2006 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,385 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Malibu model years with reports.
Of the 2006 reports, 53 involved a crash and 7 involved a fire. 31 people were injured.
What owners report most often
Recalls and investigations
Steering, electric power assist systemFeb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Campaign 15V064000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Air bags, frontalOct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Campaign 06V417000 on NHTSA.gov
Equipment, other, labelsOct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 05V486000 on NHTSA.gov
Representative owner complaints: exterior lighting
71 reports, newest first. Show all
Exterior lighting, Mar 1, 2015
I CAN'T USE MY HEADLAMP CAUSE SOMETHING IS WRONG WITH THE WIRE HARNESS IF I USE MY HEADLAMP WHILE DRIVE SMOKE WILL COME FROM UNDER THE HOOD I HAVE TO ALWAYS KEEP THEM OFF WHILE DRIVE OR SITTING STILL CAUSE I DON'T WANT IT TO CATCH A FIRE. *TR
Steering, Exterior lighting, Jan 8, 2015
UNIT HAS HAD CONTINUING INTERMITTENT POWER STEERING. VERY DANGEROUS AT TIMES. BULLETIN 14116 IS SUPPOSE TO COVER 2004-2006 MALIBU, BUT DEALER SAYS ITS NOT COVERED. HOW COULD A RECALL NOT BE A RECALL? UNIT ALSO HAS DANGEROUS INTERMITTENT HEADLIGHTS. BULBS FINE, HAS DEFECTIVE SOCKETS INSIDE THE INTEGRATED HEADLIGHT ASSEMBLY. OTHER GMS HAVE HAD THIS ISSUES BUT NO RECALLS ON THE MALIBU. *TR
Exterior lighting, Dec 13, 2014
HEADLIGHTS HAVE STARTED TO FAIL ON A REGULAR INTERVAL. I HAVE REPLACED THE LOW BEAMS 4 TIMES. I JUST PURCHASED TWO MORE BECAUSE THE RIGHT LOW BEAM HAS FAILED AGAIN. NO, I DO NOT TOUCH THE QUARTZ HALOGEN LAMP. I HAVE WORKED WITH THESE BULBS FOR MANY YEARS. *TR
Electrical system, Exterior lighting, Nov 6, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE ROADSIDE ASSISTANCE DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE CONTACT STATED THAT THE BRAKE LIGHTS FAILED TO OPERATE. THE VEHICLE HAD NOT BEEN TOWED TO THE DEALER FOR REPAIRS. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL) THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 81,000.
Service brakes, Hydraulic, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Oct 8, 2014
2006 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO RECALL NOTICES. *TGW THE CONSUMER STATED TWO DAYS AFTER THE FIRST RECALL REPAIR, BECAUSE THE REPAIR WAS NOT FULLY COMPLETED, DUE TO LACK OF PARTS, SHE EXPERIENCED TWO EPISODES WHICH SHE DEEMED UNSAFE. WHILE SITTING WITH HER FOOT ON THE BRAKE, AND THE VEHICLE IN DRIVE, SHE SUDDENLY FELT A SLIGHT SHIFT, AS IF THE VEHICLE WAS TRYING TO MOVE FORWARD, WHICH IT DID, WITHOUT ANY WARNING. THE VEHICLE BUMPED A CAR IN FRONT OF HER. THE CONSUMER REFERENCED RECALL # 14V252000. *JB
Service brakes, Hydraulic, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Oct 2, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR THE RECALL REPAIR AND WAS LATER INFORMED THAT THE PART WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 11/20/14*LJ UPDATED 8/12/2015 *JS
Service brakes, Hydraulic, Power train, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Oct 1, 2014
2006 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO TORQUE SENSOR ASSEMBLY; WIRING HARNESS TO THE BCM OR MAG BEAM AND TRANSMISSION SHIFT CABLE THAT MAY FRACTURE AT ANY TIME. *TGW THE CONSUMER WAS INFORMED, THE PARTS WERE NOT AVAILABLE. *JB
Exterior lighting, Air bags, Sep 26, 2014, crash
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 10 MPH, THE BRAKE LIGHT ILLUMINATED WITHOUT THE BRAKE PEDAL BEING DEPRESSED. AS A RESULT, ANOTHER VEHICLE CRASHED INTO THE REAR OF THE VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. THE DRIVER DID NOT SUSTAIN ANY INJURIES. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT RECEIVED NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM , ELECTRONIC STABILITY CONTROL , EXTERIOR LIGHTING , SERVICE BRAKES, HYDRAULIC , VEHICLE SPEED CONTROL) AND BELIEVED THAT THE CRASH WAS RELATED TO THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 95,075.
Steering, Service brakes, Hydraulic, Power train, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Sep 11, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED RECALL NOTIFICATIONS FOR NHTSA CAMPAIGN NUMBERS: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), 14V153000 (STEERING), AND 14V224000 (POWER TRAIN). THE PARTS NEEDED TO PERFORM THE RECALL REPAIRS WERE UNAVAILABLE. THE DEALER WAS UNCERTAIN WHEN THE PARTS WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Service brakes, Hydraulic, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Sep 8, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL); HOWEVER, THE PARTS NEEDED TO REPAIR THE VEHICLE WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Steering, Exterior lighting, Aug 28, 2014
I WAS MAKING A LEFT HAND TURN WHEN THE "POWER STEERING" ERROR APPEARED. ALL LIGHTS TURNED OFF IN THE VEHICLE AND THE STEERING WHEEL LOCKED; IT WAS AS IF THE VEHICLE HAD TURNED OFF. I COASTED DOWN THE STREET UNTIL I PARKED THE CAR AND ACTUALLY TURNED THE VEHICLE OFF. AT THAT POINT, I WAS UNABLE TO RESTART THE VEHICLE. THE NEXT MORNING WE FOUND THE TIMING BELT WAS BROKEN; ONCE REPLACED, THE VEHICLE RESTARTED. SINCE THEN, THE "POWER STEERING" ERROR HAS DISPLAYED NUMEROUS TIMES. WHEN TURNING THE WHEEL EXTREMELY LEFT OR RIGHT, THE STEERING WHEELS LOCKS. I THEN HAVE TO TURN OFF THE VEHICLE AND RESTART IT IN ORDER FOR IT TO RESET. JUST YESTERDAY, I WAS REVERSING OUT OF A PARKING SPOT WHEN THE "POWER STEERING" ERROR DISPLAYED AND MY STEERING WHEEL LOCKED UP AGAIN. THIS TIME I DID NOT HAVE TO TURN THE VEHICLE OFF; AS IT RESET ON ITS OWN. I HAVE BEEN ADVISED BY GM THAT MY VEHICLE IS NOT INCLUDED IN THE CURRENT RECALL (GM RECALL # N140115) AS MY VEHICLE WAS NOT ASSEMBLED IN THE SAME PLANT AS THE RECALLED VEHICLES. CLEARLY MY CAR HAS A PROBLEM WITH IT'S POWER STEERING. PER GM RECALL # N140115, "IN THE AFFECTED VEHICLES, THERE MAY BE A SUDDEN LOSS OF ELECTRIC POWER STEERING (EPS) ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING". *TR
Exterior lighting, Jul 30, 2014
I NOTICED THAT MY PASSENGER SIDE TAIL LIGHTS WERE VERY DIM IN FURTHER INVESTIGATION I LEARNED MY PASSENGER SIDE BRAKE LIGHTS WERE NOT ILLUMINATING AT ALL WHEN I PUSH MY BRAKE PEDAL AND WHEN THE PEDAL IS PUSHED THE TAIL LIGHTS DO NOT ILLUMINATE AT ALL AND THE PROBLEM CONTINUES INTO MY BLINKER, REVERSING INDICATOR, ETC.. ALSO WHEN I CHECK MY VIN IT TELLS ME THERE ARE NO ACTIVE RECALLS FOR MY CAR. *TR
Exterior lighting, Service brakes, Jul 17, 2014
I HAVE HAD TO REPLACE THE HEADLIGHTS AND BRAKE LIGHTS REPEATEDLY OVER THE PAST YEAR. WHEN I TURN THE AIR CONDITIONING OFF WHEN I AM ALREADY SITTING, STOPPED, THE CAR LUNGES FORWARD AND THE BRAKE HAS TO BE PRESSED FURTHER DOWN IN ORDER TO STOP THE CAR AGAIN. *TR
Exterior lighting, Vehicle speed control, Service brakes, Jun 30, 2014
CRUISE CONTROL STOPPED WORKING, REMOTE START STOPPED WORKING, BRAKE LIGHTS COME ON WHEN PEDAL IS NOT PRESSED AND GO OFF WHEN PEDAL IS PRESSED. VEHICLE SHOWS STOPPING WHEN DRIVING AND DRIVING WHEN STOPPING. WILL GET REAR-ENDED SAME THING HAPPENED 3 YEARS AGO. GM TECHNICAL SERVICE BULLETIN #08-05-22-009C ISSUED IN 2008. *TR
Electrical system, Exterior lighting, Service brakes, Jun 23, 2014
BRAKE LIGHTS STAY ON WHEN DRIVING, BUT DO NOT COME ON WHEN APPLYING THE BRAKES. *TR
Exterior lighting, Service brakes, Jun 23, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE BRAKE LIGHTS ILLUMINATED WITHOUT THE BRAKE PEDAL BEING DEPRESSED AND DIMMED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 32,000.
Steering, Exterior lighting, May 29, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE POWER STEERING WARNING LIGHT ILLUMINATED AS THE STEERING WHEEL BECAME VERY HARD TO MANEUVER. IN ADDITION, THE CONTACT MENTIONED THAT THE BRAKE LIGHTS WERE CONSTANTLY FAILING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO ADVISED HIM THAT THE VEHICLE WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING) AND NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL , EXTERIOR LIGHTING , SERVICE BRAKES, HYDRAULIC , VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS 18,000 AND THE CURRENT MILEAGE WAS 58,000.
Exterior lighting, Apr 14, 2014
BRAKE LIGHTS COMING ON WITHOUT DEPRESSING BRAKE PEDAL WHEN DRIVING CAR. *JS
Exterior lighting, Dec 4, 2013
WHEN I PRESS DOWN ON THE GAS MY BRAKE LIGHTS COME ON AND WHEN I PRESS DOWN ON THE BRAKES THEY TURN OFF. HOWEVER, THE BRAKE LIGHTS DO COME ON WHEN I PRESS THE BRAKES ALL THE WAY DOWN TO THE FLOOR. *TR
Exterior lighting, Aug 30, 2013
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, HE WAS INFORMED THAT THE BRAKE LIGHTS WERE ILLUMINATED DESPITE THE BRAKE PEDAL NOT BEING DEPRESSED. THE CONTACT PURCHASED A BRAKE SENSOR FROM A DEALER AND INSTALLED THE COMPONENT HIMSELF HOWEVER, THE FAILURE RECURRED. HE THEN INSTALLED A SECOND SENSOR BUT THE FAILURE CONTINUED TO RECUR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 224,821.
Exterior lighting, May 24, 2013
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT THE BRAKE LIGHT REMAINED ILLUMINATED WITHOUT THE BRAKES BEING DEPRESSED. IN ADDITION, THE BRAKE LIGHTS STOPPED ILLUMINATING WHEN THE BRAKES WERE BEING DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS UNABLE TO BE REPLICATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 16,000 AND THE CURRENT MILEAGE WAS 20,000. *TR
Exterior lighting, Service brakes, Apr 23, 2013
CRUISE CONTROL WENT OFF. TRIED TO RESET TO NO AVAIL. DROVE APPROXIMATELY 20 MILES. RESET CRUISE CONTROL AND IT WORKED THEN STOPPED WORKING. STOPPED THE CAR AND CHECKED THE BRAKE LIGHTS WHICH WERE STEADY ON. PUSHED THE BRAKE HARD AND THEY WENT OFF WHEN THE PEDAL WAS RELEASED. PUSHED THE BRAKES AGAIN AND THE BRAKE LIGHTS FLASHED OFF AND ON INTERMITTENTLY. DROVE ANOTHER 10 MILES AND THE CRUISE CONTROL WAS WORKING. A PERSON FOLLOWING ME STATED MY BRAKE LIGHTS STAYED ON WHETHER I WAS ACCELERATING OR STOPPING. *TR
Exterior lighting, Vehicle speed control, Service brakes, Nov 2, 2012
WHILE DRIVING VEHICLE I WAS BEING FOLLOWED BY MY DAUGHTER WHO THOUGHT I WAS RIDING MY BRAKES. IT TURNS OUT THAT THE BRAKE LIGHTS ARE GOING OFF WHEN THE BRAKES ARE APPLIED AND COMING ON WHEN BRAKES ARE RELEASED. THIS ALSO AFFECTS THE CRUISE CONTROL AS IT WILL NOT WORK WHEN THE BRAKE LIGHTS COME ON. THIS IS A VERY DANGEROUS ISSUE. PEOPLE DRIVING BEHIND ME DON'T KNOW IF I'M STOPPING OR NOT! THERE ARE COUNTLESS NUMBERS OF PEOPLE WITH THIS SAME PROBLEM AND THE DEALERSHIPS DON'T HAVE THE ANSWER TO FIX IT. THIS SHOULD BE A RECALL IF THERE EVER WAS ONE! *TR
Exterior lighting, Service brakes, Jun 22, 2012
THE BRAKE LIGHTS COME ON WHILE DRIVING THE VEHICLE UNDER ALL CONDITIONS. THE PROBLEM OCCURS REPEATEDLY AND WITHOUT WARNING. THE SAFETY ISSUE HERE IS THAT DRIVERS FOLLOWING BEHIND ARE UNABLE TO TELL IF THE BRAKE LIGHTS ARE TRULY THAT BRAKES ARE BEING APPLIED OR JUST A PHANTOM ISSUE WHICH COULD RESULT IN A REAR-END COLLISION. THIS ISSUE MAY OR MAY NOT BE RELATED TO ISSUES EXPERIENCED WITH THE CRUISE CONTROL OF THE VEHICLE EITHER NOT ENGAGING AT ALL, OR DISENGAGING ON THEIR OWN. IT MAY OR MAY NOT ALSO BE RELATED TO BRAKES AND ROTORS NEEDING REPLACEMENT MORE FREQUENTLY THAN NORMAL WEAR OR PROBLEM EXPERIENCED WITH THE REAR WINDOW DEFROSTER BEING UNRESPONSIVE. *TT
Exterior lighting, Service brakes, Jun 10, 2012
I HAVE A 06 CHEVY MAILBU MY BRAKE LIGHTS COMES ON WHEN I AM DRIVING SO IT LOOKS LIKE I AM RIDING MY BRAKES I HAVE BEEN PULLED OVER BECASE OF THIS WHEN I GOOGLED IT THERE WAS A BUNCH OF PEOPLE WITH 2006 MAILBUS WITH THE SAME PROBLEM I HAVE HAD THE BRAKE LIGHT SWITCH REPLACED ABOUT 5 TIMES AND THAT IS NOT THE PROBLEM NO ONE CAN SEEM TO FIND THE PROBLEM NOT EVEN THE CHEVY DEALERSHIP I THINK THERE SHOULD BE A RECALL ON THIS BECAUSE IT IS DANGERIOUS TO DRIVE WITH THE BRAKE LIGHTS ON WHEN YOU PRESS THE BRAKE PEDAL THE BRAKE LIGHTS GO OUT FOR ABOUT 10 SECONDS THEN COME RIGHT BACK ON. *TR