2005 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,393 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 Malibu model years with reports.
Of the 2005 reports, 65 involved a crash and 45 involved a fire. 69 people were injured and 3 people died.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Representative owner complaints
1,393 reports, newest first.
Power train, Engine, Sep 24, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. IN ADDITION, AFTER STARTING THE VEHICLE THE CONTACT WAS UNABLE TO SHIFT INTO GEAR. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE TRANSMISSION SHIFT CABLE FAILED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE CONTACT ALSO INDICATED THAT THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE FUEL CAP NEEDED TO BE REPLACED. THE FUEL CAP WAS REPLACED BUT THE CHECK ENGINE WARNING LIGHT CONTINUED TO ILLUMINATE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 47,000.
Electrical system, Exterior lighting, Air bags, Sep 22, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. WHILE DRIVING 35 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE CONTACT ALSO STATED THAT BOTH TURN SIGNALS FAILED TO FUNCTION. THE FAILURES RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.
Electrical system, Sep 20, 2015
MY CHEVROLET MALIBU CLASSIC 2005 RANDOMLY DOES NOT START. IN MOST VEHICLES WHEN YOU START A VEHICLE ALL YOU NEED TO DO IS TURN THE KEY, THAT IS NOT THE CASE WITH THIS CAR, YOU FIRST HAVE TO TURN THE KEY AND LISTEN FOR THE FUEL PUMP TO ENGAGE THEN AND ONLY IF YOU HEAR THAT CAN YOU TURN THE KEY THE REST OF THE WAY TO START YOUR VEHICLE. IF YOU DO NOT HEAR THE FUEL PUMP AND GO AHEAD AND TRY TO START THE VEHICLE YOU TRIGGER THE ANTI-THEFT SYSTEM WHICH DOES NOT ALLOW THE CAR TO START FOR ANOTHER 15 MINUTES. WHILE THIS IS NOT MUCH OF A SAFETY ISSUE IT IS STILL A HUGE ISSUE, LEAVING ME STRANDED, SOMETIMES STUCK IN A HOT CAR JUST TRYING TO GET IT TO START, MADE ME LATE FOR WORK AND OTHER FUNCTIONS NUMEROUS TIMES. AFTER WAITING YOUR 15 MINUTES YOUR VEHICLE STILL MAY NOT START. IF YOU HAVE ENOUGH PATIENTS YOU CAN SET THERE AND TURN THE KEY OFF AND ON UNTIL YOU HEAR THE FUEL PUMP ENGAGE. EVERYTHING ELSE IN THE VEHICLE WORKS RADIO, LIGHTS ETC. IT JUST DOES NOT START. LEAVING ME TO BELIEVE THE IGNITION IS TO BLAME, AND HERE RECENTLY I WILL TURN THE KEY AND ABSOLUTELY NOTHING HAPPENS. I THEN TRY AGAIN AND IT STARTS LIKE A CHARM UNTIL ABOUT TWO WEEKS AGO AND I COULD NOT GET IT TO DO ANYTHING, MY BOYFRIEND INFORMED ME TO TURN THE KEY AND PUT THE CAR IN THE NEUTRAL POSITION AND TRY TO START IT AGAIN THIS WORKED. ALL I KNOW IS THIS CAR HAS GIVEN ME MANY PROBLEMS THAT MY GM CERTIFIED MECHANIC FATHER IS SHORT OF FIGURING OUT. I BELIEVE IT IS DUE TO FAULTY PARTS OR JUST A BAD MAKE OF CAR. THE ONLY THING I COULD DISPUTE THAT IS WHEN IT IS ACTUALLY STARTING, NOT SHUTTING DOWN ON ME IT IS A REASONABLY GOOD VEHICLE. IT GETS ME FROM POINT A TO POINT B NOT ALWAYS SAFELY OR RELIABLY BUT AT LEAST I HAVE A VEHICLE I JUST WHICH GM WOULD TAKE RESPONSIBILITY FOR THEIR PART IN THIS CARS ISSUES. OR AT LEAST INFORM THE PUBLIC IN HOW TO FIX THEM.
Electrical system, Sep 20, 2015
AFTER TAKING MY CHEVROLET MALIBU CLASSIC 2005 INTO THE DEALERSHIP FOR THE RECALL IN WHICH THEY PUT INSERTS ON MY KEY AND A KING RING, RIDICULOUS IF YOU ASK ME, MY CAR HAS NOW DONE THE SAME THING THREE MORE TIMES I THOUGHT THE RECALL WAS SUPPOSE TO FIX. WHILE DRIVING AT DIFFERENT SPEEDS ( 60 MPH., 45 MPH., 20 MPH) MY CARS SHUTS OFF AS IF I TURNED THE KEY OFF. MY POWER STEERING, BRAKES ALL ELECTRICAL COMPONENTS ARE EFFECTED. I HAVE TO THEN TURN MY KEY TO THE OFF POSITION AND AGAIN START MY CAR TO CONTINUE DRIVING. IT DOES THIS WITH NO WARNING, WHILE DRIVING DOWN A HIGHWAY, WHILE TURNING, WHILE DRIVING DOWN A HILL WHICH ARE ALL VERY MUCH SAFETY ISSUES. DRIVING 60 ON A HIGHWAY AND THE CAR SHUTS DOWN LEAVING YOU WITH NO POWER STEERING NO POWER BRAKES NO WARNING LIGHTS ETC. VERY SCARY. WHILE TURNING A CORNER ALL OF A SUDDEN NO POWER STEERING SEEMS TO ME COULD CAUSE A MAJOR WRECK, AND WHILE DRIVING DOWN A HILL LOOSING YOUR POWER BRAKES COULD ALSO. THIS HAPPEN TO ME NUMEROUS TIMES BEFORE THE RECALL ALSO. I DO BELIEVE IT WAS A CHEAP WAY OF CHEVY TO TRY TO GET OUT OF THE RESPONSIBILITY FOR THIS PROBLEM. WHEN I EXPLAINED TO THE DEALER MECHANIC WHAT WAS HAPPENING HE INFORMED ME THAT THE RECALL THAT FIXED THE KEY WOULD NOT HELP THE PROBLEM OF MY CAR RANDOMLY SHUTTING OFF WHILE DRIVING IT SO WHAT WAS IT FOR THEN?
Seats, Sep 17, 2015
THE DRIVER SIDE FRONT SEAT RAILS HAVE FAILED AND THE DEALER WANTS ALMOST $1000 TO REPAIR (WHICH I DON'T HAVE RIGHT NOW). I AM AFRAID THAT THE SEAT WILL COMPLETELY FAIL WHILE DRIVING AND RESULT IN INJURY OR DEATH. IT APPEARS THAT THIS FAILURE OF THE FRONT SEAT RAILING WELD IS FAIRLY COMMON ON THIS VEHICLE AND I AM SURPRISED THAT THE NHTSA WOULD ALLOW A MANUFACTURER (GENERAL MOTORS) TO NOT FIX THIS APPARENT SERIOUS DESIGN AND MANUFACTURING FLAW. I PURCHASED THIS CAR NEW, WEIGH LESS THAN 130 LBS, HAVE NEVER BEEN IN AN ACCIDENT, AND HAVE ALWAYS BEEN GENTLE WITH THE CAR. I AM DISAPPOINTED THAT GM AND THE CHEVROLET DEALER WANT TO MAKE A PROFIT FROM ME TO REPAIR THEIR DESIGN AND MANUFACTURING DEFECT. I OFFERED TO PAY THE OUT OF POCKET COSTS TO REPAIR THE DEFECT (I THNK THIS WOULD BE ABOUT OF THE QUOTED PRICE FOR THE ACTUAL MECHANIC TIME/WAGES AND WHOLESALE PARTS PRICE), BUT WAS TURNED DOWN.
Steering, Sep 17, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 50 MPH, THE STEERING WHEEL SEIZED AND THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRICAL STEERING MOTOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 147,437.
Engine, Fuel/propulsion system, Sep 15, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE ATTEMPTING TO START THE VEHICLE, IT WOULD NOT START. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.
Electrical system, Exterior lighting, Sep 15, 2015
THE FRONT DRIVER TURN SIGNAL DOES NOT WORK, IT HAS MELTED THE PLASTIC INSIDE. I HAVE CHANGED THE BULB SEVERAL TIMES AND IT CONTINUES TO BURN OUT. THE PASSENGER TURN SIGNAL IS NOW BLINKING VERY FAST AND THEN SLOW SO I'M GUESSING IT WON'T BE LONG BEFORE THAT ONE DOESN'T WORK. ALSO THE DRIVERS SIDE REAR BLINKER AND BRAKE LIGHT DO NOT WORK. ALL OF THIS IS A HAZARD WHEN DRIVING AND COULD EASILY CAUSE AN ACCIDENT. I HAVE HEARD OF NUMEROUS PEOPLE HAVING THESE SAME ISSUES AND THIS NEEDS TO BE RESOLVED. CLEARLY THIS IS A MANUFACTURER PROBLEM. I WOULD APPRECIATE YOUR PROMPT RESPONSE AND RESOLUTION. THANK YOU. *TR
Electrical system, Sep 2, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE LOST ALL ELECTRICAL POWER TO THE INSTRUMENT PANEL AND OTHER ELECTRICAL SYSTEMS. AS A RESULT, THE CONTACT COULD NOT READ THE SPEEDOMETER AND OTHER ELECTRICAL GAUGES. THE CONTACT STATED THAT THIS WAS A RECURRING FAILURE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE IGNITION MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Electrical system, Aug 31, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AFTER SEVERAL ATTEMPTS. THE FAILURE RECURRED ON FOURTEEN SEPARATE OCCASIONS AT ANY GIVEN SPEED BEING DRIVEN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE IGNITION SWITCH WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
Steering, Aug 28, 2015
AS I WAS PULLING INTO A PARKING PLACE AT SCHOOL THE STEERING BECAME VERY HARD TO TURN. I AFTER SHUTTING OFF THE SAID CAR WAS ABLE TO GET STEERING BACK FOR A TIME. IT HAS DONE THIS THREE TIMES,IN THE PAST WEEK. I HAVE TALKED TO A DEALER ABOUT THIS THEIR HAS BEEN KNOWN ISSUSES WITH THIS CAR MODELS IN POWER STEERING ASSIST.. DEALER SAID THAT THERE IS A 150000 MILE WARRANT. GM SAIS FROM THERE WEBSITE LIFETIME WARRANT. HTTP://MEDIA.GM.COM/MEDIA/US/EN/GM/VEHICLES.DETAIL.PRINT.HTML/CONTENT/PAGES/NEWS/US/EN/2014/MAR/0331-POWER-STEERING.HTML DONT NO WHAT TO DO ABOUT GETTING THIS FIXED SEEM TO BE GETTING RUN AROUND. ADVICE PLEASE.
Power train, Aug 26, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE SHIFT LEVER FAILED TO SHIFT OUT OF GEAR. THE CONTACT MENTIONED THAT THE BRAKE PEDAL HAD TO BE DEPRESSED IN ORDER TO SHIFT OUT OF GEAR BUT NOW IT'S FAILING TO DO SO. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. ALSO, THE CONTACT STATED THAT THE VEHICLE WAS REPAIR UNDER THE NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 112,000.
Steering, Electrical system, Engine, Aug 17, 2015
I WAS DRIVING AS NORMAL WITH NO INCIDENT, PARKED WENT INTO HOME AND CAME OUT 10 MINUTES LATER, CAR WOULD NOT CRANK, AS IF BATTERY WAS DEAD.. WENT BACK IN TO GET A MULTI-METER AND CHECKED BATTERY, SHOWED 12.3 VOLTS. WENT BACK INTO CAR AND IT CRANKED RIGHT UP , NO HESITATION. NEXT DAY WENT TO GET MY GRAND-DAUGHTER (2 YEARS OLD) AND PARKED AT HER HOME. LOADED THE BABY-SEAT, AND WENT TO START CAR, DEAD BATTERY SYMPTOM AGAIN. JUMPED THE CAR FROM MY DAUGHTER AND WENT TOM WALMART TO HAVE BATTERY CHECKED. BATTERY AND CHARGE SYSTEM CHECKED FINE. TRIED TO START THE CAR AFTER TEST, ACTED LIKE A DEAD BATTERY AGAIN. WALMART TECH SAID LOOKS LIKE A BAD STARTER MOTOR. I PURCHASED A NEW STARTER AND INSTALLED. CRANKED ON FIRST HIT. CHECKED CHARGING AMPS WHILE RUNNING, 13.4 VOLTS. WENT 25 MILES TO TOWN. PARKED AND AFTER 2 HOURS CAME BACK TO CAR AND WOULD NOT CRANK. (TURNED MOTOR ONCE THEN CLICK CLICK. CLICK.) GOT A RIDE HOME AND CHECKED INTERNET FOR PROBABLE CAUSE, SEEMS LIKE HUNDREDS (THOUSANDS) HAVE THE SAME SITUATION. I FEEL THE ANTI-THEFT SYSTEM IS CUTTING OFF POWER TO CAR. I TRIED THE FIX THAT I FOUND, LOCK, UNLOCK, LOCK UNLOCK CAR WITH KEY THEN WAIT 10 MINUTES AND CRANK THE CAR. IT WORKED. I PULLED AWAY FROM MY LODGE AND WENT DOWN THE ROAD. STOPPED, MADE A RIGHT TURN HEADING FOR A TRAFFIC LIGHT AND THE CAR DIED IN THE MIDDLE OF THE ROAD. COULD NOT TURN THE STEERING WHEEL, NO ELECTRICAL SIGNS OTHER THAN ANTI THEFT LIGHT FLASHING ON DASH. TRIED REPETITIVELY TO START THE CAR BUT AGAIN JUST CLICK CLICK. CLICK. IF I HAD BEEN ON THE THRU-WAY, IT WOULD PROBABLY BEEN AN ACCIDENT. FURTHER SEARCH ON INTERNET SHOWS THIS A MAJOR PROBLEM, BUT NO RECALL IS FOUND. WHY???
Power train, Aug 10, 2015
WE JUST GOT OUT OF CHURCH AND WAS STOPPING AT A GAS STATION TO GET SOME GAS. PUT THE VEHICLE IN PARK AND IT WENT INTO REVERSE AND STAYED IN REVERSE. NO MATTER HOW WE TRIED TO GET THE GEAR SHIFT OUT OF REVERSE, IT WOULD MOVE UP AND DOWN BUT WOULD NOT COME OUT OF REVERSE. THIS IS VERY DANGEROUS IN MY OPINION AND I AM SURE WE ARE NOT THE ONLY ONES THIS HAS HAPPENED TO RECENTLY. RIGHT NOW THE VEHICLE IS IN OUR DRIVE WAY AND IT'S DIFFICULT TO EVEN FIND A TOW COMPANY THAT WILL MOVE A CAR STUCK IN REVERSE. THE VEHICLE WAS DRIVING PERFECT PRIOR TO THIS INCIDENT. DON'T GET STUCK ON THE FREE WAY IN REVERSE!!
Steering, Suspension, Aug 5, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT'S VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING), NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN), AND NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). SHORTLY AFTER THE REPAIR, THE VEHICLE STALLED WITHOUT WARNING, THE POWER STEERING FAILED, A CLUNKING NOISE WAS HEARD IN THE FRONT END, AND THE VEHICLE INDEPENDENTLY VEERED TO THE LEFT. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED THAT THE RECALL REPAIR COULD NOT BE PERFORMED AGAIN. IN ADDITION, THE DEALER STATED THAT THE STEERING COLUMN AND SUSPENSION WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. IN PREVIOUS YEARS, THE CONTACT HAD TO REPLACE THE GEAR BOX AND RACK AND PINION NUT ON TWO SEPARATE OCCASIONS AT A DEALER. THE CONTACT INFORMED THE MANUFACTURER OF ALL THE FAILURES. THE FAILURE MILEAGE WAS 50,000.
Electrical system, Aug 4, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT WHEN THE KEY WAS PLACED IN THE IGNITION, THE ENGINE FAILED TO START AND THE PASS LOCK WARNING LIGHT ILLUMINATED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE PASS LOCK FAILED. THE VEHICLE CODES WERE RESET; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE DEALER AND DIAGNOSED AS PASS LOCK SENSOR FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 69,300. MA 10/22/2015 *CN
Electrical system, Aug 3, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE FAILED TO START INTERMITTENTLY AND THE SECURITY ALERT WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE IGNITION PASS LOCK SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 83,115.
Power train, Electrical system, Jul 22, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE ANTI-THEFT WARNING LAMP FLASHED UP TO THREE TIMES AND THAT THE KEY WOULD NOT TURN OVER TO START THE VEHICLE. THE CONTACT INDICATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE ANTI-THEFT MODULE, IGNITION SWITCH, BCM, AND ADDITIONAL COMPONENTS NEEDED TO BE REPLACED DUE TO THE FAILURE. THE VEHICLE WAS ALSO INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN), BUT THE CONTACT HAD NOT RECEIVED NOTIFICATION OF THE SAFETY RECALL TO SCHEDULE THE REPAIR. THE VEHICLE WAS NOT REPAIRED AND THE CONTACT WAS NOT ABLE TO GET THE KEY TO TURN OVER TO START THE VEHICLE. THE ANTI-THEFT WARNING LAMP CONTINUED TO FLASH THREE TIMES OR MORE AND THE VEHICLE WAS UNABLE TO BE DRIVEN. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 185,445.
Exterior lighting, Service brakes, Jul 16, 2015, crash
TL* THE CONTACT OWNED A 2005 CHEVROLET MALIBU. WHILE TRAVELING APPROXIMATELY 35 MPH, THE LOW BEAM HEADLAMP ASSEMBLY FAILED TO WORK. THE CONTACT APPLIED THE BRAKE PEDAL, WHICH DID NOT RESPOND AND EXTENDED TO THE FLOORBOARD. THE CONTACT STATED THAT THE VEHICLE SPUN AROUND AND CRASHED INTO A GUARDRAIL. THE CONTACT WAS UNABLE TO CONFIRM IF THE AIR BAGS DEPLOYED. THE CONTACT WAS UNCONSCIOUS AND WAS TRANSPORTED TO THE HOSPITAL. THE DRIVER SUSTAINED HEAD INJURIES, BROKEN WRISTS, A PUNCTURED AND COLLAPSED LUNG, AND ADDITIONAL INTERNAL INJURIES THAT REQUIRED MEDICAL TREATMENT. THE CONTACT ALSO STATED THAT HIS TEETH WERE FRACTURED FROM HIS MOUTH DUE TO THE IMPACT OF THE CRASH. A POLICE REPORT WAS FILED. THE CONTACT ALSO RECEIVED SEVERAL RECALL NOTIFICATIONS PERTAINING TO NHTSA CAMPAIGN NUMBERS: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), 14V153000 (STEERING), AND 14V224000 (POWER TRAIN). THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Exterior lighting, Jul 15, 2015
DRIVER SIDE FRONT TURN SIGNAL LAMPS ARE BURNING OUT IN ONE TO TWO WEEKS EVEN WHEN REPLACED WITH GM PARTS. BOTH REAR TURN SIGNALS LAMPS ARE ALSO BURNING OUT QUICKLY.
Seats, Jul 15, 2015
THE SEAT IS NO LONGER ATTACHED TO THE SEAT TRACK ON THE RIGHT SIDE OF THE DRIVER'S SEAT. THE SEAT LEANS TO THE RIGHT EVEN WITHOUT A DRIVER IN THE SEAT. THE FACTORY WELD HAS GIVEN OUT ON THE TRACK. WE FEEL THIS VEHICLE IS NOT SAFE IF IT WAS TO BE INVOLVED IN A CRASH. THERE WAS NO INCIDENT THAT CAUSED THE WELD TO FAIL OTHER THAN GOING AROUND A CORNER AT NORMAL SPEEDS. WHEN RESEARCHING REPAIR FOR THE VEHICLE WE HAVE NOTED MANY OTHERS WITH THE SAME COMPLAINT.
Steering, Power train, Service brakes, Jul 11, 2015, crash
I WAS ON MY WAY TO SCHOOL. WHEN I TOOK MY EXIT (23 ON ROUTE 2), THE CAR SIMPLY TURNED OFF, LOCKING MY STEERING WHEEL. I LOST CONTROL, SPUNG TWICE AND LANDED ON THE RAMP OF THAT EXIT. THE CAR HAS BEEN USELESS SINCE THEN. I CALLED THE RECALL HOTLINE TO GET SUPPORT AND THEY DID NOTHING FOR ME. I'M LEFT WITH NO CAR AND NO SUPPORT BY THE GM TEAM THAT FORWARD ME ENDLESS RECALL LETTERS. I'VE HAD ENDLESS ISSUES WITH THIS CAR SINCE I FINANCED IT. ENDLESS REPAIRS, CLOSE ACCIDENTS ENCOUNTER BECAUSE OF CAR SENSOR ISSUES. BRAKES NO PROPERLY WORKING. TRACTION FAILING. IT HAS BEEN A NIGHTMARE. HOW CAN I GET SUPPORT FOR A VEHICLE WHICH I LOVED SO DEARLY AND YET NEARLY COST ME MY LIFE?
Steering, Electrical system, Jul 10, 2015
UPON ACCELERATION POWER STEERING STOPS WORKING AND POWER STEERING WARNING MESSAGE SHOWS. GM DEALER SERVICE CENTER ADVISED THAT IT IS THE IGNITION COIL. REPLACED WITH A NEWER VERSION OF THE IGNITION COIL AND ADDED A GROUND STRAP BASED ON THE DETECTED ERROR CODES AND A SERVICE BULLETIN FROM GM. UPDATED 10/9/15 *LN UPDATED 11/13/2017*CN
Steering, Jul 7, 2015
REPORTED EARLIER THAT POWER STEERING WENT OUT AFTER PARTS WERE REPLACED UNDER A RECALL. NEW: POWER STEERING WARNING/CHIMES CAME ON DURING ACCELERATION (ENTERING HIGHWAY FROM RAMP). APPOINTMENT WITH DEALER (LOU LARICHE CHEVROLET, PLYMOUTH, MI) ON 7/10/15 (8 AM EST) TO HAVE RECALL PARTS CHECKED. ...UPDATED 09/22/15 *BF UPDATED 11/07/2017*CN
Steering, Jun 30, 2015
TURNING LEFT FROM A PARKING LOT ONTO STREET. POWER STEERING STOPPED WORKING FOR LESS THAN ONE SECOND WHILE MAKING LEFT TURN. POWER STEERING ASSEMBLY HAS BEEN REPLACED EARLIER UNDER A GM RECALL. HAD NO ISSUES WITH OLD PARTS BEFORE RECALL. RECALL NUMBER: 14V153000 RECALL DATE: 03/31/2014 COMPONENT: STEERING:ELECTRIC POWER ASSIST SYSTEM