2005 Ford Escape
Problems, recalls and owner-reported issues
Suspension is the leading concern among 1,584 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Escape model years with reports.
Of the 2005 reports, 44 involved a crash and 20 involved a fire. 29 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Hybrid propulsion systemSep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Campaign 14V526000 on NHTSA.gov
Seats, front assembly, head restraintApr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 06V111000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Representative owner complaints: electrical system
169 reports, newest first. Show all
Electrical system, Engine, Jan 20, 2017
ENGINE STALLS WHILE DRIVING; ALMOST $4,000 IN REPAIRS HAVE FAILED TO CORRECT THE PROBLEM AND IT KEEPS HAPPENING. THE CAR IS NOT SAFE TO DRIVE. *TR
Electrical system, Structure, Wheels, Sep 29, 2016
TAKATA RECALL PASSENGER BACK TOWER WHEEL RUSTED ON MY 2005 FORD ESCAPE THE METER SENSOR KEEP GOING OFF LIKE THE DOORS ARE STILL OPEN THE RIMS OF THE CAR HAS RUSTED LIKE WE HAD THE CAR FOR 30 YEARS IN MOTION WHEN I NOTICE THE WHEEL TOWER RUSTED OUT
Electrical system, Jul 19, 2016
ENTERING AND ACCELERATING FROM A MAIN STREET THAT TURNS INTO A FREEWAY THE ENGINE LOST ALL POWER VERY SUDDENLY, ABS LIGHT ENGAGED, THEN DIED AS EXITING THE FREEWAY. EXTREMELY DANGEROUS WITH CHILDREN IN CAR AND NO WARNING WHICH WOULD HAVE CAUSED A MECHANIC TO LOOK INTO PREVIOUSLY. EXITING THE FREEWAY THE ENGINE DIED BUT RESTARTED WITH ABILITY TO DRIVE AT 10 MPH (IN A BAD AREA) WITH ENGINE LOSS AND NOISE. AT SHOP, I WAS TOLD THE SPARK PLUGS, COILS AND PCM WOULD NEED TO BE REPLACED IN THAT ORDER ($795), THEN THE COILS ($600), THEN THE PCM ($1400) NOT INCLUDING LABOR. A EX-FORD MASTER TECHNICIAN SAID FORD NEW OF PROBLEM AND REPLACED THOSE COMPONENTS WHEN THE CARS CAME INTO THE SHOP. FORD HAS A SEPARATE SOFTWARE CHECKING PROGRAM ONLY DESIGNED FOR FORD ESCAPES TO TEST THE PCM FOR DAMAGE CAUSED BY FAULTY PLUGS. APPARENTLY A RECALL OCCURRED FOR SOME VINS, WHEN I CONTACTED FORD HEADQUARTERS I WAS TOLD MY VEHICLE WAS NOT MADE AT A PARTICULAR PLANT ERGO MY BURDEN TO PAY OUT OF POCKET. RECALL WAS IN 2014 FOR ESCAPES WITH 80,000 MILES OR LESS WHILE IN WARRANTY. THIS IS A COMMON WELL-DOCUMENTED ELECTRICAL COMPONENT FAILURE WHICH OCCURS AFTER 80,000 MILES.
Electrical system, Vehicle speed control, Electronic stability control (ESC), Engine, Jun 21, 2016
HI I HAVE A 2005 FORD ESCAPE & UP INTO ABOUT AND YEAR I STARTED HAD HAVING ENGINE FAILURE, MY VEHICLE WOULD START & STOP, TO SUM THIS UP, IM AFFAID TO DRIVE WHEN THIS ACCURES PRAYING THAT KNOW 1 RUNS INTO THE BACK OF ME...IVE TOOKEN IT TO THE AUTO PLACE TO GET A READING & IVE REPLACED EVERYTHING THAT IT READ IGNITION COILS (TWICE), FUEL FILTERS, TUNE A/C COMPRESSOR, WOULDNT COME ON ETC....I CAN GO ON & ON..& IM STILL HAVING THE SAME PROBLEMS & FINALLY IVE DECIDED TO GOOGLE THESE ACCURANCES, TO FIND THAT THERE'S OTHER VIC..THAT HAS OCCURRED THESES SAME INCIDENTS....THIS IS A SERIOUS MATTER, THAT FORD NEEDS TO ADDRESS / RESOLVED BEFORE SOMEONE DOESN'T MAKE IT. VIC. JUST SHUTTING DOWN IN THE MIDDLE OF TRAFFIC....& IT ALSO ACCURES WHILE STATIONARY & WHILE TURNING, THIS HAS BEEN GOING ON SINCE OCT. OF 2015 & IN BETWEEN REPLACEING PARTS IT STALLED FOR A WHILE OF THE KILLING & NOW IT HAS STARTED BACK UP FULL FORCE ABOUT A WEEK AGO. 6/13/2016 & TODAY IS THE 6/21/2016
Electrical system, Structure, Vehicle speed control, Apr 15, 2016
REAR WHEEL WELLS RUSTING OUT AS WELL AS REAR SEAT WELLS UNDER DOORS RUSTING OFF IN HUGE CHUNKS,CRUISE,CD PLAYER DOESNT WORK,RADIO SHORTS OUT ON VOLUME CONTROL GOES LOUDER INSTEAD OF LOWER VOLUME,ALSO FRONT AXLE HAD TO BE REPLACED AT JOE LAKE TIRE DO THEY USE TIMKEN PRODUCTS?
Electrical system, Engine, Fuel/propulsion system, Mar 14, 2016
BOUGHT MY 05 XLT ESCAPE LAST MAY 2015 AND ALL OF A SUDDEN IT STARTED TO SHUDDER STALL WHILE IDLING AND JUST COMPLETELY DIE WHEN I WAS DRIVING ON THE HIGHWAY! GOT THE CODES READ AND IT SAID I HAD A MISFIRE ON CYLINDER 2, SO I PUT NEW COILS AND SPARK PLUGS IN IT BUT IT'S STILL NOT WORKING! STILL DOING A MISFIRE AND IT'S RUNNING BAD WHEN IT DECIDES TO CRANK UP! NOW IT'S NOT EVEN DRIVABLE.
Electrical system, Engine, Mar 4, 2016
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. AFTER COMING TO A STOP, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.
Electrical system, Mar 1, 2016
CAR RUNNING ROUGH, CAR SLOWED AND THEN WOULD NOT DRIVE. TOWED, TOLD IT NEEDS NEW PCM, CYLINDERS, COILS, AND SPARK PLUGS. CAR HAS LESS THAN 80,000 MILES. THIS IS A KNOWN PROBLEM WITH THIS CAR AND THE PCM WAS CHANGED IN LATER MODELS. FORD CREATED A DEFECTIVE PRODUCT AND DOES NOT SEEM TO CARE.
Power train, Electrical system, Vehicle speed control, Feb 5, 2016
VEHICLE JERKING 4WD LIGHT KEEPS BLINKING, POWER LOCK LIGHT POPS ON CAR ACT LIKE IT WANTS TO SHUT OFF
Electrical system, Engine, Feb 3, 2016
WHILE DRIVING VEHICLE SHUTS OFF WITHOUT WARNING, USUALLY RESTARTS BUT HAVE HAD IT TOWED. CAR HAS BEEN BACK TO DEALER 11 TIMES IN 12 MONTHS FOR SAME PROBLEM. NO RHYME OR REASON CAN BE CITY OR HIGHWAY. IT IS USUALLY PRECEDED BY INTERIOR LIGHT AND OR DOOR ADJAR LIGHT COMING ON , AFTER STALL HAPPENS CHECK ENGINE LIGHT COMES ON. DEALER HAS REPLACED COUNTLESS FUEL AND EMMISION PARTS INCLUDING ECM AND COILS, FUEL PUMP ETC. THIS HAS BEEN AN ONGOING PROBLEM SINCE DAY OF PURCHASE, THIS CAR IS UNSAFE AND APPEARS FORD DOESN'T KNOW HOW TO FIX IT. VEHICLE LAST LEFT US SIT IN FLORIDA, AFTER 2 WEEKS AND $3200 IN REPAIRS ON 12/21/2015 THE CHECK ENGINE LIGHT AND INTERIOR LIGHT CAME BACK ON 2/2/2016
Electrical system, Electronic stability control (ESC), Engine, Jan 6, 2016
WAS DRIVING MY CAR TO WORK - AT FIRST IF DIDN'T WANT TO START BUT CRANKED FINE. LET IT SIT IDLE AND HEADED TO WORK - 1/2 TO WORK STOPPED AT A LIGHT WHERE IT STARTED TO SHUDDER LIKE IT WAS GOING TO STALL (NEVER HAD ANY ISSUES BEFORE AND STILL NO WARNING LIGHTS). GOT THRU THE INTERSECTION AND LOSS ALL POWER ON THE BUSIEST STREET IN BOWLING GREEN. I DIDN'T EVEN HAVE ENOUGH POWER FOR MY EMERGENCY BLINKERS. STUCK WHERE I WAS WAS A HAZARD OF ME BEING HIT - HAD IT TOWED TO MECHANIC THINKING IT WAS THE ALTERNATOR. ALTERNATOR AND STARTER BOTH GOOD - ONCE PUT ON THE DIAGNOSTIC MACHINE - THE CAR STARTED SMOKING AND SPARKING. END RESULT - I HAVE AT LEAST 3 COILS, POTENTIAL FRIED WIRE HARNESS AND PCM FAILURE (A LOGGED COMPLAINT BUT NEVER A RECALL). THE POTENTIAL FIX WITH NO GUARANTEE THAT THIS WOULDN'T HAPPEN AGAIN IS 5-8K. MY FAMILY COULD HAVE BEEN SEVERELY HURT IF SOMEONE WOULD HAVE PLOWED INTO US. THIS IS NOT A SAFE VEHICLE AT ALL!
Electrical system, Engine, Oct 5, 2015
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE ENGINE STALLED. THE VEHICLE WAS NOT ABLE TO RESTART. THE FAILURE RECURRED ON ONE OCCASION. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 167,000.
Electrical system, Other or unspecified, Sep 25, 2015
EVERY MORNING THE CAR ALARM SUDDENLY GOES OFF UNTIL I PRESS KEY FOB. IT HAPPENS ROUTINELY FROM 5 TO 8 AM AND 8 TO 9 PM. ACCORDING TO THE INTERNET, THERE ARE MANY FORD ESCAPE OWNERS WHO HAVE THE SAME ISSUE. YOU CAN SEARCH IT BY "FORD ESCAPE ALARM GOES OFF". THIS IS REALLY ANNOYING NOT ONLY FOR OWNERS BUT ALSO FOR THEIR NEIGHBORS. ALTHOUGH THIS IS NOT CRITICAL SAFETY ISSUE, THIS IS ABSOLUTELY MANUFACTURER'S DEFECT.
Engine and engine cooling, Electrical system, Sep 16, 2015
TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. WHILE DRIVING APPROXIMATELY 30 MPH, THE SPEED SUDDENLY DECELERATED BEFORE THE VEHICLE STALLED. THE VEHICLE WAS RESTARTED, BUT CONTINUED TO EXPERIENCE THE FAILURE. DURING THE INCIDENT, THE MASTER VEHICLE ELECTRICAL HAZARD WARNING AND THE ENGINE ELECTRIC COOLANT TEMPERATURE SENSORS ILLUMINATED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 200,000.
Electrical system, Engine, Jul 28, 2015
OUR DAUGHTER WAS DRIVING HER 2005 FORD ESCAPE. SHE HAD JUST GOTTEN ON THE TURNPIKE - AS SHE WAS DRIVING THE DASH BOARD LIGHTS STARTED FLASHING AND THE CAR STARTED SLOWING DOWN - THE STEERING WHEEL LOCKED UP AND THE CAR DIED. SHE LUCKILY WAS ABLE TO GET TO THE SIDE OF THE HIGHWAY AND WAS NOT HURT. IT WAS ABOUT 99 DEGREES OUTSIDE AT 2:00 IN THE AFTERNOON. WE HAD TO HAVE A TOW TRUCK TAKE THE VEHICLE TO A CAR REPAIR SHOP. IT WAS DETERMINED THAT THE SPARK PLUGS AND COIL HAD BURNED UP AND IT WOULD BE $2,200 TO REPAIR THE CAR. AFTER LOOKING ONLINE, THIS IS S COMMON PROBLEM WITH 2005 FORD ESCAPES. THERE ARE NO RECALLS. FORD HAS SAID TO KEEP THE RECEIPT IN CASE THERE ARE RECALLS IN THE FUTURE. THAT IS LITTLE RELIEF FROM THE FACT THAT WE ARE OUT $2200 NOW AND DON'T FEEL SAFE HAVING OUR DAUGHTER DRIVING THIS VEHICLE ANY LONGER. SHE HAS HAD REGULAR MAINTENANCE ON HER CAR. ONE OTHER PROBLEM WITH VEHICLE IS THAT THE LEATHER INTERIOR HAS STARTED COMING OFF THE SIDE DOOR PANELS - IT'S LIKE THE ADHESIVE HAS JUST WORN OUT. WE HAVE TRIED TO FIX THIS BUT IT LOOKS BAD AND NO ONE WILL GUARANTEE A REPAIR ON IT BECAUSE THEY SAY IT'S A MANUFACTURING ERROR AND IT IS A DIFFICULT REPAIR. THIS 2005 FORD ESCAPE SHOULD BE CONSIDERED A LEMON!! WE HAVE ALWAYS DRIVEN FORDS WITH NO PROBLEMS - VERY DISAPPOINTING.
Power train, Electrical system, Jul 9, 2015
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED WHILE DRIVING 25 MPH, THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER WITHOUT WARNING. THE VEHICLE HAD TO BE TOWED TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE PCM AND ALL SIX COILS BURNED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 121,000. MA 10/15/2015 UPDATED 11/08/2017*CN
Electrical system, Engine, Jun 18, 2015
ON SEVERAL OCASSIONS, VEHICLE SECURITY ALARM SOUNDED SEVERAL TIMES WHILE TRYING TO START ENGINE. ALARM HORN EVENTUALLY DEACTIVATED AFTER PUSHING KEY BUTTON DURING SEVERAL STARTING ATTEMPTS. DROVE VEHICLE OUT OF PARKING LOT SLOWING FOR STOP LIGHT AND VEHICLE COMPLETELY SHUT OFF. MAJOR SAFETY CONCERN. RESTARTED ENGINE AND GAUGES SWING MINIMUM TO MAXIMUM CONTINUALLY WITH AIR BAG LIGHT ON, CHECK ENGINE LIGHT ON, THEFT LIGHT ON. GAUGES WORKED ALTERNATELY DURING MIN-MAX SWINGS, THEN STOPPED WORKING COMPLETELY. DAY AFTER OCCURENCE, NEW BATTERY WAS COMPLETELY DRAINED AND WOULD NOT HOLD A CHARGE. WHEN TRYING TO CHARGE BATTERY, VECHICLE HAD CLICKING SOUND IN GAUGE CONSOLE. HAD VEHICLE TOWED TO AUTO ELECTRICAL MECHANIC WHO TELLS ME IT IS A FAULTY DASH CONSOLE AND NOT THE VEHICLE COMPUTER AND DASH GAUGE CONSOLE NEEDS TO BE REPLACED AT A NEW PART COST OF $700. REPLACING DASH GAUGE CONSOLE WITH A NEW ONE TO FIND IF THIS FIXES VEHICLE PROBLEMS. MAJOR CONSERN IF ENGINE SHUTTING DOWN WHILE DRIVING.
Electrical system, Engine, May 25, 2015
FORD CUSTOMER CARE CASE #CAC-4150994-B2G8C6 & #4151017-N07B9 THIS WAS THE 2ND MAJOR INCIDENT; THE FIRST OCCURRED IN 1/2009. THE SECOND MAJOR OCCURRENCE WAS 2/2014, WHEN THE CHECK ENGINE LIGHT CAME ON AND THE VEHICLE VERY QUICKLY LOST ALL POWER AND ENGINE SHUT OFF, THE POWER STEERING AND POWER BRAKES ALSO DID NOT RESPOND. THE VEHICLE WOULD NOT RESTART AND HAD TO BE TOWED A FORD DEALERSHIP. THE DEALER STATED THE PCM HAD FAILED CAUSING THE COILS AND SPARK PLUGS TO ALSO FAIL. THE VEHICLE WAS AT THE DEALERSHIP FOR 2 WEEKS WAITING FOR A REPLACEMENT PCM; DEALER STATED THERE WAS A SHORTAGE OF PCM AVAILABILITY DUE TO AN EXTREMELY HIGH NATIONWIDE DEMAND FOR THE PART. DEALER REPLACED THE PCM, AS WELL AS ALL COILS AND SPARK PLUGS IN MID MARCH 2014; THE TOTAL COST OF WAS, $2,875.70. THE PCM, COILS AND PLUGS HAD ALSO BEEN REPLACED IN 1/2009 FOR THE SAME FAILURES. COILS AND PLUGS WERE ALSO REPLACED AN ADDITIONAL 2 MORE TIMES BETWEEN 2009-2014. WHEN THE PCM FAILS, THE VEHICLE IMMEDIATELY LOOSES ALL POWER, STEERING AND BRAKES, AND STOPS DEAD IN ITS TRACKS AND CANNOT BE RESTARTED CAUSING A POTENTIALLY CATASTROPHIC SITUATION. HAD THIS FAILURE OCCURRED IN TRAFFIC, A MAJOR COLLISION WOULD HAVE BEEN EMINENT AND A FATALITY PROBABLE. WHEN I CONTACTED FORD ON 3/19/2014, THEY STATED THEY ARE AWARE OF THE ISSUE AND ASSIGNED 2 CUSTOMER CARE CASE NUMBERS; BUT THEY REFUSED ANY REIMBURSEMENT OR COMPENSATION OF ANY KIND. THE MULTIPLE INCIDENTS OF DEFECTIVE PCM FAILURES SHOULD BE INVESTIGATED AS A POTENTIALLY DEADLY SAFETY ISSUE.
Electrical system, Other or unspecified, May 19, 2015
THE DRIVER'S FRONT DOOR BEGAN CAUSING PROBLEMS. OCCASIONALLY, IT DOES NOT OPEN, PERIOD. ADDITIONALLY, THE LOCK MECHANISM IS INOPERABLE. I REMOVED BOTH DRIVER'S AND PASSENGER'S FRONT DOOR PANELS TO INSPECT, COMPARE AND FINALLY DETERMINE THE ISSUE. THERE SEEMS TO BE A PROBLEM, WHICH A FRIEND TEMPORARILY FIXED. IT--THE EXTERIOR DOOR HANDLE--AFTER TWEEKING, WORKED FOR A WHILE. FAST FORWARD, 2015, I CANNOT OPEN NEARLY 3 OF MY DOORS. ONE WILL NOT OPEN AT ALL (REAR PASS.) THE DRIVER'S FRONT DOOR IS DOING THE SAME THING THE REAR DOOR HANDLE--IT LOST TENSION AND WON'T OPEN AT ALL. AFTER LOOKING IT UP ON YOUTUBE, I DETERMINED THE LOCKING SYSTEM IS THE CULPRIT. IN ORDER TO REPAIR THIS INOPERABLE DOOR HANDLE SITUATION, APPARENTLY I NEED TO PULL THE INTERIOR PANELS, REMOVE THE EXTERIOR HANDLES AND REPLACE THEM ENTIRELY. CURRENTLY, I HAVE THE DRIVER'S DOOR PANEL REMOVED BECAUSE IN THE EVENT THE HANDLE DOESN'T WORK AT ALL, I'D HAVE TO CLIMB OVER FROM THE PASSENGER SIDE JUST TO DRIVE MY 2005 FORD ESCAPE.
Electrical system, Apr 30, 2015, fire
ONGOING PROBLEM WITH COILS. I WAS DRIVING MY CAR AND SMOKE STARTED TO BILLOW OUT OF THE FRONT HOOD. I THEN PULLED OVER AND CALL THE BERKELEY TOWNSHIP POLICE AND THEY ARRIVED WITH THE PINEWALD FIRE COMPANY. MY HUSBAND AND SON ARRIVED AT SCENE AND WE HAD THE VEHICLE TOWED TO OUR HOME. THE ENGINE CONTROL MODULE MELTED THE COILS. WHEN MY SON EXAMINED THE CAR THE UPPER INTAKE MANIFOLD EXPLODED IN HIS FACE. I HAVE CONTACTED THE FORD MOTOR COMPANY AND THEY REFUSED TO DO ANYTHING ABOUT IT. ALSO, WE NOTED THAT THERE WHERE MANY OTHER COMPLAINTS ONLINE REGARDING THE SAME EXACT PROBLEM. *TR
Electrical system, Vehicle speed control, Engine, Mar 17, 2015
WAS DRIVING AT HIGHWAY SPEED (APPX 55MPH) IN 5 O'CLOCK TRAFFIC IN RALEIGH, NC ON US 1 AND THE VEHICLE LOST SPEED. ALL EMERGENCY LIGHTS CAME ON. FORCED TO PULL THE VEHICLE OFF ONTO THE SHOULDER AND WAS ALMOST REAR ENDED. THE VEHICLE SPUTTERED AND TOTALLY CUT OFF. ATTEMPTED TO RESTART THE VEHICLE BUT IT KEPT CUTTING OFF. I WAS UNABLE TO RESTART THE VEHICLE AND WAS STRANDED ON THE HIGHWAY. AFTER A CALL TO A FAMILY MEMBER AND TO AAA, THE CAR WAS TOWED HOME 3 HOURS LATER. THE NEXT DAY, THE CAR WAS TOWED TO CROSSROADS FORD IN CARY, NC. THEY DETERMINED THAT THE PCM, SPARK PLUGS AND IGNITION COILS ALL FAILED AT ONCE AND CHARGED ME $2700. ERROR CODES P0351, P0354 AND P0353 APPEARED ON THE DIAGNOSTICS. THE VEHICLE WAS REPAIRED THE NEXT DAY. THIS IS A HUGE SAFETY ISSUE SINCE THE VEHICLE SUDDENLY UNDERGOES A CATASTROPHIC FAILURE WITH LOSS OF POWER AND ACCELERATION AND COULD LEAD TO AN ACCIDENT. *TR
Electrical system, Mar 16, 2015
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING AT APPROXIMATELY 30 MPH OVER A BUMP, THERE WAS A LOUD ABNORMAL NOISE COMING FROM THE VEHICLE. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED WHEN GOING OVER A BUMP. THE CONTACT NOTICED THAT THE TOP OF THE STEERING TOWER HAD SEPARATED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE STRUCK TOWER SEPARATED DUE TO EXCESSIVE RUST. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE); HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 128,000.
Electrical system, Vehicle speed control, Electronic stability control (ESC), Feb 11, 2015
AS SOON AS I HIT ABOUT 60 MPH, BETWEEN 2-3 RPM, MY CAR BEGINS TO STALL AND FEELS LIKE THE GAS PEDAL IS GRINDING AND WON'T LET ME GO ANY FASTER WITHOUT VIBRATING THE ENTIRE VEHICLE. I INITIALLY THOUGHT IT WAS THE TRANSMISSION SLIPPING SO I TOOK IT IN TO A TRANSMISSION AUTO SHOP WHERE THE FOUND ABSOLUTELY NOTHING. WHICH IS VERY ODD FOR AN AUTO SHOP TO NOT FIND ANYTHING. ABOUT 1 WEEK AFTER THIS PROBLEM, THE SERVICE EMISSION LIGHT CAME ON. I WAS DRIVING HOME FROM WORK THE DAY THE LIGHT CAME ON AND THE CAR COMPLETELY STOPPED ON THE HIGHWAY, IN RUSH HOUR TRAFFIC. THANKFULLY I WAS CLOSE TO THE SIDE OF THE HIGHWAY AND WAS ABLE TO PULL OVER. I GOT TO THE SIDE AND PUT MY CAR INTO PARK, TURNED THE ENGINE OFF, AND WAITED A COUPLE OF MINUTES TO ALLOW MY HEART RATE TO COME BACK DOWN TO A NORMAL PACE. I TURNED THE KEY AND THE ENGINE TURNED BACK ON. I DROVE IT INTO AN AUTO SHOP TO SEE WHAT THE ISSUE WAS, AND THE READER SHOWED CYLINDER 2 MISFIRE. THE FIRST POSSIBLE FIX WAS TO REPLACE THE COIL ON PLUG, WHICH IS WHAT I DID. I GOT HOME TODAY AND AM STILL EXPERIENCING THIS SCARY FEELING OF MY CAR NOT BEING ABLE TO EXCEL ABOVE 60. I READ MANY REVIEWS THIS EVENING AND SO MANY PEOPLE HAVE EXPERIENCED VERY SIMILAR ISSUES. THIS IS NOT SAFE AND PEOPLE ARE AT SERIOUS RISK OR GETTING INJURED AND/OR IN AN ACCIDENT. THE AVERAGE COST TO FIX THE ISSUE - REPORTED BY MANY USERS ON HTTP://WWW.CARCOMPLAINTS.COM/FORD/ESCAPE/2005/ELECTRICAL/COMPUTER_PCM_FAILURE.SHTML, IS $2000. WHEN YOU HAVE A 2005 CAR OF ANY KIND, $2000 SEEMS VERY HIGH TO FIX WHEN THE CAR IS 10 YEARS OLD. PLEASE INVESTIGATE THIS ISSUE FURTHER AS THIS IS UNACCEPTABLE THAT FORD HAS YET TO RECALL THIS ISSUE. *TR
Electrical system, Fuel/propulsion system, Feb 11, 2015
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING AT APPROXIMATELY 70 MPH, AN UNKNOWN WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE CONTACT RESTARTED THE VEHICLE, BUT THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURE WAS UNABLE TO BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED A NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V526000 (HYBRID PROPULSION SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS NOT AVAILABLE.
Electrical system, Engine, Fuel/propulsion system, Feb 8, 2015
FIRST OCCURRENCE OF PROBLEM: 48800 MILES, 5/2012. ENGINE LIGHT ON AND ENGINE MISFIRING. FORD DEALERSHIP DETERMINED FAULTY IGNITION COIL IN # 6 CYLINDER. REPLACED IGNITION COIL AND SPARK PLUG. $295 SECOND OCCURRENCE OF PROBLEM: 74,400 MILES, 11/2013. ENGINE LIGHT ON AND ENGINE MISFIRING. MECHANIC REPLACED SPARKPLUGS IN CYLINDERS # 1-3 ALL AT ONCE SINCE IT IS DIFFICULT TO ACCESS THOSE. $276 ADDITIONAL OCCURRENCES OF SAME PROBLEM: UPON MISFIRING IN 2014 I BOUGHT A CODE READER WHICH INDICATED CYLINDER #5 MISFIRE - REPLACED IGNITION COIL AND SPARK PLUG. MORE MISFIRING INDICATED CYLINDER #4 MISFIRE - REPLACED IGNITION FOIL AND SPARK PLUG. MAJOR PROBLEM UPDATE. 2/2/2015 - TRAVELLING 55 MPH CAR SHUTS OFF, ALL WARNING LIGHTS COME ON, COAST TO SHOULDER. RESTART CAR, SEEMS FINE, NO WARNING LIGHTS. AGAIN CYLINDER # 4 MISFIRING - REPLACED SPARK PLUG. MY RESEARCH INDICATES THE ECM/PCM MAY BE DAMAGED AND THAT THIS IS A VERY FREQUENT PROBLEM WITH THIS CAR, OFTEN MANIFESTING AFTER THE WARRANTY EXPIRES/RECALL MILEAGE, AND COSTS $2000-$3000 OR MORE. I DON'T WAN'T TO PAY TO HAVE IT FIXED BECAUSE MANY PEOPLE HAVE HAD THE PCM FRIED MULTIPLE TIMES BUT I'M SCARED IT WILL SHUT DOWN WHILE DRIVING AGAIN AND THINK THIS SHOULD BE COVERED BY A RECALL. MANY PEOPLE ARE HAVING THIS PROBLEM AND IT APPEARS TO BE CAUSED BY FORD ENGINEERING. PLEASE HELP FORCE A RECALL OR PROVIDE ME WITH INFORMATION FOR A CLASS ACTION LAWSUIT. *JS