2001 Ford Escape
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,027 owner complaints filed for this model year. This is the 14th highest complaint count among 26 Escape model years with reports.
Of the 2001 reports, 77 involved a crash and 60 involved a fire. 75 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Structure, frame and membersApr 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14S02.
Campaign 14V165000 on NHTSA.gov
Engine and engine coolingJul 26, 2012
Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used.
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. Owners may contact Ford at 1-866-436-7332.
Campaign 12V353000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleJan 9, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 2001-2002 ESCAPE VEHICLES MANUFACTURED FROM OCTOBER 22, 1999, THROUGH JULY 19, 2002, EQUIPPED WITH A BRAKE MASTER CYLINDER RESERVOIR CAP THAT COULD LEAK BRAKE FLUID. IF BRAKE FLUID LEAKS FROM THE CAP, IT COULD COME IN CONTACT WITH THE ANTILOCK BRAKE SYSTEM (ABS) MODULE WIRING HARNESS CONNECTOR.
CORROSION CAN DEVELOP IN THE ELECTRICAL CONNECTOR LEADING TO MELTING, SMOKE OR A FIRE.
DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER RESERVOIR CAP AND THE ABS ELECTRICAL SYSTEM WILL BE MODIFIED. AN INTERIM LETTER WAS MAILED ON JANUARY 20, 2012. DUE TO A PARTS DELAY, HOWEVER, THE REMEDY MAY NOT BE AVAILABLE CURRENTLY. IF PARTS ARE NOT AVAILABLE, FORD WILL INSTRUCT OWNERS TO PARK THEIR VEHICLES OUTSIDE UNTIL SUCH TIME AS PARTS BECOME AVAILABLE. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. THIS RECALL CAMPAIGN IS RELATED TO 07V-156.
Campaign 12V005000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 10, 2007
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED.
DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 07V156000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Apr 6, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.0L V6 ENGINES, DURING DECELERATION, THE ENGINE CAN STALL.
SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
DEALERS WILL REPROGRAM THE POWER CONTROL MODULE (PCM) WITH THE APPROPRIATE CALIBRATION. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V165000 on NHTSA.gov
Seat belts, front, buckle assemblyDec 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES, A POST WITHIN THE SAFETY BELT BUCKLE COVERS COULD FRACTURE, WHICH COULD AFFECT LATCH FUNCTION, RESULTING IN EITHER A "NO LATCH" OR "PARTIAL LATCH" CONDITION. IN THE "PARTIAL LATCH" CONDITION, THE BUCKLE TONGUE CAN BE INSERTED INTO THE BUCKLE AND APPEAR TO BE ENGAGED, BUT WILL RELEASE FROM THE BUCKLE WITHOUT THE PUSH BUTTON BEING DEPRESSED WHEN A RELATIVELY LOW LOAD IS APPLIED, SUCH AS WHEN AN OCCUPANT MOVES SLIGHTLY IN THE SEAT.
IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.
DEALERS WILL HAVE THE DRIVER AND FRONT PASSENGER SAFETY BELT BUCKLE COVER REMOVED AND REPLACED WITH A NEWLY DESIGNED SERVICE BUCKLE COVER. OWNER NOTIFICATION BEGAN ON FEBRUARY 2, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V507000 on NHTSA.gov
Visibility, windshield wiper/washer, linkagesNov 27, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE WINDSHIELD WIPER LINKAGE CAN DISENGAGE DUE TO A BROKEN BALL SOCKET.
THIS CONDITION WILL LIKELY RESULT IN SUDDEN AND COMPLETE LOSS OF THE WINDSHIELD WIPER FUNCTION, OR OF THE WIPER FUNCTION ON THE DRIVER SIDE ONLY, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE WIPER MODULE.
Campaign 00V387002 on NHTSA.gov
Fuel system, gasoline, deliverySep 18, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE O-RING SEALS IN THE FUEL LINE CONNECTOR AT THE OUTLET END OF THE FUEL FILTER WERE DAMAGED WHEN THE LINE WAS CONNECTED TO THE FILTER DURING VEHICLE ASSEMBLY. IN SOME CASES, THIS DAMAGE COULD RESULT IN A FUEL ODOR, OR POSSIBLY IN FUEL DRIPPING FROM THE CONNECTION.
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE FUEL LINE. OWNER NOTIFICATION BEGAN SEPTEMBER 27, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V277001 on NHTSA.gov
Wheels, hubcap/coverSep 12, 2000
VEHICLE DESCRIPTION: SOME 4X2 SPORT UTILITY VEHICLES NOT EQUIPPED WITH AN ANTILOCK BRAKING SYSTEM MAY HAVE INADVERTENTLY BEEN BUILT WITH 4X4 REAR HUBS INSTEAD OF 4X2 HUBS. IF THE INCORRECT HUBS ARE INSTALLED ON A 4X2 VEHICLE, THE REAR WHEELS CAN LOOSEN, OR IN SOME CASES, SEPARATE FROM THE VEHICLE.
THIS CONDITION COULD CAUSE LOSS OF CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE REAR HUBS AND, IF NECESSARY, REPLACE THEM. OWNER NOTIFICATION BEGAN SEPTEMBER 25, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V260001 on NHTSA.gov
Vehicle speed controlAug 9, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE CAN HAVE A CRACKED OR MISSING SPEED CONTROL CABLE SERVO CAP LOCATING TAB. THE LOCATING TAB COULD ENTER THE SERVO CLUTCH CAVITY AND INTERFERE WITH THE SPEED CONTROL SERVO CLUTCH. ALSO, WATER COULD ENTER THOSE UNITS THAT CONTAIN A CRACKED OR MISSING SERVO CAP LOCATING TAB, EVENTUALLY CAUSING CORROSION THAT COULD INTERFERE WITH THE FUNCTION OF THE SPEED CONTROL.
IF EITHER OF THESE CONDITIONS OCCURS AND THE SPEED CONTROL IS USED, THE SPEED CONTROL COULD PREVENT THE THROTTLE FROM RETURNING TO IDLE, RESULTING IN A STUCK THROTTLE. A STUCK THROTTLE COULD RESULT IN A CRASH.
DEALERS WILL INSPECT THE SPEED CONTROL CABLES. VEHICLES WITH SPEED CONTROL CABLES FROM CAVITIES 3 AND 4 WILL HAVE THE CABLE THE SPEED CONTROL SERVO REPLACED.
Campaign 00V210001 on NHTSA.gov
Steering, steering wheel/handle barAug 8, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THESE VEHICLES MAY HAVE A MIS-ASSEMBLED OR INCORRECTLY MANUFACTURED NUT THAT ATTACHES THE STEERING WHEEL ASSEMBLY TO THE STEERING COLUMN. THE NUT COULD BE UPSIDE DOWN IN THE STEERING WHEEL ASSEMBLY, WHICH COULD OVERSTRESS THE STEERING COLUMN SHAFT WHEN THE NUT IS TIGHTENED. IN ADDITION, SOME OF THE NUTS MAY HAVE BEEN CRACKED DURING MANUFACTURE RESULTING IN THE NUT FRACTURING WHEN IT IS TIGHTENED DURING VEHICLE ASSEMBLY.
EITHER OF THESE CONDITIONS CAN LEAD TO THE STEERING WHEEL BECOMING LOOSE OR SEPARATING FROM THE STEERING COLUMN, RESULTING IN LOSS OF STEERING CONTROL.
DEALERS WILL INSPECT AND REPLACE THE STEERING WHEEL RETENTION ARMATURE AND, IF NECESSARY, THE STEERING COLUMN TO CORRECT THIS CONDITION.
Campaign 00V223001 on NHTSA.gov
Representative owner complaints
1,027 reports, newest first.
Engine and engine cooling, Aug 10, 2002
VEHICLE HAS STALLED WHEN DRIVING 3 TIMES - DEALER APPEARS UNABLE TO RESOLVE PROBLEM. DEALER WAS UNAWARE OF NTSA DEFECT INVESTIGATION FOR THIS VEHICLE.*AK
Engine and engine cooling, Visibility, Aug 9, 2002
ENGINE HAS STALLED TWICE WHILE DRIVING 40-50MPH. SUNROOF MOTOR HAD TO BE REPLACED. COOLANT RECORVERY JUG HAD TO BE REPLACED. SENSOR ASY-EGR WAS REPLACED AFTER 1ST TIME ENGINE STALLED. HAS SINCE STALLED AGAIN.
Engine and engine cooling, Other or unspecified, Aug 8, 2002
DRIVING DOWN SLIGHT DOWNHILL AT CONSTANT SPEED. ~1/2 HALF TANK GAS. WITHOUT WARNING OR OTHER INDICATION, ENGINE SUDDENLY DIED. CHECK ENGINE LIGHT AND OIL LIGHT BOTH LIT. NO OTHER LIGHTS NOTICED. PULLED OFF ROAD, HAD TO USE EMERGENCY BREAK TO STOP. PUT IN PARK AND TRIED TO START ENGINE. STARTED WITHOUT PROBLEM.
Electrical system, Aug 7, 2002
VEHICLE HAS STALLED TWICE. DEALER REPLACED MAIN COMPUTER AND VARIOUS SENSORS. PLEASE PROVIDE ADDITIONAL INFORMATION.*AK
Engine and engine cooling, Aug 5, 2002
VEHICLE HAD STALLED ON FOUR SEPARATE OCCASIONS WHILE DRIVING 35-40 MPH . VEHICLE HAS BEEN TO DEALER ON THREE OCCASIONS, AND PROBLEM STILL OCCURRING. *AK THE POWER RELAY WAS CONSIDERED THE CAUSE FOR THE VEHICLE?S STALLING AND WAS REPLACED. WHEN THE VEHICLE STALLED AGAIN, THE DEALER REPLACED THE PFF SENSOR FIRST AND POWER TRAIN CONTROL NEXT AND LASTLY DID PCM PROGRAMMING, BUT THE VEHICLE CONTINUED TO STALL. *YH
Engine and engine cooling, Aug 1, 2002
AUTO STALLED WHILE GOING DOWN EXTENDED INCLINE AT SPEED 35-40 MPH. I WAS IN A LONG LINE OF CARS AND WAS VERY LUCKY TO GET THE CAR TO THE SIDE OF THE ROAD WITHOUT AN ACCIDENT. I QUICKLY SLIPPED THE GEAR INTO NEUTRAL AS IT SLOWED AND CAR IMMEDIATELY RESTARTED. I AM PUTTING THIS INCIDENT INTO YOUR SITE, EVEN THOUGH IT HASN'T HAPPENED AGAIN SINCE DEC., BECAUSE I KNOW OTHER DRIVERS HAVE HAD THIS REOCCUR INTERMITTENTLY, EVEN AFTER FORD SUPPOSEDLY FIXED VEHICLE.*AK
Steering, Engine and engine cooling, Jul 30, 2002
ON 02/11/2002 TRAVELING AT 35MPH GOING TO WORK MADE A LEFT TURN AND TRUCK SUDDENLY STARTED TO STALL. ACCELLERATION BEGIN TO DECREASE AND A LOUD ROARING OR GRINDING SOUND WAS COMING FROM UNDER THE CAR. PULLED OVER DUE TO DECREASE IN ACCELERATION AND STOPPED CAR. TURNED CAR OFF AND ON AGAIN AND STARTED TO ACCELERATE AND CAR WOULD NOT GO ABOVE 35MPH. FINALLY MADE IT TO DEALERSHIP. DEALER LOOKED AT CAR AND DETERMINED IT WAS THE STEERING ASSEMBLY AND REPLACED. ON 03/14/02 WENT OUT TO START CAR AND DROVE 35 MPH ENGINE LIGHT CAME ON AND STAYED ON THE REMAINING OF DAY. TOOK TO DEALER THE NEXT DAY DUE TO LIGHT STILL ON, DEALER REPLACED PART INDICATING SWITCH CHIP BAD. ON 07/25 AND 07/ 29 CAR FAILS TO START AFTER AN EXTENDED PERIOD OF DRIVING HAS DONE THIS ON SEVERAL OCCASION AND HAVE CALLED DEALER TO BRING VEHICLE IN TO LOOK AT ON 08/01/02. VEHICLE STALLS AT 35 -40 MPH ON SEVERAL OCCASIONS. NOT HAPPY WITH VEHICLE PROBLEMS AND FEEL THESE DEFECTS CAN BE A DANGER TO ME AND OTHER DRIVERS ON THE ROAD. FORD SHOULD DO THERE BEST TO REPLACE PARTS AND ACCOMODATE THEIR CONSUMERS FOR TIME AND HEADACHES.*AK
Suspension, Jul 29, 2002
LOUD TICKING NOISE WHEN TURNING VEHICLE. OCCURS AT ALL SPEEDS. FORD NOTIFIED BUT CAN'T FIX PROBLEM. WILL NOT STATE WHETHER OR NOT VEHICLE IS SAFE FOR DRIVING. NO SAFETY DEFECT LISTED. *AK
Electrical system, Jul 27, 2002
HAS STALLED WHILE DRIVING AT ABOUT 35MPH. THIS HAS HAPPENED FOUR TIMES IN THE LAST FOUR MONTHS . WHEN I QUESTIONED THE DEALER ABOUT THE PROBLEM I WAS TOLD THAT THIS WAS BECAUSE THE GAS IN THE CAR WAS STILL WINTER GRADE AND IT WOULD CLEAR UP. HOWEVER THIS HAPPENED FOR THE FOURTH TIME ABOUT THREE WEEKS AGO. THIS IS MY WIFES CAR, AND THIS IS VERY SCARY FOR HER. SHE NEVER KNOWS WHEN IT WILL HAPPEN AGAIN, IT JUST STALLS OUT WHILE SHE IS IN MOTION. I. *AK
Engine and engine cooling, Jul 24, 2002
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
Engine and engine cooling, Jul 23, 2002
I WAS DRIVING IN RUSH HOUR TRAFFIC WITH THE RADIO ON AND AIR ONLY ON. I WAS PRESSING ON THE GAS AND GOING NO WHERE. THEN I REALIZED THE CAR JUST DIED. I WAS IN THE FAST LANE. THERE WAS NO WHERE TO GO SO I HAD TO TAKE A LEFT TURN AND COASTED ACROSS 2 LANES OF TRAFFIC. I WAS IN PANIC AS I WAS JUST COASTING AND HAD NO POWER TO MOVE. ALL THE POWER STEERING AND BREAKES DID NOT WORK BECAUSE THE ENGINE WAS NOT ENGAGED. IT WAS A VERY DANGEROUS SITUATION. AFTER I REACHED THE SIDE STREET, I PUT ON MY FLASHERS. I PUT THE VEHICLE IN NUTERAL. IT STARTED AND I WENT HOME. I AM VERY NERVOUS TO DRIVE THIS VEHICLE, BECAUSE IF IT HAPPENS AGAIN, I COULD BE IN A SITUATION WHERE I COULD GET KILLED, HAVING NO POWER TO STOP, ADVANCE OR TURN.*AK
Steering, Electrical system, Jul 19, 2002
WHILE DRVING STEERING WHEEL LOCKED UP AND THEN VEHICLE STALLED, ALMOST CAUSING AN ACCIDENT. VEHICLE WAS CHECKED BY DEALER, WHO ADVISED CONSUMET THAT THEY COULD NOT FIND ANY PROBLEM.*AK
Engine and engine cooling, Jul 19, 2002
REPEATED PROBLEM. THERE HAVE BEEN 5 OCCURRENCES. IT HAS BEEN TO THE DEALERSHIP 3 TIMES. ON EACH OF THESE OCCURRENCES, THE ENGINE HAS STALLED FOR NO APPARENT REASON CAUSING LOSS OF POWER BRAKING AND POWER STEERING. MOST INSTANCES OCCURRED WHILE DRIVING DOWN A SLIGHT DECLINE AT APPROXIMATELY 40-45MPH. ON ALL THREE DEALER ASSESSMENTS (TWO DIFFERENT DEALERSHIPS), THE PROBLEM COULD NOT BE REPRODUCED. THE FIRST TIME THE BASE IDLE WAS ADJUSTED. THE SECOND TIME A RELAY WAS REPLACED. THE THIRD TIME FORD CORPORATE DIRECTED THE DEALERSHIP TO INSTALL AN IDLE AIR CONTROL. I EXPRESSED SAFETLY CONCERNS ABOUT LOSS OF POWER STEERING AND BRAKES TO THE DEALERSHIP. BUT, SINCE THEY WERE NEVER ABLE TO REPRODUCE THE PROBLEM, THEY DON'T CONSIDER IT A CONCERN. THERE IS STILL A GREAT SAFETY CONCERN HERE.*AK
Vehicle speed control, Jul 16, 2002
6/10/02 ENGINE STALLED WHILE OFF THROTTLE AT APPROX 30MPH WHILE SLOWING DOWN TO TURN INTO A PLACE OF BUSINESS. LOST ALL POWER TO STEERING AND BRAKES AND NARROWLY MISSED HITTING ANOTHER CAR. HAPPENED 4 TIMES ON THE WAY TO THE DEALER ON THE SAME DATE.ABLE TO RESTART AFTER PUTTING IN PARK.DEALER HAD CAR FOR THE REST OF THE WEEK AND REPACED PCM. ON 6/22 ENGINE STALLED WHILE GOING 40MPH AND EXITING HWY 1 S ON A VERY CURVY EXIT RAMP. LOST ALL POWER STEERING AND BRAKES AND HAD TO MANHANDLE IT OFF TO THE SIDE.RESTARTED BY PUTTING IN PARK BUT HAD TO WAIT TILL MONDAY TO TALK TO SERVICE DEPT AT DEALER. ON MONDAY 6/24 DEALER WOULD NOT TAKE VEHICLE-TOO BUSY, AND HAD TO WAIT TILL 6/25 TO DELIVER TO DEALER. SERVICE PERSON SAID IT WAS OK TO DRIVE BUT I DID NOT DUE TO DANGEROUS NATURE OF THE PROBLEM. DEALER RECEIVED CAR ON 6/25, HAD IT FOR 4 DAYS AND REPLACED IAC. THE VERY NEXT DAY AFTER PICKING IT UP IT STALLED 2 TIMES AT 30MPH OFF THROTTLE. RENDERED UNUSABLE FOR THE WEEKEND. RETURNED CAR TO DEALER FOR THIRD TIME ON 7/1 AND THEY HAVE HAD IT EVER SINCE. TODAY IS 7/16 AND THEY SAY THEY HAVE A TEMPORART FIX THAT SHOULD WORK TILL FORD ISSUES A PERMANENT FIX. I AM NOT RISKING MY LIFE AND THE LIVES OF OTHERS WHO ARE UNFORTUNATE ENOUGH TO BE DRIVING NEAR ME WHEN IT STALLS SO I AM REFUSING VEHICLE AND SEEKING A NEW IDENTICAL REPLACEMENT. CURRENTLY THE DEALER IS COMMUNICATING THIS TO FORD. DEALER STALFF HAS BEEN POLITE, HELPFUL, CONCERNED, APPOLOGETIC AND WILLING TO BACK ME UP AGAINST FORD. THEY HAVE SUPPLIED ME WITH AN ACCEPTABLE LOANER VEHICLE THE ENTIRE TIME MY CAR HAS BEEN DOWN. THIS IS A DANGEROUS PROBLEM THAT FORD HAS TO FESS UP TO BEFORE MORE PEOPLE GET INJURED OR EVEN KILLED. IT'S INTOLLERABLE AND A CORPORATE LACK OF RESPONSIBILITY TO THEIR CUSTOMERS. PLEASE RECOMMEND A RECALL.*AK
Engine and engine cooling, Jul 15, 2002
WHILE DRIVING AT APPROXIMATELY 35 MPH ON A LEVEL ROADWAY, THE ENGINE UNEXPECTEDLY STOPPED. TRAFFIC WAS RELATIVELY HEAVY AND STOPPING THE VEHICLE AT THE TRAFFIC LIGHT WITHOUT HITTING THE STOPPED VEHICLE IN FRONT OF ME WAS DIFFICULT. THE VEHICLE HAD TO BE PLACED IN PARK BEFORE THE ENGINE WOULD RESTART (AS EXPECTED) -- WHICH IT DID WITHOUT ANY PROBLEM. NO CHECK ENGINE LIGHT WAS PRESENT. TIME OF DAY WAS AT APPROXIMATELY 5 PM CDT. OUTSIDE TEMPERATURE WAS ABOUT 85 DEGREES. I HAD JUST EXITED OFF THE HIGHWAY AND HAD BEEN DRIVING FOR ABOUT 8 MILES WITHOUT STOPPING BEFORE THE FAILURE. THE AIR CONDITIONING AND RADIO WERE ON DURING THE FAILURE.*AK
Engine and engine cooling, Power train, Electrical system, Jul 11, 2002
VEHICLE IS STALLING AT LOW SPEED. HAS BEEN TAKEN TO DEALER 4 TIMES. POWERTRAIN CONTROL MODULE/ WIRING ASSEMBLY AND PCM RELAY WERE REPLACED. DID NOT REMEDY THE PROBLEM.*AK
Tires, Jul 11, 2002
FIRESTONE WILDERNESS HT TIRES FAILED (P235/70R16AS, P235/70R16 1047). NLM
Tires, Jul 11, 2002
CONSUMER STATED ALL FOR WHEELS WERE CHANGED TO P225/70R16, BUT NOT THE SPARE TIRE WHICH REMAINS A 15 INCH, TIRE AND WHEEL ARE ABOUT 1 INCH LESS DIAMETER THAN THE WHEELS ON THE VEHICLE, IN ADDITION THE SPARE WHEEL STAMPED IN THE BODY METAL IS SIZED FOR THE SMALLER 15 INCH WHEEL.
Engine and engine cooling, Fuel system, Gasoline, Jul 10, 2002
CONSUMER STATES THAT THE VEHICLE STALLS WHILE DRIVING, THE MOST RECENT REPAIRS MADE BY THE DEALER WAS THE REPLACEMENT OF THE IAC AND AIR INTAKE, CONSUMER IS CONCERNED ABOUT THE PROBLEM HAPPENING AGAIN. THE INDICATOR LIGHTS FOR ENGINE COOLANT AND BATTERY ILLUMINATED, THE DEALER REPLACED A PART ON THE COOLANT REC TANK, HOWEVER THE COOLANT LIGHT ILLUMINATED AGAIN. *SLC
Engine and engine cooling, Jul 8, 2002
WHILE DRIVING, VEHICLE WILL STALL WITHOUT WARNING.*AK *TT
Engine and engine cooling, Electrical system, Jun 30, 2002
I WAS DRIVING ON THE INTERSTATE AT APPROXIMATELY 50 MPH DOWNHILL DURING RUSH HOUR WHEN I LOST POWER. I WAS ON A STRETCH OF INTERSTATE THAT HAD NO SHOULDER SO I COASTED 1/4 MILE TO THE SHOULDER. I WAS TOWED TO THE DEALER WHO REPLACED MY ALTERNATOR. SIX WEEKS LATER, I GO TO START MY CAR AND IT WOULDN'T START.*AK
Tires, Jun 27, 2002
HEARD A NOISE, TOOK VEHICLE TO DEALER AND WAS INFORMED THAT FRONT DRIVER'S SIDE TIRE WAS BEGINING TO SEPARATE, ORIGINAL TIRE. *AK FIRESTONE TIRES.*JB
Engine and engine cooling, Jun 27, 2002
VEHICLE HAS STALLED 4 TIMES AT 30-40 MPH. DEALER CANNOT FIND CAUSE. *AK
Engine and engine cooling, Jun 27, 2002
VEHICLE WILL STALL OUT AT ANY SPEED, THERE IS NO PRIOR WARNING, AND EVERYTHING WILL SHUT DOWN.*AK
Steering, Engine and engine cooling, Power train, Jun 26, 2002
WHILE DRIVING 30-35 MPH, VEHICLE WILL SHUT OFF WITHOUT ANY NOTICE. CONTACTED DEALER, WHO WAS NOT WILLING TO DO ANYTHING.*AK. NUMEROUS PARTS HAVE BEEN REPLACED REGARDING THE STALLING, BUT THE PROBLEM STILL EXISTS, THE ENGINE LIGHT ALSO ILLUMINATED, CONSUMER STATED THE TRANSMISSION WAS REPLACED IN APRIL 2002, THE ENGINE COOLING FANS WERE REPLACED, AND ALSO THE RACK AND PINION WAS REPLACED.*JB