2008 BMW 3 Series
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 691 owner complaints filed for this model year. This is the 3rd highest complaint count among 21 3 Series model years with reports.
Of the 2008 reports, 15 involved a crash and 63 involved a fire. 25 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Engine and engine cooling, exhaust system, emission control, crankcase (pcv)Mar 2, 2022
BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4 Roadster (Z4 3.0i, Z4 3.0si, Z4 sDrive30i) vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.
This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417.
Campaign 22V119000 on NHTSA.gov
Engine and engine cooling, cooling system, fanAug 10, 2012
This recall involves aftermarket parts sold by Valeo. Valeo is recalling certain engine cooling fans, part numbers 696121, 696273, and 696275, used as service replacement parts for model year 2008-2011 BMW 1-Series, 2006-2011 BMW 3-Series, 2000-2009 BMW 5-Series, 2004-2005 BMW 6-Series, and 2006-2007 BMW 7-Series vehicles. A metal-oxide semiconductor may overheat due to insufficient screwing of the semiconductor on the aluminum heat sink. This primary failure could cause adjacent components on the fan assembly motor circuit board to overheat and short.
This condition could cause the fan motor to become inoperative, or cause the motor circuit board in the assembly to overheat, potentially leading to a fire in the engine compartment.
Valeo will notify owners and replace the fans free of charge. The safety recall began on August 22, 2012. This recall is being conducted by Valeo, not by BMW. For further information, owners may contact Valeo at 1-888-718-2536.
Campaign 12E029000 on NHTSA.gov
Air bags, frontalJul 8, 2009
BMW IS RECALLING 2,350 MY 2008 1-SERIES AND 3- SERIES PASSENGER CARS. INCORRECT CRIMP CONNECTORS MAY HAVE BEEN USED ON THE SIDE AIR BAG AND BELT TENSIONER WIRING. AS A RESULT SUFFICIENT CONTACT BETWEEN THE CRIMP CONNECTORS AND THE CORRESPONDING PLUG MAY NOT OCCUR WHICH COULD LEAD TO AN INCREASE IN THE ELECTRICAL RESISTANCE OF THAT CONNECTION.
IF THAT HAPPENED, IT WOULD BE POSSIBLE FOR THE SIDE AIR BAG AND/OR THE SAFETY BELT TENSIONER NOT TO DEPLOY AND WILL NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
BMW WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2009. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES TOLL-FREE AT 1-800-525-7417.
Campaign 09V257000 on NHTSA.gov
Representative owner complaints: fuel system
82 reports, newest first. Show all
Fuel system, Gasoline, Aug 17, 2010
1. 2008 BMW 335I SEDAN HIGH FUEL PUMP PRESSURE PROBLEM. I ALMOST HAD AN ACCIDENT. 2. IT HAPPENED 3 TIMES WITHIN A YEAR. 3. THE FUEL PUMP WAS REPLACED. *TR
Fuel system, Gasoline, Power train, Aug 12, 2010
MULTIPLE FUEL SYSTEM FAILURES ON VEHICLE STARTING AT 27,055 MILES, SECOND AT 28,711 MILES, THIRD AT 40,872 MILES. ALSO EXCESSIVE TRANSMISSION LEAK AT 35,784 MILES.(REPAIRED) SEVERAL ATTEMPTS OF REPROGRAMMING SOFTWARE FAILED TO FIX THE FUEL SYSTEM PROBLEM. STILL ONGOING FUEL SYSTEM FAILURE SYMPTOMS OCCURRING AFTER RECENT DEALER SERVICE/INSPECTION. THE THIRD BREAKDOWN WAS CATASTROPHIC AND HAD TO HAVE VEHICLE TOWED OFF ROADWAY. *TR
Fuel system, Gasoline, Aug 11, 2010
1. LONG CRANKS WHEN STARTING THE ENGINE IN THE MORNING... 2. ENGINE MALFUNCTION MESSAGE, EVERY FEW DAYS.. LOSS POWER 3. BMW REPLACE HIGH PRESSURE FUEL PUMP. *TR
Fuel system, Gasoline, Aug 11, 2010
HIGH PRESSURE FUEL PUMP FAILED AFTER REPLACEMENT AND NOW THE CAR SOMETIMES STALLS AT START. *TR
Fuel system, Gasoline, Aug 7, 2010
CAR SHOWED SIGNS OF LONG CRANK, WHEN STARTING AND HESITATION WHEN DRIVING THE VEHICLE AT ALL SPEEDS. EVENTUALLY THE CHECK ENGINE LIGHT WOULD COME ON AND OFF. CAR EVENTUALLY STALLED OUT AND ENGINE LIGHT CAME ON WHEN DRIVING ON THE FREEWAY IN HEAVY TRAFFIC, ALL POWER WAS LOST IN THE VEHICLE INCLUDING STEERING. DEALERSHIP REPLACED THE HIGH PRESSURE PUMP, AND TWO MONTH LATER WHEN IT FAILED AGAIN REPROGRAMMED THE CAR. TWO ADDITIONAL VISITS TO THE SHOP FOR THE SAME CIRCUMSTANCES-CAR STALLED ON THE FREEWAY LOSING ALL POWER AND DEALERSHIP REPLACED INJECTORS, IGNITION COILS, SPARKPLUGS AND THE MOST RECENT CLAIM THAT THE CAR WAS LOW ON FUEL WITH 1/4 TANK! WHEN CAR DIES ALL OF A SUDDEN ON THE FREEWAY AT A SPEED OF 60+ MILES PER HOUR IS EXTREMELY DANGEROUS. SEEING ALL THE OTHERS WITH THE SAME PROBLEMS MADE ME REALIZE THAT BMW IS NOT GOING TO ADDRESS THE PROBLEM UNTIL SOMETHING TRAGIC HAPPENS. *TR
Fuel system, Gasoline, Aug 3, 2010
TL* THE CONTACT OWNS A 2008 BMW 335I. WHILE TRAVELING AT 60 MPH, THE VEHICLE BEGAN TO VIBRATE ABNORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE HIGH PRESSURE FUEL PUMP WAS REPLACED, HOWEVER THE FAILURE PERSISTED. THERE WERE NO FURTHER REPAIRS. THE FAILURE MILEAGE WAS 16,000 AND THE CURRENT MILEAGE WAS 30,000.
Engine and engine cooling, Fuel system, Gasoline, Jul 31, 2010
ON JULY 24, 2010, MY 2008 BMW 335I SEDAN EXPERIENCED AN HPFP FAILURE IN HEAVY TRAFFIC AT HIGHWAY SPEED. MY 335I (DELIVERED JULY 2008) HAS HAD LONG START CRANKS FOR AT LEAST ONE YEAR. MY WASHINGTON, DC BMW DEALERSHIP HAS SAID IT CANNOT REPLACE THE HPFP UNTIL IT FAILS OR THROWS AN ELECTRONIC CODE. ON JULY 24, I WAS DRIVING APPROX 500 MILES TO A VACATION. 350 MILES INTO THE TRIP, ON I-87 AT APPROX 65MPH IN VERY HEAVY TRAFFIC, A CAR CUT INTO MY (MIDDLE) LANE. I MOVED TO THE LEFT LANE AND QUICKLY APPLIED MEDIUM THROTTLE TO KEEP UP WITH TRAFFIC. MY ENGINE STUMBLED SEVERELY AS I CHANGED LANES/ACCELERATED AND THE HALF-POWER ENGINE LIGHT CAME ON. THE CAR BEGAN RUNNING EXTREMELY ROUGHLY, WOULD NOT ACCELERATE AND LOST SPEED RAPIDLY, IN THE LEFT LANE OF VERY CROWDED HIGHWAY. THE CAR BEHIND ME NEARLY REAR-ENDED ME. I SHUT OFF ANY ACCESSORIES (AIR CONDITIONING, STEREO, ETC.), PUSHED THE GAS PEDAL TO THE FLOOR AND WAS ABLE TO MAINTAIN APPROX 50-55MPH ON A LONG DOWNHILL AS I MERGED OVER TO THE RIGHT LANE AND WAS ABLE TO GET OUT OF TRAFFIC. AS I PULLED OFF, THE CAR NEARED A STALL, WITH THE ENGINE IDLE JUMPING WILDLY. I TURNED THE CAR OFF. A MINUTE OR TWO AFTER TURNING IT BACK ON, THE HALF-POWER ENGINE ICON CAME ON AGAIN, ALONG WITH A SERVICE ENGINE SOON LIGHT, AND THE ENGINE AGAIN HAD ALMOST NO POWER TO ACCELERATE AND RAN ROUGHLY. THE HPFP AND LOWER PRESSURE FUEL SENSOR WERE REPLACED BY KEELER BMW, LATHAM, NY, ON JULY 29, 2010. MY CAR HAD RECEIVED THE SOFTWARE UPDATE DURING A PAST SERVICE. I'VE KNOWN ABOUT THE HPFP PROBLEM FOR SEVERAL YEARS. BECAUSE OF THE LONG CRANKS, I HAVE BEEN WAITING FOR MINE TO FAIL AND HOPED IT WOULD NOT BE IN A DANGEROUS SITUATION. I NOTED A RECENT ARTICLE IN WHICH A BMW SPOKESPERSON SAID THE FAILURES ARE NOT OCCURRING AT HIGHWAY SPEED. GIVEN MY EXPERIENCE, BMW NEEDS TO BE HONEST ABOUT THIS PROBLEM. I WAS DRIVING AT HIGHWAY SPEED, IN VERY HEAVY TRAFFIC, AND FEEL FORTUNATE TO HAVE COME OUT WITHOUT GETTING IN AN ACCIDENT OR WORSE. *TR
Fuel system, Gasoline, Jul 31, 2010
ENGINE STARTS ARE PRECEDED BY LONG CRANKS, FLUCTUATING RPMS AND SHAKING FELT AT THE DRIVER'S SEAT. CAR GOING 70MPH, LOST POWER UPON ACCELERATION ON A BUSY HIGHWAY DRIVING BACK FROM WORK. "ENGINE MALFUNCTION - REDUCED POWER" WARNING CAME ON THE DASHBOARD, AS WELL AS THE HALF ENGINE LIGHT. CARS BEHIND ME FRANTICALLY SWITCHED LANES TO AVOID COLLISION. THE WARNING MESSAGE WENT AWAY AFTER I RESTARTED CAR LATER, BUT KEPT SHOWING UP EVERY TIME I DROVE. THIS HAPPENS WITHOUT FAIL EVERY TIME I DRIVE. I'VE ALREADY MADE AN APPOINTMENT WITH THE DEALERSHIP TO FIX PROBLEM. THIS IS, APPARENTLY, A WELL KNOWN FAILURE. BMWNA HAS ISSUED AN EXTENDED WARRANTY ON THE FUEL PUMP SYSTEM, BUT HAS NOT ISSUED AN OFFICIAL RECALL. THIS PROBLEM CAN POTENTIALLY LEAD TO SERIOUS INJURIES/COLLISIONS. BMWNA MUST ISSUE AN OFFICIAL RECALL SOON. *TR
Fuel system, Other, Electrical system, Jul 29, 2010
ENGINE MALFUNCTION. LOSS OF POWER. *TR
Fuel system, Other, Jul 25, 2010
HIGH PRESSURE FUEL PUMP FAILURE. FAILURE STARTS OFF WITH LONG STARTS, FOLLOWED BY ROUGH IDLE FOLLOWED BY REDUCED POWER AND FAILED PUMP. HAD 4 PUMPS REPLACED. *TR
Fuel system, Other, Jul 25, 2010
WHILE DRIVING AROUND 65-70MPH, I EXPERIENCED A COMPLETE LOSS OF ENGINE POWER, AND HAD TO PULL OVER TO THE SHOULDER OF THE HIGHWAY. I IMMEDIATELY RESTARTED THE VEHICLE AND WAS LEFT WITH 50% ENGINE POWER (LIMP MODE). LUCKILY THE DEALER WAS ONLY A COUPLE MILES AWAY, SO I IMMEDIATELY DROVE THERE FOR REPAIR, BUT HAD THIS BEEN ELSEWHERE IN THE REGION, I WOULD HAVE BEEN STRANDED. THE BMW HIGH PRESSURE FUEL PUMP WAS REPLACED AND THE CAR HAS BEEN WORKING WELL EVER AFTER. I WAS TOLD THAT THIS INCIDENT ACCURATELY REFLECTS WHAT TYPICAL HIGH PRESSURE FUEL PUMP (HPFP) FAILURES TYPICALLY PRESENT LIKE. *TR
Fuel system, Gasoline, Jul 25, 2010
MY WIFE WAS ON THE FREEWAY DOING 65 MPH AND THE CAR SUDDENLY STALLED, LUCKILY SHE WAS ABLE TO MOVE TO SHOULDER. TURNS OUT IT WAS A PROBLEM WITH THE FUEL PUMP. I DID NOT KNOW THERE WERE OTHER PEOPLE WHO HAVE THE SAME PROBLEM UNTIL I READ THIS ARTICLE. THERE SHOULD BE A RECALL. *TR
Fuel system, Gasoline, Jul 25, 2010
LOST ENGINE POWER DUE TO MALFUNCTIONING FUEL PUMP. THE PROBLEM HAS OCCURRED TWICE SINCE THE CAR WAS PURCHASED IN 1/2008 - IN 4/2008 AND 5/2010. BOTH TIMES THE DEALER REPLACED THE DEFECTIVE FUEL PUMP AT NO COST. *TR
Fuel system, Gasoline, Jul 25, 2010
MY 2008 BMW 335 JUST STOPPED WITHOUT ANY WARNINGS IN THE MIDDLE OF THE ROAD WHILE IT WAS CLIMBING UP THE HILL AT 35 MPH. THERE WAS NO CAR BEHIND ME. LUCKILY, I WAS NOT DRIVING ON A HIGHWAY. *TR
Fuel system, Gasoline, Jul 24, 2010
ANOTHER HIGH PRESSURE FUEL PUMP FAILURE IN MY 2008 BMW 335I. THIS TIME IT HAPPENED WITHOUT ANY WARNING, JUST AFTER PICKING UP MY CHILDREN AT PRE-SCHOOL, I PULLED OUT ONTO A BUSY STREET WHICH IS DIFFICULT TO GET A WHOLE IN TRAFFIC. STEPPED ON THE GAS TO PULL OUT AND SPEED UP QUICKLY TO THE FLOW OF TRAFFIC (45 MPH), THE CAR STARTS TO ACCELERATE FOR ABOUT 2 SECONDS, THEN ACTS LIKE I TOOK MY FOOT OFF THE ACCELERATOR, GOES INTO A LIMP MODE, RPM DROP TO 4-500RPM AND THE CAR SHAKES AND RUNS ROUGH AND WILL BARELY ACCELERATE NO MATTER HOW HARD I PUSH THE GAS PEDAL. THE FLOW OF TRAFFIC HAS TO BRAKE EXTREMELY HARD TO AVOID REAR ENDING ME SINCE THERE IS NO REAL SHOULDER OR ANY TIME TO EVEN PULL OVER, THANK GOD I WAS NOT HIT AND EVERYONE ELSE IN TRAFFIC MANAGED TO SLOW DOWN QUICKLY WITHOUT INCIDENT - IT WOULD HAVE BEEN EASY FOR THIS TO HAVE ENDED IN A 40MPH SPEED DIFFERENTIAL REAR END COLLISION WITH 2 SMALL CHILDREN IN MY CAR. I WOULD LIKE TO FEEL CONFIDENT THAT I CAN RETURN MY CAR FOR REPAIR, BUT SINCE THIS IS THE APPARENTLY REPAIRED PART ALREADY INSTALLED AND THAT EVEN THE NEW REPAIR PART THAT WILL BE PUT IN MY CAR HAS ALREADY FAILED MANY TIMES ACCORDING TO THE DEALER, I FEEL THAT BMW IS JUST PUTTING ME BACK IN POTENTIALLY THE SAME DANGEROUS POSITION TO HAPPEN AGAIN. MY FIRST FUEL PUMP FAILED AT 2000 MILES, THIS ONE FAILED AT 10000 MILES, AT THIS RATE I WILL NEED 20 FUEL PUMP REPLACEMENTS BEFORE THE 100000 MILE WARRANTY RUNS OUT AND POTENTIALLY BE IN UP TO 20 ACCIDENTS WHEN THIS HAPPENS - PLEASE REOPEN THIS CASE AND INVESTIGATE BMW FURTHER BEFORE SOMEONE IS SERIOUSLY INJURED OR KILLED! *TR
Fuel system, Gasoline, Jul 13, 2010
MULTIPLE FAILURES OF HIGH PRESSURE FUEL PUMP ON MY 2008 BMW 335I SEDAN. THE RESULT IS THE SUDDEN LOST OF POWER AND UNABLE TO DRIVE THE CAR AT MORE THAN 40MPH.. MULTIPLE FAILURES OF THE BRAKE SENSORS AND PADS.. FAILURE OF CENTRAL LOCKING SYSTEM - UNABLE TO LOCK AND UNLOCK THE CAR... *TR
Steering, Fuel system, Gasoline, Electrical system, Jun 28, 2010
BMW 328XI SPORTWAGON CAR POWER LOST SPORADICALLY WHILE CAR IS IN USE. 1ST TIME, CAR STOPPED AT STOP SIGN, WHEN ATTEMPTING TO PULL OFF, CAR TURNED OFF. ALL POWER LOST ONLY AVAILABLE FUNCTION - BRAKES. 2ND TIME, SAME DAY AS 1ST INCIDENT, CAR MOVING APPROX 50MPH, HIT A BUMP, ALL CAR POWER LOST. ONLY AVAILABLE FEATURE, BRAKES. CAR WOULD NOT RESTART FOR APPROX 2.5 HOURS. OCCURRED IN CONSTRUCTION ZONE, SO CAR AND DRIVER SITTING IN TRAFFIC LANE. UNSURE WHAT WAS FIXED. SUPPOSEDLY SOME PART NEAR GAS PUMP HOLE THAT LEAKED - CORROSION ON COMPUTER - REPLACED. 3RD TIME - CAR CUT OFF WHILE TRAVELING 10 MPH MAKING RIGHT HAND TURN. BRAKES WORKED ONLY. D/T LOSS OF POWER STEERING, CAR STOPPED IN ONCOMING TRAFFIC LANE. REPLACED "FUEL/AIR INTAKE" MODULATOR? NOT SURE OF THE NAME. OLD PART WAS AT DEALERSHIP. 4TH TIME - CAR CUT OFF WHILE MAKING LEFT HAND TURN IN BUSY INTERSECTION AT APPROX 15 MPH. ENTIRE ONBOARD COMPUTER REPLACED. 5TH TIME - TRAVELING APPROXIMATELY 25MPH. WHILE CROSSING RAILROAD TRACKS, CAR CUT OFF - RESTARTED IMMEDIATELY. HAS NOT YET BEEN REPAIRED. ALL REPAIRS DONE UNDER MANUFACTURERS WARRANTY. PARTS MAY STILL BE AVAILABLE AT DEALERSHIP. EACH INCIDENT BETWEEN 2-4 WEEKS APART. DEALERSHIP KEPT CAR DURING LAST REPAIR FOR 6 WEEKS. STILL UNABLE TO REPAIR. REGIONAL REP CALLED AND SERVICED CAR AS WELL. NUMEROUS PARTS REPLACED AT THIS POINT, WITHOUT RESOLUTION. VERY BIG SAFETY ISSUE FOR OBVIOUS REASONS. DATE OF 1ST INCIDENT 3/9/2010. DATE OF MOST RECENT INCIDENT 5/26/2010. *TR
Fuel system, Gasoline, May 10, 2010
MY 2008 BMW 335I ONLY HAD AROUND 28,000 MILES WHEN I BEGAN NOTICING IT TOOK AN INORDINATE AMOUNT OF TIME TO START THE ENGINE. IT WOULD CRANK FOR SEVERAL SECONDS BEFORE THE ENGINE FINALLY STARTED, ESPECIALLY IF IT WAS A COLD START. ONCE THE ENGINE WAS WARMED UP IT SEEMED TO RUN JUST FINE. IT HAS NOW BEEN IN THE SHOP 4 TIMES SINCE JAN 2010 AND I'M SICK OF IT! AM TERRIFIED ABOUT THE CAR STOPPING ON THE INTERSTATE, AMID TRAFFIC, LIKE HAS BEEN DESCRIBED IN VARIOUS OTHER POSTS! *TR
Fuel system, Gasoline, Electrical system, Mar 7, 2010, fire
THREE FUEL PUMP FAILURES, BMW FACTORY REP LOOKED AT CAR AT BMW CLEVELAND, IN SOLON, OHIO. ONE WEEK LATER CAR CAUGHT ON FIRE WHILE SITTING IN PARKING LOT AT WORK. *TR
Engine and engine cooling, Fuel system, Gasoline, Power train, Mar 4, 2010
TL*THE CONTACT OWNS A 2008 BMW 335XI. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH; PROCEEDING TO A TRAFFIC SIGNAL. THE TRANSMISSION EXHIBITED A JERKING MOTION. THE VEHICLE CONTINUED IN OPERATION. IN ADDITION, THE FUEL PUMP FAILED ON SEVERAL OCCASIONS. THE TURBO CHARGER AND BANOS SYSTEM FAILED TO OPERATE PROPERLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE VEHICLE WAS REPAIRED UNDER THE SERVICE WARRANTY. THE DRIVER OBSERVED AFTER THE VEHICLE SERVICE REPAIR; SMOKE WAS COMING FROM THE TAIL PIPE AND OIL WAS LEAKING. THE FAILURE MILEAGE WAS 50. THE CURRENT MILEAGE WAS 34,000. THE VIN WAS UNAVAILABLE.
Fuel system, Gasoline, Feb 10, 2010
MY CAR HAS ALREADY FAILED TWICE WITH THE SAME PROBLEM, I.E., FAILURE OF HIGH PRESSURE FUEL PUMP (HPFP). THE PROBLEM OCCURRED TWICE WITHIN A YEAR FROM THE TIME OF PURCHASE. IT APPEARED THAT BMW HAVE NO FIX TO THE ISSUE YET. CONCERNED THAT THIS PROBLEM IS SERIOUS AND LEAD TO SERIOUS PROBLEMS RELATED TO SAFETY. TWO HPFP'S WERE REPLACED BY THE BMW DEALER AND THERE IS NO GUARANTEE THAT LATEST PART WILL FIX THE ISSUE PERMANENTLY. *TR
Fuel system, Gasoline, Feb 3, 2010
ENGINE SUDDENLY SHUT OFF, LOST POWER STEERING ON FREEWAY WHILE GOING 65MPH. WAS ABLE TO SAFELY ROLL TO THE NEXT EXIT. DEALERSHIP FOUND DEFECTIVE HIGH PRESSURE FUEL PUMP. *TR
Fuel system, Gasoline, Feb 2, 2010
MULTIPLE HIGH PRESSURE FUEL PUMP(HPFP) FAILURES. WHILE DRIVING DOWN A BUSY AVENUE THE ENGINE UNEXPECTEDLY SHUTS DOWN DUE TO THE HPFP FAILING. THIS WAS AFTER THE CAR HAD MADE 2 PREVIOUS VISITS TO THE DEALERSHIP TO REPAIR HPFP PROBLEMS. CURRENTLY I AM NOW ON MY 3RD HPFP IN 2MONTHS. UNSAFE CAR TO DRIVE, ESPECIALLY IF THIS WAS TO OCCUR AT HIGH SPEEDS ON A HIGHWAY. BMW HAS BEEN HAVING ISSUES FOR THIS PROBLEM SINCE MODEL YEAR 2007 UP UNTIL 2010, WITH NO PRODUCT CHANGES OTHER THAN SIMPLE REPLACEMENTS. HPFP SHOWS SIGNS OF PROBLEMS WHEN STARTING THE CAR, DUE TO LONG CRANKS, UNSTABLE RPM'S AND ENGINE SHUTTERING. *TR
Fuel system, Other, Jan 28, 2010
THIS IS THE SECOND FAILURE OF THE HPFP IN MY 2008 BMW 335I. IT OCCURRED WHEN I LEFT WORK AND STARTED CAR AND THE CAR SHUDDERED AND THE INDICATOR SHOWED THAT THE CAR WENT INTO LIMP MODE (REDUCED POWER). DROVE THE CAR TO MY CHILD'S PRESCHOOL AND TURNED OFF THE CAR. STARTED THE CAR AND AGAIN THE CAR WENT INTO LIMP MODE. DECIDED TO TAKE THE CAR DIRECTLY TO THE DEALERSHIP AND THE CAR STALLED THREE TIMES ON THE WAY. TWO OF THE STALLS WERE WHILE THE CAR WAS MOVING. THE HPFP WAS REPLACED UNDER WARRANTY THE NEXT DAY.*CW
Fuel system, Other, Jan 20, 2010
MY BMW 335XI HAS REPEATEDLY HAD FUEL PUMP ISSUES. THE ENGINE WILL MALFUNCTION WHEN I AM IN THE MIDDLE OF THE ROAD (OFTEN TIMES IN THE MIDDLE OF THE HIGHWAY). THIS IS NOT ONLY A POTENTIAL SAFETY ISSUE FOR MYSELF, BUT FOR OTHERS ON THE ROAD AS WELL. THIS FUEL PUMP FAILURE ISSUE PREVENTS MY CAR FROM MOVING, WHICH CAN POTENTIALLY LEAD TO SOMEONE'S DEATH, ESPECIALLY ON THE HIGHWAY. PLEASE FORCE BMW TO RECALL THIS FUEL PUMP ASAP. *TR