2003 Ford Escape
Problems, recalls and owner-reported issues
Structure is the leading concern among 598 owner complaints filed for this model year. This is the 17th highest complaint count among 26 Escape model years with reports.
Of the 2003 reports, 44 involved a crash and 29 involved a fire. 32 people were injured.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Structure, frame and membersApr 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14S02.
Campaign 14V165000 on NHTSA.gov
Engine and engine coolingJul 26, 2012
Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used.
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. Owners may contact Ford at 1-866-436-7332.
Campaign 12V353000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 10, 2007
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED.
DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 07V156000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Vehicle speed control, cablesDec 7, 2004
ON CERTAIN SPORT UTILITY VEHICLES BUILT WITH 3.0L V6 ENGINES, THE ACCELERATOR CABLE MAY PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.
AN UNEXPECTED INCREASE IN ENGINE IDLE SPEED MAY INCREASE STOPPING DISTANCE AND MAY RESULT IN A VEHICLE CRASH.
DEALERS WILL REPLACE THE ACCELERATOR CABLE. THE RECALL BEGAN ON JANUARY 10, 2005. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 04V574000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Apr 6, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.0L V6 ENGINES, DURING DECELERATION, THE ENGINE CAN STALL.
SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
DEALERS WILL REPROGRAM THE POWER CONTROL MODULE (PCM) WITH THE APPROPRIATE CALIBRATION. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V165000 on NHTSA.gov
Representative owner complaints: electrical system
52 reports, newest first. Show all
Electrical system, Sep 4, 2024, crash
Never received a recall letter or notice
Service brakes, Air, Electrical system, Jun 29, 2023
The contact owns a 2003 Ford Escape. The contact stated that upon starting the vehicle, and while driving at unknown speeds, the vehicle was smoking. There were no warning lights illuminated. The owner disconnected the battery. The vehicle was taken to an independent mechanic who informed the owner that the ABS module and wiring harness needed to be replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 130,000.
Power train, Electrical system, Jul 14, 2020
SENSE WE BOUGHT THIS 2003 FORD ESCAPE WE HAVE REPLACED 5 ALTENATORS TRANSMISSION PROBLEMS .3 NEUTRAL SAFETY SWITCHES. AND STILL HAVING PROBLEMS THE TRANSMISSION PROBLEMS ARE THE SAME REASON FOR THE RECALL BUT MY CAR IS JUST A MONTH NEWER GO FIGURE
Electrical system, Other or unspecified, Fuel/propulsion system, Oct 26, 2019
AFTER DRIVING CAR, PARKING AND STARTING AGAIN, IT WILL START BUT WILL NOT KEEP RUNNING. USUALLY CAN WAIT A FEW MINUTES WITH HOOD UP AND WILL BE OK. TODAY (10/26/2019) IT WOULD NOT KEEP RUNNING. HAD IT TOWED. PURCHASED NEW 06/2003 AND HAS ALWAYS HAPPENED. FORD MECHANICS OTHER MECHANICS DO NOT KNOW WHY.
Electrical system, Oct 8, 2019
WHILE IN MOTION,ON TWO OF MY VEHICLES A 2003 AND A 2004 FORD ESCAPE ONE CYLINDER BLEW OUT THE SPARK PLUG AND COIL PACK (#5)ON BOTH VEHICLES I'M TRYING TO FIND OUT IF THERE'S A RECALL ON ? SAME TYPE OF VEHICLES MODEL ONE YEAR APART.
Electrical system, Aug 20, 2019, fire
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT WHILE HIS VEHICLE WAS NOT RUNNING AND SITTING IN HIS DRIVEWAY, THE VEHICLE CAUGHT ON FIRE WITHOUT WARNING. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE ON HIS OWN, NO INJURIES OCCURRED AND NO FIRE REPORT WAS TAKEN. UPON INVESTIGATION THE CONTACT ASSOCIATED NHTSA CAMPAIGN NUMBER: 07V156000 (ELECTRICAL SYSTEM) WITH HIS FAILURE. THE CONTACT SPOKE WITH A DEALER (APPLE FORD 3250 CAPE HORN RD, RED LION, PA 17356 717-429-0726) AND WAS ABLE TO DRIVE THE VEHICLE TO THE DEALER TO DETERMINE THE CAUSE OF THE FAILURE/FIRE. THE DEALER INFORMED THE CONTACT THAT THE FIRE WAS RELATED TO THE RECALL ASSOCIATED WITH THE VEHICLE. WHEN THE CONTACT INFORMED THE MANUFACTURER OF THE FAILURE, THEY INFORMED HIM THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 175,000.
Electrical system, Vehicle speed control, Other or unspecified, Mar 13, 2019
MY ESCAPE STARTED TO MISS, FIRST IT WASN'T BAD THEN STARTED JERKING AND IT STARTED IDLING ROUGH WHEN I STOPPED AT RED LIGHT. WHEN I STARTED MOVING AGAIN IT ACTED AS IF IT WOULD DIE AND WOULD GO. IF I GET TO 40 MPH IT IS REALLY BAD. BUT THIS HAPPENED ON MAIN HIGHWAY WITH OTHER VEHICLES ALL AROUND ME AND HAD 18 WHEELER BEHIND ME AND ALL OF SUDDEN MY SPEED DECREASED AND ME AND MY CHILDREN ALMOST WAS IN ACCIDENT BECAUSE OF DECREASE IN SPEED. IT SCARED ME AND MY TWO CHILDREN. WHEN I GOT IT LOOKED AT THE CODES SAID IT WAS MISSING ON ONE CYLINDER THEN AT ONE POINT ALL CYLINDERS.
Electrical system, Aug 13, 2017, fire
THE CAR WAS PARKED IN A SHOPPING CENTER PARKING LOT NO ONE WAS IN IT. IT SOME HOW CAUGHT ON FIRE, WHEN WE GOT THE FIRE OUT AND TOWED TO THE SHOP, IT WAS THE ALTERNATOR THAT CAUSED THE FIRE AND DID SEVERAL $1000.00 DAMAGE. THERE WERE NO ISSUES WITH THE CAR NO WARNING LIGHTS.
Electrical system, May 19, 2017
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE FAILED TO START SEVERAL TIMES WITHOUT WARNING WHEN THE KEY WAS TURNED IN THE IGNITION. IN ADDITION, THE VEHICLE STALLED WITHOUT WARNING MORE THAN ONCE. THE RPMS RACED AND, AT TIMES, THE INSTRUMENT PANEL WOULD BECOME DIM UPON EXPERIENCING AN ELECTRICAL SHORT OR INTERNAL FAILURE. THE DEALER WAS NOTIFIED OF THE FAILURES AND STATED THAT THE VEHICLE NEEDED TO BE DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT WAS UNCERTAIN IF THE VEHICLE WOULD BE REPAIRED BECAUSE THE DEALER STATED THAT THERE WAS A MANUFACTURER RECALL FOR THESE FAILURES; HOWEVER, THE VIN WAS EXCLUDED. THE RECALL DETAILS AND FAILURE MILEAGE WERE NOT AVAILABLE. *TT *JS
Electrical system, Other or unspecified, Apr 22, 2017
I HAVE A 2003 ESCAPE THAT HAS A INTERESTING PROBLEM WITH THE REAR HATCH. WHEN IT IS HOT OUT SIDE OR THE SUN IS SHINNING ON THE REAR HATCH THE LOCK WILL NOT UNLOCK,ALL THE OTHER DOORS DO. WHEN IT GETS DARK OR THE DOOR COOL DOWN THE NIT WILL UNLOCK WITH THE REST OF THE DOORS. OUR REAR HATCH. INTERMITTENTLY WORKING AND THEN NOT WORKING AT ALL. AFTER LOOKING IN THE SEARCH ENGINE ON THIS FORUM, UNDER "REAR HATCH WON'T OPEN" I FOUND A POSTING LISTING THE PART # FOR THE SOLENOID ONLY, FROM AN AFTERMARKET SOURCE. (FORD MAKES YOU BUY THE WHOLE HANDLE AND ACTUATOR ASSY. FOR $200 OR SO). THE SOLENOID WAS $10 PLUS SHIPPING. INSTALLATION WAS STRAIGHT FORWARD EXCEPT THE ROD THAT CONNECTS THE SOLENOID TO THE MECHANISM NEEDS TO BE MODIFIED AND THE WIRES SPLICED INSTEAD OF THE MODULAR PLUG ON THE STOCK ONE. IF YOUR NOT THAT MECHANICAL, YOU MAY WANT THE DEALERSHIP TO DO IT , BUT IF YOU HAVE SOME SKILLS, YOU CAN SAVE A LOT OF MONEY! (IF FORD HAD PUT A FREAKING KEY HOLE ON THE REAR HATCH IT WOULDN'T BE SUCH A BIG DEAL) SEARCH THE THREADS AND YOU WILL FIND THE POST FOR THE PART. HOPE THIS HELPS.
Electrical system, Sep 26, 2016
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V165000 (POWER TRAIN). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
Electrical system, Jul 20, 2016
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT WITHIN MONTHS OF OWNING THE VEHICLE, THAT THERE WAS A PROGRESSING FAILURE WITH A LOSS OF THE BATTERY POWER, AND THE ANTI-THEFT ALARM AND HORN RANDOMLY SOUNDED WITHOUT WARNING. THE CONTACT ATTEMPTED TO RECHARGE THE BATTERY, BUT THE FAILURE CONTINUED WITH THE ANTI-THEFT ALARM SOUNDING WHETHER THE DOOR WAS OPENED OR CLOSED. AFTER A WHILE, THE HORN AND ANTI-THEFT ALARMS STOPPED, BUT THE FAILURE PROGRESSED TO THE POINT THAT THE VEHICLE WAS UNSAFE TO BE DRIVEN. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS TO BE NOTIFIED TO DETERMINE A REPAIR SOLUTION FOR THE VEHICLE. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.
Electrical system, Engine, Jun 28, 2015
WHILE I WAS DRIVING BACK FROM THE SHOOTING RANGE THE ENGINE DID A HESITATION AND THEN WHEN I PUSHED DOWN ON THE GAS TO SEE IF IT WOULD CLEAR UP THE INSTRUMENT PANEL GAUGES WENT HAYWIRE. THE FUEL, SPEED, RPM AND HEATING CLUSTER LEVEL ARMS ALL WENT TO THE MAX POINT AND WHEN I LET OFF THE ACCELERATION TO PULL OVER THE CLUSTER PANEL GAUGES DIED LIKE THERE WAS NO POWER AND WHEN THE ENGINE IDLE LEVELED OFF THE GAUGES WENT BACK TO NORMAL. THE INSTRUMENT PANEL DID IT 4 MORE TIMES BEFORE I ACTUALLY GOT HOME. I AM AFRAID TO DRIVE IT TO WORK AND THIS IS MY ONLY TRANSPORTATION. WHAT IS CAUSING THE ISSUE WITH THIS? I NEED TO KNOW AS SOON AS POSSIBLE. THANKS.
Electrical system, Engine, May 18, 2015, fire
TL* THE CONTACT OWNED A 2003 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 5 MPH, THERE WAS SMOKE COMING FROM THE FRONT DRIVER SIDE OF THE VEHICLE WITHOUT WARNING. THE CONTACT DISCOVERED FLAMES UNDERNEATH THE VEHICLE. A POLICE OFFICER EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED AND TOWED TO AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.
Electrical system, Fuel/propulsion system, Mar 26, 2015
VEHICLE STALLS OR WILL NOT START AS DESCRIBED IN FORD RECALL NUMBER 04S13. I HAVE REPLACED MULTIPLE PARTS INCLUDING FUEL PUMP, GAS CAP, FUEL FILTER,ETC. AND NOW I FOUND THAT THERE WAS A PROBLEM WITH THE PCM PROGRAMMING ON THIS VEHICLE. I PURCHASED THIS TRUCK USED AND DO NOT KNOW IF THIS WAS SERVICED. THIS IS A DANGEROUS PROBLEM AS STALLING CAN CAUSE AN ACCIDENT. *TR
Electrical system, Engine, Sep 3, 2014
MY 2003 FOR ESCAPE REFUSES TO START AFTER BEING DRIVEN UNTIL SEVERAL HOURS IF NOT DAYS LATER. I HAVE REPLACED THE STARTER TWICE THE FIRST TIME IT WORKED FOR 2 MONTHS AND IT DID IT AGAIN ON 9-2-14 REPLACED THE STARTER AGAIN AND IT WILL NOT START STILL THERE IS NO POWER GOING TO ANY OF THE ELECTRICAL PARTS IN THE ENGINE COMPARTMENT AND THERE IS A STRONG SMELL OF FUEL. I HAVE REPLACED ALL RELAYS AND FUSES AND STILL NOTHING. I WAS STRANDED WITH MY 5 MONTH OLD AND 16 MONTH OLD IN 100 DEGREE WEATHER. *TR
Steering, Electrical system, Exterior lighting, Apr 24, 2014, crash
I CANT REMEMBER I JUST REMEMBER MY HEAD LIGHTS GOING OUT AND I TRIED TO CONTROL MY CAR AND COULDN'T. *TR
Electrical system, Aug 28, 2013
I HAD THE ALTERNATOR GO OUT IN THE MIDDLE OF A BUSY INTERSECTION IN THE MIDDLE OF RUSH HOUR TRAFFIC. I WAS VERY FORTUNATE NOT TO HAVE GOTTEN HIT. HOWEVER, THERE WAS AN ACCIDENT INVOLVING 2 OTHER VEHICLES DUE TO MY BEING STOPPED. AN ALTERNATOR GOING OUT IS NOT NORMALLY SOMETHING TO FILE A COMPLAINT ON. IT WENT OUT AGAIN IN 4 DAYS. OK, BAD ALTERNATOR, IT HAPPENS. I GET ON GOOGLE TO FIND OUT THAT THIS IS AN ONGOING PROBLEM WITH THE 2003 ESCAPES AND IT'S LISTED ALL OVER THE INTERNET. I HAD NO ADVANCED WARNING THAT THIS WAS GOING OUT. I'M ALMOST AFRAID TO DRIVE OUT OF TOWN. I DON'T KNOW ABOUT YOU ALL, BUT, I AM FINANCIALLY IN BAD SHAPE DUE TO THE ECONOMY. I AM WORKING FULL TIME FOR THE SAME WAGES I MADE IN THE 1980'S I CAN'T AFFORD MULTIPLE AUTOMOBILE REPAIRS FOR A PROBLEM THAT REQUIRES AS MUCH TIME TO REPLACE AS THIS DOES. THE FRONT AXLE HAS TO BE REMOVED IN ORDER TO REPLACE IT SO IT IS NOT A CHEAP REPAIR. WHY WOULD A REPAIR SHOP WANT TO HONOR A FAULTY PART WHEN EVIDENTLY IT'S AN ONGOING PROBLEM WITH THE VEHICLE. I SURE WOULDN'T!!! WHEN IS THIS ALTERNATOR DEFECT GOING TO CAUSE A SERIOUS ACCIDENT AND SOMEONE'S KIDS GET KILLED. HAD I BEEN FARTHER INTO THE INTERSECTION, IT WOULD HAVE BEEN MUCH WORSE.[XXX] LIKE I SAID, I HAD NO WARNING, IT JUST DIED. I HAVE 160,000 MILES ON THE VEHICLE SO I CAN UNDERSTAND THE FIRST ONE GOING OUT. BUT WHAT ABOUT THE 2ND 4 DAYS LATER? AND THIS IS A NATIONWIDE PROBLEM THAT HAS BEEN GOING ON FOR SEVERAL YEARS AND FORD IS AWARE OF IT!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TT
Electrical system, Electronic stability control (ESC), May 13, 2013, fire
ON MAY 8,2013, THE ANTI-THEFT ALARM SOUNDED WHILE MY CAR SAT IN THE DRIVEWAY. IT HAD NOT BEEN DRIVEN FOR 3 + HOURS. UPON INVESTIGATION OF THE ALARM, THERE WAS SMOKE COMING FROM THE ENGINE COMPARTMENT. THE WIRING HARNESS ATTACHED TO THE ABS HAD A SMALL FLAME AND SMOKE FROM ITS WIRING INSULATION. AFTER EXTINGUISHING THE FLAME AND DISCONNECTING THE BATTERY, I CALLED FOR A TOW . THE SAFETY FEATURES WORKED WELL AND LOCKED OUT THE ENTIRE AUTO SYSTEM. THE SERVICE TECHNICIAN SAID THERE WAS A RECALL ( RECALL 07S51 SUPPL #2 DTD 9 OCT 2009 ) AND THAT FORD SHOULD PROBABLY PROVIDE A FIX OR CREDIT TOWARD SAID FIX. THE CAR WAS THEN TOWED TO A FORD DEALERSHIP. THE CURRENT STATUS IS: 1.) THE WIRING HARNESS IS NO LONGER MANUFACTURED BY FORD AND THE DEALERSHIP HAS NO APPROVED PROVISIONS TO SECURE A HARNESS. 2.) RECALL 07S51 WAS IMPLEMENTED PER THEIR RECORDS SO THERE IS NO PROVISION FOR THE DEALERSHIP TO FIX THIS ISSUE EVEN IF THEY COULD GET A WIRING HARNESS AND THEN TROUBLESHOOT THE EXTENT OF THE DAMAGE.3.) MY PRIVATE INSURANCE'S COMPREHENSIVE PLAN DOES NOT COVER A VEHICLE SITTING STATIC FOR A WIRING FIRE. 4.) I AM AWAITING FORMS FROM FORD QUALITY GROUP TO PLEA FOR CONSIDERATION. ONCE THE FORMS ARE COMPLETED AND RECEIVED BY FORD CORPORATE OFFICES, THEIR LAWYERS WILL REQUIRE APPROX 15 DAYS TO MAKE A DETERMINATION IF MY CLAIM HAS MERIT. *TR
Electrical system, Air bags, Jun 8, 2012
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THE AIR BAGS LIGHT ILLUMINATES AND THERE WAS A CONSTANT BEEPING SOUND IN THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO RAN A DIAGNOSTIC TEST AND THERE WAS A CODE#B1869 STATING THE WIRING HARNESS FOR THE DRIVER AND PASSENGER SEATS AND BODY HARNESSES NEEDED TO BE REPLACED. THIS WOULD BE AN EXPENSE OF $686 TO THE CONTACT. THE MANUFACTURER WAS NOTIFIED WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 86,000.
Electrical system, Mar 23, 2012
WHEN I AM DRIVING MY CAR WILL TRY TO DIE AND ALL GAUGES WILL GO TO THE HIGHEST RPM, SPEED, AND FULL GAS, THEN IT WILL GO BACK TO ZERO AND THEN PROCEED TO THE SPEED I WAS GOING, THE BATTERY LIGHT WILL KEEP FLASHING BUT NO CHECK ENGINE LIGHT COMES ON. WHEN I RESEARCHED IT, IT SEEMS THAT ON MORE THAN TEN OCCASIONS IF NOT MORE ARE HAVING THE SAME ELECTRICAL PROBLEM AND NO GARAGE CAN FIGURE OUT, THEY TRY REPLACING ALTERNATORS, BATTERIES, AND WIRES AND GROUNDS AND NOTHING IS WORKING, IT CAN'T BE READ ON CODES BECAUSE NOTHING IS SHOWING UP. IF YOU ASK ME THIS SHOULD BE A RECALL BECAUSE IF YOU SEARCH IT IN BING OVER TWO HUNDRED MATCHES COMES UP WITH THE SAME COMPLAINT!!! *TR
Engine and engine cooling, Electrical system, Feb 27, 2012
THIS VEHICLE HAS A BAD MISFIRE PROBLEM,ROUGH IDLE AS WELL AS BAD HITCHING ON HIGHWAY. LOOKED IT UP ON YAHOO ANSWERS AND A LOT OF PEOPLE ARE HAVING THE SAME PROBLEM. IS THERE GOING TO BE A RECALL ON THESE VEHICLES. I'M HEARING FAULTY COMPUTERS. *TR
Engine and engine cooling, Electrical system, Apr 15, 2011
I HAVE A FORD 2003 ESCAPE 6 CYL. BOUGHT IN MAY OF 2004 NEW - 76 MILES ON IT TEST DRIVEN FROM A DEALER IN SCHULENBURG, TX - THE CHECK ENGINE LIGHT CAME ON - THE PCM COMPUTER WENT OUT AND BLEW A SPARK PLUG ON 1/16/2011 - I HAD TO REPLACE THE PCM (WHICH I WAS TOLD SHOULD HAVE BEEN A RECALL ON THE 2003 FORD ESCAPE) SINCE THIS SHOULD NEVER GO OUT ON THE CAR. THE MILEAGE WAS ONLY 43,625 ON 1/16/2011 WHEN THIS HAPPENED. I HAVE THE CAR FOR 7-8 YRS. NOW. I HAD TO REPLACE THE PCM WITH A REMANUFACTURED (SINCE IT WOULD COST WAY MORE FOR A NEW ONE) PCM - ELECTRONIC IGNITION COSTING ME JUST OVER $2,100. AGAIN, THIS PART WAS INTENDED TO NEVER GO OUT FOR THE LIFE OF THE CAR, PERIOD. THIS SHOULD HAVE BEEN A RECALL ON FORD MOTOR COMPANIES PART - AND I WAS TOLD TO COMPLAIN AND RECORD THIS TO NHTSA AS OTHERS HAVE, AND IF ENOUGH DO, THEY WOULD HAVE TO RECALL. I AM NOT SURE IF I AM IN THE RIGHT PLACE TO PLACE THIS COMPLAINT. *TR
Electrical system, Air bags, Equipment, Mar 31, 2009
I HAVE A 03 FORD ESCAPE, AND THE TROUBLE IS ENDLESS. THE CAR WILL NOT START AT TIMES AND IT IS A STRONG SMELL OF GAS WHEN THIS HAPPENS. I HAVE HAD IT IN AND OUT OF THE SHOP ABOUT 6 TIMES AND HAS HAD THE CAR FOR ONLY 2 YEARS. THE FAILURE TO START IS SCARY BECAUSE YOU DON'T KNOW IF THE CAR IS GOING TO EXPLODE OR WHAT. THE DEALERSHIP TELLS ME THAT IT IS A SENSOR THAT GOES OUT AND TELLS THE CAR IT DOESN'T HAVE TO START. BEEN REPLACED 6 TIMES AND THE OTHER DAY IT DID IT AGAIN. I HATE TO GO OUT OF TOWN BECAUSE OF THE FEAR OF GETTING STRANDED ON THE HIGHWAY. AND ANOTHER THING THE SMELL OF THE ENGINE IS CRAZY MY DAUGHTER HAS ASTHMA AND TALKING ABOUT A PROBLEM FOR HER IT IS. I CAN GO TO WORK AND GO BACK 30 MINUTES LATER TO MY CAR AND YOU CAN TELL THAT IT IS STILL SMELLING OF COURSE WHERE I GOT IT FROM THEY TOLD ME THAT IT WAS NO CONCERN IT WAS DUE TO THE FACT OF THEM DROPPING OIL WHEN THEY DID A CHANGE, COME ON PEOPLE 2 MONTHS LATER. I FEAR THAT ONE DAY IT WILL EXPLODE I JUST PRAY TO GOD THAT MY FAMILY IS NOT IN THERE. THE AIRBAG LIGHT WILL NOT GO OFF AND FROM READING IN HERE I AM SCARED TO DEATH. SOMETHING REALLY NEEDS TO BE DONE ABOUT THIS PROBLEM BEFORE SOME FAMILY LOSES A MEMBER. *TR
Electrical system, Jan 1, 2008
I PURCHASED MY 2003 FORD FOCUS IN 2005 AND EVER SINCE THE IGNITION SWITCH GETS STUCK BUT IT HAS GOT STUCK OVER THE LAST THREE YEARS . *CN