2006 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,385 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Malibu model years with reports.
Of the 2006 reports, 53 involved a crash and 7 involved a fire. 31 people were injured.
What owners report most often
Recalls and investigations
Steering, electric power assist systemFeb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Campaign 15V064000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Air bags, frontalOct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Campaign 06V417000 on NHTSA.gov
Equipment, other, labelsOct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 05V486000 on NHTSA.gov
Representative owner complaints: power train
60 reports, newest first. Show all
Power train, Engine, Nov 4, 2014
WHEN I TRY TO START MY CHEVY MALIBU IT DOESN'T CATCH AFTER TURNING THE KEY AND WILL CONSTANTLY DIE. ALREADY REPLACED THE STARTER, FUEL INTAKE, ETC BUT CONTINUES THE SAME PROBLEMS. *TR
Power train, Nov 3, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE JERKED INTERMITTENTLY. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN) EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER STATED THAT THE PART WAS NOT AVAILABLE FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE DELAY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 98,000.
Power train, Oct 17, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACTED STATED WHILE PARK, THE VEHICLE ROLLED AWAY. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
Service brakes, Hydraulic, Power train, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Oct 1, 2014
2006 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO TORQUE SENSOR ASSEMBLY; WIRING HARNESS TO THE BCM OR MAG BEAM AND TRANSMISSION SHIFT CABLE THAT MAY FRACTURE AT ANY TIME. *TGW THE CONSUMER WAS INFORMED, THE PARTS WERE NOT AVAILABLE. *JB
Power train, Traction control system, Sep 25, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 55 MPH, THE VEHICLE DECELERATED AND THE TRACTION CONTROL WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNAVAILABLE.
Power train, Latches/locks/linkages, Sep 18, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE GEAR SHIFT WAS ABLE TO BE MOVED OUT OF THE PARK POSITION WITHOUT ENGAGING THE BRAKES. THE DEALER REPAIRED THE VEHICLE ACCORDING TO NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. AFTER THE REPAIR WAS PERFORMED, THE ELECTRIC DOOR LOCKS FAILED TO OPERATE PROPERLY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 71,943.
Power train, Electrical system, Vehicle speed control, Sep 17, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). HOWEVER, THE PARTS WERE UNAVAILABLE TO SERVICE THE VEHICLE UNDER THE RECALL. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Steering, Service brakes, Hydraulic, Power train, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Sep 11, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED RECALL NOTIFICATIONS FOR NHTSA CAMPAIGN NUMBERS: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), 14V153000 (STEERING), AND 14V224000 (POWER TRAIN). THE PARTS NEEDED TO PERFORM THE RECALL REPAIRS WERE UNAVAILABLE. THE DEALER WAS UNCERTAIN WHEN THE PARTS WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Steering, Power train, Sep 8, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT RECEIVED RECALL NOTICES FOR NHTSA CAMPAIGN NUMBERS: 14V153000 (STEERING) AND 14V224000 (POWER TRAIN); HOWEVER, THE PARTS NEEDED TO REPAIR THE VEHICLE WERE UNAVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE DELAY. THE VEHICLE WAS NOT REPAIRED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 10/23/2014*LJ UPDATED 4/20/15 *JS
Steering, Power train, Service brakes, Aug 24, 2014
HELLO, I CONTACTED YOUR NATIONAL SERVICE LINE AND THEY REFERRED ME TO JACK WILSON CHEVROLET IN SAINT AUGUSTINE. WE HAVE HAD THREE RECALLS ON THIS VEHICLE AND NO RESOLUTION ON ANY OF THEM. VIN# [XXX] 2006 CHEVROLET MALIBU MAXX 65000 MILES STEERING ISSUE, TOOK TO A DEALER SHIP IN JACKSONVILLE, FL., THEY TOLD ME IT WAS A BRAKE ISSUE. HAD THE FRONT BRAKES REPLACED AND STILL HAVE THE ISSUE AND CHARGED ME 60.00 FOR A WRONG DIAGNOSIS. RECEIVED LETTER ON 7-18-2014, RECALL #13036, NO PARTS AVAILABLE AND DO NOT KNOW WHEN THEY WILL BE AT THIS TIME. RECEIVED LETTER ON 8-11-2014, RECALL #14152, NO PARTS AVAILABLE AND DO NOT KNOW WHEN THE WILL BE AT THIS TIME. THE NATIONAL CUSTOMER SERVICE CENTER CALLED JACK WILSON AND SET UP FOR ME TO GO AND HAVE THEM INSPECT RECALL ITEMS AND LET ME KNOW THAT THERE WAS NO EMINENT DANGER. I WENT TO JACK WILSON AND SPOKE WITH THE SERVICE PERSON [XXX] WHICH DID NOT HAVE THE INSPECTION DONE. SHE WAS WILLING TO INSPECT THE STEERING ISSUE WHICH SHE SAID WAS NOT A RECALL ISSUE BY TURNING THE STEERING WHEEL BACK AND FORTH AND DID NOT HAVE A CERTIFIED TECHNICIAN EVEN LOOK AT THE CAR. THIS CAR IS MY MOTHER'S ONLY CAR, SHE IS 84 AND DOING WELL UNTIL SHE GOT THESE RECALL LETTERS. SHE DOES NOT FEEL SAFE TO DRIVE THIS CAR AND NO ONE CAN TELL ME WHEN THE PARTS WILL BE AVAILABLE FOR THE REPAIRS TO BE COMPLETED. [XXX] I AM CONTACTING GM FIRST WITH THIS AS YOU REQUESTED. PLEASE HELP US WITH THIS MATTER, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Power train, Service brakes, Aug 18, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT SHE ATTEMPTED TO HAVE HER VEHICLE REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN) AND NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM , ELECTRONIC STABILITY CONTROL , EXTERIOR LIGHTING , SERVICE BRAKES, HYDRAULIC , VEHICLE SPEED CONTROL) BUT WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE DELAY. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Power train, Aug 18, 2014
LETTER FROM CONGRESSWOMAN MATSUI ON BEHALF OF CONSTITUENT RE 2006 GENERAL MOTORS CHEVROLET MALIBU RECALL. *SMD THE CONSUMER WAS INFORMED THE PARTS WERE NOT AVAILABLE, AND GM REFUSED TO PROVIDED A LOANER VEHICLE. *JB
Steering, Power train, Vehicle speed control, Aug 14, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED NOTIFICATIONS FOR RECALLS NHTSA CAMPAIGN NUMBERS: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), NHTSA CAMPAIGN NUMBERS: 14V224000 (POWER TRAIN) AND NHTSA CAMPAIGN NUMBERS: 14V153000 (STEERING). HOWEVER, THE PARTS WERE NOT AVAILABLE IN ORDER TO PERFORM THE RECALL REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Fuel system, Gasoline, Power train, Service brakes, Aug 13, 2014
I WAS UN ABLE TO GET MY CAR FROM PARK TO DRIVE. I HAD TO PULL EXTREMELY HARD ON THE SHIFTER TO GET IT TO MOVE. *TR
Power train, Aug 12, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN). THE CONTACT STATED THAT THE PART NEEDED FOR THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Power train, Jul 29, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V224000. (POWER TRAIN). THE CONTACT STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT DID NOT EXPERIENCE A FAILURE.
Power train, Jul 28, 2014
THIS IS A FOLLOW-UP TO ODI CONFIRMATION NUMBER: 10610590 WHERE THE VEHICLE WOULD COMPLETELY SHUT OFF WITHOUT WARNING. ALL POWERED FUNCTIONS WERE LOST. THE DISPLAY SCREEN WOULD SIGNAL: "ENGINE DISABLED." PER THE CHEVY DEALER, THE PROBLEM HAS BEEN IDENTIFIED AS A IMPROPER WORKING PCM (POWERTRAIN CONTROL MODULE), WHERE THE FOLLOWING ERROR CODES WERE PRESENT: P0601 TO P0606 AND U2109. ESTIMATED COST TO REPAIR, AT THIS POINT, IS $740.00 + TAX. FOR PEACE OF MIND AND OF COURSE, REASONS OF PERSONAL SAFETY, WE HOPE THAT THIS IS THE PROBLEM. *JS
Power train, Jul 24, 2014
THE TRANSMISSION CABLE OF MY CAR QUIT WORKING. I WAS TRYING TO PUT MY CAR IN PARK WHEN PICKING MY KIDS UP FROM DAYCARE, AND THE CAR WOULD NOT SHIFT INTO GEAR. THE CAR WOULD NOT SHIFT INTO PARK, DRIVE, ETC. WHEN I THOUGHT I HAD PUT THE CAR INTO PAR, THE CAR PROCEEDED TO ROLL DOWN THE HILL. I HAD TO PUT THE EMERGENCY BREAK ON, AND ALL A TOW TRUCK. THE DEALERSHIP FOUND THAT THE TRANSMISSION CABLE HAD TO BE REPLACED. ALTHOUGH THIS IS ISSUE IS PART OF A CHEVROLET RECALL, MY 2006 MALIBU MAXX IS NOT PART OF THE RECALL, AND I DO NOT UNDERSTAND WHY. *TR
Power train, Electrical system, Vehicle speed control, Service brakes, Jul 10, 2014
WHILE DRIVING AT NIGHT, ANOTHER DRIVER STOPPED TO LET ME KNOW THAT MY BRAKE LIGHTS WERE NOT WORKING. AROUND THIS TIME I ALSO NOTICED THAT MY CRUISE CONTROL WOULD STOP WORKING OR NOT WORK AT ALL. ON SEVERAL OCCASIONS AFTER I FIRST LEARNED OF THE PROBLEM PEOPLE FOLLOWING ME WOULD TELL ME THAT IT LOOKED LIKE I WAS RIDING MY BRAKES WHEN I WAS NOT TOUCHING THE BRAKE PEDAL. WHEN I WOULD PRESS THE BRAKES THEY WOULD GO OFF. I TESTED THIS BY BACKING UP TO MY GARAGE DOOR AND PRESSING THE BRAKES. THEY COME ON WHEN I LIFT MY FOOT OFF THE BRAKE BUT GO OUT WHEN I PRESS THE PEDAL. AROUND THIS TIME I ALSO NOTICED THAT THE GEAR SHIFTER WOULD SOMETIMES STICK/NOT MOVE EVEN THOUGH I HAD MY FOOT ON THE BRAKE PEDAL. MY LOCAL DEALER REPLACED A COMPUTER MODULE AND THAT SEEMED TO CORRECT THE PROBLEM FOR A WHILE BUT THE PROBLEM HAS SINCE COME BACK. *TR
Steering, Power train, Jun 2, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, A CHIME SOUNDED AS THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE POWER STEERING WARNING LIGHT WAS ALSO ILLUMINATED. ADDITIONALLY, THE TRANSMISSION WOULD SURGE WHEN THE CONTACT WOULD START THE VEHICLE. THE FAILURE RECURRED SPORADICALLY. THE VEHICLE WAS NOT REPAIRED OR DIAGNOSED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 14V153000 (STEERING) HOWEVER, THE VEHICLE WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. UPDATED 10/22/2014*LJ THE CONSUMER WAS INFORMED THE ENTIRE STEERING ASSEMBLY NEEDED TO BE REPLACED. UPDATED 02/03/15
Power train, May 29, 2014
GEAR SHIFT LEVER MOVES TO PARK POSITION, BUT PARK IS NOT ENGAGED. CAN NOT START ENGINE BECAUSE TRANSMISSION IS STILL IN DRIVE, EVEN THOUGH GEAR SHIFT SHOWS PARK. SOUNDS LIKE GM RECALL NOTICE #14152, BUT WE WERE INFORMED BY DEALER OUR VIN # IS NOT PART OF THIS RECALL. *TR
Steering, Power train, May 20, 2014
THIS HAPPENED LITERALLY AT THE END OF A 7 HOUR CAR TRIP- WE GOT LUCKY. DRIVING ON I-75 SOUTH AND APPROACHING EXIT. BEGIN TO SLOW DOWN AND ENTER EXIT RAMP. STEERING WHEEL STARTS SHAKING PROFUSELY AND IMMEDIATELY BECOMES EXTREMELY HARD TO MOVE TO EITHER SIDE. PANICKING, I MANAGED TO CONTROL THE CAR AND SLOW IT DOWN TO A VERY SLOW SPEED AND PUT THE HAZARD LIGHTS ON, AND SLOWLY MERGE INTO A GAS STATION THAT WAS, LUCKILY, RIGHT NEXT TO THE EXIT RAMP. THIS WAS EXTREMELY SCARY, UNEXPECTED, AND COULD HAVE KILLED US IF WE WERE GOING THE FULL HIGHWAY SPEED AND WERE NOT EXITING ON A RAMP. *TR
Power train, Apr 17, 2014
MY PROBLEM STARTED AROUND THE END OF FEBRUARY AND THE PROBLEM IS GETTING WORST. I HAVE A NOISES THAT COMES FROM MY STEERING WHEEL, DRIVING ANY SPEED, AND MAKING COMPLETE TURNS AT ANYTIME IT WILL JUST GO OUT. SOME TIMES IT STARTS WHEN I GO OUT TO START MY CAR UP AND THE MESSAGE BORAD SAYS CHECK POWER STEERING, WHICH MAKING IT VERY HARD TO MAKE TURNS. I CALLED THE DEALERSHIP AND THEY SAID THE KNOW ABOUT RECALL, BUT SAID I HAVE TO WAIT FOR A NOTICE BECAUSE IT'S NOT ALL 2006 CHEVROLET MALIBU'S.
Power train, Mar 17, 2014
TRANSMISSION: CHEVY MALIBU MAXX 2006 LTZ 6 CYC LURCHES SPEED UNDER CONSTANT THROTTLE & STRAIGHT LINE ROAD SURFACE & STEERING WHILE DRIVING AT MEDIUM CRUISING SPEEDS 30-45 MPH. OUR MAXX HAS HAD THIS ISSUE SERVICED TWICE BEFORE; NOW IT IS HAPPENING AGAIN. WHILE MAXX WAS UNDER FACTORY WARRANTY; THE MECHANIC WAS TOLD TO BLANK THE TRANSMISSION'S MEMORY; THIS INSTRUCTION WAS FROM AN INTERNAL FACTORY SERVICE BULLETIN. THIS CHEVY MALIBU MAXX 2006 LTZ HAS HAD ONLY ONE OWNER. THE TRANSMISSION'S MEMORY IS CORRUPTED EVERY 40K SERVICE MILES. *TR
Steering, Power train, May 1, 2013
THIS HAS BEEN HAPPENING FOR SOMETIME NOW. I START MY VEHICLE UP TO GO, PUT IT IN DRIVE AND THE CAR LOSES ITS POWER STEERING(STEERING WHEEL WILL NOT MOVE) AND THE POWER STEERING WARNING SHOWS UP ON THE DASH DISPLAY. I ALSO NOTICE AT A STOP OR AT SLOW SPEEDS THE STEERING WHEEL JUMPS FROM RIGHT TO LEFT QUITE FREQUENTLY. *TR