2002 Chevrolet Malibu
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 596 owner complaints filed for this model year. This is the 17th highest complaint count among 26 Malibu model years with reports.
Of the 2002 reports, 20 involved a crash and 1 involved a fire. 20 people were injured.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Fuel system, other, storage, tank assembly, pressure relief devicesMar 12, 2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000 on NHTSA.gov
Exterior lighting, headlightsApr 10, 2002
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME OF THESE VEHICLES WERE PRODUCED WITH A LEFT LOW-BEAM HEADLAMP THAT DOES NOT MEET THE PHOTOMETRIC PERFORMANCE REQUIREMENTS OF THE STANDARD.
LIGHT INTENSITIES BELOW THE MINIMUM INTENSITY REQUIREMENTS CAUSE REDUCTION IN VISIBILITY DOWN THE ROAD FOR THE DRIVER OF THE VEHICLE AND INTENSITIES ABOVE THE MAXIMUM INTENSITY REQUIREMENTS CAUSE INCREASE IN GLARE FOR DRIVERS AHEAD OF, OR APPROACHING, THE VEHICLE.
DEALERS WILL INSPECT THE LEFT LOW-BEAM HEADLAMP AND REPLACE IT IF IT DOES NOT MEET REQUIREMENTS. OWNER NOTIFICATION BEGAN MAY 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Campaign 02V107000 on NHTSA.gov
Representative owner complaints: engine
89 reports, newest first. Show all
Electrical system, Engine, Aug 18, 2021
The anti-theft/ passlock system fault in this generation of GM vehicles is very widespread and effects a large percentage of vehicles in this generation. I am sure there have been hundreds if not thousands of complaints about same issue and GM refuses to fix the problem. The problem causes the car to randomly shut off due to anti theft fault and can happen on interstate, highway or in town driving. This is a very dangerous fault and very expensive for owners especially when dealerships themselves don't even know what they are dealing with. They will throw parts at the problem with no real knowledge. GM needs to be held accountable. Currently the ignition the BCM have been replaced and now the car will not start at all and I have no lights or gauges on my cluster.
Electrical system, Engine, Jun 19, 2019
TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED THAT THE ENGINE HESITATED WHEN STARTED. ALSO, THE INSTRUMENT PANEL LIGHTING BECAME VERY DIM AND THE DATA ON THE SCREEN WAS NOT VISIBLE. ALSO, THE PASSENGER DOOR WOULD NOT LOCK AND THE WINDOWS FAILED TO ROLL DOWN. ALL THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT JUMPED THE BATTERY AND THE ENGINE RESTARTED. LATER, THE VEHICLE DECELERATED WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ANTI-THEFT SYSTEM FAILED. THE MECHANIC WAS CURRENTLY PERFORMING A SECOND DIAGNOSTIC TEST. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 46,786.
Other or unspecified, Engine, Fuel/propulsion system, Jul 15, 2018
MY VEHICLE IS MESSING UP ON ME AND IT WAS SHUT OFF MY VEHICLE IS MESSING UP ON ME IT WILL SHUT OFF WELL DRIVING ILL PULL OVER AND WAIT A COUPLE MINS AND I WILL PULL OUT THE FUEL FUSE AND WAIT A COUPLE MINS AND WILL PUT IT BACK AND IT WILL START AGAIN AFTER A WEEK IT SHUT OFF ON ME AND WOULD NOT START HAD TO HAVE IT TOWED TOOK IT TO A MECHANIC HE CHANGED THE FUEL PUMP AND MARJORAM WORKED FOR 5DAYS THEN THE SAME PROBLEM AGAIN CHANGED THE SENSORS WORKED OK FOR 2DAYS AND THE PROBLEM CAME BACK AGAIN SO I CHANGED THE SPARK PLUGS FUEL FILTER ALL FUSES STILL NOTHING ITS BEEN SITTING FOR 3 TO 4 MONTHS NOW I CAN'T SEEM TO FIND THE PROBLEM I CHANGED EVERYTHING U CAN THING OF NOW THE CHECK ENGINE AND TEST SYSTEM LIGHT IS ON
Other or unspecified, Engine, Apr 25, 2018
MY CAR CUTS OFF AND GOES INTO THE ANTI-THEFT SYSTEM WHILE I'M GOING DOWN THE ROAD WHEN THIS HAPPENS MY CAR HAS TO BE PUSHED OFF THE ROADWAY AND THEN I HAVE TO SIT WITH MY DRIVER SIDE DOOR OPEN AND MY KEY TURNED ON FOR 10 MINUTES UNTIL IT RESETS ITSELF THIS IS VERY DANGEROUS AND IT SCARED ME BECAUSE I WAS IN THE MIDDLE OF HIGHWAY 150 IN DANVILLE KENTUCKY. PLUSMY HEATING SYSTEM IS MESSED UP I CAN'T GET IT TO BLEED OUT THE AIR IN THE SYSTEM.
Engine and engine cooling, Nov 16, 2017
TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU CLASSIC. WHILE THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO ACCELERATE AND LOST POWER. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE EGR VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS THEN TAKEN TO GILDNER DODGE-CHRYSLER-JEEP INC (1451 N 10TH ST, ARKADELPHIA, AR 71923 (870) 246-6800), BUT NO DIAGNOSTIC FAILURE CODES WERE FOUND AND THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS PROVIDED A CALL BACK. THE APPROXIMATE FAILURE MILEAGE WAS 99,378.
Engine, Jun 1, 2017
TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED THAT THE ENGINE WARNING INDICATOR ILLUMINATED AND ANTI-FREEZE WAS LEAKING OUT OF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO AN UNKNOWN DEALER WHERE IT WAS DIAGNOSED THAT THE HEAD GASKET BLEW OUT AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE OURISMAN CHEVROLET DEALER STATED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE APPROXIMATE FAILURE MILEAGE WAS 10,333.
Electrical system, Engine, Aug 1, 2016
TL* THE CONTACT OWNS A 2002 CHEVROLET MAILBU CLASSIC. WHILE DRIVING APPROXIMATELY 10 MPH, THE ENGINE STALLED WHILE MAKING A LEFT TURN AND THE SECURITY WARNING LIGHT ILLUMINATED. THE CONTACT ALSOOBSERVED AN ABNORMAL NOISE DURING THE FAILURE. THE CONTACT ALSO STATED THAT THE POWER LOCKS UNLOCKED AND LOCKED WITHOUT BEING PROMPTED AND THE GAUGE LEVELS INCREASED. THE VEHICLE WAS ABLE TO RESTART AFTER VARIOUS ATTEMPTS; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT MENTIONED THAT THE ENGINE WAS SERVICED PER A RECALL, BUT THE NHTSA CAMPAIGN NUMBER WAS NOT AVAILABLE.THE FAILURE MILEAGE WAS 110,000.
Engine, Jun 3, 2016
PURCHASED VEHICLE USED FROM A DEALERSHIP. OVER HEATING ISSUES BEGAN WITHIN 3 MONTHS. HAD THERMOSTAT REPLACED. ALWAYS SEEMED TO HAVE TO BE ADDING WATER AS THE RESERVOIR WAS LOW OR THE INDICATOR LIGHT WOULD COME ON. 18 MONTHS LATER OVER HEATING ISSUES RETURNED WHILE DRIVING HOME ON HIGHWAY. WHEN VEHICLE COULD NO LONGER RUN, WE HAD TO HAVE IT TOWED HOME. HAVE NOW REPLACED THERMOSTAT AND WATER PUMP. ISSUE REMAINS, BUT WORSE. LOW WATER AND NOW CHECK ENGINE LIGHTS ARE ON. ALL INDICATIONS SUGGEST HEAD GASKET ISSUES WHICH WILL ULTIMATELY RESULT IN COMPLETE ENGINE FAILURE. AS SUCH, THE VEHICLE CANNOT BE SAFELY DRIVEN AND REMAINS PARKED. NO SUCH ISSUES WERE DISCLOSED AT THE TIME OF PURCHASE. ONLY LEARNED EXTENT OF PROBLEM AFTER RESEARCHING ISSUE ONLINE TO FIND MANY, MANY OTHER OWNERS OF THIS VEHICLE TYPE EXPERIENCING SAME PROBLEMS. CHEVROLET SHOWED LITTLE CONCERN WHEN CONTACTED. REPRESENTATIVE APOLOGIZED, BUT AS THERE IS NO RECALL WOULD ONLY SUGGEST TAKING THE VEHICLE TO A DEALERSHIP FOR DIAGNOSIS AND REPAIR. OWNER IS A DISABLED VETERAN ON A FIXED INCOME. CHEVROLET'S SUGGESTION IS SIMPLY NOT FINANCIALLY FEASIBLE AND LEAVES THE OWNER WITHOUT RELIABLE TRANSPORTATION TO AND FROM APPOINTMENTS. HE CANNOT USE THIS VEHICLE FOR THE PURPOSES FOR WHICH IT WAS INTENDED. FURTHERMORE, ONLINE REPORTS ALSO SUGGEST THE PROBLEM REMAINS OR RETURNS EVEN AFTER LENGTHY AND EXPENSIVE REPAIRS ARE MADE. ONCE AGAIN, CREATING CONSIDERABLE HARDSHIP TO THIS OWNER WHO NOW FEELS AS THOUGH HE WAS ROBBED FIRST BY THE DEALERSHIP WHERE HE PURCHASED THE VEHICLE FOR THEIR NONDISCLOSURE AND NOW BY CHEVROLET FOR THEIR NEGLIGENT DESIGN, QUALITY AND WORKMANSHIP AS WELL AS THEIR COMPLETE LACK OF DESIRE TO REMEDY THIS YEARS OLD DEFECT. INSTEAD SHIFTING THE FINANCIAL BURDEN FROM ONE UNSUSPECTING OWNER TO THE NEXT AND THE NEXT AFTER THAT.
Engine, Mar 22, 2016
VEHICLE WAS RUNNING FINE. PARKED CAR FOR 1 HOUR WENT TO START CAR IT WOULD TURN OVER BUT NOT START. AFTER CHECKING ALL FUSES AND FUEL PUMP I WAS ADVISED IT COULD BE AN ANTI THEFT MALFUNCTION. I FOLLOWED A PROCEDURE TO RELEARN THE SYSTEM AND THE CAR STARTED. THIS HAS HAPPENED ON 3 OCCASIONS AND I FEAR THE CAR WILL LEAVE ME STRANDED OR MALFUNCTION WHILE OPERATING WHICH COULD LEAD TO A SERIOUS INJURY
Engine, Nov 4, 2015
THERE WAS A BREAKDOWN, OF THE UPPER AND LOWER MANIFOLDS, CAUSED BY THE DEX COOLANT, AND POOR ENGINE DESIGN. COOLANT GOT INTO MY ENGINE, AND NEEDS TO BE REPAIRED OR A REPLACEMENT ENGINE REPLACED. SENDING A PICTURE OF THE OIL CAP WITH FOAM ON IT, AND ITS LIKE THIS INSIDE THE ENGINE AS WELL.
Electrical system, Other or unspecified, Engine, Jul 4, 2015
I HAD AN IGNITION SWITCH REPLACED BY A DEALER (DIMMITT CHEVROLET, CLEARWATER, FL) BECAUSE MY KEY WAS STUCK IN IT. THE SAME DEALER ALSO REPLACED MY KEY AND KEY CASING BECAUSE OF A RECALL. AFTER THAT I STARTING NOTICING THAT MY CAR WOULD INTERMITTENTLY CUT OFF FORCING ME TO PUT IN NEUTRAL AND RESTART. I THOUGHT IT MAY BE A CLOGGED FUEL FILTER AND HAD THAT REPLACED. THE ISSUE STILL EXISTS AND IT IS A DANGEROUS SITUATION TO ME AND MY FAMILY NOT KNOWING WHEN MY CAR WILL JUST STOP RUNNING, ESPECIALLY WHILE DRIVING AT HIGHWAY SPEEDS. I CHECKED AND DO NOT SEE A GM RECALL ON MY MODEL FOR SOME REASON.
Electrical system, Engine, May 18, 2015
I HAVE HAD A PROBLEM START WITH THE ANTI THEFT SYSTEM GOING OFF AND HAVING TO WAIT TEN MINUTES FOR LIGHT TO GO OUT AND START VEHICLE.
Engine and engine cooling, Feb 12, 2015
2002 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO VEHICLE JUST WOULD NOT START. *SMD THE CAM SHAFT SENSOR WAS REPLACED. *JB
Electrical system, Other or unspecified, Engine, Nov 6, 2014
2002 CHEVROLET MALIBU CLASSIC ENGINE FAILS TO START. GM PASSLOCK THEFT SYSTEM INDICATOR LIGHT FLASHES, AND STAYS LIT. VEHICLE HAS FAILED TO START AND STRANDED DRIVER AND PASSENGERS. KEY FEELS LOOSE IN IGNITION. TRIM SURROUNDING IGNITION REMAINS LOOSE FROM MULTIPLE SWITCH REPLACEMENTS. SAME ISSUE HAS BEEN DIAGNOSED BEFORE. VEHICLE DIAGNOSED AND DOCUMENTED AT GM SERVICE CENTER AS HAVING A FAILED IGNITION SWITCH FOR THE SECOND TIME. VEHICLE HAD TO HAVE IGNITION SWITCH REPLACED 2 TIMES AT OWNER'S EXPENSE FOR A GRAND TOTAL OF OVER $1200. ALL PARTS AND REPLACEMENTS HAVE BEEN PERFORMED AT THE SAME GENUINE GM SERVICE CENTER. RECOMMEND IGNITION SWITCH RECALL FOR SAFETY AND RELIABILITY ISSUES. FIRST REPLACEMENT OCCURRED IN 2008. SECOND SWITCH REPLACEMENT REQUIRED IN 2014. VEHICLE PART OF RECENT GM RECALL #:N140350 FOR UNINTENDED KEY ROTATION. REMEDY WAS PERFORMED ON THE DAY OF IGNITION SWITCH REPLACEMENT NUMBER 2; WHICH INCLUDED "INSERTS" FOR THE KEY RING SO THAT IT GOES FROM A "SLOT" DESIGN TO A HOLE DESIGN AND 2 SMALL 13 MM RINGS. IT SHOULD BE NOTED THAT THIS IS A FAILED REMEDY THAT CAN BE FOUND IN GENERAL MOTORS TSB # 05-02-35-007A AND WAS PERFORMED ON SIMILAR MODEL YEAR VEHICLES. THIS SOLUTION OR REMEDY FROM ENGINEERING DID NOT ULTIMATELY PROTECT DRIVERS AND OPERATORS FROM UNINTENDED KEY ROTATION. THIS SO CALLED RECALL REMEDY IS A PREVIOUSLY KNOWN FAILURE AND CAN BE FOUND IN PUBLIC DOCUMENTS CONCERNING GM IGNITION SWITCH LITIGATION. WHY IS GM ALLOWED TO CONTINUE TO IMPLEMENT A FAILED DESIGN WHEN IT COMES TO HANDLING THE IGNITION SWITCH RECALLS. IF IT DOESN'T WORK IN 6 DIFFERENT GM VEHICLES, THEN WHY WOULD IT WORK IN THE 1997-2005MY CHEVROLET MALIBU CLASSIC? THIS IS DECEPTIVE AND A CLEAR INDICATION THAT GM DOES NOT CARE ABOUT THEIR CUSTOMERS. *TR
Engine and engine cooling, Oct 23, 2014
2002 CHEVROLET MALIBU. CONSUMER WRITES IN REGARD TO INTAKE MANIFOLD GASKET LEAKING.* LD THE CONSUMER STATED GM USED DEX-COOL ENGINE COOLANT WHICH CAUSED PROBLEMS WITH THE ENGINE. THE REPAIR SHOP FLUSHED OUT THE DEX-COOL AND REPLACED THE COOLANT, WITH A DIFFERENT TYPE OF COOLANT. ALSO, THE INTAKE MANIFOLD WAS REPLACED AT A COST OF $477.31. *JB
Engine, Sep 22, 2014
TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING 40-80 MPH, THE VEHICLE STARTED TO JERK VIOLENTLY. THE FAILURE WAS EXPERIENCED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE VEHICLE NEEDED A TUNE UP. THE VEHICLE WAS REPAIRED BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 153,000. UPDATED 11/12/14*LJ THE CONSUMER STATED THE JERKING BECAME MORE FREQUENT. DUE TO THE JERKING GAS MILEAGE IS EXTREMELY POOR. UPDATED 7/27/2015 *JS
Steering, Engine, Aug 30, 2014
AS I WAS GETTING OFF AN EXIT FROM THE HIGHWAY THE CAR SHUT OFF AND STEERING BECAME HARD. I LET THE CAR ROLL INTO THE RIGHT LANE WHERE I COULD STOP AND TURN THE KEY TO START THE VEHICLE. THE VEHICLE STARTED IMMEDIATELY, STEERING WAS VERY HARD. I TOOK THE CAR TO A MECHANIC AND THE FOUND THAT THE POWER STEERING PUMP HAD TO BE REPLACED AND THE RACK N PINION STEERING HAD TO BE REPLACED. ONE WEEK LATER I DROVE THE CAR TO GO TO THE BEACH WITH MY DAD AND AS I WAS DRIVING THE CAR SEEMED FINE. WHEN I STOPPED AT A LIGHT THE ENGINE SHUT OFF AGAIN. ONCE AGAIN I DROVE TO THE MECHANIC THE NEXT DAY AND WHEN HE PUT THE COMPUTER TO THE CAR IT SHOWED THAT THE #4 COIL WAS MALFUNCTIONING. THANKFUL THAT I AM CAREFUL AND DEFENSIVE DRIVER. THIS SITUATIONS ARE QUITE SCARY. I OWNED A KIA SEPHIA FOR SINCE 2005 AND NEVER DID I EXPERIENCE WHAT I HAVE BEEN EXPERIENCING WITH THIS MALIBU. *TR
Engine, Aug 27, 2014
TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT APPROXIMATELY TEN MINUTES OF WAIT WAS NEEDED FOR THE VEHICLE TO BE ABLE TO RESTART. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.
Steering, Service brakes, Engine, Aug 26, 2014
WHEN DRIVING THE CAR IT MAY STALL,(AND IT HAS MANY TIMES) WHICH CAUSES FAILURE OF POWER STEERING AND BRAKES. THE CAR ALSO WON'T ALWAYS START. YOU CAN TURN THE KEY BUT THE DASHBOARD LIGHTS DON'T COME ON,IF THEY DON'T THE CAR WILL NOT START. ALSO THE BATTERY WON'T KEEP A CHARGE, UNLESS YOU START THE CAR AND LET IT RUN AT LEAST EVERY 2 DAYS. *TR
Fuel system, Gasoline, Electrical system, Engine, Jul 15, 2014
MAY 2013: CAR HARD TO START; MULTIPLE ATTEMPTS BEFORE ENGINE STARTED MAY 2013: HAD NEW KEY MADE AT LOCAL CHEVROLET DEALER DECEMBER 2013: CONTINUED PROBLEMS STARTING CAR; REPLACED IGNITION SWITCH JULY 1, 2014: GM ANNOUNCES EXPANDED RECALL TO INCLUDE 2002 MALIBU; CALLED LOCAL CHEVROLET DEALER; THEY SAID WE HAVE TO WAIT FOR THE LETTER FROM GM; DEALER DID NOT KNOW ABOUT EXPANDED RECALL JULY 14, 2014: CAR ENGINE TURNED OFF WHILE DRIVING JULY 15, 2014: CALLED LOCAL CHEVROLET DEALER AGAIN; STILL KNEW NOTHING ABOUT EXPANDED RECALL; COULDN'T ADVISE AS TO WHETHER CAR IS SAFE TO DRIVE. *TR
Engine, Jun 18, 2014
TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THERE WAS A SUDDEN LOSS OF ENGINE POWER AS THE ELECTRONIC THROTTLE CONTROL WARNING LIGHT ILLUMINATED. THE CONTACT MENTIONED THAT THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 73,000 AND CURRENT MILEAGE WAS 85,801.
Electrical system, Engine, Mar 13, 2014
MY HANDICAPPED MOTHER HAS A 2002 CHEVROLET MALIBU THAT HAS BEEN EXPERIENCING THE SAME EXACT IGNITION RELATED ISSUES AS THOSE IN THE CURRENT MASSIVE GM RECALL. ON MORE THAN TWO OCCASIONS THE ANTI-THEFT LIGHT ILLUMINATES AND THE VEHICLE SHUTS OFF WHILE SHE WAS DRIVING. THIS HAS RESULTED IN TWO SIGNIFICANT REPEAT REPAIRS, ONE IN 2010 AND ONE THIS WEEK. IN BOTH CASES THE CHEVROLET DEALERSHIP DESCRIBES THE ISSUE AS AN IGNITION PASS LOCK SENSOR THAT FAILS DUE TO KEY POSITIONING. I HAVE RESEARCHED THIS ONLINE AND HAVE FOUND HUNDREDS OF SIMILAR COMPLAINTS. LUCKILY THIS ISSUE HAS NOT RESULTED IN AN INJURY BUT EASILY COULD HAVE IN THE VERY CONGESTED METRO DC AREA THAT SHE LIVES IN. WHY IS THE MALIBU NOT BEING INCLUDED IN THE CURRENT INVESTIGATION AND RECALLS? *TR
Steering, Other or unspecified, Engine, Feb 28, 2014
I WAS DRIVING MY VEHICLE AT 35 MPH WHEN I WENT OVER A SMALL POT HOLE ON FATHER HURLEY BLVD. MY RIGHT KNEE SMASHED AGAINST MY KEY RING ON THE FRONT DASH AREA. THEE CAR LOST IMMEDIATE POWER. I COULD NOT ACCELERATE OR STEER MY VEHICLE. I HAD TO SLOWLY COAST OVER TO THE SIDE OF THE ROAD UNTIL I CAME TO A COMPLETE STOP. VEHICLES AROUND ME HAD A DIFFICULT TIME AVOIDING ME SINCE THIS EVENT HAPPENED AS I WAS APPROACHING A LANE MERGING WITH MINE AS THEY EXITED A MAJOR FREEWAY. WHEN THE VEHICLE HAD COMPLETELY STOPPED I PUT ON MY HAZARD LIGHTS AND PUT IT IN PARK. I NOTICED THAT THE KEY WAS NOT FULLY ENGAGED IN THE IGNITION SO I PUSHED IT ALL THE WAY BACK INTO THE IGNITION AND TURNED THE KEY OVER. THE CAR IMMEDIATELY STARTED UP AND I WAS ABLE TO DRIVE HOME SAFELY. THIS IS THE 3RD TIME AN EVENT LIKE THIS (WHERE MY KNEE HAS BUMPED UP AGAINST THE KEY RING AND THE CAR LOST POWER) HAS HAPPENED IN MY HISTORY OF OWNING THIS VEHICLE. *TR
Electrical system, Engine, Feb 28, 2014
WAS DRIVING DOWN THE ROAD AND THE THEFT SYSTEM LIGHT CAME ON AND ENGINE SHUT DOWN AS I WAS DRIVING DOWN THE ROAD. ALMOST CAUSED A WRECK. DID ONLINE RESEARCH AND FOUND MANY SIMILAR COMPLAINTS AND SAME INCIDENTS. NO RECALL ON IGNITION SWITCH/THEFT SYSTEM LIGHT. GM KNOWS OF AN ISSUE AND WON'T FIX THE PROBLEM. *TR
Electrical system, Engine, Feb 9, 2014
WHEN THE CAR IS STARTED, EVERYTHING SEEMS TO BE FINE, BUT THEN THE THEFT SYSTEM LIGHT COMES ON. WHEN THE CAR IS IN PARK AND REVERSE THINGS SEEM TO BE NORMAL. AT THE POINT THE CAR IS PLACED INTO DRIVE, THE FUEL LIGHT COMES ON AND SAYS THAT THERE IS NO FUEL IN THE CAR. AT THIS POINT, THE CAR WILL EITHER STALL OUT, WHILE DRIVING OR WE ARE ABLE TO CONTINUE DRIVING. IF WE ARE ABLE TO CONTINUE DRIVING, THE CAR REPEATEDLY SHUTS OFF ALL ELECTRICAL SYSTEMS, ALL GAUGES ARE MAXED OUT AND SPEED SAYS 60MPH. THIS HAPPENS REPEATEDLY THE WHOLE TIME THE CAR IS BEING DRIVEN, BUT THE CAR IS STILL FUNCTIONAL AND STILL ABLE TO BE DRIVEN. IF THE CAR SYSTEM COMES BACK ON, THE FUEL LIGHT COMES ON AND SAYS EMPTY AND EVEN THE TRUNK POPS OPEN WHILE DRIVING. THIS IS VERY DANGEROUS FOR MANY REASONS. IF THIS HAPPENS AT NIGHT, THERE ARE NO HEADLIGHTS OR ANY OTHER LIGHTS OR THEY'RE FLICKERING ON AND OFF THE WHOLE TIME. *TR