2005 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,393 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 Malibu model years with reports.
Of the 2005 reports, 65 involved a crash and 45 involved a fire. 69 people were injured and 3 people died.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Representative owner complaints
1,393 reports, newest first.
Electrical system, Engine, Jun 25, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 50 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE ENGINE AFTER MULTIPLE ATTEMPTS. THE VEHICLE WAS TAKEN TO A DEALER AND DIAGNOSED FOR ELECTRICAL CODE FAILURE. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER, BUT THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
Steering, Jun 22, 2015
I LOST CONTROL OF STEERING AND WAS UNABLE TO TURN THIS HAS HAPPENED ON SEVERAL OCCASIONS AND NOW THEIRS A KNOCKING NOISE IN STEERING. AND ITS NOT STRUTS OR ALIANMENT OR TIRES AS THESE HAVE BEEN CHECKED AND OR CHANGED
Electrical system, Exterior lighting, Jun 21, 2015
THE TURN SIGNAL BULBS GET TOO HOT AND MELTS INTO THE SOCKET WHICH MAKES THE CONNECTION GO BAD. EVEN IF YOU CHANGE THE BULB THE CONNECTION IS BAD SO THE SOCKET HAS TO BE CHANGED. THIS HAS HAPPENED ON BOTH OF THE FRONT BULBS
Electrical system, Jun 5, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU CLASSIC. THE CONTACT INDICATED THAT THE ANTI THEFT SENSOR LIGHT HAD ILLUMINATED AND STAYED IN THE ON POSITION CAUSING THE IGNITION SWITCH TO BECOME DISABLED WHICH PREVENTED THE ENGINE FROM STARTING. THE CONTACT INDICATED THAT FAILURE HAD OCCURRED ON MULTIPLE OCCASIONS. THE CAUSE OF THE FAILURE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 118,000. THE VIN WAS NOT AVAILABLE.
Seats, Jun 4, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE DRIVER SIDE SEAT MOVED ON THE TRACK AND WAS CROOKED. THE VEHICLE WAS DIAGNOSED BY THE DEALER, BUT NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.
Electrical system, Exterior lighting, Visibility/wiper, Jun 4, 2015
HEAD LAMP BULBS AND TURN SIGNAL BULBS HAVE REPEATEDLY BURNT OUT. BULBS HAVE BEEN REPLACED BY CERTIFIED GM SHOP ONLY TO BURN OUT AGAIN.
Electrical system, Exterior lighting, Vehicle speed control, Jun 1, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 65 MPH WITH THE CRUISE CONTROL ENGAGED, THE CRUISE CONTROL DEACTIVATED AND THE BRAKE LIGHTS ILLUMINATED WITHOUT WARNING. THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE BRAKE LIGHTS TURNED OFF. THE CONTACT POWERED THE VEHICLE OFF AND BACK ON AND THE BRAKE LIGHTS RESUMED NORMAL OPERATION. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LIGHT SWITCH WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 199,000.
Fuel system, Gasoline, Jun 1, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE DIAGNOSIS WAS THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 11E009000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 7/16/15*CN
Electrical system, Exterior lighting, Vehicle speed control, May 31, 2015
AFTER A FEW DAYS OF OWNING THIS CAR I NOTICED THERE WAS AN ISSUE WITH THE BRAKE LIGHTS TURNING ON WHILE DRIVING. WHEN THIS HAPPENS IT ALSO SHUTS OFF THE CRUSE CONTROL TOO. WHEN YOU FIRST PRESS THE BRAKES THE LIGHTS SHUT OFF. PRESS THEM AGAIN AND THEY WORK FOR A FEW MINUTES. I SEARCHED THE INTERNET FOR HELP, AND NOTICED GM POSTED A SERVICE BULLETIN ON THIS ISSUE. GM ADVISED TO CLEAN, AND GREASE CONTACTS FOR BCM. I DID JUST THAT. THE CLEANING WAS ONLY A TEMPORARY FIX BECAUSE THE ISSUE RETURNED DAYS LATER. AROUND MAY OF 2014 I RECEIVED NOTICE THAT GM ISSUED SEVERAL RECALLS. THE CAR HAD BEEN BROKE DOWN UNTIL FEBRUARY OF 20015, AND IN APRIL IT WAS SENT TO MY LOCAL CHEVROLET DEALER TO HAVE THE RECALLS FIXED. SHORTLY AFTER FIXING THE RECALL ISSUES THE BRAKE LIGHT ISSUES RETURNED. I CONTACTED GM/ CHEVROLET AND THEY CONTACTED MY LOCAL DEALER WHO AGREED TO LOOK AT THE CAR AGAIN FOR FREE. AFTER THEY INSPECTED IT I WAS TOLD THE BRAKE SWITCH NEEDED REPLACED. ON MAY 28, 2015 MY LOCAL CHEVY DEALER REPLACED THE SWITCH. ON MAY 30, 2015 THE BRAKE LIGHT ISSUE RETURNED. THIS IS A FAMILY CAR AND IM AFRAID THAT SOMEONE WILL END UP HITTING US. CAN YOU PLEASE HELP.
Tires, May 20, 2015
ON 12/16/14 I PURCHASED A SET OF 4 NEW 215/60R/16 95T GOODYEAR VIVA2 TIRES FROM LOUISVILLE WALMART SUPERCENTER 175 OUTER LOOP LOUISVILLE, KY 40214 FOR A 2005 CHEVROLET MALIBU MAXX. ON 05/19/2015, WITH APPROPRIATELY 1500 MILES ON THE TIRES. WHILE DRIVING AT 50 MPH THE RIGHT REAR TIRE FAILED DUE TO SIDEWALL SEPARATION. DUE TO LOW SPEED AND LIGHT TRAFFIC THERE WAS NO ACCIDENT, AT HIGHWAY SPEED THIS WOULD NOT HAVE BEEN THE CASE. NO DAMAGE TO THE TIRE OTHER THAN SIDEWALL SEPARATION WAS NOTED BY WALMART SERVICE TECHNICIAN. I WAS NOT TOLD UNTIL LATER THAT THE TIRE WAS REPLACED BY A GOODYEAR 215/60R/16 95T VIVA 3 WITH A DIFFERENT TREED PATTERN(I DO NOT FEEL THIS IS SAFE) DUE TO GOODYEAR NO LONGER MAKING THE VIVA 2 DUE TO PROBLEMS WITH THE TIRE.
Electrical system, Engine, May 18, 2015
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING 15 MPH, THE VEHICLE WOULD OVERHEAT AND FAILED TO TURN OFF. THE VEHICLE WAS TAKEN TO A DEALER, WHERE IT WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. IN ADDITION, THE CONTACT RECEIVED NOTIFICATIONS FOR NHTSA CAMPAIGN NUMBERS: 14V252000 (ELECTRICAL SYSTEM), 14V153000 (STEERING), AND 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL); HOWEVER, THE PARTS NEEDED TO DO THE REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 139,855.
Steering, May 7, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE TURNING THE STEERING WHEEL LEFT OR RIGHT, THE STEERING WHEEL BECAME LOOSE AND MADE AN ABNORMAL NOISE. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE INTERIM MEAD STEERING SHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.
Steering, Electrical system, Engine, Apr 28, 2015
MY WIFE AND I HAVE CONTACTED CHEVY DEALER A LONG TIME AGO ABOUT SAFETY RECALLS ON THIS VEHICLE A LONG TIME AGO AND HAVE NOT RECEIVED ANY INFO. ON WHEN THESE RECALLS CAN BE DONE. MOST OF THESE RECALLS STATE THAT THE PARTS HAVE NOT BEEN SENT. WHAT CAN YOUR COMPANY DO ABOUT GETTING THESE RESOLVED. *TR
Vehicle speed control, Fuel/propulsion system, Apr 27, 2015
I WAS DRIVING ON FREEWAY AND MY VEHICLE STALLED AND SHUT DOWN. I HAD NO ACCELERATION FROM GAS PEDAL, SO I HAD TO SIGNAL OVER TO THE RIGHT SHOULDER OF ROAD AND COAST TO A COMPLETE STOP. TRIED STARTING THE VEHICLE A FEW TIMES, IT WOULD START BUT WOULD NOT REV UP, EVEN WHEN GAS PEDAL WAS PRESSED. UTAH ROAD INCIDENT MANAGEMENT HELPED BY PUTTING ONE GALLON OF GASOLINE IN TANK SINCE THE TANK WAS CLOSE TO EMPTY, BUT STILL WOULD NOT START. ALSO, TRIED USING CARBURETOR SPRAY TO START THE VEHICLE BUT, STILL DID NOT WORK. HAD TO BE TOWED TO A SERVICE SHOP, WHERE THEY PERFORMED TESTS TO FIGURE OUT WHAT WAS WRONG. AFTER TESTS DIAGNOSED THAT IT WAS THE FUEL PUMP AND FILTER. I LOOKED UP WHETHER OR NOT THERE WAS A RECALL ON THIS MODEL AND YEAR OF VEHICLE. THERE WAS A RECALL FOR AFTERMARKET FUEL PUMPS, BUT I BELIEVE THAT RECALL HAS CLOSED. I HOPE TO HAVE MY VEHICLE FIXED UNDER THE SAME RECALL. *TR
Service brakes, Apr 16, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED ACCORDING TO THE RECALL, BUT THE FAILURE PERSISTED. THE SERVICE BRAKE WARNING INDICATOR LIGHT FLASHED ON AND OFF SPORADICALLY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
Steering, Apr 12, 2015
NOTHING HAS HAPPENED YET, THERE IS A KNOCK WHEN CAR IS TURNING AND U JOINT LOOKS RUSTED. KNOCK IS NOT RELATED TO CV JOINTS OR BOOTS, IT WAS SEEN BY A LICENSED MECHANIC THAT SAID IT WAS THE U JOINT IN STEERING SHAFT. FIRESTONE OF FAYETTEVILLE AR ARE THE MECHANICS THAT DIAGNOSED THE ISSUE. *TR
Engine and engine cooling, Fuel/propulsion system, Apr 10, 2015
FUEL GAUGE FLUCTUATION AND ENGINE LIGHTS COMES ON. I DID NOT HAVE THIS PROBLEM UNTIL AFTER THE LAST RECALL CAR IS IN GOOD SHAPE AND I FEEL THAT SOMETHING WENT WRONG AND THEY FAILED TO TELL ME AT THE DEALERSHIP. I NEED HELP. *TR
Steering, Apr 2, 2015
LOUD POPPING NOISE COMING FROM THE STEERING COLUMN, AND CAN BE FELT IN THE STEERING WHEEL. SLIGHT "PLAY" IN THE STEERING ON THE LEFT SIDE. THE NOISE SEEMS TO BE POPPING WITHIN THE "PLAY" AREA OF THE STEERING. PURCHASED THIS VEHICLE FROM PRIVATE OWNER WITH LOW MILES, GARAGE KEPT, AND REGULAR MAINTENANCE. PREVIOUS OWNER NOTICED A NOISE NEAR THE STEERING AT 30000 MILES. *TR
Electrical system, Apr 1, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS THEN TAKEN TO A DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 140,000.
Exterior lighting, Apr 1, 2015, fire
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE FRONT BLINKER BULBS WERE BURNING THE BULB COVERS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 75,000. UPDATED 8/27/15*CN UPDATED 10/4/2017*CN
Exterior lighting, Mar 31, 2015
PASSENGER SIDE FRONT TURN SIGNAL BULB BURNS OUT FREQUENTLY. IT ALSO WILL WORK ONE DAY AND SUDDENLY STOP WORKING THE NEXT DAY, THEN WORK AGAIN LATER WITHOUT HAVING DONE ANY INTERVENTION AT ALL. IF I WIGGLE THE BULB JUST RIGHT WITHIN THE SOCKET, I CAN GET IT TO WORK. SOMETHING AS SIMPLE AS RUNNING INTO A POTHOLE CAN MAKE THE BULB UNIT WORK OR CEASE WORKING. *TR
Steering, Mar 26, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE STEERING WHEEL BECAME TIGHT AND WAS EXTREMELY DIFFICULT TO MANEUVER. THE CONTACT HAD TO APPLY FORCE ON THE STEERING WHEEL IN ORDER TO MANEUVER THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14E044000 (STEERING) AND 14V153000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 153,000. UPDATED 5/29/15*CN UPDATED 10/2/2017*CN
Power train, Electrical system, Mar 25, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE KEY WAS DIFFICULT TO TURN OVER TO START THE VEHICLE AND THAT THE VEHICLE STALLED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE AUTHORIZED DEALER SIX MONTHS AGO AND WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBERS: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL) AND 14V224000 (POWER TRAIN), BUT THE CONTACT INDICATED THAT THE DEALER STATED THAT THE REPAIRS WERE NOT SUFFICIENT. THE CONTACT WAS WAITING FOR THE REPAIR FOR NHTSA CAMPAIGN ID NUMBER: 14V224000 (ELECTRICAL SYSTEM) AND WAS UNABLE TO DETERMINE WHEN THE RECALL WOULD BE PERFORMED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Engine, Fuel/propulsion system, Mar 22, 2015
FILLED 2005 MALIBU WITH GAS. FUEL READ FULL. PULLED OFF FROM GAS STATION FUEL GAUGE WENT TO EMPTY. FUEL LIGHT AND CHECK ENGINE LIGHT CAME ON CAR TURNED OFF WHILE AT THE LIGHT. I AM NOT TRYING TO DIE DUE TO A CORPORATION NEGLIGENCE!!!! *TR
Service brakes, Mar 13, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE SHIFTING INTO THE DRIVE POSITION, THE BRAKE PEDAL WAS DEPRESSED BUT THE VEHICLE DID NOT STOP. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 114,000. UPDATED 4/21/15*CN