2006 BMW 3 Series
Problems, recalls and owner-reported issues
Air bags is the leading concern among 1,243 owner complaints filed for this model year. This is the highest complaint count among 21 3 Series model years with reports.
Of the 2006 reports, 29 involved a crash and 40 involved a fire. 23 people were injured.
What owners report most often
Recalls and investigations
Engine and engine cooling, exhaust system, emission control, crankcase (pcv)Mar 2, 2022
BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4 Roadster (Z4 3.0i, Z4 3.0si, Z4 sDrive30i) vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.
This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417.
Campaign 22V119000 on NHTSA.gov
Engine and engine cooling, cooling system, fanAug 10, 2012
This recall involves aftermarket parts sold by Valeo. Valeo is recalling certain engine cooling fans, part numbers 696121, 696273, and 696275, used as service replacement parts for model year 2008-2011 BMW 1-Series, 2006-2011 BMW 3-Series, 2000-2009 BMW 5-Series, 2004-2005 BMW 6-Series, and 2006-2007 BMW 7-Series vehicles. A metal-oxide semiconductor may overheat due to insufficient screwing of the semiconductor on the aluminum heat sink. This primary failure could cause adjacent components on the fan assembly motor circuit board to overheat and short.
This condition could cause the fan motor to become inoperative, or cause the motor circuit board in the assembly to overheat, potentially leading to a fire in the engine compartment.
Valeo will notify owners and replace the fans free of charge. The safety recall began on August 22, 2012. This recall is being conducted by Valeo, not by BMW. For further information, owners may contact Valeo at 1-888-718-2536.
Campaign 12E029000 on NHTSA.gov
Air bags, frontalAug 5, 2008
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Campaign 08V384000 on NHTSA.gov
Suspension, front, control armOct 18, 2006
ON CERTAIN VEHICLES, ONE OF THE SUSPENSION CONTROL ARM AND SWIVEL BEARING CONNECTION BOLTS WAS NOT TIGHTENED CORRECTLY. THE BOLTED CONNECTION COULD LOOSEN.
THE BOLTED CONNECTION COULD BREAK WHICH COULD IMPAIR VEHICLE HANDLING AND CONTROL, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE BOLTED CONNECTION AND, IF NECESSARY, ADJUST THE CONNECTION. IN SOME CASES, IT MAY BE NECESSARY TO REPLACE THE SUSPENSION CONTROL ARM AND THE SWIVEL BEARING. THE RECALL BEGAN ON NOVEMBER 21, 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.
Campaign 06V400000 on NHTSA.gov
Representative owner complaints: electrical system
188 reports, newest first. Show all
Electrical system, Apr 10, 2026, fire
While driving the vehicle, the blower (A/C) began to cycle on and off. Then I began to smell electrical smoke. Then I began to see smoke coming from vents and where the windshield meets the dashboard, closer to the passenger side. I pulled over and shut off the car as the smoke was getting worse inside the car. I popped the hood and saw smoke coming from the passenger side. I then called 911. Smoke was beginning to billow from engine compartment. As I was talking to the 911 dispatcher, I saw flames beginning in the engine bay close to the firewall on passenger side. The car was a total loss and is in a tow yard. It can be inspected upon request. The 911 operated told me to be aware of smoke and explosions so I backed away about 30ft. Many cars were passing by, close to the car. There are 2 safety recalls on this vehicle that are related to possible fire. I have an open case with BMW USA. They have not inspected the car. I have liability only for insurance so they will not cover. There were no warning lamps or indicators before fire.
Electrical system, Engine, Fuel/propulsion system, Sep 15, 2025
The Valvetronic Actuator malfunctions. The malfunction may have been caused by a Battery Positive Cable that has corroded over time. The result is that the vehicle stops unexpectedly during acceleration. Driver safety and that of others is put at risk due to the vehicle suddenly losing power and stoping while being driven. The vehicle was evaluated by the dealer. Warning lamps were intermittent and inconsistent. To my knowledge there is no Valvetronic Actuator or Battery Cable specific warning lamps or messages. There was a 2017 recall for the Battery Positive Cable, but my specific VIN was not covered (by a few months). My VIN (1986 325I) should have been included in the 2017 recall.
Electrical system, May 13, 2025
Internal Adaptive bi-xenon headlight wiring insulation flaking off exposing bare wire, thus causing headlight to fail
Engine and engine cooling, Electrical system, Jan 7, 2025, fire
The contact owned a 2006 BMW 325i. The contact stated while driving 60-65 MPH, the A/C became inoperable and made an abnormally loud sound. The contact then noticed an abnormal burning wiring odor, and there was smoke coming out of the A/C vents. There was no warning light illuminated. The contact stated that she attempted to pull to the side of the road, but could not safely do so. The contact continued driving and came to a complete stop at the traffic light, where the cabin became engulfed in smoke. The contact then pulled into a business parking lot and immediately exited the vehicle. The contact stated upon opening the hood, the contact noticed a reflection of the flame inside the hood. The contact ran into the business and asked for assistance. The contact stated that upon returning to the vehicle, the contact noticed that the fire had started from the middle of the hood to the cabin of the vehicle. The contact and the business employee attempted to extinguish the fire with two fire extinguishers but were unable to do so. The fire was extinguished by the fire department. The contact stated that the vehicle burned to the ground from the middle of the hood to the trunk, where the gas tank was located, and the hood was fractured in half. The contact stated that there were burned particles around the parking lot, but there was no property damage. The fire department report was filed. A police report was filed, but the contact did not have the information available. There was no injury sustained. The vehicle was towed to a tow lot, where it was totaled. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 140,000.
Engine and engine cooling, Electrical system, Sep 12, 2024, fire
The contact's husband owns a 2006 BMW 325i. The contact stated moments after her son had started, parked and exited the vehicle, there was smoke coming from under the hood. The under hood caught on fire and the hood failed to open. The fire was extinguished by the fire department. The contact stated that the under hood, the front of the vehicle and the front tires burned significantly. A fire department report was filed. A police report was not filed. There was no injury sustained. The vehicle remained at the residence. The vehicle was awaiting to be destroyed. The dealer was contacted. The contact contacted the manufacturer and sent pictures of the incident to the manufacturer; however, the manufacturer informed the contact that the fire was not related to NHTSA Campaign Number: 22V119000(Engine and Engine Cooling). The failure mileage was unknown.
Electrical system, Air bags, Service brakes, Jan 22, 2023
After recall done pvc valve and blower heat a/c now not working the car engine light come up abs /brake and more
Electrical system, Jan 10, 2023
All door lock actuators (including the fuel cap door cover) stopped working after driving the vehicle. The passenger and both rear doors were able to open via the inside door handle, but the driver side door could not be unlocked via the key fob, console lock button, or manually pulling the inside door handle. The fuel cap door cover could only be opened via the emergency release pull in the trunk. After inspecting the fuse box, I found that fuse 57a was blown. I replaced the fuse and the locking mechanisms started functioning again. weeks later the same issue occurred, only replacing the fuses remedied the problem for only a day or two. The fact that the driver's side door could not be opened by ANY means from inside or outside the vehicle poses a severe safety risk in situations where the driver of the car needs to exit the vehicle themself or be evacuated carefully in the event of injury. There are NO warnings, messages or warning signs before this occurs. This appears to be a common issue on my model and others, originating from issues with the door lock actuators. BMW even has a service information bulletin about it: "SI B51 19 07". The fact that the driver-side door can spontaneously become unopenable from inside or outside while the driver is in the car is a HUGE safety risk.
Electrical system, Sep 29, 2022
Intermittently on startup/ignition, car electrical shuts completely down. No power to anything and key fob becomes locked in the ignition. After a few minutes the electrical comes back on on its own. This usually only happens in park on startup, however on one occasion, the electrical shut off for about 5 seconds as I was driving 70 MPH on the highway. Car went totally dark and I was fortunately able to control the wheel until power came back.
Electrical system, Engine, Fuel/propulsion system, Aug 9, 2022
BMW has issued a recall with no resolution. My engine is making noises from the crankcase and no alternative has been offered at this moment. The dealer does not want to address the issue.
Electrical system, Aug 2, 2022, fire
The contact owned a 2006 BMW 330i. The contact stated that while driving approximately 25 MPH, the air conditioning unit suddenly shut off and smoke began to come out of the air conditioning vents. After the contact exited the vehicle flames were present coming from under the passenger side dashboard. The fire and police departments were called to the scene and the flames were extinguished. During the incident, the vehicle was destroyed. A fire and a police report were taken at the scene and the vehicle was towed away. The local dealer was notified of the incident. The manufacturer was not yet contacted. The failure mileage was 190,000.
Steering, Electrical system, Other or unspecified, Jul 24, 2022
Vehicle Steering Lock Malfunction - Car does not start and stuck in Park. Cannot move steering wheel which is locked. This is a design defect that needs to be addressed. Vehicle is rendered inoperative! Cannot move or start it! approx. mileage 105k. This is a new problem besides the current recall which has not been available yet. I've also been locked out of this vehicle and had to climb out of the window, thank God it was not a fire or flood! I was able to fix that problem myself. note: Steering Lock Malfunction is a widespread problem! Dealers want to replace the entire steering column in these cases at a very high cost. Thanks, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Electrical system, May 18, 2022
The contact owns a 2006 BMW 325i. The contact received notification of NHTSA Campaign Number: 17V676000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Electrical system, Apr 26, 2022, fire
My car was just sitting in my driveway and my roommate noticed she said is there is your car supposed to be on fire and we went out there had to break the windows and it was already on fire and totally ruined from any repair. I didn't receive a recall until a year after it had already caught on fire. The car is totaled in my backyard. And is beyond repair because of the fire
Electrical system, Engine, Mar 15, 2022
Over heating and smell of burning plastic
Power train, Electrical system, Engine, Apr 12, 2021, fire
OIL FILTER HOUSING GASKET LEAKED ON TO ALTERNATOR CAUSING THE ALTERNATOR TO OVER HEAT AND MELT INTERNAL COMPONENTS WHICH CAUSING LACK OF POWER AND MULTIPLE FALSE CHECK ENGINE CODES TO COME ON AND SMOKE CLOUDED MY VIEW WHILE DRIVING SO VERY COMMON PROBLEM IS THE HEATER CORE LEAKING TOO
Electrical system, Exterior lighting, Apr 3, 2021
GOING THROUGH MY NEWLY PURCHASED, USED 2006 330XI, I FOUND SEVERAL WARNINGS FOR FRONT HEADLIGHT MALFUNCTIONS. FURTHER INVESTIGATION SHOWED ADAPTIVE FUNCTIONS WERE DISABLED AND THE LEFT LOW BEAM WAS STUCK POINTING LEFT. WHILE THE BULBS THEMSELVES WERE STILL FUNCTIONING, THE LIGHT WAS POINTED DIRECTLY AT ONCOMING TRAFFIC AND DID NOT ILLUMINATE THE ROAD IN FRONT OF ME. OPENING THE ACCESS PANEL AT THE REAR OF THE HEADLIGHT ASSEMBLY SHOWED MULTIPLE BARE WIRES INSIDE OF THE SEALED HOUSING, THE INSULATION HAD SIMPLY STARTED TO FLAKE OFF OF THE WIRES RENDERING ALL CENTERING AND LEVELING FUNCTIONS OF THE LIGHT INOPERABLE. RESEARCH HAS SHOWN THIS IS A WIDESPREAD PROBLEM WITH BMW HEADLIGHTS, FOR ADDITIONAL DOCUMENTED DATA AND CASES PLEASE REFERENCE THE FOLLOWING FORUM THREAD : HTTPS://WWW.BIMMERFEST.COM/THREADS/
Electrical system, Exterior lighting, Dec 15, 2020
E90 BMW REVERSE LIGHT STOP WORKING DO TO CAR COMPUTER SYSTEM FAULT, THIS POSES A HIGH RISK WHEN VEHICLE IS IN REVERSE OTHER DRIVER ARE NOT NOTIFIED. THIS CAN CAUSE A POTENTIAL ACCIDENT.
Electrical system, Vehicle speed control, Service brakes, Jul 19, 2020
I WAS TRAVELING TO A LOCAL STORE. MY CAR SUDDENLY JERKED,RADIO TURNED OFF WHILE LIGHTS ON DASH FLICKERED ON AND OFF. I LOST POWER TEMPORARILY AND I BEGAN SMELLING WIRES. I ALSO NOTICE A 'POP' AS I ATTEMPTED TO PULL OVER AND NOTICE NO BRAKE OPERATIONS SO I HAD TO COAST TO A STOP WITH MY 2 YEAR OLD IN THE BACKSEAT. I STARTED MY FLASHERS AND TURN OFF CAR TO SEARCH FOR SMELL. IT SEEMS LIKE DASH BUT I DIDN'T SEE ANY SMOKE. I GET BACK IN CAR AND ATTEMPT TO START IT AND NOTHING! I STILL HAVE POWER SO I WAS CONFUSED, I CHECK TRUNK ULTIMATELY AND REMOVE BATTERY COVER AND THIS IS WHAT I FOUND! THIS IS A SAFETY ISSUE AND VERY DANGEROUS. I GOT THE CAR TOWED HOME AND WON'T DRIVE UNTIL IT IS REPAIRED OBVIOUSLY. I AM UPSET BUT EVEN HAPPIER ME AND MY KID MADE IT HOME SAFELY, SOMETHING KEEPS TELLING ME TODAY WAS A BLESSING WE MADE IT.
Electrical system, Vehicle speed control, Other or unspecified, Jun 29, 2020
HAVE HAD THE CAR LESS THAN TWO MONTHS AND I HAVE BEEN EXPERIENCING NON-SAFE SITUATIONS. THE CAR JUST ONE DAY SUDDENLY DOESN?T COME OUT OF PARK. IT FINALLY GOT OUT OF PARK AND WHEN I TRY TO DRIVE AND IT REVERSES AND MAKE ALOT OF NOISE AND WHEN I SOMETIMES TRY TO REVERSE. IT DRIVES. THIS IS NOT SAFE. I?VE NEARLY GOTTEN MYSELF KILLED DUE TO THIS FAULTY BAD CAR. I TRIED TO CALL FOR A TRADE OR A REFUND AND THE COMPANY WAS RUDE TO ME. THIS CAR TAKES MY GIRLFRIEND AND I TO WORK AND THIS IS THE ONLY CARE WE HAVE. IT HASN'T BEEN A YEAR AND THE CAR HAS SO MANY ISSUES DOWN TO CAR NOT READING GEARS, BAD SPARK PLUGS , HOLE UNDERNEATH, FAULTY AIRBAGS, WINDOWS NOT WORKING, TIRE PRESSURES UNSAFE AND MUCH MORE THAT NO ONE WOULD WANT TO EXPERIENCE. *TR
Electrical system, Air bags, Apr 27, 2020
AC STOP WORKING AND A BURN WIRING SMELL CAME OUT
Electrical system, Feb 23, 2020
2006 BMW 325I THE BIODEGRADABLE WIRING HAS DETERIORATED CAUSING THE DIRECTIONAL AND HEADLAMPS TO FAIL RESULTING IN EXPENSIVE REPAIRS AND JEOPARDIZES THE SAFETY OF THE DRIVERS OF THE VEHICLE WHILE IN USE.
Electrical system, Engine, Jan 17, 2020
WHEN THE IBS IS PLUGGED IN IT DRAINS THE BATTERY FAST , THEN IT WON'T START UNLESS I UNPLUG THE B+ BLUE PLUG , THEN PLUG THE B+ CABLE BACK IN AFTER STARTED SO THE VALVETRONIC ECCENTRIC SHAFT MOTOR HAS POWER , OTHERWISE IT GOES INTO LIMP MODE WITHOUT IT PLUGGED IN , I THOUGHT THERE WAS A RECALL ON THIS BUT IT STARTS ON THE 2007 E90 I GUESS MINE IS A 2006 .
Electrical system, Other or unspecified, Engine, Sep 9, 2019
I HAVE A RECALL ON THE HEATER DEVICES, NOT QUIT SURE WHAT THAT IS BUT IT CAN CAUSE MY ENGINE TO OVERHEAT AND CATCH FIRE. I'VE ALREADY REPLACED THE COOLANT SYSTEM BECAUSE OF OVER HEATING I'M VERY SCARED OF DRIVING THE CAR. I WOULD LIKE TO GET IT FIXED A SOON AS POSSIBLE, ITS NICE CAR AND I'VE PUT A LOT OF MONEY IN IT ALREADY, TRYING TO KEEP IT ON THE ROAD,ITS MY WORK TRANSPORTATION.
Power train, Electrical system, Air bags, Aug 26, 2019
AIR BAG. WARNING SENSOR,ADAPTIVE HEADLIGHTS WARNING,POWER STEERING LEAKING,BRAKES CLUMPING,BLOWER HEATER MOTOR AND MODULE HAD TO REPLACE.
Electrical system, Aug 14, 2019
COMPLETE LOSS OF POWER, SHUT CAR OFF FOR A FEW MINUTES, WHEN TRYI G TO RESTART VEHICLE NOTICED ZERO POWER TO ANY COMPONENTS