2020 Chevrolet Equinox
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 308 owner complaints filed for this model year. This is the 13th highest complaint count among 21 Equinox model years with reports.
Of the 2020 reports, 20 involved a crash and 7 involved a fire. 12 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Child seat, vehicle latch anchorMay 11, 2023
General Motors, LLC (GM) is recalling certain 2020-2023 Chevrolet Equinox and GMC Terrain vehicles. The four rear-seat lower child seat LATCH anchorage bars may have excessive powder coating, which could prevent a child seat from being installed with the anchorage bars. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child Restraint Anchorage Systems."
The inability to install a child seat with the LATCH anchorage bars could result in an unsecured child seat, increasing the risk of injury in a crash.
Owners are advised to install child seats using the vehicle's rear seat belts until the remedy is complete. Dealers will inspect the latch anchorage bars, and remove and replace the finish, as necessary, free of charge. Owner notification letters were mailed June 2, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N232403240.
Campaign 23V339000 on NHTSA.gov
Power train, automatic transmissionOct 29, 2020
General Motors LLC (GM) is recalling certain 2018-2019 Chevrolet Cruze and Buick LaCrosse, 2018-2020 Chevrolet Equinox, Chevrolet Traverse and GMC Terrain, 2018 Chevrolet Malibu, 2019-2020 Buick Encore, Buick Enclave, Cadillac XT4, Chevrolet Blazer and GMC Acadia, and 2020 Cadillac XT6 vehicles. The start/stop accumulator endcap may have missing bolts.
Missing bolts on the start-stop accumulator endcap could result in a transmission oil leak and may progress to a loss of propulsion, increasing the risk of a crash. A transmission fluid leak in the presence of an ignition source may increase the risk of fire.
GM will notify owners, and dealers will inspect the start-stop transmission accumulator and replace it if any bolts are missing, free of charge. The recall began December 15, 2020. Owners may contact GMC customer service at 1-888-988-7267, Buick Customer service at 1-866-608-8080, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N202313440.
Campaign 20V668000 on NHTSA.gov
Service brakes, hydraulic, foundation components, disc, caliperOct 3, 2019
General Motors LLC (GM) is recalling certain 2020 Chevrolet Equinox vehicles. The rear brake calipers may have been produced with an incorrect lubricant, potentially causing the rubber seals to swell and the brakes to drag.
Brake drag may result in overheating of the brake pads, affecting the braking ability and increasing the risk of a crash.
GM will notify owners, and dealers will replace the rear brake calipers, including the brake hose gasket, brake fluid and wheel to hub lubricant, free of charge. The recall began October 29, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438. GM's number for this recall is N192270920.
Campaign 19V704000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblySep 19, 2019
General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Equinox all-wheel drive vehicles. The fuel tanks may have been manufactured with an improperly sealed seam, possibly allowing fuel to leak along the seam near the fuel inlet.
A fuel leak in the presence of the ignition source can increase the risk of a fire.
GM will notify owners, and dealers will replace the fuel tank, free of charge. The recall began October 24, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N192271870.
Campaign 19V667000 on NHTSA.gov
Representative owner complaints
308 reports, newest first.
Engine, Jan 15, 2024
I was driving at about 25 miles per hour and the vehicle made a banging noise and shut off. I went to restart and nothing would happen. I then had it towed to a local dealership. Upon evaluation the vacuum pump went out and caused catastrophic engine failure. I purchased brand new and there was no indication I had a problem. The vehicle was making no noise and no lights were on prior to the incident. I am told the repairs to the motor on a vehicle 3 years old are going to be $4,500. I have told the dealership I would like all of the parts that are removed and replaced from the vehicle when repairing
Other or unspecified, Jan 11, 2024
I was driving my car and it shut down in the middle of traffic on the freeway on [XXX] I thought I was dead I almost had a accident the car started back up and it did it again 4 times I am afraid to drive the car when it shuts down the steering wheel locks up and nothing happens I am so afraid of this Equinox please help. Not knowing what to do went to the dealer guy did a simply scan on the car and tried to sell me a car instead of trying to find the cause I am just so upset I love my car please please help me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Exterior lighting, Jan 4, 2024
Premature headlamp (low beam) failure. The light abruptly failed and it was acknowledged by the manufacturer that this should not have occurred. The failure occurred in October of 2023. Light fixture has since been replaced. The low beam bulb is not accessible for replacement in our vehicle. Instead the entire headlight assembly has to be replaced. The estimated cost for a single replacement was approx $2,600.00. After back and forth with the manufacturer they agreed to replace both headlight assemblies for approximately $1,900.00. A previous recall was issued for GM vehicles in the early 2000s that had similar premature headlight failures. This poses a safety risk because vehicles of this age are likely to still be financed and owners are unlikely to be able to afford a near $3,000 repair for a low beam headlight manufacturing defect. Please note the mileage on the vehicle was roughly 42k. There is the potential that owners will be forced to operate the vehicle with failed headlight(s) while the manufacturer refuses to fully acknowledge it is a manufacturing defect.
Electrical system, Service brakes, Dec 28, 2023
During the month of November while driving on Interstate 35 inTexas I attempted to administer my braking system during slowed traffic and they did not respond. The brake pedal became completely stiff and I had to apply incredible pressure to get the vehicle to slow down until I turned on my hazards and rolled to a stop on the shoulder. I did not have any alerts or warnings until I powered the vehicle off and powered back on to find my engine light on and the service brake assist alert on as well. I had it towed for service to which they replaced the vacuum pump, brake booster pressure sensor and brake fluid. Everything seemed to be working fine however a month later the same exact issue occurred. I took it in to the same place for service and had a brake inspection done and was told everything looked good and they were not sure what was wrong other than the ecm and ebcm were now reading codes. The issue is that this is intermittent with no warning and has been incredibly difficult to pinpoint the exact issue. This has also been incredibly pricey trying to chase an issue that appears one day and clears itself the next and lastly this has been terrifyingly frustrating as I do not know if i will have valid brake control or not on each ride. This issue could be life or death and was traumatizing as I had my son and mother in the car with me during the first event.
Service brakes, Engine, Dec 19, 2023
I was traveling the interstate I90/94 , merged to the exit ramp and found the brake pedal hard and unable to push to brake. I had to slide the car into neutral and use two feet on the brake pedal to slow down enough to make the corner at the end of the off ramp. All due to a faulty vacuum pump. The debris from the exploded vacuum pump were sent through the engine. And after having the car fixed it now uses about a quart of oil every 500 miles. Engine is shot! Seriously bad engineering design that will kill someone if it hasn't already. I am 5'11" and weigh 190 lbs. I estimate it took around 200-250 lbs of force to push the pedal to even start to slow. If I hadn't had over 40 years of driving experience, this would have ended in a catastrophic incident.
Service brakes, Hydraulic, Dec 15, 2023
The contact owns a 2020 Chevrolet Equinox. The contact stated that while driving at slow speeds speed, an abnormal grinding sound coming from the vehicle. There was no warning light illuminated. The contact drove the vehicle to an independent mechanic and was informed that the rear brake calipers had failed and needed to be replaced. The mechanic replaced the rotors and the calipers; however, the contact stated the failure returned while driving at slow speeds. Upon investigation, the contact discovered NHTSA Campaign Number: 19V704000 (Service Brakes, Hydraulic) and linked the failure to the recall. The manufacturer was notified of the failure and a case was filed. The vehicle was not repaired. The failure mileage was approximately 71,000.
Fuel/propulsion system, Nov 22, 2023
On 10/19/2023, I came out of a store and saw a large puddle forming under my 2020 Chevy Equinox and fluid spilling out. I immediately drove it to the car repair business I have used for 10 years, which was less than one mile away. The bottom line was a cracked gas tank. They confirmed the warranty had expired in February of 2023, so with no reason to think otherwise, I had them order and replace the gas tank. I filed a report with GMC, only to be told that since I didn't have an authorized GMC dealership make the repairs, there was nothing they could do, to reimburse me. I felt that this as an emergency situation, not only for myself but others around me. I'm not sure how I was supposed to know to take it elsewhere. The bottom line is this...how can a vehicle that is only just over 3 years old, need a new gas tank? This is not typical and should be investigated.
Service brakes, Nov 12, 2023
Faulty Brake Booster Vacuum code on after 60,000 miles
Fuel/propulsion system, Nov 8, 2023
There was not an accident. I was leaving work on 9/16/23 and tried to start the car and it wouldn’t turn over. I got assistance from a friend that had jumper cables because I thought it might be the battery, but it wasn’t. I had to have the vehicle towed to the dealership to find that these fuel module was defective. I see in the Google information that this sane issue was placed on the recall list for 2021-23 Chevrolet Equinox’s, but not on my 2020 model. The cost of this repair was very costly, and frustrating because I have only had the vehicle for one year to the day of this issue. I’m hoping that this problem can be recalled so that I can possibly be reimbursed for the nearly $1,000 I paid to have it repaired.
Service brakes, Oct 31, 2023
2020 Chevy equinox vacuum pump. Impossible to get the part, safety hazard, no accident yet, takes 2 feet to hold peddle down. No Chevy dealer will help me, i need to go to work.
Service brakes, Oct 27, 2023
Attempted to start braking while in high traffic. Brake assist came on and prevented the car from braking properly, almost causing a crash on the highway with the car in front. The brakes had to pressed extremely hard and the e brake had to be engaged in order to stop. Since then the brake assist has not turned off and the vehicle is not safe to drive.
Other or unspecified, Service brakes, Oct 11, 2023
Driving and brakes went out with no warning, no sounds, no anything almost causing me to rear end a 16 wheeler in the dead of night and almost causing another passenger to rear end me! No fluids are leaking. Break fluid not low. The brakes will not go to the floor in reverse, neutral, or drive. I had to get a Uber and get the car towed back home. Upon research it is apparent that this is a known problem in Chevrolets, specifically the 2020 equinox model with the vacuum pumps or something randomly going out while driving. This is very dangerous and I could have lost my life or caused someone else to loose their life! I just got my car a few months ago and it says” no unrepaired safety recalls reported” however this is clearly a known defect that was not bought to my attention upon purchasing the car.
Fuel system, Gasoline, Engine, Sep 18, 2023
The contact owns a 2020 Chevrolet Equinox. The contact stated that the check engine warning light was illuminated. While driving, the vehicle was sputtering. The vehicle was taken to the local dealer, where it was diagnosed that the fuel pump driver module was defective. The vehicle was repaired, but the failure recurred. The vehicle was taken back to the local dealer, who was unable to duplicate the failure. The contact stated that the failure was related to NHTSA Campaign Number: 19V667000 (Fuel System, Gasoline). The manufacturer was not contacted. The failure mileage was approximately 29,165.
Wheels, Service brakes, Forward collision avoidance, Sep 16, 2023, crash, fire
Got hit at 40 miles an hour in a parking lot while a running dog came through and it was caotic
Seats, Sep 11, 2023
System states rear seat reminder. Look in rear seat. Look in rear seats. This is a hazard to my infant as his car seat is located in the back seats behind the passenger.
Fuel/propulsion system, Aug 27, 2023
Fuel pump and module failed. Car started but left me stranded less than a mile from my house. It had to be towed to a repair shop.
Fuel/propulsion system, Aug 8, 2023
The suv is slow or delayed in acceleration. Pushing your foot on the gas pedal the suv will have a delay on acceleration. It is dangerous while trying to merge into traffic. Chevrolet knows its a known issue. It is a safety concern.
Engine, Fuel/propulsion system, Jul 31, 2023
Was backing out of driveway to street, Car stalled in the street and would not restart. Took to dealership which indicates that fuel pump shorted, fuel pump modulator issue, fuel injectors need to be cleaned/replaced and that spark plug need to be replaced. I have done regular oil changes on this Vehicle and only has 66050 miles on it. It was purchased as a new vehicle January 2021. Mileage is partly highway due to child away in at college. Check engine light came on before stall and code indicated that engine running lean which was told to shop when I took vehicle in several weeks ago indicating engine not operating properly. No warning light on when checked by shop, was told that they could not find issue. Several weeks later vehicle stalls and now needs approximately $3200 worth of parts and work done.
Electrical system, Other or unspecified, Service brakes, Jul 22, 2023
The brake assist warning light flashed and the electric components start blinking and the car went in reverse in traffic. The car then turnt off.
Service brakes, Jul 19, 2023
Driving on trip to New York and lost the brake assist system halfway there. No alerts or engine lights came on as they should have. Luckily we were coming up to stop light so not going to fast but almost hit car in front of us. We had no warning and this is a known problem with these cars.
Power train, Electrical system, Engine, Jul 17, 2023
Car will not accelerate over 25mph…oil leaking from somewhere…car starts rattling and making putt noises…car now randomly blinks headlights and interior lights when idle flashing off and on…sunroof will not close but goes back—shade as well. Radio screens turns black and stays on while car is off. I HATE THIS CAR!!!
Electrical system, Jul 17, 2023
discover that alternator is possible problem of stalling and car hard starting due to battery being low and reduced electrical power to use start. Wonder if power is reduce to fuel pump???
Electrical system, Engine, Fuel/propulsion system, Jul 17, 2023
vehicle STALLED WHILE PULLING OUT FROM STOP. STRUGGLED TO RESTART AFTER STALLING. believed FUEL PROBLEM BECAUSE ENGINE TURNING OVER WHEN START BUTTON PUSHED BUT NOT SOUNDING LIKE STARTED LIKE NO IGNITION IN ENGINE. when IT DID START IT STALLED AGAIN. AFTER SITTING FOR A WHILE, VEHICLE STARTED. Several days later car soppt
Power train, Electrical system, Service brakes, Jul 14, 2023
This vehicle starts glitching after exposure to rain. All of the gauges start going up and down, and every action required message pops up one after the other stating "Fuel Level Low, Shift to Park, Park Assist Off, All Wheel Drive System, Service Power Steering, ESC". The vehicle does this while driving at low to high speeds, even on the highways it has happened, the brakes are hard to push in while this is happening. This puts me and others in high danger if I cannot control the vehicle while driving. I have taken the vehicle in over 6 times to the service department of GM and not one time has anything been done. They have been unsuccessful in duplicating the problem every time I've brought it in even when it is occurring.
Service brakes, Jul 11, 2023
When I was driving my vehicle, I came up to a red light and my brake pedal was hard and I could not stop the vehicle. The brakes would not work when I tried to stop. With fast acting and thinking, I was able to pull over to avoid hitting the vehicle in front of me, luckily no other cars were around at that time. Mine and my child's safety were at risk when the vehicle would not stop and we could have been in an accident from the brakes not working. The vehicle is currently at the dealership getting diagnosed. No warning sings, warning lamps, messages or other signs happened before, during, or after the failure of the brakes. The brake pedal was so hard you could not push it down at all.