2003 Ford Escape
Problems, recalls and owner-reported issues
Structure is the leading concern among 598 owner complaints filed for this model year. This is the 17th highest complaint count among 26 Escape model years with reports.
Of the 2003 reports, 44 involved a crash and 29 involved a fire. 32 people were injured.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Structure, frame and membersApr 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14S02.
Campaign 14V165000 on NHTSA.gov
Engine and engine coolingJul 26, 2012
Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used.
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. Owners may contact Ford at 1-866-436-7332.
Campaign 12V353000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 10, 2007
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED.
DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 07V156000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Vehicle speed control, cablesDec 7, 2004
ON CERTAIN SPORT UTILITY VEHICLES BUILT WITH 3.0L V6 ENGINES, THE ACCELERATOR CABLE MAY PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.
AN UNEXPECTED INCREASE IN ENGINE IDLE SPEED MAY INCREASE STOPPING DISTANCE AND MAY RESULT IN A VEHICLE CRASH.
DEALERS WILL REPLACE THE ACCELERATOR CABLE. THE RECALL BEGAN ON JANUARY 10, 2005. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 04V574000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Apr 6, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.0L V6 ENGINES, DURING DECELERATION, THE ENGINE CAN STALL.
SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
DEALERS WILL REPROGRAM THE POWER CONTROL MODULE (PCM) WITH THE APPROPRIATE CALIBRATION. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V165000 on NHTSA.gov
Representative owner complaints: suspension
92 reports, newest first. Show all
Suspension, Structure, Dec 1, 2016
MY 17-YEAR-OLD SON WAS DRIVING THE CAR HOME FROM WORK AND AFTER MAKING A RIGHT TURN THE CAR SEVERELY JERKS TO THE RIGHT. HE ALMOST WENT OFF OF THE ROAD. WE TOOK THE CAR TO OUR LOCAL MECHANIC AND WERE TOLD THAT THERE WAS CORROSION AND SEPARATION OF THE CONTROL ARM AND WE WOULD NEED A BRACE TO COMPLETE THE REPAIR. THE MECHANIC SAID WHEN HE TOOK THE CAR FOR A TEST DRIVE THE STEERING WHEEL IS OUT OF ALIGNMENT AND HE ALMOST HIT A MAILBOX WHEN THE CAR JERKED TO THE RIGHT. WHEN INVESTIGATING HOW TO GET A USED PART I DISCOVERED THAT THERE IS A RECALL FOR THIS EXACT ISSUE (FORD RECALL #14S02). MY CAR FITS THE SAME MODEL YEAR AND PURCHASE/REGISTRATION LOCATIONS AS INDICATED IN THE RECALL, BUT FORD REFUSES TO MAKE THE REPAIR UNDER THE RECALL. CURRENTLY WE ARE COMPLETELY UNABLE TO DRIVE THE VEHICLE BECAUSE IT IS UNSAFE FOR MY SON AND OTHER DRIVERS ON THE ROAD FOR THE CAR TO BE DRIVEN. HAD MY SON BEEN DRIVING FASTER WHEN THIS HAPPENED THERE COULD HAVE BEEN A TERRIBLE ACCIDENT. *TR
Suspension, Structure, Nov 18, 2016
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. UPON EXITING A PARKING AREA, THERE WAS AN ABNORMAL SUSPENSION VIBRATION NEAR THE FRONT OF THE VEHICLE. THE FRONT SUBFRAME FRACTURED AND IMPACTED THE FRONT PASSENGER SIDE TIRE. THE CONTACT AND A MECHANIC INSPECTED THE FACT THAT THERE HAD BEEN PREMATURE RUST AND CORROSION ASSOCIATED WITH THE UNDERBODY, SUBFRAME, AND THE BAR THAT WAS CONNECTED TO THE FRAME. THE VEHICLE WAS UNABLE TO BE DRIVEN AND WAS TOWED BY THE MECHANIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO SOLUTION OTHER THAN FOR THE CONTACT TO TAKE THE VEHICLE TO THE DEALER. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V165000 (STRUCTURE) AND 15E045000 (SUSPENSION). THE FAILURE MILEAGE WAS NOT AVAILABLE.
Steering, Suspension, Wheels, Nov 2, 2016, crash
THE FRONT PASSENGER SIDE LOWER CONTROL ARM FAILED WHILE MY SON WAS DRIVING THE VEHICLE. HE WAS GOING STRAIGHT, AND THE RIGHT FRONT SIDE JUST BUCKLED UNDER WHILE HE WAS IN MOTION. LUCKILY HE WASN'T ON A HEAVILY-TRAVELED ROAD WHEN IT HAPPENED, BECAUSE THERE WOULD HAVE BEEN A SERIOUS ACCIDENT. THE VEHICLE, ALTHOUGH IT IS A 2003 FORD ESCAPE, IS NOT PART OF RECALL #14S02. WHY, I DON'T KNOW? NO ONE AT FORD CAN EXPLAIN THIS TO ME, AS IT IS EXACTLY WHAT HAS BEEN HAPPENING WITH THIS MAKE AND MODEL/YEAR. WE HAD IT REPAIRED AT GREAT COST TO US, WITH EXACTLY THE PARTS/LABOR THAT FORD HAD BEEN DESCRIBING IN THE RECALL. OUR MECHANIC EVEN GOT THE REPLACEMENT CROSSMEMBER FROM FORD! FORD THEMSELVES WANTED NOTHING TO DO WITH THE REPAIR. IN ADDITION TO THE LOWER CONTROL ARM, AND CROSSMEMBER, THE TIRE HAD TO BE REPLACED, ALONG WITH THE RIGHT FRONT AXLE ASSEMBLY, AS THEY WERE SEVERELY DAMAGED FROM THE FRAME FAILURE. I WOULD REALLY LIKE AN ANSWER AS TO WHY MY VEHICLE IS NOT INCLUDED IN THE RECALL, WHEN THE RECALL DESCRIBES EXACTLY WHAT HAS HAPPENED TO MY VEHICLE. *TR
Suspension, Wheels, Sep 26, 2016
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 33 MPH AND ATTEMPTING TO TURN, THE FRONT PASSENGER SIDE WHEEL FAILED AND THE VEHICLE BECAME DIFFICULT TO CONTROL. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT WAS ABLE TO PULL THE VEHICLE OVER TO THE SHOULDER AND DISCOVERED THAT THE FRONT PASSENGER WHEEL WAS RUSTED AND TWISTED OUTWARD. THE FAILURE CAUSED THE REAR CONTROL ARM TO ALMOST FALL OFF. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.
Suspension, Aug 20, 2016
WHILE DRIVING ON HIGHWAY THE STEERING STARTED TO BECOME UNSTABLE AND LOOSE. MOMENTS LATER THE LOWER CONTROL ARM (SUB-FRAME) ON PASSENGER SIDE SEPARATED CAUSING LOSS OF CONTROL ALMOST ENDING IN CRASH. NEVER RECEIVED NOTICE OF THE RECALL BELOW TO FIX THIS PROBLEM WHICH WAS ISSUED ABOUT TWO YEARS AGO. DEALERSHIP CONTACTED. THEY ARE DRAGGING THEIR FEET ON AN ANSWER AS TO WHETHER THEY'LL FIX. RECALL # 14S02 2001-'04 FORD ESCAPE RECALLED FOR RUST, STEERING PROBLEM FORD IS RECALLING 385,762 2001-'04 FORD ESCAPE SUVS BECAUSE A RUST PROBLEM MAY CAUSE THE LOWER CONTROL ARM TO SEPARATE, POTENTIALLY RESULTING IN DIMINISHED STEERING CONTROL. | APRIL 8, 2014 | FORD MOTOR COMPANY RECALL TITLE: FRONT SUBFRAME CROSSBRACE INSTALLATION NHTSA RECALL NUMBER: 14V165000 FORD RECALL NUMBER: 14S02
Steering, Suspension, Structure, Aug 12, 2016
WHILE DRIVING, THE FRONT RIGHT TIRE FELT LIKE IT WAS GOING TO FALL OFF THE VEHICLE. I TOOK IT TO MY MECHANIC WHO STATED THAT THE SUB-FRAME WAS CRACKED AND FORD HAD A RECALL IN PLACE. I HAD IT TOWED TO THE NEAREST FORD DEALERSHIP WHO STATED THAT IT WOULD BE COVERED UNDER THE RECALL. INSTEAD, THEY PUT A CROSS-BAR ON THE CRACKED SUB FRAME BECAUSE THEY DETERMINED IT WAS "NOT BROKEN" ONLY "CRACKED". THE SUB FRAME HAD "RUSTED AND CORRODED" DUE TO FORD'S OWN ADMITTANCE OF "FAULTY PARTS". I ASKED IF THE VEHICLE WAS SAFE AND THEY STATED "NO". I ASKED IF THE VEHICLE WOULD PASS INSPECTION AND AGAIN THEY STATED "NO". I ASKED IF THIS WAS A "BANDAID" THAT THEY PUT ON TO MAKE THEMSELVES FEEL BETTER ABOUT THE FACT THAT ANYONE OPERATING THE VEHICLE COULD LOSE TOTAL CONTROL. I ASKED TO SPEAK TO A MANAGER, WHO TOLD ME THERE WAS NOTHING HE COULD DO. HE DID STATE HE WOULD MAKES SOME CALLS AND CALLED ME A DAY OR TWO LATER TO SAY, THAT HIS MANAGER SAID IF I WANTED THE VEHICLE FIXED, I COULD PAY $1,200 FOR THE PART AND AN ADDITIONAL $600-$800 IN LABOR TO FIX THE VEHICLE, OR I COULD TRADE IT IN. I AM BEYOND FRUSTRATED THAT FORD WILL NOT BACK UP THEIR PRODUCT. THE VEHICLE HAS LESS THAN 65,000 MILES ON IT!
Suspension, Jun 20, 2016
IN MAY OF 2016, I TOOK MY FORD ESCAPE IN FOR REPAIR OF A RECALL. MY UNDERSTANDING OF THE RECALL WAS TO PREVENT A FAILURE OF THE LOWER CONTROL ARM AS I READ THE RECALL NOTICE AND THE CONVERSATION THAT I HAD WITH REPAIR CENTER AGENT. A MONTH LATER THE LOWER CONTROL ARM SEPARATES. AFTER I HAD MY VEHICLE TOWED TO FORD, IT WAS EXPRESSED TO ME THAT RECALL WAS NOT TO PREVENT FAILURE BUT MERELY TO STABILIZE THE VEHICLE IN THE EVENT OF FAILURE. HAD I NOT HAD THE RECALL PERFORMED ON MY VEHICLE THEY WOULD HAVE REPAIRED THE ESCAPE AT COST TO THEM, BUT BECAUSE I HAD THE RECALL PERFORMED THEN I MOST PAY FOR IT. WHY WOULD FORD AUTHORIZE SUCH A RIDICULOUS RECALL EFFORT. FIRST OF ALL IF IT'S KNOW ISSUE, WHY NOT REPAIR THE ISSUE. SECONDLY, HAD I KNOW THE RAMIFICATIONS, I WOULD NEVER HAVE HAD THE RECALLED PERFORMED. THE CONTROL SEPARATED WHILE DRIVING AND I HIT A BUMP.
Suspension, May 2, 2016
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE THE VEHICLE WAS BEING SERVICED FOR ROUTINE TIRE MAINTENANCE, THE CONTACT WAS INFORMED THAT THERE WAS SEVERE CORROSION TO THE REAR AXLES OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000. UPDATED 07/12/16*LJ
Suspension, Structure, Wheels, Feb 9, 2016
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE HAD A RECALL ON THE FRAME AND WAS REPAIRED. WHILE DRIVING 20 MPH, THE VEHICLE SHOOK AND THE STEERING WHEEL WOBBLED. THE FRONT DRIVER SIDE WHEEL WAS STRAIGHT WHILE THE FRONT PASSENGER SIDE WHEEL FACED OUTWARD. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SUBFRAME WAS COMPLETELY FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 145,000.
Suspension, Structure, Feb 5, 2016
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 10 MPH, A LOUD THUMPING SOUND CAME FROM THE FRONT OF THE VEHICLE AND THE STEERING MALFUNCTIONED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SUBFRAME SEPERATED DUE TO SEVERE RUST AND CORROSION, WHICH CAUSED THE LOWER CONTROL ARM TO FRACTURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 167,000.
Steering, Suspension, Jan 15, 2016
I WAS DRIVING HOME FROM WORK ON A HIGHWAY(60MPH) WHEN MY STEERING BECAME LOOSE, WEAVING LEFT AND RIGHT. HAD TO SLOW DOWN TO 20MPH UNTIL I GOT HOME. THE VEHICLE WAS INSPECTED, FOUND THAT THE PASSENGER SIDE SUBFRAME HAD BROKEN IN 2. FORD IS RECALLING 385,762 2001-'04 FORD ESCAPE SUVS BECAUSE A RUST PROBLEM MAY CAUSE THE LOWER CONTROL ARM TO SEPARATE, POTENTIALLY RESULTING IN DIMINISHED STEERING CONTROL. FORD DEALERS WILL INSTALL A REINFORCEMENT CROSSBRACE ON THE AFFECTED ESCAPES. THE SUBFRAME HAS BROKEN APART DUE TO THE CORROSION, AND IT'S UNSAFE TO DRIVE. SINCE FORD IS AWARE OF THIS, THEY SHOULD HAVE BOTH SUBFRAME REPLACE AS A RECALL AND NOT ADDING A CROSSBAR AS A RECALL. CURRENTLY THE VEHICLE IS PARKED ON MY DRIVEWAY. THE ESTIMATED COST TO REPAIR WAS TOO COSTLY.
Suspension, Structure, Dec 29, 2015
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 40 MPH, A THUMPING NOISE WAS HEARD FROM THE PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SUBFRAME WAS SEVERELY RUSTED AND FRACTURED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO STATED THAT A BRACE WAS PLACED ON BY THE DEALER IN THE SUBFRAME AS PART OF A RECALL IN 2014. THE APPROXIMATE FAILURE MILEAGE WAS 121,000.
Suspension, Structure, Dec 3, 2015
MY FORD ESCAPE HAD RECALL 14S02 COMPLETED, WHICH WAS SUPPOSED TO "FIX" THE RUSTING OUT SUB-FRAMES MADE OF INFERIOR METAL DUE TO SALT-BELT STATES SALTING OF ROADS, BY INSTALLING A FLIMSY BRACE ACROSS THE SUB-FRAME, BUT I'M HONESTLY NOT SURE WHAT IT DOES BESIDES PREVENT YOUR CAR FROM "COMPLETELY" LOSING CONTROL. FORD REFUSES TO TRULY FIX THE PROBLEM AND IT POSSES A SERIOUS RISK TO ME, MY FAMILY, AND OTHERS ON THE ROAD. IF THE SUB-FRAME DOES DETACH ON MY CAR, WHICH IT IS ONE NASTY POT-HOLE AWAY FROM DETACHING, THAN I WILL LOSE CONTROL OF MY CAR WHEN THE CONTROL ARM BREAKS OFF THE SUB-FRAME AND I WILL BE IN A POTENTIALLY LIFE THREATENING SITUATION. MY LOCAL INDEPENDENT MECHANIC WARNED ME OF THE DANGER OF THIS PROBLEM JUST RECENTLY WHILE IT WAS STATIONARY, BUT FORD DID NOT. FORD SIMPLY BRUSHED ME OFF AND DIDN'T EXPLAIN TO ME HOW DANGEROUS THIS SUPPOSED "FIX" IS. I AM STUDENT, AND IN ORDER FOR ME TO FIX THIS ON MY OWN THE COST WILL BE UNBEARABLE. I DO NOT THINK THIS IS FAIR OR FOLLOWING FEDERAL LAW, AND I DON'T KNOW HOW THIS PATHETIC BRACE HELD ON BY A COUPLE OF BOLTS WAS CONSIDERED A REAL FIX FOR A VERY DANGEROUS PROBLEM. THE MANNER IN WHICH FORD HAS HANDLED THIS SITUATION HAS BEEN DEPLORABLE AS WELL, AND I HAVE RECEIVED NOTHING BUT RUDENESS FROM THEIR SERVICE DEPARTMENT, AND CUSTOMER SERVICE REPRESENTATIVES. THE DANGER OF THIS PARTICULAR PROBLEM IS THAT WHEN THE CAR IS IN MOTION AND IT DOES DETACH, ESPECIALLY ON A HIGHWAY, THEN I, AND OTHERS WILL BE AT A RISK DUE TO LOSS OF CONTROL OF STEERING.
Suspension, Structure, Nov 23, 2015
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. WHILE DRIVING AT VARIOUS SPEEDS, THERE WERE ABNORMAL NOISES COMING FROM THE FRONT OF THE VEHICLE. IN ADDITION, BOTH FRONT TIRES LEANED INWARDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FRONT CONTROL ARM, SWAY BAR, AND TIE RODS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE MECHANIC ALSO STATED THAT THE SUBFRAME CORRODED AND NEEDED TO BE REPLACED. A WEEK LATER, WHILE REVERSING AT A LOW SPEED, THE CONTACT HEARD A LOUD NOISE COMING FROM THE FRONT OF THE VEHICLE. UPON INSPECTION, THE CONTACT NOTICED THAT THE CONTROL ARM AND AXLE FRACTURED. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,470.
Steering, Suspension, Nov 15, 2015
MY WIFE OWNS A 2003 FORD ESCAPE. WHILE DRIVING IT DOWN THE ROAD SHE NOTICED THE STEERING WAS GETTING UNCONTROLLABLE. SHE PULLED THE CAR OFF THE ROAD AND CALLED AAA FOR A TOW. THE CAR WAS TOWED TO MIDAS WHERE WE USUALLY HAVE OUR WORK DONE ON OUR VEHICLES. MIDAS LOOKED AT THE CAR WHILE STILL ON THE TOW TRUCK. THEY SAID THAT IT SHOULD BE COVERED BY THE RECALL ON THE CAR. MIDAS CALLED WAIKEM FORD AND WAS TOLD TO TELL US TO BRING IT THERE. WE HAD THE TOW TRUCK DRIVER TAKE IT THERE. THIS WAS ON 11/05/15. I WAS CALLED ON 11/6 AND TOLD THEY WOULD NOT BE ABLE TO LOOK AT THE CAR THAT DAY AND MONDAY 11/9 THEY WOULD LOOK AT IT. THIS WAS IN A MESSAGE TO MY PHONE. MONDAY I RECEIVED ANOTHER MESSAGE FROM A GUY NAMED CRAIG THAT HE HAD TAKEN PICTURES OF THE PROBLEM AND SENT IT TO FORD MOTOR COMPANY. THAT WAS ALL THE MESSAGE SAID. TUESDAY I RECEIVED A MESSAGE FROM CRAIG THAT THE CAR WAS DONE AND WE COULD PICK IT UP ANYTIME. I TOOK MY WIFE OVER TO GET THE CAR AND SHE DROVE IT HOME WHICH IS THREE BLOCKS AWAY. SHE DIDN'T NOTICE ANYTHING WRONG DO TO THE SHORT TRIP AND SLOW SPEED. SATURDAY 11/14 SHE TOOK THE CAR OUT AND ONCE AGAIN THE STEERING FELT UNCONTROLLABLE. I WENT OVER TO WAIKEM FORD AND ASK WHY THE CAR WASN'T FIXED. I WAS TOLD THAT FORD MOTOR COMPANY HAD DENIED THE FIX ON THE CAR. CROSS BRACE WAS INSTALLED WHICH IS WHAT THEY DO ON THE RECALL. HOW EVER THE FRAME RUSTED OUT WHERE THE CONTROL ARMS ATTACH AND THE CROSS BRACE DID NOTHING. THE CAR WAS RELEASED TO US WITHOUT BEING TOLD THAT THE PROBLEM WASN'T FIXED. WE WERE NOT TOLD FORD MOTOR COMPANY HAD REJECTED THE REQUEST FOR REPAIR. THIS IS A KNOWN DEFECT IN THE CAR, AND FORD SHOULD HAVE AUTHORIZED THE FIX. FORD MOTOR COMPANIES DECISION ALONG WITH WAIKEM FORD RELEASING THAT CAR TO US PUT MY WIFE AND THE PUBLIC IN DANGER.
Suspension, Power train, Nov 8, 2015
I OWN A 03 FORD ESCAPE AND WHEN DRIVING AT ABOUT 30MPH MY TIRE STARTED RUBBING THE FENDERWELL AND PULLING HARD TO THE RIGHT I HAD TO FIGHT TO KEEP MY CAR FROM HITTING THINGS AND ABOUT 5 SECONDS AFTER ALL OF A SUDDEN THERE IS A VERY LOUD CLUNK SOUND FROM MY PASSENGER FRONT TIRE. AND MY FRONT END DROPPED AND WHEEL LOCKED UP. CAUSING ME TO LOSE CONTROL OF MY VEHICLE. NEARLY MISSING PARKED CARS. I WAS TOLD MY LOWER CONTROL ARM SEPARATED FROM SUBFRAME. WHICH HAS A CORROSION ISSUE (THIS IS A KNOW PROBLEM WITH THIS MODEL, RECALL REFERENCE NUMBER --- 14S02) .. I WAS ADVISED BY A PRIVATE MECHANIC THAT MY SUBFRAME NEEDED REPLACED. I GOOGLED AND FOUND OUT ABOUT THIS RECALL AND HAD IT TAKEN TO MY LOCAL FORD DEALERSHIP AND SO FAR HAVE HEARD NOTHING.. THIS IS RIDICULOUS. AND BECAUSE OF THIS SAFETY RECALL, IT DAMAGED MY CAR EVEN FURTHER, BROKE MY C/V JOINT. PROBABLY MESSED UP THE AXEL TO
Suspension, Nov 4, 2015
THE RIGHT FRONT SUB-FRAME IS DANGEROUSLY RUSTED THROUGH, AND MY MECHANIC SAYS IT'S NOT SAFE TO DRIVE AS IT MAY COLLAPSE AN ANY MOMENT. I TOOK IT TO THE FORD DEALERSHIP IN NORTH CANTON, OHIO THIS SUMMER (APPROXIMATELY JUNE OR JULY) AND THEY SAID THE VIN NUMBER WASN'T ON THE RECALL LIST, SO THEY REFUSED TO FIX IT. THE SITUATION IS SUCH THAT I HAVE A VEHICLE THAT IS UNSAFE TO DRIVE, AND FORD MOTOR CO. WILL NOT FIX IT. AS OF NOW, I AM AFRAID TO USE THIS VEHICLE. THE QUESTION IS: WHY HAS FORD RECALLED AND REPAIRED MOST OF THESE RUSTED SUB-FRAME PROBLEMS, BUT NOT MINE?
Steering, Suspension, Structure, Oct 19, 2015
STEERING LOSE WITH LITTLE CONTROL. MECHANIC STATES A SEPARATION OF THE LOWER CONTROL ARM DUE TO EXCESSIVE CORROSION IN FRAME. MATCHES FORD RECALL 14S02. YET RECALL WAS PERFORMED JUNE 2014. SO SAFETY RECALL FAILED.
Suspension, Oct 18, 2015
I WAS DRIVING ALONG A HIGHWAY GETTING READY TO TURN WHEN THE FRAME BROKE AND I WAS BARELY ABLE TO GET OFF THE ROAD WHEN IT STOPPED BECAUSE I FOUND OUT LATER THE FRAME THAT KEPT THE C V JOINT IN PLACE CAME APART AND MY TIRE TWISTED INTO THE WHEEL WELL. THE RECALL THAT WAS TO KEEP THIS FROM HAPPENING HAD BEEN PERFORMED BUT THE REPAIR DID NOT KEEP THIS FROM HAPPENING TO MY VEHICLE.
Suspension, Structure, Fuel/propulsion system, Sep 30, 2015
WENT TO GET CAR INSPECTED AND THE EXHAUST Y PIPE AND ENGINE CRADLE SUBFRAME HAS CORRISON. CALLED THE FORD RECALL AND FOR SOME REASON MY VEHICLE DID NOT HAVE A RECALL, BUT THERE WERE OTHER 2003 RECALLS FOR THE CONTROL ARMS AND CORRISON OF THE FRAME AND MEMBERS. THIS SEEMS TO BE A PROBLEM WITH A LOT OF FORD VEHICLES BUT NOT ON THE RECALL LIST AND SHOULD BE. VEHICLE HAS 100,078 MILES. THERE IS ALSO NOISE COME FROM AN AREA AROUND THE TIRES NOT SURE WHICH ONE.
Suspension, Sep 26, 2015
I WAS PULLING OUT OF MY DRIVEWAY AND STARTED TO HEAR A LOUD CLUNKING NOISE. I PULLED THE CAR BACK IN AND IT HAS SAT THE PAST FEW DAYS. I TOOK IT TO MY MECHANIC AND WAS TOLD THAT THE WHOLE FRONT END AND FRAME ARE RUSTED AND NEEDS TO BE REPLACED. I RESEARCHED ONLINE AND AM NOW AWARE OF ALL THE ISSUES THAT INVOLVE RUST ON THESE MODELS. I AM SCARED TO EVEN DRIVE THE CAR IN THE SHAPE THAT IT IS IN. I WILL CALL THE RECALL HOTLINE BUT ACCORDING TO WHAT I HAVE READ I DON'T EXPECT MUCH HELP FROM FORD. I WILL NEVER PURCHASE ANOTHER FORD AND AM SORRY TO SAY THAT AS CONSUMERS WE SHOULD EXPECT THESE COMPANIES TO STAND BEHIND THEIR CHEAPLY MADE PRODUCTS
Suspension, Structure, Apr 20, 2015
THE LOWER CONTROL ARM ON MY 2003 FORD ESCAPE IS RUSTED THROUGH AND FORD DIDN'T INCLUDE MY VEHICLE IN THE RECALLS. THEY ARE OBVIOUSLY HAVING A WIDER ISSUE WITH THIS CONTROL ARM SINCE RECALL NUMBER 14SO2 HAS AFFECTED MY ESCAPE AS WELL. THEY CLAIM THAT MY LOWER CONTROL ARM WASN'T PART OF THE FACTORIES THAT WAS LISTED SO THEY WON'T INCLUDE ME IN THE RECALL. I HAVE HAD THIS ISSUE FOR A WHILE AND IF I WAS GOING DOWN THE HIGHWAY MY ENTIRE WHEEL COULD HAVE DISCONNECTED AND CAUSE A HORRIBLE CRASH. THEY MUST INCLUDE ALL FORD ESCAPES FROM 2001 THROUGH 2004 AS LISTED IN THIS RECALL SINCE MY ESCAPE IS OBVIOUSLY INCLUDED IN THIS RECALL AND I SHOULD NOT BE CHARGED FOR THE REPAIR OR AT LEAST NOTIFIED OF THE DANGER. THEY SHOULD NOT BE ALLOWED TO PICK AND CHOOSE WHICH CAR THEY DEEMED ACCEPTABLE FOR THE RECALL IF THERE IS OBVIOUSLY A DEFECT WHICH COULD CAUSE HARM TO THE OWNER AND IS DOCUMENTED AS BEING HARMFUL,, *TR
Steering, Suspension, Apr 8, 2015
A RECALL ON OUR FORD ESCAPE WAS PERFORMED LAST AUGUST.THE RECALL WAS FOR RUSTED FRAME/CRADLE AREA THAT HOLDS FRONT SUSPENSION TOGETHER.AT THE TIME OF THE RECALL I INFORMED THE DEALER THAT THE CRADLE WAS WEAK AND VERY RUSTY OVER AND ABOVE ANY OTHER RUST ON CAR.THE DEALER INSTALLED A BRACE BETWEEN THE TWO RAILS OF THE FRAME AND TOLD ME THAT WAS THE EXTENT OF THE RECALL.THE OTHER DAY WHILE DRIVING THE CRADLE GAVE OUT AND THE ENGINE,THE STEERING GEAR DROPPED DOWN A FEW INCHES RENDERING THE CAR UNDRIVEABLE.I WAS ABLE TO MAINTAIN CONTROL AND GET IT TO THE DEALERSHIP. I WAS TOLD THEY ARE ONLY RESPONSIBLE FOR THE BRACE NOT THE WEAK CRADLE. I GUESS MY QUESTION IS HOW CAN THIS RECALL STOP ANYONE FROM A WRECK OR DAMAGE WHEN THE ENTIRE CRADLE IS AFFECTED BY THIS PROBLEM. THIS RECALL HAD TO BE APPROVED BY SOMEONE IM SURE. THIS BRACE WILL NOT STOP A CAR FROM BEING OUT OF CONTROL AT ANY GIVIN TIME AS THE CRADLE ROT WILL AFFECT A LOT MORE THAN JUST THE LOWER CONTROL ARM AREA.I UNDERSTAND ITS AN OLD CAR BUT FORD KNOWS THERE IS A SERIOUS RUST ISSUE WITH THIS PART.IF FORD AND THE NHTSA FEEL THIS BANDAID REPAIR IS GOOD ENOUGH FOR SAFETY OF MY FAMILY THEN I HAVE MY DOUBT ON WHETHER THERE IS ANYONE IN EITHER ORGANIZATION THAT KNOWS ANYTHING ABOUT A CAR OR SAFETY AT ALL. *TR
Suspension, Apr 8, 2015
TL*THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A DEALER TO BE SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE) AND THE DEALER INSTALLED REINFORCEMENT CROSS BAR TO THE UNDER CARRIAGE OF THE VEHICLE. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC, WHO DETERMINED THAT THE CROSS BAR WAS NOT A PERMANENT REPAIR. AS A RESULT, THE FRONT SUB FRAME NEEDED TO BE REPLACED AND THE FRONT PASSENGER SIDE LOWER CONTROL ARM WAS RUSTED THROUGH. THE CONTACT FELT THAT THE RECALL REMEDY WAS NOT AN ADEQUATE REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Steering, Suspension, Structure, Mar 26, 2015
VEHICLE WENT IN FOR CONTROL ARM BRACE RECALL IN 2014 DUE TO POOR METZL USED ON THE SUBFRAME, MARCH OF 2015 IT FAILED LEAVING LIMITED CONTROL OF STEERING, FORD WAS CONTACTED AND STATED THAT THEY ARE ONLY RESPONSIBLE FOR THE CONTROL ARM RECALL AND TO CONTACT THE DEALER. THEY SAID THEY DID WHAT THEY WERE TOLD TO DO AND THE ROTTED SUBFRAME WAS NOT A PART OF THE RECALL. FORD NEEDS TO RECALL THE SUBFRAME PART BEFORE SOMEONE GETS SERIOUSLY INJURED OR KILLED. *TR