2008 BMW 3 Series
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 691 owner complaints filed for this model year. This is the 3rd highest complaint count among 21 3 Series model years with reports.
Of the 2008 reports, 15 involved a crash and 63 involved a fire. 25 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Engine and engine cooling, exhaust system, emission control, crankcase (pcv)Mar 2, 2022
BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4 Roadster (Z4 3.0i, Z4 3.0si, Z4 sDrive30i) vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.
This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417.
Campaign 22V119000 on NHTSA.gov
Engine and engine cooling, cooling system, fanAug 10, 2012
This recall involves aftermarket parts sold by Valeo. Valeo is recalling certain engine cooling fans, part numbers 696121, 696273, and 696275, used as service replacement parts for model year 2008-2011 BMW 1-Series, 2006-2011 BMW 3-Series, 2000-2009 BMW 5-Series, 2004-2005 BMW 6-Series, and 2006-2007 BMW 7-Series vehicles. A metal-oxide semiconductor may overheat due to insufficient screwing of the semiconductor on the aluminum heat sink. This primary failure could cause adjacent components on the fan assembly motor circuit board to overheat and short.
This condition could cause the fan motor to become inoperative, or cause the motor circuit board in the assembly to overheat, potentially leading to a fire in the engine compartment.
Valeo will notify owners and replace the fans free of charge. The safety recall began on August 22, 2012. This recall is being conducted by Valeo, not by BMW. For further information, owners may contact Valeo at 1-888-718-2536.
Campaign 12E029000 on NHTSA.gov
Air bags, frontalJul 8, 2009
BMW IS RECALLING 2,350 MY 2008 1-SERIES AND 3- SERIES PASSENGER CARS. INCORRECT CRIMP CONNECTORS MAY HAVE BEEN USED ON THE SIDE AIR BAG AND BELT TENSIONER WIRING. AS A RESULT SUFFICIENT CONTACT BETWEEN THE CRIMP CONNECTORS AND THE CORRESPONDING PLUG MAY NOT OCCUR WHICH COULD LEAD TO AN INCREASE IN THE ELECTRICAL RESISTANCE OF THAT CONNECTION.
IF THAT HAPPENED, IT WOULD BE POSSIBLE FOR THE SIDE AIR BAG AND/OR THE SAFETY BELT TENSIONER NOT TO DEPLOY AND WILL NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
BMW WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2009. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES TOLL-FREE AT 1-800-525-7417.
Campaign 09V257000 on NHTSA.gov
Representative owner complaints
691 reports, newest first.
Fuel system, Gasoline, Jul 25, 2010
MY 2008 BMW 335 JUST STOPPED WITHOUT ANY WARNINGS IN THE MIDDLE OF THE ROAD WHILE IT WAS CLIMBING UP THE HILL AT 35 MPH. THERE WAS NO CAR BEHIND ME. LUCKILY, I WAS NOT DRIVING ON A HIGHWAY. *TR
Fuel system, Gasoline, Jul 24, 2010
ANOTHER HIGH PRESSURE FUEL PUMP FAILURE IN MY 2008 BMW 335I. THIS TIME IT HAPPENED WITHOUT ANY WARNING, JUST AFTER PICKING UP MY CHILDREN AT PRE-SCHOOL, I PULLED OUT ONTO A BUSY STREET WHICH IS DIFFICULT TO GET A WHOLE IN TRAFFIC. STEPPED ON THE GAS TO PULL OUT AND SPEED UP QUICKLY TO THE FLOW OF TRAFFIC (45 MPH), THE CAR STARTS TO ACCELERATE FOR ABOUT 2 SECONDS, THEN ACTS LIKE I TOOK MY FOOT OFF THE ACCELERATOR, GOES INTO A LIMP MODE, RPM DROP TO 4-500RPM AND THE CAR SHAKES AND RUNS ROUGH AND WILL BARELY ACCELERATE NO MATTER HOW HARD I PUSH THE GAS PEDAL. THE FLOW OF TRAFFIC HAS TO BRAKE EXTREMELY HARD TO AVOID REAR ENDING ME SINCE THERE IS NO REAL SHOULDER OR ANY TIME TO EVEN PULL OVER, THANK GOD I WAS NOT HIT AND EVERYONE ELSE IN TRAFFIC MANAGED TO SLOW DOWN QUICKLY WITHOUT INCIDENT - IT WOULD HAVE BEEN EASY FOR THIS TO HAVE ENDED IN A 40MPH SPEED DIFFERENTIAL REAR END COLLISION WITH 2 SMALL CHILDREN IN MY CAR. I WOULD LIKE TO FEEL CONFIDENT THAT I CAN RETURN MY CAR FOR REPAIR, BUT SINCE THIS IS THE APPARENTLY REPAIRED PART ALREADY INSTALLED AND THAT EVEN THE NEW REPAIR PART THAT WILL BE PUT IN MY CAR HAS ALREADY FAILED MANY TIMES ACCORDING TO THE DEALER, I FEEL THAT BMW IS JUST PUTTING ME BACK IN POTENTIALLY THE SAME DANGEROUS POSITION TO HAPPEN AGAIN. MY FIRST FUEL PUMP FAILED AT 2000 MILES, THIS ONE FAILED AT 10000 MILES, AT THIS RATE I WILL NEED 20 FUEL PUMP REPLACEMENTS BEFORE THE 100000 MILE WARRANTY RUNS OUT AND POTENTIALLY BE IN UP TO 20 ACCIDENTS WHEN THIS HAPPENS - PLEASE REOPEN THIS CASE AND INVESTIGATE BMW FURTHER BEFORE SOMEONE IS SERIOUSLY INJURED OR KILLED! *TR
Fuel system, Gasoline, Jul 13, 2010
MULTIPLE FAILURES OF HIGH PRESSURE FUEL PUMP ON MY 2008 BMW 335I SEDAN. THE RESULT IS THE SUDDEN LOST OF POWER AND UNABLE TO DRIVE THE CAR AT MORE THAN 40MPH.. MULTIPLE FAILURES OF THE BRAKE SENSORS AND PADS.. FAILURE OF CENTRAL LOCKING SYSTEM - UNABLE TO LOCK AND UNLOCK THE CAR... *TR
Steering, Fuel system, Gasoline, Electrical system, Jun 28, 2010
BMW 328XI SPORTWAGON CAR POWER LOST SPORADICALLY WHILE CAR IS IN USE. 1ST TIME, CAR STOPPED AT STOP SIGN, WHEN ATTEMPTING TO PULL OFF, CAR TURNED OFF. ALL POWER LOST ONLY AVAILABLE FUNCTION - BRAKES. 2ND TIME, SAME DAY AS 1ST INCIDENT, CAR MOVING APPROX 50MPH, HIT A BUMP, ALL CAR POWER LOST. ONLY AVAILABLE FEATURE, BRAKES. CAR WOULD NOT RESTART FOR APPROX 2.5 HOURS. OCCURRED IN CONSTRUCTION ZONE, SO CAR AND DRIVER SITTING IN TRAFFIC LANE. UNSURE WHAT WAS FIXED. SUPPOSEDLY SOME PART NEAR GAS PUMP HOLE THAT LEAKED - CORROSION ON COMPUTER - REPLACED. 3RD TIME - CAR CUT OFF WHILE TRAVELING 10 MPH MAKING RIGHT HAND TURN. BRAKES WORKED ONLY. D/T LOSS OF POWER STEERING, CAR STOPPED IN ONCOMING TRAFFIC LANE. REPLACED "FUEL/AIR INTAKE" MODULATOR? NOT SURE OF THE NAME. OLD PART WAS AT DEALERSHIP. 4TH TIME - CAR CUT OFF WHILE MAKING LEFT HAND TURN IN BUSY INTERSECTION AT APPROX 15 MPH. ENTIRE ONBOARD COMPUTER REPLACED. 5TH TIME - TRAVELING APPROXIMATELY 25MPH. WHILE CROSSING RAILROAD TRACKS, CAR CUT OFF - RESTARTED IMMEDIATELY. HAS NOT YET BEEN REPAIRED. ALL REPAIRS DONE UNDER MANUFACTURERS WARRANTY. PARTS MAY STILL BE AVAILABLE AT DEALERSHIP. EACH INCIDENT BETWEEN 2-4 WEEKS APART. DEALERSHIP KEPT CAR DURING LAST REPAIR FOR 6 WEEKS. STILL UNABLE TO REPAIR. REGIONAL REP CALLED AND SERVICED CAR AS WELL. NUMEROUS PARTS REPLACED AT THIS POINT, WITHOUT RESOLUTION. VERY BIG SAFETY ISSUE FOR OBVIOUS REASONS. DATE OF 1ST INCIDENT 3/9/2010. DATE OF MOST RECENT INCIDENT 5/26/2010. *TR
Wheels, Jun 19, 2010
UPON MOUNTING NEW TIRES ON MY 2008 BMW 328I CONVERTIBLE (W/ SPORT PKG) AT BIG O TIRES IN DANVILLE, CA, THE TECHNICIANS INFORMED ME THAT BOTH OF MY REAR WHEELS WERE CRACKED, AND THEY COULD NOT MOUNT THE NEW TIRES ON THE VEHICLE. UPON INSPECTION AT BMW OF SAN FRANCISCO, MY SERVICE ADVISOR TOLD ME THAT IT WAS IN THEIR OPINION THAT AN "IMPACT" FROM A POTHOLE OR OTHER IRREGULAR ROAD SURFACE CAUSED THE CRACKS IN BOTH REAR WHEELS AND THAT WARRANTY COVERAGE IS DENIED. UPON MY OWN INVESTIGATION, I FOUND SEVERAL OTHER BMW CUSTOMERS DESCRIBE A SIMILAR CONCERN ON WWW.BIMMERFEST.COM, AS WELL AS AN INVESTIGATION PERFORMED BY THE BBC IN OCTOBER OF 2009. FOR BBC'S ARTICLE, PLEASE REFER TO HTTP://WWW.BBC.CO.UK/BLOGS/WATCHDOG/2009/10/BMW_ALLOY_WHEELS.HTML . *TR
Power train, May 31, 2010
INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) TO WHOM IT MAY CONCERN: THE 2008 BMW 335XI I HAVE GOT ENGINE OVER HEATED WARMING SIGH POP OUT FROM CAR COMPUTER AND THE CAR LOSE THE POWER RIGHT AWAY WHILE I WAS STILL DRIVING ON THE FAST LANE ON THE FREE WAY WHICH ALMOST GOT ME IN ACCIDENT FRONT THE CAR BEHIND TWICE. I BROUGHT THE CAR IN TO THE DEALER AND THEY SAID THERE IS ERROR RECORD SHOWING MY CAR ENGINE BEEN OVER HEATED BUT THEY CANNOT DO ANYTHING ABOUT IT THAT I NEED TO CONTACT BMWNA FOR SOLUTION. I DID SOME RESEARCH ABOUT MY CAR DOES NOT COME WITH THE OIL COOLER WHICH SHOULD ORIGINAL COME INSTALL IN THE CAR SINCE THE CAR HAS SPORT PACKAGE AND BMWNA BEEN DOING RETROFIT TO MANY OTHER CARS ALREADY. I MENTION THAT WHILE BMWNA CONTACT ME BUT THEY SAID THEY CANNOT DO ANYTHING ABOUT IT EVEN WITH THE CAR DID RECORD ENGINE OVER HEATED PROBLEM UNLESS I OVER HEATED THE CAR AT THE DEALERSHIP THEN THEY WILL CONSIDER FIXING THE PROBLEM. ALSO SINCE I AM THE SECOND OWNER OF THE VEHICLE THEY ARE NOT GOING TO OD THE OIL COOLER REFROFIT FOR ME. I ASK BMWNA THEY SHOULD TAKE CARE THIS PROBLEM SINCE THE CAR IS ONLY 1 AND HALF YEAR OLD AND THE PROBLEM SHOULD BE TAKE CAR BY WARRANTY BUT THEY SAID THEY CANNOT DO ANYTHING TO FIX IT. THIS ALREADY HAVE SOME SERIOUS SAFETY ISSUES SINCE THEY KNOW THIS CAR NEED TO BE PUTTING OIL COOLER IN ORDER NOT TO GET IT OVERHEATED AND LOSE POWER WHILE DRIVING. BMWNA DID THE RETROFIT FOR FIRST OWNER BUT I GUESS THEY DO NOT CONSIDER THE LIFE OF THE SECOND AS IMPORTANT AS THE FIRST OWNER TOO. MAYBE THEY WILL STATE LOOKING AT THE ENGINE OVERHEATED PROBLEM LIKE TOYOTA WHEN SERIOUS PROBLEM START. PLEASE LOOK INTO THIS CASE FOR SOME SECOND OWNER OF BMW THAT BMWNA TRYING TO IGNORE. THANK YOU [XXX] *TR
Tires, May 17, 2010
THE FRONT OE TIRES ON MY 2008 BMW HAVE DEVELOPED SIDEWALL BUBBLES. THE TIRES ARE BRIDGESTONE POTENZA RE050A, 225/40 R18. THIS IS INHERENTLY DANGEROUS. THERE ARE ALREADY SOME BRIDGESTONES WHICH THE COMPANY HAS RECOGNIZED AS FAULTY, THE ABOVE MODELS SHOULD BE ADDED TO THEIR LIST. *TR
Electrical system, Latches/locks/linkages, May 11, 2010
2008 BMW 328I. CONSUMER STATES WHEN POWER IS LOST TO THE DOORS, FOR ANY REASON, THE PASSENGER DOORS REMAIN LOCKED WITH NO WAY TO OPEN THEM FROM THE INSIDE OR THE OUTSIDE OF THE VEHICLE *TGW THE DRIVER'S SIDE DOOR OPENED FROM THE INSIDE WHEN THE HANDLE WAS PULLED. *JB
Fuel system, Gasoline, May 10, 2010
MY 2008 BMW 335I ONLY HAD AROUND 28,000 MILES WHEN I BEGAN NOTICING IT TOOK AN INORDINATE AMOUNT OF TIME TO START THE ENGINE. IT WOULD CRANK FOR SEVERAL SECONDS BEFORE THE ENGINE FINALLY STARTED, ESPECIALLY IF IT WAS A COLD START. ONCE THE ENGINE WAS WARMED UP IT SEEMED TO RUN JUST FINE. IT HAS NOW BEEN IN THE SHOP 4 TIMES SINCE JAN 2010 AND I'M SICK OF IT! AM TERRIFIED ABOUT THE CAR STOPPING ON THE INTERSTATE, AMID TRAFFIC, LIKE HAS BEEN DESCRIBED IN VARIOUS OTHER POSTS! *TR
Latches/locks/linkages, May 4, 2010
2008 BMW, ELECTRONIC DOOR LOCKS STUCK IN LOCKED POSITION, MUST OPEN DRIVER SIDE DOOR WITH VALET KEY. REMAINING DOORS STUCK IN LOCKED POSITION, MAKING IT IMPOSSIBLE FOR PASSENGERS TO LEAVE VEHICLE IN AN EMERGENCY SITUATION. RELATED PROBLEM IS THAT GAS CAP (WHICH LOCKS WHEN DOORS ARE LOCKED) WILL ALSO NOT OPEN. *TR
Tires, Apr 27, 2010
SIDEWALL SEPARATION (RIGHT FRONT) ON BRIDGESTONE SIZE 225/40R18 REO50A ORIGINAL EQUIPMENT RUN FLAT TIRE AT 20,000 MILES. THESE TIRES SEEM PRONE TO DELAMINATION. VERY POOR TREAD MILEAGE FOR HIGHWAY DRIVING. WORN OUT NOW. UTQG RATING SEEMS EXAGGERATED AS I'M NOT IN STOP-AND-GO DRIVING MODE. THESE TIRES ARE PRICED $70+ TO $90+ PER TIRE MORE THAN NON-RF TIRES AND B'STONE HAS A VIRTUAL MONOPOLY....BMW N.A. ONLY PERMITS REPLACEMENT OF THESE TIRES AND IT REALLY HITS THE POCKET BOOK. CONTACTED B'STONE CONSUMER RELATIONS AND MET A BRICK WALL AS THEY KNOW THEY HAVE YOU OVER A BARREL. WROTE THE PRES. OF BRIDGESTONE AND NOT EVEN THE COURTESY OF A RESPONSE. *TR
Structure, Mar 18, 2010
I HAVE A 2008 BMW 335I (E90) THAT LOST BOTH HEADLIGHT WASHER COVERS WHILE TRAVELING ON THE HIGHWAY. THESE PARTS STRUCK THE WINDSHIELD WITH GREAT FORCE AND LIKELY HIT THE VEHICLES TRAVELING BEHIND MY CAR. THESE PARTS LIKELY LITTERED THE ROADWAY WITH DEBRIS THAT COULD CAUSE OTHER VEHICLES TO SWERVE TO AVOID RUNNING OVER THEM. THIS IS A COMMON PROBLEM/DEFECT WITH NEWER BMW VEHICLE (SEE BMWLAND AND E90POST WEBSITES FOR CUSTOMER COMPLAINTS). *TR
Latches/locks/linkages, Mar 18, 2010
HTTPS://WWW-ODI.NHTSA.DOT.GOV/IVOQ/COMPLAINT.CFM. *TR
Fuel system, Gasoline, Electrical system, Mar 7, 2010, fire
THREE FUEL PUMP FAILURES, BMW FACTORY REP LOOKED AT CAR AT BMW CLEVELAND, IN SOLON, OHIO. ONE WEEK LATER CAR CAUGHT ON FIRE WHILE SITTING IN PARKING LOT AT WORK. *TR
Engine and engine cooling, Fuel system, Gasoline, Power train, Mar 4, 2010
TL*THE CONTACT OWNS A 2008 BMW 335XI. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH; PROCEEDING TO A TRAFFIC SIGNAL. THE TRANSMISSION EXHIBITED A JERKING MOTION. THE VEHICLE CONTINUED IN OPERATION. IN ADDITION, THE FUEL PUMP FAILED ON SEVERAL OCCASIONS. THE TURBO CHARGER AND BANOS SYSTEM FAILED TO OPERATE PROPERLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE VEHICLE WAS REPAIRED UNDER THE SERVICE WARRANTY. THE DRIVER OBSERVED AFTER THE VEHICLE SERVICE REPAIR; SMOKE WAS COMING FROM THE TAIL PIPE AND OIL WAS LEAKING. THE FAILURE MILEAGE WAS 50. THE CURRENT MILEAGE WAS 34,000. THE VIN WAS UNAVAILABLE.
Service brakes, Hydraulic, Mar 1, 2010
THE BRAKE SYSTEM SEEMS TO HAVE LOST ITS THREE PRESS BOOST. AFTER ABOUT 2 YEARS, UPON STARTING THE CAR (2008 BMW 335XI AUTO) THE PRESS ON THE BRAKE IS STIFF. IT IS STIFF BECAUSEIT SEEMS TO HAVE LOSS THE 3 PRESS BOOST. THE BOOST THAT IS SUPPOSED TO PROTECT THE DRIVER IN CASE OF ENGINE FAILURE. NO OTHER CARE I HAVE OWNED LEAKS OUT ITS BOOST OVERNIGHT. BMW ADMITTED THAT THE BRAKE CHECK VALVE WAS BAD AND REPLACED IT WITH A NEWLY DESIGNED PART. I ASKED WHAT THIS NEW DESIGN WAS AND THEY COULD NOT TELL ME. I READ ONLINE THAT MANY PEOPLE HAVE HAD THIS ISSUE WHICH STARTS WITH A STIFF BRAKE PEDAL THEN IT DEGRADES INTO THE SYSTEM NOT BEING ABLE TO START THE CAR. BMW TO THEIR CREDIT IMMEDIATELY FOUND ANOTHER PART AND LOANED ME A CAR IN THE MEANTIME. THE LOANED CAR HOWEVER DID NOT SHOW THIS STIFF PEDAL ISSUE. THE NEW PART THEY PUT IN AFTER ABOUT 1 MONTH STARTED TO LOSE BOOST IN THE MORNINGS OFF AND ON. I BROUGHT IT IN AND THEY SAID THIS IS NORMAL? I"M WORRIED THAT IF I LOSE ENGINE FUNCTION GOING DOWN A HILL SOMEWHERE THAT THEY THREE PRESS BOOST WON'T BE THEIR FOR ME IF WE ALLOW IT TO GET WORSE. SUFFICE TO SAY, ONCE THE ENGINE STARTS YOU GET THE NORMAL POWER ASSISTED BRAKING; HOWEVER, THIS DOES NOT ADDRESS THE ENGINE OFF THREE BRAKE PRESS SAFETY REQUIREMENT. *TR
Engine and engine cooling, Feb 24, 2010
ON THREE OCCASIONS SINCE I PURCHASED THIS VEHICLE NEW, WHILE DRIVING AND ACCELERATING THE ENGINE CUTS OUT AND RPM'S SUDDENLY DROP. THE DATE REFERENCED BELOW WAS THE FIRST TIME THIS HAPPENED. THIS HAS HAPPENED TWICE SINCE THEN. I HAVE TAKEN THE VEHICLE IN ALL THREE TIMES. THEY CHANGED SOME PARTS, BUT THIS CONTINUES TO HAPPEN. AT ONE TIME, I WAS TRY TO GET THROUGH AN INTERSECTION WITH ONCOMING TRAFFIC, ALTHOUGH THERE WAS NOT AN ACCIDENT, IT WAS SCARY. ANOTHER TIME WAS CHANGING LANES ON A HIGHWAY. THIS SEEMS TO BE INTERMITTENT PROBLEM. *TR
Fuel system, Gasoline, Feb 10, 2010
MY CAR HAS ALREADY FAILED TWICE WITH THE SAME PROBLEM, I.E., FAILURE OF HIGH PRESSURE FUEL PUMP (HPFP). THE PROBLEM OCCURRED TWICE WITHIN A YEAR FROM THE TIME OF PURCHASE. IT APPEARED THAT BMW HAVE NO FIX TO THE ISSUE YET. CONCERNED THAT THIS PROBLEM IS SERIOUS AND LEAD TO SERIOUS PROBLEMS RELATED TO SAFETY. TWO HPFP'S WERE REPLACED BY THE BMW DEALER AND THERE IS NO GUARANTEE THAT LATEST PART WILL FIX THE ISSUE PERMANENTLY. *TR
Fuel system, Gasoline, Feb 3, 2010
ENGINE SUDDENLY SHUT OFF, LOST POWER STEERING ON FREEWAY WHILE GOING 65MPH. WAS ABLE TO SAFELY ROLL TO THE NEXT EXIT. DEALERSHIP FOUND DEFECTIVE HIGH PRESSURE FUEL PUMP. *TR
Fuel system, Gasoline, Feb 2, 2010
MULTIPLE HIGH PRESSURE FUEL PUMP(HPFP) FAILURES. WHILE DRIVING DOWN A BUSY AVENUE THE ENGINE UNEXPECTEDLY SHUTS DOWN DUE TO THE HPFP FAILING. THIS WAS AFTER THE CAR HAD MADE 2 PREVIOUS VISITS TO THE DEALERSHIP TO REPAIR HPFP PROBLEMS. CURRENTLY I AM NOW ON MY 3RD HPFP IN 2MONTHS. UNSAFE CAR TO DRIVE, ESPECIALLY IF THIS WAS TO OCCUR AT HIGH SPEEDS ON A HIGHWAY. BMW HAS BEEN HAVING ISSUES FOR THIS PROBLEM SINCE MODEL YEAR 2007 UP UNTIL 2010, WITH NO PRODUCT CHANGES OTHER THAN SIMPLE REPLACEMENTS. HPFP SHOWS SIGNS OF PROBLEMS WHEN STARTING THE CAR, DUE TO LONG CRANKS, UNSTABLE RPM'S AND ENGINE SHUTTERING. *TR
Fuel system, Other, Jan 28, 2010
THIS IS THE SECOND FAILURE OF THE HPFP IN MY 2008 BMW 335I. IT OCCURRED WHEN I LEFT WORK AND STARTED CAR AND THE CAR SHUDDERED AND THE INDICATOR SHOWED THAT THE CAR WENT INTO LIMP MODE (REDUCED POWER). DROVE THE CAR TO MY CHILD'S PRESCHOOL AND TURNED OFF THE CAR. STARTED THE CAR AND AGAIN THE CAR WENT INTO LIMP MODE. DECIDED TO TAKE THE CAR DIRECTLY TO THE DEALERSHIP AND THE CAR STALLED THREE TIMES ON THE WAY. TWO OF THE STALLS WERE WHILE THE CAR WAS MOVING. THE HPFP WAS REPLACED UNDER WARRANTY THE NEXT DAY.*CW
Fuel system, Other, Jan 20, 2010
MY BMW 335XI HAS REPEATEDLY HAD FUEL PUMP ISSUES. THE ENGINE WILL MALFUNCTION WHEN I AM IN THE MIDDLE OF THE ROAD (OFTEN TIMES IN THE MIDDLE OF THE HIGHWAY). THIS IS NOT ONLY A POTENTIAL SAFETY ISSUE FOR MYSELF, BUT FOR OTHERS ON THE ROAD AS WELL. THIS FUEL PUMP FAILURE ISSUE PREVENTS MY CAR FROM MOVING, WHICH CAN POTENTIALLY LEAD TO SOMEONE'S DEATH, ESPECIALLY ON THE HIGHWAY. PLEASE FORCE BMW TO RECALL THIS FUEL PUMP ASAP. *TR
Fuel system, Other, Jan 17, 2010
2008 BMW 335XI HIGH PRESSURE FUEL PUMP FAILURE. DEALER REPLACED. FAILED IN TRAFFIC AND WENT INTO LIMP MODE. *TR
Fuel system, Gasoline, Jan 12, 2010
MY BMW 335I ONLY HAD A FEW THOUSAND MILES WHEN I BEGAN NOTICING IT TOOK AN INORDINATE AMOUNT OF TIME TO START THE ENGINE. IT WOULD CRANK FOR SEVERAL SECONDS BEFORE THE ENGINE FINALLY STARTED, ESPECIALLY IF IT WAS A COLD START. ONCE THE ENGINE WAS WARMED UP IT SEEMED TO RUN JUST FINE. THEN AFTER A FEW DAYS THE "SERVICE ENGINE" LIGHT AND EXCLAMATION POINT WERE LIGHT UP ON MY DASHBOARD. I TOOK IT TO THE DEALER AND THEY EXPLAINED BMW WAS AWARE OF THE PROBLEM WITH THE FUEL PUMP AND FUEL INJECTION SYSTEM AND THEY WOULD TAKE PROPER STEPS TO ENSURE THE PROBLEM WAS FIXED. TO MY KNOWLEDGE THEY CHANGED THE FUEL PUMP AND WHATEVER OTHER SEALS NEEDED TO BE CHANGED. CAR SEEMED TO WORK JUST FINE FOR ABOUT 6 WEEKS, NOW THE PROBLEM HAS RETURNED. THE VEHICLE NOW HAS TO CRANK FOR AN INORDINATE AMOUNT OF TIME AGAIN IN ORDER TO GET THE CAR TO START. I AM CONCERNED THIS WILL NOT BE PROPERLY FIXED AGAIN. THE CAR IS NOT YET AT 10K MILES AND I AM HAVING TO BRING IT IN TO BE FIXED FOR A SECOND TIME. THIS IS VERY DISCONCERTING. **PLEASE NOTE, THE SYSTEM WOULD NOT ALLOW THE 335I AS AN OPTION FOR THE 2009 YEAR, ONLY WHEN I CHOSE THE YEAR AS 2008, PLEASE NOTE HOWEVER THAT THIS IS A 2009 BMW NOT A 2008** *TR
Fuel system, Gasoline, Jan 5, 2010
MY CAR'S HIGH PRESSURE FUEL PUMP FAILED WHILE I WAS DRIVING ON THE HIGHWAY IN SOUTHERN CALIFORNIA. I WAS ACCELERATING TO PASS ANOTHER CAR, THE CAR STUTTERED, AND THE "CHECK ENGINE LIGHT" WENT ON. AFTER THIS OCCURRED, THE CAR COULD BARELY ACCELERATE. IT WAS THE WEEKEND, SO I HAD TO CONTINUE DRIVING TO MY DESTINATION, AS THERE WERE NO BMW DEALERSHIPS OPEN TO REPAIR THE PROBLEM. THE LOSS OF ACCELERATION MADE IT VERY DIFFICULT, AND POTENTIALLY DANGEROUS, WHEN GETTING ONTO THE FREEWAY. ALSO, HAD THE CAR GIVEN OUT COMPLETELY, IT LIKELY WOULD HAVE CAUSED AN ACCIDENT. THE PROBLEM WAS REPAIRED THE NEXT WORK DAY (12/28/2009). ACCORDING TO THE SERVICE INVOICE PROVIDED BY THE BMW DEALERSHIP, THE PROBLEM WAS A "FAULTY HIGH PRESSURE FUEL PUMP." THE FAULTY HPFP WAS REPLACED. *TR