2006 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,385 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Malibu model years with reports.
Of the 2006 reports, 53 involved a crash and 7 involved a fire. 31 people were injured.
What owners report most often
Recalls and investigations
Steering, electric power assist systemFeb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Campaign 15V064000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Air bags, frontalOct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Campaign 06V417000 on NHTSA.gov
Equipment, other, labelsOct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 05V486000 on NHTSA.gov
Representative owner complaints
1,385 reports, newest first.
Wheels, Dec 14, 2017
WHILE DRIVING 10 MPH TC LIGHT CAME ON AND STAYED ON WHILE THE VEHICLE DID NOT RESPOND TO THE WHEEL TURNING OR TO THE BREAKS BEING PRESSED TO THE FLOOR. ABOUT 20 MILES LATER WHILE SLOWING FROM 20 MPH THE TC LIGHT CAME ON AGAIN AND THE BREAKS FAILED TO WORK CAUSING THE VEHICLE NOT TO STOP WHEN NEEDED. CHECKED ALL TIRES EACH TIME TO MAKE SURE NO FLATS OR OBVIOUS ISSUES AND THERE WERE NONE.
Steering, Dec 11, 2017
INTERMITTENT LOSS OF POWER STEERING WHILE DRIVING RESULTING IN A REQUIREMENT TO DRIVE WITH ONLY MANUAL STEERING WHICH REQUIRES GREATER FORCE AND LOWERS THE ABILITY TO REACT QUICKLY TO TRAFFIC PATTERS DRAMATICALLY. THIS HAPPENS BOTH WHILE THE VEHICLE IS IN MOTION AND STOPPED. TURNING THE POWER ON AND OFF RESULTS IN TEMPORARILY RESTORING POWER STEERING. WORTH NOTING, GM SAID THE RECALL WAS CLOSED FOR THIS VEHICLE AND THE REPAIR WAS ALREADY PERFORMED, BUT FAILED TO BRING RESOLUTION TO THE PROBLEM, EVEN THOUGH IT IS THEIR SENSOR THAT IS NOW NOT FUNCTIONING AGAIN. PRESUMABLY VEHICLE WAS FIXED WITH ANOTHER FAULTY PART FROM GM OR WAS NEVER ACTUALLY FIXED TO BEGIN WITH. THIS PROBLEM CREATES A HUGE SAFETY CONCERN FOR BOTH THE DRIVER AND OTHER DRIVERS ON THE ROAD.
Steering, Dec 6, 2017
AS I WAS DRIVING LAST WEEK THE STEERING WHEEL BEGAN TO SHAKE AND I DIDN'T UNDERSTAND WHAT WAS GOING ON. THE FOLLOWING DAY, WHILE BACKING UP, A BELL BEGAN RINGING AND I COULDN'T TURN THE STEERING WHEEL. I THEN NOTICED THE POWER STEERING LIGHT WAS FLASHING. I IMMEDIATELY PULLED THE CAR UP AND TURNED IT OFF. I PHONED THE CHEVROLET COMPANY BOTH IN TOWN AND THE ONE ON THE WEBSITE AND ASKED, " WAS THERE A RECALL ON THE STEERING WHEEL" WAS TOLD NO. I TOOK THE CAR IN FOR SERVICE TO THE COMPANY AND WAS CHARGED $109.00, THEN WAS TOLD I NEED TO REPLACE THE POWER STEERING ASSIST MOTOR MODULE WITH AN ESTIMATED COST OF $807.14 AND IF THAT DOESN'T SOLVE THE PROBLEM; I WILL HAVE TO PURCHASE A TORQUE SENSOR WITH AN ESTIMATED COST OF $1269.54. I INFORMED THE COMPANY I DIDN'T FEEL THAT'S FAIR BECAUSE PROBLEM IT IS A MANUFACTURING PROBLEM, NOT ANYTHING I DID. I WAS TOLD IT ISN'T UNDER WARRANTY, HOWEVER, BASED ON THE RESEARCH I'VE DONE, I THOUGHT AS LONG AS THE PART WAS IN STOCK IT CAN BE REPLACED. A REPRESENTATIVE WAS TRYING TO HELP ME UNDERSTAND WHY IT'S NOT THEIR RESPONSIBILITY BUT I JUST DON'T UNDERSTAND WHY IT ISN'T, DUE TO THIS BEING A SAFETY ISSUE. I'M CONFUSE WHEN CERTAIN MALIBU'S HAD THIS RECALL, WHY ALL OF THEM WEREN'T AT LEAST CHECKED. I WAS ALSO TOLD THE CAR IS OLD, I UNDERSTAND THAT, BUT IT'S MINE AND IT'S ALL I HAVE AND I HAVE TAKEN GOOD CARE OF THE CAR AND IT HAS TAKEN CARE OF ME, NOT ONLY THAT I CAN'T AFFORD A NEW CAR WITH A PART-TIME JOB. THANK YOU FOR TAKING THE TIME TO READ MY COMPLAINT.
Steering, Dec 1, 2017
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 45 MPH, THE POWER STEERING WARNING INDICATOR ILLUMINATED AND THE POWER STEERING SEIZED. THE CONTACT WAS ABLE TO TURN THE VEHICLE OFF AND BACK ON, AND THE VEHICLE OPERATED NORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC POWER STEERING MODULE MALFUNCTIONED AND NEEDED TO BE REPROGRAMMED OR REPLACED. JOSEPH CHEVROLET (8733 COLERAIN AVE, CINCINNATI, OH 45251, (513) 741-6700) WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V064000 (STEERING). THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
Steering, Nov 23, 2017
ON 11-18-2017 THE STEERING WHEEL ON THIS CAR STARTS TO MOVE BACK AND FORTH BY ITSELF. WHEN DRIVING, THE POWER STEERING STOPS WORKING, THEN STARTS WORKING. YOU CAN HEAR A NOISE IN THE STEERING COLUMN LIKE CRACKLING. SOUNDS LIKE A SENSOR LOOKING FOR SOMETHING. WHEN POWER STEERING IS OUT, CAR CAN BARELY BE TURNED. THIS CAR DID HAVE THE STEERING RECALL WORK DONE ON IT A FEW YEARS AGO. HAVEN'T TALKED TO MY DEALER YET. VERY DANGEROUS. STOPPED DRIVING THE CAR.
Steering, Nov 17, 2017
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE AT A STOP LIGHT PREPARING TO MAKE A LEFT TURN, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE CONTACT TURNED INTO A FUEL STATION WHERE THE VEHICLE REMAINED. THE CONTACT CALLED PARK CHEVROLET KERNERSVILLE (615 NC-66, KERNERSVILLE, NC 27284, PHONE NUMBER: (336) 310-0238) AND WAS INFORMED THAT A RECALL REPAIR WAS ALREADY PERFORMED IN 2015. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER STATED THAT A RECALL REPAIR WAS PERFORMED IN NOVEMBER OF 2014 AND DID NOT OFFER FURTHER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 238,000.
Steering, Oct 18, 2017
STEERING LOCKS UP. THIS HAS HAPPENED SEVERAL TIMES IN THE FEW MONTHS I'VE OWNED THE VEHICLE. IT HAPPENS MOST OFTEN WHEN ATTEMPTING TO TURN WHILE ACCELERATING (SUCH AS TURNING LEFT ONTO A BUSY ROAD). SOMETIMES IT HAPPENED UPON ACCELERATION WITHOUT TURNING. THERE HAS BEEN A RECALL FOR SIMILAR PROBLEMS ON THIS SAME MAKE, MODEL AND YEAR, HOWEVER, WHEN I TYPE IN MY VIN NUMBER, NOTHING COMES UP. IT IS MOST DEFINITELY A MAJOR SAFETY PROBLEM WHICH NEEDS TO BE FIXED ASAP. I CANNOT AFFORD TO DO IT AT THIS TIME. PLEASE TELL ME IF PERHAPS MY VIN JUST DOESN'T SHOW UP, BUT I MAY BE ABLE TO GET IT FIXED AT NO CHARGE DUE TO THE RECALL THAT INVOLVES VERY SIMILAR PROBLEMS/HAZARDS.
Engine, Oct 16, 2017
ENGINE HAS BEGUN MALFUNCTIONING FOR NO REASON. EXPERIENCED PROBLEM 5 TIMES IN PAST WEEK. 1) VEHICLE WAS TRAVELING AT APPROXIMATELY 50 MPH ON FREEWAY. TRACTION CONTROL LIGHT AND CHECK ENGINE LIGHT CAME ON SIMULTANEOUSLY. RADIO INDICATED "REDUCE ENGINE POWER". I RELEASED GAS PEDAL. RADIO THEN INDICATED "ENGINE DISABLED," AND ENGINE SHUT OFF. COASTED TO A STOP. TURNED KEY TO "OFF" POSITION. TRIED TO RESTART, BUT WOULD NOT CRANK (EVERYTHING WAS COMPLETELY SILENT). TRIED TO CRANK AGAIN A MINUTE LATER. ENGINE STARTED WITHOUT HESITATION. CHECK ENGINE LIGHT CAME ON, BUT IMMEDIATELY WENT OFF. DROVE STRAIGHT TO MECHANICAL WITHIN 5 MILES. THERE WERE NO CODES TO READ. 2) VEHICLE WAS TRAVELING 30 MPH ON CITY STREET, MOVING FORWARD. TRACTION CONTROL AND CHECK ENGINE LIGHTS CAME ON. RADIO READ "REDUCE ENGINE POWER" AND WITHIN A FEW SECONDS CHANGED TO "ENGINE DISABLED" AS ENGINE SHUT DOWN. STOPPED CAR. WOULD NOT CRANK. REMOVED KEY AND WAITED ONE MINUTE. CAR CRANKED AND DROVE WITH NO PROBLEM AND NO INDICATOR LIGHTS. 3) VEHICLE WAS STATIONARY IN DRIVEWAY. TRACTION CONTROL AND CHECK ENGINE LIGHTS CAME ON. RADIO INDICATED "REDUCE ENGINE POWER" AND THEN "ENGINE DIABLED". ENGINE SHUT DOWN. TURNED KEY TO "OFF" POSITION. WAITED ONE MINUTE. CAR STARTED AND RAN WITH NO PROBLEM AND NO INDICATOR LIGHTS ON. 4) SAME INCIDENT IN SAME ORDER WHILE TRAVELING 45 MPH ON SERVICE ROAD. 5) HAPPENED IN SAME MANNER WHILE TRAVELING 70 MPH ON FREEWAY.
Electrical system, Oct 12, 2017
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT HAD NOT EXPERIENCED ANY FAILURES UNTIL THE VEHICLE WAS TAKEN TO CHEVROLET OF HOMEWOOD (18033 HALSTED ST, HOMEWOOD, IL 60430, (708) 799-2000) FOR THREE MANUFACTURER RECALLS. WEEKS AFTER THE REPAIR, THERE WAS A LOSS OF POWER AND THE VEHICLE WAS UNABLE TO START. THE CONTACT REPLACED THE BATTERY, THE VEHICLE WOULD NOT START WHEN THE KEY WAS INSERTED IN THE IGNITION. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE DEALER AND MANUFACTURER WERE NOTIFIED. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.
Exterior lighting, Oct 11, 2017
BRAKE LIGHTS ARE ON WHEN NOT PUSHING THE PEDAL. AS SOON AS YOU PUSH THE PEDAL, THE LIGHTS GO OUT. YOU COME REALLY CLOSE TO GETTING REAR-ENDED BECAUSE THE PERSON BEHIND YOU DOESN'T REALIZE THAT YOU ARE STOPPING.
Steering, Sep 21, 2017
POWER STEERING LIGHTS ON DASH BEEPING SOUND AS SOON AS YOU PUT CAR IN GEAR
Steering, Sep 11, 2017
MY VEHICLE CONTINUES TO FLASH POWER STEERING. I WAS TURNING IN AN INTERSECTION AND MY VEHICLE SHOT TO THE RIGHT REALLY HARD. EVERY TIME I AM TURNING ON THE CAR THE POWER STEERING MESSAGE COMES ON BUT, THE POWER STEERING WORKS. I HAVE RESEARCHES AND FOUNS THERE HAS BEEN A RECALL NOT SURE WHAT TO DO.
Steering, Electronic stability control (ESC), Fuel/propulsion system, Aug 19, 2017
2006 MALIBU VIN NUMBER SHOWS NO ACTIVE RECALLS BUT MY WIFE WHO DRIVES THE CAR INFORMED ME THAT THE CAR WAS ACTING FUNNY SO I TOOK FOR DRIVE AND FIRST TURN WHEEL HESITATED LIKE IT DIDN'T WANT TO TURN AND WHEN IT DID COULD FEEL IT ON THE COLUMN LIKE SOMETHING WAS MOVING THAT WASN'T SUPPOSE TO THIS IS MAIN ROAD THROUGH CITY HEAVY TRAFFIC SO IMMEDIATELY HEADED FOR HOME AND HAVE TO CROSS TRACKS TO GET THERE AND WHEN I WENT OVER SOUNDS LIKE FRONT END WANTS TO COME OFF THE CAR SOUNDS LIKE LOOSE STABILITY BAR OR JOINT AND TO TOP IT OFF I NOTICED FUEL GAUGE WAS GOING FROM FULL TO EMPTY AND BACK UP SO IN ACTUALITY SHE HAS KNOW IDEA HOW MUCH HAS SHE REALLY HAS IN VEHICLE I SEEN A LOT OF COMPLAINTS ABOUT THESE THINGS HAPPENING TO THIS MODEL AND I SEND MY WIFE AND KIDS OFF DAILY IN THIS VEHICLE WITH THESE PROBLEMS THAT COULD POSE A HUGE THREAT TO THEIR SAFETY IF IT HAPPENS TO HER ON MAIN ROAD OR RR CROSSING
Fuel/propulsion system, Aug 16, 2017
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT THE FUEL GAUGE WAS NOT DISPLAYING THE ACCURATE INFORMATION, WHICH CAUSED THE VEHICLE TO RUN OUT OF FUEL WITHOUT WARNING. ALSO, THE ENGINE INDICATOR ILLUMINATED. THE VEHICLE FAILED INSPECTION AND THE INDEPENDENT MECHANIC STATED THAT THE DTC INDICATED THAT THE FUEL LEVEL SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS TO BE TAKEN FOR AN APPOINTMENT AT NUCAR CHEVROLET (174 N DUPONT HWY, NEW CASTLE, DE 19720, (888) 626-3594). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THERE WAS NO RECALL FOR THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Steering, Aug 11, 2017
TAKATA RECALL- THE STEERING WHEEL LOCKS UP AT TIMES WHEN I AM TURNING. AFTER A FEW MINUTES IT WILL UNLOCK. IT'S SCARY, ESPECIALLY IF I DON'T KNOW IF IT WILL LET ME STRAIGHTEN UP MY WHEEL OR NOT AFTER THE TURN.
Steering, Electrical system, Aug 7, 2017
WHEN ACCELERATING AROUND 2500-3500 RPM YOU WILL HEAR A CHIMING SOUND IN THE CAR ALL INFORMATIONAL DASH LIGHTS (BRAKES,CHECK ENGINE, LOW TIRE PRESSURE.) WILL SHOW UP ALONG WITH A POWER STEERING ISSUE IN THE DIC (DRIVER INFORMATION CENTER.) WITH POSSIBLE LOSS OF POWER STEERING AFTERWARDS. THE SAME ISSUE ON PREVIOUS YEAR AND SOME 2006 MODELS HAVE A RECALL REGARDING THIS EXACT ISSUE, BUT NOT ALL 2006 MODELS THUS CAUSING A SERIOUS SAFETY CONCERN FOR THOSE THAT ARE EFFECTED BY THE POWER STEERING ISSUE, BUT NOT UNDER THE RECALL.
Steering, Aug 6, 2017
THE ELECTRIC POWER STEERING LOCKS UP MAKING IT IMPOSSIBLE TO STEER THE VEHICLE WHEN ACCELERATING IN A SHARP TURN.
Fuel/propulsion system, Aug 3, 2017
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. AFTER THE CONTACT FILLED UP THE VEHICLE WITH FUEL, THE FUEL GAUGE DISPLAYED EMPTY. THE CONTACT STATED THAT THE LOW FUEL INDICATOR ILLUMINATED, WHICH INDICATED LOW FUEL AFTER A FILL UP OR RANDOMLY WHILE DRIVING. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND TO SUPERIOR CHEVROLET (4770 COVINGTON HWY, DECATUR, GA 30035 (404) 857-2830) WHERE IT WAS DIAGNOSED WITH A FUEL LEVEL SENSOR CIRCUIT HIGH VOLTAGE MALFUNCTION. THE SENSOR NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CALLED AND INFORMED THE CONTACT THAT THE WARRANTY HAD EXPIRED. NO FURTHER ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS UNKNOWN.
Electrical system, Engine, Jul 24, 2017
ENGINE GOES INTO ENGINE POWER REDUCED MODE WHILE GOING 55 ON A HIGHWAY AND SOON THE ENGINE BECOMES DISABLED WHICH DISABLES THE STEERING AND THE BRAKES. NO INJURIES AS I WAS SMART ENOUGH TO HANDLE THE SITUATION, BUT THIS HAS OCCURRED MORE THAN ONCE AND MY CAR READS NO CODES FOR THE SITUATION.
Steering, Jul 19, 2017
WHEN DRIVING OR NOT MOVING DRIVE SHAFT MAKES A CLINGING NOISE WHEN TURNING CALLED CHEVY THEY TOLD ME IT WAS ALREADY REPLACED UNDER RECALL , HAD A MECHANIC CHEK IT OUT SAY MY FRONT END IS O K .SO I LOOKED UP ON COMPUTER FOR RECALLS .CAR HAS 80000 MILES ON CAR SHAFT WAS REPLACED AT 67000MILES DEFECT IS BACK
Steering, Jun 27, 2017
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING VARIOUS SPEEDS, THE STEERING WHEEL VIBRATED AND THE VEHICLE PULLED FROM LEFT TO RIGHT. THE VEHICLE BECAME DIFFICULT TO STEER AND LOST POWER STEERING ABILITY. THE VEHICLE WAS TAKEN TO THE DEALER (HARBIN CHEVROLET IN SCOTTSBORO, SC) WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN OR THE STEERING ASSIST MOTOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED DUE TO THE DIAGNOSTIC FEES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 114,000.
Steering, Jun 20, 2017
I HAD ONE RECALL ON IT WHEN CHEVY REPLACED A PART IN THE STEERING ABOUT 2 YEARS AGO AND THE CAR WAS DRIVING FINE AFTER. AS OF THE PAST FEW MONTHS THERE IS A RATTLE AND PULSATION IN THE STEERING WHEEL WHILE DRIVING. I SEE A LOT OF PEOPLE HAVE THIS ISSUE AND A FEW OF THEM HAD SOME PARTS CHANGED BUT THE PROBLEM IS STILL THERE. PLEASE LOOK INTO THIS BECAUSE THIS IS DANGEROUS
Electrical system, Jun 16, 2017
MY CAR SHUTS OFF WHILE DRIVING. THE LOW RPMS WILL FLUCTUATE AND THE POWER WILL TURN OFF.
Steering, Jun 6, 2017
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. WHILE ATTEMPTING TO ACCELERATE AT VARIOUS SPEEDS, THREE CHIMES SOUNDED, THE VEHICLE SEIZED, PULLED TO THE RIGHT, AND THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE CONTACT STATED THAT IF THE FAILURE OCCURRED WHILE IN CRUISE CONTROL, IT WOULD CANCEL THE CRUISE CONTROL. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC. THE DEALER WAS CONTACTED AT 304-422-6501 AND CONFIRMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL AND THAT THE SHAFT TORQUE SENSOR KIT NEEDED TO BE REPLACED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFUSED TO PROVIDE A CASE NUMBER OR EMAIL AFTER INFORMING THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 382,000.
Steering, Jun 2, 2017
TAKATA RECALL I BEARLY MERGED ON THE HIGHWAY AND MY CAR,S STEERING WHEEL GOT HARD TO MANUEVER AND THE VWHICLE STARTED SLOWING DOWN. I HAD TO STRUGGLE TO SLOWLY PULL OVER MY CAR ON SIDE OF HIGHWAY AMD TURNED IT OFF. MY CAR WOULDNT START UP AMD WHEN IT DID MY STEERING WHEEL WAS HARD TO TURN.