2002 Chevrolet Malibu
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 596 owner complaints filed for this model year. This is the 17th highest complaint count among 26 Malibu model years with reports.
Of the 2002 reports, 20 involved a crash and 1 involved a fire. 20 people were injured.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Fuel system, other, storage, tank assembly, pressure relief devicesMar 12, 2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000 on NHTSA.gov
Exterior lighting, headlightsApr 10, 2002
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME OF THESE VEHICLES WERE PRODUCED WITH A LEFT LOW-BEAM HEADLAMP THAT DOES NOT MEET THE PHOTOMETRIC PERFORMANCE REQUIREMENTS OF THE STANDARD.
LIGHT INTENSITIES BELOW THE MINIMUM INTENSITY REQUIREMENTS CAUSE REDUCTION IN VISIBILITY DOWN THE ROAD FOR THE DRIVER OF THE VEHICLE AND INTENSITIES ABOVE THE MAXIMUM INTENSITY REQUIREMENTS CAUSE INCREASE IN GLARE FOR DRIVERS AHEAD OF, OR APPROACHING, THE VEHICLE.
DEALERS WILL INSPECT THE LEFT LOW-BEAM HEADLAMP AND REPLACE IT IF IT DOES NOT MEET REQUIREMENTS. OWNER NOTIFICATION BEGAN MAY 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Campaign 02V107000 on NHTSA.gov
Representative owner complaints: hydraulic
43 reports, newest first. Show all
Service brakes, Hydraulic, Exterior lighting, Jan 12, 2009
TL*THE CONTACT OWNS A 2002 CHEVROLET MALIBU. WHILE DRIVING LESS THAN 70 MPH, THE EXTERIOR BRAKE LIGHTS ON THE VEHICLE CONTINUED TO ILLUMINATE EVEN WHEN THE BRAKE PEDAL WAS NOT DEPRESSED. THE CONTACT WAS CONCERNED THAT THE OTHER DRIVERS WOULD SWERVE AROUND HER AND ASSUME THAT SHE WAS BRAKING, WHEN IN REALITY, SHE WOULD BE IN ACCELERATION OR DRIVE MODE. THE DEALER REPLACED THE ECM AND THE SENSOR APPROXIMATELY THREE TIMES. THE VEHICLE HAS BEEN AT THE DEALER AT LEAST TWICE A MONTH FOR ONE YEAR. THE REPAIRS HAVE NOT CORRECTED THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 40,000.
Service brakes, Hydraulic, Dec 11, 2008
OWN A 2002 CHEVY MALIBU. HAD BRAKES AND ROTORS REPLACED IN 2006. JUST HAD TO DO IT AGAIN 12/5/08. CHEVY SHOULD RECALL AND REPLACE THE BRAKES FREE OF CHARGE. I USE MY CAR DAILY. *TR
Service brakes, Hydraulic, Mar 21, 2008
FROM THE FIRST DAY I HAD THIS CAR, THE BRAKES DO NOT ENGAGE COMPLETELY IN THE FIRST FEW USES OF THE BRAKES, ESPECIALLY IN WET CONDITIONS. I HAVE HAD MANY NEAR MISSES OF ACCIDENTS BECAUSE OF THE BRAKES NOT ENGAGING AND SOMETIMES NOT RELEASING-A THUMPING SOUND IS HEARD WHEN THE BRAKE CYLINDER PISTON RELEASES. *TR
Suspension, Service brakes, Hydraulic, Equipment, Feb 5, 2008
WHEN THE WEATHER IS WET OR SNOWY, AND THERE IS POSSIBLE SLICK SPOTS ON THE ROAD, THE ABS IS ENGAGED EVEN WHEN YOU ARE PULLING UP SLOWLY TO THE STOP SIGN, OR SLOWING DOWN TO ARRIVE HOME, OR EVEN COMING OUT OF THE DRIVEWAY... WHAT HAPPENS, IS WHEN DOING THOSE THINGS IN WEATHER AS DESCRIBED ABOVE, IF YOU ATTEMPT TO PUT THE BREAKS ON IT MAKES AN AWFUL GRINDING SOUND AND PUSHED BACK ON YOU SO YOU CANT BREAK... THIS HAS HAPPENED TO ME NUMEROUS TIMES JUST BACKING OUT OF MY DRIVEWAY... I PULLED UP TO A STOP SIGN BEHIND SOMEONE THIS IS RIGHT ON MY RESIDENTIAL STREET SO I WAS NOT SPEEDING AT ALL, IT WAS A RAINY DAY BUT THE RAIN WAS LIGHT, I HAVE BRAND NEW TIRES ON MY CAR TOO. AS I PULLED UP BEHIND MY NEIGHBORS CAR TO THE STOP SIGN, I WAS BARELY PUSHING DOWN MY BREAK PEDDLE WHEN IT PUSHED BACK AT ME AND MADE T HIS DEEP SOUND I COULDN'T STOP AND I ALMOST HIT MY NEIGHBOR. I WENT TO MY LONG TIME MECHANIC AND HE TOOK IT FOR A DRIVE ON A CLEAR DAY.... HE TOOK IT ON SOME GRAVEL AND STOPPED HARD WELL THE BREAKS DID THE SAME THING. HE SAID IT WAS THE ABS EVEN THOUGH HE DIDN'T LOOK AT THEM. I THINK IT IS THE WHEEL BEARINGS. I HAVE HAD MANY OTHER VEHICLES IN MY LIFE AND NON OF THEM DID THAT TO ME ON WET OR SNOWY DAYS! I KNOW IT ISN'T NORMAL AND I DO NOT FEEL SAFE DRIVING THE VEHICLE. I HAVE 2 YOUNG CHILDREN AND IF THE ABS ARE GOING TO BE THAT STINGY THEN MY CHANCES OF CRASHING WILL BE 99% HIGHER! *TR
Suspension, Service brakes, Hydraulic, Feb 4, 2008
I HAVE HAD MY 2002 CHEVY MALIBU SINCE IT WAS PURCHASED BRAND NEW FROM THE DEALERSHIP IN 2002. AFTER RUNNING FINE FOR A FEW YEARS, IT BEGAN TO DEVELOP RECURRING PROBLEMS. THE WHEEL BEARINGS (BOTH FRONT) HAVE BEEN REPLACED TWICE, ALONG WITH THE CALIPERS. *TR
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Electrical system, Jan 28, 2008
I AM CONTINUALLY HAVING PROBLEMS WITH MY 2002 CHEVY MALIBU. I HAD THE THEFT SYSTEM CONTINUALLY COME ON AND PAID $700 TO FIX THAT. FUEL PUMP WENT BAD...$500. I HAD THE COOLANT SYSTEM LEAK AND PAID $800 TO FIX THAT. EVERY TIME I GET MY BRAKE PADS REPLACED, THE ROTORS NEED REPLACED TOO, UNTIL THE LAST TIME WHEN THE CALIBERS HAD TO BE REPLACED AS WELL $900. NOW I AM HAVING DIFFICULTY STARTING MY PIECE OF JUNK. *TR
Service brakes, Hydraulic, Engine and engine cooling, Sep 27, 2007
THE ANTI-FREEZE HOLDING TANK KEEPS GETTING AN OIL RESIDUE IN IT AND THE ANTI-FREEZE KEEPS DISAPPEARING INTO THE ENGINE AND HAS TO KEEP BEING REFILLED. AFTER SPEAKING WITH A MECHANIC IT IS POSSIBLE THAT THE INTAKE MANIFOLD GASKET IS FAILING. THE A/C SWITCH ALSO TURNS OFF ON ITS OWN. ROTORS AND BRAKES HAVE BEEN REPLACED THREE TIMES. *JB
Service brakes, Hydraulic, Jun 23, 2007
I HAVE FILED A SAFETY COMPLAINT WITH CHEVROLET ON THE 2002 MALIBU I PURCHASED NEW. I HAVE HAD TO REPLACE THE BRAKES TWICE ONCE AT 33,378 MILES ON 5/5/2005 AND AGAIN AT 51,543 MILE ON 3/27/2007. THE CONSUMER COMPLAINT DEPARTMENT AND THE DEALERSHIP WHERE IT WAS REPAIR HAVE INFORMED ME THE REPLACING THE BRAKES AT 18,165 MILES ARE CONSIDERED ?ROUTINE MAINTENANCE.? FAILURE OF THE BRAKING SYSTEM WAS FOUND WHEN THE CAR DID NOT ADEQUACY STOP PLACING ME AND MY FAMILY IN DANGER. THERE WAS NO AUDIBLE OR VISUAL INDICATOR OF THE BRAKING PROBLEM, INSTEAD I HAD TO RELY ON PERFORMANCE FAILURE WHILE ON THE ROAD. TO DATE THE MANUFACTURER AND DEALERSHIP FAIL TO RECOGNIZE THE PROBLEM. *TR
Service brakes, Hydraulic, Structure, Apr 15, 2007
FOUND CORROSION ON THE BRAKE LINES AND MASTER CYLINDER, AND OTHER LINES THAT ARE LOCATED UNDER THE BATTERY CORROSION PLATE. THE BATTERY CORROSION PLATE WAS A GOOD IDEA. HOWEVER, PUTTING BRAKE LINES & OTHER COMPONENTS UNDER WERE ARE NOT A GOOD DESIGN. IT'S FLAWED, FOR IF THE BATTERY PLATE BECOMES CORRODED, THEN IT LEAKS ONTO THE LINES BELOW AND CAUSES DAMAGE AS IN MY VEHICLE. *AK
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Electrical system, Jan 10, 2007
FIRST INCIDENT OF LEAKING HAPPENED AFTER DEALERSHIP WORKED ON CAR. ARRIVED HOME COOLANT POURED OUT ON GROUND TOWED BACK. DEALERSHIP SAID RESERVOIR CAP SEAL. 10/2006 OR 11/2006, PICKING UP AT SCHOOL AND SMELLED NOT ENGINE. PARKED SAW COOLANT ON GROUND. NO ENGINE LIGHT ON BUT NEEDLE WAS PAST MIDDLE. FAMILY BROUGHT COOLANT FILLED IT UP AND WENT 5 BLOCKS TO DEALERSHIP. THEY SAID NOTHING WAS WRONG. YESTERDAY, 1/9/2007 CAR OVERHEATED IN THE SCHOOL LINE. ADDED COOLANT. I BROUGHT IT TO A NON DEALERSHIP RADIATOR SHOP OWNER THINKS INTAKE MANIFOLD GASKET LEAKING. CAR AT DEALERSHIP. I REALLY DON'T KNOW WHAT THE REAL PROBLEM IS BUT BECAUSE MY WARRANTY EXPIRED FEEL DEALERSHIP WILL TELL ME IT IS A NEW PROBLEM FROM THE FIRST EVENT SO I WILL BE RESPONSIBLE. AT LEAST TWO ROTORS REPLACED ON THE FRONT DRIVER'S WHEEL & 5 SETS OF PADS. REPORTED TO GM THEY CLAIM IT IS THE WAY I DRIVE! A NON DEALERSHIP TIRE COMPANY HAD THE PADS REPLACED WITH A GOOD BRAND. 1 1/2 YEARS SINCE I HAD TO HAVE PADS. PROBLEM WITH THE RIGHT FRONT PASSENGER DOOR LOCKS. CAR IS RUNNING AND THE DRIVER GETS OUT LEAVING CAR ON AND THEN THE PASSENGER TURNS OFF THE CAR AND GETS OUT, LOCKS CAR, THE RADIO STAYS ON. I WENT INSIDE THE STORE AND CAME OUT AND THE RADIO WAS STILL PLAYING. WHEN YOU UNLOCK THE CAR BUT ENTER ONLY THE PASSENGER FRONT DOOR AND THEN CLOSE IT AND WALK AWAY, THE CAR LOCKS ITSELF. HAPPENED SEVERAL TIMES. I HAD NOT PLACED THE KEYS ON THE SEAT OF THE CAR AND SHUT THE DOOR OR I WOULD HAVE BEEN LOCKED OUT. I REPORTED THIS BUT NO ONE SEEMED TO CARE. RADIO WAS REPLACED FOR LEFT BUTTON PAINT (NOT SURE IF IT IS PAINT OR COVER ON BUTTON) RUBS OFF. IGNITION SWITCH WAS REPLACED. FUEL PUMP REPLACED.. I TRANSPORT GRANDCHILDREN AND I NEED A SAFE CAR. *JB
Service brakes, Hydraulic, Nov 28, 2006
BRAKE ROTORS ON 2002 MALIBU FAILING EVERY 18000 TO 20000 MILES. (3 TIMES IN 4 YEARS) I HAD THE ROTORS AND BRAKES CHECKED 7 MONTHS AFTER THE LATEST REPLACEMENT BECAUSE OF VIOLENT SHIMMING IN THE FRONT END AND WAS TOLD BY DEALER EVERYTHING WAS FINE WITH MY ROTORS AND BRAKES. NOW 5 MONTHS LATER(AFTER THE PARTS WARRANTY EXPIRED) I AM TOLD I NEED NEW ROTORS AND BRAKES. GM KNOWS THEY HAVE A PROBLEM WITH THIS BUT REFUSES TO ADDRESS IT. I HAVE HAD 5 NEAR ACCIDENTS ON THE FREEWAY BECAUSE OF THE VIOLENT SHIM WHEN I HIT THE BRAKES. ALL THE DEALERSHIP WILL SAY IS THEY CAN "SEE A PATTERN". I WOULD LIKE TO KNOW HOW MANY DEATHS WERE CAUSED BY THIS PATTERN! *NM
Service brakes, Hydraulic, Jun 14, 2006
DT*: THE CONTACT STATED WHILE DRIVING 40 MPH THE ABS LIGHT ILLUMINATED. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE FRONT PASSENGER HUB AND SPEED SENSOR. THE DEALER WAS ALERTED. THE VEHICLE IS A MALIBU. *AK
Service brakes, Hydraulic, May 30, 2006
BOTH FRONT CALIPERS AND BOTH REAR CALIPERS LEAKING. PROBLEM COVERED UNDER MY FIDELITY EXTENDED WARRANTY, BUT THE NEW BRAKES THAT I HAD ON THERE WERE RUINED BY BRAKE FLUID CAUSED BY THE LEAK. WARRANTY DOES NOT COVER BRAKES. I HAVE 3 FRIENDS WITH THE EXACT SAME VEHICLE AND THE EXACT SAME PROBLEMS. *JB
Service brakes, Hydraulic, Nov 18, 2005
DT: THE CONSUMER STATED SINCE PURCHASE OF VEHICLE SHE HAD PROBLEMS WITH THE BRAKES. THE VEHICLE WILL NOT COMPLETELY STOP. SHE TOOK THE VEHICLE TO THE DEALERSHIP, AND THEY REPLACED THE PADS AND ROTORS. HOWEVER, THE CONSUMER IS STILL EXPERIENCING STOPPING PROBLEMS. SHE HAS TAKEN THE VEHICLE TO A SERVICE STATION TO HAVE THE PADS REPLACED. THEY HAVE TO BE REPLACED EVERY TWO TO THREE MONTHS. THUS FAR, THE PADS HAVE BEEN REPLACED TEN TIMES. THE PROBLEM HAS NOT BEEN FIXED OR DIAGNOSED. *AK UPDATED 12/07/05. *JB
Service brakes, Hydraulic, Exterior lighting, Oct 13, 2005
MY TURN SIGNALS WORK WHENEVER THEY FEEL LIKE IT. THIS HAS BEEN GOING ON FOR ABOUT 8 MONTHS NOW AND IT SEEMS TO BE GETTING WORSE. SOMETIMES YOU CAN HEAR THE TURN SIGNAL BUT THE LIGHT IS NOT ACTUALLY ON. ALSO, I HAVE HAD TO REPLACE MY ROTORS ON THE CAR THREE TIMES ALL READY AND THE CAR IS NOT EVEN THREE YEARS OLD YET. I AM QUITE UPSET BECAUSE BETWEEN THE TURN SIGNALS AND THE BRAKES I AM AT A HIGH RISK FOR AN ACCIDENT. I HAVE A THREE YEAR OLD DAUGHTER AND EVERYDAY I GET IN THE CAR AND DRIVE WITH HER I AM PUTTING BOTH OF OUR LIVES AT RISKS. I CAN'T BELIEVE THAT IT IS THREE YEARS AND YET THERE HAS BEEN NO RECALL ON EITHER OF THESE POTENTIALLY LIFE ENDANGERING ISSUES WHEN THERE HAS BEEN PROBLEMS WITH AT LEAST ONE OF THESE ISSUES ON PREVIOUS MODELS. WHAT IS WRONG WITH THIS PICTURE?? *JB
Suspension, Service brakes, Hydraulic, Fuel system, Gasoline, Visibility, Sep 7, 2005
I PURCHASED MY 2002 MALIBU NEW AND HAVE HAD THE BRAKES REPLACED FOUR TIMES AND AM ON MY THIRD SET OF ROTORS. AT 54000 MILES THE WHEEL BEARING AND CONTROL ARM BUSHINGS HAD TO BE REPLACED. TWO WEEKS LATER THE FUEL PUMP HAD TO BE REPLACED ALSO. THE PASSENGER SIDE REAR WINDOW CAN'T BE DOWN BECAUSE LAST TIME WE HAD A ROUGH TIME GETTING IT TO GO BACK UP.*JB
Service brakes, Hydraulic, Jun 6, 2005
DT: FRONT LOADED CALIPERS ARE NOT WORKING PROPERLY. INBOARD PADS ARE WORN AT 100 PERCENT, AND THE OUTBOARD ARE WORN AT 50 PERCENT.TIRES WERE SQUEAKING WHEN BRAKES WERE APPLIED, AND THEN A CONSTANT SQUEEK WHILE DRIVING. CONTINUED DRIVING MAKES IT WORSE. CALLER IS CONCERNED ABOUT NOT GETTING A WARNING LIGHT TO TELL HER SHE HAS A PROBLEM. CALLER WAS TOLD A WARNING LIGHT WILL NOT COME ON FOR THE BRAKE PADS BEING WORN. IF CALIPER IS NOT FIXED THE PADS WILL BE WORN AT SAME RATE. TIRES PLUS TOLD HER THIS. DEALER TOLD CALLER THEY NEVER HEARD OF CALIPERS CAUSING BRAKE PAD PROBLEMS. MANUFACTURER HAS NOT BEEN CONTACTED YET. *AK
Suspension, Service brakes, Hydraulic, May 27, 2005
DT: IN AUGUST 2004 CONSUMER HAD RIGHT AND LEFT WHEEL BEARING AND HUB ASSEMBLIES REPLACED. NOW THE ABS ACTIVATES AT LOW SPEEDS. THIS HAPPENS ALL THE TIME. NOW CONSUMER IS TOLD BY THE DEALER THAT THE RIGHT WHEEL BEARING AND HUB ASSEMBLY NEEDS TO BE REPLACED AGAIN. MANUFACTURER WAS CALLED AND THEY SAID THE PART THEY PUT IN LAST AUGUST WAS UNDER A 12 MONTH OR 12000 MILE WARRANTY AND CONSUMER HAD TO PAY TO HAVE THE PROBLEM FIXED. *TT
Service brakes, Hydraulic, May 6, 2005
DC: HIS BRAKES DO NOT WORK CORRECTLY. WHEN YOU STOP THE ABS SYSTEM KICKS IN, THE PEDAL JERKS BACK AND FORTH. THE VEHICLE DOES NOT WANT TO STOP CORRECTLY. *AK
Service brakes, Hydraulic, Apr 8, 2005
I JUST BOUGHT A USED MALIBU LS 2002. THREE DAYS LATER MY ABS BRAKE LIGHT COMES ON AFTER I HEAR SOME VIBRATING NOISE WHILE DRIVING. I HAVE TAKEN IT TO THE DEALER AND HE SAYS THERE IS NO PROBLEM. NOW EVERYTIME I START UP MY CAR AFTER 5 MINUTES THE ABS LIGHT COMES ON.*AK
Service brakes, Hydraulic, Dec 22, 2004
MY 2002 CHEVY MALIBU (3 YRS OLD, JUST OUR OF FACTORY WARRANTY) WITH 33,000 MILES HAD THE FRONT LEFT BRAKE SEIZE UP. I LIMPED IT TO THE DEALER, HALF A MILE AWAY FROM MY HOUSE. BY THE TIME I GOT THERE, THE FRONT LEFT BRAKES WERE SMOKING. I WAS TOLD THAT THE CALIPER SEIZED UP BECAUSE THE PADS WERE TOO WORN. ALSO THAT THE PADS ON THE LEFT WERE WORN ALSO. THE CHEVY DEALER SAID I NEEDED TO HAVE ROTORS TURNED ON BOTH WHEELS, CALIPERS REPLACED ON BOTH WHEELS, AND NEW PADS & CALIPER BOLTS. TOTAL COST $784 NOT COVERED BY THE EXTENDED WARRANTY THAT I PAID $1250 FOR WHEN I BOUGHT THE CAR. THE WEAR INDICATORS GAVE VERY LITTLE WARNING THAT THE BRAKES WERE WARN. I HAD THE BRAKES INSPECTED A YEAR AGO (9000 MILES AGO) AND WAS TOLD THEY WERE FINE. I CAN UNDERSTAND TURNING THE ROTORS. I EXPECT TO PAY FOR PADS. BUT REPLACING THE CALIPERS ON BOTH WHEELS? DID I JUST GET TAKEN FOR A RIDE BY MY CHEVY DEALER? I HAVE SEEN LOTS OF REPORTS ABOUT PREMATURE BRAKE WEAR ON MALIBU. WHAT ARE MY OPTIONS? I HAVE ALREADY PAID FOR THE REPAIR. *JB
Service brakes, Hydraulic, Sep 28, 2004
WHILE APPLYING THE BRAKES PEDAL WENT TO THE FLOOR. A LOUD GRINDING NOISE WAS HEARD COMING FROM THE FRONT. DRIVER TOOK VEHICLE TO DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THAT BRAKE PADS AND ROTORSA NEEDED TO BE REPLACED. *AK
Service brakes, Hydraulic, Equipment, Aug 31, 2004
WHEN THE BRAKES WERE APPLIED, THE BRAKE PEDAL PULSATED, WHICH CAUSED THE CONSUMER TO EXPERIENCE EXTENDED STOPPING DISTANCE. THE CONSUMER TOOK THE VEHICLE TO THE DEALER FOR INSPECTION AND THE MECHANIC DETERMINED THAT THE BRAKE CALIPER FAILED. *AK THE RADIO WAS INOPERATIVE. *SC *JB
Service brakes, Hydraulic, Jul 20, 2004
WHEN THE BRAKES WERE APPLIED, THE STEERING WHEEL VIBRATED HARD. THE VEHICLE IS NOW ON IT'S THIRD REPAIR FOR BRAKE ROTORS. PLEASE PROVIDE DETAILS. *JB
Service brakes, Hydraulic, Jul 13, 2004
BRAKES 2001 MALIBU CHEV. 35,000 MILES BRAKES AND ROTORS REPLACED 4 TIMES. *LA