2007 Chevrolet Equinox
Problems, recalls and owner-reported issues
Fuel/propulsion system is the leading concern among 685 owner complaints filed for this model year. This is the 6th highest complaint count among 21 Equinox model years with reports.
Of the 2007 reports, 11 involved a crash and 6 involved a fire. 17 people were injured.
What owners report most often
Recalls and investigations
Fuel system, gasoline, delivery, fuel pumpSep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Fuel leakage in the presence of an ignition source may result in a fire.
GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Campaign 12V459000 on NHTSA.gov
Air bagsNov 7, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIRBAGS OR OPTIONAL SUNROOF FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201,"OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING NHTSA IMPACT TESTS, THE INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD REQUIREMENTS.
THE RESULTS OF THIS TEST INDICATED A POSSIBILITY OF AN INCREASED RISK OF HEAD INJURY IN A CRASH.
DEALERS WILL INSTALL AN ENERGY ABSORBING FOAM PIECE TO EACH OF THE A-PILLAR TRIM ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON MAY 8, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.
Campaign 07V520000 on NHTSA.gov
Air bags, frontal, sensor/control module-inactiveAug 7, 2007
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." IN THESE VEHICLES, THE RIGHT FRONT PASSENGER SEAT IS BUILT WITH A PASSENGER SENSING SYSTEM. WHEN TESTED WITH A REPRESENTATIVE UNRESTRAINED SMALL ADULT, THE SYSTEM IS REQUIRED TO TURN THE RIGHT FRONT PASSENGER'S FRONTAL AIRBAG ON. AN ERROR IN THE SEAT SENSOR CALIBRATION CAN CAUSE IT TO FAIL THIS TEST. IN ADDITION, THIS CONDITION CAN PREVENT THE AIRBAG FROM TURNING OFF WHEN THE SEAT IS OCCUPIED BY A SMALL CHILD.
WHENEVER THE FRONT PASSENGER SEAT IS OCCUPIED, THE DRIVER SHOULD ALWAYS CHECK THE AIRBAG INDICATOR TO SEE IF THE AIRBAG IS ON OR OFF. IF IT IS NOT CORRECT FOR THE SITUATION, THE PASSENGER SHOULD BE MOVED TO A DIFFERENT SEAT. THIS CAN INCREASE THE RISK OF INJURY TO A SEAT OCCUPANT DURING CERTAIN CRASH CONDITIONS.
DEALERS WILL REPROGRAM THE SEAT'S ELECTRONIC CONTROL UNIT. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.
Campaign 07V344000 on NHTSA.gov
Visibility, windshieldJun 13, 2007
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." AN INCORRECT PRIMER MAY HAVE BEEN USED WHEN INSTALLING THE WINDSHIELD. THE SAME PRIMER MAY HAVE ALSO BEEN APPLIED TO THE LIFTGATE GLASS AND THE SIDE STATIONARY GLASS.
IN THE EVENT OF A CRASH, THE WINDSHIELD MAY NOT BE RETAINED TO THE EXTENT REQUIRED BY THE STANDARD, INCREASING THE RISK OF PERSONAL INJURIES TO THE VEHICLE OCCUPANTS.
DEALERS WILL REPLACE THE WINDSHIELD, THE LIFTGATE GLASS, AND THE SIDE STATIONARY GLASS. THE RECALL BEGAN ON JUNE 14, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.
Campaign 07V242000 on NHTSA.gov
Representative owner complaints: gasoline
90 reports, newest first. Show all
Fuel system, Gasoline, Aug 12, 2011
MY MOTHER INLAW AND WIFE HAVE A 2007 EQUINOX WITH 59 THOUSAND MILES ON IT SMELT GAS FUMES FOR A WHILE NOW IT IS POURING GAS FROM TOP OF GAS TANK CAN NOT DRIVE SHE IS 75 YEARS OLD HAVE TO TAKE HER EVERY WHERE IN BORED CAR .CAN NOT AFFORD TO HAVE IT FIXED *TR
Fuel system, Gasoline, Jul 18, 2011
I HAVE A 2007 CHEVY EQUINOX AND I SMELL GAS FUMES BUT THERE IS NO LEAK. I STARTED SMELLING THE SMELL OF GAS OVER A MONTH AGO. AFTER DRIVING THE FUMES ARE REALLY STRONG. THERE ARE NO VISIBLE LEAKS JUST THE SMELL OF GAS. THE SMELL IS ON THE RIGHT SIDE WERE THE GAS CAP IS. I CHECKED THE GAS CAP AND IT IS CLOSED PROPERLY. I TOOK THE VEHICLE TO A MECHANIC AND AFTER DIAGNOSING WITH A SMOKE MACHINE HE FOUND THE LEAK TO BE COMING OUT OF THE PRESSURE RELIEF HOSE BEHIND THE REAR TIRE WALL ON THE PASSENGER SIDE. HE REPLACED THE VAPOR CANISTER ($98.59 + TAX & LABOR) THAT IS SUPPOSE TO PREVENT ANY PRESSURIZED GAS VAPORS TO RECYCLE BACK INTO THE GAS TANK. THE SMELL IS STILL THERE! ANY ADVICE WOULD BE HELPFUL. *KB
Fuel system, Gasoline, Jul 15, 2011
ON THURSDAY 14 JUNE 2011 I THOUGHT I HAD SMELL GAS IN MY TRUCK. HAD MY HUSBAND TO LAY DOWN AN LOOK UNDER THE TRUCK AND HE SAID IT WAS WET. THE FUMES OF GAS IS GETTING STRONGER BY THE DAY. I REALLY GETTING AFRAID TO DRIVE MY TRUCK THAT BI REALLY ENJOY DRIVING. IT SEEM THAT THIS HAS HAPPEN TO OTHER. IS THERE NOT BEEN A RECALL ON THIS PROBLEM BECAUSE FOR THAT JUST TO HAPPEN ALL OF A SUDDEN IS STRANGE AND DANGEROUS I THINK. WHAT CAN YOU TELL ME THAT MIGHT HELP. *TT
Fuel system, Gasoline, Jul 15, 2011
2007 CHEVROLET EQUINOX LT, NOTICED RAW GAS SMELL COMING FROM RIGHT REAR OF VEHICLE. TOOK TO REPAIR SHOP AND WAS ADVISED THAT THE PLASTIC GAS TANK HAD A CRACK IN IT WHERE THE NECK GOES INTO THE TANK. UPON CHECKING ONLINE I SEE OTHER PEOPLE HAVING SAME PROBLEM. CONTACTED CHEVROLET SERVICE AND GOT NO WHERE. HAD REPAIR SHOP REPLACE TANK WITH NEW TANK. WITH NUMEROUS COMPLAINTS SEEN ON SAME PROBLEM IT SEEMS LIKE THERE IS A PROBLEM WITH TANK. ALSO IS A SAFETY RISK WITH GAS LEAKING OUT OF SIDE OF TANK FOR POSSIBLE FIRE
Fuel system, Gasoline, Jun 27, 2011
APROX 2 WEEKS AGO I STARTED SMELLING GAS COMING FROM THE BACK PASSENGER SIDE OF THE VEHICLE. SMELL HAS PROGRESSIVELY GOTTEN WORSE OVER THE LAST 2 WEEKS. TOOK THE VEHICLE TO A CHEVY DEALERSHIP ON 6/27/2011 AND THEY HAVE STATED THAT THEY WOULD NEED TO DROP THE FUEL TANK TO DETERMINE THE EXACT ISSUE WHICH IS ONE OF 3. ONE BEING THE CIRCLE RING ON TOP OF THE TANK, A FUEL MODULE, OR A CRACK IN THE GAS TANK. THEY EXAMINED THE ENTIRE VEHICLE AND THERE IS NOTHING THAT WOULD HAVE CAUSED ANY OF THESE ITEMS TO GO WRONG. I HAVE GOOGLED AND SEEN WHERE THERE ARE SEVERAL CONSUMERS THAT HAVE HAD THE SAME ISSUES WITH THEIR 2007 EQUINOX'S. I ASKED THE DEALERSHIP IF THERE IS A BIG RISK IN DRIVING THE VEHICLE LIKE IT IS. THEIR ANSWER WAS THAT ANYTIME GAS FUMES ARE PRESENT IT PRESENTS RISKS. EVERY NIGHT WHEN PARKING THE VEHICLE IN THE GARAGE, THE NEXT MORNING THE GAS FUMES ARE TREMONDOUSLY CONCENTRATED (THIS IS WITH ALL THE GARAGE WINDOWS OPEN TO VENT THE GARAGE). AS OF 6/27/2011, THERE HAS BEEN NO REPAIRS DONE ON THE VEHICLE. I FEEL WITH THE SEVERAL COMPLIANTS THAT I HAVE SEEN FOR THIS ISSUE, THIS THIS SHOULD A SAFETY RECALL IN WHICH CHEVY NEEDS TO CORRECT. *TR
Fuel system, Gasoline, Jun 17, 2011
MY MARRIED DAUGHTER(3 SMALL KIDS) RECENTLY STARTED SMELLING GAS AT THE RIGHT REAR OF HER 2007 EQUINOX(74,000 MI). INSPECTION BY LOCAL DEALER REVEALED GAS TANK SEAM NEAR PUMP/SENDING UNIT ASSEMBLY SEPARATED & LEAKING. VEHICLE IS STILL WITHIN POWER TRAIN AND EMISSIONS WARRANTIES BUT GM IS ONLY WILLING TO COVER COST OF NEW TANK(NOT OFFICIALLY UNDER EITHER WARRANTY, JUST AS A "GOOD WILL" GESTURE) LEAVING $500.00 IN LABOR FOR HER TO PAY. PER NHTSA WEBSITE, THERE HAVE BEEN MULTIPLE INSTANCES OF THIS PROBLEM WHICH COULD ONLY BE DESCRIBED AS A COMPONENT FAILURE / MANUFACTURING DEFECT. GIVEN THE POTENTIAL FOR A FIRE AND/OR EXPLOSION, GM SHOULD VIEW THIS AS A POTENTIAL P/R NIGHTMARE AND DO WHATEVER IS NECESSARY TO RECTIFY THE SITUATION(TO INCLUDE A LOANER VEHICLE). LOCAL DEALER HAS BEEN VERY HELPFUL BUT IT'S GM'S PLACE TO DO THE RIGHT THING RATHER THAN TAKING 'PARTIAL RESPONSIBILITY'. TWO OR MORE SIMILAR PROBLEMS REPORTED TO NHTSA HAVE BEEN COVERED UNDER WARRANTY. COMPARED TO THE COST OF A RECALL(OR GOD FORBID, A FIRE), REPAIRING EACH OF THESE AS THEY HAPPEN WITHOUT HESITATION WOULD BE AN INSIGNIFICANT EXPENSE FOR THE MANUFACTURER(AND VERY GOOD LEGAL ADVICE, I MIGHT ADD....) UPDATED 07/20/11 *BF THE CONSUMER STATED UPON FURTHER INSPECTION AT ANOTHER DEALERSHIP, IT WAS IN FACT DISCOVERED THAT THE FUEL PRESSURE LINE AT THE SENDING UNIT WAS CRACKED AND LEAKING. THE PROBLEM WAS CORRECTED AND ALL PARTS AND LABOR WERE COVERED UNDER WARRANTY. UPDATED 08/02/11*JB *TR
Fuel system, Gasoline, May 10, 2011
I HAVE A PROBLEM WITH MY 2007 CHEVY EQUINOX SMELLING LIKE GAS INSIDE AND OUTSIDE ON THE PASSENGER SIDE OF THE VEHICLE, NO NOTICEABLE DAMAGE TO THE VEHICLE, I TOOK IT IN FOR A RECALL ON THE AIRBAG SENSORS AND THE DEALER NOTED THE SMELL OF GAS, I HAVE NO WARRANTY AND CANNOT AFFORD TO TAKE IT TO A DEALER SOUNDS LIKE THIS IS A DEFECT THAT SHOULD BE COVERED BY GMC. IS GM GOING TO WAIT UNTIL SOMEONE'S EQUINOX GOES UP IN FLAMES FOR THEM TO ADMIT IT IS A DEFECT. AND THEY CALLED ME TO TRADE IT IN FOR ANOTHER ONE, NOT. *TR
Fuel system, Gasoline, Mar 1, 2011
STARTED SMELLING GASOLINE AFTER LEAVING MY 2007 CHEVY EQUINOX PARKED FOR A LONG PERIOD OF TIME. THEN MY EQUINOX HAD DIFFICULTY STARTING AFTER BEING PARKED OVERNIGHT. TOOK IT INTO THE DEALER, AND THEY FOUND A CRACKED FUEL TANK AND A LEAK IN THE FUEL PUMP. THE COST FOR THE FUEL TANKS WAS $1,000, BUT THE DEALER WAS ABLE TO APPLY A ONE-TIME GM SAFETY FIX, WHERE I ONLY PAID $200 AND GM COVERED THE REST. THE LEAK IN THE FUEL PUMP WAS COVERED BY THE WARRANTY. *TR
Fuel system, Gasoline, Feb 21, 2011
THERE IS AN OVERWHELMING SMELL OF GASOLINE INSIDE THE VEHICLE. PRIOR TO TAKING THE VEHICLE INTO THE SHOP YOU WOULD HAVE TO TURN THE KEY OVER A COUPLE TIMES TO PRIME THE LINE BEFORE IT WOULD START. I WAS TOLD THERE IS A GAS LEAK DUE TO FAULTY FUEL LINES. GM DOES NOT MAKE THE REPLACEMENT LINES SEPARATELY SO THE ENTIRE FUEL PUMP MOST BE REPLACED. THIS IS A HUGE SAFETY ISSUE AND A MANUFACTURING DEFECT I SHOULD NOT HAVE TO PAY FOR, UNFORTUNATELY THERE IS NO RECALL SO I WILL BE PAYING FOR IT OUT OF POCKET. *TR
Fuel system, Gasoline, Dec 13, 2010
2007 EQUINOX WITH 69,000 MILES HAD A GAS SMELL OUTSIDE AS WELL AS IN THE CABIN. TOOK IT RIGHT TO THE DEALER ON A FRIDAY AFTERNOON. THE SERVICE SUPERVISOR PUT IT ON THE LIFT AND SAID I HAD A GAS LEAK AND COULD NOT DRIVE THE VEHICLE. INDICATED IT WAS MOST LIKELY THE FUEL PRESSURE MODULATOR. ESTIMATED THE COST OF REPAIR WOULD BE ABOUT $650 PLUS LABOR. I CALLED BACK THAT MONDAY EVENING TO INQUIRE IF THE LEAK HAD BEEN PINPOINTED. GOOD NEWS!!! THE PART WOULD TAKE A COUPLE OF DAYS TO GET IN BUT IT WOULD BE COVERED UNDER THE WARRANTY!!! SAVED ME BETWEEN $1200 - $1500. CHEVY DEALER IN ENTERPRISE, AL IS THE GREATEST! DON'T KNOW WHY SO MANY OTHERS WITH THE SAME TYPE PROBLEM ARE TURNED AWAY BY THE DEALER. *TR
Fuel system, Gasoline, Dec 2, 2010
TL*THE CONTACT OWNS A 2007 CHEVROLET EQUINOX. THE CONTACT SMELLED GASOLINE AND NOTICED THAT THERE WAS A GASOLINE LEAK. THE DEALER WAS CONTACTED, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT DID NOT INFORM THE MANUFACTURER OF THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 58,000.
Fuel system, Gasoline, Nov 26, 2010
2007 CHEVY EQUINOX GAS LEAK. NOTICED INCREASED SMELL OF GAS. PREVIOUS TO THIS I HAD A LONGER THEN NORMAL STARTING PROBLEM, WINDS OUT THEN STARTS. I WAS TOLD TO LEAVE THE KEY IN START POSITION TO BUILD UP PRESSURE IN THE GAS LINES. I BROUGHT IT TO THE DEALER AND THEY DID NOT WANT TO WARRANTY THE DEFECT. I ASKED FOR A QUOTE AND SAID IT WAS UPWARD OF $1,500. THIS IS AFTER HAVING TO PAY $93 DOLLARS FOR TELLING ME I HAD A GAS LEAK I KNOW I ALREADY HAD. TO MY OWN TROUBLESHOOTING I FOUND THAT THE FITTING THAT ATTACHES THE HIGH PRESSURE GAS LINE TO THE GAS PUMP MANIFOLD APPEARS TO BE A PLASTIC TO PLASTIC COMPRESSION FITTING. IT IS HIGHLY LIKELY THAT AFTER CONSTANT VIBRATION THESE TWO PLASTIC PARTS CAN CREATE A GAP FOR GAS TO ESCAPE IN LARGE QUANTITY. THUS THE CONSTANT GAS SMELL. WITH THE KEY IN THE START POSITION NOTICEABLE GAS CAN BE SEEN DISPENSING ONTO THE FLOOR. A MANUFACTURE DEFECT IN MY EYES. I HAVE NO CHOICE BUT TO FIX IT MYSELF WITH GM PARTS AT A HIGH COST OF & 600.00 DOLLARS, A GAS PUMP ASSEMBLY NOT OTHERWISE FOUND ELSEWHERE. WITH THE ANTICIPATION OF THE NEW PART HAVING THE SAME DEFECT. *TR
Fuel system, Gasoline, Nov 13, 2010
I HAVE CHEVY EQUINOX 2007 WHICH HAVE PROBLEM IN THE STEERING(NOISE) WHICH THE DEALER COULDN'T FIX & THERE WAS SOME PROBLEM WITH OIL TANK WHICH SMELLS SO BAD WORRIES ME AS I DRIVE THIS TRUCK WITH MY 9 MTH OLD BABY WAS FIXED FORTUNATELY. *TR
Fuel system, Gasoline, Oct 4, 2010
NOTICED STRONG SMELL OF GASOLINE AFTER DRIVING. THE SMELL LINGERED FOR SEVERAL HOURS AFTER THE VEHICLE WAS PARKED. BROUGHT TO THE DEALER AND WAS TOLD THAT THERE WAS A FUEL LEAK. ALSO FUEL SENSOR INDICATED GAS TANK WAS 1/2 FULL, BUT DEALER STATED TANK WAS FULL. VEHICLE HAS 67000 MILES ON IT. DEALER IS REPLACING THE FUEL PUMP AND FUEL SENSOR UNDER THE POWERTRAIN WARRANTY. NO INJURIES OR DAMAGE RESULTED FROM THIS, BUT I CONSIDER THIS TO BE A SERIOUS HAZARD AS LEAKING FUEL/FUMES COULD HAVE SPARKED AN EXPLOSION. AFTER RESEARCHING THIS ISSUE, IT APPEARS OTHER OWNERS HAVE HAD SIMILAR COMPLAINTS. *TR
Fuel system, Gasoline, Mar 26, 2010
I DISCOVERED A SMELL OF FUEL FROM MY VEHICLE. HAD VEHICLE INSPECTED ON 3/25/10 AND FOUND OUT THAT THE FUEL TANK IS LEAKING DUE TO FAULTY MANUFACTURING. THE VEHICLE IS A 2007 CHEVY EQUINOX LT. IT IS JUST BEYOND WARRANTY AND NO EXTENDED WARRANTY WAS PURCHASED. THE FUEL LEAK IS BENEATH THE REAR PASSENGER SEAT. THERE IS NO WEAR AND TEAR TO THIS AREA OF THE VEHICLE. THERE IS NO DAMAGE TO THIS AREA OF THE VEHICLE. THIS VEHICLE HAS NOT BEEN IN A COLLISION. THE LEAK IS DUE TO POOR MANUFACTURING OF THIS PART. THERE HAS NOT BEEN ANY INJURY OR FIRE YET. BUT THE POTENTIAL EXISTS.