2003 Ford Escape
Problems, recalls and owner-reported issues
Structure is the leading concern among 598 owner complaints filed for this model year. This is the 17th highest complaint count among 26 Escape model years with reports.
Of the 2003 reports, 44 involved a crash and 29 involved a fire. 32 people were injured.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Structure, frame and membersApr 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14S02.
Campaign 14V165000 on NHTSA.gov
Engine and engine coolingJul 26, 2012
Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used.
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. Owners may contact Ford at 1-866-436-7332.
Campaign 12V353000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 10, 2007
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED.
DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 07V156000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Vehicle speed control, cablesDec 7, 2004
ON CERTAIN SPORT UTILITY VEHICLES BUILT WITH 3.0L V6 ENGINES, THE ACCELERATOR CABLE MAY PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.
AN UNEXPECTED INCREASE IN ENGINE IDLE SPEED MAY INCREASE STOPPING DISTANCE AND MAY RESULT IN A VEHICLE CRASH.
DEALERS WILL REPLACE THE ACCELERATOR CABLE. THE RECALL BEGAN ON JANUARY 10, 2005. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 04V574000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Apr 6, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.0L V6 ENGINES, DURING DECELERATION, THE ENGINE CAN STALL.
SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
DEALERS WILL REPROGRAM THE POWER CONTROL MODULE (PCM) WITH THE APPROPRIATE CALIBRATION. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V165000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
52 reports, newest first. Show all
Engine and engine cooling, Vehicle speed control, Mar 6, 2014
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE ABNORMALLY ACCELERATED WITHOUT WARNING. THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER 12V353000 (ENGINE AND ENGINE COOLING VEHICLE SPEED CONTROL) HOWEVER, THE FAILURE WAS NOT CORRECTED. THE VEHICLE LATER STALLED WHILE TRAVELING 60 MPH AND THE CONTACT WAS ABLE TO STOP THE ACCELERATION FAILURE BY FORCEFULLY APPLYING THE BRAKES. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THE DEALER INSPECTED THE VEHICLE AND ADVISED THAT THE THROTTLE NEEDED TO BE CLEANED OR REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGE WAS 140,000. *TR
Engine and engine cooling, Power train, Vehicle speed control, Jan 24, 2014
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 65 MPH HE TRIED TO ACCELERATE AND THE RPMS INCREASED. THE BRAKE FAILED TO ENGAGE UNTIL HE PUT THE GEAR SHIFT INTO NEUTRAL. THE CONTACT WAS ABLE TO MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD, WHERE THE VEHICLE WAS ABLE TO BE RESTARTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC DIAGNOSED THAT THERE WAS TO MUCH AIR GOING INTO THE THROTTLE BODY, AND THE COLD AIR WAS FREEZING THE THROTTLE BODY AND PREVENTED IT FROM FUNCTIONING PROPERLY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 76,000. UPDATED 3/5/14*CN *TR
Engine and engine cooling, Vehicle speed control, Apr 29, 2013, crash
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE RPM INCREASED EXCESSIVELY AND THE VEHICLE SUDDENLY ACCELERATED WHICH CAUSED THE CONTACT TO CRASH INTO A BUILDING. THE CONTACT WAS RUSHED TO THE HOSPITAL WHERE HE SUSTAINED BACK AND NECK INJURIES. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHERE IT WAS NOT DIAGNOSED FOR THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER : 12V353000 (ENGINE AND ENGINE COOLING , VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 150,000. *TR..UPDATED 06/24/13 *BF UPDATED 06/28/2013 *JS
Engine and engine cooling, Vehicle speed control, Engine, Mar 12, 2013
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT SHE RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER 12V353000 (ENGINE AND ENGINE COOLING, VEHICLE SPEED CONTROL) AND TOOK THE VEHICLE TO THE DEALER FOR RECALL REPAIRS. THE CONTACT STATED THAT APPROXIMATELY SIX MONTHS AFTER HAVING THE VEHICLE SERVICED UNDER THE RECALL THE VEHICLE BEGAN TO EXHIBIT ACCELERATION ISSUES. THE CONTACT WAS DRIVING APPROXIMATELY 20 MPH AND THE VEHICLE WOULD NOT ACCELERATE OVER 60 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED HER THAT THE CATALYTIC CONVERTER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 86,900. THE CURRENT MILEAGE WAS APPROXIMATELY 88,841. *TR
Engine and engine cooling, Power train, Oct 1, 2012
MY CAR IS MISFIRING AND STALLING ON DE-ACCELERATION (WHEN WE SLOW DOWN). IT STARTED RECENTLY. FIRST IT HAD THE ENGINE LIGHT COME ON. WE HAD IT TESTED BY A MECHANIC WITH THE ELECTRICAL READER AND IT SAID WE NEEDED A NEW COIL. WE REPLACED THE COIL, DID A FULL TUNE UP AND IT STILL IS NOT WORKING. AFTER MANY HOURS OF RESEARCH WE SEE THAT THE FORD ESCAPE PCM HAS BEEN A CONSISTENT MANUFACTURING PROBLEM AND THE 2003 FORD ESCAPE HAD THIS PROBLEM. I CALL FORD AND THEY TELL ME MY CAR WAS NOT COVERED UNDER THAT PARTICULAR RECALL. HOWEVER, IT IS CLEAR THAT THIS IS A SERIOUS PROBLEM WITH FORD ESCAPE. WHAT I AM TO DO? DRIVE THE CAR LIKE THIS AND RISK IT STALLING IN AN INTERSECTION OR ON A HILL AND HAVE THE POSSIBILITY OF A CRASH? FORD SHOULD BE HELD RESPONSIBLE FOR THIS MANUFACTURING PROBLEM THAT THEY HAVE DOCUMENTED OVER THE YEARS. *TR
Engine and engine cooling, Mar 12, 2012, fire
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE WAS PARKED IN A RESIDENTIAL DRIVEWAY WHEN THERE WAS A LOUD NOISE AND THE ENTIRE VEHICLE BECAME ENGULFED IN FLAMES. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE. THE ORIGIN OF THE FIRE WAS UNKNOWN AND A FIRE REPORT WAS FILED. THERE WERE NO INJURIES AND THE INSURANCE COMPANY WAS CONTACTED. THERE HAD BEEN NO MAINTENANCE PERFORMED ON THE VEHICLE PRIOR TO THE FAILURE FOR AT LEAST SIX MONTHS. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 157,000.
Suspension, Engine and engine cooling, Structure, Mar 6, 2012
WHEN I RECENTLY HAD MY ROUTINE MAINTENANCE CHECK ON MY VEHICLE I WAS HORRIFIED WHEN MY MECHANIC INFORMED ME THAT THE FRONT SUB FRAME WAS RUSTED FROM THE INSIDE OUT! CAN YOU IMAGINE MY UTTER SHOCK WHEN MY MECHANIC ADVISED ME THAT THIS VEHICLE IS PROHIBITED TO BE DRIVEN SINCE CATASTROPHIC OUTCOMES WOULD BE LIKELY? HOW VERY FORTUNATE NOTHING FATAL TOOK PLACE WHILE BEING IN THIS VEHICLE; BECAUSE BASED ON THE CONDITION OF THE SUB FRAME IT COULD HAVE BEEN MY REALITY TO SUFFER DETRIMENTAL CONSEQUENCES. MY YOUNG CHILDREN ARE IN THIS SUV EVERY SINGLE DAY AND TO THINK THEIR LIVES WERE AT RISK JUST BY BEING A PASSENGER HAS SICKENED ME BEYOND WORDS. I HAD NO OTHER CHOICE BUT TO GET IT REPAIRED ASAP, SO I INFORMED THE CUSTOMER RELATIONSHIP CENTER OF FORD MOTOR COMPANY AS INSTRUCTED BY THEIR WEBSITE AND ALL THEY COULD DO WAS APOLOGIZE FOR ANY INCONVENIENCE. THIS FRIGHTENING SITUATION GOES FAR BEYOND FROM BEING AN INCONVENIENCE IT COULD HAVE BEEN A MAJOR LIFE THREATENING ISSUE. I WAS NOT ASKING FORD FOR A NEW VEHICLE, I SIMPLY WAS ASKING FOR ASSISTANCE TOWARDS A MAJOR EXPENSE THAT WAS NOT CAUSED BY MY LACK OF PROTECTING MY MAJOR INVESTMENT WITH ROUTINE MAINTENANCE CHECKS BUT BY FORD HAVING DEFECTIVE SUB-FRAMES INSTALLED IN THEIR VEHICLES. MY MECHANIC HAS NEVER SEEN SUCH A STRUCTURAL DEFECT AS THIS EVER BEFORE! FORD HAS ALREADY MANUFACTURED VEHICLES THAT INVOLVED MAJOR RECALLS FOR THE EXACT SAME PROBLEM, SO QUITE NATURALLY OTHER FORD MODELS COULD SUFFER THE SAME DANGEROUS CONSEQUENCES WITH REGARDS TO THE FRONT SUB FRAME . I BELIEVE AN INVESTIGATION ON THIS HORRIFIC ISSUE IS DEEMED A NECESSITY DUE TO THE HISTORY OF FORD'S SUB FRAMES. THIS HAS BEEN VERY DEVASTATING TO ME AND I CAN'T IMAGINE ALLOWING ANOTHER CONSUMER TO ENDURE THIS MAJOR FEAR. YOUR ATTENTION TO THIS IS APPRECIATED. *TR
Engine and engine cooling, Electrical system, Feb 27, 2012
THIS VEHICLE HAS A BAD MISFIRE PROBLEM,ROUGH IDLE AS WELL AS BAD HITCHING ON HIGHWAY. LOOKED IT UP ON YAHOO ANSWERS AND A LOT OF PEOPLE ARE HAVING THE SAME PROBLEM. IS THERE GOING TO BE A RECALL ON THESE VEHICLES. I'M HEARING FAULTY COMPUTERS. *TR
Engine and engine cooling, Aug 1, 2011
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THE VEHICLE STARTED HESITATING AND SPUTTERING PRIOR TO THE FAILURE. THE CONTACT TOOK THE VEHICLE TO A MECHANIC WHO CHANGED WAS THE SPARK PLUGS AND THE COILS WERE REPLACED PRIOR TO THE CATALYTIC CONVERTER FAILING. THE CATALYTIC CONVERTER FAILURE RUINED THE ENGINE. THE FAILURE MILEAGE WAS 141,000 AND THE CURRENT MILEAGE WAS 142,000.
Engine and engine cooling, Electrical system, Apr 15, 2011
I HAVE A FORD 2003 ESCAPE 6 CYL. BOUGHT IN MAY OF 2004 NEW - 76 MILES ON IT TEST DRIVEN FROM A DEALER IN SCHULENBURG, TX - THE CHECK ENGINE LIGHT CAME ON - THE PCM COMPUTER WENT OUT AND BLEW A SPARK PLUG ON 1/16/2011 - I HAD TO REPLACE THE PCM (WHICH I WAS TOLD SHOULD HAVE BEEN A RECALL ON THE 2003 FORD ESCAPE) SINCE THIS SHOULD NEVER GO OUT ON THE CAR. THE MILEAGE WAS ONLY 43,625 ON 1/16/2011 WHEN THIS HAPPENED. I HAVE THE CAR FOR 7-8 YRS. NOW. I HAD TO REPLACE THE PCM WITH A REMANUFACTURED (SINCE IT WOULD COST WAY MORE FOR A NEW ONE) PCM - ELECTRONIC IGNITION COSTING ME JUST OVER $2,100. AGAIN, THIS PART WAS INTENDED TO NEVER GO OUT FOR THE LIFE OF THE CAR, PERIOD. THIS SHOULD HAVE BEEN A RECALL ON FORD MOTOR COMPANIES PART - AND I WAS TOLD TO COMPLAIN AND RECORD THIS TO NHTSA AS OTHERS HAVE, AND IF ENOUGH DO, THEY WOULD HAVE TO RECALL. I AM NOT SURE IF I AM IN THE RIGHT PLACE TO PLACE THIS COMPLAINT. *TR
Engine and engine cooling, Nov 30, 2010
TL*THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE SUDDENLY SHUTTERED AND COMPLETELY STALLED. THE CONTACT WAS ABLE TO RESTART IT. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.
Engine and engine cooling, Mar 22, 2010
TL*THE CONTACT OWNS A 2003 FORD ESCAPE. INTERMITTENTLY, THE VEHICLE FAILED TO ACCELERATE WHILE THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH UP AN INCLINE. THE VEHICLE WOULD ALSO SUDDENLY ACCELERATE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE GASKET RECIRCULATOR WAS REPAIRED. THE CONTACT WAS INFORMED TO DRIVE THE VEHICLE ON THE HIGHWAY AT A HIGH SPEED. AS THE CONTACT WAS ATTEMPTING TO ACCELERATE TO A HIGH SPEED SHE SUDDENLY HEARD A LOUD SOUND. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE GASKET RECIRCULATOR WAS REPAIRED FOR THE SECOND TIME AND THE CATALYTIC CONVERTER WAS ALSO SERVICED. IN MARCH 2010 WHILE TRAVELING AT 60 MPH THE CONTACT ATTEMPTED TO ACCELERATE AND THE PEDAL HAD FALLEN TO THE FLOOR AND THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THEY WOULD NOT OFFER ANY ASSISTANCE WITH THE REPAIRS. THE CURRENT MILEAGE WAS APPROXIMATELY 100,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 80,600.
Engine and engine cooling, Feb 18, 2010
I OWN A 2003 FORD ESCAPE WITH A 6 CYLINDER ENGINE WHICH I BOUGHT NEW FROM HARROLD FORD IN SACRAMENTO 11/2002. I NOTICED A STRONG OIL BURNING SMELL. AND OIL LEAKING FROM THE ENGINE. I WAS UNABLE TO LOCATE THE SOURCE OF THE LEAK, SO I TOOK THE VEHICLE INTO HARROLD FORD ON 12/30/2009. THE DEALER INFORMED ME THE OIL WAS LEAKING THRU THE OIL PAN, AND THAT FORD HAD A RETROFIT FOR THE PROBLEM. I ASKED IF THIS WAS A SEAL PROBLEM. I WAS TOLD NO, THE MATERIAL THE OIL PAN WAS MADE OF ALLOWED THE OIL TO EVENTUALLY START LEAKING DIRECTLY THRU THE MATERIAL. I ASKED IF THIS WAS A RECALL DUE TO THE FIRE DANGER, AND WAS TOLD NO. THE REPAIR WAS COMPLETED AND THE OIL PAN WAS REPLACED. I KEPT THE OLD OIL PAN. *TR
Engine and engine cooling, Power train, Dec 24, 2009
FORD IS NOT ALLOWING MY CAR TO BE INCLUDED IN THE SAFETY RECALL: 04S13 FOR POWERTRAIN CONTROL MODULE RE-CALIBRATION. I HAVE NOTIFIED FORD AND THEY ARE SAYING THEY NEVER MISS A VEHICLE THAT GETS RECALLED. MY VEHICLE HAS STALLED MORE THAN 7 TIMES WHEN DECELERATING UNDER 40PMH. I HAVE BROUGHT MY CAR INTO A MECHANIC TWO TIMES FOR THE SAME PROBLEM. EVERYTIME IT WAS DETERMINED THAT THERE WAS NO REASON FOR THE VEHICLE TO STALL. *TR
Engine and engine cooling, Aug 11, 2009
MY 2003 FORD ESCAPE 6 CYL 2 WHEEL DRIVE WAS STOPPED AT A STOPLIGHT WHEN THE ENGINE SUDDENLY REVVED TO OVER 4000 RPM FOR APPROXIMATELY 7 SECONDS. FORTUNATELY, I HAD MY FOOT ON THE BRAKE AT THE TIME. CHANGING FROM DRIVE TO NEUTRAL HAD NO EFFECT ON THE RPMS AND THE ENGINE WENT BACK TO ABOUT 1500 RPMS THROUGH NO ACTION ON MY PART. AFTERWARDS, THE VEHICLE DROVE NORMALLY. I RECALL THAT SIMILAR OCCURRENCES HAVE HAPPENED IN THE PAST SO I WANTED TO GET THIS INFORMATION TO YOU ASAP. I DO NOT RECALL WHAT VEHICLES WERE INVOLVED AT THAT TIME. WHAT WORRIES ME IS IF THAT HAPPENS WHILE I AM IN A PARKING LOT BACKING OUT OR SOME OTHER SITUATION WHERE MY REACTION WOULD BE TOO SLOW TO STOP AN ACCIDENT OR DAMAGE TO MY VEHICLE. THE VEHICLE HAS ABOUT 32,000 MILES ON IT AND I AM THE ORIGINAL OWNER. *TR
Engine and engine cooling, Jan 28, 2009, fire
TL*THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT TOOK THE VEHICLE TO A REPAIR SHOP BECAUSE THE EMISSIONS INDICATOR WAS ILLUMINATED. THE REPAIR SHOP KEPT THE VEHICLE FOR TWO WEEKS DUE TO THE PARTS THAT NEEDED TO BE ORDERED. WHEN THE GASKET WAS INSTALLED IN THE VEHICLE, THE ENGINE BECAME VERY HOT AND THE CORKING (USED TO SEAL THE GASKET) MELTED ONTO THE CATALYTIC CONVERTER. THE DEALER STATED THAT THE FAILURE WAS DUE TO THE CATALYTIC CONVERTER AND WOULD COST $3,700 JUST TO START THE VEHICLE AND DETERMINE WHAT OTHER MALFUNCTIONS WERE OCCURRING. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS APPROXIMATELY 70,000 AND FAILURE MILEAGE WAS APPROXIMATELY 68,000.
Engine and engine cooling, Sep 22, 2008
TL*THE CONTACT OWNS A 2003 FORD ESCAPE. WHEN THE CONTACT DECELERATED AND REACHED A SPEED OF 40 MPH OR LESS, THE VEHICLE WOULD STALL. IT WOULD COMPLETELY SHUT DOWN WITH NO POWER STEERING OR BRAKING ABILITY. SHE SHIFTED INTO NEUTRAL WHILE DEPRESSING THE ACCELERATOR PEDAL IN ORDER TO RESTART THE VEHICLE. THE FAILURE OCCURRED AT LEAST ONCE PER DAY. THE DEALER STATED THAT THEY WOULD REPAIR THE VEHICLE AT THE CONTACT'S EXPENSE. THE MANUFACTURER STATED THAT HER VIN WAS NOT INCLUDED IN ANY RECALLS RELATED TO THE FAILURE. THE CURRENT MILEAGE WAS APPROXIMATELY 110,000 AND FAILURE MILEAGE WAS APPROXIMATELY 107,000.
Engine and engine cooling, Aug 11, 2008
MY 2003 FORD ESCAPE STALLS WHILE DRIVING LEAVING ME WITHOUT POWER STEERING OR BRAKES. I CONTACTED FORD AT 800-392-3673 TO ASK ABOUT A RECALL. I FOUND OUT THAT FORD HAS RECALLED 363,440 FORD ESCAPES FOR THIS EXACT PROBLEM. I WAS TOLD THAT MY VIN NUMBER DID NOT CORRESPOND WITH THE 363,440 FORD ESCAPES THEY RECALLED BUT TO KEEP INTOUCH WITH MY SERVICE MANAGER AT THE FORD DEALERSHIP FOR MORE UPDATES. AT THIS TIME THEY CANNOT DO ANYTHING ABOUT IT. *TR
Engine and engine cooling, Jul 16, 2008
DEALERSHIP FAILED TO NOTIFY ME OF CURRENT VEHICLE RECALLS REGARDING MY 2003 FORD ESCAPE LIMITED, FAILED TO IDENTIFY MECHANICAL PROBLEMS DURING SCHEDULED MAINTENANCE (OIL CHANGE) AS RECOMMENDED BY THE FORD MOTOR COMPANY, WHICH STATES ITS TECHNICIANS PERFORM A "MULTI-POINT INSPECTION" "WITH THE MOST UP-TO-DATE TRAINING" WHICH LED TO SUBSEQUENT ENGINE FAILURE (LOCKED-UP). *TR
Engine and engine cooling, Apr 22, 2008
TL*THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE ATTEMPTING TO MAKE A LEFT TURN AT 5 MPH, THE VEHICLE SHUT OFF. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT MILEAGE WAS 78,942 AND FAILURE MILEAGE WAS 75,000.
Engine and engine cooling, Dec 19, 2007
2003 ESCAPE LIMITED 3.0 V6 IS DIAGNOSED WITH A CRACKED EXHAUST MANIFOLD RESULTING IN LEAKING EXHAUST GASES. VEHICLE MILEAGE IS 31,200 AND HAS NEVER BEEN OFF PAVED ROADWAYS. I THINK THIS PROBLEM HAS EXISTED FOR SOME TIME BUT HAS NEVER BEEN PICKED UP ON BY REGULAR MAINTENANCE VISITS TO THE DEALERSHIP. MY DEALER EXPLAINED THAT THE PROBLEM IS A COMMON ONE AND OBVIOUSLY SHOULD HAVE BEEN A RECALL ITEM AS LEAKING EXHAUST GASES ARE VERY DANGEROUS. *TR
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Nov 6, 2007
TL*THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING 20 MPH, THE BRAKE PEDAL WAS APPLIED. THE ENGINE BEGAN TO REV AND THE RPM RACED TO ITS MAXIMUM POTENTIAL. THE CONTACT TURNED OFF THE ENGINE IN ORDER TO STOP THE VEHICLE. THERE WERE NO WARNING INDICATORS PRESENT. THE VEHICLE WAS NOT INSPECTED BY A DEALER. THE CURRENT AND FAILURE MILEAGES WERE 62,900. UPDATED 01/09/08. *LJ THE CONSUMER STATED NOISE IN FRONT END WHEN HITTING A BUMP AND PERFORMED INSPECTION PER RECALL. UPDATED 12/12/07 *TR
Engine and engine cooling, Power train, Jun 5, 2007
TL*THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING UNDER 40 MPH, THE ENGINE FAILED. THE FAILURE HAS OCCURRED ON FOUR DIFFERENT OCCASIONS. SAFETY RECALL # 04V165000 (POWER TRAIN:AUTOMATIC TRANSMISSION CONTROL MODULE (TCM, PCM)) DOES NOT APPLY TO THE VIN. THE PURCHASE DATE AND ENGINE SIZE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 66,000. UPDATED 02/01/08. *LJ UPDATED 02/01/08 *TR
Engine and engine cooling, May 5, 2007
WE OWN A 2003 FORD EXPEDITION WITH A 5.4 L, V-8 TRITON ENGINE. WHILE DRIVING WE HEARD A LOUD BANG AND THEN IT SOUNDED LIKE THE ENGINE WAS BACK FIRING. WE SMELLED GAS AND A BURNING SMELL. WE HAD OUR EXPEDITION TOWED TO THE DEALER AND WERE INFORMED THAT SPARK PLUG #7 HAD BLOWN OUT OF THE HEAD, STRIPPING THE THREADS. THE DEALERSHIP INFORMED US THAT THE HEAD NEEDED TO BE REPLACED AT AN ESTIMATED COST OF $3,500. WE HAD PREVIOUSLY TAKEN THIS EXPEDITION INTO FORD AT 72,723 MILES BECAUSE THE ENGINE LACKED POWER AND SURGED. WE WERE TOLD THAT SPARK PLUG #7 NEEDED TO BE REPLACED. THIS WAS PRIOR TO THE FORD'S RECOMMENDATION OF A TUNE UP TO BE DONE AT 100,000. THEY REPLACED SPARK PLUG #7 UNDER WARRANTY, BUT WE WERE CHARGED TO REPLACE THE OTHER SPARK PLUGS. THIS IS THE SAME SPARK PLUG THAT BLEW OUT AT 108,411 MILES. WE HAVE CONTACTED MANY MECHANICS TO SEE WHAT OTHER OPTIONS WERE AVAILABLE. WE ATTEMPTED TO HAVE OUR EXPEDITION REPAIRED BY PLACING A RECOMMENDED PERMANENT THREAD REPLACEMENT INSERT PUT INTO THE #7 CYLINDER; WHICH DID NOT FIX THE PROBLEM. WE HAVE BEEN INFORMED THAT THE VEHICLE HAS LOW COMPRESSION IN #7 CYLINDER AND NEEDS A NEW ENGINE AT AN ESTIMATED COST OF $6,000. THE MECHANIC SHOPS THAT WE CONTACTED HAVE INFORMED US THAT THIS IS A FREQUENT PROBLEM WITH THE ALUMINUM HEADS ON THE FORD EXPEDITION AND SOME OTHER FORD TRUCKS. A REVIEW OF THE COMPLAINTS FILED WITH NHTSA SHOWS THAT THIS IS A WIDE SPREAD PROBLEM WITH THE FORD ENGINES. WE ARE REQUESTING THAT A DEFECT INVESTIGATION BE COMPLETED AND THAT FORD BE HELD RESPONSIBLE FOR THE DEFECT IN THEIR FORD EXPEDITION ENGINES/HEADS. *JB
Engine and engine cooling, Electrical system, Apr 6, 2007
ON FEBRUARY 2007 I WAS DRIVING THE EXPEDITION IN RUSH HOUR TRAFFICWHEN I NOTICED THAT CAR BEGAN TO FEEL VERY HEAVY. I ALSO NOTICED THAT THE SPEEDOMETER WAS GOING DOWN DESPITE FACT THAT I WAS PRESSING DOWN THE GAS PEDAL, AND SUDDENLY ALL OF THE ENGINE LIGHTS TURNED ON. I WAS ABLE TO PULL OVER AND START THE CAR WITH NO PROBLEM ,BUT 5 MINUTES LATER IT WILL DO THE SAME THING ALL OVER AGAIN. I TOOK THE CAR TO THE DEALER, AND EVER SINCE THEY ARE AWAITING FOR PARTS TO COME IN ,AND THEY HAVE BEEN ON NATIONAL BACKORDER. FORD D REFUSES TO GIVE ME EITHER A RENTAL OR A LOANER. FORD CONSUMER DEPARTMENT SUCKS.*AK