2003 Chevrolet Malibu
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 611 owner complaints filed for this model year. This is the 16th highest complaint count among 26 Malibu model years with reports.
Of the 2003 reports, 37 involved a crash and 4 involved a fire. 26 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000 on NHTSA.gov
Fuel system, other, storage, tank assembly, pressure relief devicesMar 12, 2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000 on NHTSA.gov
Vehicle speed control, accelerator pedalNov 1, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IN HOT AMBIENT CONDITIONS, THE ACCELERATOR PEDAL ARM MAY STICK AT THE ATTACHMENT TO THE BRACKET AND NOT RETURN TO THE ENGINE IDLE POSITION WHEN THE OPERATOR LIFTS HIS FOOT FROM THE ACCELERATOR PEDAL.
FAILURE TO RETURN TO IDLE COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE ACCELERATOR PEDAL ARM AND REPLACE THE ACCELERATOR AND BRAKE PEDAL ASSEMBLY WITH A NEW ASSEMBLY, IF NECESSARY. THE RECALL BEGAN ON DECEMBER 20, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Campaign 04V528000 on NHTSA.gov
Representative owner complaints
611 reports, newest first.
Electrical system, Nov 5, 2007
SPEEDOMETER OF 2003 CHEVY TAHOE, STOPPED WORKING ON THE FREEWAY. I HAD NO WAY O MAKING SURE WHAT MY SPEED WAS. I WAS STOPPED BY A POLICE OFFICER AND EXPLAINED MY SITUATION. THE OFFICER LOOKED AT MY SPEEDOMETER THAT WAY SHOWING 60 MPH AT A DEAD STOP. HE GAVE ME A WARNING AND TOLD ME TO GET IT FIXED. *TR
Electrical system, Nov 1, 2007
WE HAVE A 2003 CHEVY TAHOE AND THE SPEEDOMETER STOPPED WORKING AROUND 50,000 MILES. CHEVY HAS SENT NO RECALL NOTICE AND I HAVE NO IDEA HOW FAST OR SLOW I AM GOING. *TR
Exterior lighting, Oct 31, 2007
HAZARD FLASHER RELAY/SWITCH "SOUNDS OFF" AFTER THE TURN SIGNAL SWITCH IS RETURNED TO THE REST POSITION AFTER SIGNALING A RIGHT OR LEFT HAND TURN, THIS CLICKING SOUND ALSO HAPPENS WHEN THE STEERING WHEEL IS ADJUSTED AND WHILE I AM DRIVING DOWN THE ROAD ALL BY IT'S SELF. THE HAZARD AND TURN SIGNALS DO NOT LIGHT, ONLY THE AGGRAVATING CLICKING SOUND CAN BE HEARD. I CAN ALSO MAKE THE HAZARD/SIGNAL RELAY/SWITCH CLICK BY WIGGLING THE TURN SIGNAL INDICATOR SWITCH. I HAD THE HAZARD SWITCH REPLACED AT THE DEALER BUT THE PROBLEM PERSISTS. I HAVE THE HAZARD/FLASHER RELAY/SWITCH AVAILABLE FOR INSPECTION. *TR
Engine and engine cooling, Oct 12, 2007
TL*THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE DRIVING 30 MPH FOR APPROXIMATELY TEN MINUTES, THE TEMPERATURE GAUGE DISPLAYED HOT. THE COOLANT LIGHT ILLUMINATED, WHICH INDICATED THAT THE COOLANT LEVEL WAS LOW. THE CONTACT STOPPED THE VEHICLE AND CHECKED THE LEVEL. HE THEN TOOK THE VEHICLE TO CARMAX AND THEY CONFIRMED THAT THE LOWER INTAKE MANIFOLD GASKET CAUSED THE FAILURE. THE FAILURE WAS REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 45,000. UPDATED 12/12/07 *BF
Electrical system, Exterior lighting, Air bags, Oct 9, 2007
I HAVE A 2003 MALIBU SEDAN, AND THE ALARM/HORN HAS A DEFECT. LAST YEAR WE HAD A HIGH POWER WIND STORM AND MY ALARM BLEW FOR ABOUT 45 MINUTES (2 HORNS). THEY FINALLY DIED DOWN BY THEMSELVES. MY CAR WAS NOT HIT BY ANYTHING EXCEPT FOR THE HIGH WINDS. I HAD TO TAKE FUSE #43 OUT TO MAKE THE HORN STOP BLOWING EVERY TIME I STARTED MY CAR. MY CAR NEED TO PASS INSPECTION, BUT THE DEALERSHIP WANT TO CHARGE ME $95.00 AN HOUR, TO DO AN EXPLORATORY DEAL ON THE CAR, TO LOCATE THE PROBLEM. ANOTHER CAR REPAIR COMPANY TOLD ME THE COST WOULD BE $900.00, BUT COULD NOT JUSTIFY, WHAT THEY WERE GOING TO DO. THEY STATED IT COULD BE THE TURN SIGNAL OR IT COULD BE THE FUSE UNDER MY AIR BAG ON THE STEERING WHEEL. NO ONE CAN ACTUALLY EXPLAIN TO ME WHAT'S WRONG, BUT THEY WANT TO CHARGE THE HECK OUT OF ME. I DO NOT HAVE THAT TYPE OF MONEY FOR EXPLORATORY EXAMINATIONS ON MY CAR. I AM QUITE SURE THE MANUFACTURER KNOW WHAT THE PROBLEM IS WITH THIS MALIBU, AND CAN FIX IT WITHOUT A PROBLEM. I CAN NOT AFFORD THIS, I WAS NOT TOLD THE CAR HAD TWO RECALLS ON IT WHEN I BROUGHT THE CAR. I FEEL THIS IS VERY WRONG, I WOULD HAVE NEVER PURCHASE THE CAR, IF I KNEW OF RECALL PROBLEMS. NOW I AM STUCK IN THE MIDDLE WITHOUT A HORN/ALARM SYSTEM. SINCE THE DEALERSHIP WANTED TO GO INTO MY STEERING WHEEL TO CHECK THE FUSE FOR $95.00 AN HOUR, MY AIR BAG LIGHT COMES ON. *TR
Electrical system, Sep 21, 2007
PASSLOCK ANTI-THEFT SYSTEM ENGAGED WITH NO IDENTIFIABLE CAUSE. USING ORIGINAL KEY AND NO TAMPERING OCCURRED PRIOR TO PROBLEM. THEFT SYSTEM LIGHT WENT ON RANDOMLY 3 WEEKS AGO, BUT WAS ON ONLY FOR A FEW MINUTES AND NEVER ON AGAIN PRIOR TO THIS NO-START. ABLE TO RE-SET THE SYSTEM, ACCORDING TO THE MANUAL, BY WAITING 10 MINUTES FOR THE COMPUTER TO RE-SET, BUT THIS IS NOT ACCEPTABLE WHEN PARKED IN CERTAIN AREAS (MALLS DURING THE EVENING, ETC). HAPPENS FREQUENTLY ENOUGH THAT IT GETS TO BE VERY INCONVENIENT, AND IN NEED OF REPAIR. REPAIR CAN ONLY BE DONE AT A GM DEALER - WHICH IS VERY PROFITABLE FOR THE DEALER. *TR
Engine and engine cooling, Sep 14, 2007
COOLANT IS LEAKING, MECHANIC SAID IT IS OUR LOWER INTAKE MANIFOLD GASKET THAT HAS FAILED. ALSO HE SAYS TO FLUSH OUT THE DEX COOL BECAUSE IT IS A HORRIBLE COOLANT. *TR
Suspension, Vehicle speed control, Sep 13, 2007
2003 CHEVY MALIBU ACCELERATES ON ITS OWN. CUSTOMER STATES THAT THE CAR WOULD DRIVE ON ITS OWN WITHOUT PUTTING HER FOOT ON THE ACCELERATOR. **NAR**KB THE CONSUMER RECEIVED A RECALL NOTICE IN THE MAIL WHICH STATED THE ACCELERATOR PEDAL WOULD BE INSPECTED ONLY. AFTER HAVING CONTINUAL PROBLEMS WITH THE VEHICLE ACCELERATING ON IT S OWN, THE CONSUMER TOOK THE VEHICLE TO THE DEALER WHERE IT WAS DETERMINED THAT THE ACCELERATOR PEDAL HAD AN INTERNAL MALFUNCTION. THE CONSUMER IS SEEKING REIMBURSEMENT. THE CONSUMER ALSO COMPLAINED OF A RATTLE NOISE COMING FROM THE VEHICLE WHEN GOING OVER BUMPS. THE DEALER INSPECTED THE VEHICLE AND FOUND THE LEFT FRONT STRUT AND MOUNT WERE WORN. THE LEFT SIDE LOWER CONTROL ARM WAS NOISY. *JB
Electrical system, Exterior lighting, Sep 13, 2007
CAR WOULD NOT START SO HAD IT TOWED TO THE SHOP THEY SAID COMPUTER SAID NOTHING WAS WRONG AND IT STARTED FOR THEM. THEY SAID MAYBE A WEAK FUEL PUMP. DROVE IT FOR A WEEK AND SAME THING HAPPENED. HAD IT TOWED TO THE SHOP AGAIN AND THEY REPLACED THE FUEL PUMP. DROVE IT FOR 2 DAYS AND SAME THING. NOW THEY SAID IT WAS THE ANTITHEFT THE WHOLE TIME. OUT OF POCKET TOTAL EXPENSE WAS $1300.00. THERE SHOULD BE RECALLS ON THIS STUPID THING I WENT TO START MY CAR AND IT WOULD NOT TURN OVER SO I HAD TO HAVE IT TOWED TO THE DEALERSHIP AND THEY TOLD ME IT WOULD BE $650 TO FIX THE IGNITION SWITCH. IN THE MEAN TIME THE CAR IS NOW RUNNING BECAUSE THE DEALERSHIP TOLD ME THEY "RESET" THE COMPUTER. I TOLD THEM I WOULD TAKE MY CHANCES WITH IT AND DROVE OFF AFTER PAYING THE $85 DIAGNOSTIC CHARGE. WELL 2 WEEKS LATER IT DOES NOT START AGAIN. I CALL AAA AND THE TOW COMES OUT AND THE DRIVER TELLS ME IT'S THE ANTI-THEFT DEVICE, WAIT 10 MINUTES AND THE CAR WILL START. LOW IN BEHOLD IT WORKED. SO WHY DIDN'T THE DEALERSHIP TELL ME THIS IS THE PROBLEM. FUNNY THEY TOLD ME THE "RESET" COULD LAST 3 WEEKS, A YEAR, OR FOREVER... BUT THEY STILL WANTED TO MILK ME FOR $650. SO I DO A GOOGLE ON THIS AND FIND I AM NOT THE ONLY ONE WITH THE PROBLEM. WHAT THE HELL IS WRONG WITH GM IF THEY KNOW THIS PROBLEM EXIST AND DON'T FIX THE PROBLEM WITH A RECALL OR A FIX! I WILL NEVER BUY A GM CAR AGAIN!!!
Engine and engine cooling, Aug 19, 2007
I HAVE A 2003 CHEVY MALIBU, THE COOLANT STARTED TO SLOWLY LEAK OUT, THEN PROCEEDED TO LEAK FASTER WITHIN A FEW WEEKS, WE COULDN'T SEE WHERE THE COOLANT WAS GOING. I CALLED MY OLDER BROTHER EVERY WEEKEND, AND HIS 2001 PONTIAC GRAND PRIX WAS IN THE SHOP GETTING A NEW ENGINE INSTALLED, HIS GRAND PRIX, AND MY CHEVY MALIBU HAVE THE SAME ENGINE, I ASKED WHAT HAPPENED, AND HE SAID THAT HIS COOLANT STARTED LEAKING, HE COULDN'T SEE WHERE IT WAS GOING SO HE TOOK IT INTO THE SHOP, AND THE MECHANIC TOLD HIM THAT A COMMON PROBLEM WITH THESE VEHICLES MADE BY GM WAS THAT THE LOWER INTAKE MANIFOLD GASKET IS FAULTY. I HAVE LOOKED IT UP ON LINE,AND THERE IS A CLASS ACTION LAW SUIT IN CANADA AGAINST GM FOR THIS PROBLEM, AS WELL MANY PEOPLE SAY (INCLUDING MY MECHANIC) THAT THE DEX COOL IS VERY BAD FOR YOU VEHICLE. ANYWAY, MY BROTHER GOT HIS CAR TO THE MECHANIC TOO LATE, AND AFTER SHELLING OUT 700 TO FIX THE LOWER INTAKE MANIFOLD GASKET, HE ENDED UP HAVING TO PAY 5900 TO REPLACE HIS 2001 GRAND PRIX ENGINE. AS IT TURNS OUT MY MALIBU HAD THE SAME PROBLEM WITH THE LOWER INTAKE MANIFOLD GASKET, WE HAVE YET TO REPLACE IT, IT IS WORTHLESS, THE MECHANIC WHO IS CHEVY CERTIFIED, SAID THAT THE COOLANT HAS GOTTEN INTO OUR OIL, AND THE ENGINE IS WORTHLESS, WE DON'T HAVE THE 5900 TO SHELL OUT FOR A NEW ENGINE. I HAVE CONTACTED GM TWICE, THE FIRST TIME I TALKED TO A REPRESENTATIVE ON THE PHONE, AND HE SAID THAT HE DOESN'T KNOW WHY THEY ARE NOT RECALLING THE GASKET, IT IS A KNOWN PROBLEM, BUT THEY AREN'T GOING TO RECALL IT, THE SECOND TIME I TALKED TO THEM THEY TOLD ME THAT THEY WILL NOT DISCUSS THE MATTER WITH ME ANY FURTHER. I AM A SINGLE MOM WITH THREE KIDS, AND A FULL TIME JOB, AND FULL TIME SCHOOL, I HAVE A CAR THAT WHEN I BOUGHT IT THE SALESMAN TALKED ME INTO, HE TOLD ME "A MALIBU WILL LAST YOU A VERY LONG TIME," AS IT SITS IN MY PARKING LOT WHILE I AM LEFT RIDING THE BUS, AND MAKING PAYMENTS ON A CAR THAT DOES NOT RUN, DUE TO A PROBLEM THAT GM KNOWS ABOUT. *JB
Electrical system, Aug 14, 2007
MY CAR WOULD NOT START. I THOUGHT IT WAS THE BATTERY. THE BATTERY WAS FINE. I TOOK IT TO THE DEALERSHIP AND THEY SAID MY PASSLOCK SENSOR FAILED. TO REPLACE IT WAS $1200. I DON'T EVEN HAVE AN ALARM ON MY CAR JUST THE FACTORY INSTALLED THEFT SYSTEM. I FEEL IT IS A DEFECT WITH THE CAR MANUFACTURER, NOTHING I DID TO THE CAR. *TR
Electrical system, Aug 8, 2007
ANTI-THEFT SYSTEM KEEPS SHUTTING DOWN THE CAR. *TR
Engine and engine cooling, Jul 31, 2007
MY FIANCE AND I BOUGHT A 2003 CHEVY IMPALA IN NOV OF 2006 WITH ONLY 40,000 MILES. IN JULY OF 2007, THE CAR WAS STARTED AND SHUT OFF BY ITSELF A FEW MINUTES LATER. IT WOULD THEN NOT START. WE FIRST HAD IT TOWED TO A LOCAL SHOP THAT INFORMED US THAT THE UPPER INTAKE MANIFOLD HAD CRACKED. IT LEAKED ANTIFREEZE INTO THE CYLINDERS, THE SPARK PLUGS AND OTHER PARTS OF THE ENGINE AND THE COST FOR REPAIR WOULD BE 1400.00. WE HAD THE CAR TOWED TO A 2ND SHOP FOR A 2ND OPINION. THEY TOLD US THAT THE ANTIFREEZE THAT LEAKED HAD TOTALLY LOCKED UP THE ENGINE AND WE NEEDED A WHOLE NEW ONE. THAT WAS GOING TO COST US AT LEAST 2,000 FOR A USED ONE. WE THAN DECIDED THAT A 4 YEAR OLD CAR WITH 60K MILES ON IT SHOULD NOT BE IN NEED OF A NEW ENGINE SO WE AGAIN HAD IT TOWED TO A CHEVROLET DEALER REPAIR SHOP. THEY TOLD US THE SAME THING. THE CAR WAS OFFICIALLY IN NEED OF A WHOLE NEW ENGINE. WE CONTACTED CHEVROLET'S CUSTOMER CARE DEPT AND THEY ARE SO FAR UNWILLING TO HELP. WE'VE ONLY HAD THE CAR 8-9 MONTHS AND ARE CONTINUING TO MAKE PAYMENTS ON THE LOAN. PER THE DEALER, THE USED ENGINE WILL COST US 3000.00 AND A NEW ONE WILL COST IS 5050.00. *JB
Electrical system, Jul 29, 2007
MY DAUGHTER DROVE MY CAR TO WORK. IT WOULD NOT START AFTER A TRIP TO MALL. SHE WAS LEFT STRANDED DUE TO A CHEVROLET MALIBU DEFECTIVE ANTI-THEFT SYSTEM. MY CAR HAD TO BE TOWED IN A STRANGE CITY, AND IT IS STILL THERE. THE MAJOR CONSEQUENCE OF THIS BREAKDOWN IS THAT A 19 YEAR OLD GIRL WAS LEFT VULNERABLE IN A MALL PARKING LOT. IS IT A SAFETY HAZARD THAT COULD AFFECT HER? I THINK SO. I AM FEELING VULNERABLE BECAUSE MY VEHICLE IS NO LONGER 'SAFE' TO DRIVE. HAS THIS ISSUE BEEN INVESTIGATED BY THE NHTSA? WHAT WAS THE OUTCOME? WHY DOES GM FEEL THIS IS NOT AN ISSUE? A PATTERN OF BREAKDOWN HAS BEEN ESTABLISHED, AND A SOLUTION, WHETHER MONETARY OR IN REPAIR, SHOULD BE OFFERED. WILL IT TAKE SOMEONE BEING INJURED FROM A SECOND- HAND INCIDENT AS A RESULT OF 'EQUIPMENT FAILURE' TO MAKE GM NOTICE? THERE WAS NO PRIOR WARNING WITH THIS 'SHUTDOWN' OF THE CAR. AS A MOTHER, I CANNOT LET MY CHILDREN TAKE THIS CAR ON THE HIGHWAY. IN GOOD FAITH I PURCHASED THIS CAR, EXPECTING A RELIABLE MODE OF TRANSPORTATION. THIS WAS SUPPOSED TO BE A KID-CAR FOR COLLEGE THIS YEAR. HOW CAN WE SEND OUR CHILD OFF AND ALWAYS WONDER IF A CALL WILL COME IN FROM HER THAT SHE IS STRANDED ON A DESERTED ROAD THAT SHE HAS TO TRAVEL TO GET TO SCHOOL?AAA SHOULD BE FURIOUS ABOUT THE MAGNITUDE OF CALLS FOR DESIGN FAILURE ON THIS VEHICLE. THERE IS A MORAL ISSUE HERE, AND I BELIEVE THAT GM IS NOT INTERESTED IN THE 'HUMAN' FACTOR OF CAR SALES. THE RIGHT THING TO DO WOULD BE TO FIGURE OUT THE PROBLEM, ADDRESS IT AND FIX IT LIKE THE GOOD OLD DAYS OF CUSTOMER SERVICE USED TO BE AND MOVE ON. I WOULD BE WILLING TO PAY FOR THE REPAIR IN ORDER TO HAVE A RELIABLE CAR AGAIN. I AM NOW WORRYING THAT MY 2001 MALIBU WITH ANOTHER DAUGHTER OUT OF STATE WILL HAVE THE SAME PROBLEMS. A CAR THAT COULD NOT START ON A WHIM DOES NOT OFFER PEACE OF MIND TO ME. DO THE EXECUTIVES AT GM DRIVE CHEVROLET MALIBUS? WOULD THEY LET THEIR CHILDREN DRIVE A CAR LIKE MINE? PS. WHY DON'T YOU LIST 'WEBSITE' UNDER THE REFERRAL SOURCES? *TR
Electrical system, Jul 29, 2007
MY CAR STALLED ON MY DAUGHTER AND I, RECENTLY TOOK MY CAR TO THE DEALER BECAUSE MY THEFT SYSTEM LIGHT CAME ON EVERY ONCE AND A WHILE HAD TO PAY $115.00 JUST TO PUT ON THE MACHINE AND THEY TOLD ME THAT MY IGNITION SWITCH HAVE TO BE REPLACED AT A TUNE OF $515.00 PLUS TAX, WELL MY CAR STOPPED ON MY DAUGHTER AND I HAD TO PUSH IT ON THE SIDE OF THE ROAD. HAD THE BATTERY REPLACED AND STILL WOULD NOT START. I'M TIRED THEY'RE SHOULD BE A RECALL ON THIS MODEL(2003 MALIBU). *TR
Electrical system, Jul 28, 2007
WHEN DOING 60 MPH THE SPEEDOMETER NEEDLE READS OVER A 100 MPH. YOU HAVE TO STOP AND START THE ENGINE SEVERAL TIMES TO GET IT RESET TO 0 MPH. I SPENT 2 WEEKS RESEARCHING THIS AND IT IS A VERY COMMON PROBLEM WITH 2003 CHEVY TAHOE. *TR
Electrical system, Jul 22, 2007
GOT IN MY CAR, PUT MY KEY IN THE IGNITION AND TURNED IT TO THE START POSITION. THE VEHICLE WOULD NOT START. THE ANTI-THEFT LIGHT CAME ON. I TRIED THE PROCEDURE FROM THE MANUAL TO CORRECT THE PROBLEM, AND IT DID NOT WORK. IT'S A 2003 CHEVY MALIBU. *JB
Electrical system, Jul 15, 2007
I OWN A 2003 CHEVROLET MALIBU WITH 47000 MILES EVERY COUPLE OF DAYS THE ANTI THEFT SYSTEM LIGHT COMES ON WHILE IM DRIVING. I CALLED THE DEALERS AND EXPLAINED WHAT HAPPENED, AND THEY STATED THAT THEY HAVE TO PUT IT ON THE MACHINE AND IT WAS GOING TO COST ME $105.00 JUST TO PUT IT ON THE MACHINE. I WA S UPSET BECAUSE I BOUGHT THIS CAR BRAND NEW, AND I ONLY HAVE 47,000 MILES ON IT. VEHICLE SHOULD NOT BE HAVING THIS PROBLEM THIS EARLY. I HAVE READ COMPLAITS ON THIS VEHICLE, AND THERE SHOULD BE A RECALL FOR THE 2003 MALIBU BECAUSE THIS SHOULD NOT BE HAPPENING. ALSO, SOMETIMES THE CAR WILL NOT START. SO I READ IN THE OWNERS MANUAL THAT YOU HAVE TO WAIT 10 MINUTES TO TRY TO RESTART THE CAR . THIS DID NOT MAKE ANY SENSE. THERE SHOULD BE A RECALL ON THIS VEHICLE. *AK
Fuel system, Gasoline, Jun 18, 2007
MY COMPLAINT IS ABOUT CHEVROLET, CAVALIER 2003. THE CAR JUST QUIT WHILE DRIVING, THANK GOD I WAS ONLY ONE ON ROAD. THE CAR ONLY HAD 57,000 MILES ON IT, AND I HAVE BEEN KEEPING UP WITH MAINTENANCE SCHEDULE; SUCH AS OIL CHANGES, TRANSMISSION FLUIDS, FILTERS, ETC. AFTER BEING TOWED TO THE CHEVROLET DEALERSHIP AND WAITING TO SEE WHAT THE PROBLEM WAS IT WAS DETERMINED TO BE A BAD FUEL PUMP. THIS COASTED ME $721.29, WHICH WAS VERY UNEXPECTED. WHAT AMAZED ME EVEN MORE WAS MANY MORE HAD SAME PROBLEM ONCE I SEARCHED IT ONLINE. TAKE A LOOK AT THIS WEBSITE. TP://WWW.TOPIX.NET/FORUM/AUTOS/CHEVROLET-CAVALIER/TVINIC5TFU5SFSI5H I FOLLOWED ANOTHER FORUM POSTERS RESPONSE AND CAME HERE TO LET MY EXPERIENCE BE HEARD. *AK
Electrical system, Jun 17, 2007
I DROVE THE CAR HOME FROM A FRIEND'S HOUSE ABOUT 3 MILES TURNED IT OFF AND LOCKED IT USING THE REMOTE. WHEN I TRIED STARTING THE CAR ABOUT AN HOUR LATER , AFTER UNLOCKING IT USING THE REMOTE), THE CAR WOULD NOT START. IT SOUNDED LIKE IT WANTED TO START BUT JUST COULDN'T TURN OVER. LUCKILY, I HAVE A MECHANIC IN THE FAMILY THAT SUGGESTED A PROBLEM WITH THE ANTI-THEFT SYSTEM. THE PROBLEM WAS SOLVED BY TURNING THE KEY TO THE ON POSITION FOR ABOUT 10 MINUTES TO RESET THE SYSTEM. AS A RESULT I ENDED UP MISSING A VERY IMPORTANT MEETING. EVERY NOW AND THEN THE THEFT SYSTEM LIGHT ON DASHBOARD POPPED ON AND THEN EVENTUALLY WENT AWAY. I DIDN'T ALWAYS HAVE 10 EXTRA MINUTES TO SPARE JUST IN CASE THE CAR DECIDED TO DO THIS. *AK
Suspension, Jun 13, 2007
WHEEL HUB BEARINGS - SINCE I BOUGHT THE 2003 MALIBU NEW IN JANUARY 203 I HAD TO REPLACE THE WHEEL HUB BEARING 4 TIMES, ONCE UNDER WARRANTY WITH GM PARTS AT 27,918 ON 4/20/04 RIGHT SIDE), AGAIN RIGHT SIDE WITH AFTER MARKET PARTS AT 47,876, LEFT SIDE WITH AFTER MARKET PARTS AT 48,769 ON 5/3/05, AND RIGHT SIDE WITH AFTER MARKET PARTS AT 83,197 ON 4/17/07. WITH SO MANY FAILURES I BELIEVED THEREWAS EITHER AN INHERIT DESIGN FLAW OR POSSIBLE LATENT DEFECT OF THE FRONT END.*AK
Electrical system, Jun 13, 2007
CAR FAILED TO START ON RANDOM OCCASIONS. BECAME MORE FREQUENT. ANTI-THEFT SYSTEM WAS CAUSING IT NOT TO START. WOULD HAVE TO WAIT FOR TEN MINUTES TO START - IN PLACES LIKE AT A GAS PUMP WITH OTHERS WAITING TO USE IT. THEFT SYSTEM LIGHT WOULD OCCASIONALLY STAY ON EVEN WHEN IT STARTED. IT BECAME LIKE PLAYING RUSSIAN ROULETTE HOPING THE CAR WOULD START AND HOPING AGAINST HOPE THAT THE CAR WOULD NEVER STALL IN TRAFFIC AND THEN NOT RE-START. DEALER FINALLY HAD TO REPLACE THE IGNITION SWITCH, IGNITION CYLINDER AND LOCK CYLINDER TO THE TUNE OF $682.00. THIS WAS DONE AT 71,190 MILES. THE IGNITION SWITCH AND IGNITION CYLINDER WERE ALREADY REPLACED AT 46,000 MILES. OTHERS I HAVE SPOKEN TO HAVE HAD THE SAME PROBLEM WITH THIS YEAR'S MODEL OF THE MALIBU BUT THEY NEVER RECALLED IT. THE THEFT SYSTEM IS OBVIOUSLY DEFECTIVE.*AK
Equipment, Jun 10, 2007
CAR FAILS TO START CRANKS AND NO STARTS TOOK IT TO DEALER AND PROMISE NOTHING SPEND ALMOST 1000.00 DOLLARS AND IT DID IT AGAIN TODAY
Vehicle speed control, Jun 4, 2007
TL*THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING BETWEEN 30-50 MPH, THE ACCELERATOR PEDAL STICKS. THE CONTACT MUST APPLY THE BRAKES AND ATTEMPT TO REACH DOWN AND PULL THE ACCELERATOR PEDAL UP MANUALLY. THE CONTACT STATED THAT THE FAILURE BEGAN ON MAY 30, 2005 AND THERE IS SAFETY RECALL # 04V528000 (VEHICLE SPEED CONTROL:ACCELERATOR PEDAL) ON THE VEHICLE. SHE CALLED A DEALER THAT SOLD GM CARS BUT WAS NOT ACTUALLY A GM DEALER AND INFORMED HER THAT THE RECALL WAS CLOSED. THE CONSUMER HEARD SO MANY NEGATIVE THINGS ABOUT THAT SPECIFIC DEALER THAT REPAIRS WERE DONE AT ANOTHER LOCATION. THE CONTACT STATED THAT HER ACCELERATOR PEDAL HAD BEEN INSPECTED MONTHS EARLIER. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 65,000 AND FAILURE MILEAGE WAS 52,000. THE CONSUMER STATED THE VEHICLE WAS TAKEN TO A CHEVROLET DEALER WHO FIXED THE VEHICLE VIA THE RECALL IMMEDIATELY AT NO CHARGE. UPDATED 07/24/07 *TR
Tires, Jun 4, 2007
TL*THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE VEHICLE HAS FIRESTONE AFFINITY TOURING TIRES, SIZE P215-60R15. THE REAR DRIVER SIDE TIRE HAD A NAIL IN IT AND IT WAS REPAIRED. HE WAS INFORMED THAT THE TIRE HAD TREAD SEPARATION AND COULD NOT BE REPAIRED. THE DOT NUMBER WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 17,800.