2003 Chevrolet Malibu
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 611 owner complaints filed for this model year. This is the 16th highest complaint count among 26 Malibu model years with reports.
Of the 2003 reports, 37 involved a crash and 4 involved a fire. 26 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000 on NHTSA.gov
Fuel system, other, storage, tank assembly, pressure relief devicesMar 12, 2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000 on NHTSA.gov
Vehicle speed control, accelerator pedalNov 1, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IN HOT AMBIENT CONDITIONS, THE ACCELERATOR PEDAL ARM MAY STICK AT THE ATTACHMENT TO THE BRACKET AND NOT RETURN TO THE ENGINE IDLE POSITION WHEN THE OPERATOR LIFTS HIS FOOT FROM THE ACCELERATOR PEDAL.
FAILURE TO RETURN TO IDLE COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE ACCELERATOR PEDAL ARM AND REPLACE THE ACCELERATOR AND BRAKE PEDAL ASSEMBLY WITH A NEW ASSEMBLY, IF NECESSARY. THE RECALL BEGAN ON DECEMBER 20, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Campaign 04V528000 on NHTSA.gov
Representative owner complaints: electrical system
309 reports, newest first. Show all
Electrical system, Exterior lighting, Equipment, Jul 13, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND THE KEY WOULD NOT EJECT FROM THE IGNITION. THE DEALER REPAIRED THE VEHICLE ACCORDING TO A RECALL FOR THE IGNITION SWITCH, BUT THE FAILURE RECURRED. THE CONTACT ALSO STATED THAT THE BRAKE LIGHTS FAILED TO ILLUMINATE AND THE AIR CONDITIONER DID NOT FUNCTION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE NHTSA CAMPAIGN NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 33,345.
Electrical system, Jul 8, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE ANTI-THEFT WARNING LIGHT ILLUMINATED WHEN THE IGNITION KEY WAS TURNED TO START THE VEHICLE. THE CONTACT ALSO STATED THAT THE KEY FAILED TO TURN AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC ON SEVERAL OCCASIONS BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 47,000.
Electrical system, Fuel/propulsion system, Jul 6, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE ANTI-THEFT SYSTEM LIGHT ILLUMINATED AND THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE FUEL PUMP WAS REPLACED. THE FAILURE RECURRED AND THE VEHICLE WAS TOWED TO THE MECHANIC. THE TECHNICIAN ASSESSED THAT THE FUEL PUMP WAS WORKING UP TO SPECIFICATIONS AND DETERMINED THAT THE ANTI-THEFT SYSTEM CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 138,000.
Electrical system, Jun 24, 2015
FIRST TIME INCIDENT OCCURRED WAS 6/18/15, TWICE ON 6/23/2015 AND ONCE ON 6/24/15. THEFT SYSTEM CAUSED CAR NOT TO START; PERFORMED TROUBLE SHOOTING METHOD ACCORDING TO OWNER'S MANUAL (LEAVING KEY IN IGNITION ON POSITION WAIT 10 MINUTES FOR THE THEFT SYSTEM TO STOP BLINKING, TURN KEY IN IGNITION TO OFF THEN RESTART) WHICH DOESN'T INDICATE FURTHER ACTION TO TAKE IF PROBLEM PERSISTS. TOOK IT TO RYAN CHEVROLET DEALER IN MONROE, LA ON 6/24/15 WHERE SERVICE ADVISOR TRAVIS STUART SAID 125.00 DIAGNOSTIC CHARGE HAS TO BE PAID TO FIND OUT THE PROBLEM WHICH I'VE ALREADY INDICATED WHAT IT WAS AND WAS UNABLE TO FIX THE ISSUE WHICH IS AN URGENT SAFETY CONCERN BECAUSE ACCORDING TO HIM THE DEALERSHIP WAS BEHIND AND BACKUP IN REPAIRS. HE SCHEDULED FOR ME TO COME IN FOR 6/26/15 AT 8AM WHICH TRAVIS STATED WAS THE EARLIEST APPOINTMENT AVAILABILITY HE HAD. SPOKE TO CHEVROLET.COM LIVE CHAT CUSTOMER CARE REPRESENTATIVE ALEXANDRIA ON 6/24/15 SHORTLY AFTER 9PM AND STATED TO HER THE PROBLEM ALONG WITH WHAT THE DEALERSHIP TOLD ME. ALEXANDRIA TOLD ME THAT THERE WERE NO RECALLS FOR THIS TYPE OF ISSUE REGARDING 2003 CHEVY MALIBU, OWNER'S MANUAL IS JUST A STEPPING STONE AS A GUIDELINE, VEHICLE IS OVER 10 YRS OLD SO IT IS NO LONGER UNDER WARRANTY AND REPAIRS HAVE TO MADE AT MY OWN EXPENSE WITH NO TYPE OF REIMBURSEMENT TO THE CUSTOMER. I WAS NOT AWARE THIS VEHICLE WAS A RECALL UNTIL I WENT TO THE DMV TO GET IT REGISTERED IS WHERE I WAS INFORMED REGARDING THIS PARTICULAR MAKE/MODEL OF THIS VEHICLE. I SHOULDN'T HAVE TO PAY FOR SOMETHING THAT IS AN MANUFACTURER DEFECT GM IS KNOWINGLY AWARE OF INDICATED IN THEIR OWNER'S MANUAL NOR I SHOULD BE HELD ACCOUNTABLE FOR SOMETHING THROUGH NO FAULT OF MY OWN. I AM FEARFUL OF DRIVING THIS VEHICLE TO WORK OR SCHOOL PUTTING MY LIFE AT RISK EVERYDAY.
Electrical system, Air bags, Jun 3, 2015, crash
2003 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL, STEERING AND AIRBAG MALFUNCTIONS. *SMD THE CONSUMER WAS INVOLVED IN AN ACCIDENT ON MAY 19, 2011. SHE LOST CONTROL OF THE STEERING WHICH SENT THE VEHICLE IN THE OPPOSITE LANE HITTING ANOTHER CAR. HER VEHICLE WENT OUT OF CONTROL AND ENDED UP GOING BACKWARDS INTO A SIGN AND THEN HITTING TWO PARKED VEHICLES IN A PARKING LOT. THE AIR BAG DID NOT DEPLOY UNTIL AFTER SHE HIT THE SIGN. THE CONSUMER STATED SHE WAS UNAWARE THERE WAS A PROBLEM WITH IGNITION SWITCH. SHE STATED SHE HAD SEVERAL KEYS ON HER RING AT THE TIME OF THE ACCIDENT. *JB
Power train, Electrical system, May 28, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE WOULD ONLY START WHEN IN NEUTRAL. IN ADDITION, THE KEY WAS ABLE TO EJECT FROM THE IGNITION WHILE THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURE. NO REPAIRS WERE MADE TO THE VEHICLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 22,000.
Electrical system, May 8, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE STARTING THE VEHICLE, THE THEFT PASSLOCK SENSOR AND THE IGNITION LOCK CYLINDER LIGHTS ILLUMINATED AND THE VEHICLE WOULD NOT START. THE VEHICLE WAS ABLE TO START AFTER TEN MINUTES OF HOLDING THE KEY IN THE IGNITION AND RESTARTING THE VEHICLE. THE FAILURE RECURRED APPROXIMATELY 15 TIMES. THE VEHICLE WAS TAKEN THE DEALER WHERE IT WAS CONFIRMED THAT THE THEFT PASSLOCK SYSTEM MALFUNCTIONED AND THE REMEDY WAS TO REPLACE THE IGNITION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.
Electrical system, Apr 30, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING VARIOUS SPEEDS, THE SECURITY SYSTEM ACTIVATED AND THE VEHICLE SHUT OFF. THE VEHICLE HAD TO BE TOWED TO A DEALER. THE FAILURE MILEAGE WAS UNKNOWN.
Electrical system, Apr 30, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE REPAIR FOR NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM) WAS PERFORMED; HOWEVER, THE KEY DOES NOT RELEASE FROM THE IGNITION. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO INSPECTED THE IGNITION SWITCH AND ADVISED THAT THE IGNITION CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 178,808.
Electrical system, Apr 29, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHEN ATTEMPTING TO START THE VEHICLE, THE IGNITION KEY FAILED TO TURN INTO ANY POSITION. THE VEHICLE WAS TOWED TO THE DEALER, BUT WAS NOT REPAIRED. IN 2013, THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM); HOWEVER, THE REMEDY WAS INSUFFICIENT. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 118,285.
Electrical system, Apr 13, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED. IN ADDITION, THE CHECK ENGINE LIGHT, POWER STEERING, TRACTION CONTROL, AND AIR BAG WARNING LIGHTS ILLUMINATED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PRECIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V40000 (ELECTRICAL SYSTEM); HOWEVER, THE RECALL REMEDY FAILED TO REPAIR THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 119,000.
Electrical system, Mar 17, 2015
2003 CHEVROLET MONTE CARLO. CONSUMER WRITES IN REGARDS TO UNSATISFACTORY RECALL REPAIR WORK AT DEALERSHIP. *SMD THE CONSUMER STATED THE IGNITION DEFECT STILL EXISTS. *JB
Electrical system, Mar 13, 2015
FIRST OF ALL THE CAR HAS NEVER BEEN IN A WRECK.THE IGNITION SWITCH AND ELECTRICAL SWITCH WAS REPLACED BY OWNERS AT THEIR EXPENSE .THE IGNITION STARTED TO NOT WORK.WHEN THE KEY WAS TURNED ALL GAUGES WOULD FALL AND WOULD NOT CRANK.WHILE ON ROAD THE CAR WOULD SHUT OFF AS IF TURNED OFF BY KEY..THE OWNER DECIDED TO HAVE CAR REPAIRED BEFORE THE RECALL ,,IN 2012 AND 2013.OWNER WOULD LIKE TO KNOW IF THERE IS OR CAN BE A REFUND OF A PORTION OF COSTS TO HIM,HE HAS THE INVOICES OF WORK ON DONE CAR.THANK YOU VERY MUCH FOR YOUR TIME. *TR
Electrical system, Mar 9, 2015
THERE WAS NO ACCIDENT. TOOK VEHICLE IN FOR SAFETY RECALL 14350 UNINTENDED IGNITION KEY ROTATION. THE SWITCH IS STILL EXACTLY AS IT WAS BEFORE, NO RESISTANCE BETWEEN KEY POSITION 1(OFF) AND KEY POSITION 2(RUN). THERE IS NO DIFFERENCE IN THE FEEL OF THE SWITCH KEY ROTATION. DON'T FEEL RECALL PROBLEM WAS RESOLVED. THOUGHT THIS WAS WORTH A NOTE TO NHTSA SINCE GM IS SAYING RECALLS COST 4.1B. *TR
Electrical system, Engine, Mar 4, 2015
THE CAR WAS BEING DRIVEN AND THE ENGINE SUDDENLY SHUT OFF. FORTUNATELY THE CAR WAS BEING DRIVEN THROUGH A PARKING LOT AT THE TIME RATHER THAN ON A ROADWAY. THIS EVENING THE CAR WOULDN'T START AT ALL. MY PERSONAL MECHANIC HAS ALREADY ADVISED THAT THERE IS AN IGNITION PROBLEM. HOWEVER NEITHER GM OR THE CHEVY DEALERSHIP WILL FIX THE ISSUE. THEY INSIST ON CHARGING FOR A SECOND DIAGNOSTIC EVEN THOUGH WE'VE ALREADY PD SOMEONE ELSE FOR A DIAGNOSIS. *TR
Electrical system, Mar 3, 2015
TL*THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH, THE LEFT TURN SIGNAL STAYED ILLUMINATED. THE VEHICLE WAS RESTARTED AND THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BCM MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 104,364. UPDATED 04/07/15*LJ UPDATED 11/4/2015*JS
Power train, Electrical system, Feb 26, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE SHIFT LEVER FAILED TO SHIFT INTO PARK LEAVING THE VEHICLE IN THE ACCESSORY MODE, WHICH WOULD DRAIN THE BATTERY. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE SHIFTER LINKAGE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
Steering, Electrical system, Feb 25, 2015
WAS NOT ABLE TO GET KEYS OUT OF THE IGNITION SWITCH. THE KEYS WOULD STICK, AND I WAS NOT ABLE TO REMOVE THE KEYS. TOOK IT TO A CHEVROLET DEALERSHIP, AND THEY HAD TO REPLACE THE SHIFTER AND KNOB ASSEMBLY. I AM THE ORIGINAL OWNER OF THE VEHICLE AND USED THE ORIGINAL KEYS. FURTHERMORE, THIS CAR HAD LOW MILEAGE, 56,040 MILES, FOR A SEVEN YEAR OLD CAR, AND WAS BARELY DRIVEN TO HAVE TO HAVE SUCH A SERIOUS REPAIR. I SEE THAT THERE IS SOME KIND OF TECHNICAL BULLETIN FOR THIS ISSUE, BUT CHEVROLET SHOULD HAVE PAID FOR THE REPAIR INSTEAD OF CHARGING ME THE $346.56 TO REPAIR A KNOWN ISSUE THAT SHOULD HAVE BEEN RECALLED. I HAVE HAD SO MUCH TROUBLE WITH MY 2003 CHEVROLET MALIBU THAT I WOULD NEVER PURCHASE A CHEVROLET OR GM PRODUCT EVER AGAIN. MOST OF THE ISSUES THAT I SEE IN THE SERVICE BULLETINS ARE ISSUES THAT I HAVE ALSO HAD. AFTER FINDING THIS WEBSITE, I HOPE TO LET OTHER CHEVROLET MALIBU OWNERS KNOW OF THE POTENTIAL PROBLEMS THAT CAN OCCUR WITH THEIR VEHICLES, AND ALSO HOPE THAT ONE DAY, SOMETHING CAN BE DONE TO MAKE CHEVROLET LIABLE FOR ALL THESE ISSUES. *JS
Electrical system, Feb 23, 2015
TL*THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 14V400000 (ELECTRICAL SYSTEM) HOWEVER, THE FAILURE PERSISTED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,200.
Electrical system, Feb 18, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE ANTI-THEFT SYSTEM PREVENTED THE VEHICLE FROM STARTING. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 147,727.
Electrical system, Feb 9, 2015
2003 CHEVROLET MALIBU CLASSIC. CONSUMER GOT CAR FIXED DUE TO RECALL OF IGNITION PROBLEMS. REQUESTING REIMBURSEMENT. *TA THE CONSUMER WAS DENIED REIMBURSEMENT, BECAUSE THE REPAIR WAS NOT DONE BY A GM DEALER. THE IGNITION LOCK CYLINDER WAS REPLACED. THE CONSUMER STATED THE NEAREST DEALER WAS 40 MILES AWAY. *JB
Suspension, Fuel system, Gasoline, Electrical system, Feb 9, 2015
2003 CHEVROLET MALIBU FAULTY IGNITION SWITCH VEHICLE SHUT OFF IN THE MIDDLE OF THE ROAD. *MW THE CONSUMER STATED SHE HAD TO REPLACE THE IGNITION SWITCH ON TWO DIFFERENT OCCASIONS. THE FIRST TIME WAS SEPTEMBER 28, 2006 AND THE SECOND TIME WAS JUNE 3, 3014. AFTER THE SECOND SWITCH WAS INSTALLED, THE CONSUMER EXPERIENCED OTHER PROBLEMS. SHE WAS INFORMED THE VEHICLE NEEDED A BODY CONTROL MODULE AND LOCK SWITCHES. THE DEALER INSTALLED A CHIP IN THE KEYS, WHICH DID NOT CORRECT THE IGNITION PROBLEM. THE FRONT STRUTS WERE REPLACED AND THE FUEL PUMP NEEDED TO BE REPLACED. *JB
Electrical system, Feb 6, 2015
TL*THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN ID NUMBER: 14V400000 (ELECTRICAL SYSTEM) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Electrical system, Engine, Feb 6, 2015
TL*THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE SERVICE ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE CONTACT MENTIONED THAT THE CRUISE CONTROL FUNCTIONED INTERMITTENTLY AS THE INSTRUMENT PANEL GAUGES AND SENSORS FLASHED SEVERAL TIMES. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 79,000.
Electrical system, Jan 30, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT A PIECE OF CLOTHING BECAME CAUGHT IN THE IGNITION KEY WHILE DRIVING 30 MPH. THE IGNITION KEY THEN HAPHAZARDLY RELEASED FROM THE IGNITION SWITCH BUT THE VEHICLE CONTINUED TO DRIVE NORMALLY WITHOUT THE KEY BEING IN THE IGNITION SWITCH. THE CONTACT REINSERTED THE KEY WHILE THE VEHICLE WAS STILL POWERED ON AND RUNNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000. UPDATED 04/13/15*LJ UPDATED 9/20/2017*CN