2001 Ford Escape
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,027 owner complaints filed for this model year. This is the 14th highest complaint count among 26 Escape model years with reports.
Of the 2001 reports, 77 involved a crash and 60 involved a fire. 75 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Structure, frame and membersApr 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14S02.
Campaign 14V165000 on NHTSA.gov
Engine and engine coolingJul 26, 2012
Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used.
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. Owners may contact Ford at 1-866-436-7332.
Campaign 12V353000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleJan 9, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 2001-2002 ESCAPE VEHICLES MANUFACTURED FROM OCTOBER 22, 1999, THROUGH JULY 19, 2002, EQUIPPED WITH A BRAKE MASTER CYLINDER RESERVOIR CAP THAT COULD LEAK BRAKE FLUID. IF BRAKE FLUID LEAKS FROM THE CAP, IT COULD COME IN CONTACT WITH THE ANTILOCK BRAKE SYSTEM (ABS) MODULE WIRING HARNESS CONNECTOR.
CORROSION CAN DEVELOP IN THE ELECTRICAL CONNECTOR LEADING TO MELTING, SMOKE OR A FIRE.
DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER RESERVOIR CAP AND THE ABS ELECTRICAL SYSTEM WILL BE MODIFIED. AN INTERIM LETTER WAS MAILED ON JANUARY 20, 2012. DUE TO A PARTS DELAY, HOWEVER, THE REMEDY MAY NOT BE AVAILABLE CURRENTLY. IF PARTS ARE NOT AVAILABLE, FORD WILL INSTRUCT OWNERS TO PARK THEIR VEHICLES OUTSIDE UNTIL SUCH TIME AS PARTS BECOME AVAILABLE. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. THIS RECALL CAMPAIGN IS RELATED TO 07V-156.
Campaign 12V005000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 10, 2007
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED.
DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 07V156000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Apr 6, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.0L V6 ENGINES, DURING DECELERATION, THE ENGINE CAN STALL.
SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
DEALERS WILL REPROGRAM THE POWER CONTROL MODULE (PCM) WITH THE APPROPRIATE CALIBRATION. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V165000 on NHTSA.gov
Seat belts, front, buckle assemblyDec 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES, A POST WITHIN THE SAFETY BELT BUCKLE COVERS COULD FRACTURE, WHICH COULD AFFECT LATCH FUNCTION, RESULTING IN EITHER A "NO LATCH" OR "PARTIAL LATCH" CONDITION. IN THE "PARTIAL LATCH" CONDITION, THE BUCKLE TONGUE CAN BE INSERTED INTO THE BUCKLE AND APPEAR TO BE ENGAGED, BUT WILL RELEASE FROM THE BUCKLE WITHOUT THE PUSH BUTTON BEING DEPRESSED WHEN A RELATIVELY LOW LOAD IS APPLIED, SUCH AS WHEN AN OCCUPANT MOVES SLIGHTLY IN THE SEAT.
IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.
DEALERS WILL HAVE THE DRIVER AND FRONT PASSENGER SAFETY BELT BUCKLE COVER REMOVED AND REPLACED WITH A NEWLY DESIGNED SERVICE BUCKLE COVER. OWNER NOTIFICATION BEGAN ON FEBRUARY 2, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V507000 on NHTSA.gov
Visibility, windshield wiper/washer, linkagesNov 27, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE WINDSHIELD WIPER LINKAGE CAN DISENGAGE DUE TO A BROKEN BALL SOCKET.
THIS CONDITION WILL LIKELY RESULT IN SUDDEN AND COMPLETE LOSS OF THE WINDSHIELD WIPER FUNCTION, OR OF THE WIPER FUNCTION ON THE DRIVER SIDE ONLY, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE WIPER MODULE.
Campaign 00V387002 on NHTSA.gov
Fuel system, gasoline, deliverySep 18, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE O-RING SEALS IN THE FUEL LINE CONNECTOR AT THE OUTLET END OF THE FUEL FILTER WERE DAMAGED WHEN THE LINE WAS CONNECTED TO THE FILTER DURING VEHICLE ASSEMBLY. IN SOME CASES, THIS DAMAGE COULD RESULT IN A FUEL ODOR, OR POSSIBLY IN FUEL DRIPPING FROM THE CONNECTION.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE FUEL LINE. OWNER NOTIFICATION BEGAN SEPTEMBER 27, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V277001 on NHTSA.gov
Wheels, hubcap/coverSep 12, 2000
VEHICLE DESCRIPTION: SOME 4X2 SPORT UTILITY VEHICLES NOT EQUIPPED WITH AN ANTILOCK BRAKING SYSTEM MAY HAVE INADVERTENTLY BEEN BUILT WITH 4X4 REAR HUBS INSTEAD OF 4X2 HUBS. IF THE INCORRECT HUBS ARE INSTALLED ON A 4X2 VEHICLE, THE REAR WHEELS CAN LOOSEN, OR IN SOME CASES, SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD CAUSE LOSS OF CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE REAR HUBS AND, IF NECESSARY, REPLACE THEM. OWNER NOTIFICATION BEGAN SEPTEMBER 25, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V260001 on NHTSA.gov
Vehicle speed controlAug 9, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE CAN HAVE A CRACKED OR MISSING SPEED CONTROL CABLE SERVO CAP LOCATING TAB. THE LOCATING TAB COULD ENTER THE SERVO CLUTCH CAVITY AND INTERFERE WITH THE SPEED CONTROL SERVO CLUTCH. ALSO, WATER COULD ENTER THOSE UNITS THAT CONTAIN A CRACKED OR MISSING SERVO CAP LOCATING TAB, EVENTUALLY CAUSING CORROSION THAT COULD INTERFERE WITH THE FUNCTION OF THE SPEED CONTROL.
IF EITHER OF THESE CONDITIONS OCCURS AND THE SPEED CONTROL IS USED, THE SPEED CONTROL COULD PREVENT THE THROTTLE FROM RETURNING TO IDLE, RESULTING IN A STUCK THROTTLE. A STUCK THROTTLE COULD RESULT IN A CRASH.
DEALERS WILL INSPECT THE SPEED CONTROL CABLES. VEHICLES WITH SPEED CONTROL CABLES FROM CAVITIES 3 AND 4 WILL HAVE THE CABLE THE SPEED CONTROL SERVO REPLACED.
Campaign 00V210001 on NHTSA.gov
Steering, steering wheel/handle barAug 8, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THESE VEHICLES MAY HAVE A MIS-ASSEMBLED OR INCORRECTLY MANUFACTURED NUT THAT ATTACHES THE STEERING WHEEL ASSEMBLY TO THE STEERING COLUMN. THE NUT COULD BE UPSIDE DOWN IN THE STEERING WHEEL ASSEMBLY, WHICH COULD OVERSTRESS THE STEERING COLUMN SHAFT WHEN THE NUT IS TIGHTENED. IN ADDITION, SOME OF THE NUTS MAY HAVE BEEN CRACKED DURING MANUFACTURE RESULTING IN THE NUT FRACTURING WHEN IT IS TIGHTENED DURING VEHICLE ASSEMBLY.
EITHER OF THESE CONDITIONS CAN LEAD TO THE STEERING WHEEL BECOMING LOOSE OR SEPARATING FROM THE STEERING COLUMN, RESULTING IN LOSS OF STEERING CONTROL.
DEALERS WILL INSPECT AND REPLACE THE STEERING WHEEL RETENTION ARMATURE AND, IF NECESSARY, THE STEERING COLUMN TO CORRECT THIS CONDITION.
Campaign 00V223001 on NHTSA.gov
Representative owner complaints
1,027 reports, newest first.
Other or unspecified, Sep 9, 2005
9/8/05 MY HUSBAND CALLED VARSITY FORD ABOUT RECALL OF RE: CRUISE ON EXPEDITION 9/9/05 AS INSTRUCTED, I TOOK EXPEDITION TO VARSITY FOR REPAIR. ON WAY HOME NOTICED CRUISE DOES NOT WORK. MY HUSBAND HAD BEEN TOLD THIS WOULD BE A REPAIR NOT A DISCONNECT SO HE CALLED VARSITY. HE WAS TOLD I WOULD NEED AN APPT. TO CHECK THE CRUISE. I CALLED TO MAKE THE APPT. AND STATED SINCE THE CRUISE WORKED FINE BEFORE THE RECALL WORK, VARSITY WOULD NOT CHARGE ME TO GET IT WORKING AGAIN. I WAS TOLD,"NO. PROBABLY THE CRUISE MODULE HAS BLOWN." VARSITY REP, MONTY GUY STATED WOULD DO THE CHECK FOR FREE BUT TAKES NO RESPONSIBILITY FOR REPAIRS. I STATED THE CRUISE WORKED FINE BEFORE THE RECALL WORK. I WAS AGAIN TOLD VARSITY WILL TAKE NO RESPONSIBILITY FOR ANY PARTS GOING OUT FROM RECALL WORK. I CALLED FORD MOTOR. I WAS TOLD TO HAVE THE CHECK FOR FREE AND IF THE HARNESS IS LOOSE THERE WILL BE NO CHARGE, BUT FORD TAKES NO RESPONSIBILITY FOR ANY DAMAGE DONE TO THE VEHICLE BY THE DEALER. THIS IS A SCAM. PEOPLE, SUCH AS MYSELF, ARE TAKING THEIR VEHICLE IN TO THE DEALERS IN GOOD FAITH FOR YOUR RECALL ONLY TO GET A DAMAGED VEHICLE BACK. THEN THE DEALER REFUSES TO ACCEPT RESPONSIBILITY SO HE CAN GET THE VEHICLE BACK IN AND HAVE CHARGES AGAINST THE CUSTOMER. I AM IN THE PROCESS OF INFORMING ALL I KNOW WITH A FORD AND THE STATE ATTORNEY GENERAL'S OFFICE. SHAME ON YOU. THE PUBLIC LOOKS TO YOU FOR HELP. ALL YOUR RECALL HAS DONE IS SET GOOD PEOPLE UP FOR WHAT IS TO ME A BLATANT SCAM BY FORD. *NM
Air bags, Sep 8, 2005, crash
IN JUNE 2005, I WAS TRAVELING TO WORK WHEN MY CAR HYDROPLANED AND I HIT A BRIDGE. UPON IMPACT, NONE OF MY AIR BAGS DEPLOYED. I SUFFERED A FEW BUMPS AND BRUISES BUT NEVER WENT TO THE DOCTOR. IF THE ACCIDENT WERE WORSE THAN WHAT IT WAS AND THE AIR BAGS MALFUNCTIONED, I COULD HAVE BEEN KILLED. I WENT TO FORD AND NOTHING WAS EVER DONE ABOUT IT. IT WAS NEVER LOOKED INTO TO SEE IF THEY DID INFACT MALFUNCTION. I LOOKED UP THE RECALLS AND THERE WAS ONE TO THE WHEEL AND SOMETHING ELSE AND I WANT TO SEE IF THAT RECALL WERE FIXED. *JB
Power train, Sep 6, 2005
THE TRANSMISSION IN DRIVE AND REVERSE WENT OUT WHILE WE WERE ON VACATION. I WAS ABLE TO START GOING IN 2ND GEAR AND THEN SHIFT TO DRIVE TO GO UNTIL I GOT HOME. THERE WAS NO WARNING LIGHTS THAT THERE WAS A PROBLEM. BOB TOMES FORD SAID THAT I NEED TO REPLACE THE TRANSMISSION. THIS SEEMS A LITTLE BIT RIDICULOUS SINCE MY VEHICLE HAS ALWAYS BEEN PROPERLY MAINTAINED. WE BOUGHT IT NEW. I HAVE ALWAYS DRIVEN A FORD AND HAVE DRIVEN OTHER ONES WELL INTO THE 100,000 MILE RANGE WITH NEVER A PROBLEM. IT IS NOW SITTING UP AT FORD GETTING REPAIRED. IT HAS 65,000 MILES ON IT. *JB
Power train, Aug 30, 2005
(1) [2ND FAILURE] NO WARNING. (2) TRANSMISSION FAILURE COULD HAVE RESULTED IN CRASH. (3) TRANSMISSION REPLACEMENT. *JB
Power train, Aug 30, 2005
2001 FORD ESCAPE 33063 MILES VIN [XXX] COULD HAVE RESULTED IN CRASH. (1) NO WARNING (2) TRANSMISSION FAILURE (3) TRANSMISSION WAS REBUILT BY DEALER UNDER WARRANTY. *JB UPDATED 07/19/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Seat belts, Aug 28, 2005
1. THE AIRBAG LIGHT WOULD STAY ON OR FLASH 2. THERE WAS NO CONSEQUENCE OR FAILURE SINCE I RESPONDED IMMEDIATELY BY TAKING THE CAR TO THE DEALERSHIP 3. DIAGNOSTICS WERE RUN SHOWING DIAGNOSTIC CODE B1881, HIGH RESISTANCE, R&R BOTH SEATS, R&R PRETENSIONS R KITS. REINSTALL AND CLEAR CODES. I WAS TOLD THIS MEANT IN A CRASH, THE FRONT SEAT BELTS (BOTH DRIVER AND PASSENGER) WOULD FAIL TO RETRACT, IN ESSENCE, RENDERING THE SEAT BELTS USELESS. REPAIR KITS WERE INSTALLED ON EACH SEATBELT. PARTS INCLUDED WITH INSTALLATION ARE: PART NUMBER PATSKEY $35.00, 1L8Z 78610E22 AAA KIT REPAIR $103.33, 1L8Z 78610E23 AAA KIT REPAIR $103.33, PLUS LABOR $227.95 FOR A TOTAL OF $523.61. I DON'T THINK CONSUMERS SHOULD HAVE TO PAY FOR SUCH REPAIRS. I WOULD ALSO LIKE TO KNOW IF THIS IS A COMMON FAILURE IN THIS CAR AND SHOULD BE A RECALL ITEM BEFORE SOMEONE GETS HURT. *JB
Power train, Aug 22, 2005
WE ARE A LEASING COMPANY AND HAVE HAD THREE (3) 2001 FORD ESCAPES TO DATE THAT HAVE HAD FAILED TRANSMISSIONS. FORD REFUSES TO ACKNOWLEDGE OUR ATTEMPTS TO GET REIMBURSEMENT.
Vehicle speed control, Aug 15, 2005
IN MAY 2005 THE ACCELERATOR CABLE STUCK WIDE OPEN ON MY 2001 FORD ESCAPE (V-6 ENGINE AUTOMATIC TRANSMISSION) THIS HAPPENED IN MY DRIVEWAY WHEN I PUNCHED DOWN ON THE PEDAL VERY HARD. THERE IS A PLASTIC COVER ON TOP OF THE ENGINE THAT MUST BE REMOVED IN ORDER TO SEE WHERE THE CABLES HOOK UP TO THE THROTTLE BODY. I REMOVED THIS TO DETERMINE IF IT WAS THE THROTTLE BODY OR THE CABLE THAT WAS STUCK. AS I WAS TAKING IT OFF THE CABLE BECAME UNSTUCK ON IT'S OWN SO I WAS UNABLE TO DETERMINE THE PROBLEM. AT THAT POINT I TOOK IT TO THE DEALER AND THEY SAID THEY WERE UNABLE TO DUPLICATE THE PROBLEM SO THEY DID NOTHING. ON 8/10/05 MY WIFE PUSHED DOWN HARD ON THE GAS PEDAL WHILE MERGING INTO FREEWAY TRAFFIC. THE ACCELERATOR STUCK WIDE OPEN AGAIN AND SHE FOUND HERSELF GOING ABOUT 100 MPH DOWN THE HIGHWAY. FINALLY SHE PUT THE CAR IN NEUTRAL, SHUT OFF THE ENGINE, COASTED TO THE BERM AND CALLED A TOW TRUCK. SINCE THE DEALER COULDN'T FIX THE PROBLEM THE FIRST TIME I DECIDED TO LOOK AT IT AGAIN MYSELF. AGAIN I TOOK THE PLASTIC COVER OFF THE TOP OF THE ENGINE AND ONCE AGAIN THE CABLE BECAME UNSTUCK. THIS MADE ME SUSPECT THAT THE PLASTIC COVER MAY HAVE SOMETHING TO DO WITH THE PROBLEM. UPON FURTHER INSPECTION I FOUND THAT THE CRUISE CONTROL CABLE HOUSING HAD BROKEN RIGHT BEFORE THE PART THAT CONNECTS TO THE THROTTLE BODY. THIS CREATES A SITUATION THAT CAN CAUSE THE CRUISE CABLE TO PIVOT UP AND WEDGE AGAINST THE PLASTIC ENGINE COVER DURING HARD ACCELERATION INSTEAD OF IT MOVING IN ITS HOUSING LIKE IT SHOULD THUS CAUSING THE THROTTLE TO STICK WIDE OPEN. I WAS ABLE TO MAKE THIS HAPPEN A FEW TIMES SO I AM CONFIDENT THIS WAS ACTUALLY THE PROBLEM. I EXPLAINED THE PROBLEM TO THE DEALER BUT THEY WOULDN'T BE ABLE TO WORK ON THE CAR FOR OVER A WEEK SO I WENT TO THE PARTS DEPT. ORDERED THE PART (UNDER $30) WENT HOME AND PUT IT ON MYSELF (TAKES LESS THAN 5 MINUTES). THE CAR IS FIXED NOW. *NM
Service brakes, Hydraulic, Aug 13, 2005
A HISSING NOISE IS COMING FROM MY BRAKE PEDAL. WHEN I PRESS DOWN ON THE BRAKE IT GOES AWAY BUT WHEN I LET UP ON THE BRAKE IT STARTS MAKING THE HISSING NOISE AGAIN. *JB
Tires, Jul 22, 2005
DT: THREE TIRES ON THE CONSUMER'S RV HAD BLOW AT DIFFERENT TIMES. THE CONSUMER CONSULTED A DEALER WHO REPAIRED THE TIRES AND NOTED THAT THE SIDEWALLS WERE TOO WEAK. THE MANUFACTURER WAS NOT WILLING TO HELP. FIRESTONE WILL NOT RETURN CONSUMER'S PHONE CALLS. THESE FAILURES OCCURRED AT 18,000 MILES. THE 4TH TIRE FAILED AT 15,000 MILES. THIS PROBLEM WAS PREVALENT WITH THE REAR TIRES (FIRESTONE STEELTEX TIRES). *NM
Suspension, Jul 20, 2005
DT: THE CONTACT OWNED A 2001, FORD, ESCAPE. EVERY TIME CONSUMER TOOK TIRES OFF TO WORK ON THE BRAKES B OR ANYTHING ELSE SHE HAD TO REPLACE HER WHEEL BEARINGS. THIS ONLY OCCURRED ON THE LEFT FRONT TIRE. THE AUTOMOTIVE PLACE THAT SPECIALIZED IN BRAKES SAID THAT THIS OCCURRED ON A LOT ON SIMILAR MAKE, MODEL, AND YEAR VEHICLES. THE LAST TIME THEY WERE REPLACED WAS IN APRIL 2005. *AK
Exterior lighting, Jul 19, 2005
UPON TURNING MY DIRECTIONAL ON TO MAKE THE LEFT HAND TURN IT HESSITATED TO COME ON WHILE THE DIRECTIONAL STILL STAYED DOWN TO GO LEFT. AFTER ABOUT 10 SECONDS THE DIRECTIONAL CAME ON AND SMOKE CAME OUT OF THE STEERING COLUMN AS WELL AS A STREAM OF SMOKE OUT OF THE HAZARD LIGHTS BUTTON ON THE STEERING COLUMN. I SHUT THE DIRECTIONAL OFF AND THE SMOKE STOPPED AND CLEARED AWAY. I PROCEEDED TO MY DESTINATION WHICH WAS ABOUT 100 YARDS AWAY NOT USING THE DIRECTIONAL AGAIN. I CALLED MY DEALERSHIP WHERE I PURCHASED THE VEHICLE FROM AND THEY SAID IT SOUNDED LIKE THE "TURN SIGNAL SWITCH FRIED." BEING THAT THE DEALERSHIP WAS ONLY ABOUT 20 YARDS AWAY THEY CAME AND PICKED MY VEHICLE UP GIVING ME A LOANER VEHICLE TO USE. THEY TOLD ME THE PART HAD TO BE ORDERED AND THAT IT WAS GOING TO COST ABOUT $120.00 FOR THE PART AND LABOR. I HUNG UP WITH THEM AND WAS NOT HAPPY. THAT EVENING AFTER DISCUSSING THE MATTER WITH MY FATHER HE AND I FELT IT SHOULD NOT BE MY RESPONSIBLITY TO PAY THIS AMOUNT ON A DEFECTIVE PART THAT COULD HAVE CAUSED SERIOUS INJURY. THAT NEXT MORNING I PICK UP MY VEHICLE AND ASKED THE BILL TO BE BILLED AND MAILED TO MY DADS BUSINESS, HE OWNS A NAPA AUTO PARTS STORE. AFTER HAVING SHOWED MY FATHER THE BILL AND HE CALLED TWO OTHER FORD DEALERSHIPS, THAT HE KNOWS AND DOES BUSINESS WITH. HE TOLD THEM MY SITUATION AND THEY INFORMED US THAT IT IS A "COMMON PROBLEM" AND THAT THEY FIX THE PROBLEMS FOR THEIR CUSTOMERS AT NO EXPENSE TO THE CUSTOMER. AFTER FIGHTING TOOTH AND NAIL ALL DAY WITH MY DEALERSHIPS MANAGER AND PARTS MANAGER THE DEALERSHIPS MANAGER SAID HE WOULD THROW THE BILL OUT AND NOT CHARGE ME BECAUSE WE ARE GOOD CUSTOMERS. WHY WOULD TWO OTHER DEALERSHIPS PERFORM THIS AT NO COST AND MINE WANT TO CHARGE ME? MY FATHER HAS ALSO CONTACTED FORD AND SPOKE WITH A REPRESENTATIVE ABOUT THIS AND HE WAS GOING TO GET BACK TO US. WHY ISN'T THEIR A RECALL ON THIS?
Service brakes, Air, Vehicle speed control, Jul 13, 2005, crash
MY WIFE WAS DRIVING OUR 8 YEAR OLD TWINS TO A PIANO RECITAL IN MY 2001 FORD ESCAPE, AND, WHILE GOING UP A STEEP HILL ON A FOUR-LANE ROAD, THE ENGINE DOWNSHIFTED AND THE CAR ACCELERATED OUT OF CONTROL. WHEN SHE REALIZED THAT SHE THE CAR WAS SPEEDING FORWARD WHEN SHE WAS NOT PRESSING ON THE ACCELERATOR, SHE APPLIED THE BRAKES HARD, BUT NOTHING HAPPENED. IN AN ATTEMPT TO AVOID THE CARS, SHE TOOK AN OFF-RAMP BUT QUICKLY REALIZED THAT TRAFFIC WAS STOPPED THERE AS WELL. IN DESPERATION, MY WIFE PULLED THE EMERGENCY BRAKE. THE CAR THEN STOPPED, BUT THEN LOST SHE LOST EVERYTHING. MY ESCAPE STARTED ROLLING BACKWARDS DOWN THE HILL, EVEN WITH THE EMERGENCY BRAKE ON. AGAIN, THE FOOT BRAKE DIDN'T RESPOND. SHE WAS HEADED BACKWARDS DOWN THE 1/2 MILE, STEEPLY GRADED HILL INTO THE CARS COMING UP THE HILL. SHE TURNED THE WHEEL TO BACK UP THE STEEP EMBANKMENT ON THE SIDE OF THE ROAD. AFTER BOUNCING BACKWARDS THROUGH THE STEEP DITCH AND TRAVELING ABOUT 14 FEET UP THE EMBANKMENT, THE CAR PAUSED FOR A MOMENT AND THEN SLAMMED FORWARD BACK INTO THE DITCH. OUR CHILDREN WERE NOT HURT. MY WIFE HAS SUFFERED WHIPLASH WHICH IS REQUIRING MEDICATION, PHYSICAL THERAPY, AND GIVES HER CONSTANT PAIN. MY LOCAL FORD DEALER HAS BEEN HONEST THAT A CRUISE CONTROL WIRE WAS FRAYED, AND EVEN THOUGH SHE WAS NOT USING THE CRUISE CONTROL, IT WAS MOVING IN PARALLEL TO THE ACCELERATOR CABLE. THE FRAYED CRUISE CONTROL CABLE STUCK AND CAUSED THE ACCELERATOR TO COMPRESS AND STICK. THEY HAVE NO EXPLANATION FOR THE LOSS OF BRAKES AND THE FAILURE OF THE EMERGENCY BRAKE. HOWEVER, AFTER THE HONEST ASSESSMENT, POOR TREATMENT ENSUED. THE DEALERSHIP IS FIXING THE CABLE, TRANSMISSION, AND BRAKES UNDER OUR EXTENDED WARRANTY AND NOT TAKING OWNERSHIP FOR THE ACCIDENT. THEY HAVE HAD MY CAR FOR 1 MONTH TODAY, AND I STILL DO NOT HAVE IT BACK. I WILL HAVE TO PAY THE $1000 DEDUCTIBLE FOR THE AUTO BODY WORK.
Steering, Jul 7, 2005
2001 FORD ESCAPE W/37K MILES NEEDS POWER STEERING RACK REPLACED.
Power train, Jul 5, 2005
2001 FORD ESCAPE, 61,000 MILES, CLUTCH FAILURE, CLUTCH PEDAL WENT TO FLOOR, WOULD NOT DISENGAGE. WAS ON ENTRANCE RAMP TO INTERSTATE HIGHWAY, IN SLOW MOVING TRAFFIC, OTHERWISE EXTREMELY DANGEROUS. INVESTIGATED ON INTERNET AND FOUND THAT THIS PROBLEM IS DESCRIBED IN FORD TECHNICAL SERVICE BULLETIN 1-24-1, SO IS OBVIOUSLY A KNOWN ISSUE. ONE OF RELATIVELY FEW TSBS THAT COULD CAUSE A CATASTROPHIC ACCIDENT IF IT OCCURRED AT SPEED. MOST OF THE TSBS ARE FOR THINGS LIKE "WHINING/BUZZING IN AUDIO SYSTEM," "ENGINE OIL RECOMMENDATIONS/APPLICATIONS," "INTAKE MANIFOLD GASKETS--FUEL SMELL TO THE INTERIOR." WHILE SOME OF THESE MAY BE SIGNIFICANT, FEW OF THEM WOULD CAUSE A CATASTROPHIC PROBLEM IF THEY OCCURED AT SPEED. THE "GENERAL RECALL" AND "SAFETY RECALLS" CATEGORIES, WHICH INCLUDE THINGS LIKE "SPEED CONTROL CABLE DEFECT" AND "REAR DRIVESHAFT REPLACEMENT DIFFERENTIAL LEAK" SEEM TO ME MUCH MORE APPROPRIATE PLACES FOR THIS SERIOUS PROBLEM TO BE REPORTED. HAD VEHICLE TOWED TO FORD DEALER. CONVERSATION WITH THEM THIS MORNING. CONFIRMED THAT PROBLEM WAS WITH MASTER AND SLAVE CYLINDER WHICH THEY SAID NEEDED TO BE REPLACED. DENIED KNOWLEDGE OF A KNOWN PROBLEM OF THIS TYPE. SAID THAT THIS WAS NOT COVERED UNDER WARRANTY. I TOLD THEM TO GO AHEAD AND REPLACE THE CYLINDERS.
Latches/locks/linkages, Jun 28, 2005
DT: CONTACT STATED THE PASSENGER DOOR LATCHES STOPPED WORKING. AFTER ABOUT A MONTH EARLIER DRIVER'S SIDE DOOR LATCH QUIT WORKING. UPON EXAMINATION THE ATTACHMENT TO THE ROD BROKE AWAY FROM THE DOOR LATCH. THE VEHICLE HAD NOT BEEN TO A SERVICE DEALER. *AK
Power train, Jun 27, 2005
AUTOMATIC TRANSMISSION IS STARTING TO FAIL. THE GEAR SHIFTING IS BECOMING MORE AND MORE JERKY. GRINDING SOUNDS ARE NOW AUDIBLE DURING GEAR SHIFTS.
Exterior lighting, Jun 20, 2005
IN MY 2001 FORD ESCAPE XLT BOTH FRONT HEADLIGHTS HAVE LOST THEIR SEALS, AT SEPARATE TIMES WITHOUT ANY DAMANGE TO THE VEHICLE HAVING OCCURRED, AND WATER ENTER THE LIGHT COMPARTMENT, DIFUSING THE HEADLIGHT AND NECESSITATING ABOUT $300 IN REPLACEMENT COSTS, EACH. I JUST FIND IT VERY STRANGE THAT BOTH LIGHTS HAVE HAD THE SAME PROBLEM AND IT IS AN UNUSUAL PROBLEM TO BEGIN WITH. THE DRIVER SIDE HEADLIGHT WENT AROUND JUNE 2004 AND THE PASSENGER SIDE ONE JUST BROKE.
Visibility, Jun 7, 2005
ON OR AROUND APRIL 15, 2005 MY 2001 FORD ESCAPE VIN [XXX]SUNROOF BEGAN TO MALFUNCTION. THAT IS, THE ROOF DID NOT MOVE FORWARD OR BACKWARD. I TOOK THE VEHICLE TO MY LOCAL FORD DEALER TO DETERMINE THE PROBLEM. THE SERVICE ADVISOR NOTIFIED ME THAT THE RACK FORD PART NUMBER [XXX]WOULD HAVE TO BE REPLACED. I FEEL THAT WITH SUCH LITTLE USE (MAYBE A TOTAL OF 3 HOURS OVER 4 YEARS) THIS FORD PART SHOULD NOT HAVE GONE BELLY UP. IN MY OPINION, UNDER NORMAL USE, THIS PART SHOULD NOT NEED TO BE REPLACED IN SUCH A SHORT TIME WITH SUCH LITTLE USE. *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Suspension, Jun 7, 2005
DT: ON THE LEFT FRONT WHEEL OF THE VEHICLE THEIR IS NOISE COMING FROM THE AXLE. THERE IS A LOT OF MOVEMENT IN THE BRAKE PEDAL, AND THE VEHICLE PULLS TO LEFT. *NM *SB
Service brakes, Hydraulic, May 12, 2005
I AM THE ORIGINAL OWNER OF A 2001 FORD ESCAPE XLT V6, 4 WHEEL DRIVE. MY TRUCK CURRENTLY HAS 75000 MILES OF USE. I FEEL THE INCIDENT I CHOSE TO WRITE ABOUT IS A SIGNIFICANT SAFETY ISSUE AS IT INVOLVES A MALFUNCTION OF THE ANIT-LOCK BRAKING SYSTEM (ABS) WHICH SIGNIFICANTLY REDUCES BRAKING ACTION (ON DRY PAVEMENT!) WHEN IT OCCURS. I AM ALSO AWARE OF AT LEAST TWO OTHER FORD ESCAPE OWNERS THAT HAVE EXPERIENCED THE SAME FAILURE. THE FAILURE CAUSES THE ABS TO ACTIVATE ON DRY PAVEMENT, WHEN ABSOLUTELY NO SLIPPAGE IS OCCURRING AT ANY WHEEL. THE ACTIVITY OF THE ABS SYSTEM ACTUALLY SIGNIFICANTLY REDUCES BRAKING CAPACITY AND CAUSES THE BRAKE PEDAL TO GO DOWN NOTICEABLY FURTHER THAN NORMAL WHEN ATTEMPTING TO STOP. ONLY A QUICK AVOIDANCE MANEUVER ALLOWED ME TO AVOID REAR-ENDING THE CAR IN FRONT OF ME. PUMPING THE BRAKES DOES NOT HELP SINCE THE ABS HYDRAULIC CONTROL MODULE IS MODULATING THE BRAKES AT SUCH A RATE, PUMPING THE BRAKE DOES NOT PRODUCE A FIRMER PEDAL. I HAVE TRACED THE PROBLEM TO A FAULTY ABS SYSTEM ROTATION TRANSDUCER DESIGN ON THE FRONT WHEELS OF THE ESCAPE. THE TRANSDUCER IS BASICALLY A SPLINED RING ABOUT 8MM WIDE. THE RING IS APPARENTLY FRICTION FIT ONTO THE HALF-SHAFT NEAR THE FRONT CV JOINTS JUST INSIDE OF THE FRONT HUB ASSEMBLY. A SENSOR APPARENTLY PICKS UP THE PEAKS OR VALLEYS IN THE SPLINED RING AS IT ROTATES PAST THE SENSOR TO DETERMINE WHEEL ROTATION SPEED. IT IS THE SPLINED RING THAT FAILS, MINE ACTUALLY SPLIT ACROSS ITS WIDTH CAUSING IT TO LOOSEN AND MOVE AWAY FROM THE SENSOR. THIS APPARENTLY CAUSES THE ABS SYSTEM TO OPERATE ERRATICALLY AND ACTUALLY CAUSE A SIGNIFICANT REDUCTION IN BRAKING CAPACITY ON DRY PAVEMENT! THIS ERRATIC BEHAVIOR WILL OCCUR 5-10 TIMES BEFORE THE ABS CONTROLLER DETERMINES THERE IS SOMETHING WRONG AND SWITCHES OFF THE ABS SYSTEM. THIS ILLUMINATES THE ABS INDICATOR LIGHT ON THE INSTRUMENT PANEL AND DOES RESTORE NORMAL BRAKING PERFORMANCE. THIS CYCLE WILL REPEAT ITSELF EACH TIME THE TRUCK IS SHUT OFF AND RESTARTED!!
Power train, May 7, 2005
THE O/D LIGHT STARTED FLASHING .I DROVE THE VEHICLE ABOUT 5 MILES TO MY DRIVEWAY.WHEN I WENT TO MOVE THE CAR IT WOULDN'T GO IN REVERSE. CONTACTED DEALER WITH NO RESULTS. SENT CAR TO TRANSMISSION SHOP AND HAD A REBUILT TRANSMISSION PUT IN.
Engine and engine cooling, May 2, 2005
VEHICLE STALES DURING DECELARTION
Suspension, May 2, 2005
THE CONSUMER STATED THE REAR COIL SPRING BROKE AND CAUSED DAMAGE TO THE TIRE.
Power train, May 1, 2005, crash
WAS STRUCK IN THE REAR END BY ANOTHER VEHICLE, EVIDENTLY, AFTER THAT THE TWO FRONT HUB BEARINGS WENT BAD. DEALERSHIP STATED IT WAS NOT DUE TO ACCIDENT.*AK