2006 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,385 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Malibu model years with reports.
Of the 2006 reports, 53 involved a crash and 7 involved a fire. 31 people were injured.
What owners report most often
Recalls and investigations
Steering, electric power assist systemFeb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Campaign 15V064000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Air bags, frontalOct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Campaign 06V417000 on NHTSA.gov
Equipment, other, labelsOct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 05V486000 on NHTSA.gov
Representative owner complaints
1,385 reports, newest first.
Steering, Mar 18, 2018
TOUQE STEERING SENSOR WAS NOT MESSING UP WHEN RECALL WAS PREFROM FEB 2 2016 AND NOW IT IS AND CHEVY WON'T WARRANTY CAR ONLY HAS 135K
Exterior lighting, Service brakes, Mar 15, 2018
BRAKE LIGHTS ILLUMINATE WHEN BRAKE PEDAL IS APPLIED. WILL GO OFF WHEN FOOT IS TAKEN OFF OF PEDAL, BUT WILL GO BACK ON AND STAY ON WHEN PEDAL IS NOT APPLIED. THIS HAPPENS BOTH WHEN IN NEUTRAL AND IN PARK AND THE CAR IS STATIONARY. I BELIEVE THE PROBLEM IS WHERE INCREASED RESISTANCE IN THE BODY CONTROL MODULE (BCM) CONNECTION SYSTEM CAN RESULT IN VOLTAGE FLUCTUATIONS OR INTERMITTENCY IN THE BRAKE APPLY SENSOR (BAS) CIRCUIT THAT CAN CAUSE BRAKE LAMP MALFUNCTION. THE BRAKE LAMPS ILLUMINATE WITHOUT THE BRAKE PEDAL APPLIED. RECALL ON THIS PROBLEM DATED MARCH 2017, # 13036. THIS RECALL PROBLEM AND NUMBER DOES NOT SHOW UP IN THE NHTSA DATABASE.
Seats, Mar 14, 2018, fire
HEATED SEAT MALFUNCTION: TURNED HEATED SEAT ON LOWEST NUMBER AS WE LEFT HOME AND WITHIN ABOUT 1/4 OF A MILE THE SEAT BECAME EXTREMELY HOT ON MY SONS BOTTOM AND WE STARTED SMELLING A SCENT OF BURNING. MY SON IMMEDIATELY TURNED OFF THE HEATED SEAT AND RAISED UP OFF THE SEAT UNTIL I COULD GET THE CAR PULLED OVER. WHEN HE GOT OUT WE SAW A HOLE HAD BURNED INTO THE SEAT. IT ALSO BURNED A SMALL HOLE IN HIS PANTS. HE COULD HAVE BEEN SEVERELY INJURED IF WE HAD OF NOT BEEN ABLE TO PULL OVER QUICKLY.
Steering, Mar 12, 2018
POWER STEERING MOTOR STOPPED WORKING WHILE DRIVING, CAR HAS ONLY 79K MILES. DEALERSHIP DIAGNOSED THE POWER STEERING MOTOR WENT BAD, BUT THERE IS NO RECALL ON MY VEHICLE?.
Steering, Feb 28, 2018
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE OPERATING THE VEHICLE; THE "POWER STEERING" WARNING MESSAGE DISPLAYED AND THE STEERING WHEEL WOULD JERK AND VIBRATE. THE FAILURES WERE NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 140,000.
Steering, Feb 26, 2018
WHILE DRIVING THE STEERING WHEEL WILL LOCK AND LOSS POWER CAUSING THE DRIVER MORE OF AN EFFORT TO STEER THE CAR IN THE DIRECTION THAT THE CAR IS GOING SHOULD AS CURVES IF THE STEERING WHEEL LOCKS ON A CURVE THE CAR WILL CONTINUE TO GO STRAIGHT INSTEAD OF AROUND THE CURVE
Steering, Feb 20, 2018
WARNING COMES ON RADIO WITH WARNING BEEPS AND ALL POWER STEERING IS LOST UNTIL YOU TURN OFF CAR AND RESTART. IT CAN HAPPEN DURING ANY DRIVING SITUATION AT ANY SPEED. THE CAR HAS ALREADY HAD THE INITIAL RECALL TAKEN CARE OF FOR THIS SAME PROBLEM EVEN THO WE NEVER EXPERIENCED A PROBLEM WITH IT THEN. NOW EVEN THO ANOTHER RECALL WAS ISSUED THEY SAY MY CAR ISN'T IN THAT GROUP. MAKES NO SENSE.
Steering, Feb 20, 2018
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 60 MPH, THE VEHICLE SUDDENLY LOSS THE POWER STEERING ABILITY. THERE WERE NO WARNING INDICATORS ILLUMINATED BEFORE THE FAILURE. THE VEHICLE WAS DRIVEN TO OURISMAN CHEVROLET OF BALTIMORE (6633 SECURITY BLVD, WOODLAWN, MD 21207) AND THE CONTACT WAS INFORMED THAT SHE WOULD HAVE TO PAY TO HAVE IT DIAGNOSED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. IN 2014, THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT TO FILE A COMPLAINT WITH NHTSA. THE FAILURE MILEAGE WAS 105,181.
Fuel/propulsion system, Feb 19, 2018
FUEL PUMP PRESSURE SENSOR NOT WORKING VERY EXPENSIVE TO REPLACE
Steering, Feb 19, 2018
OUR CAR JUST RECENTLY STARTING HAVING THE POWER STEERING GO OUT. SOMETIMES WHEN WE FIRST START UP THE WARNING BELL SOUNDS AND THERE IS NO STEERING. OTHER TIMES WE CAN BE DRIVING DOWN THE ROAD AND THE WARNING BUZZER SOUNDS AND THERE IS NO POWER STEERING. IT IS A LOT SCARY WHEN YOU ARE DRIVING THE INTERSTATE, RUNNING 75 MPH AND THAT BUZZER GOES OFF. WE WERE TOLD BY THE GARAGE THAT THERE WAS A RECALL FOR THIS PROBLEM BUT IT WAS ONLY GOOD FOR 10 YEARS OR 150,000 MILES. NEEDLESS TO SAY, WE ARE OVER THE 10 YEARS BUT OUR MILEAGE IS AT 103,000 MILES. I WOULD THINK THAT WITH THIS BEING A SAFETY ISSUE, THE RECALL WOULD STILL BE OPEN. WE WERE TOLD BY A MECHANIC THAT IT'S A SENSOR IN THE STEERING COLUMN BUT CAN ONLY BE REPAIRED BY CHEVY.
Fuel/propulsion system, Feb 15, 2018
I FILLED MY GAS TANK AND WHEN I STARTED MY CAR, THE FUEL LIGHT LEVEL WENT FROM FULL TO EMPTY WITH THE WARNING LIGHT "LOW FUEL" LIT UP. THEN THE SERVICE ENGINE LIGHT CAME ON. AFTER ABOUT 3 TO 4 TIMES OF DRIVING THE VEHICLE, IT SEEMED TO GO BACK TO NORMAL, THAT IS UNTIL THE NEXT TIME AND THE NEXT TIME AND SO ON THAT I FILLED MY GAS TANK. IT IS CURRENTLY DOING THE SAME THING. I DO NOT EVER KNOW HOW MUCH GAS I HAVE IN THE CAR BECAUSE THE NEEDLE GOES UP AND DOWN CONSTANTLY.
Steering, Feb 10, 2018
RECALL 14116, STEERING SHAFT TORQUE SENSOR WAS PERFORMED 1 APRIL 2016 AT 37560 MILES. ON APPROX. 1-05-18, AT APPROX. 76000 MILES, THE STEERING FAILED COMPLETELY RESULTING IN EXTREMELY DIFFICULT CONTROL OF THE VEHICLE. THIS WAS LESS THAN 2 YEARS AFTER THE RECALL REPLACEMENT. UPON DIAGNOSIS TECHNICIANS FOUND THAT THE STEERING SHAFT TORQUE SENSOR AND THE ELECTRONIC POWER STEERING MOTOR CONTROL MODULE HAD FAILED. THE MOTOR CONTROL MODULE PROBABLY FAILED DUE TO INCREASED STRESS ON THE SYSTEM DUE TO THE TORQUE SENSOR HAVING FAILED. THE REPAIR SHOP HAD TWO ORIGINAL EQUIPMENT REPLACEMENTS FOR THE MOTOR CONTROL MODULE FAIL OUT OF THE BOX BEFORE A GOOD ONE WAS PROVIDED, AND BOTH UNITS HAD TO BE REPEATEDLY TESTED AND ADJUSTED BEFORE ACCEPTABLE PERFORMANCE WAS REACHED. BASED ON THE HISTORY OF THESE TYPE FAILURES IT IS APPARENT THAT GM HAS NOT CORRECTED THE PROBLEMS WITH THESE SYSTEM COMPONENTS. IT COST $747.36 FOR PARTS, AND $234.00 LABOR FOR THE REPAIR, NOT INCLUDING TAX. IT IS NOT ACCEPTABLE THAT GM IS NOT ACTUALLY CORRECTING THE APPARENT DESIGN ISSUES WITH THESE SYSTEMS, BUT IS CONTINUING TO USE THEM IN VEHICLES EVEN WITH THEIR HISTORY OF FAILURE. GM CUSTOMER SERVICE OFFERED NO HELP AT ALL FOR THE COST OF THIS REPAIR EVEN THOUGH THEIR PARTS APPEAR TO BE DEFECTIVE IN DESIGN. THEIR ONLY RESPONSE WAS THAT THEY HAD MADE THE RECALL CORRECTIONS AT NO COST ONCE AND WOULD NOT DO IT AGAIN. YET THE OEM REPLACEMENT PARTS FAILED REPEATEDLY OUT OF THE BOX. IT SEEMS THAT GM SHOULD HAVE SOME RESPONSIBILITY AS THEY CONTINUE TO PRODUCE DEFECTIVE PRODUCTS THAT APPEARS TO FAIL REPEATEDLY..
Steering, Feb 9, 2018
POWER STEERING INTERMITTENTLY WORKS THEN DOES NOT WORK AT RANDOM!! I HAVE TAKEN THIS VEHICLE TO A COUPLE OF MECHANICS ALL HAVE INFORMED ME THIS VEHICLE HAS THE SAME POWER STEERING ISSUES AS ALL THE CARS THAT WERE RECALLED, BEING EITHER FAULTY SWITCH UP UNDER DASH & OR IN THE STEERING COLUMN HOWEVER WHEN I ENTER MY VIN# FOR THE RECALL IT DOES NOT SHOW UP. I AM AFRAID MY CAR WILL CAUSE ME TO CRASH .
Steering, Feb 8, 2018
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT'S DAUGHTER ASKED HIM TO TEST DRIVE THE VEHICLE BECAUSE SHE WAS HAVING ISSUES WITH THE STEERING WHEEL. UPON STARTING THE VEHICLE, THE POWER STEERING ASSIST APPEARED TO WORK INTERMITTENTLY. WHEN THE VEHICLE WAS SHIFTED INTO DRIVE, THE STEERING WHEEL SEIZED AND THE ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS THEN DRIVEN TO JIMMY GRAY CHEVROLET (181 GOODMAN RD E, SOUTHAVEN, MS 38671 (866) 377-0570) WHERE IT WAS DIAGNOSED THAT THE DRIVESHAFT TORQUE SENSOR FAILED AND THE STEERING SHAFT TORQUE SENSOR NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED DUE TO COST. THE CONTACT STATED THAT THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING), WHICH WAS GM RECALL NUMBER: 14116, IN JULY OF 2016. THE DEALER STATED THAT THE WARRANTY FOR THE TORQUE SENSOR EXPIRED AFTER TWELVE MONTHS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000.
Steering, Feb 5, 2018
THE POWER STEERING WILL GO OUT RANDOMLY SOMETIMES WHILING TURNING AND ALSO WHEN THE CAR FIRST STARTS SOMETIMES. ALSO THE STEERING WHEEL SHAKES WHEN THE CAR IS NOT IN MOTION.
Steering, Feb 5, 2018
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 15 MPH, THE POWER STEERING FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO DENNY MENHOLT RAPID CHEVROLET CADILLAC (2323 E MALL DR, RAPID CITY, SD 57701, (605) 343-1282) WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 15V046000 (STEERING), BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS OFFERED A REPAIR AT A REDUCED COST. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. THE VIN WAS NOT AVAILABLE.
Steering, Jan 29, 2018
THE STEERING WHEEL MOVES BACK AND FORTH ON ITS OWN. I HAVE LOSS POWER STEERING POWER WHILE DRIVING. THE VEHICLE ALSO UNEXPECTEDLY DOES A HARD RIGHT ON ITS OWN WHILE DRIVING. VERY SCARY ESPECIALLY WHILE DRIVING ON THE FREEWAY. I HAVE DONE SOME RESEARCH AND IT SEEMS THIS IS A COMMON PROBLEM WITH THE MALIBUS. IT SEEMS THE ELECTRONIC POWER STEERING MOTOR OR TORQUE SENSOR IS MALFUNCTIONING.
Steering, Jan 29, 2018
THERE IS A PROBLEM WITH THE POWER STEERING IN THE CAR. IT WAS RECALLED IN 2015 BECAUSE THE POWER STEERING COULD STOP WORKING AT ANY TIME. I TOOK THE CAR IN IN 2015 AND WAS TOLD IT WAS FIXED. NOW RECENTLY THE CAR LOSES ITS POWER STEERING WHEN STARTING THE CAR. THE CAR HAS BEEN STATIONARY AND I KNOW ENOUGH NOT TO DRIVE IT, BUT IT HAS HAPPENED A FEW TIMES NOW OVER THE PAST TWO DAYS, WHERE THE POWER STEERING IS ENABLED. THIS IS THE SAME PROBLEM THAT WAS RECALLED IN 2015 UNDER SAFETY RECALL NUMBER 14772. WHAT IS THE NEXT STEP TO GET THIS FIXED AGAIN BECAUSE THIS IS A SAFETY CONCERN AND A KNOWN ISSUE THAT IS NOW REOCCURRING AND SHOULD BE COVERED UNDER THIS RECALL STILL.
Steering, Jan 29, 2018
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 20 MPH, THE STEERING WHEEL LOCKED, WHICH MADE IT DIFFICULT TO TURN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 72,000.
Steering, Vehicle speed control, Engine, Jan 16, 2018
ENGINE POWER REDUCED, TRACTION CONTROL, SERVICE ENGINE LIGHT THE FIRST TIME THE ISSUE OCCURRED, MY CAR WAS IN PARK. I STARTED MY VEHICLE, IT DIDNT TURN OVER ON THE FIRST TRY, I SIMPLY TRIED AGAIN AND IT STARTED BUT A SERVICE MESSAGE POPPED UP STATING "ENGINE POWER REDUCED AND MY CAR WOULD NOT ACCELERATE AT ALL, MY TRACTION CONTROL LIGHT CAME ON AS WELL AS SERVICE ENGINE SOON. I LET MY CAR SIT FOR A WHILE AND DECIDED TO TURN MY CAR OFF AND TRY AGAIN, SAME MESSAGE, SEVERAL HOURS LATER IT STARTED FINE, THE HECK ENGINE LIGHT WAS ON AND I DROVE IT WITH NO ISSUES, STARTED MY CAR AGAIN AND THE CHECK ENGINE LIGHT TURNED OFF. ABOUT A WEEK LATER, THIS HAPPENED AGAIN, SAME CIRCUMSTANCES. ABOUT 2 WEEKS LATER, WHILE DRIVING DOWN THE ROAD, THIS HAPPENED AGAIN AND MY CAR SLOWED DOWN DRASTICALLY AND WOULDNT EXCEED 10 MPH. THE NEXT TIME I DROVE THE VEHICLE MY CAR FLASHED A WARNED MESSAGE SIMPLY STATING " POWER STEERING" WITH NO NOTICEABLE SIGNS OF LOSS OF POWER STEERING, HOWEVER LAST YEAR I HAD TO REPLACE A SENSOR FOR MY POWER STEERING THAT WAS A RECALL, WHEN I BROUGHT IT TO A DEALERSHIP TO BE FIXED THEY CLAIMED MY RECALL WAS FIXED AND THEY WOULDNT COVER THE COST, AFTER REPLACING THE RECALL AFFECT SENSOR I NO LONGER HAD THE ISSUE, I HAVE REPLACED SEVERAL PARTS TO TRY TO FIX THIS ISSUE, SO THE FAULT IS CURRENTLY UNKNOWN. I HAVE RESEARCHED THIS ISSUE AND SEEN THAT MANY OTHER PEOPLE HAVE HAD THIS ISSUE. GM HAS DONE NOTHING TO FIX THIS VERY DANGEROUS CONDITION.
Steering, Jan 9, 2018
SHUT OFF CAR TO GET GAS, WHEN I RESTARTED THE CAR, THERE WAS A CHIME AND A MESSAGE THAT READ POWER STEERING. THE CAR HAD NO POWER STEERING. ONCE I TURNED THE CAR OFF AND THEN RESTARTED IT, THE POWER STEERING RETURNED. I SAW THAT IN 2014 THERE WAS A RECALL FOR THE EPS AND I CONTACTED A CHEVY DEALERSHIP WHICH TOLD ME THE RECALL WAS CLOSED IN 2015.
Steering, Jan 3, 2018
LOSS OF POWER STEERING WHILE DRIVING. STEERING SHAFT TORQUE SENSOR WAS REPLACED IN MARCH OF 2015. I'VE HAD IT DIAGNOSED AND THE SAME PART IS COMING UP DEFECTIVE AGAIN. OUR 17 YEAR OLD SON DRIVES THIS TO SCHOOL AND WORK AND WE CANNOT ALLOW HIM TO DRIVE IT NOW BECAUSE IT IS VERY UNSAFE. I'VE CALLED CHEVY AND THEY WILL NOT REPLACE IT FOR US. THEY SAID TAKE IT TO A CHEVY DEALER AND UNFORTUNATELY IT WILL BE AN OUT OF POCKET EXPENSE. WE HAVE ONLY OWNED THE CAR SINCE 05/17. I DO NOT FEEL LIKE WE SHOULD BE LIABLE TO PAY FOR THIS. THERE IS OBVIOUSLY SOMETHING WRONG WITH THIS PART IF IT'S BAD AGAIN JUST 2 AND A HALF YEARS LATER. WE NOW HAVE A CAR THAT WE CANNOT OPERATE SAFELY AND CAN'T AFFORD TO FIX SINCE THIS IS AN EXPENSIVE REPAIR. IF THE RECALL DIDN'T FIX THE PROBLEM THE FIRST TIME HOW CAN CHEVY NOT BE RESPONSIBLE TO MAKE THIS RIGHT? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *PM
Steering, Dec 20, 2017
MY POWER STEERING RANDOMLY GOES OUT WHILE DRIVING. I BELIEVE AT ONE POINT THERE WAS A RECALL FOR THIS EXACT PROBLEM.
Steering, Dec 18, 2017
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 45 MPH, THE STEERING WHEEL SEIZED AND THE POWER STEERING ASSIST WARNING INDICATOR ILLUMINATED. THE DRIVER COASTED TO THE SIDE OF THE ROAD, WAITED FOR A WHILE, AND WAS ABLE TO RESUME DRIVING. THE FAILURE RECURRED THREE TIMES WHILE ATTEMPTING TO REACH TO THE DESTINATION. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER STATED THAT THE VEHICLE WAS OUT OF MILEAGE AND WARRANTY, AND DID NOT OFFER FURTHER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 186,000.
Steering, Dec 16, 2017
STEERING WHEEL IS LOCKING UP AND POWER STEERING ON THE RADIO