2003 Ford Escape
Problems, recalls and owner-reported issues
Structure is the leading concern among 598 owner complaints filed for this model year. This is the 17th highest complaint count among 26 Escape model years with reports.
Of the 2003 reports, 44 involved a crash and 29 involved a fire. 32 people were injured.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Structure, frame and membersApr 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14S02.
Campaign 14V165000 on NHTSA.gov
Engine and engine coolingJul 26, 2012
Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used.
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. Owners may contact Ford at 1-866-436-7332.
Campaign 12V353000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 10, 2007
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED.
DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 07V156000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Vehicle speed control, cablesDec 7, 2004
ON CERTAIN SPORT UTILITY VEHICLES BUILT WITH 3.0L V6 ENGINES, THE ACCELERATOR CABLE MAY PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.
AN UNEXPECTED INCREASE IN ENGINE IDLE SPEED MAY INCREASE STOPPING DISTANCE AND MAY RESULT IN A VEHICLE CRASH.
DEALERS WILL REPLACE THE ACCELERATOR CABLE. THE RECALL BEGAN ON JANUARY 10, 2005. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 04V574000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Apr 6, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.0L V6 ENGINES, DURING DECELERATION, THE ENGINE CAN STALL.
SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
DEALERS WILL REPROGRAM THE POWER CONTROL MODULE (PCM) WITH THE APPROPRIATE CALIBRATION. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V165000 on NHTSA.gov
Representative owner complaints: structure
121 reports, newest first. Show all
Structure, Vehicle speed control, Engine, Apr 25, 2017
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 12V353000 (ENGINE AND ENGINE COOLING, VEHICLE SPEED CONTROL) AND 14V165000 (STRUCTURE); HOWEVER, THE PARTS FOR THE RECALL REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE UNDERCARRIAGE OF THE VEHICLE, ESPECIALLY NEAR THE CONTROL ARM, WAS CORRODED TO THE POINT THAT IT FAILED INSPECTION. ALSO, THE VEHICLE'S RPM MONITOR FLUCTUATED BETWEEN 0-5, FAILING TO CORRECTLY INDICATE AN INCREASE IN RPMS. THE FAILURE CAUSED THE VEHICLE TO REV UP WITHOUT THE CONTACT PURPOSELY CAUSING AN INCREASE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 244,310. PARTS DISTRIBUTION DISCONNECT.
Structure, Mar 28, 2017
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT 25 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE VEHICLE AND THAT WHEN DRIVING IT FELT ABNORMAL WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SUB FRAME HAD EXPERIENCED SEVERE CORROSION AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT STATED TWO YEARS PRIOR TO THE FAILURE VEHICLE WAS REMEDIED UNDER NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.
Structure, Mar 10, 2017
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING 65 MPH, A LOUD NOISE WAS HEARD COMING FROM THE FRONT PASSENGER SIDE AND THE VEHICLE IMMEDIATELY VEERED TO THE SIDE OF ROAD. THE CONTACT MENTIONED THAT THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). THE VEHICLE WAS TOWED HOME TO A FAMILY MEMBER'S HOME WHERE IT WAS INSPECTED BY AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT A CRACKED SUBFRAME DUE TO EXTREME CORROSION WAS THE CAUSE OF THE FAILURE. THE MANUFACTURER AND DEALER DID NOT PROVIDE ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 113,000.
Structure, Jan 3, 2017
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE DROVE ABNORMALLY. THE DEALER CONFIRMED THAT THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE) PRIOR TO BEING PURCHASED. THE ONTACT STATED THAT THE FRAME OF THE VEHICLE HAD CORRODED WHERE THE SUPPORT BRACKETS WERE INSTALLED FROM THE PREVIOUS RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000. ..UPDATED 02/09/17 *BF
Suspension, Structure, Dec 1, 2016
MY 17-YEAR-OLD SON WAS DRIVING THE CAR HOME FROM WORK AND AFTER MAKING A RIGHT TURN THE CAR SEVERELY JERKS TO THE RIGHT. HE ALMOST WENT OFF OF THE ROAD. WE TOOK THE CAR TO OUR LOCAL MECHANIC AND WERE TOLD THAT THERE WAS CORROSION AND SEPARATION OF THE CONTROL ARM AND WE WOULD NEED A BRACE TO COMPLETE THE REPAIR. THE MECHANIC SAID WHEN HE TOOK THE CAR FOR A TEST DRIVE THE STEERING WHEEL IS OUT OF ALIGNMENT AND HE ALMOST HIT A MAILBOX WHEN THE CAR JERKED TO THE RIGHT. WHEN INVESTIGATING HOW TO GET A USED PART I DISCOVERED THAT THERE IS A RECALL FOR THIS EXACT ISSUE (FORD RECALL #14S02). MY CAR FITS THE SAME MODEL YEAR AND PURCHASE/REGISTRATION LOCATIONS AS INDICATED IN THE RECALL, BUT FORD REFUSES TO MAKE THE REPAIR UNDER THE RECALL. CURRENTLY WE ARE COMPLETELY UNABLE TO DRIVE THE VEHICLE BECAUSE IT IS UNSAFE FOR MY SON AND OTHER DRIVERS ON THE ROAD FOR THE CAR TO BE DRIVEN. HAD MY SON BEEN DRIVING FASTER WHEN THIS HAPPENED THERE COULD HAVE BEEN A TERRIBLE ACCIDENT. *TR
Suspension, Structure, Nov 18, 2016
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. UPON EXITING A PARKING AREA, THERE WAS AN ABNORMAL SUSPENSION VIBRATION NEAR THE FRONT OF THE VEHICLE. THE FRONT SUBFRAME FRACTURED AND IMPACTED THE FRONT PASSENGER SIDE TIRE. THE CONTACT AND A MECHANIC INSPECTED THE FACT THAT THERE HAD BEEN PREMATURE RUST AND CORROSION ASSOCIATED WITH THE UNDERBODY, SUBFRAME, AND THE BAR THAT WAS CONNECTED TO THE FRAME. THE VEHICLE WAS UNABLE TO BE DRIVEN AND WAS TOWED BY THE MECHANIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO SOLUTION OTHER THAN FOR THE CONTACT TO TAKE THE VEHICLE TO THE DEALER. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V165000 (STRUCTURE) AND 15E045000 (SUSPENSION). THE FAILURE MILEAGE WAS NOT AVAILABLE.
Structure, Nov 7, 2016
THE VEHICLE WAS MOVING AT 35 MPH, THE FRONT PASSENGER SIDE WHEEL STARTED MAKING NOISE AND GOT WOBBLY. I TOOK IT TO A FORD DEALER. THE SERVICE DEPARTMENT TOOK A DAY TO DIAGNOSE THE PROBLEM. THEY INDICATED THAT THE SUB FRAME HAS RUSTED OUT AND THE LOWER CONTROL ARMS ARE NOT SECURE IN THE SUB-FRAME AND MAY SEPARATE ANYTIME. THEY REFUSE TO FIX THE PROBLEM AS PER THE RECALL SAYING THAT THEY PUT A CROSS BRACE AND THE RECALL IS FIXED. THE CROSS BRACE THAT WAS PUT, IS A BAND-AID FIX AND DOES NOT ADDRESS THE FAILURE OF THE DEFECTIVE SUB-FRAME. THE SUB-FRAME WILL FAIL EVEN AFTER INSTALLING THE CROSS BRACE THAT FORD SEEMS TO THINK WILL FIX THE PROBLEM. THE LOWER CONTROL ARM WILL SEPARATE AND THE CROSS BRACE WILL NOT PREVENT ANY ACCIDENTS THAT COULD RESULT FROM LOWER CONTROL ARM SEPARATION.
Structure, Oct 28, 2016
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). THE VEHICLE WAS REPAIRED. WHILE DRIVING APPROXIMATELY 5 TO 10 MPH, THERE WAS A GRINDING NOISE. THE VEHICLE WAS COASTED OVER TO THE SIDE OF THE ROAD AND TOWED TO A MECHANIC. IT WAS DIAGNOSED THAT THE SUBFRAME WAS COMPLETELY RUSTED. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.
Steering, Suspension, Structure, Aug 12, 2016
WHILE DRIVING, THE FRONT RIGHT TIRE FELT LIKE IT WAS GOING TO FALL OFF THE VEHICLE. I TOOK IT TO MY MECHANIC WHO STATED THAT THE SUB-FRAME WAS CRACKED AND FORD HAD A RECALL IN PLACE. I HAD IT TOWED TO THE NEAREST FORD DEALERSHIP WHO STATED THAT IT WOULD BE COVERED UNDER THE RECALL. INSTEAD, THEY PUT A CROSS-BAR ON THE CRACKED SUB FRAME BECAUSE THEY DETERMINED IT WAS "NOT BROKEN" ONLY "CRACKED". THE SUB FRAME HAD "RUSTED AND CORRODED" DUE TO FORD'S OWN ADMITTANCE OF "FAULTY PARTS". I ASKED IF THE VEHICLE WAS SAFE AND THEY STATED "NO". I ASKED IF THE VEHICLE WOULD PASS INSPECTION AND AGAIN THEY STATED "NO". I ASKED IF THIS WAS A "BANDAID" THAT THEY PUT ON TO MAKE THEMSELVES FEEL BETTER ABOUT THE FACT THAT ANYONE OPERATING THE VEHICLE COULD LOSE TOTAL CONTROL. I ASKED TO SPEAK TO A MANAGER, WHO TOLD ME THERE WAS NOTHING HE COULD DO. HE DID STATE HE WOULD MAKES SOME CALLS AND CALLED ME A DAY OR TWO LATER TO SAY, THAT HIS MANAGER SAID IF I WANTED THE VEHICLE FIXED, I COULD PAY $1,200 FOR THE PART AND AN ADDITIONAL $600-$800 IN LABOR TO FIX THE VEHICLE, OR I COULD TRADE IT IN. I AM BEYOND FRUSTRATED THAT FORD WILL NOT BACK UP THEIR PRODUCT. THE VEHICLE HAS LESS THAN 65,000 MILES ON IT!
Structure, Aug 2, 2016
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACTWAS INFORMED THAT THE VEHICLE WOULD NOT BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE) DUE TO EXCESSIVE CORROSION ON THE SUBFRAME. THE VEHICLE WAS UNSAFE TO DRIVE. THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Structure, Mar 15, 2016
2003 FORD ESCAPE. CONSUMER WRITES IN REGARDS TO CORROSION OF THE SUBFRAME LOWER CONTROL ARM RECALL NOTICE REPAIRS AND SEEKS REIMBURSEMENT. *SMD THE CONSUMER STATED SIX MONTHS AFTER THE RECALL WAS PERFORMED, HIS WIFE HEARD A TERRIBLE NOISE AND THE VEHICLE BECAME IMPOSSIBLE TO STEER. THE CONSUMER ARRIVED TO WHERE HIS WIFE WAS AND DID AN INSPECTION, AND DISCOVERED THE FRAME ON THE PASSENGER SIDE WAS COMPLETELY RUSTED THROUGH AND BROKEN IN HALF. THE NEXT DAY, A MECHANIC INSPECTED THE VEHICLE AND FOUND THE FRONT CROSS MEMBER WAS RUSTED OUT AND BROKEN ON THE PASSENGER SIDE AND THE VEHICLE WAS UNSAFE TO DRIVE. THE CONSUMER WAS INFORMED HE WAS NOT ENTITLED TO REIMBURSEMENT, BECAUSE THE LOWER CONTROL ARM SEPARATED FROM THE SUBFRAME AFTER THE RECALL WAS PERFORMED. *JB
Structure, Other or unspecified, Feb 16, 2016
THE ASH GOLD PAINT IS BUBBLING ALL OVER THE OUTSIDE ROOF REAR DOOR SIDES (ALL OVER) THE CAR TO INCLUDE THE INTERIOR. THE ROOF HAS RUSTED AND FORD WON'T DO ANYTHING. I WENT TO TWO FORD DEALERS IN SAN DIEGO AND CALLED FORD DIRECT. THE PASSED ME OVER TO THE HIGHWAY SAFETY ADMIN HOTLINE THAT TOLD ME TO CALL FORD, THEY WILL HANDLE THE COMPLAINT. EVERYDAY MORE PAINT PEELS OFF.
Air bags, Structure, Service brakes, Feb 15, 2016
0N APR 22, 2015 WHILE DRIVING FROM SHADY SPRING WV TO PRINCETON WV ON I-77 TO A DRS APPT, MY WIFE AND I NOTICED A POPPING SOUND COMING FROM THE RIGHT FRONT OF THE VEH WHEN VEERING OR TURNING RIGHT. I HAD TO WORK THAT DAY AFTER I RETURNED FROM THE DR AND HAD PLANNED TO TAKE THE VEH TO A MECHANIC AFTER I GOT OFF TO FIND OUT THE PROBLEM. WHILE DRIVING HOME FROM WORK ON PLUTO ROAD IN SHADY SPRING, I ROUNDED A CURVE TO THE RIGHT AT 20 MPH AND SOMETHING BROKE CAUSING THE VEH TO COME TO A SUDDEN STOP. I HAD THE VEH TOWED TO A&R SERVICE CTR IN SHADY SPRING AND WAS NOTIFIED THAT AFTERNOON THAT THE SUB FRAME BROKE/ LOWER CV JOINT HAD CAME LOOSE AND THAT THERE WAS EXCESSIVE RUST AND CORROSION COVERING THE WHOLE UNDERNEATH OF THE VEH. I NOTIFIED KC PREOWNED AUTO WHOM I HAD PURCHASED THE VEH FROM IN SEPT 2014. HE WENT TO THE MECH AND LOOKED AT THE VEHICLE AND CALLED ME AND STATED THE GOOD NEWS IS THERE IS A RECALL ON THE SUB FRAME THAT HAD BROKEN AND COULD BE TAKEN TO MOUNTAINEER AUTO IN BECKLEY WV FOR REPAIR. THE VEH WAS TAKEN ON APR 27 2015, AND AFTER BEING SENT TO A BODY SHOP FOR A RUSTED AND BROKEN BOLT, A NEW SUB FRAME WAS PLACED ON THE FRONT. MY WIFE PICKED IT UP ON JUN 20 2015 AND NOTICED DRIVING HOME A VIBRATION COMING FROM THE FRONT RIGHT AND A GRINDING SOUND COMING FROM THE MIDDLE OF IT. I TOOK IT BACK TO MOUNTAINEER AUTO THE NEXT DAY AND WAS TOLD BY THE SVC REP (J T) THAT FORD WAS NOT GOING TO PUT ANYMORE MONEY IN TO THIS VEH AND THERE WAS NOTHING THEY WOULD DO. I NOTIFIED THE WV ATTY GENERAL FOR HELP AND AFTER TRYING TO RECTIFY THE ISSUE RECEIVED A LETTER THAT NOTHING COULD BE DONE. THE VEH SAT IN MY DRIVEWAY UNTIL FEB 3, 2016, WHEN I SAVED UP MONEY TO FIX IT MYSELF. I TOOK IT BACK TO MOUNTAINEER AUTO AND WAS TOLD THE CARRIAGE BEARING WAS BROKE, AND NOTHING COULD BE DONE DUE TO EXCESSIVE RUST AND CORROSION. TOOK IT TO 2 BROTHERS AND RECEIVED THE ATTACHED STATEMENT.
Suspension, Structure, Wheels, Feb 9, 2016
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE HAD A RECALL ON THE FRAME AND WAS REPAIRED. WHILE DRIVING 20 MPH, THE VEHICLE SHOOK AND THE STEERING WHEEL WOBBLED. THE FRONT DRIVER SIDE WHEEL WAS STRAIGHT WHILE THE FRONT PASSENGER SIDE WHEEL FACED OUTWARD. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SUBFRAME WAS COMPLETELY FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 145,000.
Suspension, Structure, Feb 5, 2016
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 10 MPH, A LOUD THUMPING SOUND CAME FROM THE FRONT OF THE VEHICLE AND THE STEERING MALFUNCTIONED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SUBFRAME SEPERATED DUE TO SEVERE RUST AND CORROSION, WHICH CAUSED THE LOWER CONTROL ARM TO FRACTURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 167,000.
Structure, Feb 3, 2016
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING APPROXIMATLY 25 MPH, THE VEHICLE APPRUPTLY STOPPED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DISCOVERED THAT THE FRAME FRACTURED NEAR THE FRONT PASSENGER SIDE WHEEL WELL. THE VEHICLE WAS REPAIRED BY THE MANUFACTURER BUT, WHILE DRIVING, THE VEHICLE EXPERIENCED SEVERE SHAKING AND VIBRATIONS. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIED OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE UNKNOWN.
Suspension, Structure, Dec 29, 2015
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 40 MPH, A THUMPING NOISE WAS HEARD FROM THE PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SUBFRAME WAS SEVERELY RUSTED AND FRACTURED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO STATED THAT A BRACE WAS PLACED ON BY THE DEALER IN THE SUBFRAME AS PART OF A RECALL IN 2014. THE APPROXIMATE FAILURE MILEAGE WAS 121,000.
Steering, Structure, Dec 7, 2015
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING AT A HIGH SPEED, THE VEHICLE VEERED TO THE RIGHT AND FAILED TO REMAIN IN POSITION. THE CONTACT HAD TO STEER THE VEHICLE IN EXCESS IN ORDER TO KEEP THE VEHICLE IN POSITION. THE VEHICLE WAS TAKEN TO A DEALER WHO REPAIRED THE VEHICLE UNDER NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE); HOWEVER, THE LOCAL DEALER STATED THAT THERE WAS CORROSION AROUND THE ATTACHMENT AREA AND THE SUBFRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 109,000.
Suspension, Structure, Dec 3, 2015
MY FORD ESCAPE HAD RECALL 14S02 COMPLETED, WHICH WAS SUPPOSED TO "FIX" THE RUSTING OUT SUB-FRAMES MADE OF INFERIOR METAL DUE TO SALT-BELT STATES SALTING OF ROADS, BY INSTALLING A FLIMSY BRACE ACROSS THE SUB-FRAME, BUT I'M HONESTLY NOT SURE WHAT IT DOES BESIDES PREVENT YOUR CAR FROM "COMPLETELY" LOSING CONTROL. FORD REFUSES TO TRULY FIX THE PROBLEM AND IT POSSES A SERIOUS RISK TO ME, MY FAMILY, AND OTHERS ON THE ROAD. IF THE SUB-FRAME DOES DETACH ON MY CAR, WHICH IT IS ONE NASTY POT-HOLE AWAY FROM DETACHING, THAN I WILL LOSE CONTROL OF MY CAR WHEN THE CONTROL ARM BREAKS OFF THE SUB-FRAME AND I WILL BE IN A POTENTIALLY LIFE THREATENING SITUATION. MY LOCAL INDEPENDENT MECHANIC WARNED ME OF THE DANGER OF THIS PROBLEM JUST RECENTLY WHILE IT WAS STATIONARY, BUT FORD DID NOT. FORD SIMPLY BRUSHED ME OFF AND DIDN'T EXPLAIN TO ME HOW DANGEROUS THIS SUPPOSED "FIX" IS. I AM STUDENT, AND IN ORDER FOR ME TO FIX THIS ON MY OWN THE COST WILL BE UNBEARABLE. I DO NOT THINK THIS IS FAIR OR FOLLOWING FEDERAL LAW, AND I DON'T KNOW HOW THIS PATHETIC BRACE HELD ON BY A COUPLE OF BOLTS WAS CONSIDERED A REAL FIX FOR A VERY DANGEROUS PROBLEM. THE MANNER IN WHICH FORD HAS HANDLED THIS SITUATION HAS BEEN DEPLORABLE AS WELL, AND I HAVE RECEIVED NOTHING BUT RUDENESS FROM THEIR SERVICE DEPARTMENT, AND CUSTOMER SERVICE REPRESENTATIVES. THE DANGER OF THIS PARTICULAR PROBLEM IS THAT WHEN THE CAR IS IN MOTION AND IT DOES DETACH, ESPECIALLY ON A HIGHWAY, THEN I, AND OTHERS WILL BE AT A RISK DUE TO LOSS OF CONTROL OF STEERING.
Suspension, Structure, Nov 23, 2015
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING AT VARIOUS SPEEDS, THERE WERE ABNORMAL NOISES COMING FROM THE FRONT OF THE VEHICLE. IN ADDITION, BOTH FRONT TIRES LEANED INWARDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FRONT CONTROL ARM, SWAY BAR, AND TIE RODS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE MECHANIC ALSO STATED THAT THE SUBFRAME CORRODED AND NEEDED TO BE REPLACED. A WEEK LATER, WHILE REVERSING AT A LOW SPEED, THE CONTACT HEARD A LOUD NOISE COMING FROM THE FRONT OF THE VEHICLE. UPON INSPECTION, THE CONTACT NOTICED THAT THE CONTROL ARM AND AXLE FRACTURED. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,470.
Structure, Nov 1, 2015
LAST YEAR I RETURNED MY VEHICLE TO THE DEALER FOR THE SUB FRAME RECALL. I HAD THE NEW SUPPORT INSTALLED. THIS YEAR WHEN I WENT FOR MY ANNUAL VEHICLE INSPECTION I WAS TOLD TO STOP DRIVING THE VEHICLE AS MY SUBFRAME WAS SO BADLY RUSTED THAT IT COULD BREAK AT ANY TIME. WHY WAS THE SUBFRAME REPLACEMENT NOT INCLUDED IN THE RECALL?
Steering, Suspension, Structure, Oct 19, 2015
STEERING LOSE WITH LITTLE CONTROL. MECHANIC STATES A SEPARATION OF THE LOWER CONTROL ARM DUE TO EXCESSIVE CORROSION IN FRAME. MATCHES FORD RECALL 14S02. YET RECALL WAS PERFORMED JUNE 2014. SO SAFETY RECALL FAILED.
Suspension, Structure, Fuel/propulsion system, Sep 30, 2015
WENT TO GET CAR INSPECTED AND THE EXHAUST Y PIPE AND ENGINE CRADLE SUBFRAME HAS CORRISON. CALLED THE FORD RECALL AND FOR SOME REASON MY VEHICLE DID NOT HAVE A RECALL, BUT THERE WERE OTHER 2003 RECALLS FOR THE CONTROL ARMS AND CORRISON OF THE FRAME AND MEMBERS. THIS SEEMS TO BE A PROBLEM WITH A LOT OF FORD VEHICLES BUT NOT ON THE RECALL LIST AND SHOULD BE. VEHICLE HAS 100,078 MILES. THERE IS ALSO NOISE COME FROM AN AREA AROUND THE TIRES NOT SURE WHICH ONE.
Structure, Jul 17, 2015
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING OVER A BUMP IN THE ROAD AT APPROXIMATELY 10 MPH, THE FRONT PASSENGER SIDE WHEEL WELL FRACTURED AND DAMAGED THE SUSPENSION. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SUBFRAME WAS RUSTED. THE FAILURE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 145,000.
Structure, Jun 15, 2015
2003 FORD ESCAPE. CONSUMER WRITES IN REGARDS TO EXCESSIVE RUST ON VEHICLE SUB-FRAME RECALL NOTICE. *SMD THE CONSUMER STATED THE ARM CROSS BAR WAS REPLACED. HOWEVER, THE SUBFRAME WAS NOT COVERED. THE CONSUMER HAS BEEN UNSUCCESSFUL AT GETTING THE SUB FRAME REPLACED, BECAUSE NO WAS WILLING TO SELL THE PART. THE PART WAS BEING USED FOR CERTAIN VIN'S. THE CONSUMER REFERENCED RECALL # 14V165000. *JB