2020 Chevrolet Equinox
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 308 owner complaints filed for this model year. This is the 13th highest complaint count among 21 Equinox model years with reports.
Of the 2020 reports, 20 involved a crash and 7 involved a fire. 12 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Child seat, vehicle latch anchorMay 11, 2023
General Motors, LLC (GM) is recalling certain 2020-2023 Chevrolet Equinox and GMC Terrain vehicles. The four rear-seat lower child seat LATCH anchorage bars may have excessive powder coating, which could prevent a child seat from being installed with the anchorage bars. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child Restraint Anchorage Systems."
The inability to install a child seat with the LATCH anchorage bars could result in an unsecured child seat, increasing the risk of injury in a crash.
Owners are advised to install child seats using the vehicle's rear seat belts until the remedy is complete. Dealers will inspect the latch anchorage bars, and remove and replace the finish, as necessary, free of charge. Owner notification letters were mailed June 2, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N232403240.
Campaign 23V339000 on NHTSA.gov
Power train, automatic transmissionOct 29, 2020
General Motors LLC (GM) is recalling certain 2018-2019 Chevrolet Cruze and Buick LaCrosse, 2018-2020 Chevrolet Equinox, Chevrolet Traverse and GMC Terrain, 2018 Chevrolet Malibu, 2019-2020 Buick Encore, Buick Enclave, Cadillac XT4, Chevrolet Blazer and GMC Acadia, and 2020 Cadillac XT6 vehicles. The start/stop accumulator endcap may have missing bolts.
Missing bolts on the start-stop accumulator endcap could result in a transmission oil leak and may progress to a loss of propulsion, increasing the risk of a crash. A transmission fluid leak in the presence of an ignition source may increase the risk of fire.
GM will notify owners, and dealers will inspect the start-stop transmission accumulator and replace it if any bolts are missing, free of charge. The recall began December 15, 2020. Owners may contact GMC customer service at 1-888-988-7267, Buick Customer service at 1-866-608-8080, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N202313440.
Campaign 20V668000 on NHTSA.gov
Service brakes, hydraulic, foundation components, disc, caliperOct 3, 2019
General Motors LLC (GM) is recalling certain 2020 Chevrolet Equinox vehicles. The rear brake calipers may have been produced with an incorrect lubricant, potentially causing the rubber seals to swell and the brakes to drag.
Brake drag may result in overheating of the brake pads, affecting the braking ability and increasing the risk of a crash.
GM will notify owners, and dealers will replace the rear brake calipers, including the brake hose gasket, brake fluid and wheel to hub lubricant, free of charge. The recall began October 29, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438. GM's number for this recall is N192270920.
Campaign 19V704000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblySep 19, 2019
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Equinox all-wheel drive vehicles. The fuel tanks may have been manufactured with an improperly sealed seam, possibly allowing fuel to leak along the seam near the fuel inlet.
A fuel leak in the presence of the ignition source can increase the risk of a fire.
GM will notify owners, and dealers will replace the fuel tank, free of charge. The recall began October 24, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N192271870.
Campaign 19V667000 on NHTSA.gov
Representative owner complaints: service brakes
107 reports, newest first. Show all
Electrical system, Service brakes, Engine, Sep 10, 2026
While operating my vehicle, I experienced a sudden, catastrophic failure of the power-assisted braking system. The brake pedal completely lost hydraulic pressure, plunging effortlessly all the way to the floorboard. The vehicle failed to respond to normal foot-pedal application. Emergency stopping power was only achieved by pushing the pedal into the absolute floorboard, which engaged an emergency mechanical override and forced the Anti-lock Braking System (ABS) pump into a violent stutter/pulsation to halt the vehicle. No dashboard warning lights, diagnostic trouble codes (DTCs), or fluid level sensors illuminated prior to or during the braking failure. A certified automotive repair facility diagnosed the root cause as a total internal seizure and mechanical failure of the engine-driven brake booster vacuum pump. Because the vacuum pump is driven directly by the engine, its sudden lockup sheared and severely damaged the drive slots on the exhaust camshaft, necessitating an intensive engine teardown, camshaft replacement, and secondary component repair totaling $2,390. This design poses an extreme, life-threatening safety risk. The total loss of braking assist occurs without warning, and the mechanical failure simultaneously compromises internal engine timing components while moving at speed.
Service brakes, Hydraulic, Jul 27, 2026
The contact owns a 2020 Chevrolet Equinox. The contact stated that while driving 80 MPH, the message “Service Brake Assist” warning light illuminated twice. The contact stated that while attempting to depress the brake pedal, the vehicle failed to respond as needed, causing the contact to engage the parking brake and manually shift the gear shifter to a lower gear to get the vehicle to come to a complete stop. A dealer was contacted. The contact stated that the check engine warning light was illuminated. The contact stated that the failure had occurred twice. The vehicle was taken to the dealer, where it was diagnosed and determined that the brake booster pump needed to be replaced. The brake booster pump was replaced, and the vehicle was repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 94,000.
Service brakes, Engine, Jul 24, 2026
While driving, my 2020 Chevrolet Equinox suddenly lost power and shut off without warning while I was pulling into traffic. The vehicle would buzz not crank afterward but would not restart. This created a safety hazard because the unexpected engine shutdown occurred while the vehicle was in motion. This is the second brake vacuum pump failure I have experienced with this vehicle. In 2022, the brake vacuum pump failed and was found shattered internally. At that time, the engine continued running, and the pump was replaced. During this most recent incident, the brake vacuum pump failed again, and the internal end of the pump broke apart. I replaced the vacuum pump and removed the broken pieces I could access, but the vehicle remains in a crank/no-start condition. The vehicle has not yet been inspected by a dealership or independent repair facility. However, after seeing the shattered pump components, a couple of mechanics I know expressed concern that the broken pieces may have affected the engine timing. That has not been confirmed. The failed pump and replacement parts are available for inspection.
Service brakes, Jul 19, 2026
I was pulling into a parking lot off the state Thruway with the brake system failure no brakes, hard pedal, and the car would not stop
Service brakes, Jul 10, 2026
Brakes went stiff and hard to push no warning light. I was driving on the interstate with my daughter. Was stuck out of town with no breaks.
Service brakes, Engine, Jul 3, 2026
As I was coming to a stop at light my brakes became very difficult to push the pedal down to stop. It took everything in me to get the vehicle to stop before entering the intersection and oncoming traffic. I was able to get the vehicle parked safely in a nearby parking lot but then the engine wouldn't start it just kept trying to turn over. The brake assist error popped up, and then the check engine light came on. I was able to get it started again about 20 minutes later, all the same warnings and lights. I white knuckled the drive back to my house... Once I got home the engine was smoking, smelled like it was burning, and oil was spilling out all over the place underneath, impossible to see where a leak was as it was coming from the entire engine. There was ZERO warning with the vehicle, no issues up to this point, and suddenly the equinox is now useless in my driveway unable to start with oil still leaking in multiple spots. An oil pan under the main leaking area, but there are still multiple areas of oil spilling even a week later. Oddly enough my onstar report for the month came to email a few days later reporting perfect engine health and zero issues - even thought the vehicle can't start now.
Service brakes, Jul 2, 2026
The vacuum pump failed and my brakes went out pedal became extremely hard to push. I was driving on the highway at the time and was lucky I had a shoulder to slow down on and finally stop. I took the car to my usually mechanic who confirmed the vacuum pump failure but referred me to the Chevy dealer because this is a known issue. The dealer confirmed the pump had blown apart( their words to me) and that there are most likely debris now in the engine. No warning lights or alerts of any kind came on. Total suprise.
Service brakes, Hydraulic, Engine, Jul 2, 2026
The contact owns a 2020 Chevrolet Equinox. The contact stated that while driving approximately 5 MPH and approaching a stop sign, the brake pedal was depressed and there was a thumping sound coming from the brake pedal, with the message “Service Brake Assist” was displayed. The vehicle was taken to the residence and parked. The contact stated that the next day while driving approximately 63 MPH, the message "Reduced Engine Power" was displayed. The contact exited the highway, and while attempting to depress the brake pedal, the pedal was firm, and the vehicle failed to slow as intended. The contact continued to depress the brake pedal with force, and the check engine warning light was illuminated. The vehicle slowed down eventually. The vehicle was taken to an Auto Parts Store and a handheld diagnostic machine to diagnose the vehicle. The contact stated that the vehicle was turned off and failed to restart. The vehicle was restarted after three attempts. The vehicle was taken to the residence and the following day, the vehicle was towed to an independent mechanic where it was diagnosed and determined that the vacuum pump, camshaft, and timing belt needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 111,000.
Power train, Service brakes, Engine, Jun 30, 2026
December 2025 I was at a complete stop and the car clunked and the brake pedal got hard hard to push and then a couple months later a brake sensor light came on and when I plugged the code reader into it, it said give me a brake sensor code, and then it started slamming on the brakes all by itself when I went to takeoff hard like give you whiplash hard and it didn’t just do it once it did it a few times and then it wouldn’t go into reverse and then it wouldn’t go in neutral, and then it started smoking. My safety was affected by it, slamming on the brakes that could make someone hit me. It could hurt my back and neck. Yes, I have proof. Yes, I notified the dealer. Yes the vehicle has been inspected and I got an estimate by two different Car Lot the one I bought it from Ken valor motors, and Matt Mazzoni’s I have. Plus I have diagnose diagnostics printouts from OnStar and this is a 2020 vehicle. It should not be having these problems and now I’m stuck paying for a vehicle that I can’t even drive.!!
Service brakes, Jun 18, 2026
Brake vacuum, pump failed while driving which made the brakes not work. I had it towed to a dealer and they found that the pump was internally damaged. Pump was then replaced. There was no warning this was about to happen and it happened suddenly. One moment the car had brakes and the next there was no braking. A very dangerous situation and we were lucky to not have a major accident.
Service brakes, Hydraulic, Engine, Jun 17, 2026
The contact owns a 2020 Chevrolet Equinox. The contact stated the brake pedal became firm while driving approximately 40-45 MPH. The check engine warning light was illuminated, and the brake assist service message was displayed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic who determined that the brake housing had shattered inside the engine. The manufacturer was not notified of the failure. The failure mileage was approximately 213,000.
Service brakes, Jun 11, 2026
Brake vacuum pump failed at 112k miles while doing 60 on the highway with no warning or way to stop. Very dangerous. Service brake assist light only come on after the fact of brake pump failure. Shrapnel from the failed part was sent into the engine block that had to be professionally cleaned out. This happened again 4 months later when I had to replace the brake vacuum pump AGAIN. I almost wrecked and lost my life then as well since again, it happened out of nowhere while driving no warnings. Brake assist light only came on after. This is DEADLY and should be recalled and rectified by GM promptly before someone is killed.
Service brakes, Jun 1, 2026
I was driving at the speed about 30~ miles/per hour on the city road, as I was slowing down to turn into the Penera Bread where I plan to, and I pressure the break paddle, the break paddle was stocked, it cannot pressed down. It was extremely dangerous situation, I cannot stop the vehicle, and it was very scary. I finally switch the driving to 'P" to stop the vehicle, and route the vehicle to curb to force hard stop. This is extremely risky situation. My understanding is model year 2020 - 20xx Equinox has reported this problem by many consumers. Vehicle brake stocked while driving, I hope there is no injury or death occurs. This is extremely dangerous. My seatbelt pressed really hard on me, my chest hurts from this sudden hard stop, and I am so scared. A week after, I still cannot resume the driving due to the impact of the situation.
Service brakes, Engine, May 30, 2026
Multiple occasions of “engine reduced power” and vehicle stalling/jolting/jerking when trying to go over 45 mph. When trying to go to work Monday - on the interstate, it was jerking/jolting when trying to increase any speed and brakes were getting harder to press on, decided to try to reduce speed and get pulled over without the brakes, car was overheating completely. Now seeing multiple people have had this issue with the same car - I’m not sure whether it’s comforting that I’m not the only one or terrifying to know there’s multiple vehicles on the road experiencing this dangerous issue. Seeing a pending lawsuit did not surprise me one bit - I am not happy whatsoever about risking my own life and others on the roadway due to this not being a priority in the first place to correct before selling this vehicle to me, buying it with my hard earned money. Greedy greedy.
Service brakes, May 26, 2026
While driving, the vehicle experienced an almost total loss of braking capability. The pedal was very hard to press, and when pressing with all my weight, I could slow the vehicle to a stop, but it took a great distance. There was no warning or malfunction indicator until I pulled into a parking lot a few minutes later. At that point, a "Service Brake Assist" message appeared. Had I been in traffic, going faster, or in an area with pedestrian crossings, this could have caused a possibly deadly crash. I searched online and found that there is a vacuum pump that is known to fail on this vehicle, and can cause these symptoms. Upon replacing this vacuum pump, the issue was resolved. I still have the failed vacuum pump.
Service brakes, Hydraulic, May 19, 2026
The contact owns a 2020 Chevrolet Equinox. The contact stated that while driving at approximately 60 MPH, the vehicle's brakes did not depressed, it maintained the same speed the warning indicator stating service brake assist illuminated and then the check engine light illuminated. The emergency brakes were engaged in order to allow the vehicle to slow down. The vehicle was towed to the dealer where it was diagnosed with a vacuum pump for brakes failure. Additionally, metal was in the engine due to the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was
Other or unspecified, Service brakes, Engine, May 15, 2026
I was driving to work, when I got off the exit I stopped at Sheetz. When I got back in the car my brake pedal was stiff as a rock, and there was oil on the ground. A friend of mine does mechanic work so I called him and he said it sounds like the vacuum pump. I had the car towed to his garage, the tow costed me $400 which was very cheap considering where I was located. When I got it to the garage he confirmed that it was the vacuum pump and we removed several pieces of metal from inside the engine. I now have my car at the Chevy dealership in Chippewa PA. They told me to be $180 a diagnose it, well they just called me a little bit ago and said it's going to be another $900 to take everything apart and to truly diagnose it. I'm finding out now that GM has known about the failing vacuum pumps and they kept producing them anyways. I see there's a class action lawsuit taking place, and I am not very happy. My life was put at risk. And now I'm expected to be stuck paying this huge bill?
Steering, Power train, Service brakes, May 12, 2026
I am submitting this on behalf of my daughter, [XXX] . On Friday, May 8, 2026, [XXX] was traveling southbound on Highway 89A approaching [XXX] . Highway 89A is a narrow, winding two-lane canyon road with limited shoulder and significant elevation changes. While still on the canyon road, her 2020 Chevrolet Equinox suddenly lost all power, including power assist to both steering and brakes. A sudden loss of power steering and brake assist on this road presented a serious risk of loss of vehicle control. Fortunately, she was able to get the car stopped off of the roadway. However, she was then unable to place the car into Park or shut off the ignition. Multiple warning lights were illuminated across the instrument cluster. Her roadside assistance plan towed the car to the nearest repair facility, where on Monday, technicians were unable to replicate the issue. A previously stored DTC P3055 was found in the diagnostic system. This code relates to a known and documented issue with Chevrolet Equinox vehicles, for which Chevrolet has issued multiple Technical Service Bulletins, including TSB 21-NA-139, which identifies the Multifunction Power Supply Converter (GM Part #13510484) as the known culprit for this failure mode. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Power train, Service brakes, Engine, May 10, 2026
On Saturday, April 18, 2026, I was driving home from a neurology appointment with my two daughters, including my child with special needs. I intentionally chose not to take the expressway and instead drove a lower-speed route home for safety reasons. While traveling approximately 35 mph, the vehicle suddenly displayed an “Engine Power is Reduced” warning. As I attempted to safely maneuver through traffic and pull over, the brake pedal became extremely stiff and difficult to depress, requiring significant physical force to slow and stop the vehicle. The sudden reduction in braking assist created a serious safety hazard for my family. Had this occurred at highway speeds on the expressway, the outcome could have been catastrophic. A post-incident inspection identified failure of the vacuum pump drive assembly and related timing/variable valve timing (VVT) components. Photographs taken during disassembly document the condition of the timing chain, camshaft, VVT actuator/phaser, vacuum pump assembly, and associated components at the time of repair. Diagnostic records also documented DTC Code P1101 following the incident. The vehicle is currently undergoing further inspection and diagnostic evaluation at a certified Chevrolet dealership to validate CPO warranty coverage and determine the full extent and cause of the failure. Based on the sudden loss of engine performance and reduction in brake assist, I believe this condition represents a significant safety risk to vehicle occupants and the public.
Service brakes, Hydraulic, Apr 2, 2026
The contact owns a 2020 Chevrolet Equinox. The contact stated that while depressing the brake pedal, the vehicle shook and vibrated abnormally. There was no warning light illuminated. The vehicle was taken to a local dealer, but the vehicle was not diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 19V704000 (Service Brakes, Hydraulic); however, the VIN was associated with the recall. The contact later replaced the rear brakes independently. The manufacturer was contacted, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 120,000.
Other or unspecified, Service brakes, Mar 18, 2026
the car has a grinding that i am not sure where it is coming from, it maybe coming from the wheel and it also has a battery problem
Service brakes, Mar 13, 2026
The brake booster vacuum pump, in the words of Meineke, massive failure. The pump locked up and exploded, there are parts of at least under the valve cover. The failure resulted in the ruining of the camshaft, as this pump is controlled by the camshaft. The end of my camshaft looks like a mushroom head. This failure is currently in the investigation part of a class action law suit in which I am adding my name to the hat. My wife was driving at the time and fortunately was not injured during this catastrophic failure with what seems like planned obsolescence. I am also glad the kids weren’t in the car when this happened. We had just crossed 100k miles.
Service brakes, Hydraulic, Feb 12, 2026
The contact owns a 2020 Chevrolet Equinox. The contact stated that the rear tire treads were prematurely worn. A mobile independent mechanic diagnosed the vehicle at the residence, and the mechanic determined that the brakes were dragging. The brakes were replaced. The vehicle was taken to a tire dealer, where the rear tires were replaced. The vehicle was taken to the dealer, where the defective tires were inspected. The service manager associated the failure with NHTSA Campaign Number: 19V704000 (Service Brakes, Hydraulic); however, the VIN was not included. The manufacturer was notified of the failure and informed the contact that no assistance would be provided because the VIN was not included in the recall. The failure mileage was approximately 48,800.
Service brakes, Jan 21, 2026
My son was driving the car the Service Brake Assist message popped up on the screen, and the brake pedal went stiff. He was coming to a red light and had to swerve to the right to avoid hitting the cars in front of him as he had no brakes at this point. We had the vehicle towed to our house, had the vehicle looked at by our mechanic. The Diagnosis was the brake vacuum pump, part number #12684050 exploded. It is available for inspection, at this point we don't know if the metal pieces have fallen into the engine compartments and we would rather not replace the engine as well. We had contacted the Local Chevy Service dept. who said we can pay $1500.00 to for them to take apart the top of the engine to look for broken pieces, but the best option is to trade it in as soon as possible.
Service brakes, Hydraulic, Engine and engine cooling, Jan 9, 2026
The contact owns a 2020 Chevrolet Equinox. The contact stated that while driving approximately 40 MPH, the message "Engine Power Reduced" was suddenly displayed. While attempting to stop, the brake pedal was extremely difficult to depress, and the braking distance was extended. The vehicle was later towed to the local dealer, who diagnosed that the brake vacuum pump had failed and needed to be replaced. The vehicle was not yet repaired. The contact was also informed that metal shavings from the vacuum pump might have entered the engine and that an engine diagnostic test was needed. No further information was available. The manufacturer was notified of the failure. The failure mileage was 55,000.