2003 Chevrolet Malibu
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 611 owner complaints filed for this model year. This is the 16th highest complaint count among 26 Malibu model years with reports.
Of the 2003 reports, 37 involved a crash and 4 involved a fire. 26 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000 on NHTSA.gov
Fuel system, other, storage, tank assembly, pressure relief devicesMar 12, 2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000 on NHTSA.gov
Vehicle speed control, accelerator pedalNov 1, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IN HOT AMBIENT CONDITIONS, THE ACCELERATOR PEDAL ARM MAY STICK AT THE ATTACHMENT TO THE BRACKET AND NOT RETURN TO THE ENGINE IDLE POSITION WHEN THE OPERATOR LIFTS HIS FOOT FROM THE ACCELERATOR PEDAL.
FAILURE TO RETURN TO IDLE COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE ACCELERATOR PEDAL ARM AND REPLACE THE ACCELERATOR AND BRAKE PEDAL ASSEMBLY WITH A NEW ASSEMBLY, IF NECESSARY. THE RECALL BEGAN ON DECEMBER 20, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Campaign 04V528000 on NHTSA.gov
Representative owner complaints: service brakes
63 reports, newest first. Show all
Service brakes, Feb 11, 2021
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE HIS WIFE WAS DRIVING 25 MPH AND APPROACHING A RED TRAFFIC LIGHT, THE BRAKE PEDAL WAS DEPRESSED HOWEVER, THE VEHICLE CONTINUED TO ACCELERATE. THE VEHICLE WENT THROUGH THE INTERSECTION. THE CONTACT'S WIFE PLACED THE VEHICLE IN NEUTRAL, ALLOWING THE VEHICLE TO SLOW DOWN AND EVENTUALLY STOP. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 52,481.
Service brakes, May 14, 2018
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING 25-30 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE VEHICLE CAME TO A STOP AFTER AN EXTENDED PERIOD OF TIME. AFTER THE VEHICLE WAS PARKED OVERNIGHT, THE CONTACT NOTICED EXCESSIVE BRAKE FLUID LEAKING UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE BRAKE LINES WERE RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000. THE VIN WAS NOT AVAILABLE.
Electrical system, Service brakes, Aug 24, 2017
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE BRAKE SYSTEM FAILED. WHILE THE BRAKE PEDAL WAS DEPRESSED, THE BRAKE SYSTEM FAILED TO ENGAGE AND THE VEHICLE VIBRATED. THE CONTACT HAD TO ENGAGE THE EMERGENCY BRAKE TO BRING THE VEHICLE TO A STOP. THE CONTACT ALSO MENTIONED THAT THE KEY HAD TO BE RELEASED FROM THE IGNITION WITH FORCE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND STATED THAT THERE WERE NO OPEN RECALLS. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 37,000.
Structure, Service brakes, Jan 11, 2016
100% OF BRAKE LINES FAILED VIA RUST ALSO, CONTROL ARMS FRONT/REAR SEVERELY RUSTED.
Steering, Service brakes, Engine, Aug 12, 2015
THIS HAS HAPPENED FIVE TIMES NOW, I AM DRIVING AND THE ENGINE JUST SHUTS OFF, I CAN NOT BRAKE I CAN NOT STEER, I STILL HAVE LIGHTS ON THE DASHBOARD. IT HAPPENS WHEN I AM GONG ABOUT 20 TO ABOUT 35 MILES PER HOUR. I AM AFRAID TO DRIVE ON THE HIGHWAY. I DO NOT KNOW IF IT WILL HAPPEN AT A HIGHER SPEED! IT DID IT THE FIRST TIME BACK IN JUNE 2015 MY DAUGHTER WAS DRIVING, THEN AGAIN LAST FRIDAY AUGUST 7TH FOUR MORE TIMES WITH IN 10MINUTES AND A FEW MILES APART. IT IS LIKE SOMEONE JUST TURNED THE CAR OFF WHILE I AM DRIVING?
Power train, Vehicle speed control, Service brakes, Jun 18, 2015
COMPUTER PROBLEM 2003 CHEVY IMPALA 6 CYL FRONT WHEEL DRIVE AUTOMATIC 130000 MILES THIS RECENTLY STARTED, THE TRACTION ON LIGHT AND THE ABS YELLOW LIGHTS ON DASH STAY ON. RARELY DO THEY GO OFF, ONLY A FEW TIMES. THE SQUARE INDICATOR LIGHT SAYS "SERVICE TRACTION CONTROL" LIGHT COMES ON WHEN I START THE VEHICLE, STAYS ON FOR 1-2 MINUTES THEN GOES OFF. BUT THE TRACTION CONTROL LIGHT AND THE ABS LIGHT REMAINS ON. HOW CAN I RESET THIS OR WHAT TO NOT HAVE A TRIP TO THE EXPENSIVE AUTO REPAIR SHOP. I HAVE NO PROBLEM WITH THE ABS BRAKES TO OPERATE CORRECTLY, NO DELAYS OR BRAKE HESITATION WHEN I PRESS THE BRAKE PEDAL IN USE. HELP ME OUT WITH A GOOD SOLUTION. I WILL GREATLY APPRECIATE YOUR RESPONSE.
Steering, Service brakes, Engine, Feb 25, 2015
CAR WILL NOT START. SOLID "THEFT" LIGHT COMES ON DASHBOARD AND CAR WILL NOT TURN OVER, OR IF IT TURNS OVER, WILL CUT OUT SHORTLY AFTER. THIS ANTI-THEFT ISSUE CAUSES THE POWER STEERING AND BRAKES TO DISABLE, AND AM NOT ABLE TO TURN THE STEERING WHEEL. HAVE ALSO HAD CAR STALL OUT IN TRAFFIC AND LOSE ALL POWER. HAD TO HAVE CAR TOWED SEVERAL TIMES DUE TO THE ISSUE. I HAVE TRIED SEVERAL FIXES AND MECHANICAL REPAIRS, BUT THIS ISSUE CONTINUES TO GET WORSE. NO MATTER WHAT I TRY AND DO, AT RANDOM TIMES, MY CAR WILL NOT START, WHILE THE "THEFT" LIGHT COMES ON AND COMPLETELY DISABLES MY VEHICLE. AND SOMETIMES WHILE DRIVING, THE CAR JUST SHUTS OFF. I AM THE ORIGINAL OWNER OF THE VEHICLE, AND AM USING AN ORIGINAL KEY TO START THE CAR. I DO NOT HAVE ANY TYPE OF SECURITY SYSTEM INSTALLED IN MY CAR. THERE IS NO REASON FOR THE "THEFT" LIGHT TO COME ON WHEN I AM JUST TRYING TO START MY VEHICLE, NOT STEAL IT. THE IGNITION RECALL FOR MY SPECIFIC VEHICLE ONLY INVOLVES REPLACING THE KEYS, BUT THIS ANTI-THEFT ISSUE, WHICH I AND OTHER CHEVROLET MALIBU OWNERS ARE EXPERIENCING, IS A SERIOUS SAFETY ISSUE THAT COULD CAUSE A CRASH OR OTHER ACCIDENT TO OCCUR IF IT CAUSES THE CAR TO CUT OUT (LOSE POWER) FOR NO REASON WHILE DRIVING, AND AT THE SAME TIME DISABLING THE STEERING AND BRAKING SYSTEMS. THIS SHOULD DEFINITELY BE A SAFETY RECALL. *JS
Steering, Electrical system, Service brakes, Jan 22, 2015
THE CAR SHUT OFF WITH NO WARNING WHILE DRIVING ON THE ROAD. THIS WAS A TOTAL SHUT-DOWN OF THE CAR; INCLUDING THE LOSS OF POWER STEERING AND THE FUNCTIONALITY OF THE BRAKE BOOSTER. THE CAR AFTERWARDS BECOMES DIFFICULT TO START. IT MAY TAKE SEVERAL TRIES OR A PROLONGED WAITING PERIOD UNTIL THE CAR WILL WANT TO START. AFTER IT DOES START THERE'S NO TELLING IF IT WILL SHUT OFF AGAIN WHILE DRIVING. IT HAS SHUT OFF WHILE GOING THROUGH TURNS, AND PULLING OUT INTO TRAFFIC. *TR
Suspension, Fuel system, Gasoline, Electrical system, Service brakes, Dec 12, 2014
I TELL DEALER CHECK ENGINE LIGHT ON "HE SAYS NOT TO BE CONCERNED THERE IS WHITE SMOKE COMING FROM TAILPIPE IGNITION CAN TAKE UP TO 5 MIN TO GET ON CODE SAYS CAR NEEDS EGR VALVE CAR NEEDED BRAKES AND ROTORS ALL THE WAY AROUND AND TYROD DEALER WILL NOT RESPOND TO CALLS CAR WAS RECALLED FOR IGNITION SWITCH NEVER REPAIRED I NEED TO KNOW IF I CAN TAKE IT IN TO CHEVY DEALER ONY HAD 1 MONTH VEHICLE IS NOT SAFE AND I AM 76 THERE IS A WARANTY ON ENGINE AND TRANSMISSION. *TR
Suspension, Service brakes, Hydraulic, Electrical system, Oct 23, 2014
2003 CHEVROLET MALIBU. CONSUMER STATES VEHICLE STALLS. *TGW THE CONSUMER STATED THE FUEL PUMP, BATTERY AND REMOTE CONTROL WERE ALL REPLACED. HOWEVER, THE STALLING CONTINUED. THE IGNITION SWITCH WAS EVENTUALLY REPLACED. ALSO, T HE BRAKES AND STRUTS NEEDED TO BE REPLACED. *JB
Service brakes, Sep 29, 2014
I WAS DRIVING NEAR MY HOME WHEN A TURKEY RAN OUT IN FRONT OF MY VEHICLE FROM THE LEFT. I WAS LOOKING TO THE RIGHT AS I APPROACHED MY DRIVEWAY. I SAW THE TURKEY OUT OF THE CORNER OF MY EYE AND I STEPPED HARD ON MY BRAKES BECAUSE I WAS UNABLE TO IMMEDIATELY IDENTIFY THE ANIMAL. MY BRAKE PEDAL WENT STRAIGHT TO THE FLOOR AND, AFTER STOPPING COMPLETELY, I DISCOVERED THAT MY DRIVER SIDE BRAKE LINE HAD RUPTURED. I TOOK THE VEHICLE TO A REPAIR SHOP AND WAS INFORMED THAT ALL OF MY BRAKE LINES NEEDED TO BE REPLACED. I WAS TOLD THAT THIS BRAKE LINE FAILURE OCCURRED BECAUSE THE LINES WERE SUSCEPTIBLE TO CORROSION CAUSED BY ROAD SALT. *TR
Service brakes, Engine, Sep 19, 2014, crash
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING VARIOUS SPEEDS, THE ENGINE RPMS SUDDENLY INCREASED AND THE DRIVER WAS UNABLE TO APPLY THE BRAKES. THE DRIVER HAD TO CRASH INTO A CURB IN ORDER TO STOP THE VEHICLE. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.
Vehicle speed control, Service brakes, Apr 14, 2014, crash
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH, THE BRAKES FAILED WITHOUT WARNING. THE VEHICLE CONTINUED TO ACCELERATE WHILE THE BRAKES WERE APPLIED, CAUSING THE CONTACT TO CRASH INTO ANOTHER VEHICLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 29,332. UPADATED 06/24/14 MA UPDATED 06/30/2014 *JS
Electrical system, Exterior lighting, Service brakes, Jul 26, 2013
WHEN IT RAINS THE TAIL LIGHTS FILL UP WITH WATER AND THE LIGHTS DO NOT WORK CORRECTLY. AND SOMETIMES THEY DO NOT WORK AT ALL. IT HOLDS WATER AND THE LIGHTS FLASH IN A CHRISTMAS TREE LIGHT MANNER. ALSO WHEN THE BREAKS ARE STEPPED ON THE BLINKERS DO NOT WORK. ALSO WHEN YOU STEP ON THE BREAK THE BLINKER INDICATORS ON THE INSTRUMENT PANEL REMAIN LIT UP GREEN. I HAVE REPLACE BULBS AS WELL AS THE WHOLE LIGHT HOUSING. EVEN DRILLED WHOLES IN THE BOTTOM OF THE LIGHT HOUSING UNITS SO THE WATER CAN DRAINED. NOTHING CAN REMEDY THIS PROBLEM IT IS VERY DANGEROUS. *TR
Vehicle speed control, Service brakes, Engine, Jul 21, 2013
AFTER MY 2003 CHEVROLET MALIBU HAD BEEN PARKED IN THE SUN FOR A WHILE, ON A SHORT TRIP OF 4 MILES, THE CAR STARTED REVVING UP AND TAKING OFF ON IT'S ON. IT ALSO CAUSED MY A/C HOSE TO BURST (I AM CONVINCED IT IS RELATED). I TOOK IT TO DEALER FOR REPAIR AND THEY CLEANED THE THROTTLE AND REPLACED THE A/C HOSE. THERE IS STILL THE SAME PROBLEM. IT SEEMS AS THOUGH IT HAPPENS WHEN IT IS VERY HOT WEATHER AND I AM MAKING SHORT TRIPS RUNNING ERRANDS WHICH CALLS FOR TURNING ENGINE OFF AND RESTARTING. I DROVE BACK HOME WITH MY FOOT ENTIRELY ON THE BRAKES WHILE TRYING TO KEEP THE CAR FROM RUNNING OUT OF CONTROL. I AM VERY RELUCTANT TO DRIVE IT NOW, UNTIL I CAN FIND SOMEONE TO "REALLY" FIX THE PROBLEM (AS I WAS STUCK WITH A $487 REPAIR BILL). *TR
Service brakes, Hydraulic, Feb 25, 2012
THE BRAKES DEVELOPED POOR BRAKING AT SPEEDS OVER 35 MPH THE FRONT END WOULD SHIMMY WHEN APPLIED. TWICE REPLACING THE BRAKE PADS AND RESURFACING OF THE ROTORS FAILED TO CORRECT THE PROBLEM. REPLACEMENT OF THE FRONT DISK ROTORS THAT WOULD NOT WRAP WITH USE CORRECTED THE PROBLEM GM FAILED TO COVER THE REPAIRS UNDER WARRANTY. *TR
Service brakes, Hydraulic, Feb 15, 2011
TL*THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 10 MPH, THE CONTACT STATED THAT HE APPLIED PRESSURE TO THE BRAKES; HOWEVER, HE RECEIVED NO RESPONSE. THE BRAKES WOULD MAKE A SQUISHING NOISE WHEN PRESSURE WAS APPLIED, AS IF AIR WAS ESCAPING. THE MANUFACTURER INFORMED THE CONTACT THAT THEY WOULD REVIEW HIS COMPLAINT AND HE WAS WAITING FOR A RESPONSE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 69,000.
Service brakes, Hydraulic, Air bags, Vehicle speed control, Jun 12, 2008, crash
TL*THE CONTACT OWNS A 2003 CHEVROLET MALIBU. ON MAY 25, 2008, WHILE DRIVING 40 MPH, THE VEHICLE BEGAN ACCELERATING FASTER THAN NORMAL. THE CONTACT HAD TO MERGE OUT OF TRAFFIC. SHE COULD NOT FEEL THE BRAKES WORKING AND SPED THROUGH A STOP SIGN. SHE DROVE INTO A PARKING LOT TO AVOID CRASHING INTO OTHER VEHICLES. THE VEHICLE FINALLY STOPPED WHEN IT CRASHED INTO AN EMBANKMENT. THE FRONT DRIVER'S SIDE AIR BAG FAILED TO DEPLOY. THE VEHICLE WAS TAKEN TO THE BODY SHOP TO REPLACE THE DRIVER'S SIDE DOOR AND HEADLAMP. THE MANUFACTURER STATED THAT AN INVESTIGATOR WOULD INVESTIGATE THE FAILURE. THEY ARE CURRENTLY STATING THAT DUE TO THE BODY WORK THAT WAS PERFORMED ON THE VEHICLE, THEY WILL NOT INVESTIGATE THE ACCELERATION FAILURE, ONLY THE AIR BAG FAILURE. THE CONTACT HAS A BACK INJURY THAT WAS AGGRAVATED DUE TO THE CRASH. A POLICE REPORT WAS FILED. THE FAILURE AND CURRENT MILEAGES WERE 24,000.
Service brakes, Air, Wheels, Jun 2, 2008
I HAD TO REPLACE THE BRAKES ON THIS CAR AT 6,000 MILES. SINCE THEN, I HAVE HAD TO REPLACE THEM ON A YEARLY OCCURRENCE, AS WELL AS ROTORS AND WHEEL BEARINGS. THE BREAKS ALWAYS SOUND LIKE THEY ARE GRINDING AND VIBRATING. I HAVE HAD ISSUES WITH THE ABS LIGHT COMING ON. IT HAS BEEN 7 MONTHS SINCE I HAD THE ROTORS REPLACED, AND I NEED NEW BREAKS AGAIN. *TR
Service brakes, Hydraulic, Jul 7, 2006
I BOUGHT MY MALIBU NEW IN SEPTEMBER 2003. IN JANUARY 2005, I BEGAN TO NOTICE THE CAR SHUDDERING WHILE BRAKING, I TOOK THE CAR IN AND THEY MACHINED BOTH ROTORS, I TOOK IT IN AGAIN ON FEBRUARY 8TH BECAUSE THE BRAKES WERE MAKING A CHATTER AND CLANK SOUND, THEY TOLD ME THE CALIPERS NEEDED TO BE LUBRICATED, I BROUGHT IT BACK ON FEBRUARY 18 FOR THE LUBRICATION. NEXT I TOOK THE CAR IN FOR A OIL CHANGE ON MARCH 29TH AND ASKED THE TECHNICIAN TO CHECK THE BRAKES AND WAS TOLD THEY WERE FINE. ON JULY 1ST 05 I TOOK THE CAR IN AGAIN BECAUSE OF A BRAKE SQUEAL AND FOUND THE RETAINING BOLT /PIN ON THE LEFT FRONT CALIPER WAS MISSING. IT WAS REPLACED AS WELL AS THE BOLT/PIN ON THE UPPER BOLT/PIN DUE TO THE INTEGRITY OF THE ORIGINAL BOLT/PIN. ON SEPTEMBER 30TH 05 I TOOK THE CAR IN AGAIN FOR BRAKE NOISE, AND WAS TOLD THAT BOTH ROTORS WERE RUSTED, BOTH ROTORS WERE TURNED AND CLEANED AT THAT TIME. ON OCTOBER 12TH 05 WHICH WAS ONLY 8 DAYS LATER I TOOK THE CAR BACK AGAIN BECAUSE THE CAR WAS STILL MAKING A GRINDING NOISE. WHEN INSPECTED THE FRONT ROTORS WERE AGAIN FOUND TO BE RUSTY, PITTED AND WORN, THIS TIME THEY REPLACED BOTH THE ROTORS AND THE BRAKE PADS. I TOOK THE CAR IN ON NOVEMBER 23RD 05 FOR RECOMMENDED 15 MAX SERVICE WHICH INCLUDED A REAR BRAKE ADJUSTMENT, I ASKED THEM TO CHECK THE FRONT BRAKES AGAIN, BECAUSE THEY WERE STILL SQUEAKING AND THEY SAID THEY WERE FINE. MAY 25TH,06 I TOOK THE CAR IN AGAIN FOR BRAKE NOISE, THEY FIRST TOLD ME THE CALIPERS AGAIN NEEDED TO BE LUBRICATED , BUT THEN CAME BACK AND SAID THEY NEEDED TO BE REPLACED. NOW IT IS JULY OF 06 AND I AM STILL HAVING PROBLEMS WITH THE BRAKES. ALSO ON JULY 5TH, 06 I HAD TO TAKE THE CAR IN BECAUSE THE A/C AND THE RECIRCULATION MODE STOPPED WORKING, THEY REPLACED A BAD HVAC CONTROL MODULE. *NM
Service brakes, Hydraulic, Jan 27, 2006
DT*: THE CONTACT STATED THE ABS WARNING LIGHT ILLUMINATED AND THE DEALERSHIP REPLACED THE DRIVER SIDE WHEEL SPEED SENSOR. SIX MONTHS LATER, THE ABS WARNING LIGHT ILLUMINATED AGAIN, THE DEALERSHIP DETERMINED THE PASSENGER SIDE WHEEL SPEED SENSOR NEEDS TO BE REPLACED. UPDATE 2/24/2006 - THE CONSUMER PREVIOUS VEHICLE, A 2000 CHEVROLET MALIBU, ALSO HAD THE SAME BRAKE WHEEL SPEED SENSOR FAILURE. *NM
Service brakes, Hydraulic, Nov 23, 2005
2003 CHEVY MALIBU HAS HAD RECURRING BRAKE PROBLEMS FOR THE LAST 10,000 MILES IT HAS 33,000 MILES . BRAKES WOULD GRAB AND VIBRATE THE FRONT END. FINALLY WAS TOLD THAT IT NEEDED NEW ROTORS AND PADS, IT IS DRIVEN ON A REGULAR BASIS AND FROM ALL THE OTHER BRAKE COMPLAINTS I READ ABOUT THIS NEEDS TO BE INVESTIGATED. *JB
Service brakes, Hydraulic, Aug 30, 2005
ANTI -LOCK BRAKE LIGHT (ABS) IS ON AND THE ABS SOMETIMES ACTIVATES WHEN THE USING THE BRAKES AT A SLOW SPEED. *JB
Service brakes, Hydraulic, Aug 30, 2005, crash
FRONT BRAKE/ROTOR/CALIPER FAILURE. I HAVE HAD MY ROTORS, FRONT PADS AND CALIPERS REPLACED NUMEROUS TIMES ROTORS 4 TIMES, CALIPERS 4 TIMES AND FRONT PADS 16 TIMES DUE TO FAULTY DESIGN, THE CALIPERS HANG UP AND DO NOT RELEASE ALL THE WAY CAUSING THE INNER PADS TO WEAR ABNORMALLY. *NM
Service brakes, Hydraulic, Aug 18, 2005
BRAKES (ROTORS AND FRONT PADS) KEEP NEEDING TO BE REPLACE. FIRST AT 14,000 MILES AND THEN AGAIN AT 28,000 MILES. THE FIRST TIME THEY WERE REPLACED UNDER THE 36,000 MILE WARRANTY, BUT THE SECOND TIME THE DEALER REFUSED TO DO IT UNDER THE WARRANTY AND WANTED $500 FOR JOB. DEALER FIRST SAID THE REAR BRAKES WERE NOT ADJUSTED BUT WOULDN'T BLAME THE SELF ADJUSTERS THAT SHOULD KEEP THEM ADJUSTED. THEN THEY SAID THAT IT WAS MY DRIVING HABITS, REFUSING TO REFER TO ALL THE OTHER COMPLAINTS ABOUT MALIBU'S BRAKES AND THE FACT THAT NONE OF MY OTHER CARS HAVE EVER HAD BRAKES WERE OUT SO SOON. NOW THEY SAY IT IS "NORMAL" FOR MALIBU BRAKES TO WEAR OUT AFTER 14,000 MILES AND AGAIN THEY WON'T COVER THEM UNDER WARRANTY. BRAKES DO NOT WEAR OUT AFTER 14,000 MILES. *JB