAND FROM FURTHER INVESTIGATION THIS IS AN ONGOING PROBLEM WITH ZKW HEADLIGHTS ON E46 BMW'S. I DO NOT HAVE THE TECHNICAL EXPERTISE OR EXTRA CASH TO FIX THESE DEFECTS. CAN YOU HELP?? NO ACCIDENTS OR INJURIES HAVE OCCURRED YET BUT I HAVE SEEN MANY PEDESTRIANS OR BIKERS AS I PASS THEM AT NIGHT ON THE SIDE OF THE ROAD THAT I NEVER SAW UNTIL I WAS NEXT TO THEM. *TR
Electrical system, Exterior lighting, Nov 30, 2011
RIGHT SIDE SIGNAL LIGHT INTERMITTENT FAILURE. WHEN IT FINALLY FAILED THERE WAS A SCORCHED WIRE. UPON INVESTIGATION FOUND THERE IS A TSB FROM THE MANUFACTURER BUT ONLY IN WARRANTY. NO RECALL. *KB
Electrical system, Oct 3, 2011
DURING A MASSIVE RAINSTORM WINDSHIELD WIPERS, RADIO AND CENTRAL LOOKING SYSTEM STOP FUNCTIONING PROPERLY. LOOKS LIKE GENERAL MODULE 5 HAS FAILED. *TR
Electrical system, Exterior lighting, Sep 9, 2011
REAR TURN-SIGNAL INDICATORS BEGAN FAILING TO OPERATE, ESPECIALLY IN HOT, HUMID CONDITIONS. INSPECTION OF WIRING HARNESS REVEALED EVIDENCE OF WIRING-CONNECTION DEGRADATION BY HEAT OR CORROSION. THE CAR HAS NOT BEEN DAMAGED OR FLOODED IN ANY WAY. IT IS KEPT IN A GARAGE. SINCE BOTH REAR BLINKER ASSEMBLIES HAVE BEEN AFFECTED, I BELIEVE THAT THE DESIGN OR ENGINEERING WAS DEFECTIVE. THE INTERMITTENT FAILURE OF TURN SIGNALS IS A SERIOUS SAFETY HAZARD. *TR
Electrical system, Exterior lighting, Jul 5, 2011
2004 BMW 325I - SAFETY DEFECT. REAR TAIL LIGHT WIRING, MISSING ADDITIONAL GROUND WIRE TO AVOID BURNING BULB CARRIER. BMW SERVICE INFORMATION BULLETIN ISSUED 2/2007 REVEALS BMW WAS AWARE OF THIS ISSUE AND FAILED TO NOTIFY CONSUMERS. PURCHASED CAR CPO IN MARCH 2007 AND WAS NOT TOLD. REPLACED SEVERAL TAILLIGHT BULBS DUE TO INTERMITTENT FALSE INDICATOR LIGHTS. FINALLY IN 2011, 1 YEAR AFTER CAR CAME OUT OF WARRANTY...REMOVED THE WIRING HARNESS CONNECTOR TO THE BULB CARRIER AND FOUND IT TO BE MELTING. CONTACTED DEALER AND WAS TOLD IT COULD DEFINITELY START A FIRE IF LEFT TOO LONG. BMW DEALER ALSO STATED THIS IS A DEFECT ON CARS PRODUCED FROM 2001 TO 2005. AFTER DOING RESEARCH FOUND THAT BMW HAS USED FAULTY WIRING AND THERE IS A ADDITIONAL GROUND WIRE NEEDED TO FIX. NEEDLESS TO SAY , HAD TO PAY 300.00 TO HAVE PEACE OF MIND AND REPAIR. *KB
Electrical system, Exterior lighting, May 27, 2011
TAIL LIGHT WORKING INTERMITTENTLY IN BMW 2004 325 4 DOOR SEDAN. *TR
Electrical system, Exterior lighting, May 3, 2011
2004 BMW 330I - TAIL LIGHT WIRING FAILURE. TAIL LIGHT BULB SOCKET (PART NUMBER W0133-1663035 FAILED DUE TO OVER HEATING AND MELTING OF CONNECTOR. RESULTS IN LOSS OF BRAKE LIGHT FUNCTION. PROBLEM COMMON TO BOTH DRIVER AND PASSENGER SIDE. PURCHASING NEW PART TO TRY TO CORRECT PROBLEM HOWEVER PROBLEM MAY ALSO INCLUDE FAILURE OF THE CONNECTOR (FEMALE) ON THE WIRING HARNESS WHICH IS NOT READILY AVAILABLE. OVER HEATING APPEARS TO BE DUE TO UNDERSIZING OF CONNECTOR/WIRE. THIS APPEARS TO BE A COMMON PROBLEM WITH E46 BMW'S (3 SERIES). PROBLEM WAS BROUGHT TO DEALER'S ATTENTION WHILE UNDER WARRANTY,...THEY DID NOT FIX IT. CONTACTED CORPORATE HEAD QUARTERS,...THEY DID NOT ACKNOWLEDGE THIS WAS A COMMON PROBLEM. (REF. EA09-019). *TR
Electrical system, Equipment, Feb 9, 2011
JUST PAID $419.53 FOR REPAIR ON MY 2004 BMW 3 SERIES FOR TAIL LAMP CONNECTIONS AND GROUNDS. I UNDERSTAND THAT THIS DEFECT IS UNDER INVESTIGATION IN NUMBER EA09-019. PLEASE INCLUDE ME AND INFORM ME WHEN I CAN SUBMIT PAID BILL, AS I WAS TERRIFIED WHILE DRIVING IN FL ON TURNPIKE WHEN A LIGHT ON MY DASHBOARD SHOWED MY REAR BRAKES WERE FAILING. I IMMEDIATELY FOUND FIELDS BMW JIN WINTER PARK FL AND BROUGHT IT THERE. THEY WERE AWARE OF DEFECT AND TOLD ME THAT THEIR FIX WOULD INCLUDE GROUNDING OTHER REAR BRAKE LIGHT TO PREVENT OTHER SIDE FROM FAILURE. THANK YOU *TR