2004 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,697 owner complaints filed for this model year. This is the highest complaint count among 26 Malibu model years with reports.
Of the 2004 reports, 81 involved a crash and 15 involved a fire. 55 people were injured.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 19, 2004
SOME OF THESE PASSENGER VEHICLES HAVE AN ELECTRONIC CONTROL UNIT (ECU) THAT MAY CALCULATE A HIGHER THAN ACTUAL VEHICLE SPEED BECAUSE OF AN ERRATIC REAR-WHEEL SPEED SENSOR SIGNAL, AND CAUSE ABS ACTIVATION WHERE IT IS NOT NEEDED OR NEEDED ABS ACTIVATION TO BE EXTENDED DURING BRAKING AS THE VEHICLE SPEED DROPS TO ABOUT 3 MPH.
UNEXPECTED ABS ACTIVIATION COULD INCREASE STOPPING DISTANCE UP TO ABOUT 11 FEET DPENDING ON THE GRADE OF THE ROAD, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPROGRAM THE ABS CONTROLLER. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V190000 on NHTSA.gov
Seat belts, front, anchorageApr 16, 2004
ON CERTAIN PASSENGER VEHICLES, ANALYSIS OF AN A SIDE IMPACT CRASH TEST CONDUCTED BY THE NHTSA;S NEW CAR ASSESSMENT PROGRAM (NCAP) INDICATED THAT THE OUTBOARD ANCHORAGE OF THE DRIVER'S SEAT BELT COULD DISCONNECT BECAUSE OF CONTACT BETWEEN THE SEAT TRIM AND THE ANCHORAGE CONNECTOR WHEN THE SEAT WAS ADJUSTED TO ITS LOWEST POSITION.
IF THIS OCCURRED IN A CRASH, THE DRIVER COULD RECEIVE GREATER INJURIES.
DEALERS WILL INSERT A RETAINER ON BOTH THE DRIVER'S AND PASSENGER'S BELT ANCHORAGES. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V188000 on NHTSA.gov
Equipment, other, labelsFeb 24, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES THAT WERE NOT EQUIPPED WITH AN ADVANCED OCCUPANT RESTRAINT SYSTEM (AORS) HAVE DRIVER AND PASSENGER SIDE SUN VISORS WITH AORS LABELS. THE AORS LABELS DO NOT INCLUDE STATEMENTS AND THE ILLUSTRATION REQUIRED BY FMVSS NO. 208 FOR VEHICLES WITHOUT AORS.
OWNERS WILL BE SENT REPLACEMENT LABELS WITH INSTRUCTIONS ON HOW TO INSTALL THEM. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V094000 on NHTSA.gov
Representative owner complaints: electrical system
247 reports, newest first. Show all
Electrical system, Oct 12, 2016
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. WHILE OPERATING THE VEHICLE, THE INSTRUMENT PANEL LIGHTS SUDDENLY TURNED OFF AND ON. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 97,000.
Electrical system, Fuel/propulsion system, Sep 13, 2016
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING AND WAS UNABLE TO BE RESTARTED. THE SECURITY PASS LOCK AND ANTI-LOCK WARNING INDICATORS RANDOMLY FLASHED INTERMITTENTLY. THE VEHICLE BEGAN TO STALL AT RANDOM. THE VEHICLE WAS DIAGNOSED BY A MECHANIC WHO STATED THAT THE FUEL PUMP REGULATOR FAILED. THE VEHICLE WAS REPAIRED, BUT CONTINUED TO STALL. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
Electrical system, Air bags, Aug 17, 2016, crash, fire
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 23 MPH IN THE RAIN, THE VEHICLE SPUN OUT OF CONTROL AND CRASHED INTO A CEMENT BARRIER. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. TWO DAYS LATER, THE INTERIOR OF THE VEHICLE CAUGHT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT WAS FILED. THE FIRE DEPARTMENT INFORMED THE CONTACT THAT THE FIRE WAS DUE TO THE ELECTRICAL WIRING IN THE DASHBOARD. THE VEHICLE WAS NOT TOWED OR TAKEN TO THE DEALER. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 153,000.
Electrical system, Jul 25, 2016
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. AFTER THE VEHICLE WAS PARKED, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ALTERNATOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.
Electrical system, Seats, Jul 9, 2016
2004 MALIBU LT, WELD ON RT FRONT OF 6 WAY DRIVER SEAT BROKEN, SEAT MOTOR RUNS BUT CAN NOT MAKE SEAT ADJUSTMENTS. THE SEAT SAGS TO RIGHT WHEN TRYING TO MOVE FORWARD OR BACK. BUT WILL NOT MOVE FORWARD OR BACK ON THE SEAT FRAME.
Electrical system, May 21, 2016
REC'D RECALL ON IGNITION SWITCH. TOOK VEHICLE TO DEALER AND SERVICE REP TOOK 1OF MY VEHICLE KEYS, BROUGHT KEY BACK AND SAID REPAIR COMPLETES. NEVER DID HE TOUCH MY CAR. IMMEDIATELY AFTER THIS, VEHICLE WOULDN'T START. WHATEVER WAS DONE TO MY KEY THREW OFF MY ALARM SYSTEM AND LOCKED UP VEHICLE .DEALER REFUSED TO TAKE RESPONSIBILITY. CONTACTED GM AND WAS CONTACTED BACK. THEY MADE NOTE OF COMPLAINT. NOW WATCHING C CNBC AND THE IGNITION RECALL. I AM CONCERNED AS ONLY 1KEY WAS TOUCHED BY DEALER AND THAT WAS IT.
Electrical system, Mar 31, 2016
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 252,000. THE VIN WAS NOT AVAILABLE.
Electrical system, Mar 1, 2016
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. AFTER THE KEY WAS INSERTED IN THE IGNITION SWITCH, THE IGNITION SWITCH FAILED TO RESPOND. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE UNKNOWN.
Electrical system, Exterior lighting, Visibility/wiper, Feb 8, 2016
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE WINDSHIELD TRANSMISSION WIPER LINKAGE BUSHING FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT ALSO STATED THAT THE REAR PASSENGER SIDE TAIL LIGHTS FAILED. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE CONTACT ALSO STATED THAT REMOVING THE KEY FROM THE IGNITION WAS DIFFICULT AT TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OFFERED NO ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 53,000.
Electrical system, Feb 3, 2016
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STARTED THE VEHICLE AND NOTICED THAT THE IGNITION KEY PULLED OUT WHILE THE ENGINE WAS STILL RUNNING. THE CONTACT ALSO WAS ABLE TO TURN THE VEHICLE OFF WITHOUT THE KEY TURNING TO THE OFF POSITION. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT CALLED THE MANUFACTURER AND WAS ADVISED TO TAKE THE VEHICLE TO A LOCAL DEALER TO CHECK FOR RECALLS. THE VEHICLE WAS TOWED TO A DEALER WHO STATED THAT THERE WERE NO RECALLS. THE CONTACT INSISTED THAT THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 157,048.
Electrical system, Jan 27, 2016
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE KEY WOULD GET JAMMED IN THE IGNITION AND THERE WAS DIFFICULTLY SHIFTING THE VEHICLE. THE VEHICLE COULD BE SHIFTED AFTER IT WAS WARMED UP. IN ADDITION, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN BACK TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. PRIOR TO THE FAILURE, THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN). THE FAILURE MILEAGE WAS APPROXIMATELY 109,821...UPDATED 04/26/16 *BF *CN
Steering, Electrical system, Other or unspecified, Jan 6, 2016
ELECTRICAL SYSTEM:WIRING EXTERIOR LIGHTING:BRAKE LIGHTS ELECTRONIC STABILITY CONTROL SERVICE BRAKES HYDRAULIC:SWITCHES:BRAKE LIGHT STEERING:ELECTRIC POWER ASSIST SYSTEM THE BRAKE LIGHTS TO ILLUMINATE WITHOUT THE BRAKE PEDAL BEING PUSHED THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE PEDAL IS PUSHED DISABLEMENT OF CRASH AVOIDANCE FEATURES SUCH AS TRACTION CONTROL PANIC BRAKING ASSIST FEATURES. TURNING SIGNALS & BREAK LIGHTS NOT RESPONSIVE. SUDDEN LOSS OF ELECTRIC POWER STEERING ASSIST THAT HAPPENS AT ANYTIME WHILE DRIVING. PICTURES ATTACHED PUSHING BREAKS & USING TURNING SIGNALS NO RESPONSE. CAR POWER STEERING ALSO SHUTS DOWN IN THE MIDDLE OF DRIVING. CONTACTED DEALER WILL NOT PROVIDE HELP. PROBLEM HAS HAPPENED FOR THE LAST 16 MONTHS. ALMOST CRASHED 5 TIMES.
Electrical system, Dec 1, 2015
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHEN THE CONTACT ATTEMPTED TO START THE VEHICLE, THE IGNITION FAILED WHILE THE ANTI THEFT AND CHECK ENGINE LIGHT ILLUMINATED. THE FAILURE OCCURRED RANDOMLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE IGNITION CYLINDER WAS FAILING AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 145,691.
Electrical system, Oct 13, 2015
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING AT APPROXIMATELY 40 MPH, THE VEHICLE STALLED. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM) BUT THE RECALL PART WAS NOT AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 02/23/16*LJ UPDATED 4/18/18*JB
Electrical system, Sep 25, 2015
FRONT TURN SIGNALS INTERMITTEDY STOP WORKING
Electrical system, Aug 21, 2015
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE AND ANTI THEFT LIGHTS ILLUMINATED. THE VEHICLE FAILED TO START AND WAS TOWED TO AN INDEPENDENT MECHANIC. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO A DEALER, WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 152,000.
Steering, Electrical system, Aug 18, 2015
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE TURNING LEFT OR RIGHT, AN ABNORMAL NOISE EMITTED FROM THE STEERING WHEEL. THE CONTACT STATED THAT UPON TRYING TO REMOVE THE KEY FROM THE IGNITION, THE KEY HAD TO BE ADJUSTED BACK AND FORTH SEVERAL TIMES IN ORDER FOR IT TO RELEASE FROM THE IGNITION SWITCH. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V153000 (STEERING) AND 14E044000 (STEERING). THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 41,000.
Electrical system, Aug 10, 2015
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT WHILE DRIVING, THE THEFT SYSTEM WARNING LIGHT ILLUMINATED AND THE ENGINE STALLED. THE CONTACT WAS ABLE TO MANEUVER OFF THE ROAD AND SHUT THE VEHICLE OFF. THE CONTACT WAS ABLE TO RESTART THE ENGINE AFTER RESETTING THE THEFT SYSTEM. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 175,000.
Electrical system, Jul 6, 2015
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU CLASSIC. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED UNEXPECTEDLY. THE CONTACT WAS ABLE TO COAST OVER TO SIDE OF THE ROAD AND RESTART THE VEHICLE. THE DEALER DIAGNOSED THAT THE IGNITION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 210,000.
Electrical system, Jun 24, 2015
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU CLASSIC. WHEN THE IGNITION WAS TURNED TO THE ON POSITION, THE VEHICLE DID NOT START. THE CONTACT STATED THAT THE IGNITION HAD TO BE TURNED TO THE OFF POSITION THEN BACK TO THE ON POSITION IN ORDER FOR THE VEHICLE TO START. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
Electrical system, Structure, Jun 18, 2015, fire
TL* THE CONTACT OWNED A 2004 CHEVROLET MALIBU. WHILE DRIVING AT APPROXIMATELY 50 MPH, THERE WAS A BURNING ODOR COMING FROM THE VEHICLE. THE CONTACT NOTICED SMOKE COMING FROM THE REAR OF THE VEHICLE AND A DOOR CAUGHT ON FIRE. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES REPORTED. IT WAS UNKNOWN WHO EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 118,000.
Power train, Electrical system, May 27, 2015
2004 CHEVROLET MALIBU MAXX. CONSUMER WRITES IN REGARDS TO TRANSMISSION SHIFT CABLE RECALL NOTICE AND IGNITION KEY ISSUES. *SMD THE CONSUMER STATED THE DEALER WAS SUPPOSED TO FIX THE CABLE THAT CHANGED THE GEARS AND TO GET THE KEY OUT OF THE IGNITION. WHEN SHE PICKED UP THE VEHICLE, SHE ONLY HAD ONE LOW GEAR, BUT THERE WAS SUPPOSSED TO BE THREE LOW HEARS AND THE KEY WAS STILL STUCK IN THE IGNITION. *JB
Electrical system, Seats, May 26, 2015
WHILE DRIVING I5 NORTH I ADJUSTED MY ELECTRONIC FRONT SEAT FOR MORE COMFORT, AND WHEN I DID I FOUND THE SEAT MOVING CLOSER TO THE DASH BOARD, I COULDN'T STOP IT OR REVERSE IT SO I FRANTICALLY WENT FROM THE FAST LANE TO THE SHOULDER OF THE ROAD ALMOST CRASHING INTO SOMEONE. WHEN I STOPPED I FOUND MYSELF ALMOST TRAPPED BETWEEN THE STEERING WHEEL AND THE SEAT MY LEGS WERE ALMOST JAMMED INTO THE UNDERSIDE OF THE DASH BOARD AND THE ELECTRONIC SEAT NON RESPONSIVE. WHAT I FOUND OUT WAS THAT THE SWITCH HAD COME OFF THE CONTROL KNOBS AND WHEN THAT HAPPENS THE SEAT WENT ALL THE WAY FORWARD AND YOU HAVE NO CONTROL OVER IT. SOMEBODY SHOULD LOOK INTO THIS MATTER. THERE IS NO RECALLS FOR THIS BUT THERE SHOULD BE.
Power train, Electrical system, Seats, May 17, 2015
REPORTING MULTIPLE ISSUES. INCREASED PROBLEMS AFTER RECALL WORK PERFORMED..ITEMS 2 AND 3. ITEM 1 FROM THE ORIGINAL PURCHASE AND NO GM SOLUTION ON WHAT HAS BEEN A WIDE SPREAD PART QUALITY PROBLEM DOCUMENTED. DRIVERS SIDE SEAT EARLY ON FROM PURCHASE DEALER WELDED BREAK ONCE. BROKE AGAIN DRIVING WITH BROKEN SEAT NOW LEG NERVE BACK PROBLEMS. CONCERN ON SAFETY IF IN ACCIDENT A..NO RECALL WHY NO OPTION TO GET REPLACEMENT PARTS OR SEAT WHY????? WHILE DRIVING VEHICLE POWER STEERING WENT OUT REDUCED ACCELERATION DASHBOARD VARYING LIGHTS RANDOM VARIES OFF AND ON ABLE TO COAST OUT OF TRAFFIC. NO ABILITY TO RESTART. TOWED DEALER INDICATED NEED TO REPLACE GENERATOR AND BATTERY BOTH PERFORMED VEHICLE DRAINS UNABLE TO START JUMP START RUNS FAILS AGAIN LATER - NO SOLUTION PROBLEM STARTED AFTER DEALERSHIP RECALL WORK DONE ON IGNITION SWITCH RELATED TO RECALL WORK???? SITTING IN DRIVEWAY - DO WE TOW BACK TO DEALERSHIP THAT HAD US REPLACE THE GENERATOR AS AN UNNECESSARY EXPENSE??? SELECTOR MALFUNCTION NOT WORKING SERVICED NOW NO ABILITY TO USE LOW GEAR SELECTION PUSH BUTTON. STAYS ON 3 WHY AGAIN RELATED TO RECALL WORK PERFORMED??? SOME SENSATIONS OF SLIPPAGE BETWEEN GEARS AS WELL. WHY?? LIKE THE VEHICLE AND WANT IT TO BE SAFE TO DRIVE AND KEEP IN SERVICE. LOYAL GM FAMILY MEMBER THAT IS CONSIDERING CHANGING MANUFACTURERS. SATURN OWNER - NO LONGER AVAILABLE PONTIAC OWNER GRAND AM NO LONER AVAILABLE PONTIAC VIBE OWNER CHEVROLET BLAZER OWNER CHEVROLET CAMERO. CHEVROLET IMPALA OUR FAMILY LIST GOES ON. MORE DIFFICULT TO KEEP THE FAMILY LOYAL DROP DOWN BOX ON VEHICLE NEVER DISPLAYED.
Electrical system, May 6, 2015
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE KEY WAS PERMANENTLY STUCK IN THE IGNITION SWITCH AND WOULD NOT EJECT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.